The effect of donor age and low-dose gamma irradiation on the initial biomechanical properties of human tibialis tendon allografts

Donor age has no relevant role in biomechanical properties of allografts used in anterior cruciate ligament (ACL) reconstruction: A systematic review

PURPOSE

Surgeons generally consider the donor age as a factor that negatively influences the quality of allograft used in anterior cruciate ligament (ACL) reconstruction, however, the available evidence does not clearly support this statement. The purpose of the study was to investigate if donor age influences the biomechanical properties of allografts used in ACL reconstruction.

METHODS

A comprehensive literature search was conducted for all relevant articles using MEDLINE (PubMed), Scopus, and Cochrane Collaboration Library, according to the Preferred Reporting Items for Systematic Reviews and Meta-Analysis. Studies including the analysis of the correlation between biomechanical properties of the allografts and donor age were selected. The role of donor age was labelled as 'none' if absent, 'higher' or 'lower' if the properties were higher or lower in older specimens with respect to younger. The correlation was defined as 'weak' or 'strong' according to each study definition.

RESULTS

No conflicting role of donor age was reported for modulus of elasticity, load to failure, strain, stiffness and displacement. The only parameters where the significant results were consistent were the tensile strength and the stress (low or moderate correlations). When considering the tested samples with a donor's age <65 years, a significant role of age was reported in only four out of 13 groups of graft tested (patellar tendon, fascia lata, anterior tibialis tendon and posterior tibialis tendon).

CONCLUSION

The current literature did not allow to state that the donor age negatively influences the biomechanical properties of allografts, making it impossible to identify a clear age cut-off value to exclude them from ACL reconstruction procedures.

LEVEL OF EVIDENCE

Level IV, systematic review.

Tape-Reinforced Graft Suturing and Retensioning of Adjustable-Loop Cortical Buttons Improve Quadriceps Tendon Autograft Biomechanics in Anterior Cruciate Ligament Reconstruction: A Cadaveric Study

PURPOSE

To investigate the biomechanical effects of tape-reinforced graft suturing and graft retensioning for all-soft tissue quadriceps tendon (ASTQT) anterior cruciate ligament reconstruction (ACLR) in a full-construct human cadaveric model.

METHODS

Harvested cadaveric ASTQT grafts were assigned to either (1) double-suspensory adjustable-loop cortical button device (ALD) fixation in which both graft ends were fixed with a suspensory fixation device with (n = 5) or without (n = 5) tape-reinforced suturing or (2) single-suspensory distal tendon fixation in which only the patellar end was fixed with an ALD (n = 5) or fixed-loop cortical button device (FLD) (n = 5). All specimens were prepared using a No. 2 whipstitch technique, and tape-reinforced specimens had an integrated braided tape implant. Graft preparation time was recorded for double-suspensory constructs. Samples were tested on an electromechanical testing machine using a previously published protocol simulating rehabilitative kinematics and loading.

RESULTS

Tape-reinforced graft suturing resulted in greater graft load retention after cycling (11.9% difference, P = .021), less total elongation (mean [95% confidence interval (CI)], 5.57 mm [3.50-7.65 mm] vs 32.14 mm [25.38-38.90 mm]; P < .001), greater ultimate failure stiffness (mean [95% CI], 171.9 N/mm [158.8-185.0 N/mm] vs 119.4 N/mm [108.7-130.0 N/mm]; P < .001), and less graft preparation time (36.4% difference, P < .001) when compared with unreinforced specimens. Retensioned ALD constructs had less cyclic elongation compared with FLD constructs (mean total elongation [95% CI], 7.04 mm [5.47-8.61 mm] vs 12.96 mm [8.67-17.26 mm]; P = .004).

CONCLUSIONS

Tape-reinforced graft suturing improves time-zero ASTQT ACLR construct biomechanics in a cadaveric model with 83% less total elongation, 44% greater stiffness, and reduced preparation time compared with a whipstitched graft without tape reinforcement. ALD fixation improves construct mechanics when compared with FLD fixation as evidenced by 46% less total elongation.

CLINICAL RELEVANCE

Tape-reinforced implants and graft retensioning using ALDs improve time-zero ACLR graft construct biomechanics in a time-zero biomechanical model. Clinical studies will be necessary to determine whether these implants improve clinical outcomes including knee laxity and the incidence of graft rupture.

The effect of sterilization and storage on the viscoelastic properties of human tendon allografts - Continued: Storage for 0 to 4 months

The role of donor-derived tendons, also known as allografts, in anterior cruciate ligament replacement surgeries is steadily increasing. Before surgery, temporary storage and, in most cases, sterilization are essential. It is, thus, crucial to determine how these procedures alter the grafts' biomechanical properties. The purpose of this research was to analyze the effect of different sterilization methods (native, frozen, frozen + 21 kGy gamma irradiation, frozen + 21 kGy electron beam irradiation) and storage durations (0 to 4 months) on the deformation and creep of two tendon types (tibialis anterior, peroneus longus). 80 tibialis anterior and 83 peroneus longus tendons from 51 human cadavers were included. The samples were removed, placed in a radio-cryoprotectant solution, then slowly cooled, sterilized and stored at -80 °C. All groups were subject to 60 s static creep test with 250 N load. Deformation during the loading phase, creep during static loading, and the ratio of these two were evaluated. Deformation at the end of the loading phase and creep consistently exhibited significantly smaller values in the tibialis anterior compared to the peroneus longus type, as well as in electron beam-sterilized grafts as opposed to gamma beam-sterilized ones. Prolonged storage periods (within 0 to 4 months) resulted in a notable increase in these values, particularly in deformation. Based on the experimental data, the tibialis anterior tendon type and sterilization by gamma beam irradiation are better choices for anterior cruciate ligament reconstruction than the peroneus longus and sterilization by electron beam. Increased storage time affects negatively the evaluated mechanical properties.

Impact of irradiation on load-to-failure in bone-patellar tendon-bone allografts: A systematic review and meta-analysis

Introduction

To evaluate the impact various levels of irradiation have on bone-patellar tendon-bone (BTB) allograft load-to-failure.

Materials and methods

Pubmed, Google Scholar and Embase were searched for studies reporting load-to-failure measurements of BTB allografts following gamma or eBeam irradiation. All systematic reviews, editorials, as well as studies that utilized animal models and/or other graft sources (achilles, hamstring, quadriceps) were excluded. Meta-analysis was performed to compare the impact of low dose (19 ≤ kGy), intermediate (20-49 kGy) and high dose (>50 kGy) gamma and eBeam radiation on load-to-failure.

Results

Twelve studies, containing a total of 429 BTB allografts (159 controls, 270 irradiated), were identified. Load-to-failure of BTB allograft was significantly decreased at intermediate (20-49 kGy) doses of radiation, while low (≤19 kGy) and high (>50 kGy) doses did not significantly change load-to-failure.

Conclusions

Intermediate doses of radiation may negatively impact the biomechanical integrity of BTB allograft in vitro. Future studies are required to examine clinical outcomes at varying irradiation levels.

Current trends in graft choice for anterior cruciate ligament reconstruction - part I: anatomy, biomechanics, graft incorporation and fixation

Graft selection in anterior cruciate ligament (ACL) reconstruction is critical, as it remains one of the most easily adjustable factors affecting graft rupture and reoperation rates. Commonly used autografts, including hamstring tendon, quadriceps tendon and bone-patellar-tendon-bone, are reported to be biomechanically equivalent or superior compared to the native ACL. Despite this, such grafts are unable to perfectly replicate the complex anatomical and histological characteristics of the native ACL. While there remains inconclusive evidence as to the superiority of one autograft in terms of graft incorporation and maturity, allografts appear to demonstrate slower incorporation and maturity compared to autografts. Graft fixation also affects graft properties and subsequent outcomes, with each technique having unique advantages and disadvantages that should be carefully considered during graft selection.

Challenging the Perceptions of Human Tendon Allografts: Influence of Donor Age, Sex, Height, and Tendon on Biomechanical Properties

BACKGROUND

The use of allograft tendons has increased for primary and revision anterior cruciate ligament reconstruction, but allograft supply is currently limited to a narrow range of tendons and donors up to the age of 65 years. Expanding the range of donors and tendons could help offset an increasing clinical demand.

PURPOSE

To investigate the effects of donor age, sex, height, and specific tendon on the mechanical properties of a range of human lower leg tendons.

STUDY DESIGN

Descriptive laboratory study.

METHODS

Nine tendons were retrieved from 39 fresh-frozen human cadaveric lower legs (35 donors [13 female, 22 male]; age, 49-99 years; height, 57-85 inches [145-216 cm]) including: Achilles tendon, tibialis posterior and anterior, fibularis longus and brevis, flexor and extensor hallucis longus, plantaris, and flexor digitorum longus. Tendons underwent tensile loading to failure measuring cross-sectional area (CSA), maximum load, strain at failure, ultimate tensile strength, and elastic modulus. Results from 332 tendons were analyzed using mixed-effects linear regression, accounting for donor age, sex, height, and weight.

RESULTS

Mechanical properties were significantly different among tendons and were substantially greater than the effects of donor characteristics. Significant effects of donor sex, age, and height were limited to specific tendons: Achilles tendon, tibialis posterior, and tibialis anterior. All other tendons were unaffected. The Achilles tendon was most influenced by donor variables: greater CSA in men (β = 15.45 mm²; Šidák adjusted P < .0001), decreased maximum load with each year of increased age (β = -17.20 N per year; adjusted P = .0253), and increased CSA (β = 1.92 mm² per inch; adjusted P < .0001) and maximum load (β = 86.40 N per inch; adjusted P < .0001) with each inch of increased height.

