Effects of limited enzymatic hydrolysis with pepsin and high-pressure homogenization on the functional properties of soybean protein isolate

High-Pressure Homogenization Pretreatment before Enzymolysis of Soy Protein Isolate: the Effect of Pressure Level on Aggregation and Structural Conformations of the Protein

The high-pressure homogenization (HPH) treatment of soybean protein isolate (SPI) before enzymatic hydrolysis using bromelain was investigated. Homogenization pressure and cycle effects were evaluated on the enzymatic degree of hydrolysis and the antioxidant activity of the hydrolysates generated. The antioxidant activity of SPI hydrolysates was analyzed by 1,1-dipheny-2-picrylhydrazyl (DPPH). The sizes and structures of the SPI-soluble aggregate after HPH treatment were analyzed using dynamic and static laser light scattering. The changes in the secondary structure, as measured by Fourier transform infrared spectroscopy (FTIR) and the macromorphology of SPI, were measured by scanning electron microscope (SEM). These results suggested that the HPH treatment (66.65%) could increase the antioxidant activities of the SPI hydrolysates compared with the control (54.18%). SPI hydrolysates treated at 20 MPa for four cycles obtained higher DPPH radical-scavenging activity than other samples. The control was predicted to be a hard sphere, and SPI treatment at 10 MPa was speculated to be Gaussian coil, polydisperse, and then the high-pressure treated SPI became a hollow sphere. Changes in the secondary structures showed protein aggregate formation and rearrangements. The image of SPI varied from a globular to a clump structure, as observed by the SEM. In conclusion, combining HPH treatment and enzymolysis could be an effective way to improve the antioxidant activity of the SPI.

Effect of high intensity ultrasound on structure and foaming properties of pea protein isolate

The effects of high intensity ultrasound (HIUS, 20 kHz, at varying amplitude 30%, 60%, 90% for 30 min) on structure and foaming properties of pea protein isolate (PPI) were investigated. No significant change was observed from the electrophoresis profiles and circular dichroism (CD) spectrum. Analyses of fluorescence spectroscopy and the amount of free sulfhydryl groups showed that HIUS induced protein molecular partial unfolding. Furthermore, HIUS decreased particle size of PPI and increased exposed hydrophobicity, resulting in a reduction of the surface tension at the air-water interface. Therefore, the foaming ability of PPI increased from 145.6% to 200.0%. The foaming stability increased from 58.0% to 73.3% with the increasing amplitude after 10 min though all reduced to 50.0% with the extension of time. That suggested that HIUS treatment has a potential to be implemented to modify foaming properties of PPI.

Effects of High-Pressure Homogenization at Different Pressures on Structure and Functional Properties of Oyster Protein Isolates

Oyster protein isolate (OPI) suspensions (6.19 % ± 0.82 %, w/v) were treated by high-pressure homogenization (HPH) at 0 (control), 20, 40, 60, 80 or 100 MPa for three cycles. Protein profiles, secondary structure, free sulfhydryl, surface hydrophobicity, particle size distribution, zeta-potential, solubility, water and oil holding capacity (OHC), emulsifying and foaming properties of the obtained suspensions were analyzed. The results showed that HPH treatment did not cause changes in protein profiles of OPI, but caused changes in secondary structure, content of α-helix decreased but content of β-turn and random coil increased significantly (P < 0.05). Free sulfhydryl and surface hydrophobicity all increased significantly (P < 0.05) after HPH treatment, indicating that tertiary and quaternary structures changed. Functional properties of OPI significantly (P < 0.05) improved after HPH treatment, such as zeta-potential (from −12.67 to −33.57 mV), solubility (from 20.24 % to 57.99 %), OHC (from 981.77 % to 1229.40 %), foaming ability (from 17.50 % to 35.00 %), foaming stability (from 44.49 % to 66.60 %), emulsifying activity index (from 8.87 to 17.06 m2/g) and emulsion stability index (from 14.65 to 41.68 min). At 60 MPa and 80 MPa, the improvements were more remarkable. However, HPH treatment significantly (P < 0.05) decreased particle size (from 200–500 nm to 0–200 nm) and water holding capacity (from 341.15 % to 216.96 %). These improvements were closely related to structural changes and reduction of particle size. Application of different pressures affected functional properties of OPI. These results could provide information for determining HPH applying condition in OPI modification.

