Operational Parameters of Biogas Plants: A Review and Evaluation Study

Biogas Upgrading Using a Single-Membrane System: A Review

In recent years, the use of biogas as a natural gas substitute has gained great attention. Typically, in addition to methane (CH4), biogas contains carbon dioxide (CO2), as well as small amounts of impurities, e.g., hydrogen sulfide (H2S), nitrogen (N2), oxygen (O2) and volatile organic compounds (VOCs). One of the latest trends in biogas purification is the application of membrane processes. However, literature reports are ambiguous regarding the specific requirement for biogas pretreatment prior to its upgrading using membranes. Therefore, the main aim of the present study was to comprehensively examine and discuss the most recent achievements in the use of single-membrane separation units for biogas upgrading. Performing a literature review allowed to indicate that, in recent years, considerable progress has been made on the use of polymeric membranes for this purpose. For instance, it has been documented that the application of thin-film composite (TFC) membranes with a swollen polyamide (PA) layer ensures the successful upgrading of raw biogas and eliminates the need for its pretreatment. The importance of the performed literature review is the inference drawn that biogas enrichment performed in a single step allows to obtain upgraded biogas that could be employed for household uses. Nevertheless, this solution may not be sufficient for obtaining high-purity gas at high recovery efficiency. Hence, in order to obtain biogas that could be used for applications designed for natural gas, a membrane cascade may be required. Moreover, it has been documented that a significant number of experimental studies have been focused on the upgrading of synthetic biogas; meanwhile, the data on the raw biogas are very limited. In addition, it has been noted that, although ceramic membranes demonstrate several advantages, experimental studies on their applications in single-membrane systems have been neglected. Summarizing the literature data, it can be concluded that, in order to thoroughly evaluate the presented issue, the long-term experimental studies on the upgrading of raw biogas with the use of polymeric and ceramic membranes in pilot-scale systems are required. The presented literature review has practical implications as it would be beneficial in supporting the development of membrane processes used for biogas upgrading.

Valorization of crop residues and animal wastes: Anaerobic co-digestion technology

To switch the over-reliance on fossil-based resources, curb environmental quality deterioration, and promote the use of renewable fuels, much attention has recently been directed toward the implementation of sustainable and environmentally benign 'waste-to-energy' technology exploiting a clean, inexhaustible, carbon-neutral, and renewable energy source, namely agricultural biomass. From this perspective, anaerobic co-digestion (AcoD) technology emerges as a potent and plausible approach to attain sustainable energy development, foster environmental sustainability, and, most importantly, circumvent the key challenges associated with mono-digestion. This review article provides a comprehensive overview of AcoD as a biochemical valorization pathway of crop residues and livestock manure for biogas production. Furthermore, this manuscript aims to assess the different biotic and abiotic parameters affecting co-digestion efficiency and present recent advancements in pretreatment technologies designed to enhance feedstock biodegradability and conversion rate. It can be concluded that the substantial quantities of crop residues and animal waste generated annually from agricultural practices represent valuable bioenergy resources that can contribute to meeting global targets for affordable renewable energy. Nevertheless, extensive and multidisciplinary research is needed to evolve the industrial-scale implementation of AcoD technology of livestock waste and crop residues, particularly when a pretreatment phase is included, and bridge the gap between small-scale studies and real-world applications.

Unlocking biogas potential: Spatial analysis, economic viability, and climate resilience in southern regions of Khyber Pakhtunkhwa, Pakistan

