Relationship between corn vitreousness and ruminal in situ starch degradability

Effects of corn grain processing and phosphorus content in calf starters on intake, growth performance, nutrient digestibility, blood metabolites, and urinary purine derivatives

Corn grain with a high phosphorus (P) content (mainly in the form of phytate-P) may need to be processed to improve the digestibility of nutrients for young calves. Processing corn grains can improve the accessibility of phytate-P to the rumen enzymes and increase the bioavailability of P, which benefits the growth and development of calves. The objective of this study was to investigate the effects of feeding starter diets with steam-flaked corn (SFC) compared with ground corn (GC) with 2 P contents of 0.4% and 0.7% DM basis on intake, growth performance, nutrient digestibility, blood metabolites and urinary purine derivatives in dairy calves. A total of 48 female Holstein dairy calves (3 d old; average initial weight 39.7 ± 3.9 kg) were randomly assigned to a 2 × 2 factorial arrangement of treatments (12 calves/treatment) in a randomized complete block design. The treatment groups were: 1) a starter diet of GC with 0.4% P (GC-0.4P); 2) a starter diet of GC with 0.7% P (GC-0.7P); 3) a starter diet of SFC with 0.4% P (SFC-0.4P); 4) a starter diet of SFC with 0.7% P (SFC-0.7P). Calves received 6 L/d of transition milk on d 2-3 and 5 L/d of whole milk on d 4-30, which was increased to 7 L/d on d 31-45, then decreased to 5 L/d on d 46-60 and reduced to a single feeding of 2 L on d 61-62. All calves had free access to starter feed and water. All calves were weaned on d 63 and remained in the study until d 83. Rumen fluid samples were collected on d 38 (pre-weaning) and d 76 (post-weaning). Blood samples were collected on d 40 and 80 and urine samples were collected on 4 consecutive days from d 79 to 82 to analyze urinary excretion of PD. The phytate-P content ranged from 0.23 to 0.17 for GC and SFC, respectively. In particular, the interaction between corn processing method and P content showed that the SFC-0.7P diets had a greater intake of starter feed during the pre- and post-weaning periods compared with the other experimental groups. In addition, calves fed the SFC-0.7P diet had greater average daily gain, body weight, withers height at weaning, better organic matter digestibility, higher blood β-hydroxybutyrate levels and higher microbial protein synthesis compared with all other groups. Feeding the SFC diet also resulted in improved feed efficiency, improved P digestibility and a tendency toward a lower rumen pH, albeit with a tendency toward an increase in blood glucose concentration during the pre-weaning period. In addition, the inclusion of 0.7% P to the starter diet resulted in increased fiber digestibility and a slight improvement in growth performance, which was particularly evident in hip height. Overall, the inclusion of SFC in the calf starter diet, especially in combination with a 0.7% DM basis P supplement, improved growth performance and nutrient utilization in dairy calves compared with GC.

Kernel properties related to carotenoid release during in vitro gastrointestinal digestion in commercial dent maize hybrids

The objective of study was to investigate the relationships between maize kernel properties and carotenoid release during simulated gastrointestinal digestion of 103 hybrids of dent type. Commercial maize hybrids significantly differed in kernel hardness, chemical composition and carotenoid profile. Across all hybrids, the amount of digestible individual carotenoids increased as follows: β-carotene < α-cryptoxanthin < β-cryptoxanthin < lutein < zeaxanthin. The amount of digested carotenoids correlated negatively with amylose content and amylose-to-amylopectin ratio, while it correlated positively with the content of neutral detergent fibres and amylopectin as well as the Stenvert index. However, the content of endosperm lipids could not be related to carotenoid digestibility. Findings clearly indicate that the carotenoid release from the kernel during digestion is related to specific physical and chemical properties, leading to a better understanding of the effects of kernel matrix structure on carotenoid digestibility in dent-type maize hybrids.

Effect of micronization and meal size of corn grain on glycemic response and in vitro hindgut acidosis potential in horses

This study aimed to 1) evaluate the interaction of corn grain micronization and starch levels per meal on equine plasma glucose, and 2) determine if micronization affects the risk of hindgut acidosis. Six mature (aged 6 to 10 years), healthy, non-pregnant mares (initial body weight [BW]: 301 to 463 kg) were used in a 2×3 factorial cross-over design. The treatments included two forms of corn grain (ground and micronized flaked) at three levels of starch (1, 1.5, and 2 g/kg BW per meal). The blood was sampled before and 30, 60, 90, 120, 180, 240, and 300 min after morning feeding and the glucose concentration in the plasma was determined. Small intestine and hindgut dry matter (DM) disappearances of ground and micronized corn were also compared using in vitro techniques. Micronized flaked corn grain showed three times more in vitro enzymatic DM disappearance (p < 0.001) compared with ground corn. Residues of in vitro enzymatic digestion of micronized flaked corn fermented 38.59 % faster than ground corn during in vitro hindgut incubation. The horses that consumed micronized flaked corn had higher post-prandial plasma glucose concentrations (p < 0.001). Increasing starch levels per meal from 1-2 g/kg BW resulted in higher plasma glucose concentrations (P = 0.005). However, no interaction of processing and starch meal size was found. Overall, processing the corn grain by micronization or increasing starch level per meal increased the plasma glucose concentrations, but the magnitude of the increases did not match that expected from in vitro studies.

Feed characteristics of dried corn grain and corn grain silage produced in Japan compared with imported corn grain

We compared the in situ dry matter degradability (ISDMD) and crude protein degradability (ISCPD) of high-moisture corn grain silage and dried corn grains produced in Japan (JHC and JDC, respectively) with corn grains imported from the United States (USC), Brazil (BRC), and South Africa (SAC). The ISDMD values of USC, BAC, and SAC were between those of JHC and JDC, but ISDMD did not differ significantly between USC and SAC. In contrast, ISDMD was lower for BAC than USC and SAC. Overall, our results indicate that ISDMD and ISCPD in the rumen differ between corn grains sources (domestic compared with imported and between production locations), primarily due to differences between the corn varieties represented. In particular, the ISDMD and ISCPD of JHC were greater than those of JDC, and this difference in degradability needs to be considered when using high-moisture corn grain silage as a substitute for dried corn grain as a feed for dairy cattle.

Apparent Metabolizable Energy and Amino Acid Digestibility of Corn of Different Origin Fed to Male Broilers from 12 to 18 Days of Age

Apparent metabolizable energy (AME) and apparent ileal amino acid digestibility (AIAAD) of corn samples from the United States (USA), Argentina (ARG), and Brazil (BRA) fed to 432 and 324 YPM × Ross 708 male broilers from 12 to 18 d of age were evaluated using the total collection method (experiment 1) and index method (experiment 2), respectively. In experiment 1, broilers were fed either a basal diet with 30% dextrose inclusion, or a test diet obtained by the replacement of dextrose with corn from each origin. In experiment 2, broilers were fed one of three test diets in which corn from each origin was the only source of AA. All dietary treatments had 12 replicate cages. Similar (p > 0.05) AME (dry-matter basis) values were observed between corn samples. The highest gap in AME (43 kcal/kg) was found between corn from BRA (3694 kcal/kg) and corn from the USA (3651 kcal/kg). Likewise, similar (p > 0.05) AIAAD values were observed for all AA apart from tryptophan (Trp), as corn from BRA (77.45%) had a higher (p = 0.024) Trp digestibility than corn from the USA (72.53%). Overall, a similar nutrient utilization by the birds was observed for the corn samples, regardless of origin.

