AC Electric Field Enhances Cryopreservation Efficiency of Sprague-Dawley Rat Liver During a Slow Freezing Procedure

Quantitative Analysis of Ice Crystal Growth During Freezing of Dimethyl Sulfoxide Solutions Under Alternating Current Electric Fields

During cryopreservation, the growth of ice crystals can cause mechanical damage to samples, which is one of the important factors limiting the quality of preserved samples. To enhance the preservation quality of biological samples, scholars have tried various engineering methods. Among them, an electric field is an essential factor affecting solution freezing. Dimethyl sulfoxide, as a commonly used cryoprotectant, can cause mechanical damage to cells due to ice crystals even when freezing at the optimal freezing rate. Water is a strongly polar dielectric material, and the applied alternating current (AC) electric field will affect the water freezing performance. Therefore, a quantitative study of ice crystal nucleation and growth during freezing of dimethyl sulfoxide solutions under different AC electric field conditions is needed to try to reduce ice crystal damage. We created a liquid-film device to approximate the ice crystal growth process as a two-dimensional image. The frequency of the AC voltage was set from 0 to 50 kHz. We measured the supercooling of the dimethyl sulfoxide solution under AC electric field conditions. As an objective and accurate quantitative analysis of the ice crystal growth process, we propose a Dilated Convolutional Segmentation Transformer for semantic segmentation of ice crystal images. It is concluded that the average area and the growth rate of single ice crystals decrease with increasing electric field frequency at a certain concentration of dimethyl sulfoxide solution. Lower concentrations of dimethyl sulfoxide solution in combination with an AC electric field can achieve similar ice suppression effects as when higher concentrations of dimethyl sulfoxide solution act alone. We believe that AC electric fields are expected to be an aid to cryopreservation and provide some theoretical basis and experimental foundation for its development.

Control strategies of ice nucleation, growth, and recrystallization for cryopreservation

The cryopreservation of biomaterials is fundamental to modern biotechnology and biomedicine, but the biggest challenge is the formation of ice, resulting in fatal cryoinjury to biomaterials. To date, abundant ice control strategies have been utilized to inhibit ice formation and thus improve cryopreservation efficiency. This review focuses on the mechanisms of existing control strategies regulating ice formation and the corresponding applications to biomaterial cryopreservation, which are of guiding significance for the development of ice control strategies. Herein, basics related to biomaterial cryopreservation are introduced first. Then, the theoretical bases of ice nucleation, growth, and recrystallization are presented, from which the key factors affecting each process are analyzed, respectively. Ice nucleation is mainly affected by melting temperature, interfacial tension, shape factor, and kinetic prefactor, and ice growth is mainly affected by solution viscosity and cooling/warming rate, while ice recrystallization is inhibited by adsorption or diffusion mechanisms. Furthermore, the corresponding research methods and specific control strategies for each process are summarized. The review ends with an outlook of the current challenges and future perspectives in cryopreservation. STATEMENT OF SIGNIFICANCE: Ice formation is the major limitation of cryopreservation, which causes fatal cryoinjury to cryopreserved biomaterials. This review focuses on the three processes related to ice formation, called nucleation, growth, and recrystallization. The theoretical models, key influencing factors, research methods and corresponding ice control strategies of each process are summarized and discussed, respectively. The systematic introduction on mechanisms and control strategies of ice formation is instructive for the cryopreservation development.

Phase Change Behavior of NaCl-H2O Binary Solution Under the Control of AC Electric Field

Cryopreservation, which refers to preservation of cells or tissues at subzero temperatures, inevitably involves the problem of cryoinjury caused by ice crystals. The application of an external electric field during the freezing process has been shown to be a promising approach to produce miniature ice grains and decrease the fraction of ice crystallization at a slow cooling rate. Thus, the dielectric and thermodynamic properties of NaCl-H₂O binary solutions at subzero temperatures were tremendously important for understanding the mechanism of ice formation under the manipulation of an AC electric field in biopreservation. However, there was still a lack of relevant information in the literature. The first objective of this study was to systematically measure the dielectric spectrum of 0.9% NaCl-H₂O binary solutions at temperatures ranging from -100°C to 0°C with a cooling/heating rate of 2°C/min. We further measured the thermodynamic properties of a 0.9% NaCl-H₂O binary solution while applying a series of electric fields near its dielectric relaxation frequency. The effect of the electric field on the crystal morphology was studied last. Pure water was selected as the control group. The results showed that an AC electric field can alter the thermodynamic process and thus the phase transition and ice crystal structure could be manipulated. It was concluded that the AC electric-assistant preservation method will be a promising technology in cryopreservation.

Functional Tissue Analysis Reveals Successful Cryopreservation of Human Osteoarthritic Synovium

Osteoarthritis (OA) is a degenerative joint disease affecting cartilage and is the most common form of arthritis worldwide. One third of OA patients have severe synovitis and less than 10% have no evidence of synovitis. Moreover, synovitis is predictive for more severe disease progression. This offers a target for therapy but more research on the pathophysiological processes in the synovial tissue of these patients is needed. Functional studies performed with synovial tissue will be more approachable when this material, that becomes available by joint replacement surgery, can be stored for later use. We set out to determine the consequences of slow-freezing of human OA synovial tissue. Therefore, we validated a method that can be applied in every routine laboratory and performed a comparative study of five cryoprotective agent (CPA) solutions. To determine possible deleterious cryopreservation-thaw effects on viability, the synovial tissue architecture, metabolic activity, RNA quality, expression of cryopreservation associated stress genes, and expression of OA characteristic disease genes was studied. Furthermore, the biological activity of the cryopreserved tissue was determined by measuring cytokine secretion induced by the TLR ligands lipopolysaccharides and Pam3Cys. Compared to non frozen synovium, no difference in cell and tissue morphology could be identified in the conditions using the CS10, standard and CryoSFM CPA solution for cryopreservation. However, we observed significantly lower preservation of tissue morphology with the Biofreeze and CS2 media. The other viability assays showed trends in the same direction but were not sensitive enough to detect significant differences between conditions. In all assays tested a clearly lower viability was detected in the condition in which synovium was frozen without CPA solution. This detailed analysis showed that OA synovial tissue explants can be cryopreserved while maintaining the morphology, viability and phenotypical response after thawing, offering enhanced opportunities for human in vitro studies.