“What a Waste”—Can We Improve Sustainability of Food Animal Production Systems by Recycling Food Waste Streams into Animal Feed in an Era of Health, Climate, and Economic Crises?

Quantitative risk assessment model of the presence of porcine epidemic diarrhea and African swine fever viruses in spray-dried porcine plasma

Introduction

There are no microbiological regulatory limits for viruses in animal feed and feed ingredients.

Methods

A performance objective (PO) was proposed in this study to manufacture a spray-dried porcine plasma (SDPP) batch absent of any infectious viral particles. The PO levels of -7.0, -7.2, and -7.3 log TCID50/g in SDPP were estimated for three batch sizes (10, 15, and 20 tons).

Results and discussion

A baseline survey on the presence of porcine epidemic diarrhea virus (PEDV) in raw porcine plasma revealed a concentration of -1.0 ± 0.6 log TCID50/mL as calculated using a TCID50-qPCR derived standard curve. The mean African swine fever virus (ASFV) concentration in raw plasma was estimated to be 0.6 log HAD50/mL (0.1-1.4, 95% CI) during a pre-clinical scenario (collected from asymptomatic and undetected viremic pigs). Different processing scenarios (baseline: spray-drying + extended storage) and baseline + ultraviolet (UV) radiation were evaluated to meet the PO levels proposed in this study. The baseline and baseline + UV processing scenarios were >95 and 100% effective in achieving the PO for PEDV by using different batch sizes. For the ASFV in SDPP during a pre-clinical scenario, the PO compliance was 100% for all processing scenarios evaluated. Further research is needed to determine the underlying mechanisms of virus inactivation in feed storage to further advance the implementation of feed safety risk management efforts globally.

The American cockroach (Periplaneta americana) residue could partially replace the dietary puffed soybean meal in the Three-yellow chickens

Periplaneta americana residue is a byproduct of using Periplaneta americana in pharmaceutical research and development for extracting active ingredients. Three hundred Three-yellow chickens were selected for the experiment and randomly divided into 6 groups (5 replications per group, 10 chickens per replicate): the control group (group A) was fed a basal ration, and the experimental groups (groups B, C, D, E, and F) were fed experimental diets in which P. americana residue replaced puffed soybean meal at proportions of 20, 40, 60, 80, and 100%, respectively, for a period of 42 d. The aim was to assess the impact of different levels of P. americana residue on the growth, survival, intestinal morphology, digestive enzyme activity, intestinal flora, and intestinal transcriptional responses of Three-yellow chickens. The results indicated that the increase in P. americana residue levels had a linear and quadratic impact on the average daily gain (ADG) and feed conversion ratio (FCR), respectively. The ADG was notably greater in the 40% group than in the 100% group, while the FCR was significantly lower in the 20% and 40% groups than in the 100% group (P < 0.05). Protease, lipase, and amylase activities exhibited a quadratic increase with increasing concentrations of P. americana residue (P < 0.05). Protease and lipase activities were notably greater in the 20% and 40% groups than in the 0% group (control group), amylase activity was significantly greater in the 40% group than in the 0% group (control group) (P < 0.05). Duodenal crypt depth (CD) decreased quadratically with increasing P. americana residue (P < 0.05). The duodenal villus height/crypt depth ratio (V/C) was significantly lower in the 100% group than in the 60% group (P < 0.05). The intestinal villus height (VH) increased quadratically with increasing levels of P. americana residue. The VH in the 60% group was significantly greater than that in the 0% (control group), 20, 80, and 100% groups (P < 0.05). The Chao and Ace indices demonstrated linear and quadratic increases with increasing levels of P. americana residue, while the Pd index showed a quadratic increase with increasing levels of P. americana residue (P < 0.05). The relative abundance profile of Lactobacillus exhibited a linear and quadratic decrease with increasing levels of P. americana residue, with the 100% group showing a significantly lower abundance than the 0% (control group) and 40% groups (P < 0.05). The transcriptome results showed that P. americana residue could enhance the digestive system by promoting vitamin, fat, carbohydrate digestion and absorption, cholesterol metabolism, etc. In conclusion, P. americana residue can replace puffed soybean meal without negatively affecting the growth performance of three-yellow chickens. The low and medium groups had positive effects on the growth performance, digestive enzyme activity, intestinal morphology, intestinal flora, and substance digestion and absorption of three-yellow chickens. The recommended replacement of P. americana residue for puffed soybean meal in the diets of three-yellow chickens ranged from 20% to 60%.

