Engineering of Trichoderma reesei for enhanced degradation of lignocellulosic biomass by truncation of the cellulase activator ACE3

Enhanced glucose-1-phosphate production from corn stover using cellulases with reduced β-glucosidase activity via Trbgl1 gene knockout in Trichoderma reesei Rut C30

The scarcity of cellulases with low β-glucosidase activity poses a significant technological challenge in precisely controlling the partial hydrolysis of lignocellulose to cellobiose, crucial for producing high-value chemicals such as starch, inositol, and NMN. Trichoderma reesei is a primary strain in cellulase production. Therefore, this study targeted the critical β-glucosidase gene, Trbgl1, resulting in over an 86 % reduction in β-glucosidase activity. However, cellulase production decreased by 19.2 % and 20.3 % with lactose or cellulose inducers, respectively. Notably, transcript levels of cellulase genes and overall yield remained unaffected with an inducer containing sophorose. This indicates that β-glucosidase BGL1 converts lactose or cellulose to sophorose through transglycosylation activity, inducing cellulase gene transcription. The resulting enzyme cocktail, comprising recombinant cellulase and cellobiose phosphorylase, was applied for corn stover hydrolysis, resulting in a 24.3 % increase in glucose-1-phosphate yield. These findings provide valuable insights into obtaining enzymes suitable for the high-value utilization of lignocellulose.

Co-production of sugars and aroma compounds from tobacco waste using biomass-degrading enzymes produced by Aspergillus brunneoviolaceus Ab-10

Biomass-degrading enzymes produced by microorganisms have a great potential in the processing of agricultural wastes. In order to produce suitable biomass-degrading enzymes for releasing sugars and aroma compounds from tobacco scraps, the feasibility of directly using the scraps as a carbon source for enzyme production was investigated in this study. By comparative studies of ten fungal strains isolated from tobacco leaves, Aspergillus brunneoviolaceus Ab-10 was found to produce an efficient enzyme mixture for the saccharification of tobacco scraps. Proteomic analysis identified a set of plant biomass-degrading enzymes in the enzyme mixture, including amylases, hemicellulases, cellulases and pectinases. At a substrate concentration of 100 g/L and enzyme dosage of 4 mg/g, glucose of 17.6 g/L was produced from tobacco scraps using the crude enzyme produced by A. brunneoviolaceus Ab-10. In addition, the contents of 23 volatile molecules, including the aroma compounds 4-ketoisophorone and benzyl alcohol, were significantly increased after the enzymatic treatment. The results provide a strategy for valorization of tobacco waste by integrating the production of biomass-degrading enzymes into the tobacco scrap processing system.

Every road leads to Rome: diverse biosynthetic regulation of plant cell wall-degrading enzymes in filamentous fungi Penicillium oxalicum and Trichoderma reesei

Cellulases and xylanases are plant cell wall-degrading enzymes (CWDEs) that are critical to sustainable bioproduction based on renewable lignocellulosic biomass to reduce carbon dioxide emission. Currently, these enzymes are mainly produced from filamentous fungi, especially Trichoderma reesei and Penicillium oxalicum. However, an in-depth comparison of these two producers has not been performed. Although both P. oxalicum and T. reesei harbor CWDE systems, they exhibit distinct features regulating the production of these enzymes, mainly through different transcriptional regulatory networks. This review presents the strikingly different modes of genome-wide regulation of cellulase and xylanase biosynthesis in P. oxalicum and T. reesei, including sugar transporters, signal transduction cascades, transcription factors, chromatin remodeling, and three-dimensional organization of chromosomes. In addition, different molecular breeding approaches employed, based on the understanding of the regulatory networks, are summarized. This review highlights the existence of very different regulatory modes leading to the efficient regulation of CWDE production in filamentous fungi, akin to the adage that "every road leads to Rome." An understanding of this divergence may help further improvements in fungal enzyme production through the metabolic engineering and synthetic biology of certain fungal species.

