51
|
Kim SJ, Park WT, Uddin MR, Kim YB, Nam SY, Jho KH, Park SU. Glucosinolate Biosynthesis in Hairy Root Cultures of Broccoli (Brassica oleracea var. italica). Nat Prod Commun 2013. [DOI: 10.1177/1934578x1300800222] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022] Open
Abstract
Here we present previously unreported glucosinolate production by hairy root cultures of broccoli (B. oleracea var. italica). Growth media greatly influenced the growth and glucosinolate content of hairy root cultures of broccoli. Seven glucosinolates, glucoraphanin, gluconapin, glucoerucin, glucobrassicin, 4- methoxyglucobrassicin, gluconasturtiin, and neoglucobrassicin, were identified by analysis of the broccoli hairy root cultures. Both half and full strength B5 and SH media enabled the highest accumulation of glucosinolates. In most cases, the levels of glucosinolates were higher in SH and BS media. Among the 7 glucosinolates, the accumulation of neoglucobrassicin was very high, irrespective of growth medium. The neoglucobrassicin content was 7.4-fold higher in SH medium than 1/2 MS, in which its level was the lowest. The 1/2 B5 medium supported the production of the highest amounts of glucobrassicin and 4- methoxyglucobrassicin, the levels for which were 36.2- and 7.9- fold higher, respectively, than their lowest content in 1/2 MS medium. The 1/2 SH medium enabled the highest accumulation of glucoraphanin and gluconapin in the broccoli hairy root cultures, whose levels were 1.8- and 4.6-fold higher, respectively, than their lowest content in 1/2 MS medium. Our results suggest that hairy root cultures of broccoli could be a valuable alternative approach for the production of glucosinolate compounds.
Collapse
Affiliation(s)
- Sun-Ju Kim
- Department of Bio-Environmental Chemistry, Chungnam National University, 99 Daehak-ro, Yuseong-Gu, Daejeon 305-764, Republic of Korea
| | - Woo Tae Park
- Department of Crop Science, Chungnam National University, 99 Daehak-Ro, Yuseong-Gu, Daejeon 305-764, Republic of Korea
| | - Md. Romij Uddin
- Department of Crop Science, Chungnam National University, 99 Daehak-Ro, Yuseong-Gu, Daejeon 305-764, Republic of Korea
| | - Yeon Bok Kim
- Department of Crop Science, Chungnam National University, 99 Daehak-Ro, Yuseong-Gu, Daejeon 305-764, Republic of Korea
| | - Sang-Yong Nam
- Department of Horticulture, Sahmyook University, Hwarangro 815, Nowon-gu, Seoul 139-742, Republic of Korea
| | - Kwang Hyun Jho
- Department of Business Administration, Sahmyook University, Hwarangro 815, Nowon-gu, Seoul 139-742, Republic of Korea
| | - Sang Un Park
- Department of Crop Science, Chungnam National University, 99 Daehak-Ro, Yuseong-Gu, Daejeon 305-764, Republic of Korea
| |
Collapse
|
52
|
Production of pharmaceutical proteins in solanaceae food crops. Int J Mol Sci 2013; 14:2753-73. [PMID: 23434646 PMCID: PMC3588013 DOI: 10.3390/ijms14022753] [Citation(s) in RCA: 24] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/03/2012] [Revised: 01/11/2013] [Accepted: 01/22/2013] [Indexed: 12/13/2022] Open
Abstract
The benefits of increased safety and cost-effectiveness make vegetable crops appropriate systems for the production and delivery of pharmaceutical proteins. In particular, Solanaceae edible crops could be inexpensive biofactories for oral vaccines and other pharmaceutical proteins that can be ingested as minimally processed extracts or as partially purified products. The field of crop plant biotechnology is advancing rapidly due to novel developments in genetic and genomic tools being made available today for the scientific community. In this review, we briefly summarize data now available regarding genomic resources for the Solanaceae family. In addition, we describe novel strategies developed for the expression of foreign proteins in vegetable crops and the utilization of these techniques to manufacture pharmaceutical proteins.
