Comparison of aqueous chemical treatments to eliminate Salmonella on alfalfa seeds

Efficacy of Repeated Applications of Bacteriophages on Salmonella enterica-Infected Alfalfa Sprouts during Germination

Nontyphoidal Salmonella enterica is one of the leading pathogens for foodborne outbreaks in a multitude of food commodities, including alfalfa sprouts, which are commonly consumed raw. The food industry has commonly used chlorinated washes, but such methods may not be perceived as natural; this can be a detriment as a large portion of sprouts are designated for the organic market. A natural and affordable antimicrobial method that has been acquiring popularity is the use of bacteriophages. This study compared the efficacy of repeated daily applications and a single application of two separate bacteriophage cocktails (SE14, SE20, SF6 and SE14, SF5, SF6) against four Salmonella enterica (S. enterica) strains on germinating alfalfa sprout seeds from days 0 to 7. The results show S. Enteritidis to be the most susceptible to both cocktails with ~2.5 log CFU/mL decrease on day 0 with cocktail SE14, SF5, and SF6. S. enterica populations on all strains continued to grow even with repeated daily bacteriophage applications but in a significantly decreased rate (p < 0.05) compared with a single bacteriophage application. The extent of the reduction was dependent on the S. enterica strain, but the results do show benefits to using repeated bacteriophage applications during sprout germination to reduce S. enterica populations compared with a single bacteriophage application.

Synergistic Effects of Lauric Arginate and Peracetic Acid in Reducing Listeria monocytogenes on Fresh Apples

Apples are naturally coated with a water-repelling hydrophobic wax layer, which may limit the antimicrobial efficacies of surface sanitizer solutions. Lauric arginate (LAE) is a cationic surfactant with antimicrobial efficacy against Listeria monocytogenes. In this study, we investigated the antimicrobial and the wettability effects of LAE in enhancing anti-L. monocytogenes efficacy of peracetic acid (PAA) and further verified the optimized treatment combinations in a pilot spray-bar brush bed system. Apples after 48 h of inoculation were treated with PAA surface sanitation in combination with different concentrations of LAE at 22 or 46°C. The effectiveness of PAA with LAE solutions in decontaminating L. monocytogenes significantly increased with the increased concentration of PAA (60-80 ppm) or LAE (0.01-0.05%) or the treatment temperature (from 22 to 46°C). A 30-120-sec wash by 80 ppm PAA with 0.01 and 0.05% LAE at 22°C reduced L. monocytogenes on apples by 2.10-2.25 and 2.48-2.58 log10 CFU/apple, respectively. Including LAE in the PAA solution decreased contact angles on apple surfaces. However, the increased wettability of the sanitizer solution may not be the main contributor to the enhanced antimicrobial efficacy of the PAA solution, given that the addition of Tween 80 or Tween 85 only slightly boosted the anti-L. monocytogenes efficacy of PAA solutions though both increased the wettability of the PAA solutions. The synergistic effects of PAA and LAE were further validated in a pilot spray-bar brush bed packing system, where a 30-sec spray wash with 80 ppm PAA and 0.05% LAE at 22 and 46°C caused 1.68 and 2.08 log reduction of Listeria on fresh apples, respectively. This study provides an improved PAA process/preventive strategy for ensuring microbial food safety of fresh apples that is applicable to commercial apple packing lines.

Bacteriological safety of sprouts: A brief review

The germination process causes changes in the chemical composition of seeds that improves the nutritional value of sprouts, while decreasing their microbiological safety, since the germination conditions are ideal for bacterial growth as well. This review explores the bacteriological safety of sprouts and their involvement in foodborne illness outbreaks, worldwide. Additionally, approaches to improve the shelf-life and microbiological safety of sprouts are discussed. According to the literature, sprout consumption is associated with more than 60 outbreaks of foodborne illness worldwide, since 1988. Alfalfa sprouts were most commonly involved in outbreaks and the most commonly implicated pathogens were Salmonella and pathogenic Escherichia coli (especially, Shiga toxin producing E. coli). In the pre-harvest stage, the implementation of good agricultural practices is an important tool for producing high-quality seeds. In the post-harvest stage, several methods of seed decontamination are used commercially, or have been investigated by researchers. After germination, seedlings should be kept under refrigeration and, if possible, cooked before consumption. Finally, microbiological analyses should be performed at all stages to monitor the hygiene of the sprout production process.