Engineering the metabolism and morphology of the filamentous fungus Trichoderma reesei for efficient L-malic acid production

L-malic acid (MA) is a vital platform chemical with huge market demand because of its broad industrial applications. A cell factory for MA production was engineered by strengthening the intrinsic pathway without inserting foreign genes into Trichoderma reesei. The native MA transporter gene in the T. reesei genome was characterized (trmae1), and its overexpression significantly improved MA production, which increased from 2 to 56.24 g/L. Native pyruvate carboxylase, malate dehydrogenase, malic enzyme, and glucose transporter were overexpressed further to improve the titer and yield of MA production. Fungal morphology was adapted to produce MA in the fermenter by deleting gul1. A titer of 235.8 g/L MA was produced from the final engineered strain in a 5-L fermenter with a yield of 1.48 mol of MA per mol of glucose and productivity of 1.23 g/L/h. This study provides novel insights for understanding and remodeling the MA synthesis pathway.

Fungal strain improvement for efficient cellulase production and lignocellulosic biorefinery: Current status and future prospects

Lignocellulosic biomass (LCB) has been recognized as a valuable carbon source for the sustainable production of biofuels and value-added biochemicals. Crude enzymes produced by fungal cell factories benefit economic LCB degradation. However, high enzyme production cost remains a great challenge. Filamentous fungi have been widely used to produce cellulolytic enzymes. Metabolic engineering of fungi contributes to efficient cellulase production for LCB biorefinery. Here the latest progress in utilizing fungal cell factories for cellulase production was summarized, including developing genome engineering tools to improve the efficiency of fungal cell factories, manipulating promoters, and modulating transcription factors. Multi-omics analysis of fungi contributes to identifying novel genetic elements for enhancing cellulase production. Furthermore, the importance of translation regulation of cellulase production are emphasized. Efficient development of fungal cell factories based on integrative strain engineering would benefit the overall bioconversion efficacy of LCB for sustainable bioproduction.

The Ras small GTPase RSR1 regulates cellulase production in Trichoderma reesei

BACKGROUND

Lignocellulose is the most abundant renewable resource in the world and has attracted widespread attention. It can be hydrolyzed into sugars with the help of cellulases and hemicellulases that are secreted by filamentous fungi. Several studies have revealed that the Ras small GTPase superfamily regulates important cellular physiological processes, including synthesis of metabolites, sporulation, and cell growth and differentiation. However, it remains unknown how and to what extent Ras small GTPases participate in cellulase production.

RESULTS

In this study, we found that the putative Ras small GTPase RSR1 negatively regulated the expression of cellulases and xylanases. Deletion of rsr1 (∆rsr1) significantly increased cellulase production and decreased the expression levels of ACY1-cAMP-protein kinase A (PKA) signaling pathway genes and the concentration of intracellular cyclic adenosine monophosphate (cAMP). Loss of acy1 based on ∆rsr1 (∆rsr1∆acy1) could further increase cellulase production and the expression levels of cellulase genes, while overexpression of acy1 based on ∆rsr1 (∆rsr1-OEacy1) significantly reduced cellulase production and transcriptional levels of cellulase genes. In addition, our results revealed that RSR1 negatively controlled cellulase production via the ACY1-cAMP-PKA pathway. Transcriptome analysis revealed significantly increased expression of three G-protein coupled receptors (GPCRs; tre62462, tre58767, and tre53238) and approximately two-fold higher expression of ACE3 and XYR1, which transcriptionally activated cellulases with the loss of rsr1. ∆rsr1∆ tre62462 exhibited a decrease in cellulase activity compared to ∆rsr1, while that of ∆rsr1∆tre58767 and ∆rsr1∆tre53238 showed a remarkable improvement compared to ∆rsr1. These findings revealed that GPCRs on the membrane may sense extracellular signals and transmit them to rsr1 and then to ACY1-cAMP-PKA, thereby negatively controlling the expression of the cellulase activators ACE3 and XYR1. These data indicate the crucial role of Ras small GTPases in regulating cellulase gene expression.

CONCLUSIONS

Here, we demonstrate that some GPCRs and Ras small GTPases play key roles in the regulation of cellulase genes in Trichoderma reesei. Understanding the roles of these components in the regulation of cellulase gene transcription and the signaling processes in T. reesei can lay the groundwork for understanding and transforming other filamentous fungi.