The management and prevention of food losses and waste in low- and middle-income countries: A mini-review in the Africa region

This mini-review analyses food losses and waste (FLW) management in low- and middle-income countries (LMICs) and identifies potential strategies to improve FLW management efficiency on the African continent. To achieve this aim, a search of grey and published scientific literature-case studies, feasibility studies, theses, peer-reviewed journals, governments and technical reports was performed. Food waste (FW) per capita in sub-Saharan Africa (SSA) was determined to be between 6 and 11 kg capita-1 year-1. Factors militating against FLW management include a lack of infrastructure, waste reduction and mandatory waste management plans, financial support for food redistribution programmes, awareness and a lack of knowledge of FW management and effective approaches. Poor recovery systems, a lack of incentives in FW recycling programmes, a lack of a regulatory and policy framework and institutional weaknesses as well as a lack of sufficient and appropriate education programmes to improve FW source separation and collection rates are all significant challenges in the African region, with negative consequences for the environment and public health. Except for fuel conversion and food scraps for digestion to recover energy, there is a huge potential for composting and using FW as a digestate, which could eventually lead to a reduction in the amount of FW being landfilled or incinerated. The study explores potential interventions to reduce amount of FLW and form a basis for future research in this field and improving FW management efficiency in LMCs, especially on the continent of Africa. It also provides information that could assist researchers, policymakers and decision-makers reduce amount of FLW, aid in the utilization of FW for energy production, and reduce greenhouse gas emissions in the continent, as well as support the achievement of other sustainable development goals, such as 12.3, which is particularly important in the context of the African continent, which is dependent on food imports.

Transforming food waste into animal feeds: an in-depth overview of conversion technologies and environmental benefits

Food waste is a global concern, with significant quantities of edible food being discarded every day. However, innovative conversion technologies have emerged to effectively transform this waste into valuable animal feed. This review paper provides a comprehensive examination of the conversion technologies used to transform food waste into animal feed, along with an analysis of the environmental benefits associated with these processes. The paper delves into various conversion methods such as anaerobic digestion, insect-based conversion, and microbial fermentation along with exploring their mechanisms and suitability for converting food waste into valuable animal feed resources. Additionally, the environmental benefits, including waste reduction, greenhouse gas emission reduction, and resource conservation, are discussed in detail. The review highlights the potential of these technologies to address the pressing issue of food waste while contributing to a more sustainable and resource-efficient food system. The findings of this review emphasize the importance of adopting and further developing these conversion technologies as a means to mitigate environmental impacts, promote circular economy principles, and enhance the overall sustainability of the food and agriculture sector.

Preserving global land and water resources through the replacement of livestock feed crops with agricultural by-products

While animal-source foods contribute to 16% of the global food supply and are an important protein source in human diets, their production uses a disproportionately large fraction of agricultural land and water resources. Therefore, a global comprehensive understanding of the extent to which livestock production competes directly or indirectly with food crops is needed. Here we use an agro-hydrological model combined with crop-specific yield data to investigate to what extent the replacement of some substitutable feed crops with available agricultural by-products would spare agricultural land and water resources that could be reallocated to other uses, including food crop production. We show that replacing 11-16% of energy-rich feed crops (that is, cereals and cassava) with agricultural by-products would allow for the saving of approximately 15.4-27.8 Mha of land, and 3-19.6 km3 and 74.2-137.8 km3 of blue and green water, respectively, for the growth of other food crops, thus providing a suitable strategy to reduce unsustainable use of natural resources both locally or through virtual land and water trade.

Effects of Olea europaea L. Polyphenols on the Animal Welfare and Milk Quality in Dairy Cows

