Impact of corn vitreousness and processing on site and extent of digestion by feedlot cattle

Effect of Particle Size of Silage of Flint Corn Grain on Dairy Cows Fed Tropical Pasture: Performance, Intake, Ruminal Fermentation, and Digestibility

The particle size (PS) of reconstituted corn (REC) can affect the grinding rate and starch digestibility in dairy cows. We evaluated the effect of the PS of REC ensiled for 40 days on the pasture dry matter intake (DMI), lactation performance, total tract digestibility, and ruminal fermentation of grazing dairy cows. The treatments were coarse REC (CO, 1694 µm), fine REC (FI, 1364 µm), or finely ground (GC, 366 µm) flint corn (68% vitreousness) at 29.6 ± 1.4% of diet DM (mean ± SD). Eighteen dairy cows (mean milk yield 21.3 kg/d) were split into three groups by production level and were assigned within each group to a sequence of treatments in 3 × 3 Latin squares of 21-day periods. Cows were individually fed a constant amount of whole-plant corn silage 3 ×/d (2.7 kg DM/d) and corn treatments and soybean meal according to their group. There was no significant interaction between treatment and the production level. Cows fed FI had a lower DMI (16.7 vs. 18.1 kg/d) than those fed GC, and both did not differ from CO (17.7 kg/d). There was no treatment effect on milk yield (mean: 19.2 kg/d). Cows fed CO had the lowest total tract digestibility of starch (86.3 vs. 92.3% of intake) and the highest fecal starch concentration (7.0 vs. 4.0% of DM). The NDF digestibility was lower for GC-fed cows than CO- and FI-fed cows. Plasma glucose was higher in cows fed FI and CO (75.0 mg/dL) than those fed GC (70.8 mg/dL). Ruminal volatile fatty acids and the pH did not differ. Fine grinding of REC increased the feed efficiency relative to CO and GC. Coarse grinding of REC ensiled for 40 days reduced the total tract starch digestibility relative to FI and GC.

Uncertainty in non-CO2 greenhouse gas mitigation contributes to ambiguity in global climate policy feasibility

Despite its projected crucial role in stringent, future global climate policy, non-CO₂ greenhouse gas (NCGG) mitigation remains a large uncertain factor in climate research. A revision of the estimated mitigation potential has implications for the feasibility of global climate policy to reach the Paris Agreement climate goals. Here, we provide a systematic bottom-up estimate of the total uncertainty in NCGG mitigation, by developing 'optimistic', 'default' and 'pessimistic' long-term NCGG marginal abatement cost (MAC) curves, based on a comprehensive literature review of mitigation options. The global 1.5-degree climate target is found to be out of reach under pessimistic MAC assumptions, as is the 2-degree target under high emission assumptions. In a 2-degree scenario, MAC uncertainty translates into a large projected range in relative NCGG reduction (40-58%), carbon budget (±120 Gt CO₂) and policy costs (±16%). Partly, the MAC uncertainty signifies a gap that could be bridged by human efforts, but largely it indicates uncertainty in technical limitations.

Ruminal responses, digestibility, and blood parameters of beef cattle fed diets without forage with different hybrids and processing of the corn

The objective of this study was to evaluate the effects of corn hybrid and processing methods on intake and digestibility of nutrients, rumen fermentation and blood metabolites of steers fed no-forage finishing diets. Four ruminally fistulated Nellore castrated steers (502 ± 15 kg initial body weight) were distributed in a 4 × 4 Latin square design with a 2 × 2 factorial arrangement consisting of two corn hybrids (semi-dent and flint) and two processing methods (dry milled and high moisture grain). Interactions of hybrid and processing methods were observed on intake of dry matter (DM), organic matter (OM) and crude protein (CP), as well as on digestibility of DM and CP, rumen pH and ammonia nitrogen (N-NH₃ ). There was no interaction between hybrid and processing for the volatile fatty acids (VFA) total, acetate (C2), propionate (C3), isobutyric (iC4) and valeric (nC5) concentrations. VFA total concentration shown an average of 103.4 mmol/L. The C2 and C3 concentrations had no effect of the hybrid or processing with averages of 58.7 mmol/L for C2, and 31.3 mmol/l for C3. There was an effect of the processing method on starch consumption and fecal pH, the highest values were observed in grains with high moisture content. Starch digestibility was 0.89 g/g in dry milled and 0.96 g/g in high moisture corn. The greatest digestibility of starch in high moisture corn, irrespective of the corn hybrid, provided evidence of an increase in the energy supply, which may improve the feed efficiency and growth performance of cattle fed no-roughage finishing diets.

Effect of processing method and severity for hybrid fall rye on dry matter intake, ruminal fermentation, and apparent total tract nutrient digestibility in ruminally cannulated beef heifers

This study compared dry-rolled and tempered hybrid rye when processed to a coarse or fine severity on dry matter intake (DMI), ruminal fermentation, and apparent total tract nutrient digestibility for beef cattle. Eight ruminally cannulated Simmental heifers (327 ± 33.1 kg, mean ± SD) were used in a replicated 4 × 4 Latin square (21 d periods with 16 d for adaptation and 5 d collection) balanced for carry-over effects with a 2 × 2 factorial arrangement of treatments. Feeding tempered rye increased (P = 0.01) DMI when compared to dry-rolled rye, but there was no effect of processing severity. Cattle fed dry-rolled rye had greater (P = 0.04) area that pH was less than 5.5 when compared to tempered rye. Feeding dry-rolled rye increased dry matter digestibility (P = 0.02), and crude protein digestibility (P = 0.01) when compared to tempered rye, and there was a greater effect to increase total tract starch digestibility with increasing severity of processing for tempering than for dry-rolling (interaction, P = 0.03). In conclusion, tempered hybrid rye processed to a fine severity may result in similar total tract starch digestibility to dry-rolled hybrid rye without the marked reductions in DMI and ruminal pH.

