1
|
Wowk B, Phan J, Pagotan R, Galvez E, Fahy GM. 27 MHz constant field dielectric warming of kidneys cryopreserved by vitrification. Cryobiology 2024; 115:104893. [PMID: 38609033 DOI: 10.1016/j.cryobiol.2024.104893] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/18/2023] [Revised: 03/14/2024] [Accepted: 04/09/2024] [Indexed: 04/14/2024]
Abstract
Organs cryopreserved by vitrification are exposed to the lowest possible concentration of cryoprotectants for the least time necessary to successfully avoid ice formation. Faster cooling and warming rates enable lower concentrations and perfusion times, reducing toxicity. Since warming rates necessary to avoid ice formation during recovery from vitrification are typically faster than cooling rates necessary for vitrification, warming speed is a major determining factor for successful vitrification. Dielectric warming uses an oscillating electric field to directly heat water and cryoprotectant molecules inside organs to achieve warming that's faster and more uniform than can be achieved by heat conduction from the organ surface. This work studied 27 MHz dielectric warming of rabbit kidneys perfused with M22 vitrification solution. The 27 MHz frequency was chosen because its long wavelength and penetration depth are suitable for human organs, because it had an anticipated favorable temperature of maximum dielectric absorption in M22, and because it's an allocated frequency for industrial and amateur use with inexpensive amplifiers available. Previously vitrified kidneys were warmed from -100 °C by placement in a 27 MHz electric field formed between parallel capacitor plates in a resonant circuit. Power was varied during warming to maintain constant electric field amplitude between the plates. Maximum power absorption occurred near -70 °C, with a peak warming rate near 150 °C/min in 50 mL total volume with approximately 500 W power. After some optimization, it was possible to warm ∼13 g vitrified kidneys with unprecedentedly little injury from medullary ice formation and a favorable serum creatinine trend after transplant. Distinct behaviors of power absorption and system tuning observed as a function of temperature during warming are promising for non-invasive thermometry and future automated control of the warming process at even faster rates with user-defined temperature dependence.
Collapse
Affiliation(s)
- Brian Wowk
- 21st Century Medicine, Inc, 14960 Hilton Drive, Fontana, CA, 92336, USA.
| | - John Phan
- 21st Century Medicine, Inc, 14960 Hilton Drive, Fontana, CA, 92336, USA
| | - Roberto Pagotan
- 21st Century Medicine, Inc, 14960 Hilton Drive, Fontana, CA, 92336, USA
| | - Erika Galvez
- 21st Century Medicine, Inc, 14960 Hilton Drive, Fontana, CA, 92336, USA
| | - Gregory M Fahy
- 21st Century Medicine, Inc, 14960 Hilton Drive, Fontana, CA, 92336, USA
| |
Collapse
|
2
|
Pan J, Zeng Q, Peng K, Zhou Y, Shu Z. Review of Rewarming Methods for Cryopreservation. Biopreserv Biobank 2023. [PMID: 37751240 DOI: 10.1089/bio.2023.0015] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 09/27/2023] Open
Abstract
Cryopreservation is the most effective technology for the long-term preservation of biological materials, including cells, tissues, and even organs in the future. The process of cooling and rewarming is essential to the successful preservation of biological materials. One of the critical problems in the development of cryopreservation is the optimization of effective rewarming technologies. This article reviewed rewarming methods, including traditional boundary rewarming commonly used for small-volume biological materials and other advanced techniques that could be potentially feasible for organ preservation in the future. The review focused on various rewarming technique principles, typical applications, and their possible limitations for cryopreservation of biological materials. This article introduced nanowarming methods in the progressing optimization and the possible difficulties. The trends of novel rewarming methods were discussed, and suggestions were given for future development.
