Determination of sulphite reductase activity and its response to assimilable nitrogen status in a commercial Saccharomyces cerevisiae wine yeast

Wine Faults: State of Knowledge in Reductive Aromas, Oxidation and Atypical Aging, Prevention, and Correction Methods

The review summarizes the latest scientific findings and recommendations for the prevention of three very common wine faults of non-microbial origin. The first group, presented by the reductive aromas, is caused mainly by excessive H₂S and other volatile sulfur compounds with a negative impact on wine quality. The most efficient prevention of undesirable reductive aromas in wine lies in creating optimal conditions for yeast and controlling the chemistry of sulfur compounds, and the pros and cons of correction methods are discussed. The second is browning which is associated especially with the enzymatic and non-enzymatic reaction of polyphenols and the prevention of this fault is connected with decreasing the polyphenol content in must, lowering oxygen access during handling, the use of antioxidants, and correction stands for the use of fining agents. The third fault, atypical aging, mostly occurs in the agrotechnics of the entire green land cover in the vineyard and the associated stress from lack of nutrients and moisture. Typical fox tones, naphthalene, or wet towel off-odors, especially in white wines are possible to prevent by proper moisture and grassland cover and alternating greenery combined with harmonious nutrition, while the correction is possible only partially with an application of fresh yeast. With the current knowledge, the mistakes in wines of non-microbial origin can be reliably prevented. Prevention is essential because corrective solutions for the faults are difficult and never perfect.

Formation, Losses, Preservation and Recovery of Aroma Compounds in the Winemaking Process

A wine’s aroma profile is an important part of the criteria affecting wine acceptability by consumers. Its characterisation is complex because volatile molecules usually belong to different classes such as alcohols, esters, aldehydes, acids, terpenes, phenols and lactones with a wide range of polarity, concentrations and undesirable off-aromas. This review focused on mechanisms and conditions of the formation of individual aroma compounds in wine such as esters and higher alcohols by yeast during fermentation. Additionally, aroma losses during fermentation are currently the subject of many studies because they can lead to a reduction in wine quality. Principles of aroma losses, their prevention and recovery techniques are described in this review.

How to modulate the formation of negative volatile sulfur compounds during wine fermentation?

Beyond the production of positive aromas during alcoholic fermentation, Saccharomyces cerevisiae metabolism also results in the formation of volatile compounds detrimental to wine quality, including a wide range of volatile sulfur compounds (VSCs). The formation of these VSCs during wine fermentation is strongly variable and depends on biological and environmental factors. First, the comparison of the VSCs profile of 22 S. cerevisiae strains provided a comprehensive overview of the intra-species diversity in VSCs production: according to their genetic background, strains synthetized from 1 to 6 different sulfur molecules, in a 1- to 30-fold concentration range. The impact of fermentation parameters on VSCs production was then investigated. We identified yeast assimilable nitrogen, cysteine, methionine and pantothenic acid contents – but not SO₂ content – as the main factors modulating VSCs production. In particular, ethylthioacetate and all the VSCs deriving from methionine catabolism displayed a maximal production at yeast assimilable nitrogen concentrations around 250 mg/L; pantothenic acid had a positive impact on compounds deriving from methionine catabolism through the Ehrlich pathway but a negative one on the production of thioesters. Overall, these results highlight those factors to be taken into account to modulate the formation of negative VSCs and limit their content in wines.

