Molecular characterization and biofilm-formation analysis of Listeria monocytogenes, Salmonella spp., and Escherichia coli isolated from Brazilian swine slaughterhouses

This study aimed to verify the presence of Listeria monocytogenes, Salmonella spp., and Escherichia coli in two Brazilian swine slaughterhouses, as well as to perform antibiograms, detect virulence and antimicrobial resistance genes, and evaluate the in vitro biofilm-forming capability of bacterial isolates from these environments. One Salmonella Typhi isolate and 21 E. coli isolates were detected, while L. monocytogenes was not detected. S. Typhi was isolated from the carcass cooling chamber’s floor, resistant to several antimicrobials, including nalidixic acid, cefazolin, chloramphenicol, doxycycline, streptomycin, gentamicin, tetracycline, and sulfonamide, and contained resistance genes, such as tet(B), tet(C), tet(M), and ampC. It also showed moderate biofilm-forming capacity at 37°C after incubating for 72 h. The prevalence of the 21 E. coli isolates was also the highest on the carcass cooling chamber floor (three of the four samplings [75%]). The E. coli isolates were resistant to 12 of the 13 tested antimicrobials, and none showed sensitivity to chloramphenicol, an antimicrobial prohibited in animal feed since 2003 in Brazil. The resistance genes MCR-1, MCR-3, sul1, ampC, clmA, cat1, tet(A), tet(B), and blaSHV, as well as the virulence genes stx-1, hlyA, eae, tir α, tir β, tir γ, and saa were detected in the E. coli isolates. Moreover, 5 (23.8%) and 15 (71.4%) E. coli isolates presented strong and moderate biofilm-forming capacity, respectively. In general, the biofilm-forming capacity increased after incubating for 72 h at 10°C. The biofilm-forming capacity was the lowest after incubating for 24 h at 37°C. Due to the presence of resistance and virulence genes, multi-antimicrobial resistance, and biofilm-forming capacity, the results of this study suggest a risk to the public health as these pathogens are associated with foodborne diseases, which emphasizes the hazard of resistance gene propagation in the environment.

Improving the organoleptic and structural-chemical properties of semi-smoked sausages

The decline of meat resources and the rapid growth of the world's population creates a need for resource management. The purpose of the study was to test the original technology of the semi-smoked sausages production adding goji berries at different concentrations, and to assess the technological risks in the production of sausages. 400 pieces of semi-finished sausages were divided into 4 groups, 100 pieces each. The sausages for the first control group were made according to the “Krakowska” recipe. The remaining three groups were experimental, with the addition of goji berry at different concentrations (30, 50 and 70 g per 100 kg of meat). The prepared samples were analysed for the content of particulate matter and water using hydrological methods. All experimental samples were recorded with a decrease in water activity by 1.2 times compared with the control (p ≤ 0.05 between the 1st and 4th groups). A new technology for the production of semi-smoked sausage adding goji berries powder at a concentration of 0.3, 0.5, and 0.7% to meat is proposed and tested. The addition of goji berries provides solidity to the sausage samples, as well as better organoleptic and structural-chemical properties compared to the control.

Proteomic Advances in Milk and Dairy Products

Proteomics is a new area of study that in recent decades has provided great advances in the field of medicine. However, its enormous potential for the study of proteomes makes it also applicable to other areas of science. Milk is a highly heterogeneous and complex fluid, where there are numerous genetic variants and isoforms with post-translational modifications (PTMs). Due to the vast number of proteins and peptides existing in its matrix, proteomics is presented as a powerful tool for the characterization of milk samples and their products. The technology developed to date for the separation and characterization of the milk proteome, such as two-dimensional gel electrophoresis (2DE) technology and especially mass spectrometry (MS) have allowed an exhaustive characterization of the proteins and peptides present in milk and dairy products with enormous applications in the industry for the control of fundamental parameters, such as microbiological safety, the guarantee of authenticity, or the control of the transformations carried out, aimed to increase the quality of the final product.

