Improvement of immunomagnetic separation for Escherichia coli O157:H7 detection by the PickPen magnetic particle separation device

Occurrence of the Seven Most Common Serotypes of Shiga Toxin-Producing Escherichia coli in Beef Cuts Produced in Meat Processing Plants in the State of São Paulo, Brazil

ABSTRACT

Healthy cattle are considered the main reservoir of Shiga toxin-producing Escherichia coli (STEC) strains, so in some places in the world, products derived from beef are the most common source for disease outbreaks caused by these bacteria. Therefore, to guarantee that the beef produced by our slaughterhouses is safe, there is a need for continuous monitoring of these bacteria. In this study, 215 beef cuts were evaluated, including chilled vacuum-packed striploins (151 samples), rib eyes (30 samples), and knuckles (34 samples), from March to June 2018. These meat samples were collected from the slaughter of unconfined cattle, being arbitrarily collected from eight meat processing companies in São Paulo state, Brazil. Each sample was examined for the presence of STEC toxin type (stx1 and/or stx2 genes) and also the attaching and effacing E. coli (eae) gene, determined by a multiplex PCR assay. We show that the major seven STEC strains (O serogroups O26, O45, O103, O111, O121, O145, and O157) are not detected in any of the analyzed beef cut samples; however, three of them presented the virulence eae gene. Therefore, the absence of STEC strains in the beef samples may be an indication of the low prevalence of this pathogen in the cattle herd on the farm, associated with good hygiene and handling practices adopted by the meat industry.

HIGHLIGHTS

Application of F0F1‑ATPase immuno‑biosensors for detecting Escherichia coli O157:H7

Escherichia coli (E. coli) O157:H7 is an important food‑borne pathogen with a low infective threshold and high resistance to treatment. There are currently a number of detection methods available, however, the majority are time‑consuming, complex and expensive, thus it is hard for these methods to be applied in routine detection. Therefore, there is urgent requirement to develop more sensitive, rapid and specific detective techniques. In the present study, an immuno‑biosensor based on the interference of load to the F0F1‑ATPase rotation, indicated by the fluorescence fluctuation, was constructed to detect O157:H7. The results demonstrated a good linear relationship (R2=0.9818) between antigen concentration (range, 102 cfu to 104 cfu) and the fluorescence intensity. The detection signals of the samples containing 102 cfu/well and 104 cfu/well E. coli O157:H7 were significantly stronger than the signal produced by the control sample (P<0.01). Due to its higher sensibility and simplicity when compared with the current methods applied, the results of the present study indicate a promising future for the application of this technique in detecting food source pathogens.

A review on detection methods used for foodborne pathogens

Foodborne pathogens have been a cause of a large number of diseases worldwide and more so in developing countries. This has a major economic impact. It is important to contain them, and to do so, early detection is very crucial. Detection and diagnostics relied on culture-based methods to begin with and have developed in the recent past parallel to the developments towards immunological methods such as enzyme-linked immunosorbent assays (ELISA) and molecular biology-based methods such as polymerase chain reaction (PCR). The aim has always been to find a rapid, sensitive, specific and cost-effective method. Ranging from culturing of microbes to the futuristic biosensor technology, the methods have had this common goal. This review summarizes the recent trends and brings together methods that have been developed over the years.

Antimicrobial-Resistant Bacterial Populations and Antimicrobial Resistance Genes Obtained from Environments Impacted by Livestock and Municipal Waste