Whole-plant flint corn silage inclusion in total mixed rations for pre- and postweaning dairy calves

Assuming that acetic acid plays a minor role in the development of ruminal epithelium of preweaning dairy calves, the fiber supply for growing calves has been neglected. More research has been done on including starch and nonfibrous carbohydrates in solid feed for preweaning calves. Accordingly, the fiber requirement of these calves is not well known, as diet recommendations vary greatly. Hence, elucidating the effects of including fiber from long particle sizes in the diet may be essential for helping calves overcome the transition challenge during weaning. Forty-five Holstein calves were used in a randomized block design, considering sex, birth date, and weight at 28 d of age, when the supply of the total mixed ration (TMR) with the inclusion of corn silage started. Three TMR with increasing whole-plant flint corn silage content (0, 10, or 20% on a dry matter basis) were compared: 0CS, 10CS, or 20CS, respectively. During the first 28 d of life, the calves were managed homogeneously and were fed 6 L/d of whole milk, a commercial calf starter pelleted, and water ad libitum. Next, the solid diet was changed to the respective solid feed treatment. Calves were gradually weaned from 52 to 56 d of age but were evaluated for an additional 14 d postweaning. Feed intake was measured daily, while body weight and metabolic indicators of intermediate metabolism were evaluated weekly. Ruminal fluid was collected at 6, 8, and 10 wk of age. Behavioral analysis was conducted on wk 7 (preweaning) and 10 (postweaning). There was a quadratic effect for dry matter intake from wk 7 to 10, with higher intake for the 10CS diet than the 0CS and 20CS diets. Consequently, the 10CS diet also promoted greater average daily gain at wk 8 and 9 compared with the 0CS and 20CS diets. However, the final body weight was not affected by the different solid diets. Silage inclusion in calves' diet positively affected time spent ruminating and chewing pre- and postweaning. Including 10% of whole-plant flint corn silage in the diets of young dairy calves is a strategy to increase total solid intake and decrease acidosis risk by increasing pH and ruminating activity around weaning.

Particle size and storage length affect fermentation and ruminal degradation of rehydrated corn grain silage

Particle size and storage time are factors that can affect the fermentation quality and digestibility of rehydrated corn grain silage (RCS). The objective of this study was to evaluate the effect of particle size and storage time on chemical and microbiological characteristics, aerobic stability, and ruminal degradability of RCS. Corn grains were ground to pass through either a 3 mm (fine) or 9 mm (coarse) screen, rehydrated to 44.3% moisture and ensiled in 200 L polyethylene buckets. Samples were taken before and after ensiling at 10, 30, 90 and 200 days of storage to assess microbial counts, fermentation end products, and DM ruminal degradability. DM degradation was evaluated with incubation times of 0 (bag wash), 3, 6 and 48 h in 3 rumen-cannulated cows. The effective ruminal degradation (ERD) was calculated based on soluble fraction (A), degradable fraction (B) and passage rate (kp) defined as 7.0%/h: A + B [kd/(kd + kp)]. Aerobic stability was evaluated in silages after 200 days of storage, and pH and temperature were analysed up to 240 h of aerobic exposure. At 90 and 200 d of storage, fine RCS resulted in lower crude protein and greater NH₃-N concentrations than coarse RCS. Coarsely ground RCS had a lower temperature at the beginning of storage than finely ground corn. Finely ground RCS had greater yeast counts and ethanol concentrations than coarsely ground RCS during storage time. Fine RCS was more susceptible to aerobic deterioration, reaching maximum temperature and pH values faster than coarse RCS. DM ruminal degradability increased over the storage time. The particle size of the rehydrated corn grain silage did not affect the kd values after 90 d of storage, while for the ERD, a long fermentation time was necessary (200 d). Considering the fermentation characteristics and the kinetics of ruminal DM degradation, fine grinding is recommended for short storage periods and coarse grinding may be a strategy to increase the rate of grinding when the storage period is greater than 200 d.

Effect of Particle Size of Silage of Flint Corn Grain on Dairy Cows Fed Tropical Pasture: Performance, Intake, Ruminal Fermentation, and Digestibility

The particle size (PS) of reconstituted corn (REC) can affect the grinding rate and starch digestibility in dairy cows. We evaluated the effect of the PS of REC ensiled for 40 days on the pasture dry matter intake (DMI), lactation performance, total tract digestibility, and ruminal fermentation of grazing dairy cows. The treatments were coarse REC (CO, 1694 µm), fine REC (FI, 1364 µm), or finely ground (GC, 366 µm) flint corn (68% vitreousness) at 29.6 ± 1.4% of diet DM (mean ± SD). Eighteen dairy cows (mean milk yield 21.3 kg/d) were split into three groups by production level and were assigned within each group to a sequence of treatments in 3 × 3 Latin squares of 21-day periods. Cows were individually fed a constant amount of whole-plant corn silage 3 ×/d (2.7 kg DM/d) and corn treatments and soybean meal according to their group. There was no significant interaction between treatment and the production level. Cows fed FI had a lower DMI (16.7 vs. 18.1 kg/d) than those fed GC, and both did not differ from CO (17.7 kg/d). There was no treatment effect on milk yield (mean: 19.2 kg/d). Cows fed CO had the lowest total tract digestibility of starch (86.3 vs. 92.3% of intake) and the highest fecal starch concentration (7.0 vs. 4.0% of DM). The NDF digestibility was lower for GC-fed cows than CO- and FI-fed cows. Plasma glucose was higher in cows fed FI and CO (75.0 mg/dL) than those fed GC (70.8 mg/dL). Ruminal volatile fatty acids and the pH did not differ. Fine grinding of REC increased the feed efficiency relative to CO and GC. Coarse grinding of REC ensiled for 40 days reduced the total tract starch digestibility relative to FI and GC.

Silage maize as a potent candidate for sustainable animal husbandry development-perspectives and strategies for genetic enhancement

Maize is recognized as the queen of cereals, with an ability to adapt to diverse agroecologies (from 58^oN to 55^oS latitude) and the highest genetic yield potential among cereals. Under contemporary conditions of global climate change, C₄ maize crops offer resilience and sustainability to ensure food, nutritional security, and farmer livelihood. In the northwestern plains of India, maize is an important alternative to paddy for crop diversification in the wake of depleting water resources, reduced farm diversity, nutrient mining, and environmental pollution due to paddy straw burning. Owing to its quick growth, high biomass, good palatability, and absence of anti-nutritional components, maize is also one of the most nutritious non-legume green fodders. It is a high-energy, low-protein forage commonly used for dairy animals like cows and buffalos, often in combination with a complementary high-protein forage such as alfalfa. Maize is also preferred for silage over other fodders due to its softness, high starch content, and sufficient soluble sugars required for proper ensiling. With a rapid population increase in developing countries like China and India, there is an upsurge in meat consumption and, hence, the requirement for animal feed, which entails high usage of maize. The global maize silage market is projected to grow at a compound annual growth rate of 7.84% from 2021 to 2030. Factors such as increasing demand for sustainable and environment-friendly food sources coupled with rising health awareness are fueling this growth. With the dairy sector growing at about 4%-5% and the increasing shortage faced for fodder, demand for silage maize is expected to increase worldwide. The progress in improved mechanization for the provision of silage maize, reduced labor demand, lack of moisture-related marketing issues as associated with grain maize, early vacancy of farms for next crops, and easy and economical form of feed to sustain household dairy sector make maize silage a profitable venture. However, sustaining the profitability of this enterprise requires the development of hybrids specific for silage production. Little attention has yet been paid to breeding for a plant ideotype for silage with specific consideration of traits such as dry matter yield, nutrient yield, energy in organic matter, genetic architecture of cell wall components determining their digestibility, stalk standability, maturity span, and losses during ensiling. This review explores the available information on the underlying genetic mechanisms and gene/gene families impacting silage yield and quality. The trade-offs between yield and nutritive value in relation to crop duration are also discussed. Based on available genetic information on inheritance and molecular aspects, breeding strategies are proposed to develop maize ideotypes for silage for the development of sustainable animal husbandry.