Across the world, the growing embrace of anaerobic digestion for deriving energy from biogas presents substantial economic and environmental benefits. This strategic approach carries particular significance for Pakistan, which is actively striving to meet its renewable energy objectives. The study focuses on a comprehensive examination of the spatial distribution of biogas potential originating from livestock farm manure in the southern areas of Khyber Pakhtunkhwa. This factor plays a pivotal role in ascertaining the best location and economic feasibility of a bioenergy facility. The study employs a spatial analysis algorithm to estimate biogas production. By integrating livestock data, manure production metrics, and collection statistics, the algorithm provides a high-resolution assessment at 1 km interval. The analysis unveil a biogas potential of 1.40 billion cubic meters of bio-methane sourced from manure. District D.I.Khan emerges as the leading producer, generating 201.40 million cubic meters of bio-methane. Several maps illustrate optimal sites and potential capacities for biogas facilities utilizing manure. The study proposes the practicality of establishing 868 biogas plants within the surveyed geographic region. Collectively, these plants would generate a substantial 909.34 Megawatt electrical (Mwe), while individual capacities spanning from 120 Kilowatt electrical (Kwe) to an impressive 997 KWe. These findings offer a clear path for strategically siting biogas plants, a crucial component of the global battle against climate change. Moreover, the findings of this study have played a significant role in shaping guidelines aimed at mitigating methane emissions, promoting the generation of renewable energy, and advocating for sustainable waste management practices. These guidelines serve as invaluable tools for climate mitigation and adaptation endeavors.

The Use of Fungi of the Trichoderma Genus in Anaerobic Digestion: A Review

Plant waste biomass is the most abundant renewable energy resource on Earth. The main problem with utilising this biomass in anaerobic digestion is the long and costly stage of degrading its complex structure into simple compounds. One of the promising solutions to this problem is the application of fungi of the Trichoderma genus, which show a high capacity to produce hydrolytic enzymes capable of degrading lignocellulosic biomass before anaerobic digestion. This article discusses the structure of plant waste biomass and the problems resulting from its structure in the digestion process. It presents the methods of pre-treatment of lignocellulose with a particular focus on biological solutions. Based on the latest research findings, key parameters related to the application of Trichoderma sp. as a pre-treatment method are discussed. In addition, the possibility of using the digestate from agricultural biogas plants as a carrier for the multiplication of the Trichoderma sp. fungi, which are widely used in many industries, is discussed.

Enhancing methane production of co-digested food waste with granular activated carbon coated with nano zero-valent iron in an anaerobic digester

Anaerobic digestion (AD) possesses dual benefits of waste treatment and energy generation. The use of conductive additives in AD matrix has potential to improve process yield. Hence, the study aimed to investigate a thermophilic AD (TAD) inserted by granular activated carbon coated with nano zero-valent iron (GAC/nZVI) in the matrix and was operated for mono-digestion and co-digestion of cow manure with food wastes (rice and bread) to check the bioprocess improvement. The results were compared with the control TAD without conductive additives. Biogas production increased by 11 folds upon using GAC/nZVI addition compared to the control TAD. Moreover, the addition of GAC/nZVI increased the methane in biogas by 20.7 folds compared to control one. With GAC/nZVI, the maximum COD removal of 78.29% and 85.21% were noticed for co-digestion and mono digestion, respectively. Such improvement of TAD performance was due to easy bacterial communication and electron exchange through the conductive particles.

Two-Phase Anaerobic Digestion of Corn Steep Liquor in Pilot Scale Biogas Plant with Automatic Control System with Simultaneous Hydrogen and Methane Production

Experimental studies of two-phase anaerobic digestion of corn steep liquor in semi-continuous automatic and semi-automatic modes of operation of a cascade of two anaerobic bioreactors with monitoring and control systems were performed. Corn steep liquor—a waste product from the process of treating corn grain for starch extraction—was used as a substrate in the process of anaerobic digestion with simultaneous hydrogen and methane production. The daily yields of biohydrogen in bioreactor 1 of the cascade (with a working volume of 8 dm3) are variable. In good operation, they are in the range of 0.7 to 1.0 L of biogas from a 1 dm3 working volume of the bioreactor, and the optimal pH is in the range of 5.0–5.5. The concentration of hydrogen in the biogas from the hydrogen bioreactor 1 is in the range of 14–34.7%. The daily yields of biomethane in bioreactor 2 of the cascade (with a working volume of 80 dm3) vary in the range 0.4 to 0.85 L of biogas from a 1 dm3 working volume of the bioreactor, and the concentration of methane in the biogas from bioreactor 2 is high and remains practically constant (in the range 65–69%). At a dilution rate of 0.4 day−1 and an organic loading rate of 20 gL for bioreactor 1, respectively, and a dilution rate of 0.05 day−1 for bioreactor 2, the best results were obtained. The computer control system is presented. Some energetical considerations were discussed.