This study compared the populations of antimicrobial-resistant bacteria and the repertoire of antimicrobial resistance genes in four environments: effluent of three municipal wastewater treatment facilities, three cattle feedlot runoff catchment ponds, three swine waste lagoons, and two "low impact" environments (an urban lake and a relict prairie). Multiple liquid and solid samples were collected from each environment. The prevalences and concentrations of antimicrobial-resistant (AMR) Gram-negative (Escherichia coli and Salmonella enterica) and Gram-positive (enterococci) bacteria were determined from individual samples (n = 174). The prevalences of 84 antimicrobial resistance genes in metagenomic DNA isolated from samples pooled (n = 44) by collection date, location, and sample type were determined. The prevalences and concentrations of AMR E. coli and Salmonella were similar among the livestock and municipal sample sources. The levels of erythromycin-resistant enterococci were significantly higher in liquid samples from cattle catchment ponds and swine waste lagoons than in liquid samples from municipal wastewater treatment facilities, but solid samples from these environments did not differ significantly. Similarly, trimethoprim/sulfamethoxazole-resistant E. coli concentrations were significantly higher in swine liquid than in municipal liquid samples, but there was no difference in solid samples. Multivariate analysis of the distribution of antimicrobial resistance genes using principal coordinate analysis showed distinct clustering of samples with livestock (cattle and swine), low impact environment and municipal samples forming three separate clusters. The numbers of class A beta-lactamase, class C beta-lactamase, and fluoroquinolone resistance genes detected were significantly higher (P < 0.05) in municipal samples than in cattle runoff or swine lagoon samples. In conclusion, we report that AMR is a very widespread phenomenon and that similar prevalences and concentrations of antimicrobial-resistant bacteria and antimicrobial resistance genes exist in cattle, human, and swine waste streams, but a higher diversity of antimicrobial resistance genes are present in treated human waste discharged from municipal wastewater treatment plants than in livestock environments.

Improvement of the quantitation method for the tdh (+) Vibrio parahaemolyticus in molluscan shellfish based on most-probable- number, immunomagnetic separation, and loop-mediated isothermal amplification

Vibrio parahaemolyticus is a marine microorganism that can cause seafood-borne gastroenteritis in humans. The infection can be spread and has become a pandemic through the international trade of contaminated seafood. Strains carrying the tdh gene encoding the thermostable direct hemolysin (TDH) and/or the trh gene encoding the TDH-related hemolysin (TRH) are considered to be pathogenic with the former gene being the most frequently found in clinical strains. However, their distribution frequency in environmental isolates is below 1%. Thus, very sensitive methods are required for detection and quantitation of tdh⁺ strains in seafood. We previously reported a method to detect and quantify tdh⁺V. parahaemolyticus in seafood. This method consists of three components: the most-probable-number (MPN), the immunomagnetic separation (IMS) targeting all established K antigens, and the loop-mediated isothermal amplification (LAMP) targeting the tdh gene. However, this method faces regional issues in tropical zones of the world. Technicians have difficulties in securing dependable reagents in high-temperature climates where we found MPN underestimation in samples having tdh⁺ strains as well as other microorganisms present at high concentrations. In the present study, we solved the underestimation problem associated with the salt polymyxin broth enrichment for the MPN component and with the immunomagnetic bead-target association for the IMS component. We also improved the supply and maintenance of the dependable reagents by introducing a dried reagent system to the LAMP component. The modified method is specific, sensitive, quick and easy and applicable regardless of the concentrations of tdh⁺V. parahaemolyticus. Therefore, we conclude this modified method is useful in world tropical, sub-tropical, and temperate zones.

Efficacy of antimicrobial compounds on surface decontamination of seven Shiga toxin-producing Escherichia coli and Salmonella inoculated onto fresh beef

Several antimicrobial compounds have been used in commercial meat processing plants for decontamination of pathogens on beef carcasses, but there are many commercially available, novel antimicrobial compounds that may be more effective and suitable for use in beef processing pathogen-reduction programs. Sixty-four prerigor beef flanks (cutaneous trunci) were used in a study to determine whether hypobromous acid, neutral acidified sodium chlorite, and two citric acid-based antimicrobial compounds effectively reduce seven Shiga toxin-producing Escherichia coli (STEC) serogroups and Salmonella on the surface of fresh beef. Two cocktail mixtures were inoculated onto prerigor beef flank surfaces. Cocktail mixture 1 was composed of STEC serogroups O26, O103, O111, O145, and O157; and cocktail mixture 2 was composed of STEC serogroups O45, O121, and O157 and Salmonella. The inoculated fresh beef flanks were subjected to spray treatments with four antimicrobial compounds. Following antimicrobial treatments, both control and treated fresh beef samples were either enumerated immediately or were stored for 48 h at 4°C before enumeration. All four antimicrobial compounds caused 0.7- to 2.0-log reductions of STEC, Salmonella, aerobic plate counts, and Enterobacteriaceae. Results also indicated that the four antimicrobial compounds were as effective at reducing the six non-O157 STEC strains as they were at reducing E. coli O157:H7 on the surfaces of fresh beef. The recovery of all seven STEC strains and Salmonella in a low-inoculation study indicated that none of the four antimicrobial compounds eliminated all of the tested pathogens.

