Preparation of highly concentrated and white cell-poor platelet-rich plasma by plateletpheresis

Growth factor and cytokine characterization of canine platelet lysate with variable leukocyte concentration, plasma content, and heat-sensitive proteins

Background

Platelet lysate is an acellular platelet product containing factors released from secretory granules, including cytokines and growth factors. This study aimed to evaluate different centrifugation methods used to prepare canine platelet lysate with variable content of leukocytes, plasma, and heat-sensitive proteins.

Methods

Whole blood was collected from six dogs and two double-spin preparation methods were used to generate the platelet-rich plasma with reduced (PRP) and high (L-PRP) concentration of leukocytes. A portion of both methods underwent plasma depletion via centrifugation and platelet lysate was generated via freeze-thaw cycles. A portion of the generated platelet lysate underwent complement inactivation via heat treatment. Growth factors (TGF-β1, VEGF, TNF-α, PDGF-BB, HGF) were quantified in all different platelet lysate preparations using ELISAs.

Results

Both platelet-rich plasma preparations had a 6.7-fold increase in platelet concentration. White blood cell (WBC) concentration compared to whole blood increased 1.2-fold times in PRP and 1.9-fold times in L-PRP. Negligible concentrations of platelets, WBC, and hematocrit were identified in all lysate groups. Statistically significant differences were identified for PDGF, VEGF, and TNF-α, and not for TGF-β or HGF. No growth factor differences were noted between centrifugation methods. PDGF was significantly higher in platelet lysate that was plasma depleted. VEGF was significantly higher in heat-treated lysate groups. TNF-α concentrations were overall very low, though were noted to significantly increase following plasma depletion.

Conclusion

These results support that growth factors and cytokine release can be affected by the platelet lysate preparation and processing.

Optimization of a Two-Step Centrifugation Protocol for Bovine Platelet-Rich Plasma

Platelet-rich plasma ( PRP), an autologous platelet concentrated in plasma, is a source of diverse growth factors and is extensively utilized to promote tissue healing. Most of the clinical and laboratory investigations in veterinary medicine have focused on horses and dogs. Consequently, the types and detailed conditions of the PRP preparation method are based on those species. However, in bovine medicine, only a few studies have investigated the species-specific characteristics of bovine platelets. The aim of this study was to optimize the conditions of a two-step centrifugation method for bovine PRP. Whole blood samples were obtained from eight healthy lactating Holstein-Friesian cows. Eight running conditions for the first and second centrifugations each were evaluated based on the platelet recovery rate, the concentration of growth factors, and the adenosine diphosphate (ADP)-induced aggregation response, which reflects the premature platelet activation caused by the centrifugation process. The results of this study showed that for the first and second centrifugations, 900×g for 10 minutes and 1250×g for 15 minutes, respectively, were the most suitable conditions for the platelet recovery rate, and the concentration of growth factors was highest under these conditions without significant activation of premature platelet aggregation. Thus, we established an optimal two-step centrifugation protocol for bovine PRP that should provide a better understanding of bovine platelets.

Direct Impact of Human Platelets on the Development of Transplant Arteriosclerosis

BACKGROUND

Platelets play an important role in the pathogenesis of inflammatory and proliferative vascular changes. The aim of this study was to investigate whether human platelets are able to induce transplant arteriosclerosis in a humanized C57/Bl6-Rag2-/-γc-/- mouse xenograft model.

METHODS

Nonactivated and in vitro-activated human platelets were analyzed and phenotyped for surface markers by flow cytometry. Side branches of human mammary arteries were implanted into the infrarenal aorta of recipients, followed by daily application of human platelets and histological analyzed on day 30 after transplantation.

RESULTS

Human platelets collected by apheresis had low levels of platelet activation markers. However, after in vitro activation, expression was markedly increased. Sixty minutes after injection in recipient mice, nonactivated human platelets become significantly activated. Increased adhesion of platelets to the vascular endothelium was detected by in vivo fluorescence microscopy. After intravenous injection of nonactivated or activated platelets, human xenografts showed pronounced intimal proliferation. Immunohistological analysis showed that the group treated with activated human platelets exhibited significantly increased intragraft protein expression of intracellular adhesion molecule-1 and platelet-derived growth factor receptor beta and smooth muscle cell migration into the neointima.

CONCLUSIONS

These data demonstrate that an isolated daily application of both in vivo- and in vitro-activated human platelets results in the development of transplant arteriosclerosis in a humanized mouse transplantation model.

The optimal platelet concentration in platelet-rich plasma for proliferation of human cells in vitro-diversity, biases, and possible basic experimental principles for further research in the field: A review

BACKGROUND

In the last decades, several in vitro studies have tested the effect of plate-rich plasma (PRP) on the proliferation of human cells in search of a wizard for the use of PRP in a clinical setting. However, the literature displays striking differences regarding this question despite the relatively similar experimental design. The aim of this review is twofold: describe and explain this diversity and suggest basic principles for further in vitro studies in the field. The optimal platelet concentration in vivo will also be discussed.

METHODS

A search in mainly EMBASE and PubMed was performed to identify in vitro studies that investigate the effect of different PRP concentrations on human cell proliferation. The assessment of bias was based on the principles of "Good Cell Culture Practice" and adapted.

RESULTS

In total, 965 in vitro studies were detected. After the initial screening, 31 studies remained for full-text screening. A total of 16 studies met the criteria of final inclusion and appeared relatively sound. In general, the studies state consistently that PRP stimulates the proliferation of the human cell. Two main types of experimental techniques were detected: 1. The Fixed PRP Concentration Group using a fixed PRP concentration throughout the experiment, which leads to a substantial decrease in nutrition available at higher concentrations. 2. The Fixed PRP Volume Group using a fixed PRP-to-media ratio (Vol/Vol) throughout the experiment. A general tendency was observed in both groups: when the PRP to media ratio increased (Vol/Vol), the proliferation rate decreased. Further, The Low Leukocyte group observed a substantial higher optimal PRP concentration than The High leukocyte group. No prominent tendencies was seen regarding anticoagulants, activation methods, and blood donor (age or sex).