Population Kinetics and Mechanistic Aspects of Saccharomyces cerevisiae Growth in Relation to Selenium Sulfide Nanoparticle Synthesis

Biosynthesis of nanoparticles (NPs) by microorganisms is a cost- and energy-effective approach. However, how the production of NPs affects the population of producing organism remains as an unresolved question. The present study aimed to evaluate the kinetics of Saccharomyces cerevisiae growth in relation to synthesis of selenium sulfide nanoparticles by using a population model. To this end, the population of S. cerevisiae cells was investigated in terms of colony forming units (CFU) in the presence of the substrate in different time points. Fluctuation of sulfite reductase (SiR) activity, expression of MET5 and MET10 genes, and concentrations of sulfite and selenium were evaluated to support the population findings. CFU values in the test groups were lower than those in the control counterparts. The rise and fall of the SiR activity and MET5 and MET10 gene expression conformed to the variations of CFU values. The rate of reduction in the selenium and sulfite concentrations tended to decrease over the time. In conclusion, the cells population was negatively and positively affected by selenium and sulfite concentrations, respectively. The indirect relationship of the selenium ions concentration in the path analysis revealed that the product, selenium sulfide nanoparticles, caused this drop in S. cerevisiae cells population.

Influence of Nutrient Supplementation on Torulaspora Delbrueckii Wine Fermentation Aroma

This study was performed with the aim of characterizing the fermentative performance of three commercial strains of Torulaspora delbrueckii and their impact on the production of volatile and non-volatile compounds. Laboratory-scale single culture fermentations were performed using a commercial white grape juice. The addition of commercial nutrient products enabled us to test the yeasts under two different nutrient conditions. The addition of nutrients promoted fermentation intensity from 9% to 20 % with significant differences (p < 0.05) among the strains tested. The strain diversity together with the nutrient availability influenced the production of volatile compounds.

Exploration of Sulfur Assimilation of Aspergillus fumigatus Reveals Biosynthesis of Sulfur-Containing Amino Acids as a Virulence Determinant

Fungal infections are of major relevance due to the increased numbers of immunocompromised patients, frequently delayed diagnosis, and limited therapeutics. To date, the growth and nutritional requirements of fungi during infection, which are relevant for invasion of the host, are poorly understood. This is particularly true for invasive pulmonary aspergillosis, as so far, sources of (macro)elements that are exploited during infection have been identified to only a limited extent. Here, we have investigated sulfur (S) utilization by the human-pathogenic mold Aspergillus fumigatus during invasive growth. Our data reveal that inorganic S compounds or taurine is unlikely to serve as an S source during invasive pulmonary aspergillosis since a sulfate transporter mutant strain and a sulfite reductase mutant strain are fully virulent. In contrast, the S-containing amino acid cysteine is limiting for fungal growth, as proven by the reduced virulence of a cysteine auxotroph. Moreover, phenotypic characterization of this strain further revealed the robustness of the subordinate glutathione redox system. Interestingly, we demonstrate that methionine synthase is essential for A. fumigatus virulence, defining the biosynthetic route of this proteinogenic amino acid as a potential antifungal target. In conclusion, we provide novel insights into the nutritional requirements ofA. fumigatus during pathogenesis, a prerequisite to understanding and fighting infection.

Effects of rehydration nutrients on H2S metabolism and formation of volatile sulfur compounds by the wine yeast VL3

In winemaking, nutrient supplementation is a common practice for optimising fermentation and producing quality wine. Nutritionally suboptimal grape juices are often enriched with nutrients in order to manipulate the production of yeast aroma compounds. Nutrients are also added to active dry yeast (ADY) rehydration media to enhance subsequent fermentation performance. In this study we demonstrate that nutrient supplementation at rehydration also has a significant effect on the formation of volatile sulfur compounds during wine fermentations. The concentration of the 'fruity' aroma compounds, the polyfunctional thiols 3-mercaptohexan-1-ol (3MH) and 3-mercaptohexyl acetate (3MHA), was increased while the concentration of the 'rotten egg' aroma compound, hydrogen sulfide (H2S), was decreased. Nutrient supplementation of the rehydration media also changed the kinetics of H2S production during fermentation by advancing onset of H2S production. Microarray analysis revealed that this was not due to expression changes within the sulfate assimilation pathway, which is known to be a major contributor to H2S production. To gain insight into possible mechanisms responsible for this effect, a component of the rehydration nutrient mix, the tri-peptide glutathione (GSH) was added at rehydration and studied for its subsequent effects on H2S formation. GSH was found to be taken up during rehydration and to act as a source for H2S during the following fermentation. These findings represent a potential approach for managing sulfur aroma production through the use of rehydration nutrients.