Occurrence of Antimicrobial-Resistant Escherichia coli and Salmonella enterica in the Beef Cattle Production and Processing Continuum

Specific concerns have been raised that third-generation cephalosporin-resistant (3GC(r)) Escherichia coli, trimethoprim-sulfamethoxazole-resistant (COT(r)) E. coli, 3GC(r) Salmonella enterica, and nalidixic acid-resistant (NAL(r)) S. enterica may be present in cattle production environments, persist through beef processing, and contaminate final products. The prevalences and concentrations of these organisms were determined in feces and hides (at feedlot and processing plant), pre-evisceration carcasses, and final carcasses from three lots of fed cattle (n = 184). The prevalences and concentrations were further determined for strip loins from 103 of the carcasses. 3GC(r) Salmonella was detected on 7.6% of hides during processing and was not detected on the final carcasses or strip loins. NAL(r) S. enterica was detected on only one hide. 3GC(r) E. coli and COT(r) E. coli were detected on 100.0% of hides during processing. Concentrations of 3GC(r) E. coli and COT(r) E. coli on hides were correlated with pre-evisceration carcass contamination. 3GC(r) E. coli and COT(r) E. coli were each detected on only 0.5% of final carcasses and were not detected on strip loins. Five hundred and 42 isolates were screened for extraintestinal pathogenic E. coli (ExPEC) virulence-associated markers. Only two COT(r) E. coli isolates from hides were ExPEC, indicating that fed cattle products are not a significant source of ExPEC causing human urinary tract infections. The very low prevalences of these organisms on final carcasses and their absence on strip loins demonstrate that current sanitary dressing procedures and processing interventions are effective against antimicrobial-resistant bacteria.

Most-probable-number loop-mediated isothermal amplification-based procedure enhanced with K antigen-specific immunomagnetic separation for quantifying tdh(+) Vibrio parahaemolyticus in molluscan Shellfish

Although thermostable direct hemolysin-producing (tdh(+)) Vibrio parahaemolyticus is the leading cause of seafood-borne gastroenteritis, the enumeration of tdh(+) V. parahaemolyticus remains challenging due to its low densities in the environment. In this study, we developed a most-probable-number (MPN)-based procedure designated A-IS(1)-LAMP, in which an immunomagnetic separation (IMS) technique targeting as many as 69 established K antigens and a loop-mediated isothermal amplification (LAMP) assay targeting the thermostable direct hemolysin (tdh) gene were applied in an MPN format. Our IMS employed PickPen, an eight-channel intrasolution magnetic particle separation device, which enabled a straightforward microtiter plate-based IMS procedure (designated as PickPen-IMS). The ability of the procedure to quantify a wide range of tdh(+) V. parahaemolyticus levels was evaluated by testing shellfish samples in Japan and southern Thailand, where shellfish products are known to contain relatively low and high levels of total V. parahaemolyticus, respectively. The Japanese and Thai shellfish samples showed, respectively, relatively low (< 3 to 11 MPN/10 g) and considerably higher (930 to 110,000 MPN/10 g) levels of tdh(+) V. parahaemolyticus, raising concern about the safety of Thai shellfish products sold to domestic consumers at local morning markets. LAMP showed similar or higher performance than conventional PCR in the detection and quantification of a wide range of tdh(+) V. parahaemolyticus levels in shellfish products. Whereas a positive effect of PickPen-IMS was not observed in MPN determination, PickPen-IMS was able to concentrate tdh(+) V. parahaemolyticus 32-fold on average from the Japanese shellfish samples at an individual tube level, suggesting a possibility of using PickPen-IMS as an optional tool for specific shellfish samples. The A-IS(1)-LAMP procedure can be used by any health authority in the world to measure the tdh(+) V. parahaemolyticus levels in shellfish products.