Here, we evaluated the effect of dietary supplementation with an Olea europaea L. extract on the animal welfare and milk quality of dairy cows. Thirty Italian Holstein-Friesian dairy cows in the mid-lactation phase (90 to 210 days) were blocked into experimental groups based on parity class (namely, primiparous (P) (n = 10), secondiparous (S) (n = 10) and pluriparous (PL) (n = 10)) and received, for 60 days, Phenofeed Dry® at 500 mg/cow/day. Milk and blood samples were collected before the start of the treatment (T0), subsequently every 15 days (T1-T4) and at 45 days after the end of treatment (T5). In the serum, glucose and triglycerides, stress, the thyroid, lactation and sex hormones were measured; in the milk, lysozyme content as well as the fatty acid profile were assessed. In the whole animal, the enriched feed helped to maintain hormonal parameters in the physiological range while producing hypoglycemic (T4 vs. T0, for P and PL p < 0.001) and hypolipidemic effects (T4 vs. T0, for P p < 0.001 and for PL p < 0.01). At the milk level, it resulted in a reduction in total fat (T5 vs. T0, for P, S and PL p < 0.001) and in the saturated fatty acids (SFAs)/monounsaturated fatty acids (MUFAs) ratio paralleled by an increase in polyunsaturated fatty acids (PUFAs) (T5 vs. T0, for P, S and PL p < 0.001), protein content (lysozyme (T4 vs. T0, for P and PL p < 0.001)) and lactose (T5 vs. T0, for P, S and PL p < 0.001). Thus, the inclusion of natural bioactive molecules such as O. europaea L. polyphenols in the dairy cow diet may help to improve animal welfare and milk quality.

Low-opportunity-cost feed can reduce land-use-related environmental impacts by about one-third in China

Feeding animals more low-opportunity-cost feed products (LCFs), such as food waste and by-products, may decrease food-feed competition for cropland. Using a feed allocation optimization model that considers the availability of feed sources and animal requirements for protein and energy, we explored the perspectives of feeding more LCFs to animals in China. We found that about one-third of the animal feed consisted of human-edible products, while only 23% of the available LCFs were used as feed during 2009-2013. An increased utilization of LCFs (45-90 Mt) could potentially save 25-32% of feed-producing cropland area without impairing livestock productivity. Parallelly, about one-third of feed-related irrigation water, synthetic fertilizer and greenhouse gas emissions would be saved. Re-allocating the saved cropland could sustain the food energy demand of 30-185 million people. Achieving the potentials of increased LCF use requires improved technology and coordination among stakeholders.

Review: Composition and utilisation of feed by monogastric animals in the context of circular food production systems

Food production has a major impact on environmental emissions, climate change and land-use. To reduce this impact, the circularity of future food production systems is expected to become increasingly important. In a circular food system, crop land is primarily used for plant-based food production, while low-opportunity cost feed materials (LCF), i.e. crop residues, co-products of the food industry, grass from marginal land and food waste form the basis of future, animal feeds. Animal diets thus contain much less cereals and soybean meal and include a higher proportion of diverse co-products, residues and novel human-inedible ingredients. These diets are characterised by a lower starch content, and a higher content of fibre, protein, fat, and phytate compared to present diets. In this review, possible consequences of the development towards a more circular food system for the type, volume and nutritional characteristics of feed materials and complete feeds are addressed and related research questions in the area of animal nutrition, physiology and metabolism are discussed. Additional attention is given to possible effects on intestinal health and gut functionality and to (bio)technological processing of LCF to improve their suitability for feeding farm animals, with a focus on the effects in pigs and poultry. It is concluded that an increased use of LCF may limit the use of presently used criteria for the efficiency of animal production and nutrient utilisation. Development of characteristics that reflect the efficacy and efficiency of the net contribution of animal production in a circular food system is required. Animal scientists can have an important role in the development of more circular food production systems by focussing on the optimal use of LCF in animal diets for the production of animal-source food, while minimising the use of human-edible food in animal feed.

Valorization of Food Waste as Animal Feed: A Step towards Sustainable Food Waste Management and Circular Bioeconomy

The growing population and healthy food demands have led to a rise in food waste generation, causing severe environmental and economic impacts. However, food waste (FW) can be converted into sustainable animal feed, reducing waste disposal and providing an alternative protein source for animals. The utilization of FW as animal feed presents a solution that not only tackles challenges pertaining to FW management and food security but also lessens the demand for the development of traditional feed, which is an endeavour that is both resource and environmentally intensive in nature. Moreover, this approach can also contribute to the circular economy by creating a closed-loop system that reduces the use of natural resources and minimizes environmental pollution. Therefore, this review discusses the characteristics and types of FW, as well as advanced treatment methods that can be used to recycle FW into high-quality animal feed and its limitations, as well as the benefits and drawbacks of using FW as animal feed. Finally, the review concludes that utilization of FW as animal feed can provide a sustainable solution for FW management, food security, preserving resources, reducing environmental impacts, and contributing to the circular bioeconomy.

The use of animal by-products in a circular bioeconomy: Time for a TSE road map 3?