Occurrence of hydrogen sulfide in wine and in fermentation: influence of yeast strain and supplementation of yeast available nitrogen

Hydrogen sulfide (H₂S) is a powerful aroma compound largely produced by yeast during fermentation. Its occurrence in wines and other fermented beverages has been associated with off-odors described as rotten egg and/or sewage. While the formation of hydrogen sulfide (H₂S) during fermentation has been extensively studied, it is the final H₂S content of wine that is actually linked to potential off-odors. Nevertheless, factors determining final H₂S content of wine have received little attention, and it is commonly assumed that high H₂S-forming fermentations will result in high final concentrations of H₂S. However, a clear relationship has never been established. In this report, we investigated the contribution of yeast strain and nitrogen addition to H₂S formation during fermentation and its consequent occurrence the resulting wines. Five commercial Saccharomyces cerevisiae wine yeast strains were used to ferment a Chardonnay juice containing 110 mg/l of YAN (yeast assimilable nitrogen), supplemented with di-ammonium phosphate (DAP) to increase YAN concentration to moderate (260 mg/l) and high (410 mg/l) levels. In contrast to the widely reported decrease in H₂S production in response to DAP addition, a non-linear relationship was found such that moderate DAP supplementation resulted in a remarkable increase in H₂S formation by each of the five wine yeasts. H₂S content of the finished wine was affected by yeast strain, YAN, and fermentation vigor. However, we did not observe a correlation between concentration of H₂S in the finished wines and H₂S produced during fermentation, with low-forming fermentations often having relatively high final H₂S and vice versa. Management of H₂S in wine through nitrogen supplementation requires knowledge of initial YAN and yeast H₂S characteristics.

Differential expression of thiamine biosynthetic genes in yeast strains with high and low production of hydrogen sulfide during wine fermentation

AIMS

Release of hydrogen sulfide by fermenting yeast is a potential problem in wine production, because of its strong organoleptic impact. To identify the genetic determinants of sulfide production, we compared the transcriptomes of two wine yeast strains with similar oenological properties, but with very different levels of sulfide production, UDC522 (high sulfide producer) and P29 (low producer).

METHODS AND RESULTS

Oenological microfermentations were sampled at the peak production of sulfide. Transcription profiles of the two strains were analysed by three methods, a cDNA-based array, an oligonucleotide-based array and qRT-PCR analysis of selected transcripts. Less than 10% of yeast genes showed significant differences between the two strains. High sulfide production correlated with a general overexpression of thiamine biosynthesis genes, whereas genes linked to the catabolism of sulfur-containing compounds (like amino acids) showed no significant expression differences between both strains.

CONCLUSIONS

Our data suggest a relationship between the thiamine biosynthetic pathway and sulfide production during wine fermentation.

SIGNIFICANCE AND IMPACT OF THE STUDY

This study provides a first hint which indicates that for some yeast strains, biosynthesis of thiamine (and perhaps of other sulfur-containing compounds) may be more relevant than the general nitrogen metabolism in explaining sulfide production by some yeast strains during vinification, defining new targets for genetic improvement of wine yeast strains.

