Use of Nonconventional Yeasts for Modulating Wine Acidity

Commercial wine yeast nitrogen requirement influences the production of secondary metabolites (aroma, hydroxytyrosol, melatonin and other bioactives) during alcoholic fermentation

During alcoholic fermentation, Saccharomyces cerevisiae synthesizes different compounds, which are crucial for product quality: volatile compounds with sensory impact, and bioactive compounds such as melatonin (MEL) and hydroxytyrosol (HT), linked to health benefits. As many of these compounds are related with yeast's nitrogen metabolism, their production have been studied in four different commercial strains with different nitrogen requirement (Red Fruit, Uvaferm VRB, Lalvin Rhone 2323 and Lalvin QA23) being, Uvaferm UVR the higher nitrogen demander strain. All strains produced the secondary metabolites, notably Uvaferm UVR produced the highest HT concentration, despite its low growth. Uvaferm UVR emerged also as a significant producer of MEL, indicating a potential role in fermentation related stress. Moreover, Uvaferm UVR shows the highest total concentrations of volatile compounds. Multivariate analysis revealed distinct clustering based on nitrogen requirements of the strains, highlighting the strain-dependent metabolic responses.

The Influence of Chitosan on the Chemical Composition of Wines Fermented with Lachancea thermotolerans

Chitosan exerts a significant influence on various chemical parameters affecting the quality of wine produced using multiple strains of Lachancea thermotolerans. The impact of chitosan on these parameters varies depending on the specific strain studied. We observed that, under the influence of chitosan, the fermentation kinetics accelerated for all examined strains. The formation of lactic acid increased by 41% to 97% across the studied L. thermotolerans strains, depending on the specific strain. This effect also influenced acidity-related parameters such as total acidity, which increased by 28% to 60%, and pH, which experienced a decrease of over 0.5 units. The consumption of malic acid increased by 9% to 20% depending on the specific strain of L. thermotolerans. Nitrogen consumption also rose, as evidenced by all L. thermotolerans strains exhibiting a residual value of Primary Amino Nitrogen (PAN) of below the detection limit, and ammonia consumption increased by 90% to 100%, depending on the strain studied. However, certain parameters such as acetic acid, succinic acid, and glycerol showed contradictory results depending on the strain under investigation. In terms of volatile composition, chitosan supplementation led to increased production of i-butanol by 32% to 65%, 3-methylbutanol by 33% to 63%, and lactic acid ethyl ester by 58% to 91% across all studied strains of L. thermotolerans. Other analyzed aroma compounds exhibited varying changes depending on the specific strain of L. thermotolerans.

Modification of the second PEP4-allele facilitates an industrial Saccharomyces cerevisiae to tolerate tartaric acid stress

The practical significance of constructing robust industrial production strains against organic acid stress lies not only in improving fermentation efficiency but also in reducing manufacturing costs. In a previous study, we constructed an industrial Saccharomyces cerevisiae strain by modifying another PEP4-allele of a mutant that already had one PEP4-allele disrupted. This modification enhanced cellular tolerance to citric acid stress during growth. Unlike citric acid, which S. cerevisiae can consume, tartaric acid is often added to grape must during winemaking to increase total acidity and is not metabolizable. The results of the present study indicate that the modification of the second PEP4-allele improves the cellular tolerance of the strain with one PEP4-allele disrupted against tartaric acid stress during growth and contributes to maintaining intracellular pH homeostasis in cells subjected to tartaric acid stress. Moreover, under tartaric acid stress, a significant improvement in glucose-ethanol conversion performance, conferred by the modification of the second PEP4-allele, was observed. This study not only broadens our understanding of the role of the PEP4-allele in cellular regulation but also provides a prospective approach to reducing the concentration of sulfur dioxide used in winemaking.

Effect of Interspecific Yeast Hybrids for Secondary In-Bottle Alcoholic Fermentation of English Sparkling Wines

In sparkling winemaking, only a few yeast strains are regularly used for the secondary in-bottle alcoholic fermentation (SiBAF). Recently, advances in yeast development programs have yielded new breeds of interspecific wine yeast hybrids that ferment efficiently while producing novel flavors and aromas. In this work, the chemical and sensorial impacts of the use of interspecific yeast hybrids for SiBAF were studied using three commercial English base wines prepared for SiBAF using two commercial and four novel interspecific hybrids. After 12 months of lees aging, the chemical and macromolecular composition, phenolic profile, foaming, viscosity and sensory properties of the resulting 13 wines were assessed. Chemically, the yeast strains did not result in significant differences in the main wine parameters, while some differences in their macromolecular contents and sensory characteristics were noticeable. The foamability was mostly unaffected by the strain used; however, some effect on the foam stability was noticeable, likely due to the differences in polysaccharides released into the wines by the yeast strains. The wines exhibited different sensory characteristics in terms of aroma and bouquet, balance, finish, overall liking and preference, but these were mostly attributable to the differences in the base wines rather than the strain used for SiBAF. Novel interspecific yeast hybrids can be used for the elaboration of sparkling wines, as they provided wines with chemical characteristics, flavor and aroma attributes similar to those of commonly used commercial Saccharomyces cerevisiae strains.