Current genetic strategies to investigate gene functions in Trichoderma reesei

The filamentous fungus Trichoderma reesei (teleomorph Hypocrea jecorina, Ascomycota) is a well-known lignocellulolytic enzymes-producing strain in industry. To increase the fermentation titer of lignocellulolytic enzymes, random mutagenesis and rational genetic engineering in T. reesei were carried out since it was initially found in the Solomon Islands during the Second World War. Especially the continuous exploration of the underlying regulatory network during (hemi)cellulase gene expression in the post-genome era provided various strategies to develop an efficient fungal cell factory for these enzymes' production. Meanwhile, T. reesei emerges competitiveness potential as a filamentous fungal chassis to produce proteins from other species (e.g., human albumin and interferon α-2b, SARS-CoV-2 N antigen) in virtue of the excellent expression and secretion system acquired during the studies about (hemi)cellulase production. However, all the achievements in high yield of (hemi)cellulases are impossible to finish without high-efficiency genetic strategies to analyze the proper functions of those genes involved in (hemi)cellulase gene expression or secretion. Here, we in detail summarize the current strategies employed to investigate gene functions in T. reesei. These strategies are supposed to be beneficial for extending the potential of T. reesei in prospective strain engineering.

Simultaneous Production of Cellulase and β-Carotene in the Filamentous Fungus Trichoderma reesei

β-Carotene is an indispensable additive in beverage, cosmetic, feed, and pharmaceutical production. The fermentation industry annually generates abundant waste mycelia from Trichoderma reesei (T. reesei), a pivotal industrial strain for cellulase and heterologous protein production. In this study, we constructed a T. reesei cell factory for β-carotene production for the first time. Four key enzymes, CarRP, CarB, GGS1/CrtE, and HMG1, were overexpressed in T. reesei. The concentrations of medium components, including tryptone and glucose, were optimized. The modified strain accumulated β-carotene at a titer of 218.8 mg/L in flask culture. We achieved cellulase production (FPase, 22.33 IU/mL) with the concomitant production of β-carotene (286.63 mg/L) from T. reesei in a jar. Overall, this study offers a novel and unique approach to address the costly waste mycelium management process using T. reesei industrial strains that simultaneously produce proteins and carotenoids.

Metabolic Engineering of Trichoderma reesei for l-Malic Acid Production

l-Malic acid has various applications in the chemical and food industries. The filamentous fungus Trichoderma reesei is known to be an efficient enzyme producer. Here, through metabolic engineering, T. reesei was constructed for the first time as an excellent cell factory for l-malic acid production. The heterologous overexpression of genes encoding the C4-dicarboxylate transporter from Aspergillus oryzae and Schizosaccharomyces pombe initiated l-malic acid production. The overexpression of pyruvate carboxylase from A. oryzae in the reductive tricarboxylic acid pathway further increased both the titer and yield of l-malic acid, resulting in the highest titer reported in a shake-flask culture. Furthermore, the deletion of malate thiokinase blocked l-malic acid degradation. Finally, the engineered T. reesei strain produced 220.5 g/L of l-malic acid in a 5 L fed-batch culture (productivity of 1.15 g/L/h). A T. reesei cell factory was created for the efficient production of l-malic acid.

Bioconversion of corn fiber to bioethanol: Status and perspectives

Due to the rising demand for green energy, bioethanol has attracted increasing attention from academia and industry. Limited by the bottleneck of bioethanol yield in traditional corn starch dry milling processes, an increasing number of studies focus on fully utilizing all corn ingredients, especially kernel fiber, to further improve the bioethanol yield. This mini-review addresses the technological challenges and opportunities on the way to achieving the efficient conversion of corn fiber. Significant advances during the review period include the detailed characterization of different forms of corn kernel fiber and the development of off-line and in-situ conversion strategies. Lessons from cellulosic ethanol technologies offer new ways to utilize corn fiber in traditional processes. However, the commercialization of corn kernel fiber conversion may be hampered by enzyme cost, conversion efficiency, and overall process economics. Thus, future studies should address these technical limitations.

Engineering Trichoderma reesei for the hyperproduction of cellulose induced protein 1 (Cip1) on a sophorose-containing inducer to efficiently saccharify alkali-pretreated corn stover