In 2005 and 2010, the European Commission (EC) published two subsequent 'Road Maps' to provide options for relaxation of the bans on the application of animal proteins in feed. Since then, the food production system has changed considerably and demands for more sustainability and circularity are growing louder. Many relaxations envisioned in the second Road Map have by now been implemented, such as the use of processed animal proteins (PAPs) from poultry in pig feed and vice versa. However, some legislative changes, in particular concerning insects, had not been foreseen. In this article, we present a new vision on legislation for increased and improved use of animal by-products. Six current legislative principles are discussed for the bans on animal by-products as feed ingredients: feed bans; categorization of farmed animals; prohibition unless explicitly approved; approved processing techniques, the categorization of animal by-products, and monitoring methods. We provide a proposal for new guiding principles and future directions, and several concrete options for further relaxations. We argue that biological nature of farmed animals in terms of dietary preferences should be better recognised, that legal zero-tolerance limits should be expanded if safe, and that legislation should be revised and simplified.

Pearls before Swine: Plant-Derived Wastes to Produce Low-Cholesterol Meat from Farmed Pigs-A Bibliometric Analysis Combined to Meta-Analytic Studies

Due to environmental and human factors, there is a growing amount of agri-food waste worldwide. The European Commission is incentivizing a zero-waste policy by 2025, pushing to find a "second life" for at least the avoidable ones. In this review, after summarizing the nutritional values of pork and the importance of its inclusion in human diet, a phylogenetic analysis was conducted to investigate potential differences in the structure and activity of HMGCR, which is a key enzyme in cholesterol metabolism. In addition, a bibliometric analysis combined with visual and meta-analytical studies on 1047 scientific articles was conducted to understand whether the inclusion of agro-food waste could affect the growth performance of pigs and reduce cholesterol levels in pork. Although some critical issues were highlighted, the overall data suggest a modern and positive interest in the reuse of agri-food waste as swine feed. However, although interesting and promising results have been reported in several experimental trials, further investigation is needed, since animal health and meat quality are often given marginal consideration.

Standardized ileal digestibility of amino acids differs among sources of bakery meal when fed to growing pigs

A multistate experiment involving universities in IL, IN, KY, and MN was conducted as a part of the research efforts by the North-Central Coordinating Committee-42 on swine nutrition. The null hypothesis that there are no differences in the standardized ileal digestibility (SID) of amino acids (AA) among different sources of bakery meal was tested. Eleven sources of bakery meal were procured from swine-producing states in the United States and each source was included in one diet as the sole source of AA. A N-free diet was prepared as well. Diets were prepared in one batch and divided into four sub-batches that were subsequently distributed to the four participating universities. At each university, diets were fed to 12 pigs that had a T- cannula installed in the distal ileum. Pigs were allotted to incomplete Latin square designs with 12 pigs and 4, 5, or 6 periods for a total of 21 replicate pigs per diet. Each period lasted 7 d with ileal digesta being collected from the cannulas on days 6 and 7. Samples were analyzed for AA and the SID of each AA was calculated. Results indicated that there were differences (P < 0.001) in the SID of all AA except Pro among the 11 sources of bakery meal. The differences in SID of AA observed in this experiment were greater than what is usually observed among sources of the same ingredient, indicating that there is more variability among sources of bakery meal than among different sources of other ingredients. This is likely a consequence of different raw materials being used in the production of different sources of bakery meal. Regardless of source of bakery meal, the AA with the least SID was Lys indicating that some of the raw materials in the product streams used to generate the bakery meals may have been overheated. Additionally, the Lys:crude protein ratio in each source of bakery meal was not a good predictor of the SID of Lys, which likely reflects the different raw materials being included in the different meals. In conclusion, the SID of AA varies among different sources of bakery meal and the SID of Lys is less than the SID of all other indispensable AA.