Detection of Escherichia coli O157:H7 and Salmonella enterica in air and droplets at three U.S. commercial beef processing plants

Bacteria are known to be present in the air at beef processing plants, but published data regarding the prevalences of airborne Escherichia coli O157:H7 and Salmonella enterica are very limited. To determine if airborne pathogens were present in beef processing facilities, we placed sedimentation sponges at various locations in three commercial beef plants that processed cattle from slaughter through fabrication. For the 291 slaughter area air samples, E. coli O157:H7 was isolated from 15.8% and S. enterica from 16.5%. Of the 113 evisceration area air samples, E. coli O157:H7 was isolated from only one sample and S. enterica was not isolated from any sample. Pathogens were not isolated from any of the 87 air samples from fabrication areas. Pathogen prevalences, aerobic plate counts, and Enterobacteriaceae counts were highest for air samples obtained from locations near hide removal operations. The process of hide removal disperses liquid droplets, which may contact neighboring carcasses. Samples were obtained both from hide removal locations that were close enough to hide pullers to be contacted by droplets and from locations that were not contacted by droplets. Higher pathogen prevalences, aerobic plate counts, and Enterobacteriaceae counts were observed at locations with samples contacted by the hide removal droplets. We conclude that the hide removal processes likely introduce pathogens into the air via a dispersion of liquid droplets and that these droplets may be an underappreciated source of hide-to-carcass contamination.

Evaluation of commonly used antimicrobial interventions for fresh beef inoculated with Shiga toxin-producing Escherichia coli serotypes O26, O45, O103, O111, O121, O145, and O157:H7

Although numerous antimicrobial interventions targeting Escherichia coli O157:H7 have been developed and implemented to decontaminate meat and meat products during the harvesting process, the information on efficacy of these interventions against the so-called Big Six non-O157 Shiga toxin-producing E. coli (STEC) strains is limited. Prerigor beef flanks (160) were inoculated to determine if antimicrobial interventions currently used by the meat industry have a similar effect in reducing non-O157 STEC serogroups O26, O45, O103, O111, O121, and O145 compared with E. coli O157:H7. A high (10(4) CFU/cm(2)) or a low (10(1) CFU/cm(2)) inoculation of two cocktail mixtures was applied to surfaces of fresh beef. Cocktail mixture 1 was composed of O26, O103, O111, O145, and O157, while cocktail mixture 2 was composed of O45, O121, and O157. The inoculated fresh beef flanks were subjected to spray treatments by the following four antimicrobial compounds: acidified sodium chlorite, peroxyacetic acid, lactic acid, and hot water. High-level inoculation samples were enumerated for the remaining bacteria populations after each treatment and compared with the untreated controls, while low-level inoculation samples were chilled for 48 h at 4°C before enrichment, immunomagnetic separation, and isolation. Spray treatments with hot water were the most effective, resulting in mean pathogen reductions of 3.2 to 4.2 log CFU/cm(2), followed by lactic acid. Hot water and lactic acid also were the most effective interventions with the low-level inoculation on surfaces of fresh beef flanks after chilling. Peroxyacetic acid had an intermediate effect, while acidified sodium chlorite was the least effective in reducing STEC levels immediately after treatment. Results indicate that the reduction of non-O157 STEC by antimicrobial interventions on fresh beef surfaces were at least as great as for E. coli O157:H7. However, the recovery of these low inoculation levels of pathogens indicated that there is no single intervention to eliminate them.

Efficacy of hypobromous acid as a hide-on carcass antimicrobial intervention

Escherichia coli O157:H7 and Salmonella on cattle hides at slaughter are the main source of beef carcass contamination by these foodborne pathogens during processing. Hypobromous acid (HOBr) has been approved for various applications in meat processing, but the efficacy of HOBr as a hide antimicrobial has not been determined. In this study, the antimicrobial properties of HOBr were determined by spraying cattle hides at either of two concentrations, 220 or 500 ppm. Treatment of hides with 220 ppm of HOBr reduced the prevalence of E. coli O157:H7 on hides from 25.3 to 10.1% (P < 0.05) and reduced the prevalence of Salmonella from 28.3 to 7.1% (P < 0.05). Treatment of hides with 500 ppm of HOBr reduced (P < 0.05) the prevalence of E. coli O157:H7 on hides from 21.2 to 10.1% and the prevalence of Salmonella from 33.3 to 8.1%. The application of 220 ppm of HOBr reduced (P < 0.05) aerobic plate counts, total coliform counts, and E. coli counts on hides by 2.2 log CFU/ 100 cm(2). The use of 500 ppm of HOBr resulted in reductions (P < 0.05) of aerobic plate counts, total coliform counts, and E. coli counts by 3.3, 3.7, and 3.8 log CFU/100 cm(2), respectively, demonstrating that the use of higher concentrations of HOBr on hides resulted in additional antimicrobial activity. These results indicate that the adoption of a HOBr hide wash will reduce hide concentrations of spoilage bacteria and pathogen prevalence, resulting in a lower risk of carcass contamination.