Collapse
|
53
|
Swain SS, Rout KK, Chand PK. Production of triterpenoid anti-cancer compound taraxerol in Agrobacterium-transformed root cultures of butterfly pea (Clitoria ternatea L.). Appl Biochem Biotechnol 2012; 168:487-503. [PMID: 22843061 DOI: 10.1007/s12010-012-9791-8] [Citation(s) in RCA: 23] [Impact Index Per Article: 1.9] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/17/2012] [Accepted: 07/03/2012] [Indexed: 10/28/2022]
Abstract
Independent transformed root somaclones (rhizoclones) of butterfly pea (Clitoria ternatea L.) were established using explant co-cultivation with Agrobacterium rhizogenes. Rhizoclones capable of sustained growth were maintained under low illumination in auxin-free agar-solidified MS medium through subcultures at periodic intervals. Integration of T(L)-DNA rolB gene in the transformed rhizoclone genome was verified by Southern blot hybridization, and the transcript expression of T(R)-DNA ags and man2 genes was ascertained by reverse transcription polymerase chain reaction analysis. The major compound isolated and purified from the transformed root extracts was identified as the pentacyclic triterpenoid compound taraxerol using IR, (1)H-NMR, and (13)C-NMR spectroscopy. The taraxerol yield in cultured hairy roots, as quantified by HPTLC analysis, was up to 4-fold on dry weight basis compared to that in natural roots. Scanning of bands from cultured transformed roots and natural roots gave super-imposable spectra with standard taraxerol, suggesting a remarkable homology in composition. To date, this is the first report claiming production of the cancer therapeutic phytochemical taraxerol in genetically transformed root cultures as a viable alternative to in vivo roots of naturally occurring plant species.
Collapse
Affiliation(s)
- Swasti S Swain
- Plant Cell and Tissue Culture Facility, Post-Graduate Department of Botany, Utkal University, Vani Vihar, Bhubaneswar 751 004 Odisha, India
| | | | | |
Collapse
|
54
|
Green factory: Plants as bioproduction platforms for recombinant proteins. Biotechnol Adv 2012; 30:1171-84. [DOI: 10.1016/j.biotechadv.2011.08.020] [Citation(s) in RCA: 132] [Impact Index Per Article: 11.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/08/2011] [Revised: 08/24/2011] [Accepted: 08/30/2011] [Indexed: 12/15/2022]
|
55
|
Georgiev MI, Agostini E, Ludwig-Müller J, Xu J. Genetically transformed roots: from plant disease to biotechnological resource. Trends Biotechnol 2012; 30:528-37. [PMID: 22906523 DOI: 10.1016/j.tibtech.2012.07.001] [Citation(s) in RCA: 89] [Impact Index Per Article: 7.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/29/2012] [Revised: 06/27/2012] [Accepted: 07/02/2012] [Indexed: 12/24/2022]
Abstract
Hairy root syndrome is a disease that is induced by Agrobacterium rhizogenes infection and characterized by a proliferation of excessively branching roots. However, in the past 30 years A. rhizogenes-mediated transformation has also provided a valuable platform for studying biosynthesis pathways in plants. Furthermore, the genetically transformed root cultures are becoming increasingly attractive, cost-effective options for mass-producing desired plant metabolites and expressing foreign proteins. Numerous proof-of-concept studies have demonstrated the feasibility of scaling up hairy-root-based processes while maintaining their biosynthetic potential. Recently, hairy roots have also shown immense potential for applications in phytoremediation, that is, plant-based decontamination of polluted environments. This review highlights recent progress and limitations in the field, and outlines future perspectives for the industrial exploitation of hairy roots.
Collapse
Affiliation(s)
- Milen I Georgiev
- Department of Applied Biotechnologies, Institute of Microbiology, Bulgarian Academy of Sciences, 139 Ruski Boulevard, 4000 Plovdiv, Bulgaria.
| | | | | | | |
Collapse
|
56
|
Nopo L, Woffenden BJ, Reed DG, Buswell S, Zhang C, Medina-Bolivar F. Super-promoter:TEV, a powerful gene expression system for tobacco hairy roots. Methods Mol Biol 2012; 824:501-26. [PMID: 22160917 DOI: 10.1007/978-1-61779-433-9_27] [Citation(s) in RCA: 12] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/24/2023]
Abstract
In order to identify a promoter system for high-level expression of transgenes in hairy roots, we characterized the chimeric super-promoter fused to the translational enhancer from tobacco etch virus (TEV). Transgenic tobacco plants and hairy roots were generated with the super-promoter:TEV sequence and a modified green fluorescence protein (mGFP5) as a reporter gene. To exploit the utility of hairy root cultures as a secretion-based expression system, the signal peptide of patatin was fused to mGFP5 to direct its secretion into the culture medium. Levels of mGFP5 RNA were on average sixfold higher in hairy roots than leaves. Likewise, GFP protein levels per gram of fresh weight were at least tenfold higher in hairy roots than leaves. Furthermore, more than 10% of the recombinant protein produced in the hairy root culture system was found in the medium. Immunoblotting with anti-GFP antibodies showed two products of 27.1 and 29.9 kDa in all leaf and hairy root tissue extracts, whereas a single 27.1-kDa product was detected in the medium. Inducibility of the promoter was studied with mature leaves and 14-day (midlog phase) hairy roots. A twofold increase in mRNA levels was found immediately after wounding in both mature leaves and hairy roots, with a corresponding increase in mGFP5 protein after 24 h. Our studies demonstrate the utility of the super-promoter:TEV system for high-level expression of recombinant proteins in hairy root bioreactors.