Trichoderma reesei was induced to produce cellulase by a combination of glucose and β-disaccharide; however, lower levels of auxiliary proteins for degrading lignocellulosic biomass were detected by iTRAQ analysis compared with cellulose as an inducer, especially cellulose induced protein 1 (CIP1). In this study, A pdc1 promoter-driven overexpression of the endogenous Trcip1 gene was observed in T. reesei Rut C30, and the Trcip1 transcription levels of the two transformants, T. reesei OE-cip1-1 and OE-cip1-2, demonstrated 31.2- and 164.6-fold increases, respectively, but there was no significant change in cellobiohydrolase, endoglucanase and filter paper activity at 48 h. The crude enzyme was then used to hydrolyze corn stover. For T. reesei OE-cip1-1 and OE-cip1-2, the hydrolysis efficiency increased by 25.0 and 28.6% with a solid loading of 5% at 2 h, respectively. Simultaneously, 85.5 and 85.2 g/L glucose were released using a cellulase cocktail at high solid loading (20%), and these glucose release rates were significantly greater than that of T. reesei Rut C30 cellulase (77.4 g/L) at 120 h. Furthermore, scanning electron microscopy (SEM) and X-ray diffraction (XRD) showed that the enhanced hydrolysis efficiency was primarily triggered by the decrease in the crystallinity of lignocellulose, and the fiber structure had varying degrees of loosening and disintegration.

A three-gene cluster in Trichoderma reesei reveals a potential role of dmm2 in DNA repair and cellulase production

Background

The ascomycete Trichoderma reesei is one of the most efficient industrial producers of cellulase. Gene targeting by homologous recombination is a key technique for improving strains and constructing mutants. In T. reesei, tku70 (homologous to human KU70) was deleted to block non-homologous end-joining, which led to 95% of transformants exhibiting homologous recombination.

Results

Two genes located in close proximity to tku70 were identified: the ferrochelatase gene hem8 (tre78582, homologous to Aspergillus niger hemH and Cryptococcus neoformans HEM15) and a putative DNA methylation modulator-2 gene dmm2 (tre108087, homologous to Neurospora crassa dmm-2). Genome-wide surveys of 324 sequenced fungal genomes revealed that the homologues of the three genes of interest are encoded in tandem in most Sordariomycetes. The expression of this three-gene cluster is regulated by blue light. The roles of these three genes were analyzed via deletion and complementation tests. The gene hem8 was originally described as a novel and highly distinct auxotrophic marker in T. reesei and we found that the product protein, HEM8, catalyzes the final step in heme biosynthesis from highly photoreactive porphyrins. The lethal phenotype of the hem8 deletion could be overcome by hematin supplementation. We also studied the functions of tku70 and dmm2 in DNA repair using mutagen sensitivity experiments. We found that the Δtku70 strain showed increased sensitivity to bleomycin, which induces DNA double-strand breaks, and that the Δdmm2 strain was sensitive to bleomycin, camptothecin (an inhibitor of type I topoisomerases), and hydroxyurea (a deoxynucleotide synthesis inhibitor). The double-mutant Δtku70&dmm2 showed higher sensitivity to hydroxyurea, camptothecin, and bleomycin than either of the single mutants. Knockout of dmm2 significantly increased cellulase production.

Conclusions

Our data show, for the first time, that ferrochelatase encoded by hem8 catalyzes the final step in heme biosynthesis from highly photoreactive porphyrins and that dmm2 encodes a putative DNA methylation modulator-2 protein related to DNA repair and cellulase expression in T. reesei. Our data provide important insights into the roles of this three-gene cluster in T. reesei and other Sordariomycetes and show that the DNA methylation modulator DMM2 affects cellulase gene expression in T. reesei.

Supplementary Information

The online version contains supplementary material available at 10.1186/s13068-022-02132-y.

Agro waste as a potential carbon feedstock for poly-3-hydroxy alkanoates production: Commercialization potential and technical hurdles

The enormous production and widespread applications of non -biodegradable plastics lead to their accumulation and toxicity to animals and humans. The issue can be addressed by the development of eco-friendly strategies for the production of biopolymers by utilization of waste residues like agro residues. This will address two societal issues - waste management and the development of an eco-friendly biopolymer, poly-3-hydroxy alkanoates (PHAs). Strategies adopted for utilization of agro-residues, challenges and future perspectives are discussed in detail in this comprehensive review. The possibility of PHA properties improvements can be increased by preparation of blends.