Corn processing, flake density, and starch retrogradation influence ruminal solubility of starch, fiber, protein, and minerals

Five ruminally cannulated steers (body weight = 390 ± 7.86 kg) were used in three experiments to evaluate effects of corn processing, flake density, and starch retrogradation on in situ ruminal degradation. In experiment 1, corn was left whole or processed with no screen, ground through a 6-mm screen, or ground through a 1-mm screen. In experiment 2, we produced steam-flaked corn at four densities: 309, 335, 360, and 386 g/L. These four flake densities were sifted for 20 s through a 4-mm screen to produce two particle sizes within each flake density: sifted flakes (>4 mm) and sifted fines (<4 mm). In experiment 3, sifted flakes (335 g/L) were stored for 3-d at either 23 °C (starch availability = 55%) or 55 °C to induce starch retrogradation (starch availability = 41%). All samples for each of the three experiments were weighed into nylon bags and ruminally incubated for 0-h to estimate the soluble fraction. The residue remaining was analyzed for nutrient composition. In experiment 1, whole shelled corn had lesser (P < 0.01) ruminal solubility of all nutrients measured compared with ground corn. Corn ground with a screen (6 and 1 mm) had greater (P < 0.01) ruminal solubility of all nutrients measured compared with corn ground with no screen. Corn ground through a 1-mm screen had greater (P < 0.03) ruminal solubility of DM, total starch, CP, ADF, AHF, P, Mg, K, S, Zn, Fe, and Mn compared with corn ground through a 6-mm screen. In experiment 2, increasing flake density linearly decreased (P < 0.02) the soluble fraction of DM, total starch, CP, ADF, AHF, P, K, S, and Zn of sifted flakes. The soluble DM fraction of sifted fines tended to decrease (P = 0.06) linearly with increasing flake density. Total starch, CP, NDF, and Zn soluble fractions of sifted fines were not influenced by flake density. In experiment 3, storage of sifted flakes in heat-sealed foil bags at 55 °C for 3-d decreased (P < 0.04) the soluble fractions of DM, total starch, CP, NDF, P, Mg, K, S, and Fe. With each increase in the degree of corn processing, there was an increase in the solubility of nutrients. Increasing flake density can decrease ruminal solubility of flakes; however, the soluble fraction of sifted fines is not influenced as much by changes in flake density. Inducing starch retrogradation decreases ruminal solubility of starch, nonstarch OM, and minerals.

Blood metabolites and fecal starch as indicators of feed efficiency of beef cattle in the feedlot

ABSTRACT The use of blood metabolites (BM), fecal starch (FS), and apparent digestion of starch, (ATTSD) as indicators of feed efficiency (FE) in beef cattle in the feedlot was studied. Fourteen bulls were used, originating in an industrial cross, without a defined racial group, with mean body weight of 284.86kg, individually fed, being evaluated in a 42-day confinement system. After the evaluation, the animals were divided into two groups according to the individual FE: high feed efficiency (HE) and low feed efficiency (LE). There was a difference between the groups in the variables FE, feed conversion (FC), final weight (FW), and daily weight gain (DWG). The FE had a positive correlation with DWG, FC, and FW. There was no difference between the groups for the variables BM, FS, and ATTSD, nor was there any correlation between these variables and FE. Considering the feed cost, the HE animals proved more profitable. BM, FS, and ATTSD did not statistically show potential to be used as indicators of FE, despite the evidence of numerical differences of these variables between the different groups, tendency of correlations with FE, and discriminating function with potential assertiveness.

Growth performance and total tract digestibility in broiler chickens fed different corn hybrids

The aim of the present study was to investigate the variability in nutrient digestibility associated with corn genetic background and its influence on the feeding value for broiler chickens. A total of 960 1-day-old male broiler chicks (Ross 308) were distributed in eight treatments, with 12 pens per treatment and 10 birds per pen in a 42-day study. Eight corn samples (Variety 1 to Variety 8) were selected based on their nutrient composition. A fixed amount of each corn (577 g/kg in the starter diets and 662 g/kg in the finisher diets) was used to formulate feeds. Diets were offered ad libitum in pellet form. Performance parameters were determined at d 21 and d 42, and excreta samples collected at d 21 to determine energy, organic matter and dry matter (DM) whole-tract digestibility. The results revealed a decrease (P < 0.05) in body weight (BW) and feed intake in birds fed variety 8 compared to other varieties at d 21. The lowest whole tract DM and energy apparent digestibility were also observed for the variety 8 diet (P < 0.05), together with varieties 3 and 5. Energy digestibility was higher in varieties 2, 4 and 7 (P < 0.05). Multivariate analysis revealed that corn protein concentration was positively correlated with vitreousness (r = 0.60, P = 0.054) and the arabinose:xylose ratio (r = 0.67, P < 0.05) and negatively correlated with starch (r = -0.62, P < 0.05). Soluble non-starch polysaccharide content was negatively correlated with the protein solubility index (r = -0.88, P < 0.05). In addition, corn protein concentration was negatively correlated (P < 0.05) with 21-d BW (r = -0.71) and weight gain (r = -0.62). In conclusion, the corn genetic background influenced the nutrient digestibility and growth performance of broiler chickens. The content and nature of the non-starch polysaccharides were found to be two of the main factors affecting the solubility and availability of nutrients in corn, and could be the reason for the negative effects on the performance of broiler chickens as shown in the present study.

Effects of corn grain endosperm type and fineness of grind on feed intake, feeding behavior, and productive performance of lactating dairy cows

Our objective was to evaluate effects of corn grain endosperm type and fineness of grind on feed intake, feeding behavior, ruminal fermentation, and productive performance of lactating cows. Eight ruminally and duodenally cannulated Holstein cows in mid lactation (130 ± 42 d in milk; mean ± standard deviation) were used in a duplicated 4 × 4 Latin square design with 21-d periods. A 2 × 2 factorial arrangement of treatments was used with main effects of corn grain endosperm type (floury or vitreous) and fineness of grind of corn grain (fine or medium). Rations were formulated to contain 29% starch, 27% neutral detergent fiber, 18.2% forage neutral detergent fiber, and 18% crude protein. Corn grain treatments supplied 86.2% of dietary starch. Endosperm was 25% vitreous for floury corn and 66% vitreous for vitreous corn. Fineness of grind did not affect dry matter intake (DMI), but floury corn tended to reduce DMI (23.8 vs. 25.1 kg/d) compared with vitreous corn. Floury corn increased meal frequency more for fine grind size (9.57 vs. 9.41 meals/d) than medium grind size (9.78 vs. 9.75 meals/d). However, there were no effects of treatment on any other measure of feeding behavior. Endosperm type did not affect yields of milk or milk components or milk composition except that vitreous corn tended to decrease milk lactose concentration compared with floury corn. Finely ground corn decreased yields of milk (31.1 vs. 33.1 kg/d), 3.5% fat-corrected milk (33.1 vs. 35.1 kg/d), milk fat (1.22 vs. 1.32 kg/d), milk lactose (1.48 vs. 1.59 kg/d), and solids not fat (2.46 vs. 2.63 kg/d) compared with medium grind size. However, fineness of grind did not affect milk composition. Treatments had no effect on change in body weight or body condition score or efficiency of milk production (kg of 3.5% fat-corrected milk/kg of DMI). Mean ruminal pH was not affected by treatment, but pH variance was decreased by vitreous compared with floury corn. Total volatile fatty acids and propionate concentrations in the rumen were increased by floury compared with vitreous corn but were not affected by fineness of grind. Effects of fineness of grind on yield of milk and milk components were greater than the effects of corn grain vitreousness.

