Age and adaptation to Ca and P deficiencies: 2. Impacts on amino acid digestibility and phytase efficacy in broilers

Comparison of different protein sources on the phosphorus digestibility of soybean meal for broiler chickens determined using the regression method

A study was conducted to evaluate the P digestibility in soybean meal (SBM) using the regression method with different basal diet that varied in protein sources. The treatments were organized in a 4 × 3 factorial arrangement, where 4 semipurified diets were formulated with varying source of protein (no protein supplement, or added casein, potato protein isolate (PPI), or dried egg albumen (DEA) at 60 g/kg) and 3 dietary levels of SBM (290, 370, or 450 g/kg). The study was a randomized complete block design with 8 replicate cages of 6 birds per cage. The experimental diets were fed from d 19 to 22 posthatching, excreta samples were collected from d 20 to 22, and ileal digesta samples were collected on d 22. Data were analyzed as a 2-way ANOVA using the GLM procedure. The digestibility and total tract utilization of DM, P, Ca, and N were affected by protein source (P < 0.05). Diets with casein presented the highest (P < 0.05) digestibility of N. Increasing SBM level in all dietary protein sources reduced (P < 0.001) the digestibility and total tract utilization of DM. The regression-derived ileal digestibility of P in SBM was 57.8 (SE = 3.78), 63.2 (SE = 5.02), 58.8 (SE = 4.53), and 35.3% (SE = 5.27) for diets without protein supplement, with casein, PPI, or DEA, respectively; the corresponding P retention were 52.2 (SE = 11.09), 83.4 (SE = 14.89), 42.6 (SE = 15.88), and 51.9% (SE = 14.67). The protein source affected (P < 0.05) the slope and intercept of P digestibility in SBM. A comparison of the coefficients using confidence intervals demonstrated that the ileal digestibility of P in SBM determined in diets with DEA was lower (P < 0.05) than the other protein sources, which did not differ from one another. These results indicate that the selection of dietary protein supplements may affect P digestibility assays using the regression method.

Effects of limestone solubility on the efficacy of a novel consensus bacterial 6-phytase variant to improve mineral digestibility, retention, and bone ash in young broilers fed low-calcium diets containing no added inorganic phosphate

This study evaluated the effect of limestone solubility on the capacity of a novel consensus bacterial 6-phytase variant (PhyG) to improve phosphorus (P) and calcium (Ca) digestibility, retention, and utilization in low-Ca broiler diets containing no added inorganic phosphate (Pi). Male Ross 308 broilers (n = 1,152) were fed one of 16 experimental diets from 11 to 21 d of age in a randomized complete design (12 birds/cage, 6 cages/treatment). Diets comprised three positive controls (PC3, PC2, and PC1) containing 1.8, 1.2, or 0.6 g/kg MCP-P and 7.7, 7.0, or 6.2 g/kg Ca, respectively, and a negative control (NC) containing no added Pi (4.4 g/kg P; 2.8 g/kg phytate-P) and 5.5 g/kg Ca from either low or high solubility limestone (LSL or HSL, respectively, [with 42% and 97% solubility after 5 min at pH 3.0]), supplemented with 0, 250, 500, 1,000, or 2,000 FTU/kg of PhyG. Fecal samples collected on days 18 to 20 and ileal digesta collected on day 21 were analyzed for titanium dioxide, Ca, P, and phytate (IP6, inositol hexakisphosphate). Tibias (day 21) were analyzed for ash content. Data were analyzed by factorial analysis (2 limestone solubilities × 4 MCP-P levels and 2 limestone solubilities × 5 phytase dose levels) and exponential regression. Increasing dose levels of PhyG resulted in an exponential increase (P < 0.01) in the apparent ileal digestibility (AID) of P, ileal digestible P content of the diet, ileal IP6 content, and IP6 disappearance in birds fed either HSL or LSL diets, but AID Ca and ileal digestible Ca were exponentially increased by the phytase only in HSL diets (P < 0.01). Relative to HSL, the LSL increased AID P, ileal digestible P, and IP6 disappearance (P < 0.05) but reduced AID Ca, ileal digestible Ca, and retainable Ca (P < 0.05), resulting in reduced retainable P and tibia ash. Phytase exponentially increased the apparent total tract digestibility of P, retainable P, and tibia ash in HSL and LSL diets, but at or above 500 FTU/kg values were higher in HSL than LSL (interaction P < 0.05). The findings highlight that phytase dose-response effects on mineral digestibility and utilization are different for high- and low-solubility limestones, and it is therefore recommended to use digestible rather than total Ca content during diet formulation to ensure an optimal balance of Ca and P, especially in low-Ca diets. In diets containing HSL, higher phytase dose levels may be needed to compensate for the low digestible P content of the basal diet.

