Liquid hot water treatment of rice straw enhances anaerobic degradation and inhibits methane production during in vitro ruminal fermentation

Biowaste management by hydrothermal carbonization and anaerobic co-digestion: Synergistic effects and comparative metagenomic analysis

The feasibility of anaerobic co-digestion in semicontinuous mode of two major urban biowaste, food waste (FW) and garden and park waste (GPW) (75 % FW and 25 % GPW) as well as the co-digestion of FW with the process water originated from the hydrothermal carbonization of GPW (95 % FW and 5 % process water), both on a COD basis, has been assessed. The effect of varying organic loading rate (OLR) from 1.5 to 3.5 g COD/L·d on methane yield, gross energy recovery, and microbiome population was evaluated. For comparison, anaerobic digestion of FW was also conducted to determine the best strategy for sustainable biowaste management. This study showed an optimal OLR of 2.5 g COD/L·d. Acetic and propionic acid content increased as OLR raised for each condition studied, while methane yield decreased at the highest OLR tested indicating overloading of the system. The anaerobic co-digestion of FW and process water showed a 10 % increase on methane production compared to anaerobic digestion of FW (324 vs. 294 mL CH4 STP/L·d). Moreover, it enhances the process due to a greater abundance and diversity of hydrolytic and acidogenic bacteria belonging to Bacterioidota, Firmicutes, and Chloroflexi phyla, as well as promotes the hydrogenotrophic pathway under higher propionic concentrations which is not usually favoured for methane production. The integration of hydrothermal carbonization of GPW with the anaerobic co-digestion of 95 % FW and 5 % of process water results in the highest potential energy recovery and could be a good strategy for sustainable management of urban biowaste.

Effects of yeast culture on in vitro ruminal fermentation and microbial community of high concentrate diet in sheep

This research aimed to investigate effects of different yeast culture (YC) levels on in vitro fermentation characteristics and bacterial and fungal community under high concentrate diet. A total of 5 groups were included in the experiment: control group without YC (CON), YC1 (0.5% YC proportion of substrate dry matter), YC2 (1%), YC3 (1.5%) and YC4 (2%). After 48 h of fermentation, the incubation fluids and residues were collected to analyze the ruminal fermentation parameters and bacterial and fungal community. Results showed that the ruminal fluid pH of YC2 and YC4 groups was higher (P < 0.05) than that of CON group. Compared with CON group, the microbial protein, propionate and butyrate concentrations and cumulative gas production at 48 h of YC2 group were significantly increased (P < 0.05), whereas an opposite trend of ammonia nitrogen and lactate was observed between two groups. Microbial analysis showed that the Chao1 and Shannon indexes of YC2 group were higher (P < 0.05) than those of CON group. Additionally, YC supplementation significantly decreased (P < 0.05) Succinivibrionaceae_UCG-001, Streptococcus bovis and Neosetophoma relative abundances. An opposite tendency of Aspergillus abundance was found between CON and YC treatments. Compared with CON group, the relative abundances of Prevotella, Succiniclasticum, Butyrivibrio and Megasphaera elsdenii were significantly increased (P < 0.05) in YC2 group, while Apiotrichum and unclassified Clostridiales relative abundances were decreased (P < 0.05). In conclusion, high concentrate substrate supplemented with appropriate YC (1%) can improve ruminal fermentation and regulate bacterial and fungal composition.

Mixed ensiling plus nitrate destroy fiber structure of rape straw, increase degradation, and reduce methanogenesis through in vitro ruminal fermentation

BACKGROUND

Better utilization of rape straw can provide alternative strategies for sustainable ruminant and food production. The research reported here investigated changes in the carbohydrate composition of rape straw as a result of mixed ensiling with whole-crop corn or inoculated with nitrate, and the consequent effects on ruminal fermentation through in vitro batch culture. The three treatments included: rape straw and corn silage (RSTC), and ensiling treatment of rape straw with whole-crop corn (RSIC) or with calcium nitrate inoculation (RSICN).