Whole-flint corn grain or tropical grass hay free choice in the diet of dairy calves

Tropical grass hay feeding is related to improved ruminal health; however, it may decrease energy intake. On the other hand, whole-flint corn grain may be an alternative fiber source in the diet of dairy calves. Forty-two Holstein calves were used in a randomized block design, considering sex, birth date, and weight at 21 d of age, when the supply of whole-flint corn grain or tropical grass hay started. Three component-fed solid diets were compared: (1) starter concentrate only during the preweaning and starter concentrate with free choice of chopped Tifton-85 hay postweaning (SC), (2) starter concentrate with free choice of chopped Tifton-85 hay pre- and postweaning (SCH), and (3) starter concentrate with free choice of whole-flint corn grain pre- and postweaning (SCW). The animals were evaluated from 21 to 84 d of age. Calves were managed equally during the first 21 d, fed with 6 L/d of whole milk and a commercial starter concentrate (46% nonfiber carbohydrates, small particles, and pelleted) ad libitum. After that, milk feeding was reduced to 4 L/d until gradual weaning at 56 d of age. At 56 d of age, 4 animals per treatment were randomly chosen to be slaughtered for digestive tract weight evaluation and to collect tissue for histological analysis of the ruminal wall, duodenum, and cecum, whereas the other 30 animals were weaned and evaluated for a further 22 d when the SC diet also received hay ad libitum. Feed intake was measured daily. Weight gain and metabolic indicators of intermediate metabolism were evaluated weekly. Ruminal fluid was collected at wk 6, 8, 10, and 12 of age. The SCH diet increased the total and starter dry matter intake, and consequently, the average daily gain and body weight at 56 d of age. The SCW diet promoted an increase in propionate and decreased acetate-to-propionate ratio. Morphometric variables were affected by the SCH diet. The postweaning performance was unaffected by solid diets; however, the SCW diet decreased ruminal and fecal pH. Feeding hay, starting at 21 d of age, can stimulate early solid diet intake, promoting better performance and ruminal and intestinal development, when a highly fermentable and small particle pelleted starter is fed.

Effect of corn processing on growth performance, carcass characteristics, and plasma glucose-dependent insulinotropic polypeptide and metabolite concentrations in feedlot cattle

The objectives of this trial were to evaluate the association between corn processing, glucose-dependent insulinotropic polypeptide (GIP) concentration, and intramuscular (IM) fat deposition. We hypothesized that steers fed whole shelled corn (WSC) would have a greater IM fat deposition than steers fed cracked corn (CC) due to an increase in plasma GIP concentration. Backgrounded, Angus-cross cattle (initial body weight [BW] = 279 ± 9.8 kg) were used in a randomized complete block design in a feedlot setting for an average of 230 d. Cattle were allotted in 12 pens (6 pens per treatment with 8 animals per pen). There were three blocks: heifers (n = 32, initial BW = 265 ± 1.3 kg), small steers (n = 32, initial BW = 262 ± 1.3 kg), and large steers (n = 32, initial BW = 310 ± 1.4 kg). Two pens within each block were randomly assigned to one of the following treatments: 1) CC or 2) WSC. Animal growth performance, carcass characteristics, and plasma hormone and metabolite concentrations were analyzed using the MIXED procedure of SAS, including the fixed effects of treatment, or treatment, time, and their interaction. Pen and block were included as random effects. Carcass yield and quality grade distributions were compared using the GLIMMIX procedure of SAS. including the fixed effects of treatment and time with pen and block as random effects. Linear regression was used to evaluate the association of plasma GIP concentration and IM fat content. Average daily gain (P = 0.57) and final BW (P = 0.34) were similar, regardless of treatment. Cattle fed CC had reduced (P < 0.01) dry matter intake (DMI) when compared with those fed WSC. This lesser DMI resulted in improved gain:feed ratio (P < 0.01) for cattle fed CC compared with cattle fed WSC. There was no effect (P ≤ 0.33) of corn processing on plasma glucose, plasma GIP concentrations, hot carcass weight, dressing percentage, or marbling score. There was a positive linear relationship (P = 0.03) between IM fat concentration and plasma GIP concentration. In conclusion, feeding CC increased gain:feed ratio compared with WSC, but there was no difference in plasma GIP concentration, whereas plasma GIP concentration appears to be related to IM fat deposition.

The drying temperature and the moisture content at harvest affect the apparent metabolisable energy of two maize varieties in broiler chickens

1. The grain drying process may affect the feeding value of maize but until now, no general consensus has been reached. This knowledge is essential to manage maize nutritional value in feed and ensure optimal growth performance of broiler chickens. 2. A total of 72 male Ross 308 were used in a complete randomised block design to assess the effect of initial moisture content (MC) at harvest (high or low MC after the appearance of the black layer) and drying temperature (54°C, 90°C or 125°C) on the apparent faecal digestibility and the AMEn value of two maize grain types (flint and flint-dent varieties). Moreover, the relationship between in vitro dry matter digestibility coefficient (IVDMD) and salt-soluble protein (SSP) content of dried maize grain with AMEn was assessed. 3. High drying temperature (125°C) significantly decreased the AMEn (by 0.41 MJ/kg) of the maize. Maize with high-moisture content at harvest had significantly higher AMEn than maize with low moisture content (0.38 MJ/kg) depending on the variety. Based on the combination of MC at harvest and drying temperature, an AMEn difference of about 0.65 MJ per kg of dry matter was measured during this experiment. The faecal digestibility of starch remained close to 98% with low variation between the treatments. The decrease in AMEn at high drying temperature was related to the decrease in non-starch organic matter retention (NSOM_R). IVDMD and SSP content were not correlated with AMEn of dried maize (R² < 0.1). 4. This study showed that using drying temperature below 90°C for maize grain harvested at high MC, just after the black layer development, can enhance its AMEn. The IVDMD and SSP content failed to predict the AMEn of the dried maize, but further research is required to validate the results of this study.