Digestibility of energy and concentrations of metabolizable energy and net energy varies among sources of bakery meal when fed to growing pigs

The null hypothesis that there are no differences in concentrations of digestible energy (DE), metabolizable energy (ME), and net energy (NE) among different sources of bakery meal was tested in a regional experiment involving 5 of the universities on the North Central Coordinating Committee-42 on Swine Nutrition. Eleven sources of bakery meal were procured from the swine producing areas in the United States and included in one diet as the only energy containing ingredient, and each diet was then divided into 5 batches that were used at the University of Illinois, Purdue University, University of Kentucky, University of Nebraska, and North Carolina State University. At each university, diets were fed to 22 growing pigs (2 pigs per diet) that were placed in metabolism crates, and feces and urine were collected for 5 d after a 7-d adaptation period. Diets and collected samples of feces and urine were dried and analyzed for gross energy. The apparent total tract digestibility of dry matter (DM) and gross energy and concentrations of DE, ME, and NE were calculated. Results indicated that there were considerable variation in the nutritional composition among the different sources of bakery meal with relatively large coefficients of variation for crude protein, starch, and acid hydrolyzed ether extract, but it was possible to analyze all sources of bakery meal to account for 100% of the ingredients. The average DE, ME, and NE in the 11 sources of bakery meal was 3,827, 3,678, and 2,799 kcal/kg DM, respectively. However, in contrast to the hypothesis, differences (P < 0.05) among sources of bakery meal in concentrations of DE (3,827 ± 201 kcal/kg DM), ME 3,678 ± 200 kcal/kg DM), and NE (2,799 ± 156 kcal/kg DM) were observed, but the variation among the 11 sources of bakery meal was not greater than what is usually observed among different sources of other ingredients. The differences observed are likely a consequence of the different product streams and production procedures used to produce the bakery meal. In conclusion, the average DE, ME, and NE in 11 sources of bakery meal is close to values previously reported, but there is some variation among sources depending on origin.

Environmental impacts of eco-nutrition swine feeding programs in spatially explicit geographic regions of the United States

This study was conducted to determine greenhouse gas (GHG) emissions, water consumption, land use, as well as nitrogen (N), phosphorus (P), and carbon (C) balance of five diet formulation strategies and feeding programs for growing-finishing pigs (25-130 kg body weight) in the three spatially explicit geographic regions where the majority of U.S. pork production occurs. Feeding programs evaluated consisted of 1) standard corn-soybean meal (CSBM) diets, 2) CSBM containing 15% corn distillers dried grains with solubles (DDGS), 3) CSBM with 8.6% thermally processed supermarket food waste (FW), 4) low crude protein CSBM diets supplemented with synthetic amino acids (SAA), and 5) CSBM with phytase enzyme (PHY) added at 600 FTU (phytase units)/kg of diet. An attributional Life Cycle Assessment approach using a highly specialized, spatially explicit Food System Supply-Chain Sustainability (FoodS3) model was used to quantify GHG emissions, water consumption, and land use of corn, soybean meal, and DDGS based on county level sourcing. The DDGS, FW, and SAA feeding programs had less estimated N and P intake and excretion than CSBM, and the PHY feeding program provided the greatest reduction in P excretion. The FW feeding program had the least overall GHG emissions (319.9 vs. 324.6 to 354.1 kg CO2 equiv./market hog), land use (331.5 vs. 346.5 to 385.2 m2/market hog), and water consumption (7.64 vs. 7.70 to 8.30 m3/market hog) among the alternatives. The DDGS feeding program had the greatest GHG emissions (354.1 kg CO2 equiv./market hog) among all programs but had less impacts on water consumption (7.70 m3) and land use (346.5 m2) per market hog than CSBM and PHY. The SAA feeding program provided a 6.5-7.4% reduction in land use impacts compared with CSBM and PHY, respectively. Regardless of feeding program, the Midwest had the least contributions to GHG emissions and land use attributed to feed and manure among regions. Water consumption per market hog associated with feeding programs was much greater in the Southwest (59.66-63.58 m3) than in the Midwest (4.45-4.88 m3) and Mid-Atlantic (1.85-2.14 m3) regions. Results show that diet composition and U.S. geographic region significantly affect GHG emissions, water consumption, and land use of pork production systems, and the potential use of thermally processed supermarket food waste at relatively low diet inclusion rates (<10%) can reduce environmental impacts compared with other common feeding strategies.

Environmental policies for the treatment of waste generated by COVID-19: Text mining review

The rapid transmission of COVID-19 has meant that all economic and human efforts have been focused on confronting it, ignoring environmental aspects whose consequences are causing adverse situations all over the planet. The saturation of the sanitary system and confinement measures have multiplied the waste generated, which implies the need to adapt environmental policies to this new situation caused by the pandemic. It is a review article whose objective was to identify the environmental policies that would facilitate an adequate treatment of the waste generated by the pandemic. It was proposed to analyse the current lines of research developed on this paradigm, applying the text mining methodology. A systematic review of 111 studies published in environmental journals indexed in the Web of Science was carried out. The results identified three areas of interest: knowledge of transmission routes, management of the massive generation of plastics and appropriate treatment of solid waste in extreme situations. Leaders are called upon to implement the contingency plans to sustainably alleviate the enormous waste burden caused by society's adaptation to the restrictions imposed by the pandemic. Specifically, innovation aimed at achieving the reuse of medical products, the promotion of the circular economy and educational campaigns to promote clean environments should be encouraged.