Diversity of multidrug-resistant salmonella enterica strains associated with cattle at harvest in the United States

The prevalence and diversity of multidrug-resistant (MDR) Salmonella enterica strains associated with cattle at harvest in the United States were examined. Hides and carcasses of cattle were sampled at processing plants (n = 6) located in four geographically distant regions from July 2005 to April 2006. The mean prevalences of Salmonella on hides, preevisceration carcasses (immediately after hide removal), and postintervention carcasses (in the chiller and after the full complement of interventions) were 89.6%, 50.2%, and 0.8%, respectively. The values for MDR Salmonella enterica strains (defined as those resistant to two or more antimicrobials) as percentages of Salmonella prevalence were 16.7% (95% confidence interval [CI], 8.3 to 25.1%; median percent prevalence, 6.9%), 11.7% (95% CI, 4.4 to 19.0%; median, 4.8%), and 0.33% (95% CI, -0.3 to 0.70%; median, 0%), respectively. In this study, 16,218 Salmonella hide and carcass isolates were screened for antimicrobial resistance. Of these, 978 (6.0%) unique MDR S. enterica isolates were identified and serotyped and their XbaI pulsed-field gel electrophoresis (PFGE) profiles determined. The predominant MDR S. enterica serotypes observed were Newport (53.1%), Typhimurium (16.6%), and Uganda (10.9%). Differences in MDR S. enterica prevalence were detected, and PFGE analysis revealed both epidemic clusters (profiles found in plants in multiple regions/seasons) and endemic clusters (profiles observed in plants in limited regions/seasons) within several of the MDR serotypes examined. Despite these differences, multiple-hurdle processing interventions employed at all plants were found to be quite effective and decreased Salmonella carcass contamination by 98.4% (95% CI, 97.6 to 99.7%).

Evaluation of a direct-fed microbial product effect on the prevalence and load of Escherichia coli O157:H7 in feedlot cattle

Direct-fed microbials (DFM) have been identified as potential preharvest interventions for the reduction of foodborne bacterial pathogens such as Escherichia coli O157:H7. This study evaluated the efficacy of a DFM consisting of Bacillus subtilis strain 166 as an antimicrobial intervention strategy for the reduction of prevalence and load of E. coli O157:H7 in feces and on hides of feedlot cattle. Cattle (n = 526) were divided among 16 feedlot pens. Half of the pens received the DFM, and the other half did not. Hide and fecal samples were collected from each animal on days 28, 63, and 84 of the feeding trial. Over the course of the 84-day feeding period, there were no significant differences observed between treatments for either hide or fecal prevalence of E. coli O157:H7, or for the percentage of animals that were shedding E. coli O157:H7 at high levels (> or =200 CFU/g) in their feces or harboring E. coli O157:H7 at high levels (> or =40 CFU/cm(2)) on their hides. In addition, there was no significant difference between the average daily gains for the treated and control groups, with both groups averaging 1.3 kg/day. We concluded that the DFM tested would not be an effective preharvest intervention against E. coli O157:H7.

Comparative evaluation of practical functionality of rapid test format kits for detection of Escherichia coli O157:H7 on lettuce and leafy greens

Multistate outbreaks of Escherichia coli O157:H7 infection in 2005 and 2006 associated with fresh and especially minimally processed produce greatly escalated the application of rapid pathogen detection systems to safety management in this food category. Pathogen testing was rapidly integrated into preharvest qualification for field lots, incoming raw produce, or final product. The raw produce and final product were incorporated into test-and-hold programs, typically within a 10-h time frame. To enhance consumer safety and provide guidance for the industry, an assessment of selected kits in comparison to a culture-based method was undertaken. Four primary kits were compared: the Neogen Reveal, SDI RapidChek, BioControl GDS O157, and Qualicon BAX O157 MP. Nine different leafy greens were freshly harvested and inoculated with a five-isolate mixture of E. coli O157:H7 at 10 CFU/25 g of sample, and cultures were enriched following the specified protocol. The PCR method was most consistent for identifying the presence of the inoculated pathogen in the shortest period of time. For the red-pigmented leafy vegetables red butter lettuce, curly endive, red lettuce, and lollo rosa, 13, 38, 88, and 100% false-negative results, respectively, were obtained with the immunoassays, but PCR detection was minimally affected. Immunoassays were negatively affected by delays in achieving critical threshold populations during the allowed enrichment period. Leafy green type, temperature abuse, and preharvest environment were unlikely to affect the results of PCR-based kits. Findings strongly suggest that product testing systems using 8-h detection cutoffs may give false-negative results. These issues become very important in high-throughput testing and retest protocols for presumptive pathogen-positive lots of produce.