A comparative study of the effect of bacteria and yeasts communities on inoculated and spontaneously fermented apple cider

Understanding bacteria and yeasts communities can reduce unpredictable changes of apple cider. In this study, apple juice inoculated with Saccharomyces cerevisiae WET 136 and fermented spontaneously were compared, the relationships of bacteria, yeasts, organic acids, and volatiles were analyzed. Results showed that microbial diversity affected the fermentation, organic acids and volatiles in apple ciders. In the first four spontaneous fermentation days, LAB (lactic acid bacteria) multiplied and reached 7.89 lg CFU/mL, and then triggered malolactic fermentation (MLF), leading to malic acid decreased by 3880.52 mg/L and lactic acid increased by 4787.55 mg/L. The citric, succinic and fumaric acids content was 2171.14, 701.51 and 8.06 mg/L lower than that in inoculated cider, respectively. Although the yeasts multiplied during spontaneous fermentation, it did not reach 7.50 lg CFU/mL until the 5th day, which led to a long lag period, as well as later and lower production of acetaldehyde and higher alcohols. The inoculated yeast inhibited LAB, acetic acid bacteria, Rahnella, and non-Saccharomyces. Yeasts were the key to produce citric acid, acetaldehyde and 3-methyl-1-butanol in apple cider; while bacteria were closely related to the formation of lactic acid, acetic acid and ethyl acetate. It suggested that low higher alcohols and acetaldehyde can be realized by selecting yeasts, and Leuconostoc pseudomesenteroides can work as candidate to reduce L-malic and citric acids in apple cider.

Microsatellite typing of Lachancea thermotolerans for wine fermentation monitoring

Climate change is causing a lack of acidity during winemaking and oenologists use several solutions to cope with such a problem. Lachancea thermotolerans, which has the potential to tolerate the harsh physicochemical conditions of wine, has emerged as a promising alternative for pH management during winemaking and, currently, it is the most valuable yeast used for acidity control in wine. In this work a manageable method for L. thermotolerans genotyping based on a multiplexed microsatellite amplification in 6 different loci was developed. The proposed method was used to distinguish between 103 collection strains obtained from different geographical and isolation sources, and then challenged against a 429 L. thermotolerans isolates from several wineries and harvests. The procedure was also tested for fermentation monitoring and strain implantation. This approach was conceived to simplify the methodology available for L. thermotolerans genotyping, making it easy for applying in wine-related laboratories. This method can be applied to distinguish between L. thermotolerans strains in selection programs and to follow implantation of inoculated strains during winemaking with optimal results.

Sequential culture with aroma-producing yeast strains to improve the quality of Kyoho wine

Despite many non-Saccharomyces yeasts being considered spoilage microorganisms, they can increase aroma and flavor diversity in alcoholic beverages. The purpose of this study was to investigate nontraditional inoculation strategies using aroma-producing yeast strains for Kyoho wine fermentation, followed by an instrumental analysis and sensory evaluation. The winemaking process was carried out using Saccharomyces cerevisiae Gr112, Hanseniaspora uvarum Pi235, and Pichia kluyveri Pe114. Multiple inoculation strategies were explored. In instrumental analysis results, mixed culture could promote the formation of esters (5.9-folds) and glycerol (1.3-folds) and reduce the content of ethanol (-0.5% [v/v]) in wine. The sensory analysis results suggested that the three yeast strains sequential inoculation treatment was associated with the aroma attributes "floral," "red fruity," and "tropical fruity." Co-cultivation contributed to an increase in complexity and aromatic intensity, with the three-strain inoculation treatment presenting a more distinctive appearance. PRACTICAL APPLICATION: The inoculation of S. cerevisiae improved the accumulation of volatile acids and esters by inhibiting the growth of non-Saccharomyces yeast strains. Inoculation of H. uvarum and P. kluyveri would effectively solve the defect of excessive content of higher alcohols in wines produced by S. cerevisiae. The suitable inoculation strategy between non-Saccharomyces yeasts could improve the overall quality of Kyoho wine whose starter might be widely used in fermentation industry.

Advances in pulsed electric stimuli as a physical method for treating liquid foods

There is a need for alternative technologies that can deliver safe and nutritious foods at lower costs as compared to conventional processes. Pulsed electric field (PEF) technology has been utilised for a plethora of different applications in the life and physical sciences, such as gene/drug delivery in medicine and extraction of bioactive compounds in food science and technology. PEF technology for treating liquid foods involves engineering principles to develop the equipment, and quantitative biochemistry and microbiology techniques to validate the process. There are numerous challenges to address for its application in liquid foods such as the 5-log pathogen reduction target in food safety, maintaining the food quality, and scale up of this physical approach for industrial integration. Here, we present the engineering principles associated with pulsed electric fields, related inactivation models of microorganisms, electroporation and electropermeabilization theory, to increase the quality and safety of liquid foods; including water, milk, beer, wine, fruit juices, cider, and liquid eggs. Ultimately, we discuss the outlook of the field and emphasise research gaps.

Impact of Non-Saccharomyces Yeast Fermentation in Madeira Wine Chemical Composition

Madeira wine is produced via spontaneous alcoholic fermentation arrested by ethanol addition. The increasing demand of the wine market has led to the need to standardize the winemaking process. This study focuses on identifying the microbiota of indigenous yeasts present during Madeira wine fermentation and then evaluates the impact of selected indigenous non-Saccharomyces as pure starter culture (Hanseniaspora uvarum, Starmerella bacillaris, Pichia terricola, Pichia fermentans, and Pichia kluyveri) in the chemical and phenolic characterization of Madeira wine production. Results showed that the polyphenol content of the wines was influenced by yeast species, with higher levels found in wines produced by Pichia spp. (ranging from 356.85 to 367.68 mg GAE/L in total polyphenols and 50.52 to 51.50 mg/L in total individual polyphenols through HPLC methods). Antioxidant potential was higher in wines produced with Hanseniaspora uvarum (133.60 mg Trolox/L) and Starmerella bacillaris (137.61 mg Trolox/L). Additionally, Starmerella bacillaris stands out due to its sugar consumption during fermentation (the totality of fructose and 43% of glucose) and 15.80 g/L of total organic acids compared to 9.23 g/L (on average) for the other yeasts. This knowledge can be advantageous to standardizing the winemaking process and increasing the bioactive compounds, resulting in the production of high-quality wines.