CONCLUSION

Mechanical properties vary significantly across different human tendons. The effects of donor age, sex, and height are relatively small, are limited to specific tendons, and affect different tendons uniquely. The findings indicate that age negatively affected only the Achilles tendon (maximum load) and challenge the exclusion of donors aged >65 years across all tendon grafts.

CLINICAL RELEVANCE

The findings support including a broader range of tendons for use as allografts for anterior cruciate ligament reconstruction and reviewing the current exclusion criterion of donors aged >65 years.

A Prospective, Double-Blind Evaluation of Anterior Cruciate Ligament Reconstruction With Tibialis Tendon Allograft: Donor Age Does Not Alter Outcomes

Purpose

To evaluate the effect of graft donor age on outcomes of anterior cruciate ligament (ACL) reconstruction with nonirradiated, fresh-frozen tibialis tendon allografts.

Methods

This prospective, randomized, double-blind, single surgeon, 2-year follow-up study enrolled 40 patients (28 female, 12 male who underwent ACL reconstruction with tibialis tendon allografts. Results were compared with historical outcomes for allografts from donors aged 18 to 70 years. Analysis was determined by Group A (<50 years) and Group B (>50 years). Objective and subjective International Knee Documentation Committee (IKDC) forms, KT-1000 testing, and Lysholm scores were used for the evaluation.

Results

Follow-up on average of 24 months was completed in 37 patients (92.5%; Group A = 17, Group B = 20). Average patient age at surgery for Group A was 42.1 years (range 27-54) and Group B was 41.7 years (range 24-56). None of the patients required additional surgery during the initial 2-year follow-up. At 2-year follow-up, there were no significant differences in subjective outcomes. IKDC objective ratings for Group A were A-15 and B-2, and Group B were A-19 and B-1 (P = .45). Average IKDC subjective scores for Group A were 86.1 (± 16.2) and Group B were 84.1 (± 15.6) (P = .70). KT-1000 side to side differences for Group A were 0-4, 1-10, and 2-2, and Group B were 0-2, 1-10, 2-6 (P = .28). Average Lysholm scores for Group A were 91.4 (± 16.7) and Group B were 88.1 (± 12.3) (P = .49).

Conclusions

Donor age was not associated with clinical outcomes after ACL reconstruction using nonirradiated, fresh-frozen tibialis tendon allografts.

Level of Evidence

II, prospective prognostic trial.

Categorize the existing clamps used for tensile test of human graft- a systematic review

Background

The use of tendon allografts for orthopedic repair has gained wide acceptance in recent years, most notably in anterior cruciate tendon reconstruction. Multiple studies support the use of tendon allografts and the benefits of its use are well accepted and understood. One of the important criteria of the use of tendon allografts is statistically similar histological and biomechanical properties to autographs. The aim of this systematic literature review is to investigate and categorize existing clamps used in the determination of the biomechanical properties of tendons such as maximum load, maximum strength, modulus of elasticity, ultimate strain, and stiffness. A variety of clamps for use during the endurance test of tendons were categorized according to the temperature used during the measurement. The clamps are divided into three groups: room temperature, cooled and heated clamps. The second goal of our review is to overview of clamps on the following aspects: name of clamp, author and date, type of clamps, type of endurance test (static or dynamic), type preloading (dynamic or static), type of tendon and measured and calculated parameters, and summarize in Table 3, as a comprehensive catalogue.

Methods

This systematic review was carried out in keeping with the PRISMA 2020 E&E and the PRISMA-S guidelines and checklists. A search was conducted for publications dating between 1991 and February 28th 2022 through three electronic databases (Web of Science, Scopus, and PubMed). We used Critical Appraisal Skills Program checklist to check the quality of included articles.

Results

The database search and additional sources resulted in 1725 records. 1635 records eliminated during the screening for various reasons (case report, other languages, book chapter, unavailable text/conference abstract, unrelated topic). The number of articles used in the final synthesis was 90. A variety of clamps for use during the endurance test of tendons were identified and categorized according to the temperature used during the measurement. Based on this, the clamps are divided into three groups: room temperature, cooled or heated clamps.

Conclusions

On the basis of the systematic literature review, mechanical parameters determined by usage with cooled clamps proved to be more reliable than with those at room temperature and with heated clamps. The collected information from the articles included name of clamp, author and date, type of clamps, type of endurance test (static or dynamic), type preloading (dynamic or static), type of tendon and measured and calculated parameters given in Table 3. summarized. The main advantage of the cooled clamps is that there is no limit to the type and length of the tendon. This study provides an overview of clamps and does not represent the modernity of any method.

Supplementary Information

The online version contains supplementary material available at 10.1186/s12891-022-05650-w.

Influence of Age on Signal Intensity of Magnetic Resonance Imaging and Clinical Outcomes in Double-Bundle Anterior Cruciate Ligament Reconstruction: Comparisons Among Different Age Groups

BACKGROUND

Thus far, the clinical results of anterior cruciate ligament (ACL) reconstruction have been observed to be comparable between young and older patients. In contrast, age-related changes in the structural and mechanical properties of tendons used for autografts have been described. However, age-related changes associated with graft maturation remain poorly understood.

HYPOTHESES

The hypotheses of this study were that (1) clinical outcomes after ACL reconstruction would be comparable between younger and relatively older patients and (2) younger patients would show lower signal intensity changes on magnetic resonance imaging scans indicative of graft maturation that would be better than that in relatively older patients.

STUDY DESIGN

Cohort study; Level of evidence, 3.

METHODS

We retrospectively evaluated 236 patients who underwent double-bundle ACL reconstruction via the outside-in technique using hamstring autograft between January 2012 and December 2015. The patients were categorized by age into 3 groups: <20 years old, 20 to 39 years old, and ≥40 years old. Clinical outcomes were evaluated using the subjective International Knee Documentation Committee (IKDC) score, Tegner activity scale, Lysholm score, and objective assessment of joint laxity 24 months after surgery. In addition, graft maturation was evaluated using magnetic resonance imaging-derived measures of the signal intensity ratio (SIR) at 3, 6, 12, and 24 months postoperatively. Clinical outcomes and graft maturation were compared among the 3 groups.

RESULTS

The SIR of both bundles increased from 3 months to 12 months and decreased by 24 months, showing the same tendency in all groups. No significant difference was found in the SIR among the 3 groups at any time point (P > .05). The IKDC score was significantly lower in the ≥40-year group than in the <20-year group (P < .01). In contrast, no significant differences were noted in other clinical outcomes.

CONCLUSION

Patients aged ≥40 years exhibited lower IKDC scores compared with younger patients, although the results of graft maturation were comparable.

Different sterilization and disinfection methods used for human tendons - a systematic review using mechanical properties to evaluate tendon allografts

Background

It is important to know the biomechanical properties of an allograft. This is because when looking to do a transplant of a tendon, the tendon must have very similar biomechanical properties to the original tendon. To use tendon allografts, it is critical to properly sterilize the tendon before implantation. In past decades, several sterilization procedures have been used. This study aimed to systematically evaluate the existing literature to compare the values of failure load/ultimate strength and Young’s modulus of elasticity of different sterilization methods on commonly used tendon allografts. Five major scientific literature databases (Web of Science, Science Direct, Scopus, PLOS ONE, Hindawi) and additional sources were used.

Results

Studies used had to show a particular sterilization method. Studies were identified to meet the following inclusion criteria: is a controlled laboratory study, gamma irradiation (dose reported), and other sterilization methods. Search for publications dated between 1991 and March 31st, 2020. The database search and additional sources resulted in 284 records. Two hundred thirty records eliminated during the screening for various reasons. The number of articles used in the final synthesis was 54.

Conclusions

Identified sterilization methods (gamma irradiation, ethylene oxid, supercritical carbon dioxide (SCCO2), BioCleanse, Electron Beam) are offered as a catalog of potential methods.

As a result of the broadness of the present research, it provides an overview of sterilization methods and their effect on the mechanical properties (failure load and Young’s modulus of elasticity) of tendons. It does not stand for the state-of-the-art of any single process. Based on a systematic literature review, we recommend freezing and gamma irradiation or electron beam at 14.8–28.5 kGy. These methods are effective at keeping or improving the mechanical properties, while fully sterilizing the inside and the outside of the tendon. Other sterilization method (ethylene oxide, supercritical carbon dioxide (SCCO2), BioCleanse) deteriorated the mechanical properties. These methods are not recommended.

Supplementary Information

The online version contains supplementary material available at 10.1186/s12891-021-04296-4.

The influence of different sample preparation on mechanical properties of human iliotibial tract

In the run-up to biomechanical testing, fresh human tissue samples are often frozen in order to inhibit initial decomposition processes and to achieve a temporal independence of tissue acquisition from biomechanical testing. The aim of this study was to compare the mechanical properties of fresh tissue samples of the human iliotibial tract (IT) to fresh-frozen samples taken from the same IT and those modified with different concentrations of Dimethylsulfoxide (DMSO) prior to freezing. All samples were partial plastinated and destructive tensile tests were conducted with a uniaxial tensile test setup. A plastination technique already established in the laboratory was modified to improve the clamping behaviour of the samples. Material failure was caused by a gradual rupture of the load-bearing collagen fibre bundles. Contrary to our expectations, no significant difference was found between the tensile strength of fresh and fresh frozen specimens. The addition of 1 wt% DMSO did not increase the tensile strength compared to fresh-frozen samples; an addition of 10 wt% DMSO even resulted in a decrease. Based on our findings, the use of simple fresh-frozen specimens to determine the tensile strength is viable; however fresh specimens should be used to generate a complete property profile.