Collapse
Affiliation(s)
- Luis Nopo
- Arkansas Biosciences Institute, Arkansas State University, Jonesboro, AR, USA
| | | | | | | | | | | |
Collapse
|
57
|
Zalabák D, Pospíšilová H, Šmehilová M, Mrízová K, Frébort I, Galuszka P. Genetic engineering of cytokinin metabolism: prospective way to improve agricultural traits of crop plants. Biotechnol Adv 2011; 31:97-117. [PMID: 22198203 DOI: 10.1016/j.biotechadv.2011.12.003] [Citation(s) in RCA: 50] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/15/2011] [Accepted: 12/02/2011] [Indexed: 01/02/2023]
Abstract
Cytokinins (CKs) are ubiquitous phytohormones that participate in development, morphogenesis and many physiological processes throughout plant kingdom. In higher plants, mutants and transgenic cells and tissues with altered activity of CK metabolic enzymes or perception machinery, have highlighted their crucial involvement in different agriculturally important traits, such as productivity, increased tolerance to various stresses and overall plant morphology. Furthermore, recent precise metabolomic analyses have elucidated the specific occurrence and distinct functions of different CK types in various plant species. Thus, smooth manipulation of active CK levels in a spatial and temporal way could be a very potent tool for plant biotechnology in the future. This review summarises recent advances in cytokinin research ranging from transgenic alteration of CK biosynthetic, degradation and glucosylation activities and CK perception to detailed elucidation of molecular processes, in which CKs work as a trigger in model plants. The first attempts to improve the quality of crop plants, focused on cereals are discussed, together with proposed mechanism of action of the responses involved.
Collapse
Affiliation(s)
- David Zalabák
- Department of Molecular Biology, Centre of the Region Haná for Biotechnological and Agricultural Research, Palacký University, Šlechtitelů 11, 783 71 Olomouc, Czech Republic.
| | | | | | | | | | | |
Collapse
|
58
|
Chandra S. Natural plant genetic engineer Agrobacterium rhizogenes: role of T-DNA in plant secondary metabolism. Biotechnol Lett 2011; 34:407-15. [DOI: 10.1007/s10529-011-0785-3] [Citation(s) in RCA: 108] [Impact Index Per Article: 8.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/25/2011] [Accepted: 10/18/2011] [Indexed: 11/24/2022]
|
59
|
Hairy roots cultures from different Solanaceous species have varying capacities to produce E. coli B-subunit heat-labile toxin antigen. Biotechnol Lett 2011; 33:2495-502. [PMID: 21786173 DOI: 10.1007/s10529-011-0710-9] [Citation(s) in RCA: 16] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/20/2011] [Accepted: 07/15/2011] [Indexed: 10/18/2022]
Abstract
The gene encoding enterotoxigenic Escherichia coli B-subunit heat-labile toxin (LTB) antigen was co-transformed into hairy root cultures of Nicotiana tabacum (tobacco), Solanum lycopersicum (tomato) and Petunia parodii (petunia) under the CaMV35S promoter. Tobacco and petunia roots contained ~65-70 μg LTB g(-1) tissue whilst hairy roots of tomato contained ~10 μg LTB g(-1). Antigen at ~600 ng ml(-1) was detected in growth medium of tobacco and petunia. Tobacco roots with higher LTB levels showed growth retardation of ~80% whereas petunia hairy roots with similar levels of LTB showed only ~35% growth retardation, relative to vector controls. Regeneration of plants from LTB-containing tobacco hairy roots was readily achieved and re-initiated hairy roots from greenhouse-grown plants showed similar growth and LTB production characteristics as the original hairy root cultures.