Combined impact of high-pressure processing and slightly acidic electrolysed water on Listeria monocytogenes proteomes

Slightly acidic electrolysed water (SAEW) and high-pressure processing (HPP) are well-established non-thermal preservation technologies. This study investigated the deactivation mechanisms of Listeria monocytogenes by label-free quantitative proteomics analysis. Samples were treated through HPP (300 MPa for 3 min), SAEW (20 ppm available chlorine concentration), and their combinations. The KEGG pathway analysis found SAEW + HPP induced differentially expressed proteins (DEPs) associated to biofunctions of ribosomes, secondary metabolite biosynthesis, microbial metabolism in diverse environments, carbon metabolism, and biosynthesis of amino acid and aminoacyl-transfer RNA. The results showed these non-thermal treatments were able to induce the shifting of ribosome biogenesis to initiate translation in L. monocytogenes. During protein translation, the initiation stage was upregulated. However, subsequent elongation, termination, and recycling of used ribosomes were retarded. Comparing various treatments, the combination of hurdles showed greater deactivation of L. monocytogenes than any single one. The approaches developed in this study provided crucial information for minimally processing in the food industries on the application of foodborne listeriosis prevention.

Microbial Biofilms in the Food Industry-A Comprehensive Review

Biofilms, present as microorganisms and surviving on surfaces, can increase food cross-contamination, leading to changes in the food industry’s cleaning and disinfection dynamics. Biofilm is an association of microorganisms that is irreversibly linked with a surface, contained in an extracellular polymeric substance matrix, which poses a formidable challenge for food industries. To avoid biofilms from forming, and to eliminate them from reversible attachment and irreversible stages, where attached microorganisms improve surface adhesion, a strong disinfectant is required to eliminate bacterial attachments. This review paper tackles biofilm problems from all perspectives, including biofilm-forming pathogens in the food industry, disinfectant resistance of biofilm, and identification methods. As biofilms are largely responsible for food spoilage and outbreaks, they are also considered responsible for damage to food processing equipment. Hence the need to gain good knowledge about all of the factors favouring their development or growth, such as the attachment surface, food matrix components, environmental conditions, the bacterial cells involved, and electrostatic charging of surfaces. Overall, this review study shows the real threat of biofilms in the food industry due to the resistance of disinfectants and the mechanisms developed for their survival, including the intercellular signalling system, the cyclic nucleotide second messenger, and biofilm-associated proteins.

Application of Enterococcus faecium KE82, an Enterocin A-B-P-Producing Strain, as an Adjunct Culture Enhances Inactivation of Listeria monocytogenes during Traditional Protected Designation of Origin Galotyri Processing

ABSTRACT

The ability of the enterocin A-B-P-producing Enterococcus faecium KE82 adjunct strain to inactivate Listeria monocytogenes during protected designation of origin Galotyri processing was evaluated. Three trials were conducted with artisan cheeses made from traditionally "boiled" (85°C) ewe's milk. The milk was cooled at 42°C and divided in two treatments. A1 milk was inoculated with Streptococcus thermophilus ST1 and Lactococcus lactis subsp. cremoris M78, and A2 was inoculated with the basic starter ST1+M78 plus KE82 (step 1). All milks were fermented at 20 to 22°C for 24 h (step 2), and the curds were drained at 12°C for 72 h (step 3) and then salted with 1.5 to 1.8% salt to obtain the fresh Galotyri cheeses (step 4). These fresh cheeses were then ripened at 4°C for 30 days (step 5). Because artificial listerial contamination in the dairy plant was prohibited, samples of A1 and A2 cheese milk (200 mL) or curd (200 g) were collected after steps 1 through 5, inoculated with L. monocytogenes 10 (3 to 4 log CFU/mL or g), incubated at 37, 22, 12, and 4°C for predefined periods, and analyzed for microbial levels and pH. L. monocytogenes levels declined in all cheese curd portions contaminated after steps 2 through 5 (pH 4.36 to 4.84) when stored at 4 or 12°C for 15 days. The final net reductions in Listeria populations were 2.00-, 1.07-, 0.54-, and 0.61-log greater in the A2 than in the A1 curd portions after steps 2, 3, 4, and 5, respectively. In step 1, conducted to simulate the whole cheese milk fermentation process, L. monocytogenes levels declined by 1.47 log CFU/mL more in the A2 than in the A1 milk portions after 72 h at 22°C; however, slight growth (0.6 log CFU/mL) occurred during the first 6 h at 37°C. E. faecium KE82 was compatible with the starter culture and enhanced inactivation of L. monocytogenes during all steps of Galotyri cheese processing. The antilisterial effects of the combined acid and enterocin were the weakest in the fermenting milks, the strongest in the unsalted fermented curds, and declined again in the salted fresh cheeses.

