Inactivation of Mycobacterium avium subsp. paratuberculosis in cow's milk by means of high hydrostatic pressure at mild temperatures

The efficacy and safety of high-pressure processing of food

High-pressure processing (HPP) is a non-thermal treatment in which, for microbial inactivation, foods are subjected to isostatic pressures (P) of 400-600 MPa with common holding times (t) from 1.5 to 6 min. The main factors that influence the efficacy (log10 reduction of vegetative microorganisms) of HPP when applied to foodstuffs are intrinsic (e.g. water activity and pH), extrinsic (P and t) and microorganism-related (type, taxonomic unit, strain and physiological state). It was concluded that HPP of food will not present any additional microbial or chemical food safety concerns when compared to other routinely applied treatments (e.g. pasteurisation). Pathogen reductions in milk/colostrum caused by the current HPP conditions applied by the industry are lower than those achieved by the legal requirements for thermal pasteurisation. However, HPP minimum requirements (P/t combinations) could be identified to achieve specific log10 reductions of relevant hazards based on performance criteria (PC) proposed by international standard agencies (5-8 log10 reductions). The most stringent HPP conditions used industrially (600 MPa, 6 min) would achieve the above-mentioned PC, except for Staphylococcus aureus. Alkaline phosphatase (ALP), the endogenous milk enzyme that is widely used to verify adequate thermal pasteurisation of cows' milk, is relatively pressure resistant and its use would be limited to that of an overprocessing indicator. Current data are not robust enough to support the proposal of an appropriate indicator to verify the efficacy of HPP under the current HPP conditions applied by the industry. Minimum HPP requirements to reduce Listeria monocytogenes levels by specific log10 reductions could be identified when HPP is applied to ready-to-eat (RTE) cooked meat products, but not for other types of RTE foods. These identified minimum requirements would result in the inactivation of other relevant pathogens (Salmonella and Escherichia coli) in these RTE foods to a similar or higher extent.

Evaluation of Mycobacterium smegmatis as indicator of the efficacy of high hydrostatic pressure and ultra-high pressure homogenization treatments for pasteurization-like purposes in milk

The objectives of this study were: to assess the efficiency of high hydrostatic pressure or ultra-high pressure homogenization against Mycobacterium smegmatis in milk and to discuss whether M. smegmatis can be considered a suitable surrogate for other Mycobacterium spp. in high pressure inactivation trials using milk. Three strains of this specie (CECT 3017, 3020 and 3032) were independently inoculated into both skimmed (0.2% fat) and whole milk (3.4% fat) at an approximate load of 6.5 Log CFU/ml and submitted to HHP treatments at 300, 400 or 500 MPa for 10 m at 6°C and 20°C. Evolution of the surviving cells of the inoculated strains was evaluated analysing milk immediately after the treatments and after 5 and 8 d of storage at 6°C. HHP treatments at 300 MPa were seldom efficient at inactivating M. smegmatis strains, but lethality increased with pressure applied in all cases. Generation of sub-lethal injured cells was observed only after 400 MPa treatments since inactivation at 500 MPa was shown to be complete. Significant differences were not observed due to either temperature of treatment or fat content of milk, except for strain CECT3032, which was shown to be the most sensitive to HHP treatments. Milk inoculated with strain CECT3017 was submitted to ultra-high pressure homogenization (UHPH) treatments at 200, 300 and 400 MPa. Maximum reductions were obtained after 300 and 400 MPa treatments, although less than 3.50 Log CFU/ml were inactivated. UHPH did not cause significant number of injured cells. The usefulness of this species as a marker for pressure-based processing seems limited since it showed greater sensitivity than some pathogenic species including other Mycobacteria reported in previous studies.

The inhibitory effect of nisin on Mycobacterium avium ssp. paratuberculosis and its effect on mycobacterial cell wall

Infection with Mycobacterium avium ssp. paratuberculosis (M. paratuberculosis) is a widespread problem in the United States and worldwide, and it constitutes a significant health problem for dairy animals with a potential effect on human health. Mycobacterium paratuberculosis is easily transmitted through consumption of contaminated milk; therefore, finding safe methods to reduce the mycobacterial load in milk and other dairy products is important to the dairy industry. The main objective of the current study was to investigate the effect of natural products, such as bacteriocins designated as "generally regarded as safe" (GRAS), on the survival of M. paratuberculosis in milk. Commercially synthesized bacteriocin (nisin) was used to examine its effect on the survival of laboratory and field isolates of M. paratuberculosis and in contaminated milk. Surprisingly, nisin had a higher minimum inhibitory concentration (MIC) against the laboratory strain (M. paratuberculosis K10), at 500 U/mL, than against field isolates (e.g., M. paratuberculosis 4B and JTC 1281), at 15 U/mL. In milk, growth of M. paratuberculosis was inhibited after treatment with levels of nisin that are permissible in human food at 4°C and 37°C. Using both fluorescent and scanning electron microscopy, we were able to identify defects in the bacterial cell walls of treated cultures. Our analysis indicated that nisin reduced membrane integrity by forming pores in the mycobacterial cell wall, thereby decreasing survival of M. paratuberculosis. Thus, nisin treatment of milk could be implemented as a control measure to reduce M. paratuberculosis secreted in milk from infected herds. Nisin could also be used to reduce M. paratuberculosis in colostrum given to calves from infected animals, improving biosecurity control in dairy herds affected by Johne's disease.

