Decontamination of beef subprimal cuts intended for blade tenderization or moisture enhancement

Evaluation of Antimicrobial Interventions against E. coli O157:H7 on the Surface of Raw Beef to Reduce Bacterial Translocation during Blade Tenderization

The US Department of Agriculture, Food Safety Inspection Service (USDA-FSIS) considers mechanically-tenderized beef as “non-intact” and a food safety concern because of the potential for translocation of surface Escherichia coli O157:H7 into the interior of the meat that may be cooked “rare or medium-rare” and consumed. We evaluated 14 potential spray interventions on E. coli O157:H7-inoculated lean beef wafers (~10⁶ CFU/cm², n = 896) passing through a spray system (18 s dwell time, ~40 pounds per square inch, PSI) integrated into the front end of a Ross TC-700MC tenderizer. Inoculated and processed beef wafers were stomached with D/E neutralizing broth and plated immediately, or were held in refrigerated storage for 1-, 7-, or 14-days prior to microbial enumeration. Seven antimicrobials that showed better performance in preliminary screening on beef wafers were selected for further testing on beef subprimals in conjunction with blade tenderization. Boneless top sirloin beef subprimals were inoculated at ~2 × 10⁴ CFU/cm² with a four-strain cocktail of E. coli O157:H7 and passed once, lean side up, through an integrated spray system and blade tenderizer. Core samples obtained from each subprimal were examined for the presence/absence of E. coli O157:H7. The absence of E. coli O157:H7 in core samples correlated with the ability of the antimicrobials to reduce bacterial levels on the surface of beef prior to blade tenderization.

Inactivation of Escherichia coli O157:H7 in Minute Steaks Cooked under Selected Conditions

A national survey was conducted in Canada to determine consumer cooking practices for minute steaks (thin, mechanically tenderized beef cutlets). Results indicate that most Canadians prefer cooking minute steaks by pan frying and to a medium level of doneness. To identify safe cooking conditions, retail minute steaks (∼125 g), inoculated at three sites per steak with a five-strain cocktail of nontoxigenic Escherichia coli O157:H7 (6.1 log CFU per site), were cooked on a hot plate (200°C), mimicking a pan-frying scenario. The steaks (n = 5) were cooked for 4, 6, 8, or 10 min with turning over (flipping) up to four times at equal time intervals; or to 63 or 71°C at the thickest area with or without a tinfoil lid. When cooked for 4 min, E. coli O157:H7 was recovered from all inoculation sites, and the mean reductions at various sites (1.2 to 3.4 log CFU per site) were not different (P > 0.05), irrespective of the flipping frequency. When cooked for 6 min with flipping once or twice, or for 8 min with flipping once, E. coli O157:H7 was recovered from most sites; the mean reductions (3.8 to 5.3 log CFU per site) were not different (P > 0.05), but they were higher (P < 0.05) than those for steaks cooked for 4 min. When cooked for 10, 8, or 6 min with flipping once, twice, or three times, respectively, E. coli O157:H7 was eliminated from most sites, but sites with <5-log reductions were found. Reductions of E. coli O157:H7 by >5 log at all inoculation sites were attained when the steaks were cooked for 10 or 8 min with two or more or three or more flippings, respectively, or for 6 min with four flippings. When flipped twice during cooking to 63 or 71°C, E. coli O157:H7 was recovered from three or fewer sites; however, >5-log reductions throughout the steaks were only attained for the latter temperature, irrespective of whether the hot plate was covered with the tinfoil lid. Thus, turning over minute steaks twice during cooking to 71°C or flipping two, three, or four times with a cooking time of 10, 8, or 6 min could achieve 5-log reductions throughout the steaks.

Use of an Electrostatic Spraying System or the Sprayed Lethality in Container Method To Deliver Antimicrobial Agents onto the Surface of Beef Subprimals To Control Shiga Toxin-Producing Escherichia coli