Collapse
|
60
|
Makhzoum A, Petit-Paly G, St Pierre B, Bernards MA. Functional analysis of the DAT gene promoter using transient Catharanthus roseus and stable Nicotiana tabacum transformation systems. PLANT CELL REPORTS 2011; 30:1173-82. [PMID: 21308469 DOI: 10.1007/s00299-011-1025-y] [Citation(s) in RCA: 13] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/20/2010] [Revised: 01/18/2011] [Accepted: 01/24/2011] [Indexed: 05/23/2023]
Abstract
The Catharanthus roseus DAT gene encodes the enzyme acetyl-CoA:deacetylvindoline-4-O-acetyltransferase involved in the last step of the indole alkaloid pathway leading to vindoline. This gene is characterized by specific cell type expression in idioblasts and laticifers. To understand the specific transcriptional regulation mechanism(s) of DAT, several DAT promoter GUS constructs were cloned into pCAMBIA1305.1. Agroinfiltration of different explant types of C. roseus resulted in organ-specific accumulation of GUS, albeit at various levels. Heterologous accumulation of GUS in transgenic tobacco revealed both general and non-specific expression with the exception of a stomata-specific expression when 2.3 kb of the DAT promoter was coupled with a portion of the DAT ORF. These results suggest that in addition to the 2.3 kb upstream of the DAT transcriptional start site, additional cis-acting elements may be responsible for the specific spatial expression of DAT in vivo. Furthermore, hairy roots transformed with DAT promoter GUS constructs demonstrated GUS expression in root tissues (visualized through GUS enzyme activity), even though DAT is repressed in non-transformed roots.
Collapse
Affiliation(s)
- Abdullah Makhzoum
- Department of Biology and The Biotron, The University of Western Ontario, London, ON, Canada.
| | | | | | | |
Collapse
|
61
|
Pollier J, Morreel K, Geelen D, Goossens A. Metabolite profiling of triterpene saponins in Medicago truncatula hairy roots by liquid chromatography Fourier transform ion cyclotron resonance mass spectrometry. JOURNAL OF NATURAL PRODUCTS 2011; 74:1462-76. [PMID: 21615146 DOI: 10.1021/np200218r] [Citation(s) in RCA: 45] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/21/2023]
Abstract
Triterpenes are one of the largest classes of plant natural products, with an enormous variety in structure and bioactivities. Here, triterpene saponins from hairy roots of the model legume Medicago truncatula were profiled with reversed-phase liquid chromatography coupled to negative-ion electrospray ionization Fourier transform ion cyclotron resonance mass spectrometry (LC ESI FT-ICR MS). Owing to the accuracy of the FT-ICR MS, reliable molecular formulas of the detected compounds could be predicted, which, together with the generated MS(n) spectra, allowed the tentative identification of 79 different saponins, of which 61 had not been detected previously in M. truncatula. Upon collision-induced dissociation of saponins that contain a uronic acid residue in the sugar chain, fragment ions resulting from cross-ring cleavages of the uronic acid residues were observed. The identified saponins are glycosides of 10 different sapogenins, of which three were not detected before in M. truncatula. Zanhic acid glycosides, which are prevalent in the aerial parts of M. truncatula, were absent in the hairy root extracts. This metabolite compendium will facilitate future functional genomic studies of triterpene saponin biosynthesis in M. truncatula.
Collapse
Affiliation(s)
- Jacob Pollier
- Department of Plant Systems Biology, VIB, B-9052 Gent, Belgium
| | | | | | | |
Collapse
|
62
|
Echium acanthocarpum hairy root cultures, a suitable system for polyunsaturated fatty acid studies and production. BMC Biotechnol 2011; 11:42. [PMID: 21524311 PMCID: PMC3114721 DOI: 10.1186/1472-6750-11-42] [Citation(s) in RCA: 15] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/17/2010] [Accepted: 04/27/2011] [Indexed: 12/01/2022] Open
Abstract
Background The therapeutic and health promoting role of highly unsaturated fatty acids (HUFAs) from fish, i.e. eicosapentaenoic acid (EPA, 20:5n-3) and docosahexaenoic acid (DHA, 22:6n-3) are well known. These same benefits may however be shared by some of their precursors, the polyunsaturated fatty acids (PUFAs), such as stearidonic acid (SDA, 18:4 n-3). In order to obtain alternative sources for the large-scale production of PUFAs, new searches are being conducted focusing on higher plants oils which can contain these n-3 and n-6 C18 precursors, i.e. SDA and GLA (18:3n-6, γ-linolenic acid). Results The establishment of the novel Echium acanthocarpum hairy root cultures represents a powerful tool in order to research the accumulation and metabolism of fatty acids (FAs) in a plant particularly rich in GLA and SDA. Furthermore, this study constitutes the first example of a Boraginaceae species hairy root induction and establishment for FA studies and production. The dominant PUFAs, 18:2n-6 (LA, linoleic acid) and 18:3n-6 (GLA), accounted for about 50% of total FAs obtained, while the n-3 PUFAs, 18:3n-3 (ALA, α-linolenic acid) and 18:4n-3 (SDA), represented approximately 5% of the total. Production of FAs did not parallel hairy root growth, and the optimal productivity was always associated with the highest biomass density during the culture period. Assuming a compromise between FA production and hairy root biomass, it was determined that sampling times 4 and 5 gave the most useful FA yields. Total lipid amounts were in general comparable between the different hairy root lines (29.75 and 60.95 mg/g DW), with the major lipid classes being triacylglycerols. The FAs were chiefly stored in the hairy roots with very minute amounts being released into the liquid nutrient medium. Conclusions The novel results presented here show the utility and high potential of E. acanthocarpum hairy roots. They are capable of biosynthesizing and accumulating a large range of polyunsaturated FAs, including the target GLA and SDA fatty acids in appreciable quantities.