The influence of donor and recipient characteristics on allograft tendons: a systematic review

Tendon allograft has been an important alternative graft option aside from autograft. The outcome of reconstruction surgery is determined by donor and recipient related factors. The purpose of this article was to identified all studies reporting donor and recipient characteristics, including the age and gender of donors, along with the age, gender, activity level and smoking status of recipients, that affect the biomechanical properties and post-transplantation outcomes of allograft tendons. The systematic study search was based on MEDLINE via PubMed, Embase and the Cochrane Library databases. The reference lists of the included studies were used for hand searching (snowballing). The searching process was performed by two independent investigators, using search MESH term: "tendon", "allograft", and "person". Studies evaluating the influence of donor and recipient biological characteristics on the mechanical property and transplantation outcome of allograft were included. A total of 12 studies were selected for qualitative synthesis, including 6 studies evaluated the influence of donor characteristics, including age and gender, on the mechanical strength of tendon allograft. 6 studies assessed the influence of recipient characteristics, including age, gender, smoking status, and activity level, on the clinical outcome. As a conclusion, tendon allografts from donor younger than 40 years old were expected to have a higher mechanical property. Young patients or patients with a high level of activity were not recommended to receive allograft tendon when autograft is optional. There is no strong evidence supporting that neither donor or recipient gender affects the tendon allograft transplantation outcomes. Smoking history could increase the risk of complications.

Use of Allografts in Orthopaedic Surgery: Safety, Procurement, Storage, and Outcomes

The use of allografts has become a vital option for orthopaedic surgeons in the treatment of a variety of musculoskeletal lesions, ranging from osteochondral defects in the glenohumeral joint to meniscal deficiency in the young athlete. Nevertheless, barriers to treating a patient with an allograft-based procedure may arise from concerns over disease transmission, the navigation of tissue banks that supply allografts, the process of obtaining insurance approval, or optimal storage methods. This review serves to support orthopaedic surgeons in the incorporation of allografts into their practice by quelling these potential concerns. Fresh osteochondral allografts, fresh-frozen meniscal allografts, soft tissue allografts, and off-the-shelf cartilage products are the focus of this review amid broad overviews of allograft safety and tissue bank practices in the United States.

[Progress of sterilization and preservation methods for allografts in anterior cruciate ligament reconstruction]

OBJECTIVE

To review the current status and progress of sterilization and preservation for allograft in anterior cruciate ligament reconstruction.

METHODS

The related literature about the sterilization and preservation of allografts in anterior cruciate ligament reconstruction was extensively reviewed and summarized.

RESULTS

There are many sterilization methods for allografts, the most commonly used method is γ-ray irradiation, but the optimal irradiation dose is still unclear. Electron beam irradiation is also available, but excessive dose is harmful to graft shaping. A combined sterilization method combining physics and chemistry methods is still being explored. Cryopreservation is the most commonly used method of preservation. In order to reduce the influence of crystals, the principle of "slow cooling and rapid rewarming" should be adhered to as far as possible.

CONCLUSION

The processing methods of allograft can affect the effectiveness of anterior cruciate ligament reconstruction. The clinical doctors should consider the sterilization and preservation methods in practice.

Biomechanical and geometric characterization of peroneus longus allografts with respect to age

BACKGROUND

Anterior cruciate ligament injuries are among the most common injuries in high impact sports, and reconstruction is the standard surgical procedure for these ruptures. Reconstructions are often performed using allografts rather than autografts on a case-by-case basis. Controversy exists as to whether or not age of donor tissue plays a factor in the mechanical properties of allografts.

METHODS

38 peroneus longus (PL) tendons were prepared using the two-strand graft technique and then subjected to a cyclic loading test regimen of 1000 cycles to determine material properties. Specimens were grouped based on age to ascertain whether donor age affects the material properties of PL tendons.

FINDINGS

Secant modulus of the first cycle was determined to be 150.43 (SD 40.24) MPa. The average magnitude of the dynamic modulus was determined to be 82.81 (SD 24.65) MPa. Specimens were grouped into three distinct groups for analysis (x < 40 yo, 40 yo ≤ x < 60 yo, 60 yo < x).

INTERPRETATION

The need for using intrinsic material properties is highlighted. There is no significant difference in any intrinsic material property with respect to age or the fatigue of the tendon as the cycle count increases. Conversely, the measured stiffness of a tendon decreased as function of age with a large effect size. Based on analysis of graft geometries, it was determined that PL tendons become significantly more slender with increased age which result in the observed decrease in stiffness.

Cells, soluble factors and matrix harmonically play the concert of allograft integration

Implantation of allograft tissues has massively grown over the last years, especially in the fields related to sports medicine. Beside the fact that often no autograft option exists, autograft related disadvantages as donor-site morbidity and prolonged operative time are drastically reduced with allograft tissues. Despite the well documented clinical success for bone allograft procedures, advances in tissue engineering raised the interest in meniscus, osteochondral and ligament/tendon allografts. Notably, their overall success rates are constantly higher than 80%, making them a valuable treatment option in orthopaedics, especially in knee surgery. Complications reported for allografting procedures are a small risk of disease transmission, immunologic rejection, and decreased biologic incorporation together with nonunion at the graft-host juncture and, rarely, massive allograft resorption. Although allografting is a successful procedure, improved techniques and biological knowledge to limit these pitfalls and maximize graft incorporation are needed. A basic understanding of the biologic processes that affect the donor-host interactions and eventual incorporation and remodelling of various allograft tissues is a fundamental prerequisite for their successful clinical use. Further, the importance of the interaction of immunologic factors with the biologic processes involved in allograft incorporation has yet to be fully dissected. Finally, new tissue engineering techniques and use of adjunctive growth factors, cell based and focused gene therapies may improve the quality and uniformity of clinical outcomes. The aim of this review is to shed light on the biology of meniscus, osteochondral and ligament/tendon allograft incorporation and how collection and storage techniques may affect graft stability and embodiment.Level of evidence V.

Biomechanical considerations are crucial for the success of tendon and meniscus allograft integration-a systematic review

PURPOSE

This systematic review intends to give an overview of the current knowledge on how allografts used for the reconstruction of cruciate ligaments and menisci are integrated and specifically perform regarding their biomechanical function.

METHODS

Two reviewers reviewed the PubMed and Central Cochrane library with focus on the biomechanical integration of tendon ligament and meniscus allografts. The literature search was conducted in accordance with the PRISMA statement for reporting systematic reviews and meta-analyses.

RESULTS

The analysed literature on tendon allografts shows that they are more vulnerable to overstretching in the phase of degradation compared to autografts as the revascularization process starts later and takes longer. Therefore, to avoid excessive graft loads, allografts for cruciate ligament replacement should be selected that exhibit much higher failure loads than the native ligaments to counteract the detrimental effect of degradation. Further, placement techniques should be considered that result in a minimum of strain differences during knee joint motion, which is best achieved by near-isometric placement. The most important biomechanical parameters for meniscus allograft transplantation are secure fixation and proper graft sizing. Allograft attachment by bone plugs or by a bone block is superior to circumferential suturing and enables the allograft to restore the chondroprotective biomechanical function. Graft sizing is also of major relevance, because too small grafts are not able to compensate the knee joint incongruity and too large grafts may fail due to extrusion. Only adequate sizing and fixation together can lead to a biomechanically functioning allograft. The objective assessment of the biomechanical quality of allografts in a clinical setting is challenging, but would be highly desirable for monitoring the remodelling and incorporation process.

CONCLUSIONS

Currently, indicators like ap-stability after ACL reconstruction or meniscal extrusion represent only indirect measures for biomechanical graft integration. These parameters are at best clinical indicators of allograft function, but the overall integration properties comprising e.g. fixation and graft stiffness remain unknown. Therefore, future research should e.g. focus on advanced imaging techniques or other non-invasive methods allowing for in vivo assessment of biomechanical allograft properties.

Allograft Tissue Safety and Technology

Allograft tissues are commonly used by orthopedic surgeons and are processed using a variety of technologies to increase safety and clinical use. For safety, although disease transmission is a tangible risk, this possibility has been dramatically minimized through modern tissue-processing methods. These include steps to prevent processing tissues with unacceptable bioburden through rigorous screening using donor medical and social histories along with microbial testing of recovered tissue and viral testing of donor serum. Potential bioburden is also controlled through aseptic recovery and processing methods and then reduced through disinfection steps that can include antibiotics, detergents, mechanical process, chemical solutions, and terminal sterilization. Processing steps may also include decellularization methods to lower immunogenic potential of some tissues. To enhance fusion potential of bone void fillers, demineralization steps may be used, and the resultant demineralized bone matrices may be combined with a carrier to improve handling. Bone void fillers and osteochondral allografts may also be specially processed to retain a living cellular component. To preserve relevant biological, biochemical, and physical properties of allografts for clinical use and ease of handling, a number of methods may be used which include: (1) refrigeration in media, (2) freeze-drying, (3) cryopreservation, (4) freezing, and (5) media storage at room temperature. As academic and industry research continue to drive advances, the future direction of allograft tissue likely includes injectables, coatings, cellular therapies, and combinations with other materials. The technology approaches outlined here will be further described along with future directions.

Does Donor Age of Nonirradiated Achilles Tendon Allograft Influence Mid-Term Results of Revision ACL Reconstruction?

Purpose  The purpose of the present study was to investigate if the donor age of nonirradiated Achilles tendon allograft could influence the clinical results of revision anterior cruciate ligament (ACL) reconstruction.