DISCUSSION

Two major biases regarding optimal proliferation in vitro is pointed out: 1. Too high PRP volume. It is speculated that the techniques used by some studies led to an adverse growth condition and even cell starvation at higher concentrations. 2. High leukocyte levels. Reduced proliferation rate due to proinflammatory substances released during degranulation of leukocytes.

CONCLUSIONS

The two main biases may explain the bell-shaped effect of PRP and the detrimental effects at higher platelet concentrations observed in several studies. These biases may also explain the low optimal PRP concentration observed in some studies. Even if one universal optimal PRP concentration does not exist, the review indicates that PRP concentrations in the upper parts of the scale is optimal or at least beneficial. Finally, following basic experimental principles are suggested. 1: The PRP/media ratio (Vol/Vol) should be kept as constant. 2: The PRP/media ratio should provide a sufficient nutrition supply, that is, PRP ≤ 10% (Vol/Vol). 3: The cell density per well (cells/mL) should be defined. 4: Leukocyte level should be kept low, preferable depleted (< 0.1 PLT/µL).

Efficacy of a Semi Automated Commercial Closed System for Autologous Leukocyte- and Platelet-Rich Plasma (l-prp) Production in Dogs: A Preliminary Study

BACKGROUND

To characterize the cellular composition (platelets, erythrocytes, and leukocytes) and determine platelet-derived growth factor isoform BB (PDGF-BB) concentration in canine leukocyte- and platelet rich plasma (L-PRP) produced using a commercial semi-automated closed system.

METHODS

Twenty milliliters of citrated whole blood were obtained from 30 healthy un-sedated canine blood donors and processed using a semi-automated completely closed commercial system (CPUNT 20, Eltek group, Casale Monferrato, Alessandria, Italy) according to the manufacturer's instructions. Erythrocyte, leukocyte, and platelet counts were determined in both whole blood (WB) and resultant L-PRP. The PDGF-BB concentration was evaluated after bovine thrombin activation of 10 L-PRP samples.

RESULTS

This commercial system produced on average 2.3 ± 0.7 mL of L-PRP containing a high concentration of platelets (767,633 ± 291,001 μL, p < 0.001), with a 4.4 fold increase in platelet count, lower concentration of erythrocytes (528,600 ± 222,773 μL, p < 0.001) and similar concentration of leukocytes (8422 ± 6346 μL, p = 0.9918) compared with WB. L-PRP had an average of 3442 ± 2061 pg/mL of PDGF-BB after thrombin activation. Neutrophils, lymphocytes and monocytes average percent content in L-PRP was 14.8 ± 13.2, 71.7 ± 18.5 and 10.7 ± 6.4, respectively.

CONCLUSION

Sterile canine L-PRP prepared using this semi-automated closed system is easy to obtain, produces a significant increase in platelet count compared to WB and contains a detectable concentration of PDGF-BB after activation. Additional in vitro and in vivo studies are needed to assess inflammatory markers concentration and the therapeutic efficacy of this L-PRP in dogs.

Trefoil Factor 3 (TFF3) Is Involved in Cell Migration for Skeletal Repair

The aim of the study was to explore the possible role of Trefoil Factor Family peptide 3 (TFF3) for skeletal repair. The expression of TFF3 was analyzed in human joint tissues as well as in a murine bone fracture model. Serum levels of TFF3 following a defined skeletal trauma in humans were determined by ELISA. The mRNA expression of TFF3 was analyzed under normoxia and hypoxia. Expression analysis after stimulation of human mesenchymal progenitor cells (MPCs) with TFF3 was performed by RT² Profiler PCR Array. The effect of recombinant human (rh)TFF3 on MPCs was analysed by different migration and chemotaxis assays. The effect on cell motility was also visualized by fluorescence staining of F-Actin. TFF3 was absent in human articular cartilage, but strongly expressed in the subchondral bone and periosteum of adult joints. Strong TFF3 immunoreactivity was also detected in murine fracture callus. Serum levels of TFF3 were significantly increased after skeletal trauma in humans. Expression analysis demonstrated that rhTFF3 significantly decreased mRNA of ROCK1. Wound healing assays showed increased cell migration of MPCs by rhTFF3. The F-Actin cytoskeleton was markedly influenced by rhTFF3. Cell proliferation was not increased by rhTFF3. The data demonstrate elevated expression of TFF3 after skeletal trauma. The stimulatory effects on cell motility and migration of MPCs suggest a role of TFF3 in skeletal repair.

Platelet-Rich Plasma and the Knee-Applications in Orthopedic Surgery

PURPOSE OF REVIEW

To consolidate and synthesize the most recent evidence on the effects of platelet-rich plasma (PRP) in the knee with respect to osteoarthritis, meniscal injuries, ACL reconstruction, total knee arthroplasty (TKA), and high tibial osteotomy.

RECENT FINDINGS

PRP has been shown to be more beneficial in the context of knee osteoarthritis compared to both placebo and hyaluronic acid. Direct comparison with corticosteroid injections has been sparsely studied. It has also been shown to improve the clinical postoperative course in meniscal injuries and to a lesser extent TKA. Radiographic improvements without clinically significant benefits have been observed with ACL reconstructions treated with PRP. PRP injections may be more beneficial than other current non-surgical management options for specific knee pathologies. Further research should broaden the knowledge of PRP effects on the knee, and identify the type of PRP, growth factor distribution, and route of administration associated with the most benefit.