Evaluation of the efficacy of a novel phytase in short-term digestibility and long-term egg production studies with laying hens

Three independent trials were conducted to evaluate the efficacy of a novel phytase in laying hens. Trial 1 used a total of 90 laying hens (Lohmann Brown, 33-wk-old) fed either a negative control (NC) diet with 0.09% non-phytate P (NPP) or NC supplemented with 187.5 or 375 FYT phytase/kg feed for 4 d before collection of excreta and ileal digesta to measure ileal digestibility and retention of Ca and P. In trial 2 and 3, a total of 108 laying hens (Hy Line Brown, 25-wk-old) and 360 hens (Lohman Brown, 25-wk-old) were used, respectively. In both trials, the hens were randomly assigned to 3 dietary treatments: NC with 0.1% NPP, positive control (PC) and NC plus 187.5 FYT phytase/kg feed, the experimental diets were fed for 12 wk, and egg production and bone mineralization were measured. The results showed that the ileal digestibility of P increased both linearly (P = 0.012) and quadratically (P = 0.01) with increasing supplementation of phytase in trial 1. In trial 2, phytase supplementation significantly improved egg production, egg weight, and feed conversion ratio and reduced the percentage of broken eggs during the overall trial duration compared with NC. In trial 3, phytase significantly improved egg production, egg weight, and feed intake and reduced the percentage of broken eggs during the entire trial duration. In addition, percentage and weight of bone Ca and P increased significantly with added phytase. In trial 2 and 3, there was no significant difference between PC and the phytase treatment. In conclusion, the novel phytase significantly increased the ileal digestibility of P in a short-term digestibility study and improved egg production and bone mineralization in a 12-wk laying cycle. Ileal digestibility of P rather than P retention in short-term digestibility studies as well as egg production and whole tibia mineralization in long-term studies should be measured to demonstrate the efficacy of phytase in laying hens.

The Duration of the Trial Influences the Effects of Mineral Deficiency and the Effective Phytase Dose in Broilers' Diets

Two trials varying in duration (short- and long-term) were conducted to evaluate the effects of providing deficient (NC) or sufficient (PC) Ca and P levels, and different doses of a new phytase (250, 500, and 1000 FTU/kg feed), in broiler feed on growth performance, nutrient digestibility and retention, and tibia mineralization. A total of 80 and 490 male chicks (Ross) of 21 and 1 days of age were used in the short- and long-term trials, respectively. In the long-term trial, chicks fed NC diets showed a lower (p < 0.05) average daily gain and feed intake compared to chicks fed PC and a greater (p < 0.05) feed conversion ratio compared to 500 and 1000 FTU/kg feed during the starting period. Regarding the effects on minerals’ and nutrients’ coefficients of retention, animals fed NC showed a significantly higher digestibility for P than those fed the PC diet in the long-term trial. Additionally, feeding 250 to 500 FTU/kg diets increased most of the nutrients’ digestibility in the short-term but only P digestibility in the long-term trial. Tibia mineralization increased linearly with phytase addition (p < 0.05) only in the long-term trial. In conclusion, the effects of dietary mineral and phytase levels on growth performance are more noticeable in young animals. In addition, the duration of the trial is key due to a possible adaptation phenomenon of birds to low P supplementary levels.

