Effect of external dead volume on performance while wearing a respirator

Respirator dead volume accumulates exhaled carbon dioxide and returns it to the respiratory system during subsequent inhalations. Because inhaled carbon dioxide is known to be a powerful respiratory stimulant and psychoactive gas, respirator dead volume would be expected to influence performance times while respirators are worn during work. This experiment was performed at intense levels of treadmill walking (80-85% VO2max) to demonstrate maximum sensitivity to respiratory stress. Six dead volume conditions (representing a range of 280 to 1,160 mL) were imposed on the subjects. Results show linear decreases in performance times and breathing apparatus comfort with increasing dead volumes. For each 350 mL of external dead volume, a 19% decrease of performance time and an 18% decrease in breathing apparatus comfort can be expected.

Communication using a telephone while wearing a respirator

Respirators have been found to degrade communication effectiveness when wearers speak face-to-face. However, little is known about communication effectiveness when using the telephone and wearing a respirator. Eleven pairs of subjects were asked to pronounce and identify words chosen from Modified Rhyme Test lists. Each word appeared on a computer screen in one room and the speaker said the word into the telephone. The listener in another room identified the word and typed it into a computer linked with the first. Subjects wore U.S. Army M40 full-facepiece air-purifying respirators with hoods. Three different speech diaphragm arrangements and two hood materials were tested. Results show that accuracy suffered by about 10% when respirators and hoods were worn compared with the control condition. Word identification speed was one-third to one-half of the control (no respirator or hood) condition depending on specific equipment worn.

Effect of respirator inspiratory resistance level on constant load treadmill work performance

Respirator inspiratory resistance can affect performance times, especially when the experiment is optimized to elicit respiratory stress. Twelve subjects performed on a treadmill at constant speeds and grades chosen to result in performance times of 5-15 min. Six levels of inspiratory resistance were used, ranging from 0.78 to 7.64 cm H2O.sec/L. The results showed that performance times decrease linearly with resistance level, and no threshold resistance value is apparent. Inspiratory resistance also induces hypoventilation, with lower minute volumes and lower oxygen consumption values at higher resistances. These trends are also linear. From these results, there is no value for inspiratory resistance that can be given as a design goal. Other parameters such as weight and space may dictate filter resistance values, and these, in turn, will lead to determined performance degradations.

Sweat rate inside a full-facepiece respirator

The accumulation of sweat inside a full-facepiece respirator mask and the rise in facial skin temperature can be important factors for acceptability of respirators worn in the heat. This study questioned how much sweat would have to be removed from a respirator (if a design to remove accumulated sweat were possible). Results from 20 subjects sitting in a warm, humid environment (35 degrees C and 90% relative humidity) for 90 minutes indicated that the average value was about 0.203 g sweat/min from the face, head, and neck, with most of that coming from the neck region. Men were found to have higher sweating rates than women. The results indicate that a large amount of sweat could accumulate inside the mask over a typical 8-hour day. Average facial skin temperature was found to rise about 2 degrees C over the 90-minutes test, and this rise could likely be the cause of the very uncomfortable rating given to the respirator.

Effect of altered vision on constant load exercise performance while wearing a respirator

Previous testing has shown that visual acuity greatly influences task performance at light work rate levels. At moderate to heavy work rates, however, the Performance Rating Table (PRT) predicts almost no visual acuity effect. This experiment was performed to determine if the PRT value is realistic. Ten subjects walked on a treadmill at 75-80% of their maximum heart rates until their voluntary end points. Subjects wore various masks of the same kind, each with a different set of clouded lenses. Visual acuities, as measured on the Snellen eye chart, were measured before, during, and after exercise. It was found that visual acuity did not influence performance time, and that an average value for a performance rating of 91 must have been influenced by other mask factors besides visual acuity. These other factors are most likely respiratory stress, thermal stress, and other vision elements. The full-facepiece masks used in this study adversely affected visual acuity by about three-quarters of a Snellen line during exercise. Postexercise visual acuities were found to first decrease below pre-exercise values, then become better than pre-exercise values, then decline asymptotically to pre-exercise values.