Assessment of food as a source of exposure to Mycobacterium avium subspecies paratuberculosis (MAP)

The National Advisory Committee on Microbiological Criteria for Foods assessed the importance of food as a source of exposure to Mycobacterium avium subspecies paratuberculosis (MAP). MAP is the causative agent of Johne's disease, which affects primarily the small intestine of all ruminants. The significance of MAP as a human pathogen is unknown and is being investigated by several research groups. This document also reviews the efficacy of current detection methods, processing interventions, and MAP inactivation. Research needs related to MAP are provided. The Committee reached the following conclusions: current methods for detection of MAP have significant limitations, and a standard method for the detection of viable MAP cells is needed. Aside from MAP-infected domestic ruminant animals, the organism is found infrequently. If MAP in cattle is controlled, the source of MAP in other animals, food, and water may largely be eliminated. Milk, particularly raw milk, may be a likely food source for human exposure to MAP. Given the prevalence of MAP in U.S. cattle herds, ground beef may be a potential source of MAP. Although humans may be exposed to MAP through a variety of routes, including food and the environment, the frequency and amount of exposure will require additional research.

Antibacterial activities of naturally occurring compounds against Mycobacterium avium subsp. paratuberculosis

The antibacterial activities of 18 naturally occurring compounds (including essential oils and some of their isolated constituents, apple and green tea polyphenols, and other plant extracts) against three strains of Mycobacterium avium subsp. paratuberculosis (a bovine isolate [NCTC 8578], a raw-milk isolate [806R], and a human isolate [ATCC 43015]) were evaluated using a macrobroth susceptibility testing method. M. avium subsp. paratuberculosis was grown in 4 ml Middlebrook 7H9 broth containing 10% oleic acid-albumin-dextrose-catalase, 0.05% Tween 80 (or 0.2% glycerol), and 2 microg/ml mycobactin J supplemented with five concentrations of each test compound. The changes in the optical densities of the cultures at 600 nm as a measure of CFU were recorded at intervals over an incubation period of 42 days at 37 degrees C. Six of the compounds were found to inhibit the growth of M. avium subsp. paratuberculosis. The most effective compound was trans-cinnamaldehyde, with a MIC of 25.9 microg/ml, followed by cinnamon oil (26.2 microg/ml), oregano oil (68.2 microg/ml), carvacrol (72.2 microg/ml), 2,5-dihydroxybenzaldehyde (74 microg/ml), and 2-hydroxy-5-methoxybenzaldehyde (90.4 microg/ml). With the exception of carvacrol, a phenolic compound, three of the four most active compounds are aldehydes, suggesting that the structure of the phenolic group or the aldehyde group may be important to the antibacterial activity. No difference in compound activity was observed between the three M. avium subsp. paratuberculosis strains studied. Possible mechanisms of the antimicrobial effects are discussed.

Effect of high pressure and pasteurization on Mycobacterium avium ssp. paratuberculosis in milk

AIMS

To determine the effect of high pressures alone and in conjunction with pasteurization on the viability of two strains of Mycobacterium avium ssp. paratuberculosis (Map).

METHODS AND RESULTS

Map in a milk matrix was subjected to 400, 500 and 600 MPa with and without pasteurization (72 degrees C for 15 s) and plated onto Herrold's egg yolk medium (HEYM) and Middlebrook 7H10 (7H10) agar, both containing antibiotic supplements. Medium 7H10 was found to give a significantly (P < 0.001) better recovery than HEYM. A significantly greater (P < 0.001) reduction in viable numbers was observed using 500 MPa (mean log reduction of 6.52) compared with 400 MPa (mean log reduction of 2.56) and between 400 MPa and control (no applied pressure) for 10 min treatments. A treatment time of 10 min resulted in significantly (P < 0.001) fewer survivors than 5 min. Low numbers of survivors were still detected when pressure treatment at 400 and 600 MPa was combined with subsequent pasteurization.

CONCLUSIONS

The use of high-pressure was effective in reducing viable numbers of Map but even when combined with pasteurization there were still survivors, albeit when high inoculum levels of Map were used.

SIGNIFICANCE AND IMPACT OF THE STUDY

To the authors' knowledge the work reported here represents the first study of the efficacy of high-pressure treatments alone and in combination with pasteurization to kill Map. The results indicate that further research is warranted before more commercial-scale studies are commissioned.