1
|
Hab Alrman K, Alhariri S, Al- Bakri I. Ultrafiltration membrane based on chitosan/adipic acid: Synthesis, characterization and performance on separation of methylene blue and reactive yellow-145 from aqueous phase. Heliyon 2024; 10:e31055. [PMID: 38867965 PMCID: PMC11167248 DOI: 10.1016/j.heliyon.2024.e31055] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/18/2024] [Revised: 05/05/2024] [Accepted: 05/09/2024] [Indexed: 06/14/2024] Open
Abstract
Here, we report for the first time using of the nontoxic chitosan/adipic acid cross-linked membrane CS/AA in the separation of methylene blue and reactive yellow-145 from aqueous phase. The reason we chose adipic acid as a cross-linking agent is because it gives the cross-linked membrane moderate flexibility due to the presence of four methylene groups in its structure. The structure of the cross-linked membrane CS/AA and their properties were confirmed through, FTIR, differential scanning calorimetry (DSC), thermogravimetric analysis (TGA), atomic force microscopy (AFM), and BET analysis. The thermal properties of membrane indicated an improvement in its flexibility and hydrophobicity, but this improvement was accompanied by a decrease in its thermal stability. pHpzc value and porosity of the CS/AA were 7.88, and 73.95 % respectively. The average pore radius distribution ranged from 2 to 27 nm. The prepared cross-linked membrane provides spontaneous and continuous purification of water with a high efficiency. This is due to the membrane CS/AA ability to separate methylene blue and reactive yellow-145 from the aqueous phase almost completely. The results revealed that the removal efficiency and permeation flux for MB were 100 % and 1 L/m2.h respectively at initial dye concentration of (4,8) mg/L, at 1 bar, and the removal efficiency and permeation flux for RY-145 were (94,96) % and (1.06, 2.09) L/m2.h respectively at 100 mg/L and at (1,1.5) bar. Such cross-linked nanopore polymer membranes provide a new approach for emerging novel purification systems, principally in the field of environmental field.
Collapse
Affiliation(s)
- Khaled Hab Alrman
- Department of Chemistry, Faculty of Science, Damascus University, Syrian Arab Republic
| | - Sahar Alhariri
- Department of Chemistry, Faculty of Science, Damascus University, Syrian Arab Republic
| | - Iman Al- Bakri
- Department of Chemistry, Faculty of Science, Damascus University, Syrian Arab Republic
| |
Collapse
|
2
|
Cuvillier L, Passaretti A, Guilminot E, Joseph E. Agar and Chitosan Hydrogels' Design for Metal-Uptaking Treatments. Gels 2024; 10:55. [PMID: 38247779 PMCID: PMC10815442 DOI: 10.3390/gels10010055] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/06/2023] [Revised: 12/16/2023] [Accepted: 12/20/2023] [Indexed: 01/23/2024] Open
Abstract
In the field of cultural heritage, the use of natural gels is rising for the application of active agents. Here, two natural polymers are assessed: agar, a pioneer hydrogel for conservation treatments, and chitosan, a rather novel and metal-binding gel. For chitosan, a state-of-the-art based formulation (CS-ItA-LCys) is evaluated as it was reported for silver-complexing properties. It is evaluated whether these polymers can withstand the addition of the chelating compound deferoxamine, which is a bacterial siderophore. This allows for the obtainment of completely bio-sourced gel systems. A Fourier-transformed (FT) infrared spectroscopy characterization is performed, completed with rheological measurements and Cryo-Scanning Electron Microscopy (cryo-SEM) to investigate the physico-chemical properties of the gels, as well as their interaction with deferoxamine. Both polymers are also tested for their inherent complexing ability on silver ions using FT-Raman spectroscopy. A multi-analytical comparison shows different microstructures, in particular, the presence of a thick membrane for chitosan and different mechanical behaviors, with agar being more brittle. Neither hydrogel seems affected by the addition of deferoxamine; this is shown by similar rheological behavior and molecular structures in the presence or absence of the chelator. The intrinsic abilities of the chitosan formulation to make silver complex are demonstrated with the observation of two peaks characteristic of Ag-S and Ag-O bonds. Agar and chitosan are both proven to be reliable gels to act as carriers for bio-based active agents. This paper confirms the potential asset of the chitosan formulation CS-ItA-LCys as a promising gel for the complexation of soluble silver.
Collapse
Affiliation(s)
- Luana Cuvillier
- Laboratory of Technologies for Heritage Materials, University of Neuchâtel, Bellevaux 51, 2000 Neuchâtel, Switzerland; (L.C.); (A.P.)