Assessment of Sustainable Biogas Production from Co-Digestion of Jatropha De-Oiled Cake and Cattle Dung Using Floating Drum Type Digester under Psychrophilic and Mesophilic Conditions

Biodiesel is an emerging alternative fuel that is generally made from edible and non-edible oilseed crops. Jatropha curcus has a high potential for producing biodiesel, which yields 25–35% oil along with 75–65% solid byproduct, generally called a de-oiled cake. The present manuscript deals with the co-digestion of Jatropha de-oiled cake along with cattle dung (1:1 ratio) for biogas production in a floating-type biogas digester. The experimental study was carried out in a modified KVIC biogas plant of 6 cubic meter capacity for 60 days’ retention time under psychrophilic and mesophilic temperature conditions. During all the experiments, the total solid content of the slurry was maintained fixed at 10–12% by mixing 10 kg Jatropha de-oiled cake and 10 kg cattle dung with 80 kg water. The experimental results showed that the average specific biogas production of Jatropha de-oiled cake and cattle dung slurry was observed to be 0.216 m3/kg TS, 0.252 m3/kg VS and 0.287 m3/kg TS, 0.335 m3/kg VS, respectively, under the aforementioned conditions. Moreover, the biogas methane concentration was observed to be 62.33% to 69.16% under mesophilic temperature conditions compared to the psychrophilic temperature conditions, 65.21% to 69.15%, respectively. Furthermore, the average total volatile solids mass removal efficiency of feeding material in the abovementioned process was 7% higher under mesophilic temperature conditions than psychrophilic temperature conditions. Additionally, the results indicated that a total 588.8 kg of input volatile solids produced a total of 7306.56 MJ/m3 and 5177.88 MJ/m3 energy in 60 days under psychrophilic and mesophilic temperature conditions. On the basis of the results, it is concluded that Jatropha de-oiled cake may be a superior solution for improving biogas quality and composition as well as a value-added product, i.e., organic manure.

Impact of temperature, inoculum flow pattern, inoculum type, and their ratio on dry anaerobic digestion for biogas production

This study is aimed to apply dry anaerobic digestion (DAD) for methane (CH₄) enriched biogas production from unsorted organic municipal solid waste (MSW). Cumulative biogas production was monitored for 35 days of operation in batch digesters at fixed feedstock to inoculum (F/I) ratio 2. Anaerobic sludge (AS) and cow manure (CM) were used as inoculum in single and mixed modes. Several process parameters such as inoculum flow pattern (single layer, multilayer, and spiral), digestion temperature (25 to 40 °C), inoculation modes (single and mixed mode), and inoculation proportion (AS:CM = 1:1, 1:2, 1:3, and 2:1) were investigated to determine the optimum DAD conditions to maximize the CH₄ laden biogas yield. The study of inoculum flow pattern showed that digester with multilayer inoculum configuration generated the maximum 555 mL cumulative biogas with the production rate of 195 mL/day (at 25 °C). Biogas production rate and cumulative biogas production were found to increase with a rise in temperature and the maximum values of 380 mL/day and 1515 mL respectively were observed at 37 °C. The mixed mode of inoculation containing AS and CM augmented the biogas yield at previously optimized conditions. Final results showed that digester with multilayer inoculum flow pattern at 37 °C produced 1850 mL cumulative biogas with 1256.58 mL CH₄/kg volatile solid (VS) when the mixed inoculum was used at the AS:CM—1:2 ratio. Biogas production with this significant amount of CH₄ justifies the use of the DAD process for energy (biogas) generation from widely available biomass feedstock (MSW), offering various advantages to the environment.