RESULTS

Ensiling treatment of rape straw and whole-crop corn or plus nitrate enriched lactic acid bacteria and lactate. The treatments broke the fiber surface connections of rape straw, leading to higher neutral detergent soluble (NDS) content and lower fiber content. Ensiling treatments led to greater (P < 0.05) dry matter degradation (DMD), molar proportions of propionate and butyrate, relative abundance of the phylum Bacteroidetes and genus Prevotella, and lower (P < 0.05) methane production in terms of g kg-1 DMD, molar proportions of acetate, and lower acetate to propionate ratio than the RSTC treatment. The RSICN treatment led to the lowest (P < 0.05) hydrogen concentration and methane production among the three treatments.

CONCLUSION

Ensiling treatments of rape straw and whole-crop corn destroy the micro-structure of rape straw, promote substrate degradation by enriching the phylum Bacteroidetes and the genus Prevotella, and decrease methane production by favoring propionate and butyrate production. Nitrate inoculation in the ensiling treatment of rape straw and whole-crop corn further decreases methane production without influencing substrate degradation by providing an additional hydrogen sink. © 2023 Society of Chemical Industry.

Enhanced lignin degradation by Irpex lacteus through expanded sterilization further improved the fermentation quality and microbial community during the silage preservation process

Traditional autoclaving, slow degradation rate and preservation of biomass treated by fungi are the main factors restricting biological treatment. In our previous studies, strains with high efficiency and selective lignin degradation ability were obtained. To further solve the limiting factors of biological treatment, this paper proposed a composite treatment technology, which could replace autoclaves for fungal treatment and improve the preservation and utilization of fungal-pretreated straw. The autoclaved and expanded buckwheat straw were, respectively, degraded by Irpex lacteus for 14 days (CIL, EIL), followed by ensiling of raw materials (CK) and biodegraded straw of CIL and EIL samples with Lactobacillus plantarum for different days, respectively (CP, CIP, EIP). An expansion led to lactic acid bacteria, mold, and yeast of the samples below the detection line, and aerobic bacteria was significantly reduced, indicating a positive sterilization effect. Expansion before I. lacteus significantly enhanced lignin selective degradation by about 6%, and the absolute content of natural detergent solute was about 5% higher than that of the CIL. Moreover, EIL decreased pH by producing higher organic acids. The combination treatment created favorable conditions for ensiling. During ensiling, EIP silage produced high lactic acid about 26.83 g/kg DM and the highest acetic acid about 22.35 g/kg DM, and the pH value could be stable at 4.50. Expansion before I. lacteus optimized the microbial community for ensiling, resulting in EIP silage co-dominated by Lactobacillus, Pediococcus and Weissella, whereas only Lactobacillus was always dominant in CP and CIP silage. Clavispora gradually replaced Irpex in EIP silage, which potentially promoted lactic acid bacteria growth and acetic acid production. In vitro gas production (IVGP) in EIL was increased by 30% relative to CK and was higher than 24% in CIL. The role of expansion was more significant after ensiling, the IVGP in EIP was increased by 22% relative to CP, while that in CIP silage was only increased by 9%. Silage of fungal-treated samples reduced methane emissions by 28% to 31%. The study demonstrated that expansion provides advantages for fungal colonization and delignification, and further improves the microbial community and fermentation quality for silage, enhancing the nutrition and utilization value. This has practical application value for scaling up biological treatment and preserving the fungal-treated lignocellulose.