Prevalence rates of Escherichia coli O157:H7 and Salmonella at different sampling sites on cattle hides at a feedlot and processing plant

The prevalence rates of Escherichia coli O157:H7 and Salmonella at different sampling sites on cattle hides were determined at a feedlot and a processing plant. Sponge samples were collected from six hide surface sites at the feedlot (left and right shoulders, left and right ribs, back, and belly) and four sites at the processing plant (left and right shoulders, back, and belly). The prevalence of E. coli O157:H7 was approximately 80% for left and right shoulder and rib samples, 68% for back samples, and 92% for belly samples collected at the feedlot. At the processing plant, the prevalences of E. coli O157:H7 at all four sites were between 76 and 79%. Salmonella prevalence in feedlot samples was too low to allow for accurate analysis. The prevalence of Salmonella at processing was 49% for left shoulder samples, 48% for right shoulder samples, 40% for back samples, and 68% for belly samples. The results of this study indicate that the site most likely to be naturally contaminated with E. coli O157:H7 and Salmonella simultaneously was the belly.

Effectiveness of 1,3-dibromo-5,5 dimethylhydantoin on reduction of Escherichia coli O157:H7- and Salmonella-inoculated fresh meat

1,3-Dibromo-5,5-dimethylhydantoin (DBDMH; 25 degrees C) and hot water (85 degrees C) spray treatments were evaluated for efficacy in decontamination of pathogenic bacteria attached to beef carcass surfaces represented by cutaneous trunci (CT) muscle sections and beef hearts. Treatments were evaluated using two different systems, a commercial carcass wash cabinet and a model carcass washer. The effects were measured immediately after treatment and again after 48 h of storage at 4 degrees C. Section of CT and beef hearts were inoculated with bovine fecal solution containing approximately 6 log CFU/cm2 of Escherichia coli O157:H7 and Salmonella. After DBDMH or hot water spray treatments, bacterial populations were enumerated immediately and after storage for 48 h at 4 degrees C. DBDMH treatments reduced aerobic plate counts, Enterobacteriaceae, E. coli O157: H7, and Salmonella by the same or slightly lower amounts relative to hot water treatment. DBDMH reduced aerobic plate counts and Enterobacteriaceae by 2.8 to 3.6 log CFU/cm2, E. coli O157:H7 by 1.6 to 2.1 log CFU/cm2, and Salmonella by 0.7 to 2.3 log CFU/cm2 on CT sections and beef hearts. Hot water treatment reduced aerobic plate counts and Enterobacteriaceae by 3.0 to 4.1 log CFU/cm2, E. coli O157:H7 by 1.8 to 2.3 log CFU/cm2, and Salmonella by 2.5 to 2.8 log CFU/cm2. After 48 h of storage, the reductions of organisms by DBDMH and hot water treatments were not different. This study demonstrated that DBDMH spray washing could be effective as an antimicrobial intervention for beef carcasses and variety meats.

Source tracking of Escherichia coli O157:H7 and Salmonella contamination in the lairage environment at commercial U.S. beef processing plants and identification of an effective intervention

Transportation from the feedlot and lairage at the processing plant have been identified as potential sources of Escherichia coli O157:H7 and Salmonella hide contamination. The objective of this study was to perform a comprehensive tracking analysis of E. coli O157:H7 and Salmonella associated with beef cattle from the feedlot through processing. Cattle (n = 581) were sampled in a feedlot, then transported in multiple lots to three commercial, fed beef processing plants in the United States, where they were sampled again. Samples were collected from the tractor trailers prior to loading cattle and from the lairage environment spaces prior to entry of the study cattle. Pathogen prevalence on cattle hides increased on every lot of cattle between exiting the feedlot and beginning processing. Prior to loading cattle, E. coli O157:H7 was found in 9 (64%) of 14 tractor trailers. E. coli O157:H7 was detected in over 60% of the samples from each lairage environment area, while Salmonella was detected in over 70% of the samples from each lairage environment area. E. coli O157:H7 and Salmonella isolates (n = 3,645) were analyzed using pulsed-field gel electrophoresis. The results of the pulsed-field gel electrophoresis tracking indicate that the transfer of bacteria onto cattle hides that occurs in the lairage environments of U.S beef processing plants accounts for a larger proportion of the hide and carcass contamination than does the initial bacterial population found on the cattle exiting the feedlot. Finally, the results of this study indicate that hide wash cabinets are effective in removing contamination derived from the lairage environment.