Triple Bottom-Line Evaluation of the Production of Animal Feed from Food Waste: A Life Cycle Assessment

This study applies a triple bottom line (TBL) framework that incorporates the environmental, economic, and social impacts of producing animal feed from food waste (FW) collected at the post-consumption stage of the food supply chain. The environmental bottom line (BL) is conducted using life cycle assessment (LCA), the economic BL is calculated using the net present value (NPV), while the social BL is assessed using the strengths, weaknesses, opportunities, and threats (SWOT) analysis. The results within the environmental BL indicate that at a 13.8% recovery rate, animal feed produced from a ton of FW saves 0.33 m² equivalent of crop land but requires 3.5 tons of water compared to 0.9 tons and 0.78 tons for landfilling and incineration for FW treatment respectively. In addition, the production of animal feed from one ton of FW emits 1064.6 kg CO₂-eq, compared to 823.6 kg CO₂-eq using landfilling and 781.9 kg CO₂-eq when incinerated. The economic BL indicates a profit of $3.65/ton from incinerating FW, compared to cost of $93.8 and $137.6 per ton for animal feed production and landfilling of FW respectively. The analytic hierarchy process (AHP) is applied to integrate the TBL scores and rank the scenarios accordingly. AHP recommends animal feed and incineration over landfilling by a fourfold higher score. A simulation using an augmented simplex lattice mixture (ASLM) design recommends incineration with energy recovery over animal feed production from FW collected at the consumer stage. Sensitivity analysis indicates that the production of animal feed from FW is environmentally feasible if the safe recovery rate exceeds 48%, is which possible for FW collected at early stages of the food supply chain.

Proof of concept for developing novel feeds for cattle from wasted food and crop biomass to enhance agri-food system efficiency

Modern agri-food systems generate large amounts of crop-based biomass that are unfit for direct human consumption but potentially suitable for livestock feeding in production of meats, milk, and eggs. This study aims to develop novel feeds for cattle from some of those biomass materials through the natural microbial-driven processes of ensiling. Fruit and vegetables resembling supermarket discards were ensiled alone or co-ensiled with corn crop residues, mushroom wastes, etc. via laboratory experiments. Longitudinal sample analyses showed that (co-)ensiling was successful, with pH and fermentation acids changing rapidly into desirable ranges (pH < 4.5, the acids 5–13% DM with lactic acid dominating). The (co-)ensiled products had key nutritional parameters comparable to those of good quality forages commonly used on dairy farms. Additionally, in vitro incubation experiments indicated that the ensiled products could substitute certain conventional feeds while maintaining diet digestibility. Findings from this pilot study provide a proof of principle that quality novel feeds for cattle can be generated by co-ensiling food discards and low-value crop residues. Future research and animal feeding trials to demonstrate the utility of this approach can help societies more effectively utilize untapped biomass resources, strengthening the regenerative capacity of agri-food systems towards a more sustainable food future.

Ideating A Sustainable Swine Feed Prototype: A Qualitative Approach in Farmers’ Pain Point Identification and Product Development

There is a growing interest and trend in new product development (NPD) from food waste. However, most qualitative approaches rarely use the lean entrepreneur concept in the context of new product development (NPD), which allows for understanding customer insight rather than the traditional qualitative approach. Therefore, this study aims to (1) explore the swine farmer behaviors, desired outcomes, and pain points in using swine feedstuffs, (2) select three representative segments and identify high-value customers of swine feeds, and (3) develop a sustainable swine feed prototype from the fermented fish industrial residues. The target users, 24 pig farmers from 11 provinces across the Northeastern Region of Thailand, were recruited to participate in this research. Qualitative in-depth semi-structured interviews and thematic analysis were conducted to analyze their behaviors, desired outcomes, and pain points towards pig feed usages. The framework was combined with in-depth qualitative interviews and the customer, problem, and solution zoom tools. The results revealed that household farmers were the target customer segment of swine feed made from fermented fish industrial wastes. In addition, the findings showed that the household farmers typically fed their pigs with instant feeds and alternative feeds. Moreover, their desired outcomes were the pellet feed with nutrients. Furthermore, the pain points of the household farmers were the expensive cost of feeds and mold in feeds. Therefore, this segment needs to minimize the cost of feeds by using other sustainable alternatives.