Understanding of promoting enzymatic hydrolysis of combined hydrothermal and deep eutectic solvent pretreated poplars by Tween 80

In this study, lignin blockers including non-catalytic protein and surfactants were employed to promote enzymatic digestibility of pretreated poplars. Among them, Tween 80 exhibited the most pronounced facilitation, improving the glucose yield from 26.6% to 99.6% at a low enzyme loading (10 FPU/g glucan), and readily reduced the required cellulase loading by 75%. The underlying mechanism for this remarkable improvement on glucose yields by Tween 80 was elucidated. The impacts of Tween 80 on the enzyme-lignin interaction were explored by quartz crystal microbalance analysis, revealing that the binding rate of Tween 80 on lignin surfaces was 3-fold higher than that of enzyme. More importantly, Tween 80 remarkably decreased the binding capacity and binding rate of enzyme on lignins. Furthermore, the substrate properties dominating the increase in glucose yields with Tween 80 were explored. The results facilitate to understand the underlying mechanism of the promotion of surfactants on enzymatic hydrolysis.

Induction of cellulase production in Trichoderma reesei by a glucose-sophorose mixture as an inducer prepared using stevioside

Sophorose is currently the most effective inducer of cellulase production by Trichoderma reesei; however, the use of byproduct sophorose from the stevioside acid hydrolysis process has not been developed. In this study, stevioside was hydrolysed with different concentrations of HCl to obtain isosteviol and a mixture of glucose and sophorose (MGS). Isosteviol showed good inhibitory effects on the growth of Aspergillus niger, Saccharomyces cerevisiae and Escherichia coli after separation. At the same time, MGS, as a byproduct, was evaluated for cellulase production to determine the feasibility of this approach. MGS was compared with common soluble inducers, such as lactose, cellobiose, and a mixture of glucose and β-disaccharide (MGD), and induced higher cellulase production than the other inducers. The cellulase activity induced by MGS was 1.64- and 5.26-fold higher than that induced by lactose and cellobiose, respectively, and was not significantly different from that induced by MGD. The crude enzyme using MGS as an inducer with commercial β-glucosidase was further tested by hydrolyzing NaOH-pretreated corn stover with 5% solid loading, and 33.4 g L-1 glucose was released with a glucose yield of 96.04%. The strategy developed in this work will be beneficial for reducing inducer production cost through a simple stevia glycoside hydrolysis reaction and will contribute to studies aimed at improving cellulase production using soluble inducers for easier operation in industrial-scale cellulase production.

Regulation of β-Disaccharide Accumulation by β-Glucosidase Inhibitors to Enhance Cellulase Production in Trichoderma reesei

Trichoderma reesei is a high-yield producer of cellulase for applications in lignocellulosic biomass conversion, but its cellulase production requires induction. A mixture of glucose and β-disaccharide has been demonstrated to achieve high-level cellulase production. However, as inducers, β-disaccharides are prone to be hydrolyzed by β-glucosidase (BGL) during fermentation, therefore β-disaccharides need to be supplemented through feeding to overcome this problem. Here, miglitol, an α-glucosidase inhibitor, was investigated as a BGL inhibitor, and exhibited an IC50 value of 2.93 μg/mL. The cellulase titer was more than two-fold when miglitol was added to the fermentation medium of T. reesei. This method was similar to the prokaryotic expression system using unmetabolized isopropyl-β-D-thiogalactopyranoside (IPTG) as the inducer instead of lactose to continuously induce gene expression. However, cellulase activity was not enhanced with BGL inhibition when lactose or cellulose was used as an inducer, which demonstrated that the transglycosidase activity of BGL is important for the inducible activity of lactose and cellulose. This novel method demonstrates potential in stimulating cellulase production and provides a promising system for T. reesei protein expression.

Morphologically favorable mutant of Trichoderma reesei for low viscosity cellulase production

Metabolite production by filamentous fungi hampered because of high viscosity generated during growth. Low viscosity fermentation by mold is one of the preferred ways of large scale enzymes production. Cellulolytic enzymes play a key role during the process of lignocellulosic biomass conversion. In this study a mutant RC-23-1 was isolated through mutagenesis (diethyl sulfate followed by UV) of T. reesei RUT-C30. RC-23-1 not only gave higher cellulase production but also generated lower viscosity during enzyme production. Viscosity of mutant growth was more than three times lower than parent strain. RC-23-1 shows unique, yeast like colony morphology on solid media and small pellet like growth in liquid media. This mutant did not spread like mold on solid media. This mutant produces cellulases constitutively when grown in sugars. Using only glucose, the cellulase production was 4.1 FPU/ml. Among polysaccharides (avicel, xylan and pectin), avicel gave maximum of 6.2 FPU/ml and pretreated biomass (rice straw, wheat straw and sugarcane bagasse) produced 5.1-5.8 FPU/ml. At 7L scale reactor, fed-batch process was designed for cellulase production using different carbon and nitrogen sources. Maximum yield of cellulases was 182 FPU/g of lactose consumed was observed in fed-batch process. The produced enzyme used for hydrolysis of acid pretreated rice straw (20% solid loading) and maximum of 60 % glucan conversion was observed. RC-23-1 mutant is good candidate for large scale cellulase production and could be a model strain to study mold to yeast-like transformation. This article is protected by copyright. All rights reserved.