Production of 17 strains of edible mushroom grown on corn stover and its effect on the chemical composition and ruminal in vitro digestibility of the residual substrate

The objective of this study was to evaluate the production (P) (g of fresh mushrooms /bag) and biological efficiency (BE) (g of fresh mushrooms per 100 g of dry substrate) of 17 fungal strains, namely Pleurotus ostreatus Po-IAP, Po-P38, Po-P14, Po-IE202, Po-Sfco, Po-JP, Po-Psma, and Po-POS, Pleurotus djamour Pd-PRO and Pd-UTMR, Pleurotus eryngii Pe-MB and Pe-PQ, Lentinula edodes L15, L9, L5, and LC, and Hericium erinaceus Heri, produced in corn stover (CS) and to assess the content of crude protein (CP), lignin (L), cellulose, hemicellulose, acid detergent fiber (ADF), and neutral detergent fiber (NDF) and in vitro digestibility of dry matter (IVDMD) of the residual substrate of CS, the so called spent mushroom substrate (SMS), in comparison to the non-inoculated substrate (C). The variables were analyzed as a completely randomized block design using R 4.0.3 software. Means were compared using Tukey's procedure. The Pleurotus spp. strains, compared to Lentinula spp. and Hericium spp., presented better BE and P. In comparison to C, the SMS increased the CP content (p < 0.05) from 10.8% (Po-JP) to 70.3% (LC), while NDF decreased (p < 0.05) from 11.5% (Pd-Pro) to 33.5% (L15) and IVDMD increased (p < 0.05) from 16.2% (Heri) to 47.7% (Pd-UTMR). In conclusion, of the 17 strains evaluated, the 3 strains of Lentinula edodes (L5, L15, and L9), one strain of Pleurotus djamour (Pd-UTMR), and one strain of Pleurotus ostreatus (Po-IAP) generated a SMS that, due to its nutritional improvement and increase in IVDMD, could be used as feed for ruminants. Our results also showed that corn stover is a suitable substrate to produce Pleurotus spp. fruiting bodies, with strain Po-IAP as the best yielding.

Influence of Azadirachta indica and Cnidoscolus angustidens aqueous extract on cattle ruminal gas production and degradability in vitro

Introduction

Mitigation of ruminant greenhouse gas (GHG) emissions is crucial for more appropriate livestock production. Thus, there is a need of further research evaluating feed supplementation strategies to mitigate enteric GHG emissions and other gases produced within the rumen.

Methods

This study was conducted as a completely randomized experimental design to determine the effectiveness of liquid extracts from A. indica (AZI), C. angustidens (CNA), or their combination (Mix. 1:1) at dosages of 0, 36, 72, and 108 mg of liquid extract/g DM substrate incubated in reducing GHG production in vitro, particularly methane (CH4), from the diet of steers during anaerobic incubation in rumen fluid. Total gas production, CH4, CO, H2S, and fermentative characteristics were all measured in vitro.

Results

Treatment AZI at a dose of 108 mg of liquid extract/g DM substrate produced the highest (P < 0.05) gas volume at 6 h, whereas CNA at a dose of 72 mg of liquid extract/ g DM substrate produced the least (P < 0.05) at 6 and 24 h, and Mix. at a dose of 72 mg of liquid extract/g DM substrate produced the least (P < 0.05) at 48 h. In addition, CH4 levels at 6 and 24 h of incubation (36 mg/g DM substrate) were highest (P < 0.05) for CNA, and lowest (P < 0.05) for AZI, whereas this variable was lowest (P < 0.05) at 72 mg of liquid extract for CNA at 24 and 48 h. At 6 and 24 h, CO volume was highest (P < 0.05) for AZI at 108 mg of liquid extract and lowest (P < 0.05) for Mix. at 72 mg of liquid extract. Treatment Mix. had a high (P < 0.05) concentration of short chain fatty acids at 72 mg of liquid extract/g DM of substrate.

Discussion

In general, herbaceous perennial plants, such as AZI and CNA, could be considered suitable for mitigating enteric GHG emissions from animals. Specifically, the treatment Mix. achieved a greater sustainable reduction of 67.6% in CH4 and 47.5% in H2S production when compared to either AZI. This reduction in CH4 might suggest the potential of the combination of both plant extracts for mitigating the production of GHG from ruminants.