HIGHLIGHTS

Cell Growth Density and Nisin A Activity of the Indigenous Lactococcus lactis subsp. cremoris M78 Costarter Depend Strongly on Inoculation Levels of a Commercial Streptococcus thermophilus Starter in Milk: Practical Aspects for Traditional Greek Cheese Processors

ABSTRACT

Mixed thermophilic and mesophilic commercial starter cultures (CSCs), particularly those including Streptococcus thermophilus as a primary milk acidifier, have been found to reduce growth and counteract in situ nisin A (NisA+) antilisterial effects by the novel, indigenous Lactococcus lactis subsp. cremoris M78 costarter in traditional Graviera thermized milk cheese curds. Therefore, this model challenge study evaluated growth and in situ NisA+ activity of strain M78 in coculture with S. thermophilus ST1 singly in sterilized raw milk (SRM). Strain ST1, derived from a CSC for cheese, was challenged at two inoculation levels (5 and 7 log CFU/mL) in SRM against 6 and 3 log CFU/mL of strain M78 and Listeria monocytogenes, respectively. Pure cultures of each strain and cocultures of strain ST1 with the CSC L. lactis LL2, in replacement of strain M78, served as controls. At the high (7-log) inoculation level, the rapid, competitive growth (>9.3 log CFU/mL) of S. thermophilus ST1 reduced growth of both L. lactis by at least 10-fold; the industrial strain LL2 retained slightly higher relative population densities (7.4 to 9.1%) than the wild NisA+ strain M78 (3.8 to 5.6%) after 6 h at 37°C, followed by an additional 66 h of incubation at 22°C. In full contrast, at the low (5-log) inoculation level, S. thermophilus ST1 failed to predominate in SRM at 6 h; thus, the starter lactic acid bacteria populations were reversed in favor of L. lactis. Notably, strain M78 retained higher relative population densities (83.0 to 90.1%) than the CSC strain LL2 (80.3 to 85.2%) at 22°C. Moreover, at the 5-log ST1 level, the direct and deferred in situ NisA+ activities of strain M78 were at similar levels with its pure culture with L. monocytogenes in SRM, whereas at the 7-log ST1 level, the respective NisA+ effects were counteracted. Hence, 10- to 100-fold lowered inoculation levels of CSC S. thermophilus are required to enhance the performance of the M78 costarter in traditional Greek cheese technologies.

HIGHLIGHTS

Prevalence, Pathogenicity, Virulence, Antibiotic Resistance, and Phylogenetic Analysis of Biofilm-Producing Listeria monocytogenes Isolated from Different Ecological Niches in Egypt: Food, Humans, Animals, and Environment