Collapse
Affiliation(s)
- Jiaji Pan
- Department of Mechanical Engineering, College of Engineering and Design, Hunan Normal University, Changsha, China
- State Key Laboratory of Developmental Biology of Freshwater Fish, College of Life Sciences, Hunan Normal University, Changsha, China
| | - Qijin Zeng
- Department of Mechanical Engineering, College of Engineering and Design, Hunan Normal University, Changsha, China
| | - Ke Peng
- Department of Mechanical Engineering, College of Engineering and Design, Hunan Normal University, Changsha, China
| | - Yulin Zhou
- Shuda College, Hunan Normal University, Changsha, China
| | - Zhiquan Shu
- School of Engineering and Technology, University of Washington, Tacoma, Washington, USA
| |
Collapse
|
3
|
Solanki PK, Rabin Y. Thermomechanical stress analysis of rabbit kidney and human kidney during cryopreservation by vitrification with the application of radiofrequency heating. Cryobiology 2021; 100:180-192. [PMID: 33412158 PMCID: PMC8972895 DOI: 10.1016/j.cryobiol.2021.01.002] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/18/2020] [Revised: 12/31/2020] [Accepted: 01/01/2021] [Indexed: 12/19/2022]
Abstract
This study presents a computational framework for thermomechanical stress analysis in a specimen undergoing cryopreservation, with emphasis on radiofrequency (RF) heating for recovering from cryogenic storage. In particular, this study addresses cryopreservation by vitrification, where the specimen is stored in the amorphous phase (vitreous means glassy). In broad terms, the relatively high cooling and rewarming rates necessary for vitrification result in differential thermal expansion in the specimen, which is the driving force for thermo-mechanical stress. Thermomechanical stress can lead to structural damage, such as fractures or plastic deformation, rendering the specimen useless. Not without technical difficulties, those hazardous effects during the rewarming phase of the protocol can be mitigated by applying volumetric heating, with RF heating as an attractive means. The proposed computational framework in this study addresses the coupled electromagnetic, thermal and solid mechanics fields, using commercially available solvers. This study advances from a spherical-case benchmark to realistic models of the rabbit kidney and the human kidney. Results of this study suggest that structural damage to the brittle material can be prevented when stress relaxation is facilitated around the glass transition temperature. Furthermore, this study suggests that volumetric heating is necessary to surpass the critical rewarming rate, while benefiting from lowering the overall thermomechanical stress during recovery from cryogenic storage. More broadly, the computational framework presented here can be used for the optimization of the RF heating parameters, chamber specifics, specimen container shape, and the thermal protocol in order to preserve structural integrity in the specimen.
Collapse
Affiliation(s)
- Prem K Solanki
- Biothermal Technology Laboratory, Department of Mechanical Engineering, Carnegie Mellon University, Pittsburgh, PA, 15213, USA
| | - Yoed Rabin
- Biothermal Technology Laboratory, Department of Mechanical Engineering, Carnegie Mellon University, Pittsburgh, PA, 15213, USA.
| |
Collapse
|
4
|
Pan J, Ren S, Sekar PK, Peng J, Shu Z, Zhao G, Ding W, Chen M, Gao D. Investigation of Electromagnetic Resonance Rewarming Enhanced by Magnetic Nanoparticles for Cryopreservation. LANGMUIR : THE ACS JOURNAL OF SURFACES AND COLLOIDS 2019; 35:7560-7570. [PMID: 30550289 DOI: 10.1021/acs.langmuir.8b03060] [Citation(s) in RCA: 9] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/11/2023]
Abstract
The lack of an effective rewarming technique restricted the successful cryopreservation of organ or large tissues by vitrification. The conversion of electromagnetic (EM) energy into heat provides a possible solution for the rewarming process for the cryopreservation. In this work, an EM resonance rewarming system was set up with dynamic feedback control and power feeding optimization. In addition, we take advantage of magnetic nanoparticles (MNPs) to absorb magnetic field energy to further enhance the energy conversion efficiency. We achieved a >200 °C min-1 rewarming rate for tens of milliliters of cryopreserved samples. Besides, we also investigated the effect of nanoparticle size and concentration based on thermal properties by analyzing the contribution of nanoparticles and the utilization of field energy. The closed system reduced the possible concomitant side effects when increasing the number of nanoparticles or increasing the EM source power. With the remarkably low dosage of nanoparticles (0.1 mg mL-1 Fe) compared to that for other MNP-based rewarming applications, this study opens the door to new approaches for exploring novel techniques for tissue and organ preservation.