Effect of Corn Origin on Broiler Performance, Processing Yield, and Nutrient Digestibility from 1 to 35 Days of Age

This experiment studied the effect of feeding corn from the United States (USA), Argentina (ARG), and Brazil (BRA) on broiler performance, processing yield, and nutrient digestibility from 1 to 35 d of age. A total of 900-day old YPM × Ross 708 male broilers were randomly sorted in 36 floor pens, each containing 25 chicks and subjected to three experimental diets, resulting in 12 replications per dietary treatment. Starter, grower, and finisher diets were formulated to be only different in corn origin. Data were analyzed as a one-way ANOVA and means were separated using Tukey’s HSD test, with statistical significance considered at p ≤ 0.05. No significant differences (p > 0.05) were found in body weight, body weight gain, and feed intake from 1 to 35 d of age among the treatments. However, broilers fed diets with the inclusion of corn from the USA and BRA had a lower feed conversion ratio (FCR) compared with broilers fed diets with corn from ARG from to 1 to 35 d of age (1.434 and 1.434 vs. 1.452 g:g; p = 0.002). Broilers fed diets with the inclusion of corn from BRA had a higher breast weight compared with broilers fed diets with the inclusion of corn from ARG (575 vs. 553 g; p = 0.036), but did not differ in breast weight of broilers fed diets with corn from the USA (575 vs. 556 g; p > 0.05). Corn origin did not influence (p > 0.05) crude protein and fat digestibility. However, broilers fed diets with corn from the USA and BRA had greater phosphorus (P) (63.37, 62.23 vs. 55.26%; p = 0.0003), calcium (Ca) (41.59, 43.85 vs. 30.23%; p = 0.0003), and potassium (K) (88.98, 87.97 vs. 86.04%; p = 0.001) digestibility compared with broilers fed diets with corn from ARG. Overall, corn origin influenced FCR, breast weight, and P, Ca, and K digestibility of broilers from 1 to 35 d of age.

Ruminal responses, digestibility, and blood parameters of beef cattle fed diets without forage with different hybrids and processing of the corn

The objective of this study was to evaluate the effects of corn hybrid and processing methods on intake and digestibility of nutrients, rumen fermentation and blood metabolites of steers fed no-forage finishing diets. Four ruminally fistulated Nellore castrated steers (502 ± 15 kg initial body weight) were distributed in a 4 × 4 Latin square design with a 2 × 2 factorial arrangement consisting of two corn hybrids (semi-dent and flint) and two processing methods (dry milled and high moisture grain). Interactions of hybrid and processing methods were observed on intake of dry matter (DM), organic matter (OM) and crude protein (CP), as well as on digestibility of DM and CP, rumen pH and ammonia nitrogen (N-NH₃ ). There was no interaction between hybrid and processing for the volatile fatty acids (VFA) total, acetate (C2), propionate (C3), isobutyric (iC4) and valeric (nC5) concentrations. VFA total concentration shown an average of 103.4 mmol/L. The C2 and C3 concentrations had no effect of the hybrid or processing with averages of 58.7 mmol/L for C2, and 31.3 mmol/l for C3. There was an effect of the processing method on starch consumption and fecal pH, the highest values were observed in grains with high moisture content. Starch digestibility was 0.89 g/g in dry milled and 0.96 g/g in high moisture corn. The greatest digestibility of starch in high moisture corn, irrespective of the corn hybrid, provided evidence of an increase in the energy supply, which may improve the feed efficiency and growth performance of cattle fed no-roughage finishing diets.

Effects of feeding different probiotic types on metabolic, performance, and carcass responses of Bos indicus feedlot cattle offered a high-concentrate diet

Two experiments were designed to evaluate the effects of different probiotic combinations on rumen fermentation characteristics, performance, and carcass characteristics of feedlot Bos indicus beef bulls offered a high-concentrate diet. In experiment 1, 30 rumen-fistulated Nellore steers were blocked by initial body weight (BW = 350 ± 35.0 kg) and within blocks (n = 10), animals were randomly assigned to receive: 1) high-concentrate diet without probiotic supplementation (n = 10; CONT), 2) CONT plus 1 g per head of a probiotic mixture containing three strains of Enterococcus faecium and one strain of Saccharomyces cerevisiae (3.5 × 109 CFU/g; n = 10; EFSC), and 3) CONT plus 2 g per head of a probiotic mixture containing Bacillus licheniformis and Bacillus subtilis (3.2 × 109 CFU/g; n = 10; BLBS). The experimental period lasted 35 d, being 28 d of adaptation and 7 d of sampling. From day 34 to day 35 of the experimental period, ruminal fluid and fecal samples were collected every 3 h, starting immediately before feeding (0 h) for rumen fermentation characteristics and apparent nutrient digestibility analysis, respectively. In experiment 2, 240 Nellore bulls were ranked by initial shrunk BW (375 ± 35.1 kg), assigned to pens (n = 4 bulls per pen), and pens randomly assigned to receive the same treatments as in experiment 1 (n = 20 pens per treatment). Regardless of treatment, all bulls received the same step-up and finishing diets throughout the experimental period, which lasted 115 d. In both experiments, data were analyzed as orthogonal contrasts to partition-specific treatment effects: 1) probiotic effect: CONT vs. PROB and 2) probiotic type: EFSC vs. BLBS (SAS Software Inc.). In experiment 1, no contrast effects were observed on nutrient intake, overall nutrient digestibility, and rumen fermentation analyses (P ≥ 0.13). Nonetheless, supplementation of probiotics, regardless of type (P = 0.59), reduced mean acetate:propionate ratio and rumen ammonia-N concentration vs. CONT (P ≤ 0.05). In experiment 2, no significant effects were observed for final BW and dry matter intake (P ≥ 0.12), but average daily gain and feed efficiency tended to improve (P ≤ 0.10) when probiotics were offered to the animals. Probiotic supplementation or type of probiotic did not affect carcass traits (P ≥ 0.22). In summary, supplementation of probiotics containing a mixture of E. faecium and S. cerevisiae or a mixture of B. licheniformis and B. subtilis reduced rumen acetate:propionate ratio and rumen ammonia-N levels and tended to improve the performance of feedlot cattle offered a high-concentrate diet.