Effects of dietary roughage neutral detergent fiber levels and flint corn processing method on growth performance, carcass characteristics, feeding behavior, and rumen morphometrics of Bos indicus cattle1

Flint corn processing method [coarse ground corn (CGC; 3.2 mm average particle size) or steam-flaked corn (SFC; 0.360 kg/L flake density)] was evaluated in conjunction with 4 levels of NDF from sugarcane bagasse (SCB) as roughage source (RNDF; 4%, 7%, 10%, and 13%; DM basis) to determine impact on growth performance, carcass characteristics, starch utilization, feeding behavior, and rumen morphometrics of Bos indicus beef cattle. Two hundred and forty Nellore bulls were blocked by initial BW (350 ± 37 kg), assigned to 32 feedlot pens and pens within weight block were randomly assigned, in a 2 × 4 factorial arrangement (2 corn processing and 4 levels of RNDF) to treatments. Effects of corn grain processing × RNDF level were not detected (P ≥ 0.14) for growth performance, dietary net energy concentration, carcass traits, rumen morphometrics, and feeding behavior, except for time spent ruminating and time spent resting (P ≤ 0.04), and a tendency for papillae width (P ≤ 0.09). Bulls fed SFC-based diets consumed 7% less (P = 0.001), had 10.6% greater carcass-adjusted ADG (P < 0.001) and 19% greater carcass-adjusted feed efficiency (P < 0.001) compared with bulls fed CGC-based diets. Observed net energy for maintenance and gain values were 14.9% and 19.4% greater (P < 0.001), respectively, for SFC than for CGC-based diets. Fecal starch concentration was less (P < 0.001) for bulls fed SFC compared with those fed CGC. No grain processing effects were detected (P = 0.51) for rumenitis score; however, cattle fed SFC presented smaller ruminal absorptive surface area (P = 0.03). Dry matter intake increased linearly (P = 0.02) and carcass-adjusted feed efficiency tended (P = 0.06) to decrease linearly as RNDF increased. Dietary RNDF concentration did not affect carcass characteristics (P ≥ 0.19), except for dressing percentage, which tended to decrease linearly (P = 0.06) as RNDF in finishing diets increased. Increasing RNDF in finishing diets had no effect (P = 0.26) on time spent eating, but time spent ruminating and resting increased linearly (min/d; P < 0.001) with increased dietary RNDF. Steam flaking markedly increased flint corn energy value, net energy of diets, and animal growth performance, and led to improvements on feed efficiency when compared with grinding, regardless of RNDF content of diets. Increasing dietary RNDF compromised feedlot cattle feed efficiency and carcass dressing.

Effects of exogenous amylase on the in vitro digestion kinetics of whole-crop maize silages made from flint or dent grain type at different phenological stages grown in tropical condition

The effect of exogenous amylase on the in vitro rumen digestion kinetics of whole-crop maize silage made from dent (RB9004) or flint grain type (RB9308) was evaluated at different phenological stages: soft dough (SOD), early dent (EAD), ½ milkline (½M) and ¾ milkline (¾M). Forage was harvested from 70 to 110 days after sowing. Two rumen-cannulated cows receiving or not exogenous amylase (0.7 g/kg dry matter-DM, provided to achieve 396 kilo Novo units of amylase activity/kg of TMR DM) were used as donor of ruminal fluid. The in vitro gas production kinetics was evaluated according to a dual-pool logistic model. The chemical composition and gas production kinetics were affected by the hybrid and phenological stages. The flint hybrid had lower range for chemical analysis among physiological stages. Harvesting at ½M and ¾M improved DM content, bromatological composition and silage quality parameters compared to dent or flint types. Amylase (i) increased methane (CH₄ ) production and in vitro dry matter digestibility (IVDMD) in ½M stage, (ii) improved digestion kinetics by reducing lag time and increasing total gas production and fermentation rates of non-fibrous carbohydrates (NFC) and fibrous carbohydrates (FC), and (iii) increased extent and fermentation rate of NFC and increased fermentation rate of FC fraction in whole-crop maize silages produced from dent or flint types in all phenological stages. Harvesting between ½M and ¾M is the best phenological stage to improve chemical composition and silage quality parameters. Exogenous amylase showed improvements on fibre digestion of silages at ½M and ¾M phenological stages in both grain types of corn.

Feeding the combination of essential oils and exogenous α-amylase increases performance and carcass production of finishing beef cattle

Two experiments were conducted to evaluate the performance responses of finishing feedlot cattle to dietary addition of essential oils and exogenous enzymes. The treatments in each experiment consisted of (DM basis): MON-sodium monensin (26 mg/kg); BEO-a blend of essential oils (90 mg/kg); BEO+MON-a blend of essential oils plus monensin (90 mg/kg + 26 mg/kg, respectively); BEO+AM-a blend of essential oils plus exogenous α-amylase (90 mg/kg + 560 mg/kg, respectively); and BEO+AM+PRO-a blend of essential oils plus exogenous α-amylase and exogenous protease (90 mg/kg + 560 mg/kg + 840 mg/kg, respectively). Exp. 1 consisted of a 93-d finishing period using 300 Nellore bulls in a randomized complete block design. Animals fed BEO had higher DMI (P < 0.001) but similar feed efficiency to animals fed MON (P ≥ 0.98). Compared with MON, the combination of BEO+AM resulted in 810 g greater DMI (P = 0.001), 190 g greater average daily gain (P = 0.04), 18 kg heavier final body weight (P = 0.04), and 12 kg heavier hot carcass weight (P = 0.02), although feed efficiency was not significantly different between BEO+AM and MON (P = 0.89). Combining BEO+MON tended to decrease hot carcass weight compared with BEO alone (P = 0.08) but not compared with MON (P = 0.98). Treatments did not impact observed dietary net energy values (P ≥ 0.74) or the observed:expected net energy ratio (P ≥ 0.11). In Exp. 2, five ruminally cannulated Nellore steers were used to evaluate intake, apparent total tract digestibility of nutrients, and ruminal parameters in a 5 × 5 Latin square design. Feeding BEO increased the total tract digestibility of CP compared to MON (P = 0.03). Compared to MON, feeding the combination of BEO+MON increased the intake of CP (P = 0.04) and NDF (P = 0.05), with no effects on total tract digestibility of nutrients (P ≥ 0.56), except for a tendency (P = 0.09) to increase CP digestibility. Intakes of all nutrients measured, except for ether extract (P = 0.16) were greater in animals fed BEO+AM when compared with MON (P ≤ 0.03), with no differences on total tract nutrient digestibilities (P ≥ 0.11) between these two treatments. In summary, diets containing the BEO used herein enhanced DMI of growing-finishing feedlot cattle compared with a basal diet containing MON without impair feed efficiency. A synergism between BEO and AM was detected, further increasing cattle performance and carcass production compared to MON.