Anaerobic digestion of urea pretreated water hyacinth removed from Lake Abaya; bio-methane potential, system stability, and substance conversion

Water hyacinth (Eichhornia crassipes) is characterized as an aquatic plant that can grow very rapidly and freely float over water, and covers the top surface of water. It prevents the penetration of sunlight and reduces nutrients and oxygen from water bodies, and can adversely affect the aquatic ecosystem; however, it can be used in the biogas production as the sole feedstock for anaerobic digestion due to high contents of carbohydrates and biodegradable matter. Thus, this study was aimed to remove water hyacinth from Lake Abaya as a renewable energy resource for biogas production through anaerobic digestion. A lab-scale anaerobic batch reactor was applied to assess its biogas and methane generation potential. The results showed that the total solids of 91.9% at dry basis and volatile solids of 84.82% of TS. The biogas and methane production potential of 474.92 mL g⁻¹ VS and 213.92 mL g⁻¹ VS was recorded during 45 days HRT at 37 ± 1 °C. The daily methane production discloses accelerated increment starting from day 8 up to the peak point on day 12 (2170 mL d⁻¹). The biochemical conversion of substances in water hyacinth to biogas was recorded as follows: total volatile solids (96.1%), cellulose (92.5%), hemicellulose (88.2%), and chemical oxygen demand (99.3%). Based on results, E. crassipes can be the sole feedstock for the anaerobic reactor to produce biomethane, while the effluents can be applied as organic fertilizers.

Anaerobic digestion of urea pretreated water hyacinth enhanced biomethane production potential and improved digestate quality as a bio-fertilizer for the plant growth.

Machine Learning Algorithms for Temperature Management in the Anaerobic Digestion Process

Process optimization is no longer an option for processes, but an obligation to survive in the market in any industry. This argument also applies to anaerobic digestion in biogas plants. The contribution of biogas plants to renewable energy can be increased through more productive systems with less waste, which brings the common goal of minimizing costs and maximizing yields in processes. With the help of data science and predictive analytics, it is possible to take conventional process optimization and operational excellence methods, such as statistical process control and Six Sigma, to the next level. The more advanced the process optimization aspect, the more transparent and responsive the systems. In this study, seven different machine learning algorithms—linear regression, logistic regression, K-NN, decision trees, random forest, support vector machine (SVM) and XGBoost—were compared with laboratory results to define and predict the possible impacts of wide range temperature fluctuations on process stability. SVM provided the best accuracy with 0.93 according to the metric precision of the models calculated using the confusion matrix.

A Hybrid Zeolite Membrane-Based Breakthrough for Simultaneous CO2 Capture and CH4 Upgrading from Biogas

Biogas is an environmentally friendly and sustainable energy resource that can substitute or complement conventional fossil fuels. For practical uses, biogas upgrading, mainly through the effective separation of CO₂ (0.33 nm) and CH₄ (0.38 nm), is required to meet the approximately 90-95% purity of CH₄, while CO₂ should be concomitantly purified. In this study, a high CO₂ perm-selective zeolite membrane was synthesized by heteroepitaxially growing a chabazite (CHA) zeolite seed layer with a synthetic precursor that allowed the formation of all-silica deca-dodecasil 3 rhombohedral (DDR) zeolite (with a pore size of 0.36 × 0.44 nm²). The resulting hydrophobic DDR@CHA hybrid membrane on an asymmetric α-Al₂O₃ tube was thin (ca. 2 μm) and continuous, thus providing both high flux and permselectivity for CO₂ irrespective of the presence or absence of water vapor (the third largest component in the biogas streams). To the best of our knowledge, the CO₂ permeance of (2.9 ± 0.3) × 10^-7 mol m^-2 s^-1 Pa^-1 and CO₂/CH₄ separation factor of ca. 274 ± 73 at a saturated water vapor partial pressure of ca. 12 kPa at 50 °C have the highest CO₂/CH₄ separation performance yet achieved. Furthermore, we explored the membrane module properties of the hybrid membrane in terms of the recovery and purity of both CO₂ and CH₄ under dry and wet conditions. Despite the high intrinsic membrane properties of the current hybrid membrane, reflected by the high permeance and SF, the corresponding module properties indicated that high-performance separation of CO₂ and CH₄ for the desired biogas upgrading was achieved at a limited processing capacity. This supports the importance of understanding the correlation between the membrane and module properties, as this will provide guidance for the optimal operating conditions.

