Effect of exogenous xylanase, amylase, and protease as single or combined activities on nutrient digestibility and growth performance of broilers fed corn/soy diets

Two trials (a 42-d performance and a 21-d cohort digestibility) were conducted to evaluate the performance and nutrient digestibility of broilers fed corn diets supplemented with exogenous xylanase, amylase, and protease as single or combined activities. A nutritionally adequate, positive control (PC) diet was formulated. The negative control (NC) diet was formulated to be lower in metabolizable energy (∼86 kcal/kg diet) and digestible amino acids (1 to 2%) compared to PC. The other 4 treatments were based on the NC and they were either supplemented with xylanase (X), amylase (A), protease (P), or a combination of X, A, and P (XAP; to provide 2,000 U of X, 200 U of A, and 4,000 U of P/kg diet). All diets were marginal in AvP and Ca and contained a background of phytase (1,000 FTU/kg). In each trial, male broiler (Ross 308) chicks were allocated to the 5 treatments (10 replicates of 20 birds/pen and 9 replicates of 8 birds/cage for the performance and digestibility trials, respectively). In the digestibility trial, ileal digesta was collected on d21 for the determination of nutrient utilization. Data were subjected to one-way ANOVA and means were separated by Tukey's HSD test. Only the XAP improved (P < 0.05) AMEn compared to NC. X, A or XAP improved (P < 0.05) N digestibility and apparent ileal digestible energy (AIDE). Both P and XAP improved N retention. The relative improvement in energy digestibility due to enzyme supplementation was greater at the ileal level than that measured in the excreta. The measured changes on AIDE due to supplemental enzymes were much higher than the sum of calculated contributions from starch, fat, and protein. Supplementation of all enzymes reduced (P < 0.05) ileal flow of soluble rhamnose and mannose relative to NC. In the performance trial, both X and XAP improved (P < 0.05) weight gain (WG) and only XAP improved (P < 0.05) FCR compared to NC during the starter phase (1-21d). Over the entire period (1–42d), WG and FI were not influenced (P > 0.05) by dietary treatments. Both X and XAP had lower (P < 0.05) FCR compared to NC (1.540 and 1.509 vs 1.567, respectively). However, birds fed diet supplemented with XAP had an improved (P < 0.05) FCR compared to birds fed single activities and had similar (P > 0.05) FCR compared to PC. In conclusion, these results suggest a synergistic effect between X, A and P on broiler performance and nutrient digestibility. In the current study, AIDE measurements appeared to overestimate the enzyme response. Calculation of the energy contribution by supplemental enzymes using the improvements in the digestibility of the undigested fraction of starch, fat and protein may be a more accurate measurement for the enzyme response than the absolute response in AIDE.

Dietary A1 β-casein affects gastrointestinal transit time, dipeptidyl peptidase-4 activity, and inflammatory status relative to A2 β-casein in Wistar rats

We compared the gastrointestinal effects of milk-based diets in which the β-casein component was either the A1 or A2 type in male Wistar rats fed the experimental diets for 36 or 84 h. Gastrointestinal transit time was significantly greater in the A1 group, as measured by titanium dioxide recovery in the last 24 h of feeding. Co-administration of naloxone decreased gastrointestinal transit time in the A1 diet group but not in the A2 diet group. Colonic myeloperoxidase and jejunal dipeptidyl peptidase (DPP)-4 activities were greater in the A1 group than in the A2 group. Naloxone attenuated the increase in myeloperoxidase activity but not that in DPP-4 activity in the A1 group. Naloxone did not affect myeloperoxidase activity or DPP-4 activity in the A2 group. These results confirm that A1 β-casein consumption has direct effects on gastrointestinal function via opioid-dependent (gastrointestinal transit and myeloperoxidase activity) and opioid-independent (DPP-4 activity) pathways.

Cloning and expression of a xylanase xynB from Aspergillus niger IA-001 in Pichia pastoris

The high-level expression of the xylanase GH11 gene from Aspergillus niger IA-001 called xynB was successfully completed in Pichia pastoris. The xynB gene encoding a mature xylanase of 225 amino acid was subcloned into the pPICZαA vector and was transformed into P. pastoris X-33 under the control of the alcohol oxidase I (AOX1) promoter. The xynB gene was ligated with a sequence encoding modified α-factor signal peptide (pPICZαmA) and the recombinant xylanase activity, which was measured 1280 U ml(-1), was 1.5-fold higher than when it was inserted into pPICZαA and was 19.39-fold greater than the native xylanase in the original strain. In a 10 L fermenter, the recombinant xylanase activity measured 10,035 U ml(-1) after 114 h. The SDS-PAGE analysis revealed that the purified xynB protein migrated as a single band with an apparent molecular weight of 24 kDa. The specific activity, using beechwood xylan as a substrate, was 1916 U mg(-1). The xylanase activity was optimal at pH 5.0 and at 50 °C. In addition, the xynB was active over a pH range of 2.2 to 10.0. The apparent Km and Vmax values were 4.429 mg ml(-1) and 1429 U mg(-1), respectively.