Collapse
Affiliation(s)
- Jiaji Pan
- Center for Cryo-Biomedical Engineering and Artificial Organs, Department of Mechanical Engineering , University of Washington , Seattle , Washington 98195 , United States
- School of Engineering and Design , Hunan Normal University , Changsha , China 410081
| | - Shen Ren
- Center for Cryo-Biomedical Engineering and Artificial Organs, Department of Mechanical Engineering , University of Washington , Seattle , Washington 98195 , United States
| | - Praveen K Sekar
- Center for Cryo-Biomedical Engineering and Artificial Organs, Department of Mechanical Engineering , University of Washington , Seattle , Washington 98195 , United States
| | - Ji Peng
- Center for Cryo-Biomedical Engineering and Artificial Organs, Department of Mechanical Engineering , University of Washington , Seattle , Washington 98195 , United States
| | - Zhiquan Shu
- Center for Cryo-Biomedical Engineering and Artificial Organs, Department of Mechanical Engineering , University of Washington , Seattle , Washington 98195 , United States
- School of Mechanical and Materials Engineering , Washington State University , Everett , Washington 98201 , United States
| | - Gang Zhao
- Department of Electronic Science and Technology , University of Science and Technology of China , Anhui 230027 , China
| | - Weiping Ding
- Department of Electronic Science and Technology , University of Science and Technology of China , Anhui 230027 , China
| | - Ming Chen
- Center for Cryo-Biomedical Engineering and Artificial Organs, Department of Mechanical Engineering , University of Washington , Seattle , Washington 98195 , United States
| | - Dayong Gao
- Center for Cryo-Biomedical Engineering and Artificial Organs, Department of Mechanical Engineering , University of Washington , Seattle , Washington 98195 , United States
| |
Collapse
|
5
|
Taylor MJ, Weegman BP, Baicu SC, Giwa SE. New Approaches to Cryopreservation of Cells, Tissues, and Organs. Transfus Med Hemother 2019; 46:197-215. [PMID: 31244588 PMCID: PMC6558330 DOI: 10.1159/000499453] [Citation(s) in RCA: 90] [Impact Index Per Article: 18.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/05/2019] [Accepted: 03/07/2019] [Indexed: 12/11/2022] Open
Abstract
In this concept article, we outline a variety of new approaches that have been conceived to address some of the remaining challenges for developing improved methods of biopreservation. This recognizes a true renaissance and variety of complimentary, high-potential approaches leveraging inspiration by nature, nanotechnology, the thermodynamics of pressure, and several other key fields. Development of an organ and tissue supply chain that can meet the healthcare demands of the 21st century means overcoming twin challenges of (1) having enough of these lifesaving resources and (2) having the means to store and transport them for a variety of applications. Each has distinct but overlapping logistical limitations affecting transplantation, regenerative medicine, and drug discovery, with challenges shared among major areas of biomedicine including tissue engineering, trauma care, transfusion medicine, and biomedical research. There are several approaches to biopreservation, the optimum choice of which is dictated by the nature and complexity of the tissue and the required length of storage. Short-term hypothermic storage at temperatures a few degrees above the freezing point has provided the basis for nearly all methods of preserving tissues and solid organs that, to date, have proved refractory to cryopreservation techniques successfully developed for single-cell systems. In essence, these short-term techniques have been based on designing solutions for cellular protection against the effects of warm and cold ischemia and basically rely upon the protective effects of reduced temperatures brought about by Arrhenius kinetics of chemical reactions. However, further optimization of such preservation strategies is now seen to be restricted. Long-term preservation calls for much lower temperatures and requires the tissue to withstand the rigors of heat and mass transfer during protocols designed to optimize cooling and warming in the presence of cryoprotective agents. It is now accepted that with current methods of cryopreservation, uncontrolled ice formation in structured tissues and organs at subzero temperatures is the single most critical factor that severely restricts the extent to which tissues can survive procedures involving freezing and thawing. In recent years, this major problem has been effectively circumvented in some tissues by using ice-free cryopreservation techniques based upon vitrification. Nevertheless, despite these promising advances there remain several recognized hurdles to be overcome before deep-subzero cryopreservation, either by classic freezing and thawing or by vitrification, can provide the much-needed means for biobanking complex tissues and organs for extended periods of weeks, months, or even years. In many cases, the approaches outlined here, including new underexplored paradigms of high-subzero preservation, are novel and inspired by mechanisms of freeze tolerance, or freeze avoidance, in nature. Others apply new bioengineering techniques such as nanotechnology, isochoric pressure preservation, and non-Newtonian fluids to circumvent currently intractable problems in cryopreservation.
Collapse
Affiliation(s)
- Michael J. Taylor
- Sylvatica Biotech, Inc., North Charleston, South Carolina, USA
- Department of Mechanical Engineering, Carnegie Mellon University, Pittsburgh, Pennsylvania, USA
- Department of Medicine, University of Arizona, Tucson, Arizona, USA
| | | | - Simona C. Baicu
- Sylvatica Biotech, Inc., North Charleston, South Carolina, USA
| | | |
Collapse
|