Long-Term Assessment of Temperature Management in an Industrial Scale Biogas Plant

Temperature management is one of the primary considerations of biogas plant operation, and influences physical and biochemical processes. An increase in the temperature leads to an increase in the hydrolysis rate of the feedstock, while it can inhibit microorganisms taking part in different stages of anaerobic digestion. Because of the complexity of the biochemical processes within the anaerobic digestion process, there is a lack of knowledge about the effects of temperature and temperature change on efficiency. Moreover, the impact of stirring directly affects the temperature distribution in the anaerobic digestion reactors. In this study, the temperature management in an industrial-scale biogas plant was examined, and the effect of small temperature changes (from the operation temperature 42 °C) on the efficiency was studied in a laboratory under two different conditions: with stirring (at 40 and 44 °C) and without stirring (at 40 and 44 °C). The examination results from the biogas plant showed that heat transfer in the reactor was not sufficient at the bottom of the digester. Adaptation of the post-digester samples to the temperature changes was more challenging than that of the digester samples. From digestate samples, higher biomethane generation could be obtained, resulting from sufficient contact between microorganisms, enzymes, and substrates. Overall, differences between these changing conditions (approx. 6 NmL CH4 g VS−1) were not significant and could be adapted by the process.

Phase Separation in Anaerobic Digestion: A Potential for Easier Process Combination?

The flexibilization of bioenergy production has the potential to counteract partly other fluctuating renewable energy sources (such as wind and solar power). As a weather-independent energy source, anaerobic digestion (AD) can offer on-demand energy supply through biogas production. Separation of the stages in anaerobic digestion represents a promising strategy for the flexibilization of the fermentative part of biogas production. Segregation in two reactor systems facilitates monitoring and control of the provision of educts to the second methanogenic stage, thus controlling biogas production. Two-stage operation has proven to reach similar or even higher methane yields and biogas purities than single-stage operation in many different fields of application. It furthermore allows methanation of green hydrogen and an easier combination of material and energy use of many biogenic raw and residual biomass sources. A lot of research has been conducted in recent years regarding the process phase separation in multi-stage AD operation, which includes more than two stages. Reliable monitoring tools, coupled with effluent recirculation, bioaugmentation and simulation have the potential to overcome the current drawbacks of a sophisticated and unstable operation. This review aims to summarize recent developments, new perspectives for coupling processes for energy and material use and a system integration of AD for power-to-gas applications. Thereby, cell physiological and engineering aspects as well as the basic economic feasibility are discussed. As conclusion, monitoring and control concepts as well as suitable separation technologies and finally the data basis for techno-economic and ecologic assessments have to be improved.

Application of Multi-Criteria Decision-Making Tools for Assessing Biogas Plants: A Case Study in Reykjavik, Iceland

The European Union is planning a new program to achieve climate neutrality by 2050. In this context, the Icelandic government plans to ban new registrations of fossil fuel cars after 2030 as one of the strategies to make Iceland a carbon-neutral country by 2040. Upgraded biogas can be directly used in vehicles with CNG engines, reducing CO2 emissions by 80%. In this paper, several alternatives of biogas plants, simulated in previous research, were evaluated by considering techno-economic and environmental criteria through the application of multi-criteria decision-making tools. Twelve alternatives were analyzed using the Definite 3.1 software. A weighted summation algorithm, which transforms all criteria into the same scale by multiplying them by weights and then summing them to obtain the results, was used in the analysis. The multi-criteria analysis of the twelve proposed alternatives included eleven criteria (three technical, five economic, and three environmental) whose weights were changed in a total of eleven scenarios. From a global perspective, when all criteria were considered (9.1% weight) the best alternative with a score of 0.58 was the single-stage biogas plant working with municipal solid waste. Sensitivity and uncertainty analyses also demonstrated that the multi-criteria results obtained were robust and reliable.