Influence of zeolite (clinoptilolite) supplementation on characteristics of digestion and ruminal fermentation of steers fed a steam-flaked corn-based finishing diet

Four Holstein steers (328 ± 14 kg) with ruminal and duodenal cannulas were used in a 4 × 4 Latin square design to examine the effect of level of zeolite supplementation (0, 10, 20 or 30 g clinoptilolite-Ca/kg of diet) in a steam-flaked corn-based finishing diet on the characteristics of ruminal fermentation and nutrient digestion. Zeolite was top-dressed with the basal diet at time of feeding; therefore, intake of organic matter (OM), neutral detergent fibre (NDF), starch and N was equal in all treatments. Zeolite supplementation did not affect site and extent of digestion of N or NDF. Zeolite linearly decreased (P < 0.01) NH3-N flow to duodenum, but did not affect duodenal flow of microbial N, feed N, or microbial efficiency. Inclusion of zeolite linearly increased (P = 0.02) ruminal OM digestion and tended (linear, P = 0.08) to increase ruminal digestion of starch. Zeolite supplementation increased (linear effect, P < 0.01) faecal excretion of ash, resulting in decreased total tract DM digestion (linear effect, P = 0.04). However, total tract digestion of OM tended to increase (P = 0.06) with increasing zeolite supplementation. Thus, dilution of the diet with zeolite did not depress dietary digestible energy. There were no treatment effects on ruminal pH. Total ruminal volatile fatty acid concentration tended (P = 0.08) to increase as zeolite increased. Zeolite supplementation decreased ruminal molar proportion of acetate and increased molar proportion of propionate (linear effect, P < 0.01), resulting in decreased (linear effect, P < 0.01) of acetate: propionate ratio. Supplementation with zeolite at levels of up to 30 g of zeolite/kg of diet may enhance ruminal OM digestion, largely due to the tendency of increased ruminal starch digestion. Zeolite supplementation altered ruminal volatile fatty acid molar proportions (decreased acetate : propionate ratio), and therefore may have an positive impact on energy efficiency.

Effects of various roughage levels with whole flint corn grain on performance of finishing cattle

Performance responses to steam flaking flint corn as well as to the addition of roughage to finishing diets composed of whole flint corn were evaluated. Ninety-six Nellore bulls were stratified by initial BW (373 ± 11 kg) and randomly allotted to 16 feedlot pens (6 bulls/pen) in a randomized complete block design with 4 replicates/treatment. Dietary treatments for the 86-d feeding trial consisted of (DM basis) 1) 78.8% steam-flaked flint corn with 6% sugarcane bagasse and 0.20% urea, 2) 85% whole flint corn without sugarcane bagasse, 3) 81.9% whole flint corn with 3% sugarcane bagasse and 0.10% urea, and 4) 78.8% whole flint corn with 6% sugarcane bagasse and 0.20% urea. All diets contained 15% (DM basis) of a pelleted protein, mineral, and vitamin supplement. Compared with whole flint corn grain, flaking of flint grain decreased ( < 0.01) DMI but did not alter ADG ( = 0.86), so G:F was increased ( = 0.02). Although steam flaking did not alter final BW and carcass characteristics ( > 0.47), it increased energy content of the diet ( < 0.03) and total tract starch digestibility ( < 0.01). In addition, flaking increased ( < 0.01) NEg of flint corn when compared with whole corn. Increasing the roughage content of WC-based diets resulted in quadratic ( < 0.02) responses in DMI, NEm and NEg intakes, ADG, and final BW but had no effect ( > 0.47) on G:F or on observed energy content of the diet. In summary, steam flaking of flint corn when fed in diets containing 6% sugarcane bagasse decreased DMI by 17% but increased G:F by 20% and NEg of corn calculated from feedlot performance by 23%; these responses markedly exceed those typically observed with dent corn grain. Moreover, adding 3% sugarcane bagasse to a flint whole corn grain diet optimized feedlot performance of Nellore bulls.

Effect of flint corn processing method and roughage level on finishing performance of Nellore-based cattle

This study was conducted to evaluate the effects of flint corn processing method (CPM) and level of NDF from roughage (rNDF) on performance, carcass characteristics, and starch utilization by finishing Nellore-based cattle fed high-concentrate, flint corn-based diets. In this study, 112 Nellore type bulls (initial BW 384.07 ± 29.53 kg and 24-36 mo of age) were individually fed using Calan gates or individual pens. The animals were used in a randomized complete block design in a 2 × 4 factorial arrangement with 2 CPM, high-moisture flint corn (HMC) or finely ground dry flint corn (FGC), with 1 of 4 levels of rNDF, 3, 8, 13, and 18% (DM basis), using sugarcane silage (SS) as roughage. Bulls were adapted to the finishing diet over a 21-d period and fed for a total of 81 d. Fecal starch (FS) concentration was determined on d 46 and 74 of the feeding period. There was a quadratic effect of rNDF on final BW ( < 0.01) and ADG ( = 0.01). Optimal concentrations of rNDF were estimated using the first derivative of second order polynomials, indicating that final BW and ADG were maximized with 13.3 and 13.0% rNDF, respectively. An interaction was observed between CPM and rNDF ( = 0.05) for DMI, with peak DMI occurring at 11.3 and 13.7% rNDF with FGC and HMC, respectively. Cattle fed HMC had 13.9% greater G:F ( < 0.01) compared with those fed FGC (0.172 vs. 0.151, respectively). There were quadratic effects of rNDF on HCW ( = 0.04) and ME intake ( < 0.01); heaviest carcass weights were estimated, in both cases, to be achieved with 12.8% rNDF. A quadratic effect of rNDF for renal, pelvic, and inguinal fat weight ( = 0.04) was observed, with a peak estimated to occur at 12.6% rNDF. An interaction between CPM and rNDF also was observed for FS ( < 0.05). Bulls fed FGC with 3% rNDF had greater FS content, and FS linearly decreased as concentration of rNDF increased. For bulls fed HMC, FS was 3.0% of DM and was unaffected by rNDF in the diet. Lower FS from bulls fed HMC suggests that availability of starch from flint corn was greater than that of FGC. For Nellore-based cattle fed a flint corn-based diet containing SS and 8% whole lint cottonseed, performance was optimized with 12.8% rNDF. In the absence of cottonseed addition to diets, optimal performance would be expected with about 14.5% rNDF.