The enzyme interactome concept in filamentous fungi linked to biomass valorization

Biomass represents an abundant and inexpensive source of sugars and aromatic compounds that can be used as raw materials for conversion into value-added bioproducts. Filamentous fungi are sources of plant cell wall degrading enzymes in nature. Understanding the interactions between enzymes is crucial for optimizing biomass degradation processes. Herein, the concept of the interactome is presented as a holistic approach that depicts the interactions among enzymes, substrates, metabolites, and inhibitors. The interactome encompasses several stages of biomass degradation, starting with the sensing of the substrate and the subsequent synthesis of hydrolytic and oxidative enzymes (fungus-substrate interaction). Enzyme-enzyme interactions are exemplified in the complex processes of lignocellulosic biomass degradation. The enzyme-substrate-metabolite-inhibitor interaction also provides a better understanding of biomass conversion, allowing bioproduct production from recalcitrant agro-industrial residues, thus bringing greater value to residual biomass. Finally, technological applications are presented for optimizing the interactome at various levels.

Trichoderma reesei ACE4, a Novel Transcriptional Activator Involved in the Regulation of Cellulase Genes during Growth on Cellulose

The filamentous fungus Trichoderma reesei is a model strain for cellulase production. Cellulase gene expression in T. reesei is controlled by multiple transcription factors. Here, we identified by comparative genomic screening a novel transcriptional activator, ACE4 (activator of cellulase expression 4), that positively regulates cellulase gene expression on cellulose in T. reesei. Disruption of the ace4 gene significantly decreased expression of four main cellulase genes and the essential cellulase transcription factor-encoding gene ace3. Overexpression of ace4 increased cellulase production by approximately 22% compared to that in the parental strain. Further investigations using electrophoretic mobility shift assays, DNase I footprinting assays, and chromatin immunoprecipitation assays indicated that ACE4 directly binds to the promoter of cellulase genes by recognizing the two adjacent 5'-GGCC-3' sequences. Additionally, ACE4 directly binds to the promoter of ace3 and, in turn, regulates the expression of ACE3 to facilitate cellulase production. Collectively, these results demonstrate an important role for ACE4 in regulating cellulase gene expression, which will contribute to understanding the mechanism underlying cellulase expression in T. reesei. IMPORTANCE T. reesei is commonly utilized in industry to produce cellulases, enzymes that degrade lignocellulosic biomass for the production of bioethanol and bio-based products. T. reesei is capable of rapidly initiating the biosynthesis of cellulases in the presence of cellulose, which has made it useful as a model fungus for studying gene expression in eukaryotes. Cellulase gene expression is controlled through multiple transcription factors at the transcriptional level. However, the molecular mechanisms by which transcription is controlled remain unclear. In the present study, we identified a novel transcription factor, ACE4, which regulates cellulase expression on cellulose by binding to the promoters of cellulase genes and the cellulase activator gene ace3. Our study not only expands the general functional understanding of the novel transcription factor ACE4 but also provides evidence for the regulatory mechanism mediating gene expression in T. reesei.