The efficacy of an electrostatic spraying system (ESS) and/or the sprayed lethality in container (SLIC) method to deliver antimicrobial agents onto the surface of beef subprimals to reduce levels of Shiga toxin-producing Escherichia coli (STEC) was evaluated. Beef subprimals were surface inoculated (lean side; ca. 5.8 log CFU per subprimal) with 2 mL of an eight-strain cocktail comprising single strains of rifampin-resistant (100 μg/mL) STEC (O26:H11, O45:H2, O103:H2, O104:H4, O111:H^-, O121:H19, O145:NM, and O157:H7). Next, inoculated subprimals were surface treated with lauric arginate (LAE; 1%), peroxyacetic acid (PAA; 0.025%), or cetylpyridinium chloride (CPC; 0.4%) by passing each subprimal, with the inoculated lean side facing upward, through an ESS cabinet or via SLIC. Subprimals were then vacuum packaged and stored at 4°C. One set of subprimals was sampled after an additional 2 h, 3 days, or 7 days of refrigerated storage, whereas another set was retreated via SLIC after 3 days of storage with a different one of the three antimicrobial agents (e.g., a subprimal treated with LAE on day 0 was then treated with PAA or CPE on day 3). Retreated subprimals were sampled after 2 h or 4 days of additional storage at 4°C. A single initial application of LAE, PAA, or CPC via ESS or SLIC resulted in STEC reductions of ca. 0.3 to 1.3 log CFU per subprimal after 7 days of storage. However, when subprimals were initially treated with LAE, PAA, or CPC via ESS or SLIC and then separately retreated with a different one of these antimicrobial agents via SLIC on day 3, additional STEC reductions of 0.4 to 1.0 log CFU per subprimal were observed after an additional 4 days of storage. Application of LAE, PAA, or CPC, either alone or in combination, via ESS or SLIC is effective for reducing low levels (ca. 0.3 to 1.6 log CFU) of STEC that may be naturally present on the surface of beef subprimals.

Meta-analysis on the effect of interventions used in cattle processing plants to reduce Escherichia coli contamination

Cattle coming from feedlots to slaughter often harbor pathogenic E. coli that can contaminate final meat products. As a result, reducing pathogenic contamination during processing is a main priority. Unfortunately, food safety specialists face challenges when trying to determine optimal intervention strategies from published literature. Plant intervention literature results and methods vary significantly, making it difficult to implement interventions with any degree of certainty in their effectiveness. To create a more robust understanding of plant intervention effectiveness, a formal systematic literature review and meta-analysis was conducted on popular intervention methods. Effect size or intervention effectiveness was measured as raw log reduction, and modeled using study characteristics, such as intervention type, temperature of application, initial microbial concentration, etc. Least-squares means were calculated for intervention effectiveness separately on hide and on carcass surfaces. Heterogeneity between studies (I²) was assessed and factors influencing intervention effectiveness were identified. Least-squares mean reductions (log CFU/cm²) on carcass surfaces (n=249) were 1.44 [95% CI: 0.73-2.15] for acetic acid, 2.07 [1.48-2.65] for lactic acid, 3.09 [2.46-3.73] for steam vacuum, and 1.90 [1.33-2.47] for water wash. On hide surfaces (n=47), least-squares mean reductions were 2.21 [1.36-3.05] for acetic acid, 3.02 [2.16-3.88] for lactic acid, 3.66 [2.60-4.72] for sodium hydroxide, and 0.08 [-0.94-1.11] for water wash. Meta-regressions showed that initial microbial concentrations and timing of extra water washes were the most important predictors of intervention effectiveness. Unexplained variation remained high in carcass, hide, and lactic acid meta-regressions, suggesting that other significant moderators are yet to be identified. The results will allow plant managers and risk assessors to evaluate plant interventions, variation, and factors more effectively.

Effects of Plant-Derived Extracts, Other Antimicrobials, and Their Combinations against Escherichia coli O157:H7 in Beef Systems