Reduction in pathogenic load of wheat by tempering with saline organic acid solutions at different seasonal temperatures

As a raw agricultural commodity, wheat is exposed to microbial contamination; therefore, enteric pathogens may be among its microbiota creating a food safety risk in milled products. This research evaluates (1) the effectiveness of organic acids dissolved in saline solutions to reduce the counts of pathogenic microorganisms in soft and hard wheat, and also investigates the effect of seasonal temperature on (2) survivability of pathogens in wheat kernels and on (3) pathogen inactivation during tempering with saline organic acid solutions. Wheat samples were inoculated with cocktails of either 5 serovars of Salmonella enterica, 5 E. coli O157:H7 or 6 non-O157 Shiga toxin-producing E. coli (STEC) strains to achieve a concentration of ~7 log CFU/g. Inoculated samples were allowed to stand for 7-days at temperatures (2.0, 10.8, 24.2, 32 °C) corresponding to those experienced during winter, spring/fall, and summer (average and maximum) in the main wheat growing regions in the state of Nebraska, USA. Besides water, solutions containing acid (acetic or lactic 2.5% or 5.0% v/v) and NaCl (~26% w/v) were used for tempering the wheat to 15.0% (soft) and 15.5% (hard) moisture at the different seasonal temperatures. The survival of pathogenic microorganisms throughout the resting period, and before and after tempering was analyzed by plating samples on injury-recovery media. The survival rate of pathogenic microorganisms on wheat kernels was higher at temperatures experienced during the winter (2.0 °C) and spring/fall (10.8 °C) months. Regardless of tempering temperature, the initial pathogen load was reduced significantly by all solutions when compared to the control tempered with water (P ≤ .05). The combination of lactic acid (5.0%) and NaCl was the most effective treatment against Salmonella enterica, E. coli O157:H7 and non-O157 STEC, with average reduction values of 1.8, 1.8 and 1.6 log CFU/g for soft wheat and 2.6, 2.4 and 2.4 log CFU/g for hard wheat, respectively. Implementation of organic acids and NaCl in tempering water may have the potential to reduce the risk of pathogen contamination in milled products.

Effects of Lactobacillus plantarum, Pediococcus acidilactici, and Pediococcus pentosaceus on the Growth of Listeria monocytogenes and Salmonella on Alfalfa Sprouts

The germination conditions of sprouted vegetables consisting of relatively high temperatures and humidity, low light, and abundance of nutrients are ideal for pathogen survival and growth. The continual occurrence of outbreaks and recalls associated with sprout vegetables indicate additional measures are needed to improve product safety. The objective of this study was to evaluate the efficacy of a mixture of Lactobacillus plantarum, Pediococcus acidilactici, and Pediococcus pentosaceus (LPP) against Listeria monocytogenes and Salmonella on alfalfa sprouts during 5 days of sprouting at 20°C and its influence on sprout quality. Alfalfa seeds were inoculated with L. monocytogenes or Salmonella (each at 1 and 3 log CFU/g) and LPP (7 log CFU/g). Populations of LPP were maintained at 7.5 to 8.0 log CFU/g throughout sprouting. LPP had a significant effect on the growth of L. monocytogenes and Salmonella ( P < 0.05). After 5 days of sprouting, populations of L. monocytogenes at an initial concentration of 1 and 3 log CFU/g of seeds treated with LPP were approximately 4.5 and 1.0 log CFU/g less than the untreated seeds, respectively. Populations of Salmonella at an initial concentration of 1 and 3 log CFU/g were 1.0 log CFU/g less than the control. LPP did not compromise the yield, seedling length, or pH of the sprouts.

Outbreaks caused by sprouts, United States, 1998-2010: lessons learned and solutions needed

After a series of outbreaks associated with sprouts in the mid-1990s, the U.S. Food and Drug Administration (FDA) published guidelines in 1999 for sprouts producers to reduce the risk of contamination. The recommendations included treating seeds with an antimicrobial agent such as calcium hypochlorite solution and testing spent irrigation water for pathogens. From 1998 through 2010, 33 outbreaks from seed and bean sprouts were documented in the United States, affecting 1330 reported persons. Twenty-eight outbreaks were caused by Salmonella, four by Shiga toxin-producing Escherichia coli, and one by Listeria. In 15 of the 18 outbreaks with information available, growers had not followed key FDA guidelines. In three outbreaks, however, the implicated sprouts were produced by firms that appeared to have implemented key FDA guidelines. Although seed chlorination, if consistently applied, reduces pathogen burden on sprouts, it does not eliminate the risk of human infection. Further seed and sprouts disinfection technologies, some recently developed, will be needed to enhance sprouts safety and reduce human disease. Improved seed production practices could also decrease pathogen burden but, because seeds are a globally distributed commodity, will require international cooperation.

Response of Medicago truncatula seedlings to colonization by Salmonella enterica and Escherichia coli O157:H7

Disease outbreaks due to the consumption of legume seedlings contaminated with human enteric bacterial pathogens like Escherichia coli O157:H7 and Salmonella enterica are reported every year. Besides contaminations occurring during food processing, pathogens present on the surface or interior of plant tissues are also responsible for such outbreaks. In the present study, surface and internal colonization of Medicago truncatula, a close relative of alfalfa, by Salmonella enterica and Escherichia coli O157:H7 were observed even with inoculum levels as low as two bacteria per plant. Furthermore, expression analyses revealed that approximately 30% of Medicago truncatula genes were commonly regulated in response to both of these enteric pathogens. This study highlights that very low inoculum doses trigger responses from the host plant and that both of these human enteric pathogens may in part use similar mechanisms to colonize legume seedlings.