A 24-month follow-up after treatment of hallux rigidus with resection arthroplasty in combination with a resorbable polymer-based implant and platelet-rich plasma

BACKGROUND

Aim of this study was to analyze the clinical outcome after treatment of hallux rigidus with implantation of a resorbable polymer-based implant immersed with autologous platelet-rich plasma (PRP).

METHODS

Forty-five patients with hallux rigidus were treated with three-stage resection arthroplasty and subsequent covering of the metatarsal head with a polyglycolic acid-hyaluronan implant immersed with autologous PRP. Patients were clinically assessed using the AOFAS rating scale preoperatively and at 12 and 24 month follow-up. Alignment and range of motion in the metatarsophalangeal joint was measured using a goniometer.

RESULTS

The AOFAS rating scale and ROM showed significant (p<.01) improvement in all subcategories one and two years after surgery compared to the preoperative situation.

CONCLUSIONS

Covering of the metatarsal head after resection arthroplasty with the PGA-hyaluronan implant immersed with autologous PRP is safe and leads to a notable improvement of the symptoms in patients with hallux rigidus.

Optimisation of a double-centrifugation method for preparation of canine platelet-rich plasma

Background

Platelet-rich plasma (PRP) has been expected for regenerative medicine because of its growth factors. However, there is considerable variability in the recovery and yield of platelets and the concentration of growth factors in PRP preparations. The aim of this study was to identify optimal relative centrifugal force and spin time for the preparation of PRP from canine blood using a double-centrifugation tube method.

Methods

Whole blood samples were collected in citrate blood collection tubes from 12 healthy beagles. For the first centrifugation step, 10 different run conditions were compared to determine which condition produced optimal recovery of platelets. Once the optimal condition was identified, platelet-containing plasma prepared using that condition was subjected to a second centrifugation to pellet platelets. For the second centrifugation, 12 different run conditions were compared to identify the centrifugal force and spin time to produce maximal pellet recovery and concentration increase. Growth factor levels were estimated by using ELISA to measure platelet-derived growth factor-BB (PDGF-BB) concentrations in optimised CaCl₂-activated platelet fractions.

Results

The highest platelet recovery rate and yield were obtained by first centrifuging whole blood at 1000 g for 5 min and then centrifuging the recovered platelet-enriched plasma at 1500 g for 15 min. This protocol recovered 80% of platelets from whole blood and increased platelet concentration six-fold and produced the highest concentration of PDGF-BB in activated fractions.

Conclusions

We have described an optimised double-centrifugation tube method for the preparation of PRP from canine blood. This optimised method does not require particularly expensive equipment or high technical ability and can readily be carried out in a veterinary clinical setting.

Electronic supplementary material

The online version of this article (doi:10.1186/s12917-017-1123-3) contains supplementary material, which is available to authorized users.

ALLOGENEIC PLATELET-RICH PLASMA FOR ROTATOR CUFF REPAIR

OBJECTIVE

To investigate the safety and efficacy of allogeneic platelet-rich plasma (PRP) in rotator cuff repair .

METHODS

Seventeen patients with a full-thickness rotator cuff tear were included. Ten patients underwent arthroscopic rotator cuff repair with allogeneic, and seven patients with autologous PRP. Three PRP gels in a volume 3 ml each were applied between the torn end and the greater tuberosity. Clinical outcomes were assessed preoperatively and at a minimum of 2 years after surgery. Structural outcomes were evaluated with the presence of retear and the change of the cross-sectional area (ACT) of the supraspinatus .

RESULTS

Allogeneic PRP did not cause any adverse events during the follow-up period. There was no significant difference in the clinical outcome measures between the two groups (all p > 0.05). The retear rate was 33.3% and 25.0% in the allogeneic group and autologous group, respectively (p = 0.764). The change between the one-year postoperative and immediately postoperative ACT was not also significantly different between the two groups (p = 0.373) .

CONCLUSION

Allogeneic PRP in arthroscopic rotator cuff did not cause any local or general complications and that has the efficacy comparable to autologous PRP with respect to the clinical and structural outcomes. Level of Evidence III, Retrospective Comparative Study.

Harmful Effects of Leukocyte-Rich Platelet-Rich Plasma on Rabbit Tendon Stem Cells In Vitro

BACKGROUND

Platelet-rich plasma (PRP) is now widely used as a promising treatment for patients with tendinopathy. However, the efficacy of PRP treatment for tendinopathy is controversial mainly because of inconsistent results from human clinical trials and particularly because the concentration and effect of leukocytes in PRP remain largely unknown.

HYPOTHESIS

Leukocyte-rich PRP (L-PRP) inhibits growth factor release, decreases proliferation, and induces nontenocyte differentiation of tendon stem cells (TSCs); increases catabolic cytokine concentrations; and causes inflammation and apoptosis. Thus, L-PRP has a detrimental effect on tendon stem/progenitor cells, which impairs injured tendon healing.

STUDY DESIGN

Controlled laboratory study.

METHODS

Pure PRP (P-PRP) and L-PRP were prepared from the same individual rabbit blood, and platelet numbers in each PRP product were adjusted to reach the same level. The leukocyte level in L-PRP was 4 and 8 times higher than those in whole blood and P-PRP, respectively. The growth factors in both P-PRP and L-PRP were measured by enzyme-linked immunosorbent assay kits. The morphology, stemness, proliferation, and differentiation of TSCs grown in L-PRP and P-PRP were examined by microscopy, immunocytochemistry, population doubling time, quantitative real-time polymerase chain reaction, and histological analysis.

RESULTS

L-PRP produced lower levels of growth factors, such as vascular endothelial growth factor (VEGF), epidermal growth factor (EGF), transforming growth factor (TGF)-β1, and platelet-derived growth factor (PDGF), than did P-PRP. TSC proliferation was significantly decreased in L-PRP in a concentration-dependent manner. Furthermore, TSCs cultured in P-PRP produced more collagen and formed tendon-like tissue; however, TSCs grown in L-PRP differentiated into nontenocytes and produced more inflammatory factors such as membrane-associated prostaglandin synthase (mPGES) and interleukin (IL)-1β. Moreover, L-PRP was associated with increased apoptosis.