The Role of Agriculture and Rural Areas in the Development of Autonomous Energy Regions in Poland

In many countries, energy security is treated as a priority for the coming decades, and at the same time energy production from the vast majority conventional energy sources does not meet environmental protection criteria. Hence, the need to use renewable energy sources (RES), which can largely satisfy energy needs. The aim of the study was to identify possibilities of creating autonomous energy regions (ARE) in Poland, based on renewable energy sources. Attention was paid to the role and significance of the potential of rural areas in this respect, taking into account the possibilities of increasing energy production from these sources in individual regions of Poland. The research was conducted on a regional level (division into voivodships) and on a local level (division into powiats, which form voivodships). When assessing the potential for constructing ARE based on RES, the following energy sources were taken into account: water, wind, sun, biogas and biomass. It was found that the highest RES potential versus energy consumption can be obtained in powiats where the share of arable land and forests exceeds 80%. The research showed that in most regions of Poland (powiats, voivodships), there is a large potential for obtaining additional energy from RES, which would cover over 73% of the country’s demand for electricity. This could be the basis for building energy independence on a local scale. The results of the study indicated that as many as seven regions would become self-sufficient in terms of electricity demand.

Increasing the Content of Olive Mill Wastewater in Biogas Reactors for a Sustainable Recovery: Methane Productivity and Life Cycle Analyses of the Process

Anaerobic codigestion of olive mill wastewater for renewable energy production constitutes a promising process to overcome management and environmental issues due to their conventional disposal. The present study aims at assessing biogas and biomethane production from olive mill wastewater by performing biochemical methane potential tests. Hence, mixtures containing 0% (blank), 20% and 30% olive mill wastewater, in volume, were experimented on under mesophilic conditions. In addition, life cycle assessment and life cycle costing were performed for sustainability analysis. Particularly, life cycle assessment allowed assessing the potential environmental impact resulting from the tested process, while life cycle costing in conjunction with specific economic indicators allowed performing the economic feasibility analysis. The research highlighted reliable outcomes: higher amounts of biogas (80.22 ± 24.49 NL.kg_SV⁻¹) and methane (47.68 ± 17.55 NL.kg_SV⁻¹) were obtained when implementing a higher amount of olive mill wastewater (30%) (v/v) in the batch reactors. According to life cycle assessment, the biogas ecoprofile was better when using 20% (v/v) olive mill wastewater. Similarly, the economic results demonstrated the profitability of the process, with better performances when using 20% (v/v) olive mill wastewater. These findings confirm the advantages from using farm and food industry by-products for the production of renewable energy as well as organic fertilizers, which could be used in situ to enhance farm sustainability.

Enhancement of euryhaline Asterarcys quadricellulare biomass production for improving biogas generation through anaerobic co-digestion with carbon rich substrate

The microalga was isolated from Muktsar, the southwestern zone of Indian Punjab and identified as Asterarcys quadricellulare BGLR5 (MF661929) by 18S rRNA sequence analysis. The optimization of various cultural factors by the Plackett-Burman and central composite (CCD) designs helped in discerning the significant cultural factors for the increased production of biomass and other functional components (chlorophyll, carbohydrate, lipid and protein). The optimal cultural conditions as per the model were pH 9.9, 81 μmol m^-2 s^-1 light intensity, 22 °C temperature, growth period of 25 days, NaNO₃ 12 mM, 15 mM NH₄Cl, and 7 mM K₂HPO₄. In comparison to the basal condition biomass (0.886 g L^-1), a 0.42-fold increase in biomass yield was attained. Further, the highest yield of biogas (P: 361.81 mL g^-1 VS) with enhanced biogas production rate (R _m: 8.19 mL g^-1 day^-1) was achieved in co-digesting paddy straw with Asterarcys quadricellulare biomass in 1:1 ratio compared to their digestion individually. Further, the co-digestion resulted in the positive synergistic effect which increased the observed biogas yield compared to the estimated yield by 11-58% depending upon the amount of algal biomass and paddy straw used. Hence, the present study signifies that the biomass of Asterarcys quadricellulare BGLR5 can be utilized as a co-substrate with paddy straw to enhance the biogas yield.

SUPPLEMENTARY INFORMATION

The online version contains supplementary material available at 10.1007/s13205-021-02792-x.