Collapse
|
63
|
Abstract
Cyclotides are disulfide-rich miniproteins with a circular backbone and a knotted arrangement ofdisulfide bonds. Because these plant-derived peptides are resistant to degradation and exhibit a diverse range of bioactivity they have become important agronomic and industrial objectives. They belong to a group of compounds with low market volume and high price that are poorly processed by microorganisms, are too complex for economic chemical synthesis, and thus are valuable candidates for the synthesis in plant cell bioprocesses. This review highlights current research aimed at production routes of cyclotides in Oldenlandia affinis plantlets and cell cultures, and summarizes recent advances in bioprocessing aspects, with particular emphasis on the development of suitable bioreactor configurations for plant cell culture-based processes, the optimization of culture environments as a powerful means to improve yields, bioreactor operational modes, and trends in protein recovery.
Collapse
Affiliation(s)
- Heike Dörnenburg
- Institute of Bioprocess Engineering, University of Erlangen-Nuremberg, Paul-Gordan-Str. 3, 91052 Erlangen, Germany.
| |
Collapse
|
64
|
Production and metabolic engineering of bioactive substances in plant hairy root culture. Appl Microbiol Biotechnol 2011; 90:1229-39. [DOI: 10.1007/s00253-011-3228-0] [Citation(s) in RCA: 58] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/14/2011] [Revised: 02/27/2011] [Accepted: 02/28/2011] [Indexed: 02/05/2023]
|
65
|
Ono NN, Tian L. The multiplicity of hairy root cultures: prolific possibilities. PLANT SCIENCE : AN INTERNATIONAL JOURNAL OF EXPERIMENTAL PLANT BIOLOGY 2011; 180:439-446. [PMID: 21421390 DOI: 10.1016/j.plantsci.2010.11.012] [Citation(s) in RCA: 94] [Impact Index Per Article: 7.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 10/11/2010] [Revised: 11/24/2010] [Accepted: 11/25/2010] [Indexed: 05/28/2023]
Abstract
Hairy root cultures (HRCs), induced by Agrobacterium rhizogenes infection, have been established from a wide variety of plant species. HRCs accumulate phytochemicals to levels comparable to that of intact plants and are usually stable in their biosynthetic capacity. When optimized for liquid cultures, hairy roots can be grown in industrial-scale bioreactors providing a convenient, abundant and sustainable source of phytochemicals. Due to their ease of propagation and growth in confined environments, HRCs have also been used in recent years in the synthesis of recombinant therapeutic proteins, especially those that have been challenging to express in bacteria, yeast and mammalian expression systems. Although phytochemicals are recognized for their important roles in plant and human health, large gaps still exist in understanding how phytochemicals (in particular, secondary/specialized metabolites) are synthesized in plants. This review presents recent developments and findings in phytochemical and recombinant protein production, as well as new revelations in gene discovery and biochemical pathway elucidation, by the utilization of HRCs. Although many challenges still exist for industrial applications of HRCs, the immediate future of this diverse system, especially for the bench-side scientists, is still found to be promising and abounding in possibilities.