Influence of different Lachancea thermotolerans strains in the wine profile in the era of climate challenge

The study performed sequential fermentations of red grape juice using several strains of Lachancea thermotolerans and one strain of Saccharomyces cerevisiae. Due to the new conditions imposed by climate change, wine acidity must be affected as well as the volatile profile. Non-Saccharomyces yeasts such as L. thermotolerans are real alternatives to soften the impact of climate change in winemaking. The L. thermotolerans strains included three commercially available strains and two wine-related natural isolates. L. thermotolerans showed significant statistical differences in basic chemical parameters such as lactic acid, malic acid, or ethanol concentrations as well as in the volatile profile. S. cerevisiae clearly produced some volatile compounds in higher amounts than the studied L. thermotolerans strains while others showed the opposite effect. Sequential fermentations involving any of the studied strains of L. thermotolerans with S. cerevisiae showed an increased volatile profile compared to the S. ceresisiae single fermentation, highlighting the synergic effect between the studied species.

Effects of alcoholic fermentation on the non-volatile and volatile compounds in grapefruit (Citrus paradisi Mac. cv. Cocktail) juice: A combination of UPLC-MS/MS and gas chromatography ion mobility spectrometry analysis

Grapefruit has attracted much attention as a functional fruit, of which “Cocktail” is a special variety with low acidity. The present study aimed to investigate the effects of alcoholic fermentation on the non-volatile and volatile compounds of “Cocktail” grapefruit juice. To analyze, a non-targeted metabolomics method based on UPLC-MS/MS and volatiles analysis using GC-IMS were performed. A total of 1015 phytochemicals were identified, including 296 flavonoids and 145 phenolic acids, with noticeably increasing varieties and abundance following the fermentation. Also 57 volatile compounds were detected, and alcoholic fermentation was effective in modulating aromatic profiles of grapefruit juice, with terpenes and ketones decreasing, and alcohols increasing together with esters. Citraconic acid and ethyl butanoate were the most variable non-volatile and volatile substances, respectively. The results provide a wealth of information for the study of “Cocktail” grapefruit and will serve as a valuable reference for the large-scale production of grapefruit fermented juice in the future.

Yeasts from fermented Brazilian fruits as biotechnological tools for increasing phenolics bioaccessibility and improving the volatile profile in derived pulps

Caatinga Biome fruits have been scarcely explored as a source of biotechnological yeasts. This study isolated yeasts from naturally fermented Caatinga fruits and evaluated Hanseniaspora opuntiae125,Issatchenkia terricola 129, and Hanseniaspora opuntiae 148 on fermentation of soursop and umbu-cajá pulps. All strains were able to ferment the pulps (72 h), increasing (p < 0.05) acetic acid, phenolics concentration and bioaccessibility, and maintaining counts above 7 log CFU/mL after fermentation and/or in vitro digestion. H. opuntiae 125 showed the highest counts (8.43-8.76 log CFU/mL; p < 0.05) in pulps and, higher organic acids production, increased survival to digestion, and higher bioaccessibility of various phenolics (p < 0.05) in the umbu-cajá pulp.I. terricola129 andH. opuntiae 148 showed higher metabolic activity, concentration and bioaccessibility of specific phenolics in umbu-cajá and soursop pulps, respectively (p < 0.05). Volatiles varied (p < 0.05) with the yeast strain. Generally, the yeast biotechnological performance for pulp fermentation was better on its fruit source.

Native Non-Saccharomyces Yeasts as a Tool to Produce Distinctive and Diverse Tamjanika Grape Wines

The enological potential of two previously characterized indigenous yeast isolates, Hanseniaspora uvarum S-2 and Candida famata WB-1, in pure and sequential inoculation with commercial yeast Saccharomyces cerevisiae QA23 were analyzed in industrial-scale vinification of the grape variety Tamjanika. Their contribution to the quality and aroma profile was investigated by quantifying volatile compounds and wine sensory evaluation. Both yeast isolates were able to complete alcoholic fermentation, to reduce ethanol concentration up to 1.06% v/v (in monoculture) in comparation to S. cerevisiae QA23, and to enhance aroma and sensory profile. Based on calculated odor activity values (OAV), p-cymene, ethyl hexanoate, ethyl octanoate, and ethyl decanoate were the major aroma volatile compounds in all Tamjanika wine samples. Analyzed yeast strains significantly affected relative contribution of volatile compounds and can be considered responsible for the differences and uniqueness of the obtained wine samples. Besides confirmation of good enological and fermentative characteristics, selected isolates can be characterized as high ester-producing strains with potential to enhance the floral and fruity aromas of wine. The present study represents a further step toward the use of indigenous yeast isolates at industrial-scale fermentation in order to ensure the regional signature of Tamjanika wine.