Comparative transcriptome analysis of Trichoderma reesei reveals different gene regulatory networks induced by synthetic mixtures of glucose and β-disaccharide

The mixture of glucose and β-disaccharide (MGD) synthesized by transglycosylation of glucose as a low-cost soluble carbon source can efficiently induce cellulase production in Trichoderma reesei, which holds potential for the biorefining of lignocellulosic biomass. However, it is not yet fully understood how MGD induces T. reesei cellulase. In this study, transcriptomic analyses were conducted to investigate the molecular basis of MGD for lignocellulose-degrading enzyme production of T. reesei Rut C30 compared with that on lactose. Particular attention was paid to CAZymes, transcription factors, transporters and other protein processing pathways related to lignocellulose degradation. As a result, MGD can elicit transcription of GH5-, GH6- and GH7-encoding cellulases that is up to 1.4-fold higher than that induced by lactose, but GH11- and GH74-encoding xylanases are downregulated by 1.7- and 4.4-fold, respectively. Gene expression profiles suggest that the transcription activators xyr1 and vib1 are significantly upregulated and that the mitogen-activated protein kinase pathway is strengthened compared to the case of lactose induction. In addition, hac1-encoding UPR-specific transcription factors are significantly upregulated by MGD, which may be enhanced due to proper folding and processing of nascent proteins. These findings provide a theoretical basis for further understanding the characterization of efficient cellulase production using MGD as an inducer in T. reesei and offer potential strategies for strain improvement.

An overview of Trichoderma reesei co-cultures for the production of lignocellulolytic enzymes

Biorefineries are core facilities for implementing a sustainable circular bioeconomy. These facilities rely on microbial enzymes to hydrolyze lignocellulosic substrates into fermentable sugars. Fungal co-cultures mimic the process of natural biodegradation and have been shown to increase certain enzyme activities. Trichoderma reesei and its many mutant strains are major cellulase producers and are heavily utilized as a source of carbohydrate-active enzymes. Several reports have demonstrated that T. reesei co-cultures present higher enzyme activities compared with its monocultures, especially in the context of β-glucosidase activity. The performance of T. reesei during co-culturing has been assessed with several fungal partners, including Aspergillus niger, one of the most recurrent partners. Various aspects of co-cultivation still need further investigation, especially regarding the molecular interactions between fungi in controlled environments and the optimization of the resulting enzyme cocktails. Since plenty of genetic and physiological data on T. reesei is available, the species is an outstanding candidate for future co-culture investigations. Co-cultures are still a developing field for industrial enzyme production, and many aspects of the technique need further improvement before real applications. KEY POINTS: • T. reesei co-cultures are an alternative for producing lignocellulolytic enzymes. • Several reports suggest an increase in certain enzyme activities in co-cultures. • More in-depth investigations of co-cultures are necessary for advancing this field.

Effects of the Transcription Factor Ace2 from Trichoderma reesei on Cellulase and Hemicellulase Expression in Trichoderma orientalis EU7-22

Trichoderma orientalis (T. orientalis) EU7-22 has a complete cellulase system and shows a remarkable enzyme activity with high potential in the industry. Ace2 is an important transcriptional factor for cellulase and hemicellulase expression in Trichoderma reesei (T. reesei). However, the ace2 gene cannot be found in the genome of T. orientalis. Researches show that the mechanism of cellulase transcriptional regulation in T. orientalis keeps high similarity with T. reesei up till now. So, in this study, the ace2 of Trichoderma reesei QM9414 was heterologous expressed in T. orientalis EU7-22. As a result, xylanase activity and β-glucosidase activity of ace2 heterogeneous expression strains are improved and total cellulase activity is decreased. The result of qPCR is in accordance with enzyme activities. This study provides a reference for an in-depth study on transcriptional regulation mechanisms of T. orientalis.

Estimation of glucosamine in biomass of Trichoderma reesei cultivated on lignocellulosic substrates

Effects of the compositions of lignocellulosic substrate including hemicellulose, cellulose, lignin, and protein on the glucosamine content in biomass of Trichoderma reesei TISTR3080 were studied. A synthetic solid surface media containing different ratios of xylan (hemicellulose), carboxymethyl cellulose (cellulose), lignin, and various concentrations of yeast extract (source of protein) were used to cultivated T. reesei. Regression analysis identified significant individual and interaction factors that affected glucosamine quantity in T. reesei biomass. A regression model was developed to estimate the glucosamine content in biomass of T. reesei from the compositions of the lignocellulosic substrate. An acceptable error (not more than 10%) of the regression model was obtained from validation with the experimental results of glucosamine content in biomass of T. reesei cultivated on lignocellulosic solid surface media made from copra waste and banana peel.