Influence of Wheat Straw Pelletizing and Inclusion Rate in Dry Rolled or Steam-flaked Corn-based Finishing Diets on Characteristics of Digestion for Feedlot Cattle

Eight Holstein steers (216±48 kg body weight) fitted with ruminal and duodenal cannulas were used to evaluate effects of wheat straw processing (ground vs pelleted) at two straw inclusion rates (7% and 14%; dry matter basis) in dry rolled or steam-flaked corn-based finishing diets on characteristics of digestion. The experimental design was a split plot consisting of two simultaneous 4×4 Latin squares. Increasing straw level reduced ruminal (p<0.01) and total tract (p = 0.03) organic matter (OM) digestion. As expected, increasing wheat straw level from 7% to 14% decreased (p<0.05) ruminal and total tract digestion of OM. Digestion of neutral detergent fiber (NDF) and starch, per se, were not affected (p>0.10) by wheat straw level. Likewise, straw level did not influence ruminal acetate and propionate molar proportions or estimated methane production (p>0.10). Pelleting straw did not affect (p≥0.48) ruminal digestion of OM, NDF, and starch, or microbial efficiency. Ruminal feed N digestion was greater (7.4%; p = 0.02) for ground than for pelleted wheat straw diets. Although ruminal starch digestion was not affected by straw processing, post-ruminal (p<0.01), and total-tract starch (p = 0.05) digestion were greater for ground than for pelleted wheat straw diets, resulting in a tendency for increased post-ruminal (p = 0.06) and total tract (p = 0.07) OM digestion. Pelleting wheat straw decreased (p<0.01) ruminal pH, although ruminal volatile fatty acids (VFA) concentration and estimated methane were not affected (p≥0.27). Ruminal digestion of OM and starch, and post-ruminal and total tract digestion of OM, starch and N were greater (p<0.01) for steam-flaked than for dry rolled corn-based diets. Ruminal NDF digestion was greater (p = 0.02) for dry rolled than for steam-flaked corn, although total tract NDF digestion was unaffected (p = 0.94). Ruminal microbial efficiency and ruminal degradation of feed N were not affected (p>0.14) by corn processing. However, microbial N flow to the small intestine and ruminal N efficiency (non-ammonia N flow to the small intestine/N intake) were greater (p<0.01) for steam-flaked than for dry rolled corn-based diets. Ruminal pH and total VFA concentration were not affected (p≥ 0.16) by corn processing method. Compared with dry rolled corn, steam-flaked corn-based diets resulted in decreased acetate:propionate molar ratio (p = 0.02). It is concluded that at 7% or 14% straw inclusion rate, changes in physical characteristics of wheat straw brought about by pelleting negatively impact OM digestion of both steam-flaked and dry-rolled corn-based finishing diets. This effect is due to decreased post-ruminal starch digestion. Replacement of ground straw with pelleted straw also may decrease ruminal pH.

Effects of corn processing method and dietary inclusion of wet distillers grains with solubles on energy metabolism, carbon-nitrogen balance, and methane emissions of cattle

The growing ethanol industry in the Southern Great Plains has increased the use of wet distillers grains with solubles (WDGS) in beef cattle (Bos taurus) finishing diets. Few studies have used steam-flaked corn (Zea mays L.; SFC)-based diets to evaluate the effects of WDGS in finishing cattle diets, and a reliable estimate of the net energy value of WDGS has yet to be determined. Effects of corn processing method and WDGS on energy metabolism, C and N balance, and enteric methane (CH(4)) production were evaluated in a short-term study using 8 Jersey steers and respiration calorimetry chambers. A 2 by 2 factorial arrangement of treatments was used in a Latin square design. The 4 treatment combinations consisted of: i) SFC-based diet with 0% WDGS (SFC-0); ii) SFC-based diet with 30% WDGS (SFC-30); iii) dry-rolled corn (DRC)-based diet with 0% WDGS (DRC-0); and iv) DRC-based diet with 30% WDGS (DRC-30). Diets were balanced for degradable intake protein (DIP) and ether extract (EE) by the addition of cottonseed (Gossypium hirsutum L.) meal and yellow grease. As a proportion of GE, grain processing method did not affect (P ≥ 0.12) fecal, digestible, urinary, and ME, or heat production. Steers consuming SFC-based diets produced less (P < 0.04) CH(4) than steers consuming DRC-based diets. Retained energy tended to be greater (P = 0.09) for cattle consuming SFC- than DRC-based diets. Inclusion of WDGS did not affect (P ≥ 0.17) fecal, digestible, urinary, metabolizable, and retained energy, or heat production as a proportion of GE. Furthermore, neither inclusion of WDGS or grain processing method affected (P ≥ 0.17) daily CO(2) production. Due in part to greater N intake, cattle consuming diets containing 30% WDGS excreted more (P = 0.01) total N and excreted a greater (P < 0.01) quantity of N in the urine. From these results, we conclude that cattle consuming SFC-based diets produce less CH(4) and retain more energy than cattle fed DRC-based diets; however, dietary inclusion of WDGS at 30% seems to have little effect on CH(4) production and energy metabolism when diets are balanced for DIP and EE. Cattle excrete a greater amount of C when fed DRC compared with SFC-based diets, and dietary inclusion of 30% WDGS increases urinary N excretion. Finally, we determined the NE(g) values for WDGS were 1.66 and 1.65 Mcal/kg in a SFC or DRC-based diet, respectively, when WDGS replaced 30% of our control (SFC-0 and DRC-0) diets.