Pareto Optimal Metabolic Engineering for the Growth-coupled Overproduction of Sustainable Chemicals

Our research aims to help industrial biotechnology develop a sustainable economy using green technology based on microorganisms and synthetic biology through two case studies that improve metabolic capacity in yeast models Yarrowia lipolytica (Y. lipolytica) and Saccharomyces cerevisiae (S. cerevisiae). We aim to increase the production capacity of beta‐carotene (β‐carotene) and succinic acid, which are among the highest market demands due to their versatile use in numerous consumer products. We performed simulations to identify in silico ranking of strains based on multiple objectives: the growth rate of yeast microorganisms, the number of used chromosomes, and the production capability of β‐carotene (for Y. lipolytica) and succinate (for S. cerevisiae). Our multiobjective optimization methodology identified notable gene deletions by searching a vast solution space to highlight near‐optimal strains on Pareto Fronts, balancing the above‐cited three objectives. Moreover, preserving the metabolic constraints and the essential genes, this study produced robust results: seven significant strains of Y. lipolytica and seven strains of S. cerevisiae. We examined gene knockout to study the function of genes and pathways. In fact, by studying the frequently silenced genes, we found that when the GPH1 gene is knocked out in S. cerevisiae, the isocitrate lyase enzyme is activated, which converts the isocitrate into succinate. Our goals are to simplify and facilitate the in vitro processes. Hence, we present strains with the least possible number of knockout genes and solutions in which the genes are turned off on the same chromosome. Therefore, we present results where the constraints mentioned above are met, like the strains where only two genes are switched off and other strains where half of the knockout genes are on the same chromosome. This study offers solutions for developing an efficient in vitro mutagenesis for microorganisms and demonstrates the efficiency of multiobjective optimization in automatizing metabolic engineering processes.

Formation, Losses, Preservation and Recovery of Aroma Compounds in the Winemaking Process

A wine’s aroma profile is an important part of the criteria affecting wine acceptability by consumers. Its characterisation is complex because volatile molecules usually belong to different classes such as alcohols, esters, aldehydes, acids, terpenes, phenols and lactones with a wide range of polarity, concentrations and undesirable off-aromas. This review focused on mechanisms and conditions of the formation of individual aroma compounds in wine such as esters and higher alcohols by yeast during fermentation. Additionally, aroma losses during fermentation are currently the subject of many studies because they can lead to a reduction in wine quality. Principles of aroma losses, their prevention and recovery techniques are described in this review.

Effects of three indigenous non-Saccharomyces yeasts and their pairwise combinations in co-fermentation with Saccharomyces cerevisiae on volatile compounds of Petit Manseng wines

The combined use of selected Saccharomyces cerevisiae and non-Saccharomyces strains is becoming an effective way to achieve wine products with distinctive aromas. The purpose of this study was to further improve the wine aroma complexity through optimizing inoculation protocols of multi-starters. The three indigenous non-Saccharomyces strains (Torulaspora delbrueckii, Hanseniaspora vineae, and Lachancea thermotolerans) and their pairwise combinations (co-inoculation) were sequentially inoculated with S. cerevisiae in Petit Manseng grape must, respectively. Results evidenced a higher divergence in aroma compounds produced by two different non-Saccharomyces species compared to single species. Especially for the combination of T. delbrueckii and L. thermotolerans, the concentrations of most ethyl esters were further increased, contributing to a higher score of 'pineapple' note in agreement with sensory analysis. Our results highlighted that the inoculation of more than one non-Saccharomyces species is a potential strategy to improve the aroma diversity and quality of industrial wines.

Assessment of chemical constitution and aroma properties of kiwi wines obtained from pure and mixed fermentation with Wickerhamomyces anomalus and Saccharomyces cerevisiae

BACKGROUND

To improve the aroma of kiwi wine through the utilization of Wickerhamomyces anomalus, kiwi juice was fermented using a selected W. anomalus strain in pure culture and mixed fermentations with Saccharomyces cerevisiae, which was inoculated simultaneously and sequentially. The physicochemical indices, volatile compounds and aroma properties of the kiwi wines were assessed.

RESULTS

The study suggested that the ethanol, color indices and organic acids of the wines were closely related to the method of inoculation. Compared with the pure S. cerevisiae fermentation, the mixed fermentations produced more varieties and concentrations of volatiles. The sequential fermentations increased the concentrations of esters and terpenes, improving the flower and sweet fruit notes of the wines. The simultaneous inoculation enhanced the contents of esters and aldehydes, intensifying the flower, sweet and sour fruit of the wines. Partial least-squares regression analysis showed that esters and terpenes contributed greatly to the flower and sweet fruit aroma, whereas aldehydes were the major contributors to the sour note.

CONCLUSION

Based on our results, the mixed fermentations not only enriched the types and concentrations of volatiles, but also had better sensory properties. © 2021 Society of Chemical Industry.

Effects of sequential inoculation of Lachancea thermotolerans and Oenococcus oeni on chemical composition of spent coffee grounds hydrolysates

Spent coffee grounds (SCG) disposal is an environmental problem. These residues from coffee brewing and instant coffee production have potential to produce novel alcoholic beverages. SCG valorization through sequential alcoholic and malolactic fermentation was investigated using a yeast, Lachancea thermotolerans Concerto and a lactic acid bacterium (LAB), Oenococcus oeni Lalvin 31 in this study. Our results showed that sequential inoculation prevented early death of yeast confronted when simultaneous inoculation was adopted, allowing for growth and persistence of both yeast and LAB till the end of fermentation. Adequate ethanol production (4.91 ± 0.13 %, v/v) with low residual sugar content was also attained. In addition, relatively lower levels of acetic, lactic, and succinic acids were produced by sequential inoculation than that of simultaneous inoculation. Furthermore, SCG hydrolysates fermented via sequential inoculation had the widest variety of volatiles (e.g. esters and ketones). Overall, our results indicated that sequential inoculation of L. thermotolerans and O. oeni in SCG hydrolysates might be a way to develop novel beverages with pleasant flavor profiles.