CONCLUSION

L-PRP has harmful effects on TSCs.

CLINICAL RELEVANCE

This study revealed the direct effects of different compositions of PRP on TSCs and provided basic scientific data to help understand the cellular and molecular mechanisms of the efficacy of PRP treatment in clinical use.

Does application of moderately concentrated platelet-rich plasma improve clinical and structural outcome after arthroscopic repair of medium-sized to large rotator cuff tear? A randomized controlled trial

BACKGROUND

Platelet-rich plasma (PRP) has the potential to improve tendon-bone healing. The evidence is still controversial as to whether PRP application after repair of medium-sized to large cuff tears leads to superior structural and clinical outcome, especially after single-row repair.

METHODS

In a randomized study, 102 patients (PRP group, 52 patients; control group, 50 patients) with medium-sized and large degenerative posterosuperior tears were included for arthroscopic repair with a minimum follow-up of 2 years. Patients were evaluated with clinical scores (visual analog scale score, Constant-Murley score, University of California-Los Angeles score, and American Shoulder and Elbow Surgeons score) and ultrasound to assess retear and vascularity pattern of the cuff.

RESULTS

Visual analog scale scores were significantly lower in the PRP group than in controls at 1 month, 3 months, and 6 months but not later. Constant-Murley scores were significantly better in the PRP group compared with controls at 12 and 24 months, whereas University of California-Los Angeles scores were significantly higher in the PRP group at 6 and 12 months (P < .05). The American Shoulder and Elbow Surgeons score in both groups was comparable at all the times. At 24 months, retear in the PRP group (n = 2; 3.8%) was significantly lower than in the control group (n = 10; 20%; P = .01). The retear difference was significant only for large tears (PRP:control group, 1:6; P = .03). Doppler ultrasound examination showed significant vascularity in the PRP group repair site at 3 months postoperatively (P < .05) and in peribursal tissue until 12 months.

CONCLUSION

Application of moderately concentrated PRP improves clinical and structural outcome in large cuff tears. PRP also enhances vascularity around the repair site in the early phase.

Clinical-grade quality platelet-rich plasma releasate (PRP-R/SRGF) from CaCl2 -activated platelet concentrates promoted expansion of mesenchymal stromal cells

BACKGROUND AND OBJECTIVES

The aim of our study was to test a platelet-rich plasma releasate (PRP-R/SRGF) from CaCl2 -activated platelets as a source of growth factors for the expansion of mesenchymal stromal cells (MSCs). PRP-R/SRGF, obtained with a low-cost procedure, is characterized by a reduced variability of growth factor release.

MATERIALS AND METHODS

PRP-R/SRGF is a clinical-grade quality solution obtained from CaCl2 -activated platelets. Its activity was evaluated by measuring the proliferation, the phenotype, the differentiation potential and the immunosuppressive properties of MSCs derived from bone marrow (BM) and adipose tissue (AT).

RESULTS

PRP-R/SRGF was more active than FBS to expand BM- and AT-derived MSCs. PRP-R/SRGF treatment did not affect the expression of typical MSCs surface markers, neither MSCs differentiation potential nor their capability to inhibit activated T-cell proliferation.

CONCLUSIONS

The clinical-grade PRP-R/SRGF may be used in the clinical setting for the expansion of MSCs.

PRP and articular cartilage: a clinical update

The convincing background of the recent studies, investigating the different potentials of platelet-rich plasma, offers the clinician an appealing alternative for the treatment of cartilage lesions and osteoarthritis. Recent evidences in literature have shown that PRP may be helpful both as an adjuvant for surgical treatment of cartilage defects and as a therapeutic tool by intra-articular injection in patients affected by osteoarthritis. In this review, the authors introduce the trophic and anti-inflammatory properties of PRP and the different products of the available platelet concentrates. Then, in a complex scenario made of a great number of clinical variables, they resume the current literature on the PRP applications in cartilage surgery as well as the use of intra-articular PRP injections for the conservative treatment of cartilage degenerative lesions and osteoarthritis in humans, available as both case series and comparative studies. The result of this review confirms the fascinating biological role of PRP, although many aspects yet remain to be clarified and the use of PRP in a clinical setting has to be considered still exploratory.

Clinical and structural outcomes after arthroscopic repair of full-thickness rotator cuff tears with and without platelet-rich product supplementation: a meta-analysis and meta-regression

PURPOSE

The purpose of this study was to perform a systematic review, meta-analysis, and meta-regression of all Level I and Level II studies comparing the clinical or structural outcomes, or both, after rotator cuff repair with and without platelet-rich product (PRP) supplementation.

METHODS

A literature search of the PubMed and EMBASE databases was performed to identify all Level I or II studies comparing the clinical or structural outcomes, or both, after arthroscopic repair of full-thickness rotator cuff tears with (PRP+ group) and without (PRP- group) PRP supplementation. Data included outcome scores (American Shoulder and Elbow Surgeons [ASES], University of California Los Angeles [UCLA], Constant, Simple Shoulder Test [SST] and visual analog scale [VAS] scores) and retears diagnosed with imaging studies. Meta-analyses compared preoperative, postoperative, and gain in outcome scores and relative risk ratios for retears. Meta-regression compared the effect of PRP treatment on outcome scores and retear rates according to 6 covariates. Minimum effect sizes that were detectable with 80% power were also calculated for each study.