Effect of Unsaturated Fatty Acid Ratio In Vitro on Rumen Fermentation, Methane Concentration, and Microbial Profile

It is well known that dairy cows are fed diets with high fat content, which can adversely affect rumen fermentation. However, whether the effects of high fat content on rumen fermentation are related to the composition of fatty acids (FA) is for further study. We explored the effects of unsaturated fatty acid (UFA) ratios in vitro on rumen, methane concentration and microbial composition under the same fat levels. The experiment included a low-unsaturated group (LU, UFA proportion: 42.8%), a medium-unsaturated group (MU, UFA proportion: 56.9%), and a high-unsaturated group (HU, UFA proportion: 70.9%). The incubation fluid pH and NH3-N levels were not significantly different in the three groups. Total volatile fatty acid (TVFA), acetate, propionate, butyrate, and valerate in the MU group had a decreased trend compared to the LU group (0.05 < p < 0.1), and no difference was found in other volatile fatty acids (VFAs) among the three groups. Furthermore, gas production kinetic parameters among the three groups did not differ significantly. The LU group’s CH4 concentration was significantly higher than the HU group (p < 0.05). The CO2 concentration in the LU group was also significantly higher than the MU and LU groups (p < 0.05). Additionally, 16S rRNA microbial sequencing results showed that the Shannon diversity value significantly increased in the MU group (p < 0.05) compared to the LU group. Other alpha diversity indices (Chao 1, observed species, and ACE) did not differ among the three groups. The increased proportion of UFA significantly decreased the relative abundance of Succinivibrionaceae_UCG_001 and Fibrobacter (p < 0.05). Meanwhile, the multiple Lachnospiraceae bacteria significantly increased in the MU group (p < 0.05). Overall, our findings indicated that the microbial community in the incubation system could be affected by elevating proportions of UFA, affecting the yield of VFA, whereas the CH4 concentration was reduced.

Comparisons of Ramie and Corn Stover Silages: Effects on Chewing Activity, Rumen Fermentation, Microbiota and Methane Emissions in Goats

The study aimed to investigate the nutritional value of ramie (Boehmeria nivea) silage, and its consequences for chewing activity, rumen fermentation, and enteric methane (CH4) emissions in goats, by comparing it with corn stover (CS) silage. An in vitro ruminal experiment was firstly performed to investigate the substrate degradation and fermentation of CS and ramie silage. The ramie silage diet was formulated by replacing 60% of CS silage with ramie silage (dry matter (DM) basis). Eight female Xiangdong Black goats (a local breed in Southern China, 1 to 1.2 years of age) with BW of 21.0 ± 1.05 kg were used for this experiment and were randomly assigned to either one of the two dietary treatments in a cross-over design. The ramie silage had higher crude protein (CP) and ash content and lower hemicellulose content, together with decreased (p < 0.05) nutrient degradation and methane production and increased (p < 0.05) acetate molar percentage and acetate to propionate ratio through in vitro ruminal fermentation. Feeding the ramie silage diet did not alter feed intake (p > 0.05), decreased (p < 0.05) nutrient digestibility, and increased (p < 0.05) chewing activity and rumination activity, with reductions (p < 0.05) in eating activity and idle activity. Although feeding the ramie silage diet caused a greater (p < 0.05) molar percentage of acetate and lower molar percentage of propionate, it decreased the rumen-dissolved CH4 concentration and enteric CH4 emissions (p < 0.05). Feeding the ramie silage diet did not alter (p > 0.05) the population of bacteria, protozoa, and fungi; it increased the 16S rRNA gene copies of Ruminococcus flavefaciens (p < 0.05). Further 16SrRNA gene amplicon analysis indicated a distinct bacterial composition between the two treatments (p < 0.05). Feeding the ramie silage diet led to a lower abundance of genera Lawsonibacter, Sedimentibacter, Saccharofermentans, Sediminibacterium, and Bifidobacterium (p < 0.05). Ramie can be an alternative forage resource to stimulate chewing activity and reduce CH4 emissions in ruminants.