A novel consensus bacterial 6-phytase variant added to phytate-rich diets totally replaced inorganic phosphate in broilers

The capacity of a novel bacterial 6-phytase variant (PhyG) to totally replace dietary supplemental inorganic phosphate (Pi) in broilers aged one day old was evaluated using a phased dosing strategy and reduction in dietary phytate. A total of 1,248 one-day-old Ross 308 broilers were assigned to 24 pens (52 birds/pen, 12 pens/diet, six each males and females) in a complete randomised block design with a 2×2 factorial arrangement (two diets, two genders). Diets comprised: (1) a positive control (PC) based on maize, wheat and soybean meal, containing Pi from monocalcium phosphate and 2,000 XU/kg xylanase, and; (2) an inorganic phosphate-free (IPF) diet equivalent to PC but with reduced Ca (-2.0 g/kg) and supplemented with PhyG at 3,000, 2,000 and 1000 FTU/kg from d 0 to 11 (3.4 g/kg phytate-P (PP)), d 11 to 22 (3.3 g/kg PP) and d 22 to 42 (2.8 to 2.9 g/kg PP), respectively. A negative control was not included for animal welfare reasons. Tibias were collected on d 11, 22 and 42 from two birds/pen. Treatment IPF maintained or improved average daily gain (ADG), average daily feed intake and feed conversion ratio (FCR) vs PC during all phases; Body weight was higher in the IPF treatment than the PC at d 42 (+3.97%, P<0.01) and ADG during d 0 to 42 (+4.10%, P<0.01). Overall (d 0 to 42), treatment IPF improved FCR in males (-5 points vs PC, P<0.05) but not females. Tibia ash was equivalent in IPF and PC throughout, with no gender differences. In conclusion, when applied as a phased dosing strategy to diets with graded reduction in PP content, PhyG totally replaced supplemental Pi during all growth phases in males and females.

Modeling improvements in ileal digestible amino acids by a novel consensus bacterial 6-phytase variant in broilers

Data from 13 datasets from 4 trials on the effect of a novel consensus bacterial 6-phytase variant (PhyG) on the apparent ileal digestibility (AID) of amino acids (AA) in broilers were used to model AID AA responses. The datasets were obtained from 3 trial locations (New Zealand, Australia and United States) and collectively incorporated variations in diet composition (feedstuff composition, phytate-P (PP) level, limestone solubility), feed form (mash or pellet), bird genetics (strain), and age at sampling (11-35 d of age). In total, 384 observations were analyzed. First, the relationships between AID of AA (as coefficients) and increasing phytase dose level from 0 to 4,000 FTU/kg were evaluated across all datasets using exponential curve fitting. Second, the percentage unit change in AID of AA at each phytase dose level from baseline (basal diet [BD] without phytase) was calculated separately for each dataset and the data then modeled together using exponential curve fitting. The model-predicted mean coefficient of AID of total AA in basal diets was 0.76 (range 0.56 [Cys] to 0.83 [Glu]), which was increased by PhyG to 0.80 and 0.81 at 2,000 and 4,000 FTU/kg, respectively. Exponential increases in the percentage unit improvement in AID of 18 individual and of total AA with increasing phytase dose level were evident (P < 0.05). Improvements (vs. BD) at 2,000 FTU/kg and 4,000 FTU/kg, respectively, were greatest for Cys (+9.2 and +11.0% units), Met (after deduction of synthetic Met, +8.4 and +9.0% units), and Thr (after deduction of synthetic Thr, +6.2 and +7.3% units). The data demonstrated consistent improvements in the AID of AA by the phytase. The modeling results generated from data gathered from birds sampled at different ages and from different dietary settings with correction of synthetic AA for Lys, Met, Thr, and Trp, enabled a more accurate prediction of the digestible AA contribution from the diet by this novel phytase. This will allow diet-specific AA matrix recommendations to be made in commercial feed formulations.

Effects of a novel consensus bacterial 6-phytase variant on the apparent ileal digestibility of amino acids, total tract phosphorus retention and tibia ash in young broilers