Effects of Limited Hydrolysis and High-Pressure Homogenization on Functional Properties of Oyster Protein Isolates

In this study, the effects of limited hydrolysis and/or high-pressure homogenization (HPH) treatment in acid conditions on the functional properties of oyster protein isolates (OPI) were studied. Protein solubility, surface hydrophobicity, particle size distribution, zeta potential, foaming, and emulsifying properties were evaluated. The results showed that acid treatment led to the dissociation and unfolding of OPI. Subsequent treatment such as limited proteolysis, HPH, and their combination remarkably improved the functional properties of OPI. Acid treatment produced flexible aggregates, as well as reduced particle size and solubility. On the contrary, limited hydrolysis increased the solubility of OPI. Furthermore, HPH enhanced the effectiveness of the above treatments. The emulsifying and foaming properties of acid- or hydrolysis-treated OPI significantly improved. In conclusion, a combination of acid treatment, limited proteolysis, and HPH improved the functional properties of OPI. The improvements in the functional properties of OPI could potentiate the use of oyster protein and its hydrolysates in the food industry.

Formation of macromolecules in wheat gluten/starch mixtures during twin-screw extrusion: effect of different additives

BACKGROUND

Wheat gluten comprises a good quality and inexpensive vegetable protein with an ideal amino acid composition. To expand the potential application of wheat gluten in the food industry, the effect of different additives on the physicochemical and structural properties of wheat gluten/starch mixtures during twin-screw extrusion was investigated.

RESULTS

Macromolecules were observed to form in wheat gluten/starch mixtures during twin-screw extrusion, which may be attributed to the formation of new disulfide bonds and non-covalent interactions, as well as Maillard reaction products. Additionally, the water retention capacity and in vitro protein digestibility of all extruded wheat gluten/starch products significantly increased, whereas the nitrogen solubility index and free sulfhydryl group (SH) content decreased, during twin-screw extrusion. Secondary structural analysis showed that α-helices disappeared with the concomitant increase of antiparallel β-sheets, demonstrating the occurrence of protein aggregation. Microstructures suggested that the irregular wheat gluten granular structure was disrupted, with additive addition favoring transformation into a more layered or fibrous structure during twin-screw extrusion.

CONCLUSION

The findings of the present study demonstrate that extrusion might affect the texture and quality of extruded wheat gluten-based foods and suggest that this process might serve as a basis for the high-value application of wheat gluten products. © 2017 Society of Chemical Industry.

Germination-Assisted Enzymatic Hydrolysis Can Improve the Quality of Soybean Protein

This study aimed to investigate the effects of combined germination and Alcalase hydrolysis on the quality of soybean protein. Protein profiles, water solubility, foaming and emulsifying properties, thixotropic properties, and in vitro protein digestibility (IVPD) were tested, the chemical score (CS), essential amino acid index (EAAI), and protein efficiency ratio (PER) of soybean protein were also defined. The combined treatment of germination and Alcalase hydrolysis remarkably improved the solubility, emulsification activity index, emulsion stability index, and foaming capacity of soybean protein. Notably, a decrease in foaming stability was detected. The electrophoretic profile showed a weak breakdown of soybean protein during germination. However, a strong breakdown of protein was observed after the hydrolysis with Alcalase. The combined treatment also decreased the CS and EAAI of soybean protein, but only by 18%. Meanwhile, the IVPD and PER of soybean protein were significantly improved. Moreover, the protein of the germinated and hydrolyzed soybean flour demonstrated better swallowing properties. These findings indicated that the combined treatment of germination and enzymatic hydrolysis can improve the quality of soybean protein.

Landmarks in the historical development of twenty first century food processing technologies

Over a course of centuries, various food processing technologies have been explored and implemented to provide safe, fresher-tasting and nutritive food products. Among these technologies, application of emerging food processes (e.g., cold plasma, pressurized fluids, pulsed electric fields, ohmic heating, radiofrequency electric fields, ultrasonics and megasonics, high hydrostatic pressure, high pressure homogenization, hyperbaric storage, and negative pressure cavitation extraction) have attracted much attention in the past decades. This is because, compared to their conventional counterparts, novel food processes allow a significant reduction in the overall processing times with savings in energy consumption, while ensuring food safety, and ample benefits for the industry. Noteworthily, industry and university teams have made extensive efforts for the development of novel technologies, with sound scientific knowledge of their effects on different food materials. The main objective of this review is to provide a historical account of the extensive efforts and inventions in the field of emerging food processing technologies since their inception to present day.