A Combination of Novel Microecological Agents and Molasses Role in Digestibility and Fermentation of Rice Straw by Facilitating the Ruminal Microbial Colonization

In this study, we evaluated the effect of microecological agents (MA) combined with molasses (M) on the biodegradation of rice straw in the rumen. Rice straw was pretreated in laboratory polyethylene 25 × 35 cm sterile bags with no additive control (Con), MA, and MA + M for 7, 15, 30, and 45 days, and then the efficacy of MA + M pretreatment was evaluated both in vitro and in vivo. The scanning electron microscopy, X-ray diffraction analysis, and Fourier-transform infrared spectroscopy results showed that the MA or MA + M pretreatment altered the physical and chemical structure of rice straw. Meanwhile, the ruminal microbial attachment on the surface of rice straw was significantly increased after MA+M pretreatment. Furthermore, MA + M not only promoted rice straw fermentation in vitro but also improved digestibility by specifically inducing rumen colonization of Prevotellaceae_UCG-001, Butyrivibrio, and Succinimonas. Altogether, we concluded that microecological agents and molasses could be the best choices as a biological pretreatment for rice straw to enhance its nutritive value as a ruminant's feed.

Energy recovery from food waste and garden and park waste: Anaerobic co-digestion versus hydrothermal treatment and anaerobic co-digestion

The feasibilities of the anaerobic co-digestion of two of the most relevant biowastes, food waste and garden and park waste, were evaluated and compared with the hydrothermal treatment of each waste and the anaerobic co-digestion of raw biowastes with the process water generated. The effects on the process stability and energy recovery were also analyzed. Anaerobic digestion was the best option for food waste treatment from an energetic point of view, with 81% recovery of the energy stored in the feedstock, while the highest energy recovery from garden and park waste was obtained for the solid fraction generated from hydrothermal treatment (85.5%). In addition, the anaerobic co-digestion of food waste with 5% of the process water generated from garden and park waste showed a similar energy recovery to that of food waste only (∼80%), thus improving the biological stability of the process.

Comparisons of Corn Stover Silages after Fresh- or Ripe-Corn Harvested: Effects on Digestibility and Rumen Fermentation in Growing Beef Cattle

Both waxy corn stover after fresh- (CF) and ripe-corn (CR) harvested are important byproducts of corn cropping system and have 20 d difference in harvest time. The study aimed to investigate the effects of prolonging harvest time on the nutritive value of corn stover silage by comparing CF with CR silages. In vitro ruminal experiment was firstly performed to investigate substrate degradation and fermentation of CF and CR silages. The CR diet was formulated by replacing 50% forage of CF silage with CR silage on a dry matter (DM) basis. Fourteen crossbred steers (Simmental × Limousin × local Chinese) aged 13 months with an average weight of 318.1 ± 37.1 kg were selected and randomly allocated into two dietary treatment groups. Although the CR silage had greater DM and fiber contents than CF silage, it did not alter in vitro degradation (p > 0.05), but with lower molar percentage of propionate and acetate to propionate ratio (p < 0.05). The cattle fed CR diet had a higher DM intake and lower fiber digestibility with reduction in 18S rRNA gene copies of protozoa and fungi and 16S rRNA gene copies of Fibrobacter succinogenes (p < 0.05). Further 16S rRNA gene amplicon analysis indicated a similar diversity of bacteria community between CR and CF treatments (p > 0.05). Few differences were observed in the abundance of genera larger than 1% (p > 0.05), except for the reduction in abundance of genera Ruminococcaceae_NK4A214_group in CR treatment (p < 0.05). In summary, prolonging 20 d harvest time of corn stover silage increases the forage fiber and DM content, which promotes feed intake with decreased fiber degradation, although rumen fermentation and growth performance are not changed in growing beef cattle.