Salmonella and Escherichia coli O157:H7 contamination on hides and carcasses of cull cattle presented for slaughter in the United States: an evaluation of prevalence and bacterial loads by immunomagnetic separation and direct plating methods

The hide and carcass hygiene of cull cattle at slaughter in four geographically distant regions of the United States was examined from July 2005 to April 2006 by measuring the aerobic plate counts (APC) and the prevalences and loads of Salmonella and Escherichia coli O157:H7. The geometric mean log(10) APC CFU/100 cm(2) levels on hides and preevisceration and postintervention carcasses ranged from 6.17 to 8.19, 4.24 to 6.47, and 1.46 to 1.96, respectively, and were highest in the summer (P < 0.0001). The average prevalences of Salmonella on hides and preevisceration and postintervention carcasses were 89.6% (95% confidence interval [CI], 85.1 to 94.0), 50.2% (95% CI, 40.9 to 59.5), and 0.8% (95% CI, 0.18 to 1.42), respectively. The prevalences of E. coli O157:H7 were 46.9% (95% CI, 37.3 to 56.6) and 16.7% (95% CI, 9.8 to 23.6) on hides and preevisceration carcasses, respectively. Examination of the concomitant incidence of Salmonella and E. coli O157:H7 showed that, on average, 33.3% (95% CI, 15.9 to 69.8) of cattle hide and 4.1% (95% CI, 0.98 to 17.3) of preevisceration carcass samples were contaminated with both pathogens. The pathogen prevalence on hides and carcasses was not significantly affected by the season; however, significant differences were observed between plants with respect to the incoming pathogen load and the ability to mitigate hide-to-carcass transfer. In spite of these differences, postintervention carcass contamination was significantly reduced (P < 0.001), likely as a result of the use of one or more of the processing interventions employed at each of the four processing plants examined.

Fecal shedding of foodborne pathogens by Florida-born heifers and steers in U.S. beef production segments

The objective in this study was to assess breed effects in fecal prevalence of Escherichia coli O157:H7 in heifers on a development program in Florida and in their steer half siblings in stocker and feedlot phases in Oklahoma. A secondary objective was to characterize fecal shedding of Campylobacter and Salmonella in subsets of the same samples. After weaning, heifers (n = 501; purebreds and F1 crosses of Angus, Brahman, and Romosinuano) were preconditioned and placed in a local development program. Steers (n = 481) were transported to Oklahoma, where they grazed wheat for 6 months and then were placed in feedlot pens. Fecal samples were obtained at least every 28 days for 12 months on most animals. None of the 10,982 samples tested positive for E. coli O157:H7. Overall fecal prevalences of Campylobacter and Salmonella in heifers were 1.7 and 0.04%, respectively. Corresponding overall prevalences in steer samples were 27.2 and 0.6%. Campylobacter isolates were mostly C. jejuni and were tetracycline resistant. Eight Salmonella isolates were Salmonella Typhimurium that were either quad or penta resistant, most often to ampicillin, chloramphenicol, sulfamexathole, and tetracycline. Feedlot steers had greater odds of positive detection of Campylobacter (odds ratio, 8.5; confidence interval, 3.7, 19.5) than when grazing winter wheat. No breed effect was detected for fecal prevalence of these pathogens.