Wet distillers grains plus solubles concentration in steam-flaked-corn-based diets: Effects on feedlot cattle performance, carcass characteristics, nutrient digestibility, and ruminal fermentation characteristics

Two experiments were conducted to determine the effects of wet distillers grain plus solubles (WDG; <15% sorghum grain) concentration in steam-flaked corn (SFC) diets on feedlot performance, carcass characteristics, ruminal fermentation, and diet digestibility. In Exp. 1, six hundred crossbred steers (364 ± 35 kg of BW) were used in a randomized complete block design with 8 replications/treatment. Dietary treatments consisted of a dry-rolled corn (DRC) control diet without WDG, a SFC control without WDG, and SFC with 4 WDG concentrations (15, 30, 45, 60% DM basis) replacing SFC, cottonseed meal, urea, and yellow grease. Final BW, ADG, G:F, HCW, and 12th-rib fat depth were greater (P ≤ 0.05) for SFC compared with DRC. Dry matter intake tended (P = 0.06) to be greater for DRC compared with SFC. Final BW, ADG, G:F, HCW, 12th-rib fat depth, and marbling score decreased linearly (P < 0.01) with increasing WDG concentration. In Exp. 2, six ruminally and duodenally cannulated crossbred steers (481 ± 18 kg of BW) were used in a 6 × 6 Latin square design using the same diets as Exp. 1. Ruminal, postruminal, and total tract OM and NDF digestibility were not different (P > 0.14) for DRC compared with SFC. Ruminal and total tract starch digestibility were greater (P < 0.01) for SFC compared with DRC. Dry matter and OM intake were not different (P ≥ 0.43) among WDG treatments. Ruminal and total tract OM digestibility decreased linearly (P < 0.01) with increasing WDG concentration. Intake, ruminal digestibility, and total tract digestibility of NDF increased linearly (P < 0.01) with increasing WDG concentration. Starch intake decreased linearly (P < 0.01) with increasing WDG concentration. Ruminal starch digestibility increased (P = 0.01) with increasing concentration of WDG. Total tract starch digestibility decreased quadratically (P < 0.01) with increasing concentration of WDG. Feeding SFC improved steer performance compared with DRC. The concentration of WDG and corn processing method influences nutrient digestibility and ruminal fermentation. The addition of WDG in SFC-based diets appears to negatively affect animal performance by diluting the energy density of the diet.

Comparative effects of processing methods on the feeding value of maize in feedlot cattle

The primary reason for processing maize is to enhance feeding value. Total tract starch digestion is similar for coarsely processed (dry rolled, cracked) dry maize. Enhancements in starch digestion due to dry rolling maize v. feeding maize whole may be greater in light-weight calves than in yearlings, and when DM intake is restricted ( < 1·5 % of body weight). The net energy (NE) maintain (NEm) and NE gain (NEg) values for whole maize are 8·83 and 6·02 MJ (2·11 and 1·44 Mcal)/kg, respectively. Compared with conventional dry processing (i.e. coarse rolled, cracked), finely processing maize may increase the initial rate of digestion, but does not improve total tract starch digestion. Tempering before rolling (without the addition of steam) may enhance the growth performance response and the NE value of maize. Average total tract starch digestion is similar for high-moisture and steam-flaked maize. However, the proportion of starch digested ruminally is greater (about 8 %) for high-moisture maize. The growth performance response of feedlot cattle to the feeding of high-moisture maize is highly variable. Although the NEm and NEg value of whole high-moisture maize was slightly less than that of dry processed maize (averaging 9·04 and 6·44 MJ (2·16 and 1·54 Mcal)/kg, respectively), grinding or rolling high-moisture maize before ensiling increased (6 %) its NE value. Substituting steam-flaked maize for dry processed maize increases average daily gain (6·3 %) and decreases DM intake (5 %). The comparative NEm and NEg values for steam-flaked maize at optimal processing (density = 0·34 kg/l) are 10·04 and 7·07 MJ (2·40 and 1·69 Mcal)/kg, respectively. These NE values are greater (3 %) than current tabular values (National Research Council, 2000), being more consistent with earlier standards (National Research Council, 1984). When maize is the primary or sole source of starch in the diet, concentration of starch in faeces (faecal starch, % of DM) of feedlot steers can serve as an indicator of total tract starch digestion, and, hence, the feeding value of maize.

Applying technology with newer feed ingredients in feedlot diets: do the old paradigms apply?

Use of coproducts such as corn and sorghum distillers grain (DG) and corn gluten feed (CGF) in beef cattle finishing diets has increased significantly in recent years, but research to evaluate the efficacy of traditional feeding practices and feed additives when coproducts are fed has not kept pace. Grain processing methods that increase starch availability seem equally effective in traditional diets and diets with wet CGF; however, in wet DG diets, some studies have shown decreased efficacy of grain processing, whereas others have shown no evidence of an interaction. Limited data are available on the physical and nutritional value of the fiber in wet DG and CGF; however, CGF at concentrations >/=25% of the dietary DM seems to have some degree of "roughage value," whereas fiber in wet DG seems to have less potential to replace traditional roughage sources. There is little evidence that efficacy of ionophores and antibiotics is changed with diets based on wet CGF or that they interact when wet DG is added to finishing diets. In vitro data from our laboratory suggest no loss of monensin efficacy in substrates with 15% (DM basis) corn DG in terms of changes in VFA and gas production. Moreover, efficacy of ionophores was not affected in our data by diet substrates with increasing concentrations of S, and in vitro H(2)S production in substrates containing wet DG seems predictable from substrate S concentrations. Nonetheless, limited in vivo data indicate decreased ruminal acetate-to-propionate ratios in diets with increased wet DG, which may minimize the potential for ionophores to alter propionate. Likewise, in vivo results indicate that feeding wet DG may decrease ruminal pH; thus, to maximize DMI and minimize digestive upsets, optimal concentrations of roughage need to be evaluated in diets containing wet DG. Research is needed on other potential technology interactions with coproducts of biofuel production such as glycerol and condensed distillers solubles. The effects of yeast products and live microbial cultures in diets with coproduct feeds have generally not been determined. Because of the elevated fiber concentrations in CGF and DG, effects of exogenous enzyme preparations on ruminal fermentation and fiber digestion of diets containing these coproducts should be evaluated.

Evaluation of dried distillers grains and roughage source in steam-flaked corn finishing diets