Penicillium janthinellum NCIM1366 shows improved biomass hydrolysis and a larger number of CAZymes with higher induction levels over Trichoderma reesei RUT-C30

BACKGROUND

Major cost of bioethanol is attributed to enzymes employed in biomass hydrolysis. Biomass hydrolyzing enzymes are predominantly produced from the hyper-cellulolytic mutant filamentous fungus Trichoderma reesei RUT-C30. Several decades of research have failed to provide an industrial grade organism other than T. reesei, capable of producing higher titers of an effective synergistic biomass hydrolyzing enzyme cocktail. Penicillium janthinellum NCIM1366 was reported as a cellulase hyper producer and a potential alternative to T. reesei, but a comparison of their hydrolytic performance was seldom attempted.

RESULTS

Hydrolysis of acid or alkali-pretreated rice straw using cellulase enzyme preparations from P. janthinellum and T. reesei indicated 37 and 43% higher glucose release, respectively, with P. janthinellum enzymes. A comparison of these fungi with respect to their secreted enzymes indicated that the crude enzyme preparation from P. janthinellum showed 28% higher overall cellulase activity. It also had an exceptional tenfold higher beta-glucosidase activity compared to that of T. reesei, leading to a lower cellobiose accumulation and thus alleviating the feedback inhibition. P. janthinellum secreted more number of proteins to the extracellular medium whose total concentration was 1.8-fold higher than T. reesei. Secretome analyses of the two fungi revealed higher number of CAZymes and a higher relative abundance of cellulases upon cellulose induction in the fungus.

CONCLUSIONS

The results revealed the ability of P. janthinellum for efficient biomass degradation through hyper cellulase production, and it outperformed the established industrial cellulase producer T. reesei in the hydrolysis experiments. A higher level of induction, larger number of secreted CAZymes and a high relative proportion of BGL to cellulases indicate the possible reasons for its performance advantage in biomass hydrolysis.

Modification of transcriptional factor ACE3 enhances protein production in Trichoderma reesei in the absence of cellulase gene inducer

BACKGROUND

Trichoderma reesei is one of the best-known cellulolytic organisms, producing large quantities of a complete set of extracellular cellulases and hemicellulases for the degradation of lignocellulosic substances. Hence, T. reesei is a biotechnically important host and it is used commercially in enzyme production, of both native and foreign origin. Many strategies for producing enzymes in T. reesei rely on the cbh1 and other cellulase gene promoters for high-level expression and these promoters require induction by sophorose, lactose or other inducers for high productivity during manufacturing.

RESULTS

We described an approach for producing high levels of secreted proteins by overexpression of a transcription factor ACE3 in T. reesei. We refined the ace3 gene structure and identified specific ACE3 variants that enable production of secreted cellulases and hemicellulases on glucose as a sole carbon source (i.e., in the absence of an inducer). These specific ACE3 variants contain a full-length Zn₂Cys₆ binuclear cluster domain at the N-terminus and a defined length of truncations at the C-terminus. When expressed at a moderate level in the fungal cells, the ACE3 variants can induce high-level expression of cellulases and hemicellulases on glucose (i.e., in the absence of an inducer), and further improve expression on lactose or glucose/sophorose (i.e., in the presence of an inducer). Finally, we demonstrated that this method is applicable to industrial strains and fermentation conditions, improving protein production both in the absence and in the presence of an inducer.

CONCLUSIONS

This study demonstrates that overexpression of ACE3 variants enables a high level of protein production in the absence of an inducer, and boosts protein production in the presence of an inducer. It is an efficient approach to increase protein productivity and to reduce manufacturing costs.

Regulating Strategies for Producing Carbohydrate Active Enzymes by Filamentous Fungal Cell Factories

Filamentous fungi are important eukaryotic organisms crucial in substrate degradation and carbon cycle on the earth and have been harnessed as cell factories for the production of proteins and other high value-added products in recent decades. As cell factories, filamentous fungi play a crucial role in industrial protein production as both native hosts and heterologous hosts. In this review, the regulation strategies of carbohydrate active enzyme expression at both transcription level and protein level are introduced, and the transcription regulations are highlighted with induction mechanism, signaling pathway, and promoter and transcription factor regulation. Afterward, the regulation strategies in protein level including suitable posttranslational modification, protein secretion enhancement, and protease reduction are also presented. Finally, the challenges and perspectives in this field are discussed. In this way, a comprehensive knowledge regarding carbohydrate active enzyme production regulation at both transcriptional and protein levels is provided with the particular goal of aiding in the practical application of filamentous fungi for industrial protein production.