The effect of a novel consensus bacterial 6-phytase variant (PhyG) on apparent ileal digestibility (AID) of amino acids (AA) and phosphorus (P) utilization in young broilers when added to diets with high phytate-P (PP) content without added inorganic phosphate (Pi) and deficient in digestible (dig) AA and metabolizable energy (ME) was investigated. A total of 256 Ross 308 male broilers were assigned to 4 treatments (8 birds/cage, 8 cages/treatment) in a completely randomized design. Treatments comprised a positive control (PC, 2,975 kcal/kg ME, 3.7 g/kg dig P, 2.83 g/kg PP, 8.4 g/kg Ca, 10.6 g/kg dig lysine), a negative control (NC) without added Pi (ME −68 kcal/kg, crude protein −10 g/kg, dig AA −0.1 to −0.4 g/kg, Ca −2.0 g/kg, dig P −2.2 g/kg, Na −0.4 g/kg vs. PC), and NC plus 500 or 1,000 FTU/kg of PhyG. Test diets were corn/soy/rapeseed-meal/rice-bran-based and fed from 5 to 15 d of age. Ileal digesta and tibias were collected on day 15. Excreta was collected during days 12 to 15 to determine P retention. The NC (vs. PC) reduced (P < 0.05) P retention (−10.4% units), tibia ash (−14.3% units), weight gain (−109 g), feed intake (−82 g) and increased FCR (from 1.199 to 1.504), confirming that the NC was extremely deficient in nutrients and energy. Phytase addition to the NC linearly (P < 0.001) improved performance, but did not fully recover it to the level of the PC due to the severe nutrients/energy reduction in NC. Phytase linearly increased P retention (P < 0.001), tibia ash (P < 0.001), AID of dry matter (P < 0.05), nitrogen (P < 0.01), gross energy (P < 0.05), and all 17 individual AA (P < 0.01). At 1,000 FTU/kg, phytase increased (P < 0.05) P retention vs. PC and NC (+14.5 and +24.9% units, respectively) and increased tibia ash vs. NC (+13.8% units), equivalent to PC. The NC decreased AID of Cys, Gly, Thr, and Met vs. PC (P < 0.05). At 1,000 FTU/kg, phytase increased AID of all 17 AA vs. NC (P < 0.01), equivalent to PC. At 1,000 FTU/kg, AID AA responses (above NC) ranged from +4.5% (Met) to +15.0% (Cys), being maximal for essential Thr (+10.4%) and Val (+8.2%) and non-essential Cys (+15.0%) and Gly (+10.4%). The results highlight the efficacy of PhyG at a dose level of 500 to 1,000 FTU/kg in young broilers for improving the ileal digestibility of nitrogen, AA, and energy alongside P retention and tibia ash. The performance data emphasize the need to consider digestible nutrient intake as a response variable in exogenous enzyme studies.

Microbial phytase is widely used in commercial broiler diets to improve digestion of phosphorus (P) and reduce its excretion into the environment. Phytase improves the digestion of phosphorus and other nutrients including amino acids (AA). This study evaluated the effect of a novel consensus bacterial 6-phytase variant (PhyG) added to a nutrient-reduced diet without any added inorganic P on the digestibility of nutrients including P and AA in the ileum of young broilers. Effects on P retention and bone mineralization were also assessed. Compared to an unsupplemented negative control diet, PhyG improved growth performance, P retention, bone mineralization (tibia ash), digestibility of dry matter, nitrogen, gross energy, and all 17 individual AA during 5 to 15 d post-hatch, in a dose-dependent manner (dose range 0 to 1,000 phytase units [FTU] per kilogram of feed). For some AA, the increases in digestibility with PhyG at 1,000 FTU/kg were substantial (cysteine: +15.0%, threonine:+10.4%), and for all AA were equivalent to the responses produced by a nutritionally adequate positive control (unsupplemented) diet. The results demonstrate the efficacy of PhyG to improve AA digestibility alongside growth performance, P retention, and bone mineralization in young broilers.

Effect of increasing dose level of a novel consensus bacterial 6-phytase variant on phytate degradation in broilers fed diets containing varied phytate levels