RESULTS

Eleven studies were included in this review and a maximum of 8 studies were used for meta-analyses according to data availability. There were no statistically significant differences between the PRP+ and PRP- groups for overall outcome scores or retear rates (P > .05). Overall gain in the Constant score was decreased when liquid PRP was injected over the tendon surface compared with PRP application at the tendon-bone interface (-6.88 points v +0.78 points, respectively; P = .046); however, this difference did not reach the previously reported minimum clinically important difference (MCID) for Constant scores. When the initial tear size was greater than 3 cm in anterior-posterior length, the PRP+ group exhibited decreased retear rates after double-row repairs when compared with the PRP- group (25.9% v 57.1%, respectively; P = .046). Sensitivity power analyses revealed that most included studies were only powered to detect large differences in outcome scores between groups.

CONCLUSIONS

There were no statistically significant differences in overall gain in outcome scores or retear rates between treatment groups. Gain in Constant scores was significantly increased when PRPs were applied at the tendon-bone interface when compared with application over the top of the repaired tendon. Retear rates were significantly decreased when PRPs were used for the treatment of tears greater than 3 cm in anterior-posterior length using a double-row technique. Most of the included studies were only powered to detect large differences in outcome scores between treatment groups. In addition, an increased risk for selection, performance, and attrition biases was found.

LEVEL OF EVIDENCE

Level II, meta-analysis of Level I and Level II studies.

Platelet-rich plasma in the management of articular cartilage pathology: a systematic review

OBJECTIVE

Using systematic review methodology, we endeavored to answer the following questions concerning the treatment of osteochondral pathology: (1) what pathologies have been treated in vivo with the use of platelet-rich plasma (PRP); (2) what methods of PRP preparation and delivery have been reported; (3) what assessment tools and comparison group have been used to assess its effectiveness; and (4) what are the clinical outcomes of its use.

DATA SOURCES

A systematic literature search was performed of the OVID, EMBASE, and Evidence Based Medicine Reviews databases to identify all studies published up to October 2012 that assessed clinical outcomes of the use of PRP for the treatment of chondral and osteochondral pathology, excluding those including concomitant management of acute fractures or ligament reconstruction.

DATA EXTRACTION

The included studies were reviewed and the following data were extracted and tabulated: study authors' year and journal, study design and level of evidence, pathology treated, methods of PRP preparation and delivery, and clinical outcome scores.

DATA SYNTHESIS

Ten studies were included in the final analysis. The majority of studies assessed the use of PRP in the treatment of degenerative osteoarthritis of the knee or hip (representing 570 of a total of 662 joints). The majority of patients were treated with intra-articular injections, whereas 2 studies used PRP as an adjunct to surgical treatment. Significant improvements in joint-specific clinical scores (7 of 8 studies), general health scores (4 of 4 studies), and pain scores (4 of 6 studies) compared with baseline were reported up to 6-month follow-up, but few studies provided longer-term data. No studies reported worse scores compared with baseline at final follow-up. Three of 4 comparative studies reported significantly better clinical and/or pain scores when compared with hyaluronic acid injections at similar follow-up times.

CONCLUSIONS

Currently, there is a paucity of data supporting the use of PRP for the management of focal traumatic osteochondral defects. There is limited evidence suggesting short-term clinical benefits with the use of PRP for symptomatic osteoarthritis of the knee, but the studies published to date are of poor quality and at high risk for bias. Further high-quality comparative studies with longer follow-up are needed to ascertain whether PRP is beneficial, either alone or as an adjunct to surgical procedures, in the management of articular cartilage pathology.

Platelet-rich plasma for arthroscopic repair of large to massive rotator cuff tears: a randomized, single-blind, parallel-group trial

BACKGROUND

Platelet-rich plasma (PRP) is expected to have a biological augmentation potential in the healing of various diseases and injuries, including rotator cuff tears. However, few evaluations have been performed specifically for large to massive tears.

PURPOSE

To assess the efficacy of PRP augmentation in patients undergoing arthroscopic repair for large to massive rotator cuff tears.

STUDY DESIGN

Randomized controlled trial; Level of evidence, 1.

METHODS

A total of 48 patients scheduled for arthroscopic repair of large to massive rotator cuff tears were randomly assigned to receive either PRP-augmented (PRP group) or conventional treatment (conventional group). In the PRP group, 3 PRP gels (3 × 3 mL) were applied to each patient between the torn end and the greater tuberosity. The primary outcome measure was the retear rate assessed by magnetic resonance imaging (MRI) or computed tomographic arthrography (CTA) at a minimum of 9 months after surgery. Secondary outcome measures included pain, range of motion, muscle strength, overall satisfaction, functional scores, and the change in cross-sectional area (CSA) of the supraspinatus.

RESULTS

The retear rate of the PRP group (20.0%) was significantly lower than that of the conventional group (55.6%) (P = .023). Clinical outcomes showed no statistical difference between the 2 groups (all P > .05) except for the overall function (P = .043). The change in 1-year postoperative and immediately postoperative CSA was significantly different between the 2 groups: -15.54 ± 94.34 mm² in the PRP group versus -85.62 ± 103.57 mm² in the conventional group (P = .047).

CONCLUSION

The application of PRP for large to massive rotator cuff repairs significantly improved structural outcomes, as evidenced by a decreased retear rate and increased CSA of the supraspinatus compared with repairs without PRP augmentation. While there was no significant difference in clinical outcomes except the overall shoulder function after 1-year follow-up, better structural outcomes in the PRP group might suggest improved clinical outcomes at longer term follow-up.

Description of a double centrifugation tube method for concentrating canine platelets

Background

To evaluate the efficiency of platelet-rich plasma preparations by means of a double centrifugation tube method to obtain platelet-rich canine plasma at a concentration at least 4 times higher than the baseline value and a concentration of white blood cells not exceeding twice the reference range. A complete blood count was carried out for each sample and each concentrate. Whole blood samples were collected from 12 clinically healthy dogs (consenting blood donors). Blood was processed by a double centrifugation tube method to obtain platelet concentrates, which were then analyzed by a flow cytometry haematology system for haemogram. Platelet concentration and white blood cell count were determined in all samples.