Comparison of nutritional components (isoflavone, protein, oil, and fatty acid) and antioxidant properties at the growth stage of different parts of soybean [Glycine max (L.) Merrill]

This is the first study to investigate antioxidant capacities of isoflavones prepared using microwave-assisted hydrolysis method from different parts (seeds, leaves, leafstalks, pods, stems and roots) of soybean at growth stages. In addition, the fluctuations in the isoflavone, protein, fatty acid, and oil contents in R6-R8 (R6: beginning; R7: beginning maturity; R8: full maturity) seeds were confirmed. The R7 seeds exhibited the most predominant contents of isoflavones (1218.1±7.3 μg/g) in the following order: daidzein (48%)>genistein (35%)>glycitein (17%). The second highest isoflavone content was found in the leaves (1052.1±10.4 μg/g), followed by R8 seeds>roots>R6 seeds>leafstalks> pods; the stems exhibited the lowest isoflavone content (57.2±1.7 μg/g). Interestingly, daidzein showed the highest individual isoflavone content with remarkable variations (57.2-766.8 μg/g), representing 46-100% of the total isoflavone content. R8 exhibited higher protein, fatty acid, and oil contents than R6 or R7. Moreover, the antioxidant capacities against two radicals in different parts of soybean plant showed considerable differences depending upon the isoflavone content. Our results suggested that soybean leaves and seeds might be useful materials for functional foods.

Protein functionality of concentrates prepared from yellowfin tuna (Thunnus albacares) roe by cook-dried process

Three kinds of roe protein concentrates (RPCs: boil-dried concentrate, BDC; steam-dried concentrate, SDC; freeze-dried concentrate, FDC) were prepared from yellowfin tuna to produce value added products for food applications. The buffer capacities of the RPCs were higher under alkaline than under acidic conditions. The water holding capacities of the RPCs were in range 4.5-4.7 g/g protein at pH 6.0. The protein solubility of the FDC (14.2%) was higher than those of the BDC (5.4%) and SDC (5.5%) at pH 6.0. The foaming capacity of the FDC (156.8%) was higher than those of the BDC (109.7%) and SDC (109.4%); the FDC foam was stable for 60 min. The oil-in-water emulsifying activity index of the FDC (12.2m2/g protein) exceeded those of the BDC and SDC (2.2m2/g protein). Protein concentrates from yellowfin tuna roe may be useful as a potential protein source and as a high-value food ingredient.

Enzymatic hydrolysis of anchovy fine powder at high and ambient pressure, and characterization of the hydrolyzates

BACKGROUND

At specific conditions of high pressure, the stability and activity of some enzymes are reportedly known to increase. The aim of this study was to apply pressure-tolerant proteases to hydrolyzing anchovy fine powder (AFP) and to determine product characteristics of the resultant hydrolyzates.

RESULTS

Anchovy fine powder enzyme hydrolyzates (AFPEHs) were produced at 300 MPa and ambient pressure using combinations of Flavourzyme 500MG, Alcalase 2.4L, Marugoto E and Protamex. When the same protease combination was used for hydrolysis, the contents of total soluble solids, total water-soluble nitrogen and trichloroacetic acid-soluble nitrogen in the AFPEHs produced at 300 MPa were conspicuously higher than those in the AFPEHs produced at ambient pressure. This result and electrophoretic characteristics indicated that the high-pressure process of this study accelerates protein hydrolysis compared with the ambient-pressure counterpart. Most peptides in the hydrolyzates obtained at 300 MPa had molecular masses less than 5 kDa. Functionality, sensory characteristics and the content of total free amino acids of selected hydrolyzates were also determined.

CONCLUSION

The high-pressure hydrolytic process utilizing pressure-tolerant proteases was found to be an efficient method for producing protein hydrolyzates with good product characteristics.

Changes occurring in compositions and antioxidant properties of healthy soybean seeds [Glycine max (L.) Merr.] and soybean seeds diseased by Phomopsis longicolla and Cercospora kikuchii fungal pathogens

Changes in the compositions (isoflavone, protein, oil, and fatty acid) and antioxidant properties were evaluated in healthy soybeans and soybeans diseased by Phomopsis longicolla and Cercospora kikuchii. The total isoflavone content (1491.3 μg/g) of healthy seeds was observed to be considerably different than that of diseased seeds (P. longicolla: 292.6, C. kikuchii: 727.2 μg/g), with malonlygenistin exhibiting the greatest decrease (726.1 → 57.1, 351.9 μg/g). Significantly, three isoflavones exhibited a slight increase, and their structures were confirmed as daidzein, glycitein, and genistein, based on their molecular ions at m/z 253.1, 283.0, and 269.1 using the negative mode of HPLC-DAD-ESI/MS. The remaining compositions showed slight variations. The effects against 2,2-diphenyl-1-picrylhydrazyl and 2,2'-azino-bis(3-ethylbenzthiazoline-6-sulphonic acid) radicals in healthy seeds were stronger than the diseased soybeans, depending upon the isoflavone level. Our results may be useful in evaluating the relationship between composition and antioxidant activity as a result of changes caused by soybean fungal pathogens.