•

L. thermotolerans and O. oeni were used in spent coffee grounds (SCG) hydrolysates fermentation.

•

Sequential inoculation of O. oeni prevented early yeast cell death.

•

Sequential inoculation produced desired content of ethanol.

•

Sequential inoculation generated and/or retained the widest variety of volatiles.

Selection of Three Indigenous Lebanese Yeast Saccharomyces cerevisiae with Physiological Traits from Grape Varieties in Western Semi-Desert and Pedoclimatic Conditions in the Bekaa Valley

Wine production depends on the fermentation process performed by yeasts, especially (but not solely) strains of the species Saccharomyces cerevisiae, which is a technique that has been practiced from the Middle Ages till modern days. Selecting indigenous starters offers a beneficial technique to manage alcoholic grape juice fermentation, conserving the particular sensory qualities of wine produced from specific regions. This paper investigated yeast biodiversity of four grape varieties (Carignan, Syrah, Grenache, and Aswad Karesh) grown in the pedoclimatic western semi-desert Bekaa Valley. Further research identified, characterized, and selected strains with the most industrial wine interest and economic value to Lebanon. By using molecular methods and by the ITS PCR analysis, the isolates belonging to the Saccharomyces and non-Saccharomyces genus were identified. These isolates taken from four varieties were further characterized by amplification with Interdelta and δ12/δ21 primer pairs, permitting the identification of 96 S. cerevisiae strains. Forty-five genomically homogenous groups were classified through the comparison between their mtDNA RFLP patterns. Based on physiological characterization analysis (H2S and SO2 production, killer phenotype, sugar consumption, malic and acetic acid, etc.), three strains (NL28629, NL28649, and NL28652) showed interesting features, where they were also vigorously fermented in a synthetic medium. These strains can be used as a convenient starter for typical wine production. In particular, Carignan and Syrah had the highest percentage of strains with the most desirable physiological parameters.

An Integrative View of the Role of Lachancea thermotolerans in Wine Technology

The interest in Lachancea thermotolerans, a yeast species with unusual characteristics, has notably increased in all ecological, evolutionary, and industrial aspects. One of the key characteristics of L. thermotolerans is the production of high quantities of lactic acid compared to other yeast species. Its evolution has mainly been driven by the influence of the environment and domestication, allowing several metabolic traits to arise. The molecular regulation of the fermentative process in L. thermotolerans shows interesting routes that play a complementary or protective role against fermentative stresses. One route that is activated under this condition is involved in the production of lactic acid, presenting a complete system for its production, showing the involvement of several enzymes and transporters. In winemaking, the use of L. thermotolerans is nowadays mostly focused in early–medium-maturity grape varieties, in which over-ripening can produce wines lacking acidity and with high concentrations of ethanol. Recent studies have reported new positive influences on quality apart from lactic acid acidification, such as improvements in color, glutathione production, aroma, malic acid, polysaccharides, or specific enzymatic activities that constitute interesting new criteria for selecting better strains. This positive influence on winemaking has increased the availability of commercial strains during recent years, allowing comparisons among some of those products. Initially, the management of L. thermotolerans was thought to be combined with Saccaharomyces cerevisiae to properly end alcoholic fermentation, but new studies are innovating and reporting combinations with other key enological microorganisms such as Schizosaccharomyces pombe, Oenocous oeni, Lactiplantibacillus plantarum, or other non-Saccharomyces.

Wine Yeasts Selection: Laboratory Characterization and Protocol Review

Wine reflects the specificity of a terroir, including the native microbiota. In contrast to the use of Saccharomyces cerevisiae commercial starters, a way to maintain wines' microbial terroir identities, guaranteeing at the same time the predictability and reproducibility of the wines, is the selection of autochthonous Saccharomyces and non-Saccharomyces strains towards optimal enological characteristics for the chosen area of isolation. This field has been explored but there is a lack of a compendium covering the main methods to use. Autochthonous wine yeasts from different areas of Slovakia were identified and tested, in the form of colonies grown either on nutrient agar plates or in grape must micro-fermentations, for technological and qualitative enological characteristics. Based on the combined results, Saccharomyces cerevisiae PDA W 10, Lachancea thermotolerans 5-1-1 and Metschnikowia pulcherrima 125/14 were selected as potential wine starters. This paper, as a mixture of experimental and review contributions, provides a compendium of methods used to select autochthonous wine yeasts. Thanks to the presence of images, this compendium could guide other researchers in screening their own yeast strains for wine production.