1. The effect of increasing the dose level of a novel consensus bacterial 6-phytase variant on apparent ileal digestibility (AID) of phosphorus (P), phytic acid (inositol hexa-phosphate, IP₆) and ileal IP₆ degradation profile was studied in diets containing varying phytate-P (PP) levels.2. Ross 308, one-day-old males (n=1,800) were allocated to cages (20 birds/cage, six cages/treatment) in a completely randomised design employing a 3 × 5 factorial arrangement (three PP levels: 2.45 (low) 2.95 (medium) and 3.45 g/kg (high); five dose levels of phytase (PhyG): 0, 500, 1,000, 2,000 and 4,000 FTU/kg). Phased diets were based on wheat, corn, soybean meal, rapeseed meal and rice bran (d 0 to 10; 2.60 g/kg digestible P, 7.6 g/kg calcium (Ca); d 11 to 21; 2.10 g/kg digestible P, 6.4 g/kg Ca). Ileal digesta was collected on d 21 for determination of P, IP₆ and IP-esters content. Data were analysed by factorial ANOVA; means separation was achieved using Tukey's HSD test.3. Increasing PP reduced AID of IP₆ and sum of IP_3-6 (%) (P<0.05) but absolute P-release (g/kg diet) above NC was increased (P<0.05) at high vs. low PP. Increasing phytase dose exponentially increased (P<0.001) AID IP_6, sum of IP_3-6 (%) and digestible IP_3-6-P g/kg diet (P<0.001). AID P was increased but there was an interaction with PP level (P<0.001). Ileal accumulation of IP_5-3-P was universally low with PhyG at ≥1,000 FTU/kg (<0.06 g/100g DM). At 2,000 and 4,000 FTU/kg, AID IP₆ was 97.2, 92.7, 92.6% and 100, 97.2, 97.1%, respectively, at low, medium and high PP. At 2,000 FTU/kg, phytate-P release estimated as the increase (above NC) in ileal digestible sum of IP_3-6-P in the diet was 2.26, 2.59 and 3.10 g/kg in low, medium and high PP, respectively.4. The data demonstrated that the novel phytase was effective in breaking down phytate to low IP-esters in diets with varied PP content but the optimal dose level for maximising P-release may differ in diets with varying PP content.

Buttiauxella phytase maintains growth performance in broilers fed diets with reduced nutrients under a commercial setting

The effect of down specifying nutrients in diets supplemented with Buttiauxella spp. phytase was studied in a commercial trial. Three treatments were tested with five replicate groups, each containing 700, one-day-old straight run Ross 308 broilers. Birds were fed pelleted diets from days 0-42 in four phases: starter (days 0-10); grower (days 11-21); finisher 1 (days 22-35) and finisher 2 (days 36-42). A nutritionally adequate, unsupplemented, positive control (PC) diet based on wheat, corn and soybean meal was compared against two down specified, negative control (NC) diets containing Buttiauxella phytase supplemented at 500 or 1000 FTU/kg. The reduction level was 0.134 and 0.159% unit for digestible phosphorus, 0.164 and 0.189% unit for calcium, 0.03 and 0.04% unit for sodium, 0.283 and 0.309 MJ/kg for nitrogen corrected apparent metabolizable energy in all phases and variable digestible amino acids in different phases, respectively for the diets containing the phytase at 500 and 1000 FTU/kg. An unsupplemented NC diet was not included, as it would have caused welfare and health issues. Weight gain and mortality-corrected feed conversion ratio for birds receiving phytase at either inclusion levels were equivalent to the PC group. Feed intake was increased by 500 FTU/kg phytase (P<0.05) during 0-21 d vs PC. Including 1000 FTU/kg phytase reduced water intake vs PC at 0-42 d and water-to-feed intake ratios, after the starter phase (P<0.05). Carcass yield in birds supplemented with either phytase level was not different from PC. Tibia ash was unaffected by treatment. Estimated feed costs (inclusive of phytase) were lower in supplemented than un-supplemented (PC) diets, by 10.0 to 13.7 €/ton diet. The trial demonstrated that reducing nutrient specifications of diets supplemented with Buttiauxella phytase maintained growth performance, lowered feed costs, with production benefits maximised at inclusion levels of 1000 FTU/kg.

Interactive effect of dietary calcium and phytase on broilers challenged with subclinical necrotic enteritis: 3. Serum calcium and phosphorus, and bone mineralization

Calcium is chelated by phytic acid and forms phytate-mineral complexes reducing Ca availability and the ability of phytase to hydrolyze phytate. An increased Ca concentration in the gut favors the activity of Clostridium perfringens (C. perfringens). Therefore, it was hypothesized that high dietary calcium with high dietary phytase would decrease serum Ca and P and bone mineralization during necrotic enteritis occurrence. A total of 768 one-day-old Ross 308 male chicks were randomly allocated to 8 treatments with 6 replicate pens, each housing 16 birds. A 2 × 2 × 2 factorial arrangement of treatments was applied: dietary Ca (0.6 or 1.0%), phytase (500 or 1,500 FTU/kg), and challenge (no or yes). Half of the birds (384) were challenged with Eimeria spp. on day 9 and C. perfringens strain EHE-NE18 on day 14 and 15. Blood was collected from 2 birds per pen to determine Ca, P, and parathyroid hormone in the serum. The middle toe, tibia, and femur were excised from 2 birds per pen on day 16 and 29 for determination of ash, breaking strength (BS), and mineral concentration. The challenge decreased (P < 0.05) serum Ca⁺ in birds regardless of dietary Ca level (day 16). There was a challenge × Ca interaction (P < 0.05) for tibial BS (day 16), with challenge being more severe in birds fed high Ca than low Ca diets. A challenge × phytase interaction (P < 0.05) was present for femur ash (day 16), with high phytase only increasing ash in challenged birds. The challenge decreased (P < 0.05) the BS of femur and tibia at each time point. Birds fed high dietary Ca had lower tibial Mg (P < 0.001), Fe (P < 0.001), Na (P < 0.001), and Zn (P < 0.05) concentrations (day 29). Altogether, high dietary Ca and phytase improved bone mineralization showing that attention to Ca and P nutrition and phytase matrix values is warranted when high levels of phytase are used.