In vitro Inoculation of Fresh or Frozen Rumen Fluid Distinguishes Contrasting Microbial Communities and Fermentation Induced by Increasing Forage to Concentrate Ratio

In vitro rumen batch culture is a technology to simulate rumen fermentation by inoculating microorganisms from rumen fluids. Although inocula (INO) are commonly derived from fresh rumen fluids, frozen rumen fluids are also employed for the advantages of storing, transporting, and preserving rumen microorganisms. The effects of frozen INO on microbial fermentation and community may be interfered with by substrate type, which has not been reported. This study was designed to test whether rumen fluid treatments (i.e., fresh and frozen) could interact with incubated substrates. A complete block design with fractional arrangement treatment was used to investigate the effects of INO (fresh or frozen rumen fluids) and concentrate-to-forage ratios (C/F, 1:4 or 1:1) on rumen fermentation and microbial community. The effects of increasing C/F were typical, including increased dry matter (DM) degradation and total volatile fatty acids (VFA) concentration (P < 0.001), and decreased acetate to propionate ratio (P = 0.01) and bacterial diversity of richness and evenness (P ≤ 0.005) with especially higher fermentative bacteria such as genus Rikenellaceae_RC, F082, Prevotella, Bacteroidales_BS11, Muribaculaceaege, and Christensenellaceae_R-7 (P ≤ 0.04). Although frozen INO decreased (P < 0.001) DM degradation and altered rumen fermentation with lower (P ≤ 0.01) acetate to propionate ratio and molar proportion of butyrate than fresh INO, typical effects of C/F were independent of INO, as indicated by insignificant INO × C/F interaction on substrate degradation, VFA profile and bacterial community (P ≥ 0.20). In summary, the effect of C/F on fermentation and bacterial diversity is not interfered with by INO type, and frozen INO can be used to distinguish the effect of starch content.

Fibrolytic rumen bacteria of camel and sheep and their applications in the bioconversion of barley straw to soluble sugars for biofuel production

Lignocellulosic biomass such as barley straw is a renewable and sustainable alternative to traditional feeds and could be used as bioenergy sources; however, low hydrolysis rate reduces the fermentation efficiency. Understanding the degradation and colonization of barley straw by rumen bacteria is the key step to improve the utilization of barley straw in animal feeding or biofuel production. This study evaluated the hydrolysis of barley straw as a result of the inoculation by rumen fluid of camel and sheep. Ground barley straw was incubated anaerobically with rumen inocula from three fistulated camels (FC) and three fistulated sheep (FR) for a period of 72 h. The source of rumen inoculum did not affect the disappearance of dry matter (DMD), neutral detergent fiber (NDFD). Group FR showed higher production of glucose, xylose, and gas; while higher ethanol production was associated with cellulosic hydrolysates obtained from FC group. The diversity and structure of bacterial communities attached to barley straw was investigated by Illumina Mi-Seq sequencing of V4-V5 region of 16S rRNA genes. The bacterial community was dominated by phylum Firmicutes and Bacteroidetes. The dominant genera were RC9_gut_group, Ruminococcus, Saccharofermentans, Butyrivibrio, Succiniclasticum, Selenomonas, and Streptococcus, indicating the important role of these genera in lignocellulose fermentation in the rumen. Group FR showed higher RC9_gut_group and group FC revealed higher Ruminococcus, Saccharofermentans, and Butyrivibrio. Higher enzymes activities (cellulase and xylanase) were associated with group FC. Thus, bacterial communities in camel and sheep have a great potential to improve the utilization lignocellulosic material in animal feeding and the production of biofuel and enzymes.

