Impact of diet, moisture, location, and storage on soluble phosphorus in broiler breeder manure

High levels of contact dermatitis and decreased mobility in broiler breeders, but neither have a relationship with floor eggs

Contact dermatitis, both on the foot pads and hocks, is a well-known health issue in broilers. Less is known about contact dermatitis in broiler breeders, however, although they have many risk factors for developing leg health problems in common with broilers. This study aimed to describe the prevalence and severity of contact dermatitis during the production cycle in 5 lines of broiler breeders, investigate possible causes of contact dermatitis, and study its relationship with gait, egg production, and floor egg percentage. Five commercially available genetic lines of broiler breeders were housed in 21 pens of 550 females and 50 males from 20 to 60 wk of age. Every 10 wk litter quality, leg health measurements (foot pad dermatitis, hock burn, and gait) and body weight were assessed of 50 random hens per pen. Total number of eggs, number of eggs laid outside the nest (floor eggs), and mortality were recorded daily per pen. Prevalence of foot pad dermatitis, hock burn, and gait problems increased with age. Litter quality started to decrease at 50 wk of age. Prevalence of foot pad dermatitis was affected by litter quality, whereas genetic line had little effect. One genetic line was more prone to developing hock burns, though generally the prevalence of hock burn (13%) was much lower than that of foot pad dermatitis (74%). The percentage of broiler breeders with gait problems increased up to 24% with age, but this was not related to the prevalence of contact dermatitis. The lines differed in body weight from 32 wk of age onwards, and a higher body weight was related to lower egg production and higher cumulative mortality. The percentage of floor eggs was not related to leg health parameters or genetic line. Broiler breeders thus have similar leg health problems as broilers, but these problems are not related to the percentage of floor eggs, suggesting that other factors are involved in the undesirable behavior of floor laying.

Formations of hydroxyapatite and inositol hexakisphosphate in poultry litter during the composting period: sequential fractionation, P K-edge XANES and solution (31)P NMR investigations

Little is known about how the solubility and chemical speciation of phosphorus (P) in poultry litters are altered during the composting period. This study investigated the quantitative and qualitative changes in organic P (Po) and inorganic P (Pi) compositions in poultry litters during the seven-day composting period using sequential extraction in combination with P K-edge X-ray absorption near-edge structure (XANES) and solution (31)P nuclear magnetic resonance (NMR) spectroscopy. The result of sequential extraction illustrated that the significant decrease of H2O-P by 55% in poultry litters occurred concomitantly with the increase of HCl-Pi and HCl-Po during the composting period (p < 0.05). X-ray diffraction results for poultry litter samples showed three distinct peaks indicative of hydroxyapatite. Phosphorus K-edge XANES confirmed the increase of hydroxyapatite during the composting period, corresponding to the increase of HCl-Pi determined by the sequential extraction. The NaOH-EDTA extraction for solution (31)P NMR revealed that myo-inositol hexakisphosphate (IHP) constituted about 80% of phosphate monoesters and was increased from 16 to 28% in the poultry litter during the composting period. The combined applications of chemical extraction and molecular-spectroscopic techniques determined that water-soluble P in poultry litter was transformed into less soluble phases, primarily hydroxyapatite and IHP, during the composting period.

Broiler breeder manure phosphorus forms are affected by diet, location, and period of accumulation

Phosphorus (P) modifications of poultry diets have successfully decreased the total P (TP) in manures, but the effects on manure water-soluble P (WSP(M)) remain unclear. Our objectives were to characterize P forms in broiler breeder manures as affected by dietary P modification, location within the pen, and manure accumulation period. Two diets were formulated with and without phytase to attain 0.40% available P (AvP) during the breeder laying phase (22-64 wk of age). Manure was collected after accumulation periods of 48 h, 3 wk, and 39 wk in locations under the feeder and drinker and under the common area (between the feeder and drinker) of the pen. The TP, WSP(M), orthophosphate, and phytate in manure were measured. Broiler breeders that were fed phytase with a simultaneous reduction in nonphytate P (NPP) produced manures with 15% lower TP than those fed a traditional diet, but did not change WSP(M) when averaged over manure accumulation periods and locations within the pen. Regardless of diet, location within the pen, or accumulation period (r(2) = 0.76), the WSP(M) increased linearly as the manure moisture increased. As manure accumulation periods increased (48 h, 3 wk, and 39 wk), TP manure concentrations increased (11.9, 13.2, and 17.3 g/kg, respectively), orthophosphate proportions increased (73.2, 80.1, and 91.0%, respectively), and phytate proportions decreased (23.1, 17.0, and 6.7%, respectively). The mineralization of phytate and other organic complexes, which drive off carbon dioxide, presumably contributed to the increased orthophosphate and TP concentrations. Keeping breeder manures dry helps to avoid the mineralization of phytate to orthophosphate; this mineralization increased WSP(M) in our study, and thus increased the potential for elevated P loss in runoff when surface applied.

Effects of Phosphorus Level and Phytase in Broiler Breeder Rearing and Laying Diets on Live Performance and Phosphorus Excretion

The effects of a reduced dietary nonphytate phosphorus (NPP) level and inclusion of phytase on broiler breeder performance and P concentrations in the litter and manure were investigated. Ross 308 broiler breeder pullets and Ross 344 cockerels were placed sex-separate in a blackout growing house and fed standard starter and grower diets to 9 wk of age. At 10 wk of age, 4 treatments (A, B, C, D) were assigned to each of 4 floor pens of 68 pullets and 1 pen of 50 cockerels. From 10 to 21 wk, treatments A to D contained 0.37, 0.27, 0.27, and 0.17% NPP, respectively, with 300 phytase units (FTU)/kg of phytase added to treatments B and D. At 21 wk of age, birds were photostimulated and transferred to a two-thirds slat-litter breeder house with 16 pens of 60 pullets and 6 cockerels. A laying diet was fed from 22 to 64 wk and NPP levels of treatments A to D were adjusted to 0.37, 0.27, 0.19, and 0.09%, respectively, and phytase addition to treatments B and D was increased to 500 FTU/kg. Analysis of the litter from growing pens showed no effect on litter total P when phytase replaced 0.1% of NPP. However, decreasing the dietary NPP by 0.1% without phytase reduced the litter total P by 18%. Water-soluble P (WSP) and the WSP:total P ratio decreased when the grower dietary NPP level was reduced to 0.17% with added phytase and was correlated with litter moisture levels in growing pens. During the laying period, a reduction in NPP from 0.37 to 0.09% with added phytase reduced both the manure total P and WSP by 42%. Hen-day egg production was highest on the lowest NPP diet with phytase, but fertility decreased when the dietary NPP was reduced below 0.37%. Results showed that phytase inclusion in a broiler breeder laying diet at the expense of all added P from dicalcium phosphate reduced the manure total P and WSP concentrations by 42%, with no effect on the number of chicks produced per hen housed.