The impact of age and feeding length on phytase efficacy during the starter phase of broiler chickens

Phytase is of importance to the poultry industry because of its ability to hydrolyze phytate and release phosphorus (P) for use by poultry. However, the effect of age on phytase efficacy is not fully understood. A total of 864 day-old broiler chicks were used to investigate the effect of age and feeding length on phytase efficacy using growth performance, mineral utilization, and tibia ash as response criteria of evaluation. The experiment was arranged as a 3 × 2 × 2 factorial in a randomized complete block design with 3 diets including; a positive control (PC; 0.4% non-phytate P (nPP)), a negative control (NC; 0.2% nPP) and a NC diet supplemented with phytase at 2,000 FYT/kg; 2 ages (i.e., days 14 and 22); and 2 feeding lengths (i.e., 2 and 5 D) with 8 replicates each. Birds fed the NC had decreased (P < 0.01) body weight gain and feed efficiency compared with birds fed the PC regardless of age or feeding length. Similarly, birds fed the phytase-supplemented diet had improved (P < 0.01) performance as compared to birds fed the NC regardless of age. There were no significant differences in P utilization between birds fed for 2 to 14 D or 22 D and birds fed for 5 D to both ages. However, phytase was more efficacious at day 14 than day 22 when mineral utilization was considered because the super dose of phytase elicited greater response in birds fed the phytase supplemented diet for 2 D until day 14. In contrast, percentage tibia ash improved (P < 0.01) in birds fed phytase supplemented diet for 5 D at both ages as compared with birds fed for 2 D. In conclusion, testing phytase products, even at high doses, for 2 D during the second week in the life cycle of broiler chicks, can be recommended from the results of this study.

Dietary phytate has a greater anti-nutrient effect on feed conversion ratio compared to body weight gain and greater doses of phytase are required to alleviate this effect as evidenced by prediction equations on growth performance, bone ash and phytate degradation in broilers

Cobb 400, male broilers (n=4,752) were fed one of 12 diets, with 12 pens/diet and 33 birds/pen. Treatments consisted of 3 levels of phytate P (0.24, 0.345, or 0.45%) and 4 doses of phytase (0, 500, 1,000, or 2,000 phytase units (FTU)/kg). Diets were formulated with reduced Ca (0.22%), available P (0.20%), energy (80 to 120 kcal/kg), and amino acids (1 to 5%) when compared with breed requirements. Prediction equations suggested feeding dietary phytate P > 0.275, 0.295, or 0.319% reduced feed intake (FI) and body weight gain (BWG) and increased feed conversion ratio, respectively, from day 0 to 21. Supplementing phytase at 561, 1,285, or >2,000 FTU/kg resulted in the maximum FI, BWG, or feed efficiency, respectively. From day 0 to 42, maximum BWG or feed efficiency were achieved at phytate P concentrations <0.281 or 0.25%, respectively. Supplementing phytase at 449 or 2,000 FTU/kg maximized BWG or feed efficiency, respectively. Tibia ash weight, percent or Ca concentration were maximized at phytate P concentrations <0.24, 0.296, or 0.24%, respectively and phytase supplementation at 822 or >2,000 FTU/kg maximized tibia ash weight or percent respectively. In the absence of phytase, phytate (IP6) concentration in the gizzard was greatest in birds fed 0.45% phytate P and phytase supplementation between 1,132 to 1,285 FTU/kg resulted in the lowest IP6 concentration in the gizzard. There was no effect of dietary phytate P on the concentration of phytate esters (IP5 or IP4) in the gizzard, which were minimized at 1,208 FTU/kg of phytase. In the absence of phytase, the concentration of phytate ester (IP3) or inositol in the gizzard was greatest in birds fed 0.345% phytate P and phytase supplementation at ∼500 FTU/kg minimized IP3, whereas 2,000 FTU/kg maximized inositol, except in birds fed 0.45% phytate P, which was maximized at 202 FTU/kg of phytase. Prediction equations can be useful to determine the influence of phytase and phytate P on broiler performance, phytate degradation and bone ash.