Maize seed coatings and seedling sprayings with chitosan and hydrogen peroxide: their influence on some phenological and biochemical behaviors

OBJECTIVE

To evaluate the effect of chitosan (CH) and hydrogen peroxide (H(2)O(2)) seed coatings and seedling sprinklings on two different maize varieties by measuring their phenology, the H(2)O(2) presence, the catalase (CAT) activity, and the protein quantity.

METHODS

Seven groups of ten seeds for each maize variety were treated with CH (2% (20 g/L) and 0.2% (2 g/L)) or H(2)O(2) (8 mmol/L) by coating, sprinkling, or both. Germination and seedling growth were measured. One month after germination, the presence of H(2)O(2) in seedlings in the coated seed treatments was evaluated. Protein content and CAT activity were determined under all treatments.

RESULTS

H(2)O(2) seed coating enhanced the germination rate and increased seedling and stem length in the quality protein maize (QPM) variety. Seedlings had a higher emergence velocity under this treatment in both varieties. CH and H(2)O(2) sprinklings did not have an effect on seedling phenology. Exogenous application of H(2)O(2) promoted an increase of endogenous H(2)O(2). CH and H(2)O(2) seedling sprinkling increased the protein content in both maize varieties, while there was no significant effect on the CAT activity of treated seeds and seedlings.

CONCLUSIONS

CH and H(2)O(2) enhance some phenological and biochemical features of maize depending on their method of application.

From Exit to Entry: Long-term Survival and Transmission of Salmonella

Salmonella spp. are a leading cause of human infectious disease worldwide and pose a serious health concern. While we have an improving understanding of pathogenesis and the host-pathogen interactions underlying the infection process, comparatively little is known about the survival of pathogenic Salmonella outside their hosts. This review focuses on three areas: (1) in vitro evidence that Salmonella spp. can survive for long periods of time under harsh conditions; (2) observations and conclusions about Salmonella persistence obtained from human outbreaks; and (3) new information revealed by genomic- and population-based studies of Salmonella and related enteric pathogens. We highlight the mechanisms of Salmonella persistence and transmission as an essential part of their lifecycle and a prerequisite for their evolutionary success as human pathogens.

Inactivation of Escherichia coli O157:H7 on radish seeds by sequential treatments with chlorine dioxide, drying, and dry heat without loss of seed viability

We developed and validated a treatment to inactivate Escherichia coli O157:H7 on radish seeds without decreasing seed viability. Treatments with aqueous ClO(2) followed by drying and dry-heat treatments were evaluated for efficacy to inactivate the pathogen. Conditions to dry radish seeds after treatment with water (control) or ClO(2) were established. When treated seeds with high water activity (a(w)) (>0.99) were stored at 45°C and 23% relative humidity (RH), the a(w) decreased to <0.30 within 24 h. Drying high-a(w) seeds before exposing them to dry-heat treatment (≥60°C) was essential to preserve seed viability. The germination rate of radish seeds which had been immersed in water for 5 min, dried at 45°C and 23% RH for 24 h, and heated at 70°C for 48 h or at 80°C for 24 h was not significantly decreased (P ≤ 0.05) compared to that of untreated radish seeds. Sequential treatments with ClO(2) (500 μg/ml, 5 min), drying (45°C, 23% RH, 24 h), and dry heating (70°C, 23% RH, 48 h) eliminated E. coli O157:H7 (5.9 log CFU/g) on radish seeds and, consequently, sprouts produced from them without decreasing the germination rate. These sequential treatments are recommended for application to radish seeds intended for sprout production.

Synergistic effect of chlorine dioxide and drying treatments for inactivating Escherichia coli O157:H7 on radish seeds

Studies were done to determine whether calcium hypochlorite (Ca(OCl)(2)) and chlorine dioxide (ClO(2)) treatment followed by drying had a synergistic killing effect on microorganisms on radish seeds intended for sprout production. Uninoculated radish seeds and seeds inoculated with Escherichia coli O157:H7 were treated with water, Ca(OCl)(2) (free chlorine concentrations of 50 or 200 microg/ml), or ClO(2) (50 or 200 microg/ml) for 5 min and subsequently dried at 25 degrees C for up to 24 h. Populations of total aerobic bacteria (TAB), molds and yeasts (MY), and E. coli O157:H7 on the seeds treated with Ca(OCl)(2) were not significantly different (P = 0.05) than populations on seeds treated with ClO(2) at the same concentrations. However, populations of microorganisms on seeds treated with ClO(2) decreased more rapidly during drying. Treatment with ClO(2) (200 microg/ml) followed by drying caused reductions in TAB, MY, and E. coli O157:H7 of 3.1, 2.0, and 3.8 log CFU/g, respectively. When seeds were treated with water, Ca(OCl)(2) (50 or 200 microg/ml), and ClO(2) (50 microg/ml) and subsequently dried, reductions in TAB, MY, and E. coli O157:H7 were 0.2 to 2.0, 0.4 to 2.0, and 1.4 to 2.2 log CFU/g, respectively. Results indicate that inactivation of E. coli O157:H7 on radish seeds is greater after treatment with ClO(2) followed by drying than after treatment with Ca(OCl)(2) followed by drying, thus providing a synergistic treatment combination for reducing the safety risk associated with sprouts produced from these seeds.