Effect of nitrogen supplementation and Saccharomyces species on hydrogen sulfide and other volatile sulfur compounds in shiraz fermentation and wine

A Shiraz must with low yeast assimilable nitrogen (YAN) was supplemented with two increasing concentrations of diammonium phosphate (DAP) and fermented with one Saccharomyces cerevisiae and one Saccharomyces bayanus strain, with maceration on grape skins. Hydrogen sulfide (H(2)S) was monitored throughout fermentation, and a total of 16 volatile sulfur compounds (VSCs) were quantified in the finished wines. For the S. cerevisiae yeast strain, addition of DAP to a final YAN of 250 or 400 mg/L resulted in an increased formation of H(2)S compared to nonsupplemented fermentations (100 mg/L YAN). For this yeast, DAP-supplemented fermentations also showed prolonged formation of H(2)S into the later stage of fermentation, which was associated with increased H(2)S in the final wines. The S. bayanus strain showed a different H(2)S production profile, in which production was inversely correlated to initial YAN. No correlation was found between total H(2)S produced by either yeast during fermentation and H(2)S concentration in the final wines. For both yeasts, DAP supplementation yielded higher concentrations of organic VSCs in the finished wines, including sulfides, disulfides, mercaptans, and mercaptoesters. PCA analysis indicated that nitrogen supplementation before fermentation determined a much clearer distinction between the VSC profiles of the two yeasts compared to nonsupplemented fermentations. These results raise questions concerning the widespread use of DAP in the management of low YAN fermentations with respect to the formation of reductive characters in wine.

Modulation of volatile sulfur compounds by wine yeast

Sulfur compounds in wine can be a 'double-edged sword'. On the one hand, certain sulfur-containing volatile compounds such as hydrogen sulfide, imparting a rotten egg-like aroma, can have a negative impact on the perceived quality of the wine, and on the other hand, some sulfur compounds such as 3-mercaptohexanol, imparting fruitiness, can have a positive impact on wine flavor and aroma. Furthermore, these compounds can become less or more attractive or repulsive depending on their absolute and relative concentrations. This presents an interesting challenge to the winemaker to modulate the concentrations of these quality-determining compounds in wine in accordance with consumer preferences. The wine yeast Saccharomyces cerevisiae plays a central role in the production of volatile sulfur compounds. Through the sulfate reduction sequence pathway, the HS(-) is formed, which can lead to the formation of hydrogen sulfide and various mercaptan compounds. Therefore, limiting the formation of the HS(-) ion is an important target in metabolic engineering of wine yeast. The wine yeast is also responsible for the transformation of non-volatile sulfur precursors, present in the grape, to volatile, flavor-active thiol compounds. In particular, 4-mercapto-4-methylpentan-2-one, 3-mercaptohexanol, and 3-mercaptohexyl acetate are the most important volatile thiols adding fruitiness to wine. This paper briefly reviews the metabolic processes involved in the production of important volatile sulfur compounds and the latest strategies in the pursuit of developing wine yeast strains as tools to adjust wine aroma to market specifications.

Winemaking Biochemistry and Microbiology: Current Knowledge and Future Trends

The fermentation of grape must and the production of premium quality wines are a complex biochemical process that involves the interactions of enzymes from many different microbial species, but mainly yeasts and lactic acid bacteria. Yeasts are predominant in wine and carry out the alcoholic fermentation, while lactic acid bacteria are responsible for malolactic fermentation. Moreover, several optional winemaking techniques involve the use of technical enzyme preparations. Considerable progress has been made recently in understanding the biochemistry and interactions of enzymes during the winemaking process. In this study, some of these recent contributions in the biochemistry of winemaking are reviewed. This article intends to provide an updated overview (including works published until December, 2003) on the main biochemical and microbiological contributions of the different techniques that can be used in winemaking. As well as considering the transformations that take place in traditional winemaking, the production of special wines, such as sparkling wines, 'sur lie' wines, and biologically aged wines, are also studied.

Fermentative activity and production of volatile compounds by Saccharomyces grown in synthetic grape juice media deficient in assimilable nitrogen and/or pantothenic acid

AIMS

To understand the impact of assimilable nitrogen and pantothenic acid on fermentation rate and synthesis of volatile compounds by Saccharomyces under fermentative conditions.