The antimicrobial effects of thyme oil (TO), grapefruit seed extract (GSE), and basil essential oil, alone or in combination with cetylpyridinium chloride (CPC), sodium diacetate, or lactic acid, were evaluated against Escherichia coli O157:H7 in a moisture-enhanced beef model system. The model system was composed of a nonsterile beef homogenate to which NaCl (0.5%) and sodium tripolyphosphate (0.25%) were added, together with the tested antimicrobial ingredients. Beef homogenate treatments were inoculated (ca. 3 log CFU/ml) with rifampin-resistant E. coli O157:H7 (eight-strain mixture) and incubated at 15 °C (48 h). The most effective individual treatments were TO (0.25 or 0.5%) and GSE (0.5 or 1.0%), which immediately reduced (P < 0.05) pathogen levels by ≥ 3.4 log CFU/ml. Additionally, CPC (0.04%) reduced initial E. coli O157:H7 counts by 2.7 log CFU/ml. Most combinations of the tested plant-derived extracts with CPC (0.02 or 0.04%) and sodium diacetate (0.25%) had an additive effect with respect to antibacterial activity. In a second study, antimicrobial interventions were evaluated for their efficacy in reducing surface contamination of E. coli O157:H7 on beef cuts and to determine the effect of these surface treatments on subsequent internalization of the pathogen during blade tenderization. Beef cuts (10 by 8 by 3.5 cm) were inoculated (ca. 4 log CFU/g) on one side with the rifampin-resistant E. coli O157:H7 strain mixture and were then spray treated (20 lb/in(2), 10 s) with water, GSE (5 and 10%), lactic acid (5%), or CPC (5%). Untreated (control) and spray-treated surfaces were then subjected to double-pass blade tenderization. Surface contamination (4.4 log CFU/g) of E. coli O157:H7 was reduced (P < 0.05) to 3.4 (5% CPC) to 4.1 (water or 5% GSE) log CFU/g following spray treatment. The highest and lowest transfer rates of pathogen cells from the surface to deeper tissues of blade-tenderized sections were obtained in the untreated control and CPC-treated samples, respectively.

Reduction of Surrogates for Escherichia coli O157:H7 and Salmonella during the Production of Nonintact Beef Products by Chemical Antimicrobial Interventions

The efficacy of chemical antimicrobials for controlling Escherichia coli O157:H7 and Salmonella during production of marinated nonintact beef products was evaluated using nonpathogenic surrogates. Boneless beef strip loins were inoculated with either approximately 5.8 or 1.9 log CFU/cm(2) (high and low inoculation levels, respectively) of nonpathogenic rifampin-resistant E. coli. Inoculated strip loins were chilled at 2°C for 24 h, vacuum packaged, and aged for 7 to 24 days at 2°C. After aging, strip loins received no treatment (control) or one of five antimicrobial spray treatments: 2.5% L-lactic acid (pH 2.6), 5.0% L-lactic acid (pH 2.4), 1,050 ppm of acidified sodium chlorite (pH 2.8), 205 ppm of peroxyacetic acid (pH 5.2), or tap water (pH 8.6). Mean application temperatures were 53, 26, 20, and 18°C for lactic acid, water, peroxyacetic acid, and acidified sodium chlorite treatments, respectively. Treated and control strip loins were vacuum tumbled in a commercial marinade. Samples were collected throughout the experiment to track the effects of antimicrobial treatment and processing on inoculated surrogates. For high-inoculation strip loins, the 5.0% L-lactic acid treatment was most effective for reducing surrogates on meat surfaces before marination, producing a 2.6-log mean reduction. Peroxyacetic acid treatment resulted in the greatest reduction of surface-located surrogate microorganisms in marinated product. Water treatment resulted in greater internalization of surrogate microorganisms compared with the control, as determined by enumeration of surrogates from cored samples. Producers of nonintact beef products should focus on use of validated antimicrobial sprays that maximize microbial reduction and minimize internalization of surface bacteria into the finished product.

A review of factors that affect transmission and survival of verocytotoxigenic Escherichia coli in the European farm to fork beef chain

Verocytotoxigenic Escherichia coli (VTEC) are a significant foodborne public health hazard in Europe, where most human infections are associated with six serogroups (O157, O26, O103, O145, O111 and O104). With the exception of O104, these serogroups are associated with bovine animals and beef products. This paper reviews our current knowledge of VTEC in the beef chain focusing on transmission and the factors which impact on survival from the farm through transport, lairage, slaughter, dressing, processing and distribution, in the context of the European beef industry. It provides new information on beef farm and animal hide prevalence, distribution and virulence factors as well as pre-chilled carcass and ground beef prevalence, generated by the recently completed EU Framework research project, ProSafeBeef. In the concluding section, emerging issues and data gaps are addressed with a view to increasing our understanding of this pathogen and developing new thinking on detection and control.

Survival of Shiga toxin-producing Escherichia coli and Stx bacteriophages in moisture enhanced beef

Moisture enhancement of meat through injection is a technology to improve the sensory properties and the weight of meat. However, the technology may increase the risk of food borne infections. Shiga toxin-producing Escherichia coli (STEC) or bacteriophages carrying cytotoxin genes (Shiga toxin genes, stx), which is normally only present on the surface of intact beef, may be transferred to the inner parts of the muscle during the injection process. Pathogens and bacteriophages surviving the storage period may not be eliminated in the cooking process since many consumers prefer undercooked beef. Measures to increase the microbial food safety of moisture enhanced beef may include sterilization or washing of the outer surface of the meat before injection, avoiding recycling of marinade and addition of antimicrobial agents to the marinade. This paper reviews the literature regarding microbial safety of moisture enhanced beef with special emphasis on STEC and Stx bacteriophages. Also, results from a European Union research project, ProSafeBeef (Food-CT-16 2006-36241) are presented.