Integral valorization of orange peel waste through optimized ensiling: Lactic acid and bioethanol production

The management of the huge amount of orange peel waste (OPW) is a complex issue although it has a very high potential in terms of biorefining. One of the main problems in the valorisation of OPW is the seasonality of its production with the ensiling method being largely proposed as a possible solution. During the ensiling process, value added chemicals including lactic acid, acetic acid and ethanol are spontaneously produced together with a significant loss of volatile solids (VS) . In this contribution, the stimulation of lactic acid bacteria by either a biological (inoculation with leachate coming from a previous ensiling process) or chemical (MnCl₂ supplementation) methods has been tested with the aim to increase the chemicals production preventing, at the same time, the VS loss. The inoculation with the leachate improves both the VS recovery (+7%) and the concentration of lactic acid (+113%) with respect to the uninoculated one (control). The overall yields of the process are noticeable, up to about 55 g·kg_TS^-1 of lactic acid, 26 g·kg_TS^-1 of acetic acid and 120 g g·kgTS-1 of ethanol have been produced. On the other hand, the chemical stimulation enhances the production of liquid products together with a significant VS loss. The proposed preservation method, due to its simplicity, can be easily implemented at full-scale allowing the production of added-value chemicals and the concurrent storage of the OPW that can be further valorised (e.g. animal feed, pectin or biomethane production).

Impact of organic loading rate and reactor design on thermophilic anaerobic digestion of mixed supermarket waste

A mixture of supermarket food waste from bakery, butchery, cooked meats and cheese, fishmonger, fruit, and vegetable sections was subjected to anaerobic digestion under thermophilic conditions (55 °C). Lab-scale induced bed reactors (IBR) and completely stirred tank reactors (CSTR) were operated at different organic loading rates (OLR), i.e., 3.0, 3.6 and 4.6 kg volatile solids (VS) per m³ of reactor and day. Regardless of the type of reactor, an OLR of 3.6 kg VS/m³·day was found to be the optimum, achieving up to 48.1% more methane production per kg of treated waste than for the other OLRs tested. In general, there were no statistically significant differences (p-value < 0.05) between IBR and CSTR performance at the same OLR tested. However, for the optimum OLR, the IBR achieved a mean methane production of 1.5 L CH₄/L_reactor·day (426.7 L CH₄/kg VS) and the highest VS removal (89.0%, on average). This reactor obtained 22.1% more CH₄ yield than the analogous CSTR and the highest methane content in the biogas (66.9% CH₄). Finally, the process was successfully tested under large-scale conditions (1.25 m³ IBR pilot-plant). The CH₄ production and the biodegradation yield were in line with those obtained in the lab-scale IBR.

The Effect of Static Magnetic Field on Methanogenesis in the Anaerobic Digestion of Municipal Sewage Sludge

The present study aimed to determine the effect of a 17.6 mT static magnetic field (SMF) on the efficiency of anaerobic digestion (AD) of municipal sewage sludge (MSS). The SMF had a significant impact on methane (CH4) production efficiency, the levels of fermentation rate (ηFMSS) vs. removal rate (ηVS), and the structure of the anaerobic bacteria consortium, but it did not affect cumulative biogas production. The highest CH4 yield (431 ± 22 dm3CH4/kgVS) and the highest methane content in the biogas (66.1% ± 1.9%) were found in the variant in which the SMF exposure time was 144 min/day. This variant also produced the highest ηFMSS and ηVS values, reaching 73.8% ± 2.3% and ηVS 36.9% ± 1.6%, respectively. Longer anaerobic sludge retention time in the SMF area significantly decreased AD efficiency and caused a significant reduction in the number of methanogens in the anaerobic bacteria community. The lowest values were observed for SMF exposure time of 432 min/day, which produced only 54.8 ± 1.9% CH4 in the biogas. A pronounced reduction was recorded in the Archaea (ARC915) and Methanosaeta (MX825) populations in the anaerobic sludge, i.e., to 20% ± 11% and 6% ± 2%, respectively.