Two studies were conducted to evaluate effects of dried distillers grains with solubles (DDGS) and alfalfa hay (AH) or corn silage (CS) on feedlot performance, carcass characteristics, ruminal fermentation, and diet digestibility in cattle fed steam-flaked corn (SFC) diets. In trial 1, crossbred heifers (n = 358; BW = 353 +/- 13 kg) were used in a finishing trial to evaluate interactions between corn-DDGS and roughage source (AH or CS) in terms of impact on feedlot performance and carcass characteristics. Experimental diets (DM basis) consisted of SFC and 11% CS without DDGS (SFC-CS), SFC and 11% CS with 25% DDGS (DDGS-CS), SFC and 6% AH without DDGS (SFC-AH), and SFC with 25% DDGS and 6% AH (DDGS-AH). Heifers were fed for ad libitum intake once daily for 97 d. Results indicated no interaction between DDGS and roughage source with respect to animal performance. Feeding DDGS did not affect ADG (P = 0.19), DMI (P = 0.14), or feed conversion (P = 0.67). Heifers fed CS had greater DMI than those fed AH (P = 0.05), but ADG (P = 0.56) and G:F (P = 0.63) were not different. There were no differences among treatments with respect to HCW, dressing percentage, subcutaneous fat thickness, quality grades, or yield grades (P > 0.20). Cattle fed CS tended (P = 0.10) to have greater marbling scores than those fed AH. There was an interaction (P = 0.02) between roughage and DDGS with respect to incidence of liver abscess. The greatest incidence was observed in cattle fed diets without DDGS when CS was fed, and the least was observed in cattle fed diets without DDGS when AH was used. In the second trial, ruminal fermentation characteristics and diet digestibility were examined in 12 cannulated Holstein steers fed similar diets to those fed in the finishing trial. Ruminal pH for all treatments was below 5.8 for 14 h after feeding. Acetate:propionate ratios were less (P = 0.02) in steers fed 25% DDGS but had greater (P = 0.02) ruminal lactate concentrations compared with cattle fed 0% DDGS. Feeding 25% DDGS decreased (P < 0.01) ruminal ammonia concentrations, and digestion of DM and OM was less (P < 0.01) compared with diets without DDGS. The decrease in digestibility was largely attributable to decreases in digestion of CP (P = 0.03) and NDF (P < 0.01). Feeding strategies aimed at increasing ruminal pH and ruminally available protein may improve digestion of DDGS in steam-flaked corn-based finishing diets.

Seed-specific expression of the wheat puroindoline genes improves maize wet milling yields

The texture of maize (Zea mays L.) seeds is important to seed processing properties, and soft dent maize is preferred for both wet-milling and livestock feed applications. The puroindoline genes (Pina and Pinb) are the functional components of the wheat (Triticum aestivum L.) Hardness locus and together function to create soft grain texture in wheat. The PINs (PINA and PINB) are believed to act by binding to lipids on the surface of starch granules, preventing tight adhesion between starch granules and the surrounding protein matrix during seed maturation. Here, maize kernel structure and wet milling properties were successfully modified by the endosperm-specific expression of wheat Pins (Pina and Pinb). Pins were introduced into maize under the control of a maize gamma-Zein promoter. Three Pina/Pinb expression positive transgenic lines were evaluated over two growing seasons. Textural analysis of the maize seeds indicated that the expression of PINs decreased adhesion between starch and protein matrix and reduced maize grain hardness significantly. Reduction in pressure required to fracture kernels ranged from 15.65% to 36.86% compared with control seeds. Further, the PINs transgenic maize seeds had increased levels of extractable starch as characterized by a small scale wet milling method. Starch yield was increased by 4.86% on average without negatively impacting starch purity. The development of softer maize hybrids with higher starch extractability would be of value to maize processors.

Effects of dry-rolled or steam-flaked corn finishing diets with or without twenty-five percent dried distillers grains on ruminal fermentation and apparent total tract digestion

A metabolism study was conducted to evaluate ruminal fermentation and apparent total tract digestibilities of cattle finishing diets. Holstein steers (n = 16, 351 kg of BW) with ruminal cannulas were fed diets consisting of 0 or 25% dried corn distillers grains (DDG), using dry-rolled corn (DRC) or steam-flaked corn (SFC) as the principal energy source (2 x 2 factorial arrangement). The study was conducted in 2 periods, with 4 steers per treatment in each period. Periods consisted of a 12-d adaptation phase and a 3-d collection phase. Compared with DRC, feeding SFC decreased intakes of DM, OM, starch, NDF, and ether extract (P < 0.01), and steers fed SFC excreted less DM, OM, starch, NDF, and ether extract (P < 0.01). Compared with SFC, feeding DRC decreased ruminal concentrations of acetate, butyrate, isobutyrate, and isovalerate, and decreased the acetate-to-propionate ratio (P < 0.01). Compared with SFC, DRC decreased ruminal propionate, valerate, and lactate concentrations (P < 0.01). When compared with cattle fed SFC, ruminal pH of cattle fed DRC was less at 0 h and greater at 6 h postfeeding (P < 0.01). Ruminal ammonia concentrations were greater for DRC vs. SFC at h 0, 6, 10, 12, 14, 16, 18, 20, and 22 postfeeding (P < 0.05). Feeding DDG decreased consumption of starch and ether extract, but increased NDF intake (P < 0.01). Fecal excretion of ether extract was increased by adding DDG compared with diets without DDG (P < 0.05), resulting in less apparent total tract digestibility of ether extract for cattle fed DDG (P < 0.01). Ruminal lactate concentrations were increased with addition of DDG compared with diets without DDG (P = 0.01). Ruminal ammonia concentrations were less for steers fed 25 vs. 0% DDG at 2, 4, 6, 8, and 10 h postfeeding (P < 0.05). We conclude, based on these results, that ruminal fermentation and apparent total tract digestibility of DDG are affected by grain processing.

Hardness methods for testing maize kernels

Maize is a highly important crop to many countries around the world, through the sale of the maize crop to domestic processors and subsequent production of maize products and also provides a staple food to subsistance farms in undeveloped countries. In many countries, there have been long-term research efforts to develop a suitable hardness method that could assist the maize industry in improving efficiency in processing as well as possibly providing a quality specification for maize growers, which could attract a premium. This paper focuses specifically on hardness and reviews a number of methodologies as well as important biochemical aspects of maize that contribute to maize hardness used internationally. Numerous foods are produced from maize, and hardness has been described as having an impact on food quality. However, the basis of hardness and measurement of hardness are very general and would apply to any use of maize from any country. From the published literature, it would appear that one of the simpler methods used to measure hardness is a grinding step followed by a sieving step, using multiple sieve sizes. This would allow the range in hardness within a sample as well as average particle size and/or coarse/fine ratio to be calculated. Any of these parameters could easily be used as reference values for the development of near-infrared (NIR) spectroscopy calibrations. The development of precise NIR calibrations will provide an excellent tool for breeders, handlers, and processors to deliver specific cultivars in the case of growers and bulk loads in the case of handlers, thereby ensuring the most efficient use of maize by domestic and international processors. This paper also considers previous research describing the biochemical aspects of maize that have been related to maize hardness. Both starch and protein affect hardness, with most research focusing on the storage proteins (zeins). Both the content and composition of the zein fractions affect hardness. Genotypes and growing environment influence the final protein and starch content and, to a lesser extent, composition. However, hardness is a highly heritable trait and, hence, when a desirable level of hardness is finally agreed upon, the breeders will quickly be able to produce material with the hardness levels required by the industry.