The effect of particle size of commercial soybean meal on performance and nutrient utilization of broiler chicks

Nutritional evaluation of soybean meals varying in particle size

The objective of this study was to evaluate the effect of varying soybean meal (SBM) particle sizes on nutritional value of the SBM. Seven samples of dehulled solvent-extracted SBM from the same batch were ground to varying mean particles of <386, 466, 809, 1,174, 1,577, 2,026, and 2,321 μm. Two precision-fed rooster assays (crop intubation with 25 g of SBM followed by 48 h total excreta collection) were performed to determine TME_n and standardized amino acid (AA) digestibility. There were no significant differences for TME_n among SBM samples, and there was also no consistent significant effect of particle size on standardized AA digestibility. In addition to the 2 precision-fed rooster assays, a 21 d broiler chick trial was conducted using corn-SBM based diets using 4 diets that differed only in the mean particle size of SBM (466, 809, 1,174, or 1,577 μm), being fed from 2 to 23 d of age. Chicks fed diets containing 809 or 1,174 μm SBM had increased (P < 0.05) weight gain compared with chicks fed the diet containing 466 μm SBM, and chicks fed diets containing 1,174 or 1,577 μm SBM had increased (P < 0.05) feed efficiency compared with chicks fed the diet containing 466 μm SBM. The diet containing 466 μm SBM yielded the highest (P < 0.05) AME_n and total tract P retention. Ileal P digestibility and standardized AA digestibilities did not differ among treatments. Relative gizzard weight (percent of body weight) was increased (P < 0.05) by the 2 largest SBM particle sizes. The results from these 3 experiments showed that increasing SBM particle size may be beneficial to broiler growth performance and may increase gizzard size but had no consistent significant effect on ME, AA digestibility, or P digestibility/retention.

Mitigating the Spread and Translocation of Salmonella Enteritidis in Experimentally Infected Broilers under the Influence of Different Flooring Housing Systems and Feed Particle Sizes

This study aimed to evaluate the influences of different flooring designs and feed particle sizes on the spread of Salmonella (S.) in broiler chickens. Birds (n = 480) were allocated to four different housing systems (fully littered with and without floor heating, partially and fully slatted flooring with sand bath) and two dietary treatments (finely and coarsely ground diets) in 24 boxes. Two broilers per box were experimentally infected with S. Enteritidis (8.00 log10 CFU/bird) at d 17. Salmonella prevalence in caecal contents and the liver was highest in broilers housed on fully slatted floor until d 36/37 (88.1% and 91.5%, respectively), and lowest in litter flooring (caecal content 64.4%) and litter flooring with floor heating (liver 61.7%). In turn, broilers on littered flooring expressed the lowest Salmonella counts in caecal content at d 36/37 (2.21 ± 1.75 log10 CFU/g), partial slatted flooring the highest (3.76 ± 1.46 log10 CFU/g). The mean Salmonella count in the caecal content was significantly lower for birds fed a coarsely ground diet (0.96 and 1.94 log10 CFU/g) than a finely ground diet (5.07 and 3.34 log10 CFU/g) at d 23 and d 36/37, respectively (p < 0.0001). Slatted flooring with a sand bath did not show advantages in terms of Salmonella reduction, whereas the coarsely ground diet markedly reduced the spread of Salmonella.

Effect of feed grinding methods with and without expansion on prececal and total tract mineral digestibility as well as on interior and exterior egg quality in laying hens

The grinding of cereals by various milling methods as well as thermal treatment of feed may influence mineral digestibility and egg quality. The present study investigated the effect of feed produced by disc mill (D) and wedge-shaped disc mill (WSD), as mash (M) or expandate (E) on apparent ileal absorption (AIA) and apparent total digestibility (ATD) of calcium, phosphorus, magnesium, zinc, manganese, copper and iron, as well as on egg quality in laying hens. A total of 192 hens (Lohmann Brown) aged 19 wk, were assigned using a randomized design with a 2 × 2 factorial arrangement. Four experimental diets were offered ad libitum. Eggs were analyzed for weight, shape index, area, shell weight per unit surface area, yolk color, air cell, blood spot, Haugh unit, albumen and yolk measures (index, weight, height, width and length), shell measures (surface area, stability, density, thickness and membrane weight), as well as percent contents of albumen, yolk, shell, and shell membrane. The ATD for phosphorus, manganese, and copper was higher in WSD compared with D treatment (P = 0.028, P = 0.028 and P = 0.016, respectively). The interaction between milling methods and thermal treatment influenced ATD of copper (P = 0.033), which was higher in WSD+M group (41.0 ± 20.2) compared with D+E group (-3.21 ± 25.1), whereas no differences were observed for D+M (1.90 ± 37.8) and WSD+E (8.02 ± 36.2) groups. Egg stability tended to be higher in E compared with M treatment (P = 0.055). Albumen weight, percentage albumen weight, and albumen: yolk were higher and percentage yolk weight was lower in D compared with WSD treatment (P = 0.043, P = 0.027, P = 0.024, and P = 0.041, respectively). Number of blood spots was higher in E than M treatment (P = 0.053). In conclusion, use of a wedge-shaped disc mill resulted in higher ATD for phosphorus, manganese, and copper than use of a disc mill; however, digestibility for majority of minerals as well as egg quality parameters was comparable. Therefore, feed produced by either disc mill or wedge-shaped disc mill as mash or expandate may be used for laying hens without negative effects on egg quality.