Control of Salmonella on Sprouting Mung Bean and Alfalfa Seeds by Using a Biocontrol Preparation Based on Antagonistic Bacteria and Lytic Bacteriophages

The following reports on the application of a combination of antagonistic bacteria and lytic bacteriophages to control the growth of Salmonella on sprouting mung beans and alfalfa seeds. Antagonistic bacteria were isolated from mung bean sprouts and tomatoes by using the deferred plate assay to assess anti-Salmonella activity. From the isolates screened, an Enterobacter asburiae strain (labeled “JX1”) exhibited stable antagonistic activity against a broad range of Salmonella serovars (Agona, Berta, Enteritidis, Hadar, Heidelberg, Javiana, Montevideo, Muenchen, Newport, Saint Paul, and Typhimurium). Lytic bacteriophages against Salmonella were isolated from pig or cattle manure effluent. A bacteriophage cocktail prepared from six isolates was coinoculated with E. asburiae JX1 along with Salmonella in broth culture. The combination of E. asburiae JX1 and bacteriophage cocktail reduced the levels of Salmonella by 5.7 to 6.4 log CFU/ml. Mung beans inoculated with Salmonella and sprouted over a 4-day period attained levels of 6.72 ± 0.78 log CFU/g. In contrast, levels of Salmonella were reduced to 3.31 ± 2.48 or 1.16 ± 2.14 log CFU/g when the pathogen was coinoculated with bacteriophages or E. asburiae JX1, respectively. However, by using a combination of E. asburiae JX1and bacteriophages, the levels of Salmonella associated with mung bean sprouts were only detected by enrichment. The biocontrol preparation was effective at controlling the growth of Salmonella under a range of sprouting temperatures (20 to 30°C) and was equally effective at suppressing the growth of Salmonella on sprouting alfalfa seeds. The combination of E. asburiae JX1 and bacteriophages represents a promising, chemical-free approach for controlling the growth of Salmonella on sprouting seeds.

Microbial diversity changes in soybean sprouts treated with enterocin AS-48

Seed sprouts may act as vehicles for foodborne pathogenic bacteria. In the present study, the effect of washing treatment with the enterococcal bacteriocin enterocin AS-48 on the microbiota of two batches of soybean sprouts was studied by culture-dependent and independent methods throughout storage at 10 degrees C. Viable cell counts of bacteriocin-treated samples revealed some modifications only for lactic acid bacteria and enterococci during storage. In the control samples from batch 1, the culture-independent DGGE analysis revealed species from genera Rahnella and Serratia as the predominant bacteria at early stages. Several bands corresponding to other genera (two Pantoea bands, one Escherichia band, and five Enterobacter bands) were also detected during storage of control samples, especially at days 3 and 5, while one Rahnella band disappeared. By contrast, some of the enterobacteria (Pantoea Escherichia and Enterobacter) were not detected or showed very faint bands in batch 1 bacteriocin-treated samples, in which two new and intense bands corresponding to genera Enterococcus and Leuconostoc were detected. Batch 2 showed a more homogeneous bacterial population, composed mainly by species of genus Enterobacter together with Pantoea. The major modifications detected in the bacteriocin-treated samples from batch 2 included the loss of one genus Enterobacter band at days 3, 5 and 7, and the detection of a new band corresponding to genus Leuconostoc at days 5 and 7. These results suggest that bacteriocin treatment disturbs the microbial balance in sprouts, producing changes in the microbial profile that cannot be detected by culture-dependent methods. The results also encourage the use of culture-independent methods to gain more insights into the global effects of bacteriocins in food systems.

Combination treatments for killing Escherichia coli O157:H7 on alfalfa, radish, broccoli, and mung bean seeds

In this study, the effectiveness of prolonged dry-heat treatment (50 degrees C) alone or in combination with chemical treatments (1% oxalic acid, 0.03% phytic acid, 50% ethanol, electrolyzed acidic water, and electrolyzed alkaline water) in eliminating Escherichia coli O157:H7 on laboratory-inoculated alfalfa, radish, broccoli, and mung bean seeds was compared with that of dry-heat treatment in combination with irradiation treatment. Dry-heat treatment for 17 or 24 h alone could reduce E. coli O157:H7 numbers to below detectable levels in radish, broccoli, and alfalfa seeds, but was unable to reduce the pathogen numbers to below the detectable level in mung bean seeds. In addition, dry-heat treatment for 17 h plus sanitizer treatments were effective in greatly reducing pathogen populations on radish, broccoli, and alfalfa seeds, without compromising the quality of the sprouts, but these treatments did not eliminate the pathogen from radish and alfalfa seeds. Seventeen hours of dry heat followed by a 1.0-kGy dose of irradiation completely eliminated E. coli O157:H7 from radish and mung bean seeds, whereas only a minimum radiation dose of 0.25 kGy was required to completely eliminate the pathogen from broccoli and alfalfa seeds. Dry heat in combination with radiation doses of up to 1.0 kGy did not negatively impact the seed germination rate or length of alfalfa, broccoli, and radish seeds or the length of alfalfa, broccoli, and radish sprouts, but did decrease the length of mung bean sprouts.