Methods  All patients that underwent ACL revision between 2004 and 2008 with at least 4 years of follow-up were included. For all the patients that met the inclusion criteria, the age of the graft donor was obtained from the tissue bank. Lysholm score was administered to patients that met inclusion criteria. In addition, patients were divided in two groups based on the donor age (<45 years vs. ≥45 years), and the baseline characteristics and outcomes were compared.

Results  Fifty-two patients were evaluated at a mean 4.8 ± 0.8 years follow-up with Lysholm score. The Lysholm significantly improved from 62.3 ± 6.6 at preoperative status to 84.4 ± 12.3 at final follow-up. The mean donor age was 48.7 ± 8.4 years; a significant difference in Lysholm score was noted between patients that received an allograft with a donor age <45 years (14 patients; 27%) and those receiving an allograft with a donor age ≥45 years (38; 73%) (89.5 ± 3.2 vs. 80.1 ± 11.1, respectively; p  = 0.0469). The multiple regression model showed the donor age, the final follow-up, and the preoperative Lysholm score as significant predictors of postoperative Lysholm score ( p  < 0.0002).

Conclusion  Donor age of nonirradiated Achilles tendon allograft influenced the mid-term results of revision ACL reconstruction, thus advising the use of grafts from young donors.

Level of Evidence  Level III, retrospective comparative study.

Morphological and molecular characterization of human hamstrings shows that tendon features are not influenced by donor age

PURPOSE

Age-related modifications of tendons, such as reduced tenocyte proliferation and modified extracellular matrix (ECM) turnover, have been previously described, but results are often incomplete and discordant. The aim of this study was to investigate, using morphological and molecular methods, the effect of ageing on human tendons and tenocytes, especially focusing on the collagen turnover pathways, in order to understand how the ageing process could influence tendon biology and structure.

METHODS

Morphological analysis was performed on fragments from human semitendinosus and gracilis tendons harvested from 10 adult (mean age 41.8 ± 13.3 years) and 6 aged healthy patients (mean age 72.7 ± 7.0 years) by haematoxylin and eosin, Sirius red and Alcian blue staining. The expression of genes and proteins involved in collagen turnover and focal adhesions was assessed by real-time PCR, slot blot and zymography in cultured tenocytes. Cytoskeleton arrangement was studied by immunofluorescence and cell migration by wound healing assay.

RESULTS

The structure and composition of ECM in ageing tendons are preserved as well as the expression of genes and proteins involved in collagen turnover pathways. Although morphological analysis revealed that ageing tenocytes tended to an impaired migration potential and that actin filaments are occasionally shorter and randomly distributed, the expression of proteins involved in focal adhesion formation is preserved.

CONCLUSION

Results of this study suggest that the structure of ageing tendons is preserved and that ageing tenocytes maintain their ability for ECM remodelling, supporting the hypothesis that ageing tendons maintain their biomechanical properties. The biological reliability of aged tendons has a clinical relevance, supporting the use of tendon autografts also in the elderly patients. Since the common and successful orthopaedic procedure of anterior cruciate ligament reconstruction using either autografts or allografts is becoming more common in older age groups, these findings suggest that the donor age would not significantly influence the clinical outcome.

"Proprietary Processed" Allografts: Clinical Outcomes and Biomechanical Properties in Anterior Cruciate Ligament Reconstruction

BACKGROUND

The processing of allograft tissues in anterior cruciate ligament (ACL) reconstruction continues to be controversial. While high-dose irradiation of grafts has received scrutiny for high failure rates, lower dose irradiation and "proprietary-based" nonirradiated sterilization techniques have become increasingly popular, with little in the literature to evaluate their outcomes. Recent studies have suggested that the specifics of allograft processing techniques may be a risk factor for higher failure rates.

PURPOSE

To assess these proprietary processes and their clinical outcomes and biomechanical properties.

STUDY DESIGN

Systematic review.

METHODS

A systematic review was performed using searches of PubMed, EMBASE, Google Scholar, and Cochrane databases. English-language studies were identified with the following search terms: "allograft ACL reconstruction" (title/abstract), "novel allograft processing" (title/abstract), "allograft anterior cruciate ligament" (title/abstract), "anterior cruciate ligament allograft processing" (title/abstract), or "biomechanical properties anterior cruciate ligament allograft" (title/abstract). Duplicate studies, studies not providing the allograft processing technique, and those not containing the outcomes of interest were excluded. Outcomes of interest included outcome scores, complication and failure rates, and biomechanical properties of the processed allografts.

RESULTS

Twenty-four studies (13 clinical, 11 biomechanical) met inclusion criteria for review. No demonstrable difference in patient-reported outcomes was appreciated between the processing techniques, with the exception of the Tutoplast process. The clinical failure rate of the Tutoplast process was unacceptably high (45% at 6 years), but no other difference was found between other processing techniques (BioCleanse: 5.4%; AlloTrue: 5.7%; MTF: 6.7%). Several studies did show an increased failure rate, but these studies either combined processing techniques or failed to delineate enough detail to allow a specific comparison for this study. The biomechanical studies showed overall maintenance of satisfactory biomechanical properties throughout multiple testing modes with normalization to the percentage of control specimens.

CONCLUSION

A comparison of proprietary allograft processing techniques is difficult because of the variability and lack of specificity of reporting in the current literature. Among the available literature, except for the Tutoplast process, no notable differences were found in the clinical outcomes or biomechanical properties. Future study with a longer follow-up is necessary to determine the role and limitations of these grafts in the clinical setting.

What Factors Influence the Biomechanical Properties of Allograft Tissue for ACL Reconstruction? A Systematic Review

BACKGROUND

Allograft tissue is used in 22% to 42% of anterior cruciate ligament (ACL) reconstructions. Clinical outcomes have been inconsistent with allograft tissue, with some series reporting no differences in outcomes and others reporting increased risk of failure. There are numerous variations in processing and preparation that may influence the eventual performance of allograft tissue in ACL reconstruction. We sought to perform a systematic review to summarize the factors that affect the biomechanical properties of allograft tissue for use in ACL reconstruction. Many factors might impact the biomechanical properties of allograft tissue, and these should be understood when considering using allograft tissue or when reporting outcomes from allograft reconstruction.

QUESTIONS/PURPOSES

What factors affect the biomechanical properties of allograft tissue used for ACL reconstruction?

METHODS

We performed a systematic review to identify studies on factors that influence the biomechanical properties of allograft tissue through PubMed and SCOPUS databases. We included cadaveric and animal studies that reported on results of biomechanical testing, whereas studies on fixation, histologic evaluation, and clinical outcomes were excluded. There were 319 unique publications identified through the search with 48 identified as relevant to answering the study question. For each study, we recorded the type of tissue tested, parameters investigated, and the effects on biomechanical behavior, including load to failure and stiffness. Primary factors identified to influence allograft tissue properties were graft tissue type, sterilization methods (irradiation and chemical processing), graft preparation, donor parameters, and biologic adjuncts.

RESULTS

Load to failure and graft stiffness varied across different tissue types, with nonlooped tibialis grafts exhibiting the lowest values. Studies on low-dose irradiation showed variable effects, whereas high-dose irradiation consistently produced decreased load to failure and stiffness values. Various chemical sterilization measures were also associated with negative effects on biomechanical properties. Prolonged freezing decreased load to failure, ultimate stress, and ultimate strain. Up to eight freeze-thaw cycles did not lead to differences in biomechanical properties of cadaveric grafts. Regional differences were noted in patellar tendon grafts, with the central third showing the highest load to failure and stiffness. Graft diameter strongly contributed to load-to-failure measurements. Age older than 40 years, and especially older than 65 years, negatively impacted biomechanical properties, whereas gender had minimal effect on the properties of allograft tissue. Biologic adjuncts show potential for improving in vivo properties of allograft tissue.

CONCLUSIONS

Future clinical studies on allograft ACL reconstruction should investigate in vivo graft performance with standardized allograft processing and preparation methods that limit the negative effects on the biomechanical properties of tissue. Additionally, biologic adjuncts may improve the biomechanical properties of allograft tissue, although future preclinical and clinical studies are necessary to clarify the role of these treatments.

CLINICAL RELEVANCE

Based on the findings of this systematic review that emphasize biomechanical properties of ACL allografts, surgeons should favor the use of central third patellar tendon or looped soft tissue grafts, maximize graft cross-sectional area, and favor grafts from donors younger than 40 years of age while avoiding grafts subjected to radiation doses > 20 kGy, chemical processing, or greater than eight freeze-thaw cycles.

Does the type of graft affect the outcome of revision anterior cruciate ligament reconstruction? a meta-analysis of 32 studies

AIMS

Our aim was to perform a meta-analysis of the outcomes of revision anterior cruciate ligament (ACL) reconstruction, comparing the use of different types of graft.

MATERIALS AND METHODS

A search was performed of Medline and Pubmed using the terms "Anterior Cruciate Ligament" and "ACL" combined with "revision", "re-operation" and "failure". Only studies that reported the outcome at a minimum follow-up of two years were included. Two authors reviewed the papers, and outcomes were subdivided into autograft and allograft. Autograft was subdivided into hamstring (HS) and bone-patellar tendon-bone (BPTB). Subjective and objective outcome measures were analysed and odds ratios with confidence intervals were calculated.