Implication of milling methods, thermal treatment, and particle size of feed in layers on mineral digestibility and retention of minerals in egg contents

Feed production with different milling methods, thermal treatment, and particle size may influence mineral digestibility and retention in eggs. The present study investigated the impact of roller (R) and hammer (H) mills, mash (M) and expandate (E) with fine (F) and coarse (C) particle sizes, on apparent ileal absorption (AIA) and apparent total digestibility (ATD) and retention of calcium, phosphorus, magnesium, zinc, manganese, copper and iron in yolk, albumen, and shell. A total of 384 hens (Lohmann Brown), 19 weeks old, were assigned using a randomized design with a 2×2×2 factorial arrangement. Eight experimental diets were offered ad libitum during the whole experimental period and one week before for diet adaption. The AIA of magnesium, zinc, copper, and iron was higher in treatment R in comparison with treatment H (P<0.01, P≤0.03, P<0.01 and P<0.01, respectively). The AIA of magnesium was higher in treatment M than treatment E (P<0.01). The AIA of magnesium was higher in treatment C in comparison with treatment F (P≤0.05) due to particle size. The ATD of copper and iron was higher in treatment R than treatment H (P<0.01 and P≤0.03, respectively). The ATD was higher for phosphorus and lower for iron in treatment F than treatment C (P≤0.05 and P≤0.02. respectively). The copper concentration in yolk and albumen was higher in treatment C than treatment F (P<0.01 and P≤0.03, respectively). Besides a few overall interactions, the AIA and ATD of copper and manganese were lower in H+M group than R+M group (P≤0.05). The ATD of iron was higher in the M+C group compared to the M+F group (P<0.01), whereas the albumen zinc concentration was higher in the E+C group than E+F group (P < 0.01). In conclusion, the feed produced by hammer mill had negative effects on AIA and ATD for trace elements in particular, but mineral concentrations in egg contents were mostly comparable for all treatments. Therefore, milling methods, thermal treatment, and particle sizes used in the present study can be used for layer feed formulation without negatively affecting egg quality.

Evaluation of soybean meal source and particle size on broiler performance, nutrient digestibility, and gizzard development

Although there have been several reports concerning the effects of particle size of cereal grains on productive performance of poultry, there is limited information about the effects of soybean meal (SBM) particle size on broiler performance. The objective of the present experiments was to evaluate the effects of SBM source and particle size on broiler performance, gizzard weight, and nutrient digestibility. The first experiment was a 2 × 2 factorial arrangement of 2 SBM sources: expeller-extracted (ESBM) and solvent-extracted (SSBM), and 2 particle sizes: coarse grind, 971 µm, and fine grind, 465 µm. The second experiment was a 2 × 2 factorial arrangement of 2 ESBM particle sizes: coarse grind, 1,290 µm, and fine grind, 470 µm, and 2 corn particle sizes: coarse grind, 1,330 µm, and fine grind, 520 µm. In the first experiment, there was an interaction (P < 0.05) between SBM source and particle size on BW at 49 d of age. No differences in BW were observed when birds were fed coarse SSBM or ESBM, whereas birds fed diets containing fine ESBM exhibited lower BW than birds fed diets containing fine SSBM. In the second experiment, fine-grind ESBM (P < 0.05) and corn (P < 0.01) produced greater 19-d BW than did coarse grind. A significant interaction (P < 0.01) between ingredient type and particle size revealed that chicks fed coarse particles of corn or ESBM exhibited higher protein digestibility compared with chicks fed only fine particles. Corn particle size had a greater effect on gizzard weight than ESBM particle size. Birds fed diets that contained coarse corn had larger gizzards than birds fed fine corn (P < 0.01), but differences in gizzard weight were not observed when birds were fed coarse or fine ESBM. Particles greater than 1,300 µm depressed BW but improved protein digestibility.