Influence of age and duration of feeding low-phosphorus diet on phytase efficacy in broiler chickens during the starter phase

A total of 1,408 male broiler chickens were used to evaluate the impact of age and duration of feeding low-phosphorus (P) diet on the efficacy of phytase using growth performance, nutrient utilization, tibia ash, and plasma indices. Diets were formulated with 2 non-phytate P (nPP) concentrations (i.e., 0.20 and 0.40%) and 2 phytase concentrations (i.e., 1,000 and 2,000 FTU/kg) added to the 0.20% nPP diet. Four dietary treatments with 8 replicate cages each were fed to broiler chicks at different ages and for different duration. Specifically, these were days 6 to 8 (12 birds per replicate), 12 to 14, 9 to 14, 20 to 22, or 6 to 22 (8 birds per replicate). Parameters were measured on the last day of each period. Duration of feeding effect was examined by comparing responses of birds fed for 2 or 5 D at day 14 and for 2 or 16 D at day 22; age effect was determined by comparing responses of birds fed for 2 D at age 8, 14 and 22 D post-hatching. Body weight gain and gain-to-feed ratio were increased (P < 0.01) in birds fed diets supplemented with phytase; however, an increase in duration of feeding improved (P < 0.01) feed efficiency with birds fed for 16 D performing better than birds fed for 2 D at day 22. In addition, phytase supplementation improved (P < 0.01) apparent P and calcium digestibility and retention, but the age effect on phytase efficacy was more apparent at day 14 and the duration of feeding effect was evident in birds fed for 2 D due to the increased levels of mineral utilization at that age/duration of feeding as compared with the other groups. The results of this study show that phytase efficacy was at optimum in birds fed low-P diet for 2 D at day 14. This period can be recommended for further bioefficacy studies of phytase.

Supplementation of Buttiauxella sp. 6-phytase to commercial laying hen diets with reduced nutrient density on productive performance and egg quality

A study was conducted to evaluate productive performance in laying hens fed diets with reduced nutrient density based on the nutritional contribution of a Buttiauxella phytase in laying-hen diets from 21-57 weeks of age. A commercial laying hen diet was offered ad libitum to the 480 ISA Brown laying hens from 18-21 weeks of age. From 21 weeks onwards, the hens received one of four dietary treatments: a positive control (PC) diet, a down specified diet (DS1) + phytase at 300 FTU/kg, a second down-specified diet (DS2) + phytase at 600 FTU/kg and a third test diet formulated as per DS1 + phytase at 1,200 FTU/kg feed. The PC was formulated based on ISA breeder recommendations. DS1 was formulated with reduction of 0.149% available P, 0.134% Ca, 55 kcal/kg AME, 0.33% CP, digestible amino acids (up to 0.015%) and 0.013% Na based on the contribution of Buttiauxella phytase at 300 FTU/kg. DS2 was formulated with reduction of 0.177% available P, 0.159% Ca, 60 kcal/kg AME, 0.61% CP, digestible amino acids (up to 0.028%) and 0.02% Na based on the contribution of Buttiauxella phytase at 600 FTU/kg. Every dietary treatment was fed to 12 cages containing 10 hens each. The trial treatments did not include a full, DS negative control, as ethical considerations regarding birds' welfare when feeding such diets over such an extended period of time did not permit this. No significant differences were seen in hen-day egg production, feed intake, egg weight, feed to egg mass ratio, shell, yolk or albumen proportion, unsaleable eggs or shell breaking strength in laying hens fed the PC diet or the DS diets with added phytase. Yolk colour increased significantly with phytase supplementation. Supplementing the DS1 diet with 300 FTU and the DS2 diet with 600 FTU resulted in non-significant differences in tibia ash, Ca and P, compared to the PC diet. The data from this study indicated that applying the nutrient contributions for Buttiauxella phytase at 300 and 600 FTU/kg maintained the egg production, BW and egg quality parameters compared to PC. The best economic efficiency value during the whole experimental period was recorded with phytase at 600 FTU/kg when full matrix values are used. When commercial diets are formulated based on ISA breeder recommendations, lowering diet nutrient density while supplementing with phytase reduced the overall diet cost, which should contribute to the profitability of egg production.