RESULTS

A total of 32 studies met the inclusion criteria. Five studies used HS autografts, eight reported using BPTB autografts, two used quadriceps tendon autografts and eight used various types. Seven studies reported using allografts, while the two remaining used both BPTB autografts and allografts. Overall, 1192 patients with a mean age of 28.7 years (22.5 to 39) and a mean follow-up of 5.4 years (2.0 to 9.6) were treated with autografts, while 269 patients with a mean age of 28.4 years (25 to 34.6) and a mean follow-up of 4.0 years (2.3 to 6.0) were treated with allografts. Regarding allografts, irradiation with 2.5 mrad was used in two studies while the graft was not irradiated in the seven remaining studies. Reconstructions following the use of autografts had better outcomes than those using allograft with respect to laxity, measured by KT-1000/2000 (MEDmetric Corporation) and the rates of complications and re-operations. Those following the use of allografts had better mean Lysholm and Tegner activity scores compared with autografts. If irradiated allografts were excluded from the analysis, outcomes no longer differed between the use of autografts and allografts. Comparing the types of autograft, all outcomes were similar except for HS grafts which had better International Knee Documentation Committee scores compared with BPTB grafts.

CONCLUSION

Autografts had better outcomes than allografts in revision ACL reconstruction, with lower post-operative laxity and rates of complications and re-operations. However, after excluding irradiated allografts, outcomes were similar between autografts and allografts. Overall, the choice of graft at revision ACL reconstruction should be on an individual basis considering, for instance, the preferred technique of the surgeon, whether a combined reconstruction is required, the type of graft that was previously used, whether the tunnels are enlarged and the availability of allograft. Cite this article: Bone Joint J 2017;99-B:714-23.

Does a different dose of gamma irradiation have the same effect on five different types of tendon allografts? - a biomechanical study

INTRODUCTION

The goals of our study were to evaluate the biomechanical differences between five tendons and the changes in biomechanical properties caused by irradiation.

METHODS

Achilles, quadriceps, semitendinosus + gracilis (STG), tibialis anterior (TA) and the peroneus longus (PL) were harvested from 30 donors. Group A contained 50 tendons without gamma irradiation. The groups were irradiated with a dose of 21 kGy (group B 50 tendons) and with a dose of 42 kGy (group C 50 tendons). The grafts were soaked in a radio-protectant solution and frozen at -80 °C. Cyclic loading tests were performed followed by load to failure tests. Young modulus of elasticity, maximum force, strain at tensile strength and strain at rupture were calculated.

RESULTS

The Achilles tendons had significantly lower Young modulus than the TA (p = 0.0036) in group A. The Achilles showed significantly lower than PL (p = 0.000042) and TA (p = 0.00142) in group B and C. The quadriceps and the ST (p = 0.0037) provided poorer values than the TA (p = 0.0432) in group C. We found no difference in maximum loads among the tendons in group A. The maximum load of the Achilles and quadriceps showed better results than the PL (p = 0.0016), (p = 0.0018) and the STG (p = 0.0066), (p = 0.0019) in group C. The TA had similar results like the Achilles and quadriceps.

DISCUSSION AND CONCLUSIONS

The vulnerability of gamma irradiation of TA was less than Achilles and quadriceps tendons.

Maximum load to failure of high dose versus low dose gamma irradiation of anterior cruciate ligament allografts: A meta-analysis

BACKGROUND

The objective of this study was to systematically evaluate the existing literature to compare the biomechanical effects of low dose and high dose gamma irradiation on commonly used ACL allografts.

METHODS

A systematic search was performed in PubMed, Cumulative Index for Nursing and Allied Health Literature (CINAHL), Cochrane Reviews, SCOPUS, and SportDiscus. Nine studies were identified that met the following inclusion criteria: 1) controlled laboratory study, 2) investigation of standard allografts for anterior cruciate ligament reconstruction (ACLR), 3) gamma irradiation (dose reported) and a negative control group, and 4) mechanical loading (results reported).

RESULTS

Nine studies met all inclusion and exclusion criteria. There was a dose-dependent relationship between radiation and decreased mechanical tendon integrity. Low dose radiation (<2.5Mrad [Mrad]) showed graft weakening with an average of 4.3% decrease in load to failure (standardized mean difference [SMD], 0.23; 95% CI 0.216, 0.68; p=0.31), whereas high-dose radiation showed a significantly larger (32.4% average) decrease in load to failure (SMD, 1.79; 95% CI 1.194, 2.38; p<0.001).

CONCLUSIONS

Gamma irradiation has a negative effect on tendon allograft strength that is dose-dependent, with particularly large effects noted at irradiation doses of ≥2.5Mrad.

Allograft tissue irradiation and failure rate after anterior cruciate ligament reconstruction: A systematic review

AIM: To evaluate whether anterior cruciate ligament (ACL) allograft irradiation is effective for sterility without compromising graft integrity and increasing failure rate.

METHODS: A literature search was conducted using PubMed, Cochrane, and Google. The following search terms were used: “Gamma irradiation AND anterior cruciate ligament AND allograft” with a return of 30 items. Filters used included: English language, years 1990-2015. There were 6 hits that were not reviewed, as there were only abstracts available. Another 5 hits were discarded, as they did not pertain to the topic of interest. There were 9 more articles that were excluded: Three studies were performed on animals and 6 studies were meta-analyses. Therefore, a total of 10 articles were applicable to review.

RESULTS: There is a delicate dosing crossover where gamma irradiation is both effective for sterility without catastrophically compromising the structural integrity of the graft. Of note, low dose irradiation is considered less than 2.0 Mrad, moderate dose is between 2.1-2.4 Mrad, and high dose is greater than or equal to 2.5 Mrad. Based upon the results of the literature search, the optimal threshold for sterilization was found to be sterilization at less than 2.2 Mrad of gamma irradiation with the important caveat of being performed at low temperatures. The graft selection process also must include thorough donor screening and testing as well as harvesting the tissue in a sterile fashion. Utilization of higher dose (≥ 2.5 Mrad) of irradiation causes greater allograft tissue laxity that results in greater graft failure rate clinically in patients after ACL reconstruction.

CONCLUSION: Allograft ACL graft gamma irradiated with less than 2.2 Mrad appears to be a reasonable alternative to autograft for patients above 25 years of age.

Radiation sterilization of tissue allografts: A review

Tissue substitutes are required in a number of clinical conditions for treatment of injured and diseased tissues. Tissues like bone, skin, amniotic membrane and soft tissues obtained from human donor can be used for repair or reconstruction of the injured part of the body. Allograft tissues from human donor provide an excellent alternative to autografts. However, major concern with the use of allografts is the risk of infectious disease transmission. Therefore, tissue allografts should be sterilized to make them safe for clinical use. Gamma radiation has several advantages and is the most suitable method for sterilization of biological tissues. This review summarizes the use of gamma irradiation technology as an effective method for sterilization of biological tissues and ensuring safety of tissue allografts.

Change in Size of Hamstring Grafts During Preparation for ACL Reconstruction: Effect of Tension and Circumferential Compression on Graft Diameter

BACKGROUND

There is good consensus that anterior cruciate ligament (ACL) grafts should be pretensioned to remove creep prior to implantation, but the literature contains little information on the influence of graft preparation or circumferential compression on graft size. The purpose of this study was to investigate how the size of hamstring allografts changes as they are prepared for ACL reconstruction. We hypothesized that grafts decrease in diameter as they are prepared with both tension and circumferential compression. We also investigated the interrater reliability of graft diameter measurements during each step of graft preparation.

METHODS

Twenty pairs of fresh-frozen human hamstring tendons obtained from an allograft supplier were prepared in a standardized fashion for ACL reconstruction (suturing followed by longitudinal tensioning followed by circumferential compression followed by relaxation). Four blinded raters measured each graft in a sequential manner after each graft preparation step. Interrater reliability was assessed using the intraclass correlation coefficient ICC(2,1). The mean allograft diameter at each time point was calculated and compared across all time points using repeated-measures analysis of variance (ANOVA).

RESULTS

Subjecting the grafts to both tension and circumferential compression significantly decreased their mean diameter (to 7.38 mm compared with 8.28 mm at baseline; p = 0.044). Interrater reliability revealed almost perfect agreement at each measurement interval, with the ICC ranging from 0.933 to 0.961.

CONCLUSIONS

The average diameter of hamstring ACL grafts decreases by almost 1 mm after they are subjected to both tension and circumferential compression within a standard cylindrical sizing block.

CLINICAL RELEVANCE

Because ACL bone tunnels are drilled in 0.5-mm increments, preparing soft-tissue grafts with circumferential compression in addition to tension may allow creation of tunnels that are one to two incremental sizes smaller. This could permit less bone removal, which may be particularly applicable for certain reconstruction techniques such as pediatric, double-bundle, or revision ACL reconstruction, in which limited space is available for tunnel drilling.

Structural mechanical properties of radiation-sterilized human Bone-Tendon-Bone grafts preserved by different methods

To avoid the risk of infectious disease transmission from donor to recipient, allografts should be terminally sterilized. In the previous paper (Kaminski et al. in Cell Tissue Bank 10:215–219, 2009) we presented the effect of various methods of preservation (deep fresh freezing, glycerolization, lyophilization), followed by irradiation with different doses of electron beam (EB), on material (intrinsic) mechanical properties of human patellar tendons cut out as for anterior cruciate ligament reconstruction, obtained in failure tensile test. As structural mechanical properties are equally important to predict the behaviour of the graft as a whole functional unit, the purpose of the present paper was to show the results for failure load and elongation, obtained in the same experiment. Paired Bone-Tendon-Bone grafts (BTB) were prepared from cadaveric human patella tendons with both patellar and tibial attachments. They were preserved by deep freezing, glycerolization or lyophilization and subsequently EB-irradiated with the doses of 25, 35, 50 or 100 kGy (fresh-frozen grafts) or a single dose of 35 kGy (glycerolized and lyophilized grafts). Each experimental (irradiated) group was provided with control (non-irradiated), donor-matched group. The specimens from all groups were subjected to mechanical failure tensile test with the use of Instron system in order to measure their structural properties (failure load and elongation). All lyophilized grafts were rehydrated before mechanical testing. In our study we did not observe significant deterioration of structural mechanical properties of BTB grafts processed by fresh-freezing and then terminal sterilized with growing doses of EB up to 100 kGy. In contrast, BTB grafts processed by glycerolization or lyophilization and irradiated with 35 kGy showed significant decrease of failure load. Obtained results suggest that deep-frozen irradiated grafts retain their initial mechanical properties to an extent which does not exclude their clinical application. However, biomechanical investigations constitute only the first step to evaluate the potential clinical usefulness of such allografts and further extensive in vivo studies are needed.