METHODS AND RESULTS

A 2 x 3 factorial experimental design was employed with the concentrations of yeast assimilable nitrogen (YAN) (60 and 250 mg l(-1)) and pantothenic acid (10, 50 and 250 microg l(-1)) as variables. In media containing 250 microg l(-1) pantothenic acid, H2S production by two different species of Saccharomyces decreased when YAN was increased from 60 to 250 mg l(-1). Conversely, H2S production was significantly higher when the concentration of assimilable nitrogen was increased if pantothenic acid was deficient (10 or 50 microg l(-1)). Yeast synthesis of other volatile compounds were impacted by both assimilable nitrogen and pantothenic acid.

CONCLUSIONS

While growth and fermentative rate of Saccharomyces was more influenced by nitrogen than by pantothenic acid, complicated interactions exist between these nutrients that affect the synthesis of volatile compounds including H2S.

SIGNIFICANCE AND IMPACT OF THE STUDY

This study has important implications for the winemaking industry where a better understanding of the nutritional requirements of Saccharomyces is necessary to reduce fermentation problems and to improve final product quality.

MET17 and hydrogen sulfide formation in Saccharomyces cerevisiae

Commercial isolates of Saccharomyces cerevisiae differ in the production of hydrogen sulfide (H(2)S) during fermentation, which has been attributed to variation in the ability to incorporate reduced sulfur into organic compounds. We transformed two commercial strains (UCD522 and UCD713) with a plasmid overexpressing the MET17 gene, which encodes the bifunctional O-acetylserine/O-acetylhomoserine sulfhydrylase (OAS/OAH SHLase), to test the hypothesis that the level of activity of this enzyme limits reduced sulfur incorporation, leading to H(2)S release. Overexpression of MET17 resulted in a 10- to 70-fold increase in OAS/OAH SHLase activity in UCD522 but had no impact on the level of H(2)S produced. In contrast, OAS/OAH SHLase activity was not as highly expressed in transformants of UCD713 (0.5- to 10-fold) but resulted in greatly reduced H(2)S formation. Overexpression of OAS/OAH SHLase activity was greater in UCD713 when grown under low-nitrogen conditions, but the impact on reduction of H(2)S was greater under high-nitrogen conditions. Thus, there was not a good correlation between the level of enzyme activity and H(2)S production. We measured cellular levels of cysteine to determine the impact of overexpression of OAS/OAH SHLase activity on sulfur incorporation. While Met17p activity was not correlated with increased cysteine production, conditions that led to elevated cytoplasmic levels of cysteine also reduced H(2)S formation. Our data do not support the simple hypothesis that variation in OAS/OAH SHLase activity is correlated with H(2)S production and release.

SSU1 mediates sulphite efflux in Saccharomyces cerevisiae

Ssu1p, a plasma membrane protein involved in sulphite metabolism in Saccharomyces cerevisiae, was found to be required for efficient sulphite efflux. An SSU1 null mutant accumulated significantly more sulphite than wild-type, whereas cells expressing multicopy SSU1 accumulated significantly less. Cells expressing FZF1-4, a dominant allele of a transcriptional activator of SSU1 that confers sulphite resistance, also accumulated less sulphite. beta-galactosidase activity in the FZF1-4 strain carrying an SSU1::lacZ fusion was found to be 8.5-fold higher than in a strain carrying wild-type FZF1, confirming that the heightened resistance was correlated with hyperactivation of SSU1. Multicopy SSU1 was also found to increase the sulphite resistance of a number of unrelated sulphite-sensitive strains by a factor of 3- to 8-fold. Rates of efflux of free sulphite from cells expressing multicopy SSU1 or FZF1-4 were significantly greater than that from wild-type or from a SSU1 null mutant. Rates of efflux of bound sulphite from wild-type, a SSU1 null mutant, a FZF1-4 mutant, or cells expressing multicopy SSU1 were not significantly different, suggesting that Ssu1p specifically mediates efflux of the free form of sulphite.