Survivability of Escherichia coli O157:H7 in mechanically tenderized beef steaks subjected to lactic acid application and cooking under simulated industry conditions

Mechanical tenderization improves the palatability of beef; however, it increases the risk of translocating pathogenic bacteria to the interior of beef cuts. This study investigated the efficacies of lactic acid spray (LA; 5 % ), storage, and cooking on the survivability of Escherichia coli O157:H7 in mechanically tenderized beef steaks managed under simulated industry conditions. Beef subprimals inoculated with either high (10(5) CFU/ml) or low (10(3) CFU/ml) levels of E. coli O157:H7 were treated (LA or control) and stored for 21 days prior to mechanical tenderization, steak portioning (2.54 cm), and additional storage for 7 days. Steaks were then cooked to an internal temperature of 55, 60, 65, 70, or 75°C. Samples were enumerated and analyzed using DNA-based methods. Treatment with LA immediately reduced E. coli O157:H7 on the lean and fat surfaces of high- and low-inoculum-treated subprimals by more than 1.0 log CFU/cm(2) (P < 0.05). Storage for 21 days reduced surface populations of E. coli O157:H7 regardless of the inoculation level; however, the populations on LA- and control-treated lean surfaces of high- and low-inoculum-treated subprimals were not different after 21 days (P > 0.05). E. coli O157:H7 was detected in core samples from high-inoculum-treated steaks cooked to 55, 60, or 70°C. Conversely, E. coli O157:H7 was not detected in core samples from low-inoculum-treated steaks, regardless of the internal cooking temperature. These data suggest that LA- and storage-mediated reduction of pathogens on subprimals exposed to typical industry contamination levels (10(1) CFU/cm(2)) reduces the risk of pathogen translocation and subsequent survival after cooking.

Sensitivity of Shiga toxin-producing Escherichia coli, multidrug-resistant Salmonella, and antibiotic-susceptible Salmonella to lactic acid on inoculated beef trimmings

Studies were performed to determine whether lactic acid treatments used to reduce Escherichia coli O157:H7 on beef trimmings are also effective in controlling non-O157 Shiga toxin-producing E. coli (nSTEC), and multidrug-resistant and antibiotic-susceptible Salmonella. Beef trimming pieces (10 by 5 by 1 cm) were inoculated (3 log CFU/cm(2)) separately with four-strain mixtures of rifampin-resistant E. coli O157:H7, O26, O45, O103, O111, O121, and O145. Similarly, in a second study, trimmings were separately inoculated with rifampin-resistant E. coli O157:H7, and antibiotic-susceptible or multidrug-resistant (MDR and/or MDR-AmpC) Salmonella Newport and Salmonella Typhimurium. Inoculated trimmings were left untreated (control) or were immersed for 30 s in 5% lactic acid solutions (25 or 55°C). No differences (P ≥ 0.05) were obtained among surviving counts of E. coli O157:H7 and those of the tested nSTEC serogroups on lactic acid-treated (25 or 55°C) samples. Counts (3.1 to 3.3 log CFU/cm(2)) of E. coli O157:H7 and nSTEC were reduced (P < 0.05) by 0.5 to 0.9 (25°C lactic acid) and 1.0 to 1.4 (55°C lactic acid) log CFU/cm(2). Surviving counts of Salmonella on treated trimmings were not influenced by serotype or antibiotic resistance phenotype and were similar (P ≥ 0.05) or lower (P < 0.05) than surviving counts of E. coli O157:H7. Counts (3.0 to 3.3 log CFU/cm(2)) were reduced (P < 0.05) by 0.5 to 0.8 (E. coli O157:H7) and 1.3 to 1.5 (Salmonella) log CFU/cm(2) after treatment of samples with 25°C lactic acid. Corresponding reductions following treatment with lactic acid at 55°C were 1.2 to 1.5 (E. coli O157:H7) and 1.6 to 1.9 (Salmonella) log CFU/cm(2). Overall, the results indicated that lactic acid treatments used against E. coli O157:H7 on beef trimmings should be similarly or more effective against the six nSTEC serogroups and against multidrug-resistant and antibiotic-susceptible Salmonella Newport and Salmonella Typhimurium.