Progress in comprehending the phytate–phytase axis in chicken-meat production

After an extended delay, the level of acceptance of exogenous phytases by the global chicken-meat industry is now almost complete. Contemporary bacterial phytases degrade phytate primarily in the gizzard. The extent of phytate degradation determines the extent to which phytate-bound phosphorus (P) is liberated; however, studies designed to investigate phytate degradation along the digestive tract have generated some confusing outcomes. This may be related to the reactivity of the phytate moiety, coupled with problems with inert dietary markers and perhaps a lack of complete and uniform extractions of phytate from digesta due to variations in digesta pH and phytate solubility. Quite recently, phytase was shown to have profound impacts on sodium (Na) digestibility coefficients in four segments of the small intestine. This has obvious implications for intestinal uptakes of glucose and amino acids via their respective Na+-dependent transport systems and it is possible that phytate and phytase have reciprocal impacts on ‘sodium pump’ (Na+, K+-ATPase) activity. It has been recently demonstrated unequivocally that phytase has the capacity to increase amino acid digestibility coefficients to the extent that phytase may generate a ‘proximal shift’ in the sites of amino acid absorption. The impact of phytase on starch digestibility is more equivocal and phytase responses may stem more from enhanced glucose absorption rather than starch digestion. The acceptance of phytase is hardly surprising, given its capacity to increase P utilisation coupled with numerous other positive influences that are still being properly realised.

Effects of particle size and adaptation duration on the digestible and metabolizable energy contents and digestibility of various chemical constituents in wheat for finishing pigs determined by the direct or indirect method

Objective

This experiment was conducted as a 3×2×2 factorial design to examine the effects of particle size (mean particle size of 331, 640, or 862 μm), evaluation method (direct vs indirect method) and adaptation duration (7 or 26 days) on the energy content and the apparent total tract digestibility (ATTD) of various chemical components in wheat when fed to finishing pigs.

Methods

Forty-two barrows (Duroc×Landrace×Yorkshire) with an initial body weight of 63.0±0.8 kg were individually placed in metabolic cages and randomly allotted to 1 of 7 diets with 6 pigs fed each diet. For the indirect method, the pigs were fed either a corn-soybean meal based basal diet or diets in which 38.94% of the basal diet was substituted by wheat of the different particle sizes. In the direct method, the diets contained 97.34% wheat with the different particle sizes. For both the direct and indirect methods, the pigs were adapted to their diets for either 7 or 26 days.

Results

A reduction in particle size linearly increased the digestible energy (DE) and metabolizable energy (ME) contents as well as the ATTD of gross energy, crude protein, organic matter, ether extract (EE) and acid detergent fiber (ADF) (p<0.05), and had a trend to increase the ATTD of dry matter of wheat (p = 0.084). The DE, ME contents, and ATTD of gross energy, crude protein, dry matter and organic matter were higher (p<0.05) when determined by the direct method, but the ATTD of ADF, EE, and neutral detergent fiber were higher when determined by the indirect method (p<0.05). Prolongation of the adaption duration decreased the ATTD of neutral detergent fiber (p<0.05) and had a trend to increase the ATTD of EE (p = 0.061). There were no interactions between particle size and the duration of the adaptation duration. The ATTD of EE in wheat was influenced by a trend of interaction between method and adaptation duration (p = 0.074). The ATTD of ADF and EE in wheat was influenced by an interaction between evaluation method and wheat particle size such that there were linear equations (p<0.01) about ATTD of ADF and EE when determined by the direct method but quadratic equations (p = 0.073 and p = 0.088, respectively) about ATTD of ADF and EE when determined by the indirect method.

Conclusion

Decreasing particle size can improve the DE and ME contents of wheat; both of the direct and indirect methods of evaluation are suitable for evaluating the DE and ME contents of wheat with different particle sizes; and an adaptation duration of 7 d is sufficient to evaluate DE and ME contents of wheat in finishing pigs.