Scenario Analysis for Selecting Sewage Sludge-to-Energy/Matter Recovery Processes

The sewage sludges are the byproducts of the wastewater treatment. The new perspective of the wastewater value chain points to a sustainable circular economy approach, where the residual solid material produced by sewage sludge treatments is a resource rather than a waste. A sewage sludge treatment system consists of five main phases; each of them can be performed by different alternative processes. Each process is characterized by its capability to recover energy and/or matter. In this paper, a state of the art of the sludge-to-energy and sludge-to-matter treatments is provided. Then, a scenario analysis is developed to identify suitable sewage sludge treatments plants that best fit the quality and flowrate of sewage sludge to be processed while meeting technological and economic constraints. Based on the scientific literature findings and experts’ opinions, the authors identify a set of reference initial scenarios and the corresponding best treatments’ selection for configuring sewage sludge treatment plants. The scenario analysis reveals a useful reference technical framework when circular economy goals are pursued. The results achieved in all scenarios ensure the potential recovery of matter and/or energy from sewage sludges processes.

Integration of Artificial Intelligence into Biogas Plant Operation

In the biogas plants, organic material is converted to biogas under anaerobic conditions through physical and biochemical processes. From supply of the raw material to the arrival of the products to customers, there are serial processes which should be sufficiently monitored for optimizing the efficiency of the whole process. In particular, the anaerobic digestion process, which consists of sequential complex biological reactions, requires improved monitoring to prevent inhibition. Conventional implemented methods at the biogas plants are not adequate for monitoring the operational parameters and finding the correlation between them. As Artificial Intelligence has been integrated in different areas of life, the integration of it into the biogas production process will be inevitable for the future of the biogas plant operation. This review paper first examines the need for monitoring at the biogas plants with giving details about the process and process monitoring as well. In the following sections, the current situation of implementations of Artificial Intelligence in the biogas plant operation and in the similar industries will be represented. Moreover, considering that all the information gathered from literature and operational needs, an implementation model will be presented.

The Potential of Agricultural Biogas Production in Ukraine—Impact on GHG Emissions and Energy Production

Renewable energy production is gaining importance in the context of global climate changes. However, in some countries other aspects increasing the role of renewable energy production are also present. Such a country is Ukraine, which is not self-sufficient in energy supply and whose dependency on poorly diversified import of energy carriers regularly leads to political tensions and has socio-economic implications. Production of agricultural biogas seems to be a way to both slow down climatic changes and increase energy self-sufficiency by replacing or complementing conventional sources of energy. One of the most substantial barriers to agricultural biogas production is the low level of agricultural concentration and significant economies of scale in constructing biogas plants. The aim of the paper was thus to assess the potential of agricultural biogas production in Ukraine, including its impact on energy self-sufficiency, mitigation of greenhouse gas (GHG) emissions and the economic performance of biogas plants. The results show that due to the prevailing fragmentation of farms, most manure cannot be processed in an economically viable way. However, in some regions utilization of technically available manure for agricultural biogas production could cover up to 11% of natural gas or up to 19% of electricity demand. While the theoretical potential for reducing greenhouse gas emissions could reach 5% to 6.14%, the achievable technical potential varies between 2.3% and 2.8% of total emissions. The economic performance of agricultural biogas plants correlates closely with their size and bioenergy generation potential.

The Effective Management of Organic Waste Policy in Albania

Following a recycling or continuous recycling process, there is always waste with no material or market value that can be converted into energy or other fossil fuel substitutes. The present study aimed to evaluate the management of organic waste policy and to predict the trend of organic waste generation in Albania. The research used an appropriate Box–Jenkins Auto Regressive Integrated Moving Average (ARIMA) to determine the quantification of organic waste to be generated. The main results obtained can support the decision-making process in the planning, change and short-term implementation of organic waste management, and the information provided is very useful in collecting, transporting, storing and managing waste in Albanian cities (Tirana, Durrës, Kukës, Berat, Shkodra, Dibër, Gjirokastër and Elbasan). Furthermore, the high percentage of the organic waste generation until 2025 constitutes good premises to raising public awareness related to their energy recovery.