Evaluation of Lactic Acid as an Initial and Secondary Subprimal Intervention for Escherichia coli O157:H7, Non-O157 Shiga Toxin–Producing E. coli, and a Nonpathogenic E. coli Surrogate for E. coli O157:H7

Lactic acid can reduce microbial contamination on beef carcass surfaces when used as a food safety intervention, but effectiveness when applied to the surface of chilled beef subprimal sections is not well documented. Studies characterizing bacterial reduction on subprimals after lactic acid treatment would be useful for validations of hazard analysis critical control point (HACCP) systems. The objective of this study was to validate initial use of lactic acid as a subprimal intervention during beef fabrication followed by a secondary application to vacuum-packaged product that was applied at industry operating parameters. Chilled beef subprimal sections (100 cm2) were either left uninoculated or were inoculated with 6 log CFU/cm2 of a 5-strain mixture of Escherichia coli O157:H7, a 12-strain mixture of non-O157 Shiga toxin–producing E. coli (STEC), or a 5-strain mixture of nonpathogenic (biotype I) E. coli that are considered surrogates for E. coli O157:H7. Uninoculated and inoculated subprimal sections received only an initial or an initial and a second “rework” application of lactic acid in a custom-built spray cabinet at 1 of 16 application parameters. After the initial spray, total inoculum counts were reduced from 6.0 log CFU/cm2 to 3.6, 4.4, and 4.4 log CFU/cm2 for the E. coli surrogates, E. coli O157:H7, and non-O157 STEC inoculation groups, respectively. After the second (rework) application, total inoculum counts were 2.6, 3.2, and 3.6 log CFU/cm2 for the E. coli surrogates, E. coli O157:H7, and non-O157 STEC inoculation groups, respectively. Both the initial and secondary lactic acid treatments effectively reduced counts of pathogenic and nonpathogenic strains of E. coli and natural microflora on beef subprimals. These data will be useful to the meat industry as part of the HACCP validation process.

Dispersion and survival of Escherichia coli O157:H7 and Salmonella Typhimurium during the production of marinated beef inside skirt steaks and tri-tip roasts

To determine the depth of pathogen dispersion and the ability of pathogens to survive in enhanced beef products and spent marinade, beef inside skirt steaks and tri-tip roasts were vacuum tumbled with two commercial marinades. The marinades were inoculated with Escherichia coli O157:H7 and Salmonella Typhimurium, resulting in an approximate count of 5.2 log CFU/ml. Both inside skirt steaks and tri-tip roasts were vacuum tumbled for 1 h and sampled immediately after tumbling (day 0), or were vacuum packaged, stored (ca. 4°C), and sampled on days 7 and 14. Samples of the spent marinade were taken after tumbling (day 0) and on days 3 and 7. For both marinades, Salmonella Typhimurium and E. coli O157:H7 were dispersed throughout the inside skirt steaks during vacuum tumbling. Although Salmonella Typhimurium and E. coli O157:H7 for the skirt steaks were still detectable after 14 days of storage, the log values were lower than those on days 0 and 7. For the tri-tip roasts, the pathogen distribution varied, depending on the thickness of the roasts, and pathogens were detectable on days 0, 7, and 14. The spent marinade sampled on days 0, 3, and 7 showed that the pathogens survived at refrigerated temperatures. Because pathogens can transfer to the interior of beef inside skirt steaks and tri-tip roasts when vacuum tumbled with contaminated marinade and survived during refrigerated storage, establishments should consider the potential food safety risks associated with reuse of marinade during the production of vacuum-tumbled beef products.

Effect of sodium citrate plus sodium diacetate or buffered vinegar on quality attributes of enhanced beef top sirloins

As new pathogen intervention products come to market, it is important to ensure that they maintain or improve meat quality. Shelf-life and palatability traits were measured for top sirloins enhanced to 110% with solutions containing 0.5% sodium chloride and 0.4% sodium tripolyphosphate (CNT); CNT with a 1% solution of 80% sodium citrate plus 20% sodium diacetate (SC+D); or CNT with 2% buffered vinegar (VIN) in the final product. Enhancement solution did not influence color over 7days of retail display, except VIN was subjectively more red than CNT and SC+D on d 7 and SC+D had less discoloration than CNT on d 7 (P<0.05). VIN was rated lower (P<0.05) than CNT for trained sensory tenderness and there was no difference in shear force between treatments. SC+D and VIN show promise for use in beef enhancement solutions, however, further sensory studies are warranted.