Effects of different moist orange pulp inclusions in the corn grain rehydration for silage production on chemical composition, fermentation, aerobic stability, microbiological profile, and losses

This study evaluated the effects of different moist orange pulp (MOP) inclusions in corn grain rehydration for silage production as a strategy to store and use MOP and whether these inclusions result in adequate fermentation and aerobic stability (AE) and acceptable losses. Ground corn grain and MOP were weighed separately and mixed to obtain MOP inclusions of 21%, 34%, or 42%. The control treatment was obtained with corn rehydrated with distilled water and MOP inclusion of 0%, with five laboratory silos (15-L buckets) per treatment. Acid detergent fiber, acid detergent insoluble protein, acid detergent lignin, lactic acid, acetic acid, and ethanol contents increased linearly with increasing MOP inclusion, whereas starch, in vitro dry matter (DM) digestibility and butyric acid contents and pH decreased linearly. NH₃ -N/TN content reduced quadratically and was minimal with 8.34 g/kg DM at 14% MOP inclusion. Total DM losses increased quadratically with maximal losses of 4.26% DM at 25% MOP inclusion. AE reduced by 2.8 h for each 1% increase in MOP inclusion. Rehydration of corn grain with MOP results in an adequate fermentation process. The inclusion of 34% MOP was the best because DM losses were lower and AE was not drastically reduced.

Physical and chemical kernel traits affect starch digestibility and glycemic index of cooked maize flours

Maize starch is an important carbohydrate source in human diet, and its digestion contributes to the postprandial blood glucose level. This article describes in vitro starch digestibility and its relation to endosperm hardness and composition in cooked maize flours. Starch digestion and estimated glycemic index (GI) were significantly (p < 0.05) lower in hard endosperm genotypes (65.1 and 77.3, respectively) than in soft ones (70.7 and 80.7, respectively), and they were negatively correlated (p < 0.05) with specific zein concentrations (total zeins, Z1, Z2, and C1, E, and F zeins). Cooking with sodium sulfite significantly (p < 0.001) increased starch hydrolysis in all genotypes (∼13%), evidencing the impact of disulfide bonds on this attribute. Explored amylose:starch ratios did not impact starch digestibility. Regardless of hardness, fine grinding significantly (p < 0.001) increased total starch digestibility in >30%. Our results focus on specific kernel physicochemical traits for developing maize food products with lower starch digestibility and GI.

Effects of grain adaptation programs and antimicrobial feed additives on performance and nutrient digestibility of Bos indicus cattle fed whole shelled corn

Two experiments were conducted to evaluate the effects of feed additives [monensin (MON); 30 mg/kg of dry matter (DM), and virginiamycin (VM); 25 mg/kg DM] and grain adaptation programs [adding roughage (ROU; sugarcane bagasse) or not (NO-ROU) during the 20-d adaptation period] on performance, carcass characteristics, and nutrient digestibility of Bos indicus cattle fed finishing diets containing 85% whole shelled corn and 15% of a pelleted protein-mineral-vitamin supplement. In Exp.1, 105 Nellore bulls [initial body weight (BW) = 368 ± 25 kg] were used in a complete randomized block design with a 2 × 2 factorial arrangement of treatments, consisting of two feed additives (MON and VM) associated with two adaptation programs (ROU or NO-ROU during the 20-d adaptation period). Effects of feed additives × adaptation programs were not detected (P ≥ 0.13). Feed additives did not affect dry matter intake (DMI), average daily gain (ADG), and feed efficiency (G:F) during the 20-d adaptation period (P ≥ 0.35). During the total feeding period (105 d), feeding MON decreased DMI (P ≤ 0.03) compared to VM. Adding sugarcane bagasse to finishing diets during the 20-d adaptation period (ROU) increased ADG (P = 0.05) and G:F (P = 0.03), and tended to increase BW (P = 0.09) compared to NO-ROU. In Exp. 2, 10 ruminally cannulated Nellore steers (BW = 268 ± 38 kg) were used in a completely randomized design to evaluate the effects of the two feed additives used in the Exp. 1 (MON and VM; 5 steers/treatment) on DMI, total apparent digestibility of nutrients, and ruminal fermentation characteristics. No differences in DMI, total tract apparent digestibility of nutrients, and ruminal fermentation characteristics were observed between MON and VM (P ≥ 0.32). An effect of sampling day (P < 0.001) was observed for ruminal pH, which was greater on day 0 compared to day 7, 14, and 21 of the experimental period (P ≤ 0.05). In summary, supplementing monensin and virginiamycin for finishing Nellore bulls fed whole shelled corn diets, resulted in similar growth performance and carcass characteristics. Including sugarcane bagasse to adapt finishing bulls to no-roughage diets containing whole shelled corn is an alternative to increase growth performance.

Feeding Grazing Dairy Cows With Different Energy Sources on Recovery of Human-Edible Nutrients in Milk and Environmental Impact

The use of grazing systems for milk production is widely used globally because it is a lower-cost feeding system. However, under tropical conditions, the energy content of pastures became is a limitation to improve animal performance and efficiency while reducing the environmental impact. The objective of our study was to evaluate the impact of supplying different dietary sources of energy to lactating dairy cows grazing tropical pastures on the recovery of human-edible (HE) nutrients in milk and the environmental impact. Two experiments were conducted simultaneously. In experiment 1, forty early lactating dairy cows were used in a randomized block design. In experiment 2, four late-lactating rumen-cannulated dairy cows were used in a 4 × 4 Latin Square design. All cows had free access to pasture and treatments were applied individually as a concentrate supplement. Treatments were flint corn grain-processing method either as fine ground (FGC) or steam-flaked (SFC) associated with Ca salts of palm fatty acids supplementation either not supplemented (CON) or supplemented (CSPO). We observed that feeding cows with SFC markedly reduced urinary nitrogen excretion by 43%, and improved milk nitrogen efficiency by 17% when compared with FGC. Additionally, we also observed that feeding supplemental fat improved milk nitrogen efficiency by 17% compared with cows receiving CON diets. A tendency for decreased methane (CH4) per unit of milk (−31%), CH4 per unit of milk energy output (−29%), and CH4 per unit of milk protein output (−31%) was observed when CSPO was fed compared with CON. Additionally, SFC diets increased HE recovery of indispensable amino acids by 7–9% when compared with FGC diets, whereas feeding supplemental fat improved HE recovery of indispensable amino acids by 17–19% compared with CON. Altogether, this study increased our understanding of how manipulating energy sources in the dairy cow diet under tropical grazing conditions can benefit HE nutrient recovery and reduce nutrient excretion.

Effects of exogenous α-amylases, glucoamylases, and proteases on ruminal in vitro dry matter and starch digestibility, gas production, and volatile fatty acids of mature dent corn grain

Two separate experiments were carried out to evaluate the effects of incremental doses of 10 exogenous endo-acting α-amylase and exo-acting glucoamylase; 1LAT (bacterial α-amylase), 2AK, 3AC, 4Cs4, 5Trga, 6Afuga, 7Fvga, and 10Tg (fungal α-amylases, glucoamylases, and α-glucosidase), 8Star and 9Syn (fungal amylase-mixtures; experiment 1) and three exogenous proteases; 11P14L, 12P7L, and 13P30L (bacterial proteases; experiment 2) on in vitro dry matter digestibility (IVDMD) and in vitro starch digestibility (IVSD) of mature dent corn grain using a batch culture system. Incremental doses of the exogenous enzymes (0, 0.25, 0.50, 0.75, and 1.00 mg/g of dried substrate) were applied directly to the substrate (0.5 g of ground corn, 4 mm) in sextuplicate (experiment 1) or quadruplicate (experiment 2) within F57 filter bags, which were incubated at 39 °C in buffered rumen fluid for 7 h. Rumen fluid was collected 2-3 h after the morning feeding from three lactating dairy cows and pooled. Cows were consuming a midlactation total mixed ration (TMR; 1.60 Mcal/kg DM and 15.4%; net energy of lactation and crude protein, respectively). Three independent runs were carried out for each experiment. Data were analyzed as a randomized complete block design using run as the blocking factor. Dose was used as a fixed factor while run was considered a random factor. Linear, quadratic, and cubic orthogonal contrasts were also tested. In experiment 1, enzymes 2AK, 3AC, and 10Tg did not increase (P > 0.10) IVDMD and IVSD, whereas 0.25 mg of enzymes 1LAT, 5Trga, and 8Star increased (P < 0.01) IVDMD by 23%, 47%, and 62% and IVSD by 35%, 41%, and 58%, respectively, compared with the control. Enzymes 4Cs4, 6Afuga, 7Fvga, and 9Syn linearly increased IVDMD and IVSD (P < 0.01). Greatest increases in IVDMD (82.9%) and IVSD (85.9%) resulted with 1 mg of 6Afuga compared to control. In experiment 2, the lowest dose of exogenous proteases 11P14L and 12P7L increased (P < 0.01) IVDMD by 98% and 87% and IVSD by 57% and 64%, respectively, whereas the highest dose of 13P30L increased (P = 0.02) IVDMD by 44.8% and IVSD by 30%, relative to the control. In conclusion, IVSD and IVDMD were increased by one α-amylase, certain glucoamylases, and all proteases tested, with the glucoamylase 6Afuga in experiment 1 and the neutral protease 12P7L in experiment 2, increasing IVDMD and IVSD to the greater extents. Future in vivo studies are required to validate these findings before these enzyme additives can be recommended for improving the digestibility of mature dent corn grain.

Effect of kernel processing and particle size of whole-plant corn silage with vitreous endosperm on dairy cow performance

Kernel processing and theoretical length of cut (TLOC) of whole-plant corn silage (WPCS) can affect feed intake, digestibility, and performance of dairy cows. The objective of this study was to evaluate for lactating dairy cows the effects of kernel processing and TLOC of WPCS with vitreous endosperm. The treatments were a pull-type forage harvester without kernel processor set for a 6-mm TLOC (PT6) and a self-propelled forage harvester with kernel processor set for a 6-mm TLOC (SP6), 12-mm TLOC (SP12), and 18-mm TLOC (SP18). Processing scores of the WPCS were 32.1% (PT6), 53.9% (SP6), 49.0% (SP12), and 40.1% (SP18). Twenty-four Holstein cows (139 ± 63 d in milk) were blocked and assigned to six 4 × 4 Latin squares with 24-d periods (18 d of adaptation). Diets were formulated to contain 48.5% WPCS, 15.5% citrus pulp, 15.0% dry ground corn, 9.5% soybean meal, 6.8% low rumen degradability soybean meal, 1.8% calcium soap of palm fatty acids (FA), 1.7% mineral and vitamin mix, and 1% urea (dry matter basis). Nutrient composition of the diets (% of dry matter) was 16.5% crude protein, 28.9% neutral detergent fiber, and 25.4% starch. Three orthogonal contrasts were used to compare treatments: effect of kernel processing (PT6 vs. SP6) and effect of TLOC (particle size; SP6 vs. SP12 and SP12 vs. SP18). Cows fed SP6 produced 1.2 kg/d greater milk yield with no changes in dry matter intake, resulting in greater feed efficiency compared with PT6. Cows fed SP6 also produced more milk protein (+36 g/d), lactose (+61 g/d), and total solids (+94 g/d) than cows fed PT6. The mechanism for increased yield of milk and milk components involved greater kernel fragmentation, starch digestibility, and glucose availability for lactose synthesis by the mammary gland. However, cows fed SP6 had lower chewing time and tended to have greater levels of serum amyloid A compared with PT6. Milk yield was similar for SP6 and SP12, but SP12 cows tended to have less serum amyloid A with greater chewing time. Cows fed SP18 had lower total-tract starch digestibility and tended to have lower plasma glucose and produce less milk compared with cows fed SP12. Compared with PT6, feeding SP6 raised linear odd-chain FA concentration in milk. Similarly, a reduction of these same FA occurred for SP12 compared with SP6. Cows fed SP6 had greater proportion of milk C14:1 and C16:1 compared with PT6 and SP12. Lesser trans C18:1 followed by greater C18:0 concentrations were observed for SP12 and PT6 compared with SP6, which is an indication of more complete biohydrogenation in the rumen. Under the conditions of this study, the use of a self-propelled forage harvester with kernel processing set for a 12-mm TLOC is recommended for WPCS from hybrids with vitreous endosperm.

Propylene Glycol and Maize Grain Supplementation Improve Fertility Parameters in Dairy Cows

Simple Summary

The excessive mobilization of fatty acids from dairy cows’ adipose tissue increases blood non-esterified fatty acid concentrations and could have a negative effect on the fertility parameters and milk yield, as well as increase the risk of metabolic disorders and also result in early-lactation culling risk. Propylene glycol and rumen-protected starch from maize grain are commonly used as glucose precursors reducing nonesterified fatty acid levels; however, no such comparisons are available, thus it was decided to assume it as the aim of this study. Propylene glycol had a positive effect on shortening the period to first ovulation. Propylene glycol and maize grain improved the first service conception rate and decreased the number of services per conception in cows. In conclusion, both treatments with propylene glycol and maize grain had a slight effect on the metabolic profile and no effect on milking performance, yet they improved fertility parameters, which could indirectly enhance milk production economics.

Abstract

The aim of the study was to determine the effect of propylene glycol and maize grain content by-pass starch supplementation during the transition period and the first 56 days of lactation on blood metabolic indices, milk production and fertility parameters in dairy cows. Seventy-five Polish Holstein-Friesian dairy cows were assigned to treatment 21 days before calving. The treatments included: TG—2.5 kg triticale grain/cow per day supplemented from 14 days prepartum to day 56 postpartum, PG—2.5 kg triticale grain/cow per day supplemented from day 14 before parturition to day 56 postpartum, and 400 g propylene glycol/cow per day from 14 days prepartum to 14 days of lactation and MG—2.5 kg maize grain/cow per day supplemented from day 14 before parturition to day 56 postpartum. PG and MG had an effect resulting in the highest glucose concentration at 28 d of lactation. Cows assigned to the PG and MG groups had significantly higher cholesterol levels confronted with TG group at day 14 of lactation, while at days 28 and 56 the same difference was observed only between the MG and TG groups. PG had an effect on shortening the period to first ovulation. PG and MG improved the first service conception rate and decreased the number of services per conception in cows. In conclusion, both treatments of dairy cows with PG and MG improved their fertility parameters, while they had a slight effect on their metabolic profile and no effect on their milking performance.