Effects of xylanase and citric acid on the performance, nutrient retention, and characteristics of gastrointestinal tract of broilers fed low-phosphorus wheat-based diets

An experiment was conducted to study the effects of xylanase and citric acid on the performance, nutrient retention, jejunal viscosity, and size and pH of the gastrointestinal tract of broilers fed a low-P wheat-based diet. The experiment was conducted as a 2 × 3 factorial arrangement with 2 levels of xylanase (0 and 200 mg/kg) and 3 levels of citric acid (0, 20, and 40 g/kg). Each of the 6 dietary treatments was fed to 4 replicate pens (17 birds/pen) from 0 to 24 d of age. Chromium oxide (3 g/kg) was added to the diets as an indigestible marker to determine the apparent nutrient retention. No interaction effect was observed between xylanase and citric acid in any measured response. Xylanase did not affect feed intake but significantly increased BW gain by 3.6% (P < 0.05) from 1 to 24 d of age and improved G:F by 3.9% (P < 0.01). The inclusion of 40 g/kg of citric acid decreased (P < 0.01) BW gain and feed intake by 8.6 and 12.5%, respectively. The inclusion of 20 and 40 g/kg of citric acid improved G:F by 2.3 and 4.5% (P < 0.05), respectively. Xylanase significantly decreased the viscosity of digesta and improved the retention of DM, CP, and energy, but did not have a significant effect on the retention of fat and P. Inclusion of 20 and 40 g/kg of citric acid in the diets increased P retention by 15.8 and 16.3% (P < 0.01), respectively. Citric acid significantly decreased the pH of crop contents (P < 0.05). In conclusion, citric acid, at the 40 g/kg inclusion level, reduced feed intake and BW gain but improved G:F and P retention. Xylanase decreased digesta viscosity, increased nutrient retention, and consequently improved the performance of broilers fed the low-P wheat-based diet. Thus, adding 20 g/kg of citric acid, especially in the starter period, and 200 mg/kg of xylanase to low-P wheat-based diets can be helpful.

BOARD-INVITED REVIEW: opportunities and challenges in using exogenous enzymes to improve nonruminant animal production

Diets fed to nonruminant animals are composed mainly of feed ingredients of plant origin. A variety of antinutritional factors such as phytin, nonstarch polysaccharides, and protease inhibitors may be present in these feed ingredients, which could limit nutrients that may be utilized by animals fed such diets. The primary nutrient utilization-limiting effect of phytin arises from the binding of 6 phosphate groups, thus making the P unavailable to the animal. The negative charges allow for formation of insoluble phytin-metal complexes with many divalent cations. Furthermore, phytin and protein can form binary complexes through electrostatic links of its charged phosphate groups with either the free amino group on AA on proteins or via formation of ternary complexes of phytin, Ca(2+), and protein. The form and extent of de novo formation of binary and ternary complexes of phytin and protein are likely to be important variables that influence the effectiveness of nutrient hydrolysis in plant-based diets. Nonstarch polysacharides reduce effective energy and nutrient utilization by nonruminant animals because of a lack of the enzymes needed for breaking down the complex cell wall structure that encapsulate other nutrients. Enzymes are used in nonruminant animal production to promote growth and efficiency of nutrient utilization and reduce nutrient excretion. The enzymes used include those that target phytin and nonstarch polysaccharides. Phytase improves growth and enhances P utilization, but positive effects on other nutrients are not always observed. Nonstarch polysaccharide-hydrolyzing enzymes are less consistent in their effects on growth and nutrient utilization, although they show promise and it is imperative to closely match both types and amounts of nonstarch polysaccharides with appropriate enzyme for beneficial effects. When used together with phytase, nonstarch polysaccharide-hydrolyzing enzymes may increase the accessibility of phytase to phytin encapsulated in cell walls. The future of enzymes in nonruminant animal production is promising and will likely include an understanding of the role of enzyme supplementation in promoting health as well as how enzymes may modulate gene functions. This review is an attempt to summarize current thinking in this area, provide some clarity in nomenclature and mechanisms, and suggest opportunities for expanded exploitation of this unique biotechnology.