Brittle Culm 15 mutation alters carbohydrate composition, degradation and methanogenesis of rice straw during in vitro ruminal fermentation

Brittle Culm 15 (BC15) gene encodes a membrane-associated chitinase-like protein that participates in cellulose synthesis, and BC15 gene mutation affects cell wall composition in plant, such as cellulose or hemicellulose. The present study was designed to investigate the changes of carbohydrates composition in bc15 mutant straw, and the resulting consequence on rumen fermentation, methanogenesis, and microbial populations (qPCR) during in vitro ruminal fermentation process. Two substrates, bc15 mutant and wild-type (WT) rice straws, were selected for in vitro rumen batch culture. The first experiment was designed to investigate the kinetics of total gas and CH₄ production through 48-h in vitro ruminal fermentation, while the second experiment selected incubation time of 12 and 48 h to represent the early and late stage of in vitro ruminal incubation, respectively, and then investigated changes in biodegradation, fermentation end products, and selected representative microbial populations. The bc15 mutant straw had lower contents of cellulose, neutral detergent fiber (NDF) and acid detergent fiber (ADF), and higher contents of water-soluble carbohydrates, neutral detergent solubles (NDS) and monosaccharides. The bc15 mutant straw exhibited a distinct kinetics of 48-h total gas and CH₄ production with faster increases in early incubation when compared with WT straw. The bc15 mutant straw had higher DM degradation, NDF degradation and total volatile fatty acid concentration at 12 h of incubation, and lower NDF degradation and CH₄ production at 48 h of incubation, together with lower acetate to propionate ratio and ADF degradation and higher butyrate molar percentage and NDS degradation at both incubation times. Furthermore, the bc15 mutant straw resulted in greater 16S gene copies of F. succinogenes, with lower 18S gene copies of fungi at both incubation times. These results indicated that the BC15 gene mutation decreased fibrosis of cell wall of rice straw, enhanced degradation at the early stage of rumen fermentation, and shifts fermentation pattern from acetate to propionate and butyrate production, leading to the decreased volume and fractional rate of CH₄ production. However, BC15 gene mutation may enhance hardenability of cell wall structure of rice straw, which is more resistant for microbial colonization with decreased fiber degradation. Thus, this study modified rice straw by manipulating a cell wall biosynthesis gene and provides a potential strategy to alter degradation and CH₄ production during in vitro ruminal fermentation process.

Liquid hot water as sustainable biomass pretreatment technique for bioenergy production: A review

In recent years, lignocellulosic biomass has emerged as one of the most versatile energy sources among the research community for the production of biofuels and value-added chemicals. However, biomass pretreatment plays an important role in reducing the recalcitrant properties of lignocellulose, leading to superior quality of target products in bioenergy production. Among existing pretreatment techniques, liquid hot water (LHW) pretreatment has several outstanding advantages compared to others including minimum formation of monomeric sugars, significant removal of hemicellulose, and positive environmental impacts; however, several constraints of LHW pretreatment should be clarified. This contribution aims to provide a comprehensive analysis of reaction mechanism, reactor characteristics, influencing factors, techno-economic aspects, challenges, and prospects for LHW-based biomass pretreatment. Generally, LHW pretreatment could be widely employed in bioenergy processing from biomass, but circular economy-based advanced pretreatment techniques should be further studied in the future to achieve maximum efficiency, and minimum cost and drawbacks.

Hydrothermal pretreatment technologies for lignocellulosic biomass: A review of steam explosion and subcritical water hydrolysis

The pretreatment of lignocellulosic biomass enhances the conversion efficiency to produce biofuels and value-added chemicals, which have the potential to replace fossil fuels. Compared to physicochemical and other pretreatment techniques, the hydrothermal methods are considered eco-friendly and cost-effective. This paper reviews the strengths, weaknesses, opportunities and threats of steam explosion and subcritical water hydrolysis as the two promising hydrothermal technologies for the pretreatment of lignocellulosic biomass. Although the principle of the steam explosion in depolymerizing the lignin and exposing the cellulose fibers for bioconversion to liquid fuels is well known, its underlying mechanism for solid biofuel production is less identified. Therefore, this review provides an insight into different operating conditions of steam explosion and subcritical water hydrolysis for a wide variety of feedstocks. The mechanisms of subcritical water hydrolysis including dehydration, decarboxylation and carbonization of waste biomass are comprehensively described. Finally, the role of microwave heating in the hydrothermal pretreatment of biomass is elucidated.