- Haute Ecole Arc Conservation Restauration, University of Applied Sciences and Arts Western Switzerland HES-SO, Espace de l’Europe 11, 2000 Neuchâtel, Switzerland
| | - Arianna Passaretti
- Laboratory of Technologies for Heritage Materials, University of Neuchâtel, Bellevaux 51, 2000 Neuchâtel, Switzerland; (L.C.); (A.P.)
- Haute Ecole Arc Conservation Restauration, University of Applied Sciences and Arts Western Switzerland HES-SO, Espace de l’Europe 11, 2000 Neuchâtel, Switzerland
| | - Elodie Guilminot
- Arc’Antique Conservation and Research Laboratory, 26 Rue de la Haute Forêt, 44300 Nantes, France;
| | - Edith Joseph
- Haute Ecole Arc Conservation Restauration, University of Applied Sciences and Arts Western Switzerland HES-SO, Espace de l’Europe 11, 2000 Neuchâtel, Switzerland
| |
Collapse
|
3
|
Lewicki S, Zwoliński M, Hovagimyan A, Stelmasiak M, Szarpak Ł, Lewicka A, Pojda Z, Szymański Ł. Chitosan-Based Dressing as a Sustained Delivery System for Bioactive Cytokines. Int J Mol Sci 2023; 25:30. [PMID: 38203201 PMCID: PMC10778940 DOI: 10.3390/ijms25010030] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/26/2023] [Revised: 12/08/2023] [Accepted: 12/14/2023] [Indexed: 01/12/2024] Open
Abstract
Wounds represent a common occurrence in human life. Consequently, scientific investigations are underway to advance wound healing methodologies, with a notable focus on dressings imbued with biologically active compounds capable of orchestrating the wound microenvironment through meticulously regulated release mechanisms. Among these bioactive agents are cytokines, which, when administered to the wound milieu without appropriate protection, undergo rapid loss of their functional attributes. Within the context of this research, we present a method for fabricating dressings enriched with G-CSF (granulocyte colony-stimulating factor) or GM-CSF (granulocyte-macrophage colony-stimulating factor), showcasing both biological activity and protracted release dynamics. Based on Ligasano, a commercial polyurethane foam dressing, and chitosan crosslinked with TPP (sodium tripolyphosphate), these dressings are noncytotoxic and enable cytokine incorporation. The recovery of cytokines from dressings varied based on the dressing preparation and storage techniques (without modification, drying, freeze-drying followed by storage at 4 °C or freeze-drying followed by storage at 24 °C) and cytokine type. Generally, drying reduced cytokine levels and their bioactivity, especially with G-CSF. The recovery of G-CSF from unmodified dressings was lower compared to GM-CSF (60% vs. 80%). In summary, our freeze-drying approach enables the storage of G-CSF or GM-CSF enriched dressings at 24 °C with minimal cytokine loss, preserving their biological activity and thus enhancing future clinical availability.
Collapse
Affiliation(s)
- Sławomir Lewicki
- Institute of Outcomes Research, Maria Sklodowska-Curie Medical Academy, 03-411 Warsaw, Poland
| | - Michał Zwoliński
- Faculty of Medical Sciences and Health Sciences, Kazimierz Pulaski University of Radom, 26-600 Radom, Poland; (M.Z.); (A.H.); (M.S.)
| | - Adrian Hovagimyan
- Faculty of Medical Sciences and Health Sciences, Kazimierz Pulaski University of Radom, 26-600 Radom, Poland; (M.Z.); (A.H.); (M.S.)
| | - Marta Stelmasiak
- Faculty of Medical Sciences and Health Sciences, Kazimierz Pulaski University of Radom, 26-600 Radom, Poland; (M.Z.); (A.H.); (M.S.)