Factors influencing the growth of Salmonella during sprouting of naturally contaminated alfalfa seeds

In this study, the factors that affect Salmonella growth during sprouting of naturally contaminated alfalfa seeds associated with two previous outbreaks of salmonellosis were examined. A minidrum sprouter equipped with automatic irrigation and rotation systems was built to allow sprouting to be conducted under conditions similar to those used commercially. The growth of Salmonella during sprouting in the minidrum was compared with that observed in sprouts grown in glass jars under conditions commonly used at home. The level of Salmonella increased by as much as 4 log units after 48 h of sprouting in jars but remained constant during the entire sprouting period in the minidrum. The effect of temperature and irrigation frequency on Salmonella growth was examined. Increasing the sprouting temperature from 20 to 30 degrees C increased the Salmonella counts by as much as 2 log units on sprouts grown both in the minidrum and in the glass jars. Decreasing the irrigation frequency from every 20 min to every 2 h during sprouting in the minidrum or from every 4 h to every 24 h during sprouting in the glass jars resulted in an approximately 2-log increase in Salmonella counts. The levels of total aerobic mesophilic bacteria, coliforms, and Salmonella in spent irrigation water closely reflected those found in sprouts, confirming that monitoring of spent irrigation water is a good way to monitor pathogen levels during sprouting.

Salmonella infections associated with mung bean sprouts: epidemiological and environmental investigations

We investigated an outbreak of Salmonella Enteritidis (SE) infections linked to raw mung bean sprouts in 2000 with two case-control studies and reviewed six similar outbreaks that occurred in 2000–2002. All outbreaks were due to unusual phage types (PT) of SE and occurred in the United States (PT 33, 1, and 913), Canada (PT 11b and 913), and The Netherlands (PT 4b). PT 33 was in the spent irrigation water and a drain from one sprout grower. None of the growers disinfected seeds at recommended concentrations. Only two growers tested spent irrigation water; neither discarded the implicated seed lots after receiving a report of Salmonella contamination. We found no difference in the growth of SE and Salmonella Newport on mung beans. Mung bean sprout growers should disinfect seeds, test spent irrigation water, and discontinue the use of implicated seed lots when pathogens are found. Laboratories should report confirmed positive Salmonella results from sprout growers to public health authorities.

Thermal inactivation of Salmonella and Escherichia coli O157:H7 on alfalfa seeds

Alfalfa seeds inoculated with five strains of Salmonella or Escherichia coli O157:H7 were subjected to dry heat at 55 degrees C for up to 8 days. Five-log reductions in Salmonella or E. coli O157:H7 on seeds were observed. No pathogens were detected on the sprouted seeds, which were initially inoculated with ca. 2 log CFU/g of Salmonella or more than 8 log CFU/g of E. coli O157:H7. The percentages of germination of the alfalfa seeds did not significantly decrease after 6 days of heating at 55 degrees C. These results showed that heat treatment of alfalfa seeds at 55 degrees C for up to 6 days was effective in enhancing the safety of alfalfa sprouts without affecting germination significantly.

Inactivation of Escherichia coli O157:H7 and Salmonella on artificially or naturally contaminated mung beans (Vigna radiata L) using a stabilized oxychloro-based sanitizer

AIMS

To evaluate the efficacy of a stabilized oxychloro-based (SOC) sanitizer to decontaminate mung beans artificially or naturally contaminated with Escherichia coli O157:H7 or Salmonella.

METHODS AND RESULTS

Naturally contaminated beans were produced by introducing a five-strain cocktail of E. coli O157:H7 or Salmonella onto the flowers of growing mung bean plants. Escherichia coli O157:H7 was only sporadically recovered from sprout lots (three testing positive from 10 tested) derived from harvested beans. In contrast, Salmonella was recovered from 18 of 20 lots screened. Pathogens present on naturally contaminated seed could be successfully inactivated with SOC applied at 200 ppm for 24 h at 28 degrees C. SOC treatment could also decontaminate artificially inoculated mung bean batches containing different levels of contaminated seed. SOC inactivated E. coli O157:H7, but not Salmonella introduced onto damaged (scarified) beans.

CONCLUSIONS

SOC sanitizer could inactivate Salmonella or E. coli O157:H7 naturally or artificially introduced onto mung beans. However, the SOC treatment failed to inactivate Salmonella introduced onto damaged mung beans.