Evaluation of Escherichia coli O157:H7 translocation and decontamination for beef vacuum-packaged subprimals destined for nonintact use

The translocation of Escherichia coli O157:H7 as well as the impact of water washing and partial or complete surface trimming as possible pathogen reduction strategies were evaluated for vacuum-packaged beef subprimals destined for nonintact use. Cap-on and cap-off beef top sirloin butts were inoculated with two levels of E. coli O157:H7: a high-inoculum level of approximately 10(4) CFU/cm(2) and a low-inoculum level of approximately 10(2) CFU/cm(2). Following inoculation, the subprimals were vacuum packaged and stored for 0, 14, or 28 days. Upon removal from storage, the following sites were evaluated: exterior of the bag, purge, the inoculation site on the subprimal, the area adjacent to the inoculation site, and the surface opposite from the inoculation site. The following treatments then were applied: water wash, water wash followed by full-surface trimming, water wash followed by partial-surface trimming, full-surface trimming, full-surface trimming followed by water wash, partial-surface trimming, and partial-surface trimming followed by water wash. For both high- and low-inoculated top sirloin butts, contamination of adjacent and opposite surfaces was found after vacuum packaging. Of the treatments applied, water washing alone was the least effective for both high- and low-inoculated subprimals. Full trimming, with or without a water wash, proved to be the most effective treatment used to reduce E. coli O157:H7 to nondetectable levels.

Inactivation of Shiga toxin-producing O157:H7 and non-O157:H7 Shiga toxin-producing Escherichia coli in brine-injected, gas-grilled steaks

We quantified translocation of Escherichia coli O157:H7 (ECOH) and non-O157:H7 verocytotoxigenic E. coli (STEC) into beef subprimals after brine injection and subsequently monitored their viability after cooking steaks cut therefrom. Beef subprimals were inoculated on the lean side with ca. 6.0 log CFU/g of a five-strain cocktail of rifampin-resistant ECOH or kanamycin-resistant STEC, and then passed once through an automatic brine-injector tenderizer, with the lean side facing upward. Brine solutions (9.9% ± 0.3% over fresh weight) consisted of 3.3% (wt/vol) of sodium tripolyphosphate and 3.3% (wt/vol) of sodium chloride, prepared both with (Lac(+), pH = 6.76) and without (Lac(-), pH = 8.02) a 25% (vol/vol) solution of a 60% potassium lactate-sodium diacetate syrup. For all samples injected with Lac(-) or Lac(+) brine, levels of ECOH or STEC recovered from the topmost 1 cm (i.e., segment 1) of a core sample obtained from tenderized subprimals ranged from ca. 4.7 to 6.3 log CFU/g; however, it was possible to recover ECOH or STEC from all six segments of all cores tested. Next, brine-injected steaks from tenderized subprimals were cooked on a commercial open-flame gas grill to internal endpoint temperatures of either 37.8 °C (100 °F), 48.8 °C (120 °F), 60 °C (140 °F), or 71.1 °C (160 °F). Regardless of brine formulation or temperature, cooking achieved reductions (expressed as log CFU per gram) of 0.3 to 4.1 of ECOH and 0.5 to 3.6 of STEC. However, fortuitous survivors were recovered even at 71.1 °C (160 °F) for ECOH and for STEC. Thus, ECOH and STEC behaved similarly, relative to translocation and thermal destruction: Tenderization via brine injection transferred both pathogens throughout subprimals and cooking highly contaminated, brine-injected steaks on a commercial gas grill at 71.1 °C (160 °F) did not kill all cells due, primarily, to nonuniform heating (i.e., cold spots) within the meat.