Collapse
Affiliation(s)
- Nadia N Ono
- Department of Plant Sciences, University of California, Davis, CA, USA
| | | |
Collapse
|
66
|
Sivakumar G, Liu C, Towler MJ, Weathers PJ. Biomass production of hairy roots of Artemisia annua and Arachis hypogaea in a scaled-up mist bioreactor. Biotechnol Bioeng 2011; 107:802-13. [PMID: 20687140 DOI: 10.1002/bit.22892] [Citation(s) in RCA: 30] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/09/2022]
Abstract
Hairy roots have the potential to produce a variety of valuable small and large molecules. The mist reactor is a gas phase bioreactor that has shown promise for low-cost culture of hairy roots. Using a newer, disposable culture bag, mist reactor performance was studied with two species, Artemisia annua L. and Arachis hypogaea (peanut), at scales from 1 to 20 L. Both species of hairy roots when grown at 1 L in the mist reactor showed growth rates that surpassed that in shake flasks. From the information gleaned at 1 L, Arachis was scaled further to 4 and then 20 L. Misting duty cycle, culture medium flow rate, and timing of when flow rate was increased were varied. In a mist reactor increasing the misting cycle or increasing the medium flow rate are the two alternatives for increased delivery of liquid nutrients to the root bed. Longer misting cycles beyond 2-3 min were generally deemed detrimental to growth. On the other hand, increasing the medium flow rate to the sonic nozzle especially during the exponential phase of root growth (weeks 2-3) was the most important factor for increasing growth rates and biomass yields in the 20 L reactors. A. hypogaea growth in 1 L reactors was µ = 0.173 day(-1) with biomass yield of 12.75 g DW L(-1). This exceeded that in shake flasks at µ = 0.166 day(-1) and 11.10 g DW L(-1). Best growth rate and biomass yield at 20 L was µ = 0.147 and 7.77 g DW L(-1), which was mainly achieved when medium flow rate delivery was increased. The mist deposition model was further evaluated using this newer reactor design and when the apparent thickness of roots (+hairs) was taken into account, the empirical data correlated with model predictions. Together these results establish the most important conditions to explore for future optimization of the mist bioreactor for culture of hairy roots.
Collapse
Affiliation(s)
- Ganapathy Sivakumar
- Arkansas Biosciences Institute, Arkansas State University, Jonesboro, AR 72467, USA
| | | | | | | |
Collapse
|
67
|
Ryan PR, Tyerman SD, Sasaki T, Furuichi T, Yamamoto Y, Zhang WH, Delhaize E. The identification of aluminium-resistance genes provides opportunities for enhancing crop production on acid soils. JOURNAL OF EXPERIMENTAL BOTANY 2011; 62:9-20. [PMID: 20847099 DOI: 10.1093/jxb/erq272] [Citation(s) in RCA: 66] [Impact Index Per Article: 5.1] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/06/2023]
Abstract
Acid soils restrict plant production around the world. One of the major limitations to plant growth on acid soils is the prevalence of soluble aluminium (Al(3+)) ions which can inhibit root growth at micromolar concentrations. Species that show a natural resistance to Al(3+) toxicity perform better on acid soils. Our understanding of the physiology of Al(3+) resistance in important crop plants has increased greatly over the past 20 years, largely due to the application of genetics and molecular biology. Fourteen genes from seven different species are known to contribute to Al(3+) tolerance and resistance and several additional candidates have been identified. Some of these genes account for genotypic variation within species and others do not. One mechanism of resistance which has now been identified in a range of species relies on the efflux of organic anions such as malate and citrate from roots. The genes controlling this trait are members of the ALMT and MATE families which encode membrane proteins that facilitate organic anion efflux across the plasma membrane. Identification of these and other resistance genes provides opportunities for enhancing the Al(3+) resistance of plants by marker-assisted breeding and through biotechnology. Most attempts to enhance Al(3+) resistance in plants with genetic engineering have targeted genes that are induced by Al(3+) stress or that are likely to increase organic anion efflux. In the latter case, studies have either enhanced organic anion synthesis or increased organic anion transport across the plasma membrane. Recent developments in this area are summarized and the structure-function of the TaALMT1 protein from wheat is discussed.
Collapse
Affiliation(s)
- P R Ryan
- CSIRO Plant Industry, GPO Box 1600, Canberra, ACT 2601, Australia.
| | | | | | | | | | | | | |
Collapse
|
68
|
Mairet F, Villon P, Boitel-Conti M, Shakourzadeh K. Modeling and optimization of hairy root growth in fed-batch process. Biotechnol Prog 2010; 26:847-56. [PMID: 20187141 DOI: 10.1002/btpr.388] [Citation(s) in RCA: 15] [Impact Index Per Article: 1.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/24/2022]
Abstract
This article proposes a feeding strategy based on a kinetic model to enhance hairy roots growth. A new approach for modeling hairy root growth is used, considering that there is no nutrient limitation thanks to an appropriate feeding, and the intracellular pools are supposed to be always saturated. Thus, the model describes the specific growth rate from extracellular concentration of the major nutrients and nutrient uptakes depend on biomass growth. An optimized feeding strategy was determined thanks to the model to maintain the major nutrient levels at their optimum assuming optimal initial concentrations. The optimal feed rate is computed in open loop using kinetic model prediction or in closed loop using conductivity measurements to estimate biomass growth. Datura innoxia was chosen as the model culture system. Shake flask cultures were used to calibrate the model. Finally, cultures in bioreactor were performed to validate the model and the control laws.