Enological potential of non-Saccharomyces yeast strains of enological and brewery origin from Ukrainian Collection of Microorganisms

Non-conventional wine yeasts are extensively studied as promising producers of hydrolytic enzymes and as potential starter cultures in winemaking due to their ability to improve organoleptic properties of wine. Thirty-six yeast strains of enological and brewery origin from the Ukrainian Collection of Microorganisms belonging to Torulaspora, Kloeckera, Candida, Metschnikowia, Pichia, and Zygosaccharomyces genera have been screened for the production of extracellular hydrolases, stress tolerance, fermentative activity, and other traits of enological interest. This study revealed the high incidence of lipolytic, proteolytic, and β-glucosidase activities among the yeasts, while no pectinase activity was detected. Esterase, cellulase and glucanase activities were found in a small proportion of yeasts (8.33–16.66%). Several Pichia anomala, Kloekera javanica, Pichia membranifaciens, and Metschnikowia pulcherrima strains demonstrated a wide range of hydrolytic activities. High tolerance to stress factors (ethanol, osmotic, and oxidative stress) present during alcoholic fermentation was detected in P. anomala and M. pulcherrima strains. Fermentative activity of several yeast strains was evaluated in microfermentations in a model semi-synthetic medium. Strain P. anomala UCM Y-216 was selected as the most promising culture for winemaking due to its hydrolytic activities, tolerance to stress factors and other valuable metabolic traits. This study represents the first step for selecting a non-conventional yeast strain of enological origin as a potential co-culture for winemaking.

Native Yeasts and Lactic Acid Bacteria Isolated from Spontaneous Fermentation of Seven Grape Cultivars from the Maule Region (Chile)

Grapes are a source of native yeasts and lactic acid bacteria (LAB); however, the microbial make up is dependent on the grape cultivar and the regional growth conditions. Therefore, the aim of this study was to characterize the yeast and LAB in seven grape cultivars cultivated in Chile. Grape juices were fermented at 25 °C for 7 days. Samples were collected to analyze sugar, organic acids, and ethanol. Microbial evolution was measured with culture-dependent and molecular approaches. Then, a native isolated Candida oleophila was selected for further sequential fermentations with Saccharomyces cerevisiae. The grape cultivars in the Maule showed a diversity of non-Saccharomyces yeasts, with a greater diversity observed at the beginning of the fermentation. However, species from the Hansenasporia, Metschnikowia, Torulaspora, Lachancea, and Candida genera were detected after 7 days, suggesting tolerance to environments rich in ethanol, capability may be associated to the terroir studied, which is characterized by torrid weather and antique and traditional vineyards. The alcoholic fermentation negatively impacted the LAB population, and after 7 days only Leuconostoc mesenteroides was isolated. In the sequential fermentations, C. oleophila was able to produce fermented grape juices with <1.5 g/L glucose, 12.5% (v/v) alcohol, and low concentrations of malic (<1.00 g/L) and succinic (2.05 g/L) acids, while acetic acid reached values >0.3 (g/L). To our knowledge this is the first time C. oleophila has been reported as a potential starter culture for wine production. However, more studies are necessary to fully characterize the potential of C. oleophila on wine attributes.

The Combined Use of Lachancea thermotolerans and Lactiplantibacillus plantarum (former Lactobacillus plantarum) in Wine Technology

Most commercialized red wines are produced through alcoholic fermentation performed by yeasts of the Saccharomyces genus, and a second fermentation performed by lactic bacteria of the Oenococus oeni species once the first is completely finished. However, the classical process can suffer complications, of which the risks can increase in grape juices with high contents of sugar and pH. Due to climate change, these situations are becoming more common in the winemaking industry. The main risks in those scenarios are alcoholic-fermentation stops or sluggish and undesirable bacteria development while alcoholic fermentation is not finished yet and wine still contains residual sugars. The study propose a novel alternative that offers a solution or reduces the risk of those scenarios while increasing acidity, which is another serious problem of warm viticulture regions. The alternative consists of the combined use of Lachancea thermotolerans to reduce the pH of musts that suffer from a lack of acidity, Lactiplantibacillus plantarum (formerly Lactobacillus plantarum) to achieve malic acid stability during the first stages of alcoholic fermentation, and Saccharomyces bayanus to complete the alcoholic fermentation in difficult wines of high potential alcohol degree of over 15% (v/v). The new proposed biotechnology produced wines with higher final concentrations in lactic acid, glycerol, color intensity, ethyl lactate and 2-phenyl ethyl acetate in 2.39 g/L, 0.52 g/L, 21%, 48% and 37% respectively than the classical methodology where Saccharomyces genus performs alcoholic fermentation and later Oenococus oeni performs malolactic fermentation. Additionally, the new alternative produced wines with lower concentration in ethanol, pH, acetic acid, ethyl acetate, diacetyl and 1-propanol in 0.37% (v/v), 0.26, 0.08 g/L, 22%, 69% and 28% respectively than the classic method.

Improvement of Torulaspora delbrueckii Genome Annotation: Towards the Exploitation of Genomic Features of a Biotechnologically Relevant Yeast

Saccharomyces cerevisiae is the most commonly used yeast in wine, beer, and bread fermentations. However, Torulaspora delbrueckii has attracted interest in recent years due to its properties, ranging from its ability to produce flavor- and aroma-enhanced wine to its ability to survive longer in frozen dough. In this work, publicly available genomes of T. delbrueckii were explored and their annotation was improved. A total of 32 proteins were additionally annotated for the first time in the type strain CBS1146, in comparison with the previous annotation available. In addition, the annotation of the remaining three T. delbrueckii strains was performed for the first time. eggNOG-mapper was used to perform the functional annotation of the deduced T. delbrueckii coding genes, offering insights into its biological significance, and revealing 24 clusters of orthologous groups (COGs), which were gathered in three main functional categories: information storage and processing (28% of the proteins), cellular processing and signaling (27%), and metabolism (23%). Small intraspecies variability was found when considering the functional annotation of the four available T. delbrueckii genomes. A comparative study was also conducted between the T. delbrueckii genome and those from 386 fungal species, revealing a high number of homologous genes with species from the Zygotorulaspora and Zygosaccharomyces genera, but also with Lachancea and S. cerevisiae. Lastly, the phylogenetic placement of T. delbrueckii was clarified using the core homologs that were found across 204 common protein sequences of 386 fungal species and strains.

