Assessment of microwave drying for rapid and convenient analysis of medicinal plants for quality assurance

INTRODUCTION

The safety and quality of many medicinally important herbs are compromised since farmers and small organizations are involved in the cultivation, aggregation, and primary processing of these herbs. Such organizations often lack adequate quality control facilities. To improve the safety and quality of herbal products, simple, rapid, and affordable quality control systems are required.

OBJECTIVES

The aim of this study was to assess the suitability of microwave oven-drying for moisture content (MC) determination and sample preparation of herbs in small organizations.

METHODS

Microwave oven-drying (720 W) and convective oven-drying at 105°C for MC determination were compared. The effects of three different drying methods (microwave oven-drying, low-temperature convective drying, and freeze-drying) on in vitro antioxidant and polyphenol oxidase (PPO) activity were determined, similarity analysis was conducted using HPLC signature spectra, and validation was performed with LC-MS focusing on one herb.

RESULTS

Microwave oven-drying at 720 W significantly reduced the drying time (from hours to minutes), whereas the spatial variation of temperature in convective ovens set at 105°C can cause about 10% underestimation of MC. Microwave oven-drying showed similar macro-properties like freeze-drying and higher extractability (10%-20%) and in vitro antioxidant capacity (33%-66%) and lower PPO activity compared to low-temperature convective drying. HPLC signature spectra revealed strong similarity of soluble components between freeze-dried and microwave oven-dried herbs. LC-MS analysis demonstrated more common compounds between freeze-dried and microwave oven-dried Centella asiatica extracts, whereas convective tray-dried samples had fewer compounds common with samples obtained by freeze-drying or microwave oven-drying.

CONCLUSIONS

Microwave oven-drying is rapid (tens of min) and shows small batch-to-batch variation compared to oven-drying at 105°C. The in vitro antioxidant assays and signature spectra can be used for assessing the source and purity or quality of a specific herb variety.

Determination of Bioactive Components in Mandarin Fruits: A Review

During the last decade, there has been a continuous rise in the consumption of fresh easy-to-peel mandarins. However, the majority of the knowledge comes from other citrus fruit, like orange, while there are relatively few studies about mandarins and no comprehensive research on literature data about them. One of the most important steps in the analytical process is sample preparation. Its value is evident in analyzing the samples with complex matrices, such as in mandarin fruit. In addition, mandarin contains hundreds to thousands of various compounds and metabolites, some of them present in extremely low concentrations, that interfere with the detection of one another. Hence, mandarin samples are commonly pretreated by extraction to facilitate analysis of bioactive compounds, improve accuracy and quantification levels. There is an abundance of extraction techniques available, depending on the group of compounds of interest. Finally, modern analytical techniques, have been applied to cope with numerous bioactive compounds in mandarins. Considering all the above, this review aims to (i) list the most valuable procedures of sample preparation, (ii) highlight the most important techniques for extraction of bioactive compounds from mandarin fruit, and (iii) summarize current trends in the identification and determination of bioactive compounds in mandarin.