Effects of processing, moisture, and storage length on the fermentation profile, particle size, and ruminal disappearance of reconstituted corn grain

Our objective was to examine the effects of processing, moisture, and anaerobic storage length of reconstituted corn grain (RCG) on the fermentation profile, geometric mean particle size (GMPS), and ruminal dry matter disappearance (DMD). Dry corn kernels were ground (hammer mill, 5-mm screen) or rolled, then rehydrated to 30%, 35%, or 40% moisture, and stored for 0, 14, 30, 60, 90, 120, or 180 d in laboratory silos. Rolled corn had an increased GMPS compared with ground corn (2.24 and 1.13 mm, respectively, at ensiling). However, there was a trend for an interaction between processing and moisture concentration to affect particle size, with GMPS increasing with increased moisture concentration, especially in ground corn. Longer storage periods also slightly increased GMPS. Processing, moisture, and storage length interacted to affect the fermentation pattern (two- or three-way interactions). Overall, pH decreased, whereas lactic acid, acetic acid, ethanol, and NH3-N increased with storage length. RCG with 30% moisture had less lactic acid than corn with 35% and 40% moisture, indicating that fermentation might have been curtailed and also due to the clostridial fermentation that converts lactic acid to butyric acid. Ensiling reconstituted ground corn with 30% of moisture led to greater concentrations of ethanol and butyric acid, resulting in greater DM loss than grain rehydrated to 35% or 40% of moisture. Ammonia-N and in situ ruminal DMD were highest for reconstituted ground corn with 35% or 40% of moisture, mainly after 60 d of storage. Therefore, longer storage periods and greater moisture contents did not offset the negative effect of greater particle size on the in situ ruminal DMD of rolled RCG. Nonetheless, RCG should be ensiled with more than 30% moisture and stored for at least 2 mo to improve the ruminal DMD and reduce the formation of ethanol and butyric acid.

Whole-flint corn grain or tropical grass hay free choice in the diet of dairy calves

Tropical grass hay feeding is related to improved ruminal health; however, it may decrease energy intake. On the other hand, whole-flint corn grain may be an alternative fiber source in the diet of dairy calves. Forty-two Holstein calves were used in a randomized block design, considering sex, birth date, and weight at 21 d of age, when the supply of whole-flint corn grain or tropical grass hay started. Three component-fed solid diets were compared: (1) starter concentrate only during the preweaning and starter concentrate with free choice of chopped Tifton-85 hay postweaning (SC), (2) starter concentrate with free choice of chopped Tifton-85 hay pre- and postweaning (SCH), and (3) starter concentrate with free choice of whole-flint corn grain pre- and postweaning (SCW). The animals were evaluated from 21 to 84 d of age. Calves were managed equally during the first 21 d, fed with 6 L/d of whole milk and a commercial starter concentrate (46% nonfiber carbohydrates, small particles, and pelleted) ad libitum. After that, milk feeding was reduced to 4 L/d until gradual weaning at 56 d of age. At 56 d of age, 4 animals per treatment were randomly chosen to be slaughtered for digestive tract weight evaluation and to collect tissue for histological analysis of the ruminal wall, duodenum, and cecum, whereas the other 30 animals were weaned and evaluated for a further 22 d when the SC diet also received hay ad libitum. Feed intake was measured daily. Weight gain and metabolic indicators of intermediate metabolism were evaluated weekly. Ruminal fluid was collected at wk 6, 8, 10, and 12 of age. The SCH diet increased the total and starter dry matter intake, and consequently, the average daily gain and body weight at 56 d of age. The SCW diet promoted an increase in propionate and decreased acetate-to-propionate ratio. Morphometric variables were affected by the SCH diet. The postweaning performance was unaffected by solid diets; however, the SCW diet decreased ruminal and fecal pH. Feeding hay, starting at 21 d of age, can stimulate early solid diet intake, promoting better performance and ruminal and intestinal development, when a highly fermentable and small particle pelleted starter is fed.

Rehydration of dry corn preserves the desirable bacterial community during ensiling

This study evaluated the rehydration approach of mature corn grains as an alternative for high-moisture corn grain silage production in distinct corn hybrids, storage period, cultivation locations and kernel maturity at plant harvest. High-moisture corn was used as a control. The dry matter content and pH of the silage were measured, and the bacterial community associated with corn grains pre- and post-ensiling was also assessed through 16S rRNA high-throughput sequencing. The decrease in pH value was directly linked to an ecological microbial succession of Enterobacteriales and Actinomycetales to Lactobacillales in the silage at 120 days after storage, either in rehydrated or high-moisture corn. These results were similar for both maize production locations and hybrids tested. Finally, the similarity between the ensiling processes including rehydrated corn and the high-moisture corn grain silages proves the reliability of the rehydration approach as an alternative for the maintenance of a successful bacterial community structure and composition capable of producing high-quality silages from dent and flint corn hybrids in tropical conditions.

Effects of source and concentration of neutral detergent fiber from roughage in beef cattle diets on feed intake, ingestive behavior, and ruminal kinetics

The objectives of this research were to evaluate the effects of source and concentration of α-amylase-treated neutral detergent fiber (aNDF) from roughage on feed intake, ingestive behavior, and ruminal kinetics in beef cattle receiving high-concentrate diets. Six ruminally cannulated Nellore steers (408 ± 12 kg of body weight) were randomly assigned to a 6 × 6 Latin square design with six diets: 10% aNDF from corn silage (10CS); 20% aNDF from corn silage (20CS); or four diets containing 10% aNDF from corn silage and 10% aNDF from one of the following sources: sugarcane (SC), sugarcane bagasse (SCB), soybean hulls (SH), or low oil cottonseed hulls (LOCH). The parameters of passage and degradation kinetics were estimated based on a two-compartmental model with gamma- and exponential-distributed residence times. The nonlinear models were fitted by nonlinear least squares, and a linear mixed-effects model was fitted to all variables measured from the Latin square design that were related to intake, digestibility, digestion kinetic parameters, and residence times. Mean particle size (MPS) between roughage sources (CS, SCB, and SC) and coproducts (SH and LOCH) was affected (P < 0.05). Dry matter intake (DMI) was not affected (P > 0.05) by 20CS, SC, SH, or LOCH. Steers fed 20CS or LOCH diets had 16% and 20% greater DMI, respectively, (P < 0.05) than steers fed 10CS diet. Steers fed SCB consumed the least dry matter (DM). The SH and LOCH diets had lower MPS values (about 8.77 mm) in comparison to 20CS, SCB, and SC diets (about 13.08 mm) and, consequently, affected (P < 0.05) rumen content, ruminal in situ disappearance, nutrient digestibility, and solid fractional passage rate. Chewing time was affected (P < 0.05) by roughage sources and concentration. Lower values of distance travel inside the rumen (min/cm) were observed (P < 0.05) for the SCB and SC diets in comparison with any other diet. Except for SCB, there was no difference (P > 0.05) in rumen fill, among other treatments. Mean daily ruminal pH was not affected (P > 0.05) by 20CS, SCB, SC, and LOCH diets, and it ranged from 6.1 to 6.23. Total short-chain fatty acids concentration was affected (P < 0.05) by roughage source and concentration. Based on our results, we recommend that under Brazilian finishing diets, replacing roughage sources, except for SCB, based on aNDF concentration of the roughage in high-concentrate diets containing finely ground flint corn does not affect DMI.