Serious outbreaks of foodborne disease have been caused by Listeria monocytogenes found in retail delicatessens and the severity of disease is significant, with high hospitalization and mortality rates. Little is understood about the formidable public health threat of L. monocytogenes in all four niches, humans, animals, food, and environment, in Egypt. This study analyzed the presence of L. monocytogenes collected from the four environmental niches and bioinformatics analysis was implemented to analyze and compare the data. PCR was used to detect virulence genes encoded by pathogenicity island (LIPI-1). prfA amino acid substation that causes constitutive expression of virulence was common in 77.7% of isolates. BLAST analysis did not match other isolates in the NCBI database, suggesting this may be a characteristic of the region associated with these isolates. A second group included the NH1 isolate originating in China, and BLAST analysis showed this prfA allele was shared with isolates from other global locations, such as Europe and North America. Identification of possible links and transmission pathways between the four niches helps to decrease the risk of disease in humans, to take more specific control measures in the context of disease prevention, to limit economic losses associated with food recalls, and highlights the need for treatment options.

Prevalence, Genotypic Characteristics and Antibiotic Resistance of Listeria monocytogenes From Retail Foods in Bulk in Zhejiang Province, China

Listeria monocytogenes is an important foodborne pathogen causing public concern. A total of 3354 retail foods in bulk were sampled and screened for L. monocytogenes. Seventy-three (2.2%) samples including 21 ready-to-eat (RTE) foods and 52 raw foods were confirmed positive for L. monocytogenes. Sushi and salmon sashimi occupied the top two slots in RTE foods with relatively high presence rate of 12.9 and 6.9%, respectively. Meanwhile, L. monocytogenes was found to be distributed unequally in raw foods; the presence rates in raw meat (3.5%) and poultry (3.8%) were significantly higher than that in raw seafood (1.3%). Notably, L. monocytogenes was not detected in raw freshwater food. The L. monocytogenes isolates belonged to four serotypes, 1/2a, 1/2b, 1/2c, and 4b, with the most prevalent serotype being 1/2a (47.9%). Eighteen sequence types (STs) and eighteen virulence types (VTs) containing four newly assigned VTs (VT180, VT181, VT182, and VT183) were determined via multilocus sequence typing (MLST) and multi-virulence-locus sequence typing (MVLST). Among the 73 L. monocytogenes isolates, 23 (31.5%) belonged to epidemic clones (ECs) including ECI, ECIV, ECV, ECVI, ECVIII and ECXI among which ECV was predominant. Antibiotic susceptibility tests revealed a high resistance rate (11.0%) to tetracycline. Moreover, we identified the distribution patterns of virulence genes of four Listeria pathogenicity islands (LIPI) in L. monocytogenes isolates. prfA, hly, plcA, plcB, mpl, actA genes in LIPI-1 and inlA, inlB, inlC, inlJ genes in LIPI-2 were detected in approximately all L. monocytogenes isolates. The distribution of both LIPI-3 genes and LIPI-4 genes exhibited association with lineage and ST. LIPI-4 genes were present exclusively in ST87 isolates. Relatedness analysis revealed the absence of distinct association between STs, ECs, LIPI-3 and LIPI-4 distribution and specific food groups. This study provided fundamental data for Chinese food safety authorities to grasp the contamination status of L. monocytogenes in foods, assess the potential risk of this pathogen and further address the safety issue of retail foods in bulk in China.

Implicated Food Products for Listeriosis and Changes in Serovars of Listeria monocytogenes Affecting Humans in Recent Decades