Increased Failure Rates After Anterior Cruciate Ligament Reconstruction With Soft-Tissue Autograft-Allograft Hybrid Grafts

PURPOSE

To compare the rate of failure between a group of patients who underwent anterior cruciate ligament (ACL) reconstruction with an autograft-allograft hybrid soft-tissue graft and a matched group of patients who underwent ACL reconstruction with hamstring autograft.

METHODS

From 2007 to 2012, 29 patients underwent hybrid ACL reconstruction performed by 4 fellowship-trained sports medicine surgeons at a single institution. Patients who underwent ACL reconstruction with hamstring autograft comprised the control group and were matched to patients in the hybrid group by sex, age, date of surgery, reconstruction technique, and method of femoral fixation. Graft failure was defined as revision ACL reconstruction or complete graft rupture on magnetic resonance imaging. Graft compromise was defined as magnetic resonance imaging evidence of partial graft rupture or arthroscopically identified partial graft rupture. Lysholm Knee Scoring Scale and International Knee Documentation Committee scores were obtained.

RESULTS

Both groups included 10 men and 19 women, with a mean postoperative follow-up period of 44.4 ± 16.9 months in the hybrid group and 48.0 ± 15.2 months in the control group. Follow-up was obtained in 25 of 29 patients (86.2%) in the hybrid group, and each was matched to 1 patient who received hamstring autograft. The failure rate was 13.8% (4 of 29 patients) in the hybrid group compared with 3.4% (1 of 29) in the control group (P = .160). An additional 27.6% of hybrid group patients (7 of 29) had compromised grafts as defined earlier, as compared with 1 (3.4%) of the control patients (P = .022). Thus the overall hybrid graft failure/compromise rate was 37.9% (11 of 29) compared with 6.9% (2 of 29) for the hamstring autograft group (P = .005). In the hybrid group, the Lysholm score (80.2 ± 12.1) was significantly lower than that in the control autograft ACL group (89.9 ± 11.8) (P = .030). The International Knee Documentation Committee score for the hybrid ACL group (71.26 ± 19.5) was significantly worse than that for the autograft ACL group (85.7 ± 13.0) (P = .012).

CONCLUSIONS

Allograft-autograft hybrid hamstring ACL grafts fail or become structurally compromised at a higher rate than matched autograft hamstring controls.

LEVEL OF EVIDENCE

Level III, retrospective comparative study.

Revision Risk After Allograft Anterior Cruciate Ligament Reconstruction: Association With Graft Processing Techniques, Patient Characteristics, and Graft Type

BACKGROUND

Allograft tissue is a common graft choice for anterior cruciate ligament reconstruction (ACLR). Allograft sterilization methods vary widely across numerous commercial tissue vendors. Multiple studies, despite being limited in sample size, have suggested a higher rate of clinical failure associated with the use of allograft tissue in ACLR when compared with autograft.

PURPOSE

To examine the association of graft processing techniques, patient characteristics, and graft type with risk of revision surgery after allograft ACLR.

STUDY DESIGN

Cohort study; Level of evidence, 3.

METHODS

A retrospective cohort study was conducted that used an integrated United States health care system's ACLR registry to identify primary unilateral cases in which allografts were used. Aseptic revision was the endpoint of the study. Allograft type, processing methods (irradiation dose, AlloWash, AlloTrue, BioCleanse), and graft donor age were assessed as potential risk factors for revision, with adjustment for patient age, sex, and body mass index (BMI) by use of survival analysis. Hazard ratios (HR) and 95% confidence intervals (CIs) were calculated.

RESULTS

A total of 5968 primary ACLR cases with allograft were included in the study, of which 3688 (61.8%) were male patients. The median age of the cohort at the time of surgery was 34.1 years (interquartile range, 24.1-42.9 years). The mean time to follow-up (±SD) was 2.1 ± 1.5 years. There were 3751 (62.9%) allograft ACLRs using soft tissue, 1188 (19.9%) with Achilles tendon, and 1029 (17.2%) with bone-patellar tendon-bone (BPTB). Graft processing groups included BioCleanse (n = 367), AlloTrue or AlloWash (n = 2278), irradiation greater than 1.8 Mrad (n = 1146), irradiation up to 1.8 Mrad (n = 3637), and no irradiation (n = 1185). There were 156 (2.6%) aseptic revisions. After adjustment for patient age, sex, and BMI, the use of BioCleanse (HR = 2.45; 95% CI, 1.36-4.40) and irradiation greater than 1.8 Mrad (HR = 1.64; 95% CI, 1.08-2.49) were associated with a higher risk of revision when compared with all other methods of processing. BPTB allografts were at higher risk of revision (HR = 1.79; 95% CI, 1.20-2.66) when compared with soft tissue allografts. Conversely, with every 5-year increase in age, the risk of revision was 0.67 (95% CI, 0.61-0.73) times lower. Male patients were found to be at higher risk of revision when compared with females (HR = 1.47; 95% CI, 1.04-2.07). The use of AlloWash or AlloTrue processing, patient BMI, and graft donor age did not affect revision rate significantly.

CONCLUSION

In the largest known study of its kind examining outcome after primary allograft ACLR, graft irradiation greater than 1.8 Mrad, BioCleanse graft processing, younger patient age, male patients, and BPTB allograft were all associated with a higher risk of clinical failure and subsequent revision surgery.

Impact of Hamstring Graft Diameter on Tendon Strength: A Biomechanical Study

PURPOSE

The purpose of this study was to compare the tensile strength of hamstring grafts of varying combined pull-through diameters within the clinically relevant range of 6 to 9 mm.

METHODS

We tested 44 non-irradiated allograft hamstring grafts (11 per group). Combined looped semitendinosus and gracilis grafts were allocated to the 6-, 7-, 8-, or 9-mm group based on the smallest-diameter lumen that the graft could be "pulled through" using a surgical sizing instrument. Testing was performed on an Instron materials testing machine (Instron, Norwood, MA). Samples were secured with cryoclamps, prestressed, and pulled to failure at a rate of 10% gauge length per second.

RESULTS

The mean load to failure was 2,359 ± 474 N, 3,263 ± 677 N, 3,908 ± 556 N, and 4,360 ± 606 N for the 6-, 7-, 8-, and 9-mm grafts, respectively. Minimum failure loads were as low as 1,567 N, 2,288 N, 2,874 N, and 3,720 N for each group, respectively. There were statistically significant differences between the 6- and 7-mm, 6- and 8-mm, 6- and 9-mm, and 7- and 9-mm groups (P = .01).

CONCLUSIONS

Statistically different increasing tensile strength was seen as graft diameter increased. Significant variability exists in the strength of multi-stranded hamstring allografts within the diameter range of 6 to 9 mm that often falls well below the commonly accepted value of 4,000 N for a hamstring graft.

CLINICAL RELEVANCE

Recent evidence suggests a higher early failure rate of hamstring autografts in subsets of patients with graft diameters of 8 mm or less. This study may increase awareness that hamstring grafts may not be nearly as strong as previously appreciated and that increasing tendon diameters by 1 to 2 mm may dramatically affect graft strength. These data may be helpful in preoperative discussions regarding variable hamstring size, strength, and potential intraoperative augmentation options.

The past, present and future in scaffold-based tendon treatments

Tendon injuries represent a significant clinical burden on healthcare systems worldwide. As the human population ages and the life expectancy increases, tendon injuries will become more prevalent, especially among young individuals with long life ahead of them. Advancements in engineering, chemistry and biology have made available an array of three-dimensional scaffold-based intervention strategies, natural or synthetic in origin. Further, functionalisation strategies, based on biophysical, biochemical and biological cues, offer control over cellular functions; localisation and sustained release of therapeutics/biologics; and the ability to positively interact with the host to promote repair and regeneration. Herein, we critically discuss current therapies and emerging technologies that aim to transform tendon treatments in the years to come.

The effect of donor age on structural and mechanical properties of allograft tendons

BACKGROUND

Allograft tendons are commonly used in surgical ligament reconstruction. While it is commonly accepted that donor age will affect mechanical properties of graft tissue, the apparent age threshold is unknown.

HYPOTHESIS

Donor age will significantly influence the structural and mechanical properties of tibialis posterior allograft tendons.

STUDY DESIGN

Controlled laboratory study.

METHODS

A total of 550 allograft posterior tibialis tendons were examined. Linear stiffness, ultimate tensile force, ultimate displacement, tensile modulus, ultimate tensile strength, and ultimate tensile strain were calculated for specimens from donors in each of 6 age groups: 15-29, 30-39, 40-49, 50-59, 60-69, and 70-79 years. Both first- and second-order polynomial regressions were performed to determine the correlation between structural and mechanical properties and age. Welch analyses of variance with Games-Howell post hoc tests were performed to facilitate comparisons among age groups.