The Impact of Chitosan on the Chemical Composition of Wines Fermented with Schizosaccharomyces pombe and Saccharomyces cerevisiae

This study investigates the influence of the antimicrobial agent chitosan on a selected Schizosaccharomyces pombe strain during the alcoholic fermentation of ultra-pasteurized grape juice with a high concentration of malic acid. It also studies a selected Saccharomyces cerevisiae strain as a control. The study examines several parameters relating to wine quality, including volatile and non-volatile compounds. The principal aim of the study is to test the influence of chitosan on the final chemical composition of the wine during alcoholic fermentation, and to compare the two studied fermentative yeasts between them. The results show that chitosan influences the final concentration of acetic acid, ethanol, glycerol, acetaldehyde, pyruvic acid, α-ketoglutarate, higher alcohols, acetate esters, ethyl esters, and fatty acids, depending on the yeast species.

Total titratable acidity and organic acids of wines produced from cactus pear (Opuntia-ficus-indica) fruit and Lantana camara (L. Camara) fruit blended fermentation process employed response surface optimization

Fruits and fermentation methods are important sources of organic acids that determine organoleptic properties, microbiological and biochemical stability of fruit wines. This study is aimed at investigating total titrable acidity and organic acids of fruit wines produced by response surface optimization of cactus pear and Lantana camara fruits blend and cactus pear fruit alone. The predictive mathematical model of the blended fruit wine is well fitted (R 2 = 0.9618 and absolute average deviation (AAD) = 2.06%). The optimum values of fermentation temperature, inoculum concentration, and Lantana camara fruitjuice concentration to produce predictive total titrable acidity of 0.8% (w/v citric acid) were 24°C, 10% (v/v), and 10.7% (v/v), respectively. The blended fruit wine was with lower total titrable acidity (w/v citric acid) of 0.83 ± 0.058% compared to wine produced from cactus pear fruit alone 1.06 ± 0.27%. The high performance liquid chromatography (HPLC) analysis of both produced wines revealed the difference in concentration of citric (±3.35 mg/ml), L-tartaric (± 3.71 mg/ml), and L-ascorbic acid (± 0.07 mg/ml). Citric acid was predominant organic acid in both fruit wines, and its content in the cactus pear is 7.09 ± 0.07 mg/ml and blended fruit wine 4.74 ± 0.07 mg/ml.

The Effect of Non-Saccharomyces and Saccharomyces Non-Cerevisiae Yeasts on Ethanol and Glycerol Levels in Wine

Non-Saccharomyces and Saccharomyces non-cerevisiae studies have increased in recent years due to an interest in uninoculated fermentations, consumer preferences, wine technology, and the effect of climate change on the chemical composition of grapes, juice, and wine. The use of these yeasts to reduce alcohol levels in wines has garnered the attention of researchers and winemakers alike. This review critically analyses recent studies concerning the impact of non-Saccharomyces and Saccharomyces non-cerevisiae on two important parameters in wine: ethanol and glycerol. The influence they have in sequential, co-fermentations, and solo fermentations on ethanol and glycerol content is examined. This review highlights the need for further studies concerning inoculum rates, aeration techniques (amount and flow rate), and the length of time before Saccharomyces cerevisiae sequential inoculation occurs. Challenges include the application of such sequential inoculations in commercial wineries during harvest time.

Combined Use of Lachancea thermotolerans and Schizosaccharomyces pombe in Winemaking: A Review

The combined use of Lachancea thermotolerans and Schizosaccharomyces pombe is a new winemaking biotechnology that aims to solve some modern industrial oenology problems related to warm viticulture regions. These areas are characterized for producing musts with high levels of sugar that can potentially be converted into wines with elevated ethanol contents, which are usually associated with high pH levels. This biotechnology was reported for the first time in 2015, and since then, several scientific articles have been published regarding this topic. These reported scientific studies follow an evolution similar to that performed in the past for Saccharomyces cerevisiae and Oenococcus oeni; they start by reporting results for basic winemaking parameters at the beginning, later continuing with more advanced parameters. This review compares the results of different researchers that have applied this new biotechnology and have studied wine quality parameters such as ethanol, glycerol, malic acid, lactic acid, amino acids, aroma compounds, or anthocyanins. It is shown that the new biotechnology is repeatedly reported to solve specific winemaking problems such as the lack of acidity, biogenic amines, ethyl carbamate, or undesirable color losses. Such results highlight this biotechnology as a promising option for warm viticulture areas.

Selection of Saccharomyces cerevisiae Starter Strain for Merwah Wine

In order to select Saccharomyces cerevisiae starter strains for ‘‘Merwah’’ wine production, three strains (M.6.16, M.10.16, and M.4.17) previously isolated from ‘‘Merwah’’ must and characterized at the lab scale were tested in pilot-scale fermentation in a Lebanese winery during the 2019 vintage. The three inoculated musts were compared to that obtained with a spontaneous fermentation. During the fermentations, must samples were taken to evaluate the dominance of the inoculated strains, and at the end of fermentation, the obtained wines were subjected to chemical and sensorial characterization. Molecular monitoring by interdelta analysis revealed that only M.4.17 was able to complete the fermentation and dominate over the wild yeasts. Based on the analysis of principal technological parameters (i.e., residual sugar, fermentative vigor, sulfur production, and acetic acid) and sensorial analysis of the wines obtained, M.4.17 was selected as an adequate starter for the production of typical ‘‘Merwah’’ wine.