Animal board invited review: Animal source foods in healthy, sustainable, and ethical diets - An argument against drastic limitation of livestock in the food system

Animal source foods are evolutionarily appropriate foods for humans. It is therefore remarkable that they are now presented by some as unhealthy, unsustainable, and unethical, particularly in the urban West. The benefits of consuming them are nonetheless substantial, as they offer a wide spectrum of nutrients that are needed for cell and tissue development, function, and survival. They play a role in proper physical and cognitive development of infants, children, and adolescents, and help promote maintenance of physical function with ageing. While high-red meat consumption in the West is associated with several forms of chronic disease, these associations remain uncertain in other cultural contexts or when consumption is part of wholesome diets. Besides health concerns, there is also widespread anxiety about the environmental impacts of animal source foods. Although several production methods are detrimental (intensive cropping for feed, overgrazing, deforestation, water pollution, etc.) and require substantial mitigation, damaging impacts are not intrinsic to animal husbandry. When well-managed, livestock farming contributes to ecosystem management and soil health, while delivering high-quality foodstuffs through the upcycling of resources that are otherwise non-suitable for food production, making use of marginal land and inedible materials (forage, by-products, etc.), integrating livestock and crop farming where possible has the potential to benefit plant food production through enhanced nutrient recycling, while minimising external input needs such as fertilisers and pesticides. Moreover, the impacts on land use, water wastage, and greenhouse gas emissions are highly contextual, and their estimation is often erroneous due to a reductionist use of metrics. Similarly, whether animal husbandry is ethical or not depends on practical specificities, not on the fact that animals are involved. Such discussions also need to factor in that animal husbandry plays an important role in culture, societal well-being, food security, and the provision of livelihoods. We seize this opportunity to argue for less preconceived assumptions about alleged effects of animal source foods on the health of the planet and the humans and animals involved, for less top-down planning based on isolated metrics or (Western) technocratic perspectives, and for more holistic and circumstantial approaches to the food system.

Exploring the prospects of the fifth quarter in the 21st century

A variable proportion of slaughtered livestock, generally referred to as the fifth quarter, is not part of the edible dressed meat and regarded as animal byproduct. In order for the fifth quarter to play a significant role in the current effort toward a circular bio-based economy, it has to successfully support food security, social inclusivity, environmental sustainability, and a viable economy. The high volume of these low-value streams and their nutrient-dense nature can facilitate their position as a very important candidate to explore within the context of a circular bio-based economy to achieve some of the United Nations Sustainable Development Goals (UN-SDGs). While these sources have been traditionally used for various applications across different cultures and industries, it seems evident that their full potential has not yet been exploited, leaving these products more like an environmental burden rather than valuable resources. With innovation and well-targeted interdisciplinary collaborations, the potential of the fifth quarter can be fully realized. The present review intends to explore these low-value streams, their current utilization, and their potential to tackle the global challenges of increasing protein demands while preventing environmental degradation. Factors that limit widespread applications of the fifth quarter across industries and cultures will also be discussed.

Food Waste to Livestock Feed: Prospects and Challenges for Swine Farming in Peri-urban Sri Lanka

Using farm animals for their natural capability of "recycling" food waste (FW) that is unfit for direct human consumption can support a circular economy as shown in the case of Sri Lanka's Western Province. The reuse of organic residues including FW as animal feed is a traditional agricultural practice in Sri Lanka but is less studied within an urban FW context. A survey of piggeries using FW in and around the rapidly urbanizing city of Colombo showed that FW is a major feed source in the farms accounting for on average 82% of total feed. About 40% of the farms collected the FW mainly from hotels, restaurants, and institutional canteens. Urban FW is supplied to farmers free of charge when collected directly from the sources, although 26% of the farmers collected FW via intermediaries against a fee. As FW is collected daily, the restaurants appreciate the reliable service, the farmers the low-cost feed, and the municipality the reduced FW volumes to be collected. However, this triple-win situation encounters challenges such as (tourist related) seasonal low supply, which was exacerbated under the Covid-19 lockdown of food services. Another area of concern refers to biosafety. Although the large majority of interviewed farmers boil FW which contains raw meat or fish, there is a paucity of related guidelines and control. Given the benefits of FW use, it is worthwhile to explore how far these informal partnerships could be scaled without increasing transport costs for farmers, while introducing biosafety monitoring. For now, the regulatory environment is highly siloed and does not support material transitions across sector boundaries towards a circular economy.