Effects of sodium citrate plus sodium diacetate and buffered vinegar on Escherichia coli O157:H7 and psychrotrophic bacteria in brine-injected beef

The objective of this research was to examine the effects of sodium citrate plus sodium diacetate or buffered vinegar on Escherichia coli O157:H7 and psychrotrophic bacteria when incorporated in brine solutions for injected beef. Two experiments were conducted in which 30 top rounds and 30 top sirloins were injected (110%) to contain (i) 0.5% sodium chloride and 0.4% sodium tripolyphosphate as the control (CNT); (ii) CNT with a 1% solution of 80% sodium citrate plus 20% sodium diacetate (SC + D); or (iii) CNT with 2% buffered vinegar (VIN) in the final product. For the E. coli challenge, muscles were surface inoculated to target 6 log CFU/cm(2). After injection and 10 days of storage in a vacuum package (4°C), one half of each muscle was sampled raw and the other half was cooked to an internal temperature of 60°C with a 12-min hold. For raw samples, a significant reduction of 0.6 and 1.0 log CFU/g of E. coli O157:H7 was observed in both SC + D- and VIN-injected top rounds and sirloins, respectively. All cooked samples were E. coli O157:H7 negative. For psychrotrophic analysis, subprimals were injected and vacuum packaged for 10 days at 0 ± 1°C. After 10 days of storage, steaks were fabricated and placed in aerobic display (4 ± 1°C) for 1, 7, 14, and 21 days. Psychrotrophic organism growth was restricted in SC + D and VIN samples when compared with CNT on all days except day 1. Sodium citrate plus sodium diacetate or buffered vinegar may improve the safety and shelf life of multineedle brine-injected beef.

Overview of current meat hygiene and safety risks and summary of recent studies on biofilms, and control of Escherichia coli O157:H7 in nonintact, and Listeria monocytogenes in ready-to-eat, meat products

As meat consumption is increasing around the world, so do concerns and challenges to meat hygiene and safety. These concerns are mostly of a biological nature and include bacterial pathogens, such as Escherichia coli O157:H7, Salmonella and Campylobacter in raw meat and poultry, and Listeria monocytogenes in ready-to-eat processed products, while viral pathogens are of major concern at foodservice. A major goal of scientists, industry, public health and regulatory authorities is to control pathogenic microorganisms and improve meat product hygiene and safety within a country and internationally. This paper is not a comprehensive or critical review of the scientific literature on the broad area of meat hygiene and safety, but it provides an overview of major current meat hygiene and safety issues, and then a summary of studies on biofilm formation by pathogens, control of E. coli O157:H7 in nonintact meat products, and control of L. monocytogenes in ready-to-eat meat products, conducted at the Center for Meat Safety & Quality and Food Safety Cluster of Colorado State University in recent years.

Validation of a lactic acid- and citric acid-based antimicrobial product for the reduction of Escherichia coli O157: H7 and Salmonella on beef tips and whole chicken carcasses

The objectives of this study were to determine the effects of a lactic acid- and citric acid-based antimicrobial product on the reduction of Salmonella on whole broiler carcasses during processing and the reduction of Salmonella and Escherichia coli O157:H7 on beef trim. Freshly harvested broiler carcasses were inoculated with an inoculum of Salmonella strains to yield a 10(5) CFU/ml pathogen load on the surface of the carcass. The beef tips were inoculated as well with an inoculum of either E. coli O157:H7 or Salmonella to yield 10(4) CFU/100 cm(2). After 30 min for attachment, the broiler carcasses were treated with Chicxide applied for 5 s via a spray or immersed in Chicxide for 5, 10, or 20 s. Broiler carcasses were rinsed in poultry rinse bags with 400 ml of Butterfield's phosphate buffer in which Salmonella was enumerated from the diluents and Butterfield's phosphate. Chicxide significantly reduced Salmonella by 1.3 log CFU/ml with spray treatment and 2.3 log CFU/ml for all dip treatments. Following 30 min of attachment, the beef tips were placed into a spray cabinet with either Beefxide or sterilized water (control) and sprayed at 1 ft/2.5 s chain speed at 40 lb/in(2). The external surface of each beef tip was swabbed (100 cm(2)) to determine pathogen loads. Beefxide significantly reduced E. coli O157:H7 by 1.4 log CFU/100 cm(2) and Salmonella by 1.1 log CFU/100 cm(2) (P < 0.05) compared with the control samples.