Abrupt temporal fluctuations in the chicken fecal microbiota are explained by its gastrointestinal origin

One of the main challenges in understanding the composition of fecal microbiota is that it can consist of microbial mixtures originating from different gastrointestinal (GI) segments. Here, we addressed this challenge for broiler chicken feces using a direct 16S rRNA gene-sequencing approach combined with multivariate statistical analyses. Broiler feces were chosen because of easy sampling and the importance for pathogen transmission to the human food chain. Feces were sampled daily for 16 days from chickens with and without a feed structure-induced stimulation of the gastric barrier function. Overall, we found four dominant microbial phylogroups in the feces. Two of the phylogroups were related to clostridia, one to lactobacilli, and one to Escherichia/Shigella. The relative composition of these phylogroups showed apparent stochastic temporal fluctuations in feces. Analyses of dissected chickens at the end of the experiment, however, showed that the two clostridial phylogroups were correlated to the microbiota in the cecum/colon and the small intestine, while the upper gut (crop and gizzard) microbiota was correlated to the lactobacillus phylogroup. In addition, chickens with a stimulated gizzard also showed less of the proximate GI dominating bacterial group in the feces, supporting the importance of the gastric barrier function. In conclusion, our results suggest that GI origin is a main determinant for the chicken fecal microbiota composition. This knowledge will be important for future understanding of factors affecting shedding of both harmful and beneficial gastrointestinal bacteria through feces.

Feed formulations to reduce N excretion and ammonia emission from poultry manure

This summary focuses on reducing nitrogen (N) and ammonia emissions from poultry manure through the use of improved amino acid digestibilities and enzyme supplementation. Proper feed processing techniques, phase feeding, and the minimization of feed and water waste can contribute to additional minor reductions in these emissions. Reductions in environmental pollution can be achieved through improved diet formulation based on available nutrients in the ingredients, reducing crude protein (CP) levels and adding synthetic amino acids. Use of amino acid and CP digestibilities can reduce N excretion up to 40% and a 25% increase in N digestibility can be achieved with enzyme supplementation in broiler diets. Digestibilities can be measured by two methods: the excreta and ileal amino acid digestibilities. Both methods allow amino acid levels to be reduced by 10% or more. Enzyme supplementation decreases intestinal viscosity, improves metabolizable energy levels, and increases amino acid digestibilities. Many feed manufacturers still use total amino acid content to formulate feeds. To meet amino acid requirements, crystalline amino acids are needed. The use of feather, meat and bone meal must not be overestimated or underestimated and the limiting amino acids such as cystine, tryptophan, and threonine must be carefully analyzed.

Effect of Increased Heat Processing and Particle Size on Phosphorus Bioavailability in Corn Distillers Dried Grains with Solubles

Previous studies have reported that increased heat processing and feeding larger particle size ingredients may increase the bioavailability of phytate P in some feedstuffs. Therefore, one chick experiment was conducted to determine the effect of various increased heat processing treatments on bioavailability of P in corn distillers dried grains with solubles (DDGS), and 2 chick experiments were conducted to determine the effect of particle size on bioavailability of P in DDGS. In addition, one precision-fed cecectomized rooster assay was conducted to evaluate the effects of increased heating on amino acid digestibility. For the chick experiments, a P-deficient cornstarch-dextrose-soybean meal basal diet containing 0.10% nonphytate P was supplemented with 0.0, 0.05, or 0.10% P from KH(2)PO(4) or 1 of 2 levels of DDGS. Diets were fed from 8 to 22 d of age, and P bioavailability relative to the P in KH(2)PO(4) was estimated using the standard curve or slope-ratio methods with tibia ash as the response variable. Increased heating of DDGS by autoclaving at 124 kPa and 121 degrees C for 60 to 80 min or by heating in a drying oven at 121 degrees C for 60 min significantly increased relative P bioavailability in DDGS (from 70 to as high as 91%) in several treatments. Amino acid digestibility, however, was greatly reduced by increased heating in most cases, particularly for Lys. Relative bioavailability of P was not significantly affected by DDGS particle sizes ranging from 542 to 837 microm. Our results indicated that increased heating of DDGS increased bioavailability of P but decreased digestibility of amino acids, particularly Lys, and that bioavailability of P was not affected by particle size.

Stepwise extraction of proteins and carbohydrates from soybean seed

The stepwise hot water extraction of soybeans, which were extractions in a series of procedures of whole soybean seeds, dehulled and sliced ones, and pressed ones carried out by autoclaving, was investigated to study the localization in the seed and their characteristics. The characteristics of each extraction were studied by HPLC, SDS-PAGE, components analysis, microscopic observation, and effect for some enzymes. Carbohydrates were easier to extract than protein. In the extractions, the ratio of uronic acid per total sugar was constantly about 0.3. A comparison of these extracts, soybean milk, extraction from defatted soybean meal, and soybean milk residues was also carried out, and the characteristics and the localization were investigated. Mid-sized proteins in soybean milk were easy to extract. However, hardly any high molecular weight proteins or high molecular weight carbohydrates were extracted. The proteins and carbohydrates were considered to be localized in the middle lamella and in the protein and/or oil bodies of the cell, and the proteins and carbohydrates were gradually extracted through seed and cell breaking. Gelation was observed only in the boiled extracts from whole seeds. Pepsin and trypsin digests of the high molecular weight protein had inhibitory activity against the angiotensin I converting enzyme.