Collapse
Affiliation(s)
- Francis Mairet
- Transformations Intégrées de Matière Renouvelable, Université de Technologie de Compiègne, BP 649, Compiègne 60206, France.
| | | | | | | |
Collapse
|
69
|
Franconi R, Demurtas OC, Massa S. Plant-derived vaccines and other therapeutics produced in contained systems. Expert Rev Vaccines 2010; 9:877-92. [PMID: 20673011 DOI: 10.1586/erv.10.91] [Citation(s) in RCA: 36] [Impact Index Per Article: 2.6] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/16/2023]
Abstract
The use of contained plant systems for the production of biopharmaceuticals represents a powerful alternative to current methods, combining the benefits of whole-plant systems and cell cultures. In vitro contained production systems include plant cell suspensions, hairy root cultures, novel plants grown in contained conditions and microalgae. These systems show intrinsic advantages, such as control over growth conditions, production in compliance with good manufacturing practice and avoidance of political resistance to the release of genetically modified field crops. At present, one of the two plant-produced vaccine-related products that have gone all the way through production and regulatory hurdles derives from tobacco cell suspensions, and the second is a human therapeutic enzyme, which is expected to reach commercial development soon and derives from carrot suspension cells. In the future, several other products from contained systems are expected to reach the clinical trial stage.
Collapse
Affiliation(s)
- Rosella Franconi
- Italian National Agency for New Technologies, UTBIORAD, CR Casaccia, Rome, Italy.
| | | | | |
Collapse
|
70
|
Kajikawa M, Morikawa K, Abe Y, Yokota A, Akashi K. Establishment of a transgenic hairy root system in wild and domesticated watermelon (Citrullus lanatus) for studying root vigor under drought. PLANT CELL REPORTS 2010; 29:771-778. [PMID: 20445980 DOI: 10.1007/s00299-010-0863-3] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/25/2009] [Revised: 04/16/2010] [Accepted: 04/19/2010] [Indexed: 05/29/2023]
Abstract
Root vigor is an important trait for the growth of terrestrial plants, especially in water-deficit environments. Although deserts plants are known for their highly developed root architecture, the molecular mechanism responsible for this trait has not been determined. Here we established an efficient protocol for the genetic manipulation of two varieties of watermelon plants: a desert-grown wild watermelon that shows vigorous root growth under drought, and a domesticated cultivar showing retardation of root growth under drought stress. Agrobacterium rhizogenes-mediated transgenic hairy roots were efficiently induced and selected from the hypocotyls of these plants. Transgenic GUS expression was detected in the roots by RT-PCR and histochemical GUS staining. Moreover, a liquid culture system for evaluating their root growth was also established. Interestingly, growth of the hairy roots derived from domesticated variety of watermelon strongly inhibited under high osmotic condition, whereas the hairy roots derived from wild variety of watermelon retained substantial growth rates under the stress condition. The new protocol presented here offers a powerful tool for the comparative study of the molecular mechanism underlying drought-induced root growth in desert plants.
Collapse
Affiliation(s)
- Masataka Kajikawa
- Nara Institute of Science and Technology, Graduate School of Biological Sciences, 8916-5 Takayama, Ikoma, Nara, 630-0192, Japan
| | | | | | | | | |
Collapse
|
71
|
Abstract
Cyclotides are disulfide-rich mini-proteins with the unique structural features of a circular backbone and knotted arrangement of three conserved disulfide bonds. They typically comprise 28-37 amino acids and are produced from linear precursors, and translational modification via oxidative folding, proteolytic processing and N-C cyclization. Because these plant-derived peptides are resistant to degradation and do exhibit a diverse range of biological activities, they have become important agronomic and industrial objectives. Due to its tolerance to sequence variation, the cyclotide backbone is also potentially useful as a molecular scaffold for protein-engineering applications. Several production options are available for bioactive plant metabolites including natural harvesting, total chemical synthesis, and expression of plant pathways in microbial systems. For the cyclotides with low yields in nature, chemical complexity and lack of knowledge of the complete biosynthetic pathway, however, many of these options are precluded. Plant cell-culture technology shows promise towards the goal of producing therapeutically active cyclotides in quality and quantities required for drug development as they are amenable to process optimization, scale-up, and metabolic engineering. It is conceivable that plant-based production systems may ultimately prove to be the preferred route for the production of native or designed cyclotides, and will contribute towards the development of target-specific drugs.