Results

Platelet concentration at least 4 times higher than the baseline value and a white blood cell count not exceeding twice the reference range were obtained respectively in 10 cases out of 12 (83.3%) and 11 cases out of 12 (91.6%).

Conclusions

This double centrifugation tube method is a relatively simple and inexpensive method for obtaining platelet-rich canine plasma, potentially available for therapeutic use to improve the healing process.

Growth factor release from platelet concentrates: analytic quantification and characterization for clinical applications

BACKGROUND AND OBJECTIVES

Clinical use of plasma rich in growth factors requires biochemical product control. We aimed to measure and modulate concentrations of growth factors in solutions deriving from platelet apheresis or whole blood.

MATERIALS AND METHODS

Growth factor concentrations were measured 5', 10', 20', 30', 60' after CaCl2 was added at 40°C to platelet-apheresis products (n = 39) or after 60' in platelet concentrates from whole blood (n = 13). Growth factor release was also obtained in platelet apheresis a) by incubation at 22°C or 40°C for 10' or 30' (n = 4); b) by repeated freeze-thaw (n = 9).

RESULTS

Fibroblast growth factor (FGF), platelet-derived growth factor (PDGF) isoforms AA and AB and transforming growth factor beta (TGF-β) concentrations (pg/10(9 ) plt) were 25-60% higher in growth factors solutions from whole blood compared to platelet apheresis. Vascular endothelial growth factor (VEGF), TGF-β and PDGF isoforms were released early (5-10') during incubation: TGF-β concentration increased also at 30'. FGF and epidermal growth factor (EGF) were released only after 30'. Incubation at 40°C/10' increased VEGF (+70%) and decreased EGF (-30%) and PDGF-BB (-50%) versus 22°C/30'. Shock significantly increased TGF-β (1.6-fold), EGF (1.5-fold), FGF (4.5-fold) and lowered PDGF isoforms (0.2- to 0.5-fold) versus prolonged incubation at 40°C.

CONCLUSION

Platelets from platelet apheresis and whole-blood release all investigated growth factors. The release can be regulated controlling incubation time and/or temperature and performing cell lysis.

Can platelet-rich plasma (PRP) improve bone healing? A comparison between the theory and experimental outcomes

The increased concentration of platelets within platelet-rich plasma (PRP) provides a vehicle to deliver supra-physiologic concentrations of growth factors to an injury site, possibly accelerating or otherwise improving connective tissue regeneration. This potential benefit has led to the application of PRP in several applications; however, inconsistent results have limited widespread adoption in bone healing. This review provides a core understanding of the bone healing mechanisms, and corresponds this to the factors present in PRP. In addition, the current state of the art of PRP preparation, the key aspects that may influence its effectiveness, and treatment outcomes as they relate specifically to bone defect healing are presented. Although PRP does have a sound scientific basis, its use for bone healing appears only beneficial when used in combination with osteoconductive scaffolds; however, neither allograft nor autograft appear to be appropriate carriers. Aggressive processing techniques and very high concentrations of PRP may not improve healing outcomes. Moreover, many other variables exist in PRP preparation and use that influence its efficacy; the effect of these variables should be understood when considering PRP use. This review includes the essentials of what has been established, what is currently missing in the literature, and recommendations for future directions.

The Augmentation of a Collagen/Glycosaminoglycan Biphasic Osteochondral Scaffold with Platelet-Rich Plasma and Concentrated Bone Marrow Aspirate for Osteochondral Defect Repair in Sheep: A Pilot Study

OBJECTIVE

This study investigates the combination of platelet-rich plasma (PRP) or concentrated bone marrow aspirate (CBMA) with a biphasic collagen/glycosaminoglycan (GAG) osteochondral scaffold for the treatment of osteochondral defects in sheep.

DESIGN

Acute osteochondral defects were created in the medial femoral condyle (MFC) and the lateral trochlea sulcus (LTS) of 24 sheep (n = 6). Defects were left empty or filled with a 6 × 6-mm scaffold, either on its own or in combination with PRP or CBMA. Outcome measures at 6 months included mechanical testing, International Cartilage Repair Society (ICRS) repair score, modified O'Driscoll histology score, qualitative histology, and immunohistochemistry for type I, II, and VI collagen.

RESULTS

No differences in mechanical properties, ICRS repair score, or modified O'Driscoll score were detected between the 4 groups. However, qualitative assessments of the histological architecture, Safranin O content, and collagen immunohistochemistry indicated that in the PRP/scaffold groups, there was a more hyaline cartilage-like tissue repair. In addition, the addition of CBMA and PRP to the scaffold reduced cyst formation in the subchondral bone of healed lesions.

CONCLUSION

There was more hyaline cartilage-like tissue formed in the PRP/scaffold group and less subchondral cystic lesion formation in the CBMA and PRP/scaffold groups, although there were no quantitative differences in the repair tissue formed.

Platelet-rich plasma stimulates cell proliferation and enhances matrix gene expression and synthesis in tenocytes from human rotator cuff tendons with degenerative tears

BACKGROUND

Platelet-rich plasma (PRP) contains various growth factors and appears to have a potential to promote tendon healing, but evidence is lacking regarding its effect on human tenocytes from rotator cuff tendons with degenerative tears.

HYPOTHESIS

Platelet-rich plasma stimulates cell proliferation and enhances matrix gene expression and synthesis in tenocytes isolated from human rotator cuff tendons with degenerative tears.

STUDY DESIGN

Controlled laboratory study.