Functional properties and structure changes of soybean protein isolate after subcritical water treatment

Subcritical water is an emerging method in food industry. In this study, soybean protein isolate (SPI) was treated by subcritical water (SBW) at various temperatures (0, 120, 160, 200 °C) for 20 min. The changes in the appearances, physicochemical properties and structural changes were investigated. After SBW treatment, the color of SPI solution modified turned to be yellow. The mean particle size and turbidity of SPI had similar behaviors. The mean particle size was decreased from 263.7 nm to 116.8 nm at 120 °C and then reached the maximum at 160 °C (1446.1 nm) due to the aggregation of protein. Then it was decreased to 722.9 nm at 200 °C caused by the protein degradation. SBW treatment could significantly enhance the solubility, emulsifying and foaming properties of SPI. With increasing temperature, the crystalline structure of protein was gradually collapsed. The degradation of the protein advanced structure occurred, especially at 200 °C revealed by ultra-high resolution mass spectrometry. Better functional properties exhibited in hydrolysis products indicating that SBW treatment could be used as a good method to modify the properties of soy proteins isolate for specific purposes under appropriate treatment condition.

Structural and Gel Textural Properties of Soy Protein Isolate When Subjected to Extreme Acid pH-Shifting and Mild Heating Processes

Changes in the structural and gel textural properties were investigated in soy protein isolate (SPI) that was subjected to extreme acid pH-shifting and mild heating processes. The SPI was incubated up to 5 h in pH 1.5 solutions at room temperature or in a heated water bath (50 or 60 °C) to lead to protein structural unfolding, followed by refolding at pH 7.0 for 1 h. The combination of pH-shifting and heating treatments resulted in drastic increases in the SPI gel penetration force (p < 0.05). These treatments also significantly enforced the conversion of sulphydryl groups into disulfides, increased the particle size and hydrophobicity values, reduced the protein solubility (p < 0.05), and strengthened the disulfide-mediated aggregation of SPI. The intrinsic fluorescence spectroscopy results indicated structural unravelling when protein was subjected to acidic pH-shifting in combination with heating processes. The slight loss of secondary structure was observed by circular dichroism. These results suggested that pH-shifting combined with heating treatments provide great potential for the production of functionality-improved SPI, with the improved gelling property highly related to changes in the protein structure and hydrophobic aggregation.

Comparative study of the functional properties of three legume seed isolates: adzuki, pea and soy bean

The aim of this work was to compare functional properties including solubility, emulsifying and foaming properties of native and thermally treated adzuki, soy and pea protein isolates prepared under the same conditions. These functional properties were tested at four pH values: pH 3.0, pH 5.0, pH 7.0 and pH 8.0. The lowest solubility at all pH values were obtained for isolate of adzuki whereas isolates of soybean had the highest values at almost all pHs. Thermal treatment reduced solubility of soy and pea isolates at all pH values, whereas solubility of adzuki isolate was unchanged, except at pH 8. Native isolate of adzuki had the best emulsifying properties at pH 7.0 whereas at the other pH values some of native pea and soybean protein isolates were superior. After thermal treatment, depending on tested pH and selected variety all of three species could be a good emulsifier. Native soy protein isolates formed the most stable foams at all pHs. Thermal treatment significantly improved foaming properties of adzuki isolate, whereas reduced foaming capacity of soy and pea isolates, but could improve foam stability of these isolates at specific pH. Appropriate selection of legume seed as well as variety could have great importance in achievement of desirable functional properties of final products. All three tested species could find specific application in wide range of food products.

Effect of pH and pepsin limited hydrolysis on the structure and functional properties of soybean protein hydrolysates

Effects of limited enzymatic hydrolysis with pepsin on the functional properties and structure characteristics of soybean proteins were investigated. Hydrolysates with different incubation time (10 to 900 min) were prepared. Results showed that SPI hydrolyzed for 60 min exhibited the best emulsibility and the ability of resisting freezing/thawing. Sodium dodecyl sulfate-polyacrylamide gel electrophoresis proved that pepsin can degrade glycinin but had little effect on the α' subunit of β-conglycinin. The structure unfolding reached the largest extent after incubation for 60 min and the soluble and flexible aggregates were formed. After 120 min, glycinin was degraded totally and β-conglycinin formed insoluble aggregates. Moreover, 2 methods were applied for the deactivation of pepsin to obtain final hydrolysates at pH 2.0 and 7.0, respectively. The structure analysis revealed that the unfolding extent and structure characteristic were different in these 2 conditions. When adjusting the pH value from 2.0 to 7.0, the unfolding protein molecular would reaggregate again at pH 7.0 due to the charge neutralization, and the hydrodynamic diameter and λmax absorbance decreased compared to pH 2.0. Moreover, some of the insoluble aggregates formed at pH 2.0 became soluble at pH 7.0, because of the salt-in phenomenon.