Microbiological characterization of lamb carcasses at commercial processing plants in the United States

Although the United States produces 203 million lb (ca. 92.1 kg) of domestic lamb and mutton each year, thorough studies of the microbiological safety during lamb processing are lacking. To address this missing information, a total of 2,548 sponge samples from pelts, preevisceration carcasses, and postintervention carcasses were collected from multiple large commercial lamb processing plants to determine aerobic plate counts, the prevalences of Escherichia coli O157:H7, non-O157 Shiga toxin-producing E. coli (STEC), and Salmonella. The averages of the aerobic plate counts from pelts, the preevisceration carcasses, and the postintervention carcasses were 6.3, 4.4, and 2.4 log CFU/100 cm2, respectively. The prevalences of E. coli O157:H7 from the pelts, the preevisceration carcasses, and the postintervention carcasses were 12.8, 1.6, and 2.9%, respectively. The average Salmonella prevalences were 14.4, 4.3, and 1.8% for pelts, preevisceration carcasses, and postintervention carcasses, respectively. The most frequently identified Salmonella serotype was Heidelberg. The prevalences of non-O157 STEC from pelts, preevisceration carcasses, and postintervention carcasses averaged 86.2, 78.6, and 81.6%, respectively. A total of 488 non-O157 S0TEC strains were isolated from postintervention carcasses. Sixty-nine different serotypes of non-O157 STEC were identified. The most frequently detected serotypes were O91:H14 (40.8%), followed by O5:H19 (18.4%). A small number of STEC serotypes associated with severe human illness were isolated from postintervention carcasses. These were serotypes O76:H19, O128:H2 (0.8%), O146:H8 (2.1%), ) O146:H21, O163:H19, and O174:H8 (1.3%). The results of this study establish a baseline for microbiological quality and prevalences of Salmonella, E. coli O157:H7, and STEC in U.S. lamb processing plants.

Effects of a minimal hide wash cabinet on the levels and prevalence of Escherichia coli O157:H7 and Salmonella on the hides of beef cattle at slaughter

Harborage of Escherichia coli O157:H7 and Salmonella on animal hides at slaughter is the main source of beef carcass contamination during processing. Given this finding, interventions have been designed and implemented to target the hides of cattle following entry into beef processing plants. Previous interventions targeting hides have not been suitable for all beef processing plants because of cost and space restrictions. In this study, a hide wash cabinet was evaluated to determine whether it was more amenable to widespread use in the beef processing industry, especially for small and medium-size plants. Overall, 101 (35.1%) of 288 beef cattle hides sampled before entry into the hide wash cabinet harbored E. coli O157:H7 at or above the limit of detection (40 CFU/100 cm2). After passage through the hide wash cabinet, only 38 (13.2%) of 288 hides had E. coli O157:H7 levels > or =40 CFU/100 cm2. Before the hide wash cabinet, 50 (17%) of 288 hides harbored E. coli O157:H7 at levels above 100 CFU/100 cm2, with one sample as high as 20,000 CFU/100 cm2. In contrast, only 14 (5%) of 288 hides had E. coli O157:H7 levels above 100 CFU/100 cm2 after hide washing, with the highest being 2000 CFU/100 cm2. These same trends also were found for Salmonella before and after hide washing. These results indicate that the hide wash cabinet described in this study was effective and should provide small and medium-size processing plants with an affordable hide wash intervention strategy.

Rapid enrichment strategy for isolation of Listeria from bovine hide, carcass, and meat samples

Since the outbreak of foodborne illness linked to Escherichia coli O157:H7 bacteria in ground beef in the early 1980s, the beef processing industry has focused on increasing the safety of beef products by implementing procedures for surveying live cattle, carcasses, and beef products for bacterial pathogens. Effective methods are in place for screening cattle and beef products for the presence of E. coli O157:H7 contamination, and recent work has established the acceptability of these methods for surveillance of Salmonella. In keeping with the need to continually improve the food safety of beef products, new work investigating pathogen prevalence now includes surveillance for Listeria monocytogenes. Tryptic soy broth (TSB) has been documented as a robust nonselective medium for the enrichment of both E. coli and Salmonella from bovine hide, carcass, and meat samples. The University of Vermont modification medium is most often used as the primary enrichment medium for surveillance of Listeria spp. In this study, samples from bovine hides (n=50), preevisceration carcasses (n=50), and beef trim (n=193) were used to evaluate TSB as a primary enrichment medium for the isolation of Listeria spp., including L. monocytogenes. No significant difference (P > 0.05) between TSB and the University of Vermont modification medium was observed when all three sample types underwent primary enrichment for the isolation of Listeria spp. Furthermore, the standard secondary enrichment ratio for Fraser broth used for Listeria recovery can be modified to accommodate a high-throughput method for processing multiple samples.