RESULTS

All parameters displayed a weak correlation with age, with the highest R (2) term being 0.063 for ultimate tensile strength. Linear stiffness, ultimate tensile force, and tensile modulus displayed almost no correlation with age. Ultimate tensile strength increased slightly with age up to 40-49 years and then decreased with further increases in age. Slight decreases in ultimate displacement and ultimate tensile strain were observed with increasing age. Numerous statistically significant differences were observed between age groups for each outcome parameter; however, the magnitudes of the differences between age groups are relatively small (<15%) for all outcome parameters.

CONCLUSION

Age explained at most 6% of the variation in structural and mechanical properties of tibialis posterior allograft tendons.

CLINICAL RELEVANCE

Posterior tibialis tendons from all age groups displayed structural properties superior to the native anterior cruciate ligament, with higher stiffness and ultimate force, and less displacement to failure. Although statistically significant differences in structural and mechanical properties were observed between age groups, the magnitudes of the differences are small and most likely not clinically relevant. The age of the donor will not likely affect the suitability of a graft for use in surgical reconstruction.

Soft-tissue allografts terminally sterilized with an electron beam are biomechanically equivalent to aseptic, nonsterilized tendons

BACKGROUND

Allograft safety is contingent on effective sterilization. However, current sterilization methods have been associated with decreased biomechanical strength and higher failure rates of soft-tissue allografts. In this study, electron beam (e-beam) sterilization was explored as an alternative sterilization method to preserve biomechanical integrity. We hypothesized that e-beam sterilization would not significantly alter the biomechanical properties of tendon allograft compared with aseptic, nonsterilized controls and gamma-irradiated grafts.

METHODS

Separate sets of forty fresh-frozen tibialis tendon allografts (four from each of ten donors) and forty bisected bone-patellar tendon-bone (BTB) allografts (four from each of ten donors) were randomly assigned to four study groups. One group received a 17.1 to 21.0-kGy gamma radiation dose; two other groups were sterilized with an e-beam at either a high (17.1 to 21.0-kGy) or low (9.2 to 12.2-kGy) dose. A fourth group served as nonsterilized controls. Each graft was cyclically loaded to 200 N of tension for 2000 cycles at a frequency of 2 Hz, allowed to relax for five minutes, and then tested in tension until failure at a 100%/sec strain rate. One-way analysis of variance testing was used to identify significant differences.

RESULTS

Tibialis tendons sterilized with both e-beam treatments and with gamma irradiation exhibited values for cyclic tendon elongation, maximum load, maximum displacement, stiffness, maximum stress, maximum strain, and elastic modulus that were not significantly different from those of nonsterilized controls. BTB allografts sterilized with the high e-beam dose and with gamma irradiation were not significantly different in cyclic tendon elongation, maximum load, maximum displacement, stiffness, maximum stress, maximum strain, and elastic modulus from nonsterilized controls. BTB allografts sterilized with the e-beam at the lower dose were significantly less stiff than nonsterilized controls (p = 0.014) but did not differ from controls in any other properties. The difference in stiffness likely resulted from variations in tendon size rather than the treatments, as the elastic moduli of the groups were similar.

CONCLUSIONS

The biomechanical properties of tibialis and BTB allografts sterilized with use of an e-beam at a dose range of 17.1 to 21.0 kGy were not different from those of aseptic, nonsterilized controls or gamma-irradiated allografts.

CLINICAL RELEVANCE

E-beam sterilization can be a viable method to produce safe and biomechanically uncompromised soft-tissue allografts.

DermACELL: a novel and biocompatible acellular dermal matrix in tissue expander and implant-based breast reconstruction

BACKGROUND

Acellular dermal matrices present a new alternative to supporting expanders and implants for breast reconstruction in breast cancer patients following mastectomy. However, some studies have suggested that acellular dermal matrix may increase the complication rates in certain clinical settings. DermACELL acellular dermal matrix offers advanced processing in order to attempt to decrease bio-intolerance and complications.

METHODS

Ten consecutive patients that presented for breast reconstruction and were candidates for tissue expanders underwent the procedure with the use of an acellular dermal matrix. The patients underwent postoperative expansion/adjuvant cancer therapy, then tissue expander exchange for permanent silicone breast prostheses. Patients were followed through the postoperative course to assess complication outcomes. Histologic evaluation of host integration into the dermal matrix was also assessed.

RESULTS

Of the ten patients, eight completed reconstruction while two patients failed reconstruction. The failures were related to chronic seromas and infection. Histology analysis confirms rapid integration of mesenchymal cells into the matrix compared to other acellular dermal matrices.

CONCLUSIONS

Based on our observations, DermACELL is an appropriate adjunct to reconstruction with expanders. Histological analysis of vascularization and recellularization support the ready incorporation of DermACELL into host tissue. Level of Evidence: Level IV, therapeutic study.

Effect of hydrogen peroxide on human tendon allograft

Bacterial contamination of tendon allografts at the completion of processing has historically been about 2 %, with tendons that are found to be culture positive being discarded. Treatment of tendon allograft with hydrogen peroxide at the beginning of tissue processing may reduce bacterial contamination, however, the potential side effects of hydrogen peroxide treatment include hydrolysis of the collagen and this may alter the mechanical properties of the graft. Pairs of human tendons were used. One was washed in 3 % hydrogen peroxide for 5 min and the untreated tendon was used as a control. The ultimate tensile strength of the tendons was determined using a material testing machine. A freeze clamp technique was used to hold the tendons securely at the high loads required to cause tendon failure. There was no statistical difference in the ultimate tensile strength between the treated and untreated tendons. Mean strength ranged from Extensor Hallucis Longus at 588 Newtons to Tibialis Posterior at 2,366 Newtons. Hydrogen peroxide washing may reduce bacterial contamination of tendon allograft and does not affect the strength of the tendon.

Cryopreservation with glycerol improves the in vitro biomechanical characteristics of human patellar tendon allografts

PURPOSE

To evaluate the in vitro biomechanical characteristics of patellar tendon ligaments (BTB) when stored as fresh frozen or as glycerol cryopreserved allografts.

METHODS

Seventy patellar tendons were harvested from 35 cadaveric human donors and randomly assigned into seven groups. Grafts in group FRESH were mechanically tested within 2 h of harvesting. FROZ-3, FROZ-6, and FROZ-9 were deep-frozen to -80 °C for 3, 6, and 9 months, respectively. Grafts in groups CRYO-3, CRYO-6, and CRYO-9 were initially incubated with 10% glycerol in a phosphate-buffered saline for 1 h and then stored in glycerol solution (10% glycerol in PBS) at -80 °C for 3, 6, and 9 months, respectively. Grafts were mechanically tested with two cycling modes (50-250 °N and 150-500 °N) and then loaded to failure.

RESULTS

Cryopreserved grafts demonstrated more consistent results and expressed lower elongation rates after both cycling loading protocols compared to their frozen counterparts at all storage times. During load-to-failure analysis, ultimate stiffness levels were predominantly higher (23.9-61.5%) in cryopreserved grafts compared with frozen grafts, and ultimate stress levels were 26% (13.3-47.7%) higher, regardless of the storage time. Moreover, cryopreserved grafts revealed similar ultimate elongation and uniformly higher ultimate stiffness and ultimate stress levels compared to fresh grafts.

CONCLUSION

The results of this in vitro study demonstrated superior mechanical properties of cryopreserved grafts compared to frozen grafts within a preservation period of 9 months. Cryopreservation with glycerol solution might be used to further improve the quality of preserved soft-tissue allografts.

Real time cancer prediction based on objective tissue compliance measurement in endoscopic surgery

OBJECTIVE

To investigate the feasibility of real time cancer tissue diagnosis intraoperatively based on in vivo tissue compliance measurements obtained by a recently developed laparoscopic smart device.

BACKGROUND

Cancer tissue is stiffer than its normal counterpart. Modern forms of remote surgery such as laparoscopic and robotic surgical techniques diminish direct assessment of this important tissue property. In vivo human tissue compliance of the normal and cancer gastrointestinal tissue is unknown. A Clinical Real Time Tissue Compliance Mapping System (CRTCMS) with a predictive power comparable to the human hand and useable in routine surgical practice has been recently developed.

METHODS

The CRTCMS is employed in the operating theater to collect data from 50 patients undergoing intra-abdominal surgical interventions [40 men, 10 women, aged between 32 and 89 (mean = 66.4, range = 57)]. This includes 10 esophageal and 27 gastric cancer patients. A total of 1212 compliance measurements of normal and cancerous in vivo gastrointestinal tissues were taken. The data were used to calibrate the CRTCMS to predict cancerous tissue in a further 12 patients (3 cancer esophagus and 9 cancer stomach) involving 175 measurements.

RESULTS

The system demonstrated a high prediction power to diagnose cancer tissue in real time during routine surgical procedures (sensitivity = 98.7%, specificity = 99%). An in vivo human tissue compliance data bank of the gastrointestinal tract was produced.

CONCLUSIONS

Real time cancer diagnosis based on in vivo tissue compliance measurements is feasible. The reported data open new avenues in cancer diagnostics, surgical robotics, and development of more realistic surgical simulators.

The biomechanical effects of 1.0 to 1.2 Mrad of γ irradiation on human bone-patellar tendon-bone allografts

BACKGROUND

Recent data suggest that anterior cruciate ligament (ACL) reconstruction with irradiated allograft tissue may lead to increased failure rates.

HYPOTHESIS

Low-dose (1.0-1.2 Mrad) gamma irradiation does not significantly alter the preimplantation biomechanical properties of bone-patellar tendon-bone (BTB) allografts.