Listeriosis is a foodborne disease with a high fatality rate, and infection is mostly transmitted through ready-to-eat (RTE) foods contaminated with Listeria monocytogenes, such as gravad/smoked fish, soft cheeses, and sliced processed delicatessen (deli) meat. Food products/dishes stored in vacuum or in modified atmospheres and with extended refrigerator shelf lives provide an opportunity for L. monocytogenes to multiply to large numbers toward the end of the shelf life. Elderly, pregnant women, neonates, and immunocompromised individuals are particularly susceptible to L. monocytogenes. Listeriosis in humans manifests primarily as septicemia, meningitis, encephalitis, gastrointestinal infection, and abortion. In the mid 1990s and early 2000s a shift from L. monocytogenes serovar 4b to serovar 1/2a causing human listeriosis occurred, and serovar 1/2a is becoming more frequently linked to outbreaks of listeriosis, particularly in Europe and Northern America. Consumer lifestyle has changed, and less time is available for food preparation. Modern lifestyle has markedly changed eating habits worldwide, with a consequent increased demand for RTE foods; therefore, more RTE and take away foods are consumed. There is a concern that many Listeria outbreaks are reported from hospitals. Therefore, it is vitally important that foods (especially cooked and chilled) delivered to hospitals and residential homes for senior citizens and elderly people are reheated to at least 72°C: cold food, such as turkey deli meat and cold-smoked and gravad salmon should be free from L. monocytogenes. Several countries have zero tolerance for RTE foods that support the growth of Listeria.

Hurdle factors minimizing growth of Listeria monocytogenes while counteracting in situ antilisterial effects of a novel nisin A-producing Lactococcus lactis subsp. cremoris costarter in thermized cheese milks

The capacity of growth, survival, and adaptive responses of an artificial contamination of a three-strain L. monocytogenes cocktail in factory-scale thermized (65 °C, 30 s) Graviera cheese milk (TGCM) was evaluated. Bulk TGCM samples for inoculation were sequentially taken from the cheese making vat before process initiation (CN-LM) and after addition of a commercial starter culture (CSC), the CSC plus the nisin A-producing (NisA+) costarter strain Lactococcus lactis subsp. cremoris M78 (CSC + M78), and all ingredients with the rennet last (CSC + M78-RT). Additional treatments included Listeria-inoculated TGCM samples coinoculated with the NisA+ costarter strain M78 in the absence of the CSC or with the CSC in previously sterilized TGCM to inactivate the background microbiota (CSC-SM). All cultures were incubated at 37 to 42 °C for 6 h, followed by additional 66 h at 22 °C, and 48 h at 12 °C after addition of 2% edible salt. L. monocytogenes failed to grow and declined in all CSC-inoculated treatments after 24 h. In contrast, the pathogen increased by 3.34 and 1.46 log units in the CN-LM and the CSC-SM treatments, respectively, indicating that the background microbiota or the CSC alone failed to suppress it, but they did so synergistically. Supplementation of the CSC with the NisA+ strain M78 did not deliver additional antilisterial effects, because the CSC Streptococcus thermophilus reduced the growth prevalence rates and counteracted the in situ NisA+ activity of the costarter. In the absence of the CSC, however, strain M78 predominated and caused the strongest in situ nisin-A mediated effects, which resulted in the highest listerial inactivation rates after 24 to 72 h at 22 °C. In all TGCM treatments, however, L. monocytogenes displayed a "tailing" survival (1.63 to 1.96 log CFU/mL), confirming that this pathogen is exceptionally tolerant to cheese-related stresses, and thus, can't be easily eliminated.

Foodborne pathogens

Foodborne pathogens are causing a great number of diseases with significant effects on human health and economy. The characteristics of the most common pathogenic bacteria (Bacillus cereus, Campylobacter jejuni, Clostridium botulinum, Clostridium perfringens, Cronobacter sakazakii, Esherichia coli, Listeria monocytogenes, Salmonella spp., Shigella spp., Staphylococccus aureus, Vibrio spp. and Yersinia enterocolitica), viruses (Hepatitis A and Noroviruses) and parasites (Cyclospora cayetanensis, Toxoplasma gondii and Trichinella spiralis), together with some important outbreaks, are reviewed. Food safety management systems based on to classical hazard-based approach has been proved to be inefficient, and risk-based food safety approach is now suggested from leading researchers and organizations. In this context, a food safety management system should be designed in a way to estimate the risks to human health from food consumption and to identify, select and implement mitigation strategies in order to control and reduce these risks. In addition, the application of suitable food safety education programs for all involved people in the production and consumption of foods is suggested.