Zygotorulaspora cariocana sp. nov., a yeast species isolated from tree bark in Brazil

Six strains of a novel yeast species were isolated from tree bark collected in the Atlantic Forest and the Amazon Rainforest in Brazil. Analyses of the sequences of D1/D2 domains of the large subunit rRNA gene showed that the strains belong to a species in the genus Zygotorulaspora. The species differed by 5.54 % sequence divergence (25 substitutions and five indels out of 542 bp) in the D1/D2 sequences from Zygotorulaspora mrakii, its closest relative. The ITS sequence of the type strain of the novel species differs by 27–69 nucleotide substitutions/indels from the other Zygotorulaspora species. The novel species is able to grow on trehalose, maltose, l-sorbose, inulin and at 37 °C, which are negative in Z. mrakii. The name Zygotorulaspora cariocana sp. nov. is proposed. The holotype of Z. cariocana sp. nov. is CBS 16118T. The MycoBank number is MB 833702.

Yeasts for low input winemaking: Microbial terroir and flavor differentiation

Vitis vinifera flowers and grape fruits are one of the most interesting ecosystem niches for native yeasts development. There are more than a 100 yeast species and millions of strains that participate and contribute to design the microbial terroir. The wine terroir concept is understood when grape and wine micro-regions were delimited by different quality characteristics after humans had been growing vines for more than 10,000 years. Environmental conditions, such as climate, soil composition, water management, winds and air quality, altitude, fauna and flora and microbes, are considered part of the "terroir" and contribute to a unique wine style. If "low input winemaking" strategies are applied, the terroir effect will be expected to be more authentic in terms of quality differentiation. Interestingly, the role of the microbial flora associated with vines was very little study until recently when new genetic technologies for massive species identification were developed. These biotechnologies allowed following their environmental changes and their effect in shaping the microbial profiles of different wine regions. In this chapter we explain the interesting positive effects on flavor diversity and wine quality obtained by using "friendly" native yeasts that allowed the microbial terroir flora to participate and contribute during fermentation.

Climate Changes and Food Quality: The Potential of Microbial Activities as Mitigating Strategies in the Wine Sector

Climate change threatens food systems, with huge repercussions on food security and on the safety and quality of final products. We reviewed the potential of food microbiology as a source of biotechnological solutions to design climate-smart food systems, using wine as a model productive sector. Climate change entails considerable problems for the sustainability of oenology in several geographical regions, also placing at risk the wine typicity. The main weaknesses identified are: (i) The increased undesired microbial proliferation; (ii) the improved sugars and, consequently, ethanol content; (iii) the reduced acidity and increased pH; (iv) the imbalanced perceived sensory properties (e.g., colour, flavour); and (v) the intensified safety issues (e.g., mycotoxins, biogenic amines). In this paper, we offer an overview of the potential microbial-based strategies suitable to cope with the five challenges listed above. In terms of microbial diversity, our principal focus was on microorganisms isolated from grapes/musts/wines and on microbes belonging to the main categories with a recognized positive role in oenological processes, namely Saccharomyces spp. (e.g., Saccharomyces cerevisiae), non-Saccharomyces yeasts (e.g., Metschnikowia pulcherrima, Torulaspora delbrueckii, Lachancea thermotolerans, and Starmerella bacillaris), and malolactic bacteria (e.g., Oenococcus oeni, Lactobacillus plantarum).

Enological Repercussions of Non-Saccharomyces Species in Wine Biotechnology

The use of non-Saccharomyces yeasts in enology has increased since the beginning of the current century because of the potential improvements they can produce in wine sensory quality [...]

Enological Repercussions of Non-Saccharomyces Species

The bulk of the sugar fermentation in grape juice, in order to produce wine is carried out by yeasts of the genus Saccharomyces, mainly S [...]

The Importance of Yeasts on Fermentation Quality and Human Health-Promoting Compounds

Non-Saccharomyces are important during wine fermentation once they influence wine composition. In the early stages of wine fermentation, and together with indigenous or commercial strains of Saccharomyces cerevisiae, non-Saccharomyces are able to transform grape-must sugars into ethanol, CO2, and other important secondary metabolites. A better understanding of yeast biochemistry will allow the selection of yeast strains that have defined specific influences on fermentation efficiency, wine quality, and the production of human health-promoting compounds. Yeast metabolism produces compounds derived from tryptophan, melatonin, and serotonin, which are found in fermented beverages, such as wine and beer. Melatonin is a neurohormone secreted from the pineal gland and has a wide-ranging regulatory and neuroprotective role, while serotonin, as well as being a precursor of melatonin synthesis, is also a neurotransmitter. This review summarizes the importance of some conventional and nonconventional yeast strains’ alcoholic fermentations, especially in the production of metabolites that promote human health and thus, attract consumers attention towards fermented beverages. A brief reference is also made on fermented beverages containing probiotics, namely kombucha, also known as kombucha tea, and its interesting microorganism’s symbiotic relationships named SCOBY.