Fibrolytic enzymes improve the nutritive value of high-moisture corn for finishing bulls

Exogenous fibrolytic enzymes (EFE) improve the energy availability of grains for nonruminant animals by reducing encapsulation of the endosperm nutrients within grain cell walls; however, these benefits are unknown in the treatment of corn-based silage for cattle. The objective of the present study was to evaluate the effects of adding EFE at ensiling on the nutritive value of high-moisture corn (HMC) and snaplage (SNAP) for finishing Nellore bulls. The EFE dose was 100 g/Mg fresh matter in both HMC and SNAP. Diets were 1) a SNAP + HMC control (without enzyme addition); 2) SNAP + HMC EFE (with enzymes); 3) a whole-plant corn silage (WPCS) + HMC control (without enzyme addition); and 4) WPCS + HMC EFE (with enzymes). In addition to the silages, the diets were also composed of soybean hulls, soybean meal, and mineral-vitamin supplement. The statistical design was a randomized complete block with a factorial arrangement of treatments, and the experiment lasted 122 d. For in situ and in vitro analyses, 2 cannulated dry cows were used. There was no interaction between the diets and EFE application (ADG, P = 0.92; DMI, P = 0.77; G:F, P = 0.70), and there was no difference between the SNAP and WPCS diets regarding the DMI (P = 0.53), ADG (P = 0.35), and feed efficiency (ADG:DMI, P = 0.83). Adding EFE to the HMC and SNAP at ensiling did not affect ADG but decreased DMI (P = 0.01), resulting in greater feed efficiency by 5.91% (P = 0.04) than that observed in animals fed diets without the addition of EFE. Addition of EFE to HMC resulted in reduced NDF content and increased in vitro and in situ DM digestibility compared with untreated HMC. No effects were found for the addition of EFE to SNAP. Fecal starch decreased with EFE application (P = 0.05). Therefore, the diet energy content (TDN, NEm, and NEg) calculated from animal performance increased (P = 0.01) with the addition of EFE to HMC. In conclusion, exchanging the NDF from WPCS with that from SNAP did not affect the performance of finishing cattle, whereas the addition of EFE to HMC at ensiling improved animal performance by increasing the energy availability of the grain.

Effects of dietary roughage neutral detergent fiber levels and flint corn processing method on growth performance, carcass characteristics, feeding behavior, and rumen morphometrics of Bos indicus cattle1

Flint corn processing method [coarse ground corn (CGC; 3.2 mm average particle size) or steam-flaked corn (SFC; 0.360 kg/L flake density)] was evaluated in conjunction with 4 levels of NDF from sugarcane bagasse (SCB) as roughage source (RNDF; 4%, 7%, 10%, and 13%; DM basis) to determine impact on growth performance, carcass characteristics, starch utilization, feeding behavior, and rumen morphometrics of Bos indicus beef cattle. Two hundred and forty Nellore bulls were blocked by initial BW (350 ± 37 kg), assigned to 32 feedlot pens and pens within weight block were randomly assigned, in a 2 × 4 factorial arrangement (2 corn processing and 4 levels of RNDF) to treatments. Effects of corn grain processing × RNDF level were not detected (P ≥ 0.14) for growth performance, dietary net energy concentration, carcass traits, rumen morphometrics, and feeding behavior, except for time spent ruminating and time spent resting (P ≤ 0.04), and a tendency for papillae width (P ≤ 0.09). Bulls fed SFC-based diets consumed 7% less (P = 0.001), had 10.6% greater carcass-adjusted ADG (P < 0.001) and 19% greater carcass-adjusted feed efficiency (P < 0.001) compared with bulls fed CGC-based diets. Observed net energy for maintenance and gain values were 14.9% and 19.4% greater (P < 0.001), respectively, for SFC than for CGC-based diets. Fecal starch concentration was less (P < 0.001) for bulls fed SFC compared with those fed CGC. No grain processing effects were detected (P = 0.51) for rumenitis score; however, cattle fed SFC presented smaller ruminal absorptive surface area (P = 0.03). Dry matter intake increased linearly (P = 0.02) and carcass-adjusted feed efficiency tended (P = 0.06) to decrease linearly as RNDF increased. Dietary RNDF concentration did not affect carcass characteristics (P ≥ 0.19), except for dressing percentage, which tended to decrease linearly (P = 0.06) as RNDF in finishing diets increased. Increasing RNDF in finishing diets had no effect (P = 0.26) on time spent eating, but time spent ruminating and resting increased linearly (min/d; P < 0.001) with increased dietary RNDF. Steam flaking markedly increased flint corn energy value, net energy of diets, and animal growth performance, and led to improvements on feed efficiency when compared with grinding, regardless of RNDF content of diets. Increasing dietary RNDF compromised feedlot cattle feed efficiency and carcass dressing.

Lactation performance of dairy cows fed rehydrated and ensiled corn grain differing in particle size and proportion in the diet

Rehydrated and ensiled mature ground corn has high ruminal starch digestibility, but particle size (PS) and dietary starch proportion (ST) can affect starch digestion and lactating cow performance. We evaluated the effect of rehydrated and ensiled corn (REC), PS, and ST on intake, lactation performance, nutrient digestibility, ruminal fermentation profile, and chewing behavior of dairy cows. Kernels from an 84% vitreousness hybrid were finely (FN) or coarsely (CS) ground, yielding geometric mean particle sizes of 1,591 and 2,185 µm, respectively. Ground kernels were rehydrated [60% dry matter (DM)] and ensiled in 200-L buckets for ≥205 d. The grinding rate (t/h) was 3.9 for FN and 11.7 for CS. The PS did not affect DM loss (11.3% of ensiled) or silage pH (3.8). Samples of each bucket (n = 15/PS) before and after silage fermentation were incubated in situ for 0, 3, 6, 18, and 48 h in 4 rumen-cannulated lactating cows. Ensiling increased the effective ruminal in situ DM degradation (63.7 vs. 34.1%), regardless of PS. Sixteen Holstein cows (152 ± 96 d in milk) in 4 × 4 Latin squares (21-d periods) were individually fed a 2 × 2 factorial combination of low (LO) or high (HI) starch diets with FN or CS. Cows were fed the same REC incubated in situ. Varied concentration of starch in the diet (29.2 vs. 23.5% of DM) was achieved by partial replacement of REC (22.0 vs. 14.2% of DM) with citrus pulp (0 vs. 8.2% of DM). Milk, protein, fat, and lactose yields did not differ. Milk fat percentage was reduced and protein percentage was increased by HI. Treatment FN increased feed efficiency (energy-corrected milk/digestible organic matter intake) when fed with HI. Total-tract starch digestibility tended to be reduced by CS (96.4 vs. 97.2% of starch intake). Serum β-hydroxybutyrate was increased by LO. High-starch diet reduced the molar proportions of acetate and butyrate in ruminal fluid and increased propionate and isoacids. Particle size did not affect ruminal fermentation profile. Coarse grinding reduced plasma d-lactate concentration with HI. Diet HI reduced the proportion of daily intake from 1900 to 0700 h and induced preferential intake of feed particles <8 mm and greater refusal of particles >19 mm in the morning. Fine REC reduced rumination time per day and increased eating time per DM intake. Milk and plasma urea-N did not differ. Ensiling of mature flint corn for >200 d largely eliminated the effect of the PS of REC on the studied outcomes. The proportion of REC in the diet affected ruminal fermentation profile and milk solids concentration, but did not affect short-term performance and digestibility. Coarse grinding of REC may allow increasing the grinding rate and thus save labor and energy during ensiling.