Can we effectively manage parasites, prions, and pathogens in the global feed industry to achieve One Health?

Prions and certain endoparasites, bacteria, and viruses are internationally recognized as types of disease-causing biological agents that can be transmitted from contaminated feed to animals. Historically, foodborne biological hazards such as prions (transmissible spongiform encephalopathy), endoparasites (Trichinella spiralis, Toxoplasma gondii), and pathogenic bacteria (Salmonella spp., Listeria monocytogenes, Escherichia coli O157, Clostridium spp., and Campylobacter spp.) were major food safety concerns from feeding uncooked or improperly heated animal-derived food waste and by-products. However, implementation of validated thermal processing conditions along with verifiable quality control procedures has been effective in enabling safe use of these feed materials in animal diets. More recently, the occurrence of global Porcine Epidemic Diarrhea Virus and African Swine Fever Virus epidemics, dependence on international feed ingredient supply chains, and the discovery that these viruses can survive in some feed ingredient matrices under environmental conditions of trans-oceanic shipments has created an urgent need to develop and implement rigorous biosecurity protocols that prevent and control animal viruses in feed ingredients. Implementation of verifiable risk-based preventive controls, traceability systems from origin to destination, and effective mitigation procedures is essential to minimize these food security, safety, and sustainability threats. Creating a new biosafety and biosecurity framework will enable convergence of the diverging One Health components involving low environmental impact and functional feed ingredients that are perceived as having elevated biosafety risks when used in animal feeds.

New perspectives for evaluating relative risks of African swine fever virus contamination in global feed ingredient supply chains

There are no published reports indicating that the African swine fever virus (ASFV) has been detected in feed ingredients or complete feed. This is primarily because there are only a few laboratories in the world that have the biosecurity and analytical capabilities of detecting ASFV in feed. Several in vitro studies have been conducted to evaluate ASFV concentration, viability and inactivation when ASFV was added to various feed ingredients and complete feed. These inoculation studies have shown that some feed matrices support virus survival longer than others and the reasons for this are unknown. Current analytical methodologies have significant limitations in sensitivity, repeatability, ability to detect viable virus particles and association with infectivity. As a result, interpretation of findings using various measures may lead to misleading conclusions. Because of analytical and technical challenges, as well as the lack of ASFV contamination data in feed supply chains, quantitative risk assessments have not been conducted. A few qualitative risk assessments have been conducted, but they have not considered differences in potential scenarios for ASFV contamination between various types of feed ingredient supply chains. Therefore, the purpose of this review is to provide a more holistic understanding of the relative potential risks of ASFV contamination in various global feed ingredient supply chains and provide recommendations for addressing the challenges identified.

Developing a Methodology for Aggregated Assessment of the Economic Sustainability of Pig Farms

The economic sustainability of agricultural production is a crucial concern for most farmers, especially for pig producers who face dynamic changes in the market. Approaches for economic sustainability assessment found in the literature are mainly focused on the short-term economic viability of the farm and rarely take a long-term perspective. In this paper, we propose and test a new, innovative assessment and aggregation method, which brings about a broader view on more long-term aspects of economic sustainability. This wider view on economic sustainability, in addition to classical concepts such as technical efficiency, labor productivity, and farm profitability, incorporates the assessment of the levels of entrepreneurship, risk management, and the resilience of the invested resources. All indicators were scaled and aggregated using scaling and weighting procedures proposed by experts into subthemes and themes. The methodology was tested on a sample of 131 pig farms located in 6 EU countries: Germany, Italy, the Netherlands, Poland, Finland, and Austria. We hypothesized that closed-cycle farms might be economically more sustainable than those farms that are specialized in pig breeding or finishing. The results showed that closed-cycle farms do indeed have advantages in terms of raising healthy animals and having slightly better overall resilience of resources, however specialized breeding and finishing farms appeared to be more sustainable in the areas of profitability, risk management, and reproductive efficiency. Our approach supports evidence-based economic sustainability assessments of pig farms and provides a tool that can be used for economic sustainability improvement strategies for farms.