METHODS

Tenocytes were enzymatically isolated and cultured. To evaluate cell proliferation, tenocytes were cultured with 10% (vol/vol) platelet-poor plasma (PPP), PRP activated with calcium, and PRP activated with calcium and thrombin at platelet concentrations of 100, 200, 400, 800, 1000, 2000, 4000, 8000, and 16,000 × 10(3)/µL for 14 days. Cell number was measured at days 7 and 14. To investigate matrix gene expression and synthesis, cells were cultured with a PPP or PRP gel (10% vol/vol) at a platelet concentration of 1000 × 10(3)/µL for 14 days. Quantitative real-time reverse transcriptase polymerase chain reaction was performed to determine the expressions of type I and III collagen, decorin, tenascin-C, and scleraxis, and measurements of total collagen and glycosaminoglycan (GAG) synthesis were conducted at days 7 and 14.

RESULTS

Platelet-rich plasma significantly increased cell proliferation at days 7 and 14 in a dose-dependent manner, and the addition of thrombin moved up the plateau of proliferation. Platelet-rich plasma significantly induced the gene expression of type I collagen at day 7 but not at day 14, while it significantly promoted that of type III both at days 7 and 14. The ratio of type III/I collagens did not change at days 7 and 14. The expressions of decorin and scleraxis significantly increased at day 14, whereas that of tenascin-C significantly increased at days 7 and 14. Platelet-rich plasma significantly increased total collagen synthesis at days 7 and 14 and GAG synthesis at day 14.

CONCLUSION

Platelet-rich plasma promoted cell proliferation and enhanced gene expression and the synthesis of tendon matrix in tenocytes from human rotator cuff tendons with degenerative tears.

CLINICAL RELEVANCE

These findings suggest that PRP might be used as a useful biological tool for regenerative healing of rotator cuff tears by enhancing the proliferation and matrix synthesis of tenocytes from tendons with degenerative tears.

A cell-free scaffold-based cartilage repair provides improved function hyaline-like repair at one year

BACKGROUND

Bone marrow stimulation techniques in cartilage repair such as drilling are limited by the formation of fibrous to hyaline-like repair tissue. It has been suggested such techniques can be enhanced by covering the defect with scaffolds. We present an innovative approach using a polyglycolic acid (PGA)-hyaluronan scaffold with platelet-rich-plasma (PRP) in drilling.

QUESTIONS/PURPOSES

We asked whether (1) PRP immersed in a cell-free PGA-hyaluronan scaffold improves patient-reported 1-year outcomes for the Knee injury and Osteoarthritis Score (KOOS), and (2) implantation of the scaffold in combination with bone marrow stimulation leads to the formation of hyaline-like cartilage repair tissue.

PATIENTS AND METHODS

We reviewed 52 patients who had arthroscopic implantation of the PGA-hyaluronan scaffold immersed with PRP in articular cartilage defects of the knee pretreated with Pridie drilling. Patients were assessed by KOOS. At 9 months followup, histologic staining was performed in specimens obtained from five patients to assess the repair tissue quality.

RESULTS

The KOOS subscores improved for pain (55 to 91), symptoms (57 to 88), activities of daily living (69 to 86), sports and recreation (36 to 70), and quality of life (38 to 73). The histologic evaluation showed a homogeneous hyaline-like cartilage repair tissue.

CONCLUSIONS

The cell-free PGA-hyaluronan scaffold combined with PRP leads to cartilage repair and improved patient-reported outcomes (KOOS) during 12 months of followup. Histologic sections showed morphologic features of hyaline-like repair tissue. Long-term followup is needed to determine if the cartilage repair tissue is durable.

LEVEL OF EVIDENCE

Level IV, therapeutic study. See the Guidelines for Authors for a complete description of levels of evidence.

Platelet-rich plasma differs according to preparation method and human variability

BACKGROUND

Varying concentrations of blood components in platelet-rich plasma preparations may contribute to the variable results seen in recently published clinical studies. The purposes of this investigation were (1) to quantify the level of platelets, growth factors, red blood cells, and white blood cells in so-called one-step (clinically used commercial devices) and two-step separation systems and (2) to determine the influence of three separate blood draws on the resulting components of platelet-rich plasma.

METHODS

Three different platelet-rich plasma (PRP) separation methods (on blood samples from eight subjects with a mean age [and standard deviation] of 31.6 ± 10.9 years) were used: two single-spin processes (PRPLP and PRPHP) and a double-spin process (PRPDS) were evaluated for concentrations of platelets, red and white blood cells, and growth factors. Additionally, the effect of three repetitive blood draws on platelet-rich plasma components was evaluated.

RESULTS

The content and concentrations of platelets, white blood cells, and growth factors for each method of separation differed significantly. All separation techniques resulted in a significant increase in platelet concentration compared with native blood. Platelet and white blood-cell concentrations of the PRPHP procedure were significantly higher than platelet and white blood-cell concentrations produced by the so-called single-step PRPLP and the so-called two-step PRPDS procedures, although significant differences between PRPLP and PRPDS were not observed. Comparing the results of the three blood draws with regard to the reliability of platelet number and cell counts, wide variations of intra-individual numbers were observed.

CONCLUSIONS

Single-step procedures are capable of producing sufficient amounts of platelets for clinical usage. Within the evaluated procedures, platelet numbers and numbers of white blood cells differ significantly. The intra-individual results of platelet-rich plasma separations showed wide variations in platelet and cell numbers as well as levels of growth factors regardless of separation method.

Optimized preparation method of platelet-concentrated plasma and noncoagulating platelet-derived factor concentrates: maximization of platelet concentration and removal of fibrinogen

Platelet-rich plasma (PRP) has been clinically used as an easily prepared growth factor cocktail that can promote wound healing, angiogenesis, and tissue remodeling. However, the therapeutic effects of PRP are still controversial, due partly to the lack of optimized and standardized preparation protocols. We used whole blood (WB) samples to optimize the preparation protocols for PRP, white blood cell-containing (W-PRP), platelet-concentrated plasma (PCP), and noncoagulating platelet-derived factor concentrate (PFC). PRP and W-PRP were most efficiently collected by 10 min centrifugation in a 15-mL conical tube at 230-270 g and 70 g, respectively. To prepare PCP, platelets were precipitated by centrifugation of PRP at >2300 g, 90% of supernatant plasma was removed, and the platelets were resuspended. For preparation of noncoagulating PFC, the supernatant was replaced with one-tenth volume of saline, followed by platelet activation with thrombin. Platelet (before activation) and platelet-derived growth factor (PDGF)-BB (after activation) concentrations in PCP were approximately 20 times greater than those in WB, whereas PFC contained a 20-times greater concentration of platelets before platelet activation and a 50-times greater concentration of PDGF-BB without formation of a fibrin gel after platelet activation than WB. Surprisingly, total PDGF-BB content in the PFC was twice that of activated WB, which suggested that a substantial portion of the PDGF-BB became trapped in the fibrin glue, and replacement of plasma with saline is crucial for maximization of platelet-derived factors. As an anticoagulant, ethylene di-amine tetra-acetic acid disodium inhibited platelet aggregation more efficiently than acid citrate dextrose solution, resulting in higher nonaggregated platelet yield and final PDGF-BB content. These results increase our understanding of how to optimize and standardize preparation of platelet-derived factors at maximum concentrations.

Does platelet-rich plasma accelerate recovery after rotator cuff repair? A prospective cohort study

BACKGROUND

Platelet-rich plasma (PRP) has been recently used to enhance and accelerate the healing of musculoskeletal injuries and diseases, but evidence is still lacking, especially on its effects after rotator cuff repair.

HYPOTHESIS

Platelet-rich plasma accelerates recovery after arthroscopic rotator cuff repair in pain relief, functional outcome, overall satisfaction, and enhanced structural integrity of repaired tendon.

STUDY DESIGN

Cohort study; Level of evidence, 2.

METHODS

Forty-two patients with full-thickness rotator cuff tears were included. Patients were informed about the use of PRP before surgery and decided themselves whether to have PRP placed at the time of surgery. Nineteen patients underwent arthroscopic rotator cuff repair with PRP and 23 without. Platelet-rich plasma was prepared via plateletpheresis and applied in the form of a gel threaded to a suture and placed at the interface between tendon and bone. Outcomes were assessed preoperatively and at 3, 6, 12, and finally at a minimum of 16 months after surgery (at an average of 19.7 ± 1.9 months) with respect to pain, range of motion, strength, and overall satisfaction, and with respect to functional scores as determined using the following scoring systems: the American Shoulder and Elbow Surgeon (ASES) system, the Constant system, the University of California at Los Angeles (UCLA) system, the Disabilities of the Arm, Shoulder and Hand (DASH) system, the Simple Shoulder Test (SST) system, and the Shoulder Pain and Disability Index (SPADI) system. At a minimum of 9 months after surgery, repaired tendon structural integrities were assessed by magnetic resonance imaging.

RESULTS

Platelet-rich plasma gel application to arthroscopic rotator cuff repairs did not accelerate recovery with respect to pain, range of motion, strength, functional scores, or overall satisfaction as compared with conventional repair at any time point. Whereas magnetic resonance imaging demonstrated a retear rate of 26.7% in the PRP group and 41.2% in the conventional group, there was no statistical significance between the groups (P = .388).

CONCLUSION

The results suggest that PRP application during arthroscopic rotator cuff repair did not clearly demonstrate accelerated recovery clinically or anatomically except for an improvement in internal rotation. Nevertheless, as the study may have been underpowered to detect clinically important differences in the structural integrity, additional investigations, including the optimization of PRP preparation and a larger randomized study powered for healing rate, are necessary to further determine the effect of PRP.

Elastic Stable Intramedullary Nailing (ESIN), Orthoss® and Gravitational Platelet Separation--System (GPS®): an effective method of treatment for pathologic fractures of bone cysts in children

Background

The different treatment strategies for bone cysts in children are often associated with persistence and high recurrence rates of the lesions. The safety and clinical outcomes of a combined mechanical and biological treatment with elastic intramedullary nailing, artificial bone substitute and autologous platelet rich plasma are evaluated.

Methods

From 02/07 to 01/09 we offered all children with bone cysts the treatment combination of elastic intramedullary nailing (ESIN), artificial bone substitute (Orthoss^®) and autologous platelet rich plasma, concentrated by the Gravitational Platelet Separation (GPS^®) - System. All patients were reviewed radiologically for one year following the removal of the intramedullary nailing, which was possible because of cyst obliteration.

Results

A cohort of 12 children (4 girls, 8 boys) was recruited. The mean patient age was 11.4 years (range 7-15 years). The bone defects (ten humeral, two femoral) included eight juvenile and four aneurysmal bone cysts. Five patients suffered from persistent cysts following earlier unsuccessful treatment of humeral bone cyst after pathologic fracture; the other seven presented with acute pathologic fractures. No peri- or postoperative complications occurred. The radiographic findings showed a total resolution of the cysts in ten cases (Capanna Grade 1); in two cases a small residual cyst remained (Capanna Grade 2). The intramedullary nails were removed six to twelve months (mean 7.7) after the operation; in one case, a fourteen year old boy (Capanna Grade 2), required a further application of GPS^® and Orthoss^® to reach a total resolution of the cyst. At follow-up (20-41 months, mean 31.8 months) all patients showed very good functional results and had returned to sporting activity. No refracture occurred, no further procedure was necessary.

Conclusions

The combination of elastic intramedullary nailing, artificial bone substitute and autologous platelet rich plasma (GPS^®) enhances the treatment of bone cysts in children, with no resulting complications.