Effects on the microbiological condition of product of decontaminating treatments routinely applied to carcasses at beef packing plants

Reports on the microbiological effects of decontaminating treatments routinely applied to carcasses at beef packing plants indicate that washing before skinning may reduce the numbers of enteric bacteria transferred from the hide to meat. Washing skinned carcasses and/or dressed sides can reduce the numbers of aerobes and Escherichia coli by about 1 log unit, and pasteurizing sides with steam or hot water can reduce their numbers by > 1 or > 2 log units, respectively. Spraying with 2% lactic acid, 2% acetic acid, or 200 ppm of peroxyacetic acid can reduce the numbers of aerobes and E. coli by about 1 log, but such treatments can be ineffective if solutions are applied in inadequate quantities or to meat surfaces that are wet after washing. Trimming and vacuum cleaning with or without spraying with hot water may be largely ineffective for improving the microbiological conditions of carcasses. When contamination of meat during carcass dressing is well controlled and carcasses are subjected to effective decontaminating treatments, the numbers of E. coli on dressed carcasses can be < 1 CFU/ 1,000 cm2. However, meat can be recontaminated during carcass breaking with E. coli from detritus that persists in fixed and personal equipment. The adoption at all packing plants of the carcass-dressing procedures and decontaminating treatments used at some plants to obtain carcasses that meet a very high microbiological standard should be encouraged, and means for limiting recontamination of product during carcass breaking and for decontaminating trimmings and other beef products should be considered.

Translocation of surface-inoculated Escherichia coli O157:H7 into beef subprimals following blade tenderization

In phase I, beef subprimals were inoculated on the lean side with ca. 0.5 to 3.5 log CFU/g of a rifampin-resistant (rifr) cocktail of Escherichia coli O157:H7 and passed once, lean side up, through a mechanical blade tenderizer. Inoculated subprimals that were not tenderized served as controls. Ten core samples were removed from each subprimal and cut into six consecutive segments: segments 1 to 4 comprised the top 4 cm and segments 5 and 6 the deepest 4 cm. Levels of E. coli O157:H7 recovered from segment 1 of control subprimals when inoculated with ca. 0.5, 1.5, 2.5, or 3.5 log CFU/g were 0.6, 1.46, 2.5, and 3.19 log CFU/g, respectively. Following tenderization, pathogen levels recovered from segment 1 inoculated with 0.5 to 3.5 log CFU/g were 0.22, 1.06, 2.04, and 2.7 log CFU/g, respectively. Levels recovered in segment 2 were 7- to 34-fold lower than levels recovered from segment 1. Next, in phase II, the translocation of ca. 4 log CFU of the pathogen per g was assessed for lean-side-inoculated subprimals passed either once (LS) or twice (LD) through the tenderizer and for fat-side-inoculated subprimals passed either once (FS) or twice (FD) through the tenderizer. Levels in segment 1 for LS, LD, FS, and FD tenderized subprimals were 3.63, 3.52, 2.85, and 3.55 log CFU/g, respectively. The levels recovered in segment 2 were 14- to 50-fold lower than levels recovered in segment 1 for LS, LD, FS, and FD subprimals. Thus, blade tenderization transfers E. coli O157:H7 primarily into the topmost 1 cm, but also into the deeper tissues of beef subprimals.

Thermal inactivation of Escherichia coli O157:H7 in beef treated with marination and tenderization ingredients

Internalization of Escherichia coli O157:H7 in nonintact beef products during mechanical tenderization or during injection of marination and tenderization ingredients is of concern if such products are undercooked. This study tested organic acids (0.2% citric acid and 0.3% acetic acid), potassium and calcium salts (1.8% potassium lactate, 0.63% calcium lactate, 0.86% calcium ascorbate, and 0.23% calcium chloride), and sodium chloride (2.5%) for their influence on thermal destruction of E. coli O157:H7 in ground beef serving as a model system. Ground beef batches (700 g; 5% fat) were mixed with equal volumes (22 ml) of each treatment solution or distilled water and portions (30 g) of treated ground beef were extruded in test tubes (2.5 by 10 cm). A five-strain mixture of E. coli O157:H7 (0.3 ml; 7 log CFU/g) was introduced at the center of the sample with a pipette. After overnight storage (4 degrees C), simulating product marination, samples were heated to 60 or 65 degrees C internal temperature, simulating rare and medium rare doneness of beef, in a circulating water bath. At 65 degrees C, treatments with citric and acetic acid showed greater (P < 0.05) reduction (4 to 5 log CFU/g) of E. coli O157:H7 than all the other ingredients and the control (3 to 4 log CFU/g). Sodium chloride reduced weight losses (16 to 18% compared with 20 to 27% by citric or acetic acid) and resulted in a 4-log reduction in counts during cooking to 65 degrees C. Ingredients such as citric or acetic acid may improve thermal inactivation of E. coli O157:H7 internalized in nonintact beef products, while sodium chloride may reduce cooking losses in such products.