STUDY DESIGN

Controlled laboratory study.

METHODS

Cyclic and failure mechanical properties were evaluated for 20 paired central-third human BTB allografts, with and without 1.0 to 1.2 Mrad of gamma irradiation. Testing included cyclic loading at 0.5 Hz for 100 cycles from 50 to 200 N and failure testing at a strain rate of 10% per second.

RESULTS

Cyclic elongation did not change significantly (P = .151) with irradiation, increasing from a mean ± SD of 9.4 ± 2.1 mm to 11.3 ± 3.4 mm. Cyclic creep strain approached a significant increase with irradiation (1.3% ± 0.8% to 2.6% ± 1.5%; P = .076). Failure testing was not affected with irradiation with regard to maximum load (1680 ± 417 mm to 1494 ± 435 mm), maximum stress (40.8 ± 10.6 MPa to 37.5 ± 15.7 MPa), elongation (7.85 ± 1.35 mm to 8.67 ± 2.05 mm), or strain at maximum stress (0.158 ± 0.03 to 0.175 ± 0.03). Graft stiffness significantly decreased by 20% with irradiation (278 ± 67 N/mm to 221 ± 50 N/mm; P = .035).

CONCLUSION

Low-dose (1.0-1.2 Mrad) gamma irradiation decreases BTB graft stiffness by 20%, but it does not affect other failure or cyclic parameters.

CLINICAL RELEVANCE

Aside from graft stiffness during load to failure testing, low-dose (1.0-1.2 Mrad) gamma irradiation of central-third human BTB allografts is not deleterious to preimplantation biomechanical properties.

Effect of donor age on patellar tendon allograft ACL reconstruction

Anterior cruciate ligament reconstruction with patellar tendon allograft tissue is a common orthopedic procedure. It is unknown what effect, if any, the donor age has on clinical outcomes. Biomechanical studies have shown the strength of cadaveric patellar tendon to be independent of age, but no clinical studies have evaluated patient outcomes related to this variable. The purpose of this study was to evaluate the effect of allograft donor age on clinical outcomes of patients undergoing allograft anterior cruciate ligament reconstruction with patellar tendon allograft. Case logs were reviewed to identify primary anterior cruciate ligament reconstruction with allograft patellar tendon by a single surgeon using a standard endoscopic transtibial technique with interference screw fixation. Revision and multiligamentous surgeries were excluded. Seventy-seven patients who met these criteria were identified. Allografts were fresh-frozen, aseptically harvested patellar tendons from a single tissue bank. The donor age was obtained. Clinical outcomes were obtained by contacting patients by telephone and retrospective chart review. Pre- and postoperative Lysholm and Tegner knee scores were used for comparison.Data from 75 patients with an average follow-up of 24 months were obtained. Average donor age was 44 years (range, 14-65 years), and average patient age was 37 years (range, 18-60 years). Statistical analysis of pre- and postoperative Lysholm scores demonstrated statistically significant improvement (P≤.001). Using donor age as a continuous variable, no effect was found on postoperative improvement in Lysholm score or Tegner score (P=.6).

Use of controlled low dose gamma irradiation to sterilize allograft tendons for ACL reconstruction: biomechanical and clinical perspective

As reviewed here, numerous biomechanical and clinical studies support the use of controlled, low temperature irradiation of allograft tendons, to provide both excellent clinical results and medical-device grade sterile allografts with minimal risk of disease transmission.

Inactivation of enveloped and non-enveloped viruses on seeded human tissues by gamma irradiation

Human tissue allografts are widely used in a variety of clinical applications with over 1.5 million implants annually in the US alone. Since the 1990s, most clinically available allografts have been disinfected to minimize risk of disease transmission. Additional safety assurance can be provided by terminal sterilization using low dose gamma irradiation. The impact of such irradiation processing at low temperatures on viruses was the subject of this study. In particular, both human tendon and cortical bone samples were seeded with a designed array of viruses and the ability of gamma irradiation to inactivate those viruses was tested. The irradiation exposures for the samples packed in dry ice were 11.6–12.9 kGy for tendon and 11.6–12.3 kGy for bone, respectively. The viruses, virus types, and log reductions on seeded tendon and bone tissue, respectively, were as follows: Human Immunodeficiency Virus (RNA, enveloped), >2.90 and >3.20; Porcine Parvovirus (DNA, non-enveloped), 1.90 and 1.58; Pseudorabies Virus (DNA, enveloped), 3.80 and 3.79; Bovine Viral Diarrhea Virus (RNA, enveloped), 2.57 and 4.56; and Hepatitis A Virus (RNA, non-enveloped), 2.54 and 2.49, respectively. While proper donor screening, aseptic technique, and current disinfection practices all help reduce the risk of viral transmission from human allograft tissues, data presented here indicate that terminal sterilization using a low temperature, low dose gamma irradiation process inactivates both enveloped and non-enveloped viruses containing either DNA or RNA, thus providing additional assurance of safety from viral transmission.

Anterior cruciate ligament allograft surgery: underreporting of graft source, graft processing, and donor age

BACKGROUND

There has been much controversy regarding the effects of sterilization techniques and graft history on the structural integrity of allograft ligaments used in reconstruction of the anterior cruciate ligament. The purpose of this review was to comprehensively examine anterior cruciate ligament allograft studies published in the last decade to evaluate the extent to which tissue source, tissue processing techniques, and donor age are reported.

METHODS

The authors reviewed 202 articles published from 1999 through November 2009, of which 68 retrospective, prospective, biomechanical, and histology studies evaluating 4689 allografts were included.

RESULTS

The majority of studies do not accurately report key elements of graft history including tissue bank, processing or sterilization technique, or donor age. Underreporting was particularly prominent in clinical studies as compared with basic science studies. Limited reporting of allograft processing, allograft source, and donor age raises serious questions regarding the generalizability of published studies of allograft tissue for anterior cruciate ligament reconstruction. Conclusion/

CLINICAL RELEVANCE

Orthopaedic surgeons who use allograft tissue must understand the tissue treatments being used (ie, preservation methods, chemical and sterilization processes) to best inform their patients regarding the risks, benefits, and long-term outcomes when such tissues are used. A complete understanding of the implanted tissue, as well as surgeon and recipient demographics, is necessary to ensure appropriate and predictable long-term outcomes.

Effect of donor age on bone mineral density in irradiated bone-patellar tendon-bone allografts of the anterior cruciate ligament

BACKGROUND

Allograft tissue remains a valuable alternative for anterior cruciate ligament reconstruction. No study to date has correlated the effect of donor age to bone mineral density (BMD) in a large series of irradiated bone-patellar tendon-bone (BPTB) allograft tissue. Hypothesis/

PURPOSE

The authors attempted to correlate donor age with BMD in a large group of BPTB allograft specimens treated with low-dose gamma irradiation (1.0-1.3 Mrad) collected over a 4-year period. They hypothesized there would be no effect of donor age on the BMD of irradiated BPTB allografts.

STUDY DESIGN

Descriptive laboratory study.

METHODS

A total of 110 BPTB allograft specimens from 44 male and 66 female donors with a mean age of 46 years (range, 21-58 years) were analyzed. Bone mineral density data were obtained from both the patellar and tibial bone plugs of the BPTB complex. Statistical analyses were conducted using linear regression for correlations and 2-tailed Student t tests for comparisons between groups.

RESULTS

The mean BMD of the patellar bone plug (0.471 g/cm(2)) was significantly greater than the mean BMD of the tibial bone plug (0.328 g/cm(2)) (P < .001). No correlation was identified between donor age and BMD for either the patella or tibial bone plugs (R(2) = .014 and .011, respectively). Both patellar and tibial BMD was significantly greater for the male grafts than the female ones.

CONCLUSION

No correlation was found between donor age and BMD for irradiated BPTB allograft tissue. The patellar bone plugs were noted to have a greater BMD than the tibial bone plugs. Allograft tissue from male donors had higher BMD values than that harvested from female donors.

Tension level during preconditioning influences hamstring tendon graft properties

BACKGROUND

Hamstring tendon grafts used for anterior cruciate ligament reconstruction are preconditioned to reduce the influence of viscoelasticity on the stiffness and tension.

HYPOTHESIS

Increasing the tension applied during preconditioning will decrease the loss of tension and stiffness due to viscoelasticity.

STUDY DESIGN

Controlled laboratory study.

METHODS

Six quadruple-strand hamstring tendon grafts were tested twice in vitro with 2 tension levels applied during preconditioning. The grafts were preconditioned at 80 N or 160 N, followed by 15 minutes of relaxation, and subsequently loaded to 80 N to represent application of initial tension. After 5 minutes of relaxation, the tension was recorded and the stiffness was measured over 0.06 mm of displacement. The tension and stiffness measurements were repeated 3 hours later. The data were compared between the 2 preconditioning levels with a 2-way repeated-measures analysis of variance.

RESULTS

Graft tension and stiffness were significantly larger (P < .05) for 160 N during preconditioning. For 80 N, the average tension at 5 minutes and 3 hours was 40 N and 21 N, respectively, compared with 50 N and 30 N, respectively, for 160 N. For 80 N, the average stiffness at 5 minutes and 3 hours was 152 N/mm and 124 N/mm, respectively, compared with 173 N/mm and 146 N/mm, respectively, for 160 N.

CONCLUSION

Increasing the tension applied to hamstring tendon grafts during preconditioning can decrease the postoperative loss of tension and stiffness due to viscoelasticity.

CLINICAL RELEVANCE

The increased graft tension and stiffness could reduce postoperative knee laxity.