Nutrient composition and in vitro fermentability of corn grain and stover harvested at different periods in Goesan, a mountainous area

With South Korea's limited capability of feed production because of its relatively small cultivable area, the country is pushed to depend on foreign feed imports despite the immensely fluctuating price of corn. Hence, intensive efforts to increase the total cultivable area in Korea like extending of farming to mountainous area is being practiced. Corn was planted in Goesan County, a mountainous area in the country. Grain and stover were harvested separately in three harvest periods: early-harvest (Aug 8), mid-harvest (Aug 18), and late-harvest (Aug 28). The nutrient composition such as dry matter (DM), crude protein (CP), crude fat (EE), organic matter (OM), neutral detergent fiber (NDF), acid detergent fiber (ADF), and non-fibrous carbohydrates (NFC) was determined after harvest. Effective degradability (ED) of the major nutrients (DM, NDF, ADF, and CP) were measured through in vitro fermentation of rumen fluid from Hanwoo (Korean cattle). pH, ammonia-N concentration, volatile fatty acid (VFA) concentration, and gas production were periodically measured at 0, 3, 6, 12, 24, 48, and 72 h. Corn grain showed higher nutrient content and ED than stover. It also had higher gas production but its pH, ammonia-N, and total VFA concentration were lower than corn stover. The best nutrient composition of corn grain was observed in early-harvest (high CP, EE, NDF, OM, NFC, and low ADF). Early-harvest of corn grain also had high effective degradability of dry matter (EDDM), effective degradability of neutral detergent fiber (EDNDF), effective degradability of acid detergent fiber (EDADF), and total VFA concentration. On the other hand, the best nutrient composition of stover was observed in mid-harvest (high DM, CP, NDF, and low ADF). EDDM, EDNDF, and EDADF were pronounced in early-harvest and mid-harvest of stover but the latter showed high total VFA concentration. Hence, early and mid-harvested corn stover and grain in a mountainous area preserved their nutrients, which led to the effective degradation of major nutrients and high VFA production.

Feeding the combination of essential oils and exogenous α-amylase increases performance and carcass production of finishing beef cattle

Two experiments were conducted to evaluate the performance responses of finishing feedlot cattle to dietary addition of essential oils and exogenous enzymes. The treatments in each experiment consisted of (DM basis): MON-sodium monensin (26 mg/kg); BEO-a blend of essential oils (90 mg/kg); BEO+MON-a blend of essential oils plus monensin (90 mg/kg + 26 mg/kg, respectively); BEO+AM-a blend of essential oils plus exogenous α-amylase (90 mg/kg + 560 mg/kg, respectively); and BEO+AM+PRO-a blend of essential oils plus exogenous α-amylase and exogenous protease (90 mg/kg + 560 mg/kg + 840 mg/kg, respectively). Exp. 1 consisted of a 93-d finishing period using 300 Nellore bulls in a randomized complete block design. Animals fed BEO had higher DMI (P < 0.001) but similar feed efficiency to animals fed MON (P ≥ 0.98). Compared with MON, the combination of BEO+AM resulted in 810 g greater DMI (P = 0.001), 190 g greater average daily gain (P = 0.04), 18 kg heavier final body weight (P = 0.04), and 12 kg heavier hot carcass weight (P = 0.02), although feed efficiency was not significantly different between BEO+AM and MON (P = 0.89). Combining BEO+MON tended to decrease hot carcass weight compared with BEO alone (P = 0.08) but not compared with MON (P = 0.98). Treatments did not impact observed dietary net energy values (P ≥ 0.74) or the observed:expected net energy ratio (P ≥ 0.11). In Exp. 2, five ruminally cannulated Nellore steers were used to evaluate intake, apparent total tract digestibility of nutrients, and ruminal parameters in a 5 × 5 Latin square design. Feeding BEO increased the total tract digestibility of CP compared to MON (P = 0.03). Compared to MON, feeding the combination of BEO+MON increased the intake of CP (P = 0.04) and NDF (P = 0.05), with no effects on total tract digestibility of nutrients (P ≥ 0.56), except for a tendency (P = 0.09) to increase CP digestibility. Intakes of all nutrients measured, except for ether extract (P = 0.16) were greater in animals fed BEO+AM when compared with MON (P ≤ 0.03), with no differences on total tract nutrient digestibilities (P ≥ 0.11) between these two treatments. In summary, diets containing the BEO used herein enhanced DMI of growing-finishing feedlot cattle compared with a basal diet containing MON without impair feed efficiency. A synergism between BEO and AM was detected, further increasing cattle performance and carcass production compared to MON.

Response of common silage corn hybrids to inoculant application: fermentation profile, carbohydrate fractions, and digestibility during ensiling

Corn silage digestibility studies have focussed on genetically distant corn types. Conversely, silage additive studies monitored fermentation differences without discussing the subject of hybrid digestibility. How ensiling phases and additives affect silage quality in commercial corn hybrids has not been properly examined yet. As corn silage quality is a result of combined silage fermentation and digestibility characteristics, the aim of the study was to examine fermentation and digestibility responses to inoculant application in whole-plant corn silage of commercial hybrids intended for silage production in several time points during ensiling. Three corn hybrids grown under identical conditions in a split-plot field test were ensiled without inoculant application and with inoculant containing lactic acid bacteria and carbohydrate-degrading enzymes. Silages were sampled before ensiling, at the peak of the fermentation phase and during the stable phase. The fermentation profile, carbohydrate fraction, ruminal in vitro true dry matter digestibility, ruminal in vitro starch digestibility, and ruminal in vitro neutral detergent fibre digestibility were monitored. Although adding inoculant to silage improved its lactic acid production and decrease in pH, it did not affect its starch and fibre contents or their digestibility. Digestibility improved as ensiling continued, with the highest in vitro neutral detergent fibre digestibility and in vitro true dry matter digestibility values observed in the stable phase. Corn hybrids in this study differed in main fermentation characteristics, carbohydrate contents, and digestibility. These results suggest that even for commercial corn hybrids, the hybrid type is more important than inoculant for optimising silage characteristics and digestibility.

In situ rumen degradation of kernels from short-season corn silage hybrids as affected by processing. Transl Anim Sci 2018;2:428-438. [PMID: 32704725 DOI: 10.1093/tas/txy084]

The objective of this in situ study was to evaluate the rumen degradability of kernels from short-season corn hybrids grown for silage in Western Canada (Lacombe, AB) and determine whether decreasing kernel particle size would enhance ruminal degradability in a similar manner for all hybrids. The study was a completely randomized design with 3 beef cows (replicates) and a 6 (hybrid) × 3 (particle size) factorial arrangement of treatments. Kernels were processed to generate three different particle sizes: large (2.3 mm), medium (1.4 mm), and small (0.7 mm). Processed samples were incubated in the rumen for 0, 3, 6, 12, 24, and 48 h using the in situ method and degradation kinetics of DM and starch were determined. Effective rumen degradability (ED) was estimated using a passage rate of 0.04 (ED4), 0.06 (ED6), and 0.08/h (ED8). Hybrids exhibited a range in whole plant DM content (23.7 to 25.0%), starch content (15.9 to 28.1% DM), kernel hardness (21.9 to 34.4 s/20 g) and density (3.57 to 4.18 g/mL), and prolamin content (8.24 to 11.34 g/100 g starch). Differences in digestion kinetics among hybrids were generally more pronounced for starch than DM. The hybrids differed in starch degradability (P < 0.05), with earlier maturing hybrids having lower A fraction, lower k _d, and lower ED, with hybrid effects on ED being accentuated with faster passage rate. Kernel DM content (r = -0.85, -0.87), hardness (r = -0.89, -0.86), and density (r = -0.84, -0.85) were negatively correlated with ED4 and ED8 of starch, respectively, due mainly to decreased k _d of fraction B. Reducing the particle size of kernels increased ED of starch due to increased A fraction and k _d of the B fraction. A tendency (P = 0.09) for hybrid × processing effects for ED6 and ED8 indicated that processing had greater effects on increasing ED of starch for earlier maturing hybrids. We conclude that short-season hybrids that mature early may have lower ED of DM and starch and would benefit from prolonged ensilage time. Kernel processing during silage making is recommended for short-season corn hybrids as a means of enhancing rumen availability of starch.