| | - Łukasz Szarpak
- Henry JN Taub Department of Emergency Medicine, Baylor College of Medicine, Houston, TX 77030, USA;
- Department of Clinical Research and Development, LUX MED Group, 02-676 Warsaw, Poland
| | - Aneta Lewicka
- Military Centre of Preventive Medicine, 05-100 Nowy Dwór Mazowiecki, Poland;
| | - Zygmunt Pojda
- Department of Regenerative Medicine, Maria Sklodowska-Curie National Research Institute of Oncology, 02-781 Warsaw, Poland;
| | - Łukasz Szymański
- Department of Molecular Biology, Institute of Genetics and Animal Biotechnology, Polish Academy of Sciences, 05-552 Magdalenka, Poland
| |
Collapse
|
4
|
Armendáriz-Ontiveros MM, Villegas-Peralta Y, Madueño-Moreno JE, Álvarez-Sánchez J, Dévora-Isiordia GE, Sánchez-Duarte RG, Madera-Santana TJ. Modification of Thin Film Composite Membrane by Chitosan-Silver Particles to Improve Desalination and Anti-Biofouling Performance. MEMBRANES 2022; 12:membranes12090851. [PMID: 36135870 PMCID: PMC9505310 DOI: 10.3390/membranes12090851] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/13/2022] [Revised: 08/24/2022] [Accepted: 08/27/2022] [Indexed: 05/26/2023]
Abstract
Reverse osmosis (RO) desalination is a technology that is commonly used to mitigate water scarcity problems; one of its disadvantages is the bio-fouling of the membranes used, which reduces its performance. In order to minimize this problem, this study prepared modified thin film composite (TFC) membranes by the incorporation of chitosan-silver particles (CS-Ag) of different molecular weights, and evaluated them in terms of their anti-biofouling and desalination performances. The CS-Ag were obtained using ionotropic gelation, and were characterized by Fourier transform infrared spectroscopy (FTIR), high-resolution scanning electron microscopy (HR-SEM), energy-dispersive X-ray spectroscopy (EDX), thermogravimetric analysis (TGA) and dynamic light scattering (DLS). The modified membranes were synthetized by the incorporation of the CS-Ag using the interfacial polymerization method. The membranes (MCS-Ag) were characterized by Fourier transform infrared spectroscopy (FTIR), atomic force microscopy (AFM) and contact angle. Bactericidal tests by total cell count were performed using Bacillus halotolerans MCC1, and anti-adhesion properties were confirmed through biofilm cake layer thickness and total organic carbon (%). The desalination performance was defined by permeate flux, hydraulic resistance, salt rejection and salt permeance by using 2000 and 5000 mg L-1 of NaCl. The MCS-Ag-L presented superior permeate flux and salt rejection (63.3% and 1% higher, respectively), as well as higher bactericidal properties (76% less in total cell count) and anti-adhesion capacity (biofilm thickness layer 60% and total organic carbon 75% less, compared with the unmodified membrane). The highest hydraulic resistance value was for MCS-Ag-M. In conclusion, the molecular weight of CS-Ag significantly influences the desalination and the antimicrobial performances of the membranes; as the molecular weight decreases, the membranes' performances increase. This study shows a possible alternative for increasing membrane useful life in the desalination process.
Collapse
Affiliation(s)
| | - Yedidia Villegas-Peralta
- Departamento de Ciencias del Agua y Medio Ambiente, Instituto Tecnológico de Sonora, 5 de Febrero 818 Sur, Ciudad Obregón 85000, Mexico
| | - Julia Elizabeth Madueño-Moreno
- Departamento de Ciencias del Agua y Medio Ambiente, Instituto Tecnológico de Sonora, 5 de Febrero 818 Sur, Ciudad Obregón 85000, Mexico
| | - Jesús Álvarez-Sánchez
- Departamento de Ciencias del Agua y Medio Ambiente, Instituto Tecnológico de Sonora, 5 de Febrero 818 Sur, Ciudad Obregón 85000, Mexico
| | - German Eduardo Dévora-Isiordia
- Departamento de Ciencias del Agua y Medio Ambiente, Instituto Tecnológico de Sonora, 5 de Febrero 818 Sur, Ciudad Obregón 85000, Mexico
| | - Reyna G. Sánchez-Duarte
- Departamento de Ciencias del Agua y Medio Ambiente, Instituto Tecnológico de Sonora, 5 de Febrero 818 Sur, Ciudad Obregón 85000, Mexico
| | | |
Collapse
|
5
|
Application of microbial immobilization on chitosan composite membrane for manganese removal in water treatment. POLYMER 2022. [DOI: 10.1016/j.polymer.2022.124531] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/17/2023]
|
6
|
Biocompatible fibers from fungal and shrimp chitosans for suture application. CURRENT RESEARCH IN BIOTECHNOLOGY 2022. [DOI: 10.1016/j.crbiot.2022.10.007] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022] Open
|
7
|
Hidalgo AM, Murcia MD. Membranes for Water and Wastewater Treatment. MEMBRANES 2021; 11:membranes11040295. [PMID: 33921781 PMCID: PMC8073157 DOI: 10.3390/membranes11040295] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Download PDF] [Subscribe] [Scholar Register] [Received: 03/29/2021] [Accepted: 04/09/2021] [Indexed: 01/05/2023]
|