Collapse
Affiliation(s)
- Heike Dörnenburg
- Institute of Bioprocess Engineering, University of Erlangen-Nuremberg, Germany.
| |
Collapse
|
72
|
Kim YK, Li X, Xu H, Il Park N, Uddin MR, Pyon JY, Park SU. Production of phenolic compounds in hairy root culture of tartary buckwheat (Fagopyrum tataricum Gaertn). ACTA ACUST UNITED AC 2009. [DOI: 10.1007/s12892-009-0075-y] [Citation(s) in RCA: 21] [Impact Index Per Article: 1.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/20/2022]
|
73
|
Wu CH, Bernard SM, Andersen GL, Chen W. Developing microbe-plant interactions for applications in plant-growth promotion and disease control, production of useful compounds, remediation and carbon sequestration. Microb Biotechnol 2009; 2:428-40. [PMID: 21255275 PMCID: PMC3815904 DOI: 10.1111/j.1751-7915.2009.00109.x] [Citation(s) in RCA: 62] [Impact Index Per Article: 4.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022] Open
Abstract
Interactions between plants and microbes are an integral part of our terrestrial ecosystem. Microbe–plant interactions are being applied in many areas. In this review, we present recent reports of applications in the areas of plant‐growth promotion, biocontrol, bioactive compound and biomaterial production, remediation and carbon sequestration. Challenges, limitations and future outlook for each field are discussed.
Collapse
Affiliation(s)
- Cindy H Wu
- Lawrence Berkeley National Laboratory, Earth Sciences Division, One Cyclotron Road, Berkeley, CA 94720, USA.
| | | | | | | |
Collapse
|
74
|
Peebles CA, Sander GW, Li M, Shanks JV, San KY. Five year maintenance of the inducible expression of anthranilate synthase inCatharanthus roseushairy roots. Biotechnol Bioeng 2009; 102:1521-5. [DOI: 10.1002/bit.22173] [Citation(s) in RCA: 20] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/09/2022]
|
75
|
Lata H, Mizuno CS, Moraes RM. The role of biotechnology in the production of the anticancer compound podophyllotoxin. Methods Mol Biol 2009; 547:387-402. [PMID: 19521861 DOI: 10.1007/978-1-60327-287-2_31] [Citation(s) in RCA: 8] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/09/2023]
Abstract
Podophyllotoxin is a plant-derived compound found in Podophyllum sp. that is used to produce semi-synthetic anticancer pharmaceuticals such as etoposide, teniposide, and etoposide phosphate. This chapter describes the role of biotechnology to produce podophyllotoxin and our attempts to domesticate Podophyllum peltatum L., also known as the American mayapple. The domestication research on mayapple included surveys of the natural population, identification of high yielding genotypes, propagation, cultivation, sustainable harvest procedures and the development of protocols for in vitro germplasm bank.
Collapse
Affiliation(s)
- Hemant Lata
- National Center for Natural Products Research, School of Pharmacy, The University of Mississippi, University, MS, USA
| | | | | |
Collapse
|
76
|
Plant in vitro culture for the production of antioxidants — A review. Biotechnol Adv 2008; 26:548-60. [DOI: 10.1016/j.biotechadv.2008.07.001] [Citation(s) in RCA: 286] [Impact Index Per Article: 17.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/04/2008] [Revised: 07/01/2008] [Accepted: 07/10/2008] [Indexed: 12/20/2022]
|
77
|
Mairet F, Sierra J, Glorian V, Villon P, Shakourzadeh K, Boitel-Conti M. A new approach to define optimized range of medium composition for enhancement of hairy root production in fed-batch process. Bioprocess Biosyst Eng 2008; 32:257-65. [DOI: 10.1007/s00449-008-0246-0] [Citation(s) in RCA: 10] [Impact Index Per Article: 0.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/29/2008] [Accepted: 07/08/2008] [Indexed: 10/21/2022]
|
78
|
Liu J, Dolan MC, Reidy M, Cramer CL. Expression of bioactive single-chain murine IL-12 in transgenic plants. J Interferon Cytokine Res 2008; 28:381-92. [PMID: 18593333 DOI: 10.1089/jir.2007.0129] [Citation(s) in RCA: 12] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/13/2022] Open
Abstract
Interleukin-12 (IL-12), an important immunomodulator for cell-mediated immunity, shows significant potential as a vaccine adjuvant and anticancer therapeutic. However, its clinical application is limited in part by lack of an effective bioproduction system for this complex heterodimeric glycoprotein. Transgenic plants show promise as scalable bioproduction platforms for challenging biopharmaceutical proteins. To test the potential of plants to effectively produce bioactive IL-12, we developed transgenic tobacco plant lines and derived root cultures yielding high levels of mouse IL-12 (MuIL-12). Functional IL-12 is a heterodimer consisting of two disulfide-linked subunits, p35 and p40. To ensure the stoichