In VitroMechanical Testing of Braided Polyurethane Elastic Fiber and Braided Polyester for Equine Laryngoplasty

Ex vivo biomechanical evaluation of polyester and polyblend suture techniques to perform equine laryngoplasty

OBJECTIVE

To validate the use of a polyblend tape suture in equine laryngoplasty (PL).

STUDY DESIGN

Experimental study.

ANIMALS

Thirty-two cadaveric larynges.

METHODS

Each larynx was randomly assigned to 1 of 4 groups: PL with polyblend tape suture (TigerTape), without (TT) or with a cannula (TTC) in the muscular process of the arytenoid cartilage, and PL with polyester suture (Ethibond), without (EB) or with a cannula (EBC). Construct stiffness, total migration, creep, and drift values were measured after 3000 cycles. The specimens were then loaded to failure to assess their residual properties: load at failure, total energy, displacement, and 2 stiffness coefficients.

RESULTS

After cyclic testing, the total migration and creep were lower in TTC (6.36 ± 1.20 mm; 1.35 ± 0.38 mm/s) than in EB (11.12 ± 4.20 mm; 3.39 ± 2.68 mm/s) and in the TT constructs (11.26 ± 1.49 mm; 3.20 ± 0.54 mm/s); however, no difference was found with EBC (9.19 ± 3.18 mm; 2.14 ± 0.99). A correlation was found between total migration and creep (R = .85). The TTC constructs failed at higher loads (129.51 ± 33.84 N) than EB (93.16 ± 18.21 N) and EBC (81.72 ± 13.26 N) whereas the EB and EBC constructs were less stiff than TT and TTC (P < .001).

CONCLUSION

Biomechanical properties were generally superior for the TTC constructs tested under cyclical loading. The TT and TTC constructs failed at a higher load than EB and EBC constructs. The cannula in TTC and EBC reduced the failure at the muscular process.

CLINICAL SIGNIFICANCE

These results provide evidence to support the in vivo evaluation of the polyblend tape suture with or without a cannula in the muscular process for laryngoplasty in horses.

Ex vivo evaluation of arytenoid corniculectomy, compared with three other airway interventions, performed on cadaveric equine larynges with simulated recurrent laryngeal neuropathy

OBJECTIVE

To compare laryngeal impedance, in terms of air flow and pressure, following arytenoid corniculectomy (COR) versus 3 other airway interventions (left-sided laryngoplasty with ipsilateral ventriculocordectomy [LLP], LLP combined with COR [LLPCOR], and partial arytenoidectomy [PA]) performed on cadaveric equine larynges with simulated left recurrent laryngeal neuropathy (RLN) and to determine whether relative laryngeal collapse correlated with the interventions performed.

SAMPLE

28 cadaveric equine larynges.

PROCEDURES

Each larynx in states of simulated left RLN alone and with airway interventions in the order LLP, LLPCOR, COR, and PA was evaluated in a box model construct that replicated upper airway flow mechanics consistent with peak exercise in horses. Results for impedance, calculated from airflow and pressure changes, were compared between states for each larynx. Multivariable mixed-effects analysis controlling for repeated measures within larynx was performed to calculate the predicted mean impedance for each state.

RESULTS

Results indicated that tracheal adapter diameter, individual larynx properties, airway intervention, and relative laryngeal collapse affected laryngeal impedance. The LLP and LLPCOR interventions had the lowest impedance, whereas the COR and PA interventions did not differ substantially from the simulated left RLN state. Residual intraclass correlation of the model was 27.6 %.

CONCLUSIONS AND CLINICAL RELEVANCE

Although impedance was higher for the simulated left RLN with the COR intervention state than with the LLP intervention state, given the clinical success of PA for treating RLN in horses and the similar results for the COR and PA intervention states in the present study, the use of COR warrants further investigation. The residual interclass correlation suggested that individual laryngeal variation affected impedance and may have a clinical effect.

In vitro comparison of 3 techniques of prosthesis attachment to the muscular process of the equine arytenoid cartilage

OBJECTIVE

To determine the degree and ease of arytenoid abduction achieved with abaxial placement of a FASTak II suture anchor compared to 2 suture patterns with different directions of insertion-caudomedial to craniolateral and medial to lateral.

STUDY DESIGN

Ex vivo experimental.

STUDY POPULATION

Cadaveric larynges from 10 Standardbred racehorses.

METHODS

Each larynx was sequentially instrumented with all 3 arytenoid suture attachment in random order: (1) abaxial placement of a FASTak II suture, (2) caudomedial to craniolateral suture, and (3) medial to lateral suture placement. Each construct was abducted at 5N increments from 0 to 25N and the left to right quotient angle ratio (LRQ) measured from digital pictures acquired at each sequential increment.

RESULTS

Arytenoid abduction (higher LRQ) was greater with FASTak II construct than either of the suture patterns. The largest difference occurred at 5N. Approximately 50% less force was required to achieve an LRQ of 1.0 with the FASTak II anchor compared to the suture patterns. No difference was detected between the 2 suture constructs throughout the study.

CONCLUSION

Use of the FASTak II suture anchor improved arytenoid abduction compared to 2 suture patterns and minimized the suture loads required to achieve maximum arytenoid abduction.

CLINICAL RELEVANCE

Use of the FASTak II anchor may decrease the suture load required to achieve arytenoid abduction in clinical cases. This may reduce the load placed on the laryngoplasty, thereby, minimizing postoperative loss of abduction.

Ex Vivo Mechanical Evaluation of a Sternal ZipFix(®) Implant for Prosthetic Laryngoplasty in Horses

OBJECTIVE

To evaluate the properties of a ZipFix(®) (ZipFix) implant in equine laryngeal cartilages.

STUDY DESIGN

Ex vivo biomechanical study.

SAMPLE POPULATION

Equine arytenoid (n=36) and cricoid cartilages (n=18).

METHODS

Suture bites were placed in arytenoid or cricoid cartilages using a ZipFix(®) implant or a single strand of USP 5 braided polyester (TiCron™), and arytenoid and cricoid cartilages were separately subjected to single load to failure (25 N preload) or cyclic loading for 1,000 cycles, followed by single load to failure. Load, distraction, and stiffness were recorded.

RESULTS

Four arytenoid-ZipFix cartilages fractured on implant placement. Under single load, arytenoid-ZipFix (n=9) failed at a greater mean load (359.01 ± 57.98 N) than arytenoid-Ticron (159.11 ± 22.98 N; n=12; P<.001). Arytenoid-ZipFix stiffness (31.32 ± 4.26 N/mm) was significantly greater than arytenoid-Ticron (13.18 ± 2.60 N/mm; P<.001). Cricoid-ZipFix stiffness (20.83 ± 3.37 N/mm) was significantly greater than cricoid-Ticron (13.6 ± 3.82 N/mm; n=6; P=.006). Under cyclic load, arytenoid-ZipFix distraction (2.53 ± 0.63 mm; n=5) was significantly less than arytenoid-Ticron (5.06 ± 1.37 mm; n=6, P=.006). After cyclic load, arytenoid-ZipFix failure load (295.16 ± 54.95 N) was significantly greater than arytenoid-Ticron (127.69 ± 32.67 N; P=.002). Arytenoid-ZipFix stiffness (35.59 ± 1.58 N/mm) was significantly greater than arytenoid-Ticron (24.10 ± 6.85 N/mm; P=.019).

CONCLUSION

In arytenoid cartilages, the sternal ZipFix(®) implant was significantly stronger and stiffer compared to a single strand of Ticron. During placement of the ZipFix(®) implant, frequent arytenoid cartilage failure occurred before testing, suggesting the implant is not suitable for clinical application.