SIGNIFICANCE AND IMPACT OF THE STUDY

SOC sanitizer represents an effective method for decontaminating undamaged mung beans.

Evaluation of chemical and physical (high-pressure and temperature) treatments to improve the safety of minimally processed mung bean sprouts during refrigerated storage

The objective of this study was to compare the effects of combined high hydrostatic pressure and temperature treatments with different chemical sanitation treatments (water, sodium hypochlorite, and hydrogen peroxide) on the microbiological properties of mung bean sprouts. In a first study, the raw product was subjected to several combined high-pressure and temperature treatments for calculating a mathematical model by a response surface methodology. The number of pressure-temperature (150 to 400 MPa; 20 to 40 degrees C) combinations was limited to 10. In addition, a model system consisting of mung bean sprout juice was inoculated with Listeria monocytogenes (CECT 4032). Microbial inactivation with this model system was also investigated by a response surface methodology. The highest aerobic mesophilic bacteria and L. monocytogenes inactivation was achieved at maximum pressure and temperature (5.5 and 1.8 log cycles, respectively). In a second study, the effect of five different processing lines on the microbial load reduction of minimally processed mung bean sprouts during refrigerated storage was studied. All treatments reduced the initial population of aerobic mesophilic bacteria and fecal coliforms, with the physical treatment of 400 MPa and 40 degrees C being the most effective, showing initial reductions of 5.8 and 7.8 log CFU/ g, respectively. Recovery of bacteria from sprouts treated under these conditions was not observed during storage. However, the sprouts that received washing treatments with water, sodium hypochlorite, and hydrogen peroxide exhibited increases in aerobic mesophilic and fecal coliform counts after 3 days of storage at 4 degrees C.

Inactivation of escherichia coli 0157:H7 and Salmonella on mung beans, alfalfa, and other seed types destined for sprout production by using an oxychloro-based sanitizer

The efficacy of a stabilized oxychloro-based food grade sanitizer to decontaminate seeds destined for sprout production has been evaluated. By using mung bean seeds as a model system, it was demonstrated that the sanitizer could be used to inactivate a five-strain cocktail of Escherichia coli O157:H7 or Salmonella introduced onto beans at 10(3) to 10(4) CFU/g. Salmonella was more tolerant to stabilized oxychloro than was E. coli O157:H7, with sanitizer levels of >150 and >50 ppm, respectively, being required to ensure pathogen-free sprouts. The decontamination efficacy was also found to be dependent on treatment time (>8 h optimal) and the seed-to-sanitizer ratio (>1:4 optimal). Stabilized oxychloro treatment did not exhibit phytotoxic effects, as germination and sprout yields were not significantly (P > 0.05) different as compared with untreated controls. Although human pathogens could be effectively eliminated from mung beans, the aerobic plate count of native microflora on sprouts grown from treated seed was not significantly (P > 0.05) different from the controls. The diversity of microbial populations (determined through 16S rRNA denaturing gradient gel electrophoresis analysis) associated with bean sprouts was not significantly affected by the sanitizer treatment. However, it was noted that Klebsiella and Herbasprillum (both common plant endophytes) were absent in sprouts derived from decontaminated seed but were present in control sprouts. When a further range of seed types was evaluated, it was found that alfalfa, cress, flax, and soybean could be decontaminated with the stabilized oxychloro sanitizer. However, the decontamination efficacy with other seed types was less consistent. It appears that the rate of seed germination and putative activity of sanitizer sequestering system(s), in addition to other factors, may limit the efficacy of the decontamination method.

Inactivation of Escherichia coli O157:H7, Salmonella typhimurium DT104, and Listeria monocytogenes on inoculated alfalfa seeds with a fatty acid-based sanitizer

Alfalfa seeds were inoculated with a three-strain cocktail of Escherichia coli O157:H7, Salmonella enterica subsp. enterica serovar Typhimurium DT104, or Listeria monocytogenes by immersion to contain approximately 6 to 8 log CFU/g and then treated with a fatty acid-based sanitizer containing 250 ppm of peroxyacid, 1,000 ppm of caprylic and capric acids (Emery 658), 1,000 ppm of lactic acid, and 500 ppm of glycerol monolaurate at a reference concentration of 1X. Inoculated seeds were immersed at sanitizer concentrations of 5X, 10X, and 15X for 1, 3, 5, and 10 min and then assessed for pathogen survivors by direct plating. The lowest concentration that decreased all three pathogens by >5 log was 15. After a 3-min exposure to the 15X concentration, populations of E. coli O157:H7, Salmonella Typhimurium DT104, and L. monocytogenes decreased by >5.45, >5.62, and >6.92 log, respectively, with no sublethal injury and no significant loss in seed germination rate or final sprout yield. The components of this 15x concentration (treatment A) were assessed independently and in various combinations to optimize antimicrobial activity. With inoculated seeds, treatment C (15,000 ppm of Emery 658, 15,000 ppm of lactic acid, and 7,500 ppm of glycerol monolaurate) decreased Salmonella Typhimurium, E. coli O157:H7, and L. monocytogenes by 6.23 and 5.57 log, 4.77 and 6.29 log, and 3.86 and 4.21 log after 3 and 5 min of exposure, respectively. Treatment D (15,000 ppm of Emery 658 and 15,000 ppm of lactic acid) reduced Salmonella Typhimurium by >6.90 log regardless of exposure time and E. coli )157:H7 and L. monocytogenes by 4.60 and >5.18 log and 3.55 and 3.14 log after 3 and 5 min, respectively. No significant differences (P > 0.05) were found between treatments A, C, and D. Overall, treatment D, which contained Emery 658 and lactic acid as active ingredients, reduced E. coli O157:H7, Salmonella Typhimurium, and L. monocytogenes populations by 3.55 to >6.90 log and may provide a viable alternative to the recommended 20,000 ppm of chlorine for sanitizing alfalfa seeds.

Regulation of enteric endophytic bacterial colonization by plant defenses

Bacterial endophytes reside within the interior of plants without causing disease or forming symbiotic structures. Some endophytes, such as Klebsiella pneumoniae 342 (Kp342), enhance plant growth and nutrition. Others, such as Salmonella enterica serovar Typhimurium (S. typhimurium), are human pathogens that contaminate raw produce. Several lines of evidence are presented here to support the hypothesis that plant defense response pathways regulate colonization by endophytic bacteria. An ethylene-insensitive mutant of Medicago truncatula is hypercolonized by Kp342 compared to the parent genotype. Addition of ethylene, a signal molecule for induced systemic resistance in plants, decreased endophytic colonization in Medicago spp. This ethylene-mediated inhibition of endophytic colonization was reversed by addition of the ethylene action inhibitor, 1-methylcyclopropene. Colonization of Medicago spp. by S. typhimurium also was affected by exogenous ethylene. Mutants lacking flagella or a component of the type III secretion system of Salmonella pathogenicity island 1 (TTSS-SPI1) colonize the interior of Medicago spp. in higher numbers than the wild type. Arabidopsis defense response-related genotypes indicated that only salicylic acid (SA)-independent defense responses contribute to restricting colonization by Kp342. In contrast, colonization by S. typhimurium is affected by both SA-dependent and -independent responses. S. typhimurium mutants further delineated these responses, suggesting that both flagella and TTSS-SPI1 effectors can be recognized. Flagella act primarily through SA-independent responses (compromising SA accumulation still affected colonization in the absence of flagella). Removal of a TTSS-SPI1 effector resulted in hypercolonization regardless of whether the genotype was affected in either SA-dependent or SA-independent responses. Consistent with these results, S. typhimurium activates the promoter of PR1, a SA-dependent pathogenesis-related gene, while S. typhimurium mutants lacking the TTSS-SPI1 failed to activate this promoter. These observations suggest approaches to reduce contamination of raw produce by human enteric pathogens and to increase the number of growth-promoting bacteria in plants.

Isolation, identification, and selection of lactic acid bacteria from alfalfa sprouts for competitive inhibition of foodborne pathogens

Several studies have investigated the control of pathogens on alfalfa sprouts, and some treatments have been shown to be effective in reducing pathogen populations. However, control methods investigated thus far only provide pathogen control at a given point in the sprouting process and can affect germination. Competitive inhibition of pathogens with lactic acid bacteria might provide pathogen control throughout the sprouting process and up to consumption. The purpose of this study was to isolate and identify lactic acid bacteria from alfalfa sprouts to inhibit the growth of foodborne pathogens. Fifty-eight lactic acid bacteria isolates were obtained from alfalfa seeds and sprouts. These isolates were evaluated for inhibitory action against Salmonella enterica, Escherichia coli O157:H7, and Listeria monocytogenes by agar spot tests. All pathogens were inhibited by 32 (55%) of the isolates, S. enterica by 56 (97%), E. coli O157:H7 by 49 (84%), and L. monocytogenes by 41 (71%). The isolates were identified by the Analytical Profile Index evaluation of carbohydrate utilization. Isolates obtained from a sample of alfalfa seeds and identified as Lactococcus lactis subsp. lactis showed zones of inhibition of 4.0 mm or greater for all pathogens. One of these isolates, Lactococcus lactis subsp. lactis (L7), and an isolate previously obtained, Pediococcus acidilactici (D3), were evaluated for competitive inhibition of S. enterica, E. coli O157:H7, and L. monocytogenes in deMan Rogosa Sharpe agar and broth. Pathogen populations were significantly reduced by day 5. The selected isolates will be further evaluated in future studies for inhibitory action toward S. enterica, E. coli O157:H7, and L. monocytogenes during sprouting.

Analysis of published sprout seed sanitization studies shows treatments are highly variable

Consumption of raw sprouts has caused many foodborne illness outbreaks in the last decade, and most outbreaks have been linked to contaminated seeds. Many seed sanitization treatments have been studied as a means to reduce the risk of illness associated with sprouts. Published data on seed sanitization were analyzed collectively to identify factors that influenced the efficacy of seed sanitization and to determine the variability associated with various sanitization processes. Temperature and duration of the sanitization treatment were found to produce a negligible effect on log microbial reductions. Salmonella, Escherichia coli O157:H7, and total aerobic microorganisms were all inactivated at similar rates. Data were fit to triangular or uniform distributions for 16 different chemical treatments. Among the most effective treatments were 8% hydrogen peroxide (uniform distribution [2.5, 4.5]), 20,000 ppm of chlorine (triangular distribution [1, 2.5, 6.5]), and 1% Ca(OH)2 (triangular distribution [0.5, 4, 5]). Chemical treatments where more published data were available showed more variability.

Changes in growth and antioxidant status of alfalfa sprouts during sprouting as affected by gamma irradiation of seeds

Viking 3000 alfalfa seeds irradiated with gamma rays to doses of 0, 1, 2, 3, or 4 kGy were sprouted and allowed to grow for up to 8 days at 23 degrees C. Germination, growth (yield and length), antioxidant capacity, and ascorbic acid (AA) were measured during sprouting. Results showed percent germination of the seeds and the rates of growth of the sprouts were inversely related to the radiation dose absorbed by the seeds. Both antioxidant capacity and AA content expressed on a fresh weight basis decreased during growth of the sprouts. Sprouts grown from irradiated seeds had greater antioxidant capacity and AA content on a fresh weight basis than those grown from nonirradiated seeds. However, when the nutritive values were expressed on a per gram of seed basis, irradiation had no effect on the nutritive values of sprouts.

Internalization of bioluminescent Escherichia coli and Salmonella Montevideo in growing bean sprouts

AIMS

Investigate the interaction of bioluminescent Escherichia coli and Salmonella Montevideo with germinating mung bean sprouts.

METHODS AND RESULTS

E. coli or Salm. Montevideo introduced on mung beans became established both internally and externally on sprouts after the initial 24 h germinating period. In both cases the inoculated bacterium formed the predominant microflora on the sprouted beans throughout. From the bioluminescent profile of inoculated sprouting beans, bacterial growth was found to be in close proximity to the roots but not on the hypocotyls. Clumps (biofilms) of cells with low viability were observed within the grooves between epidermal cells on hypocotyls. Treatment with 20,000 ppm sodium hypochlorite removed the majority of bacteria from the surface of hypocotyls although nonviable single cells were occasionally observed. However, viable bacteria were recovered from the apoplastic fluid, and extracts of surface-sterilized sprouts indicating that the internal bacterial populations had been protected. This was confirmed using in situ beta-glucuronidase staining of surface-sterilized sprouts where cleaved enzyme substrate (by the action of internalized E. coli) was visualized within the plant vascular system.

CONCLUSIONS

E. coli or Salmonella present on seeds become internalized within the subsequent sprouts and cannot be removed by postharvest biocidal washing.

SIGNIFICANCE AND IMPACT OF THE STUDY

Mung bean production should be carefully controlled to prevent contamination occurring in order to minimize the health risk associated with raw bean sprouts.

Bactericidal effects of konjac fluid on several food-poisoning bacteria

In this study, the bactericidal effects of Japanese alkaline foods on food-poisoning bacteria were evaluated. Konjac is an alkaline food soaked in calcinated calcium (the pH of konjac fluid ranges from 11.42 to 12.53). Konjac fluids completely inactivated Escherichia coli, enterohemorrhagic E. coli O157:H7 and E. coil O26:H9, Salmonella Enteritidis, Vibrio parahemolyticus. and Staphylococcus aureus. The initial level of 6 log CFU/ml dramatically decreased after incubation with konjac fluid, and no viable gram-negative bacterium cells could be detected within 1 to 2 days and no viable S. aureus cells could be detected within 3 to 5 days. On the other hand, treatment with konjac fluid was also effective in reducing levels of spore-forming bacteria (Bacillus subtilis, Bacillus cereus, Clostridium perfringens, and Clostridium botulinum type E and type A). At least a 4-log reduction of spore-forming bacteria was obtained in konjac fluid within 7 to 14 days. Vegetative cells were more susceptible to konjac fluid than spores were. When the initial cell count was 6 log CFU/ml, a few surviving spores remained for 60 to 90 days, but no spores could be detected after 120 days. When the initial count of spore-forming bacteria was 3 to 4 log CFU/ml, the cells considered vegetative were completely inactivated within I to 3 days. Repeated treatment with konjac fluid caused complete inactivation of spores in less than 1 to 3 days. Our studies indicate that konjac fluid, which has a long history of use in food, will control food-poisoning bacterial contamination during the production or preservation of konjac and other foods and has a preventive effect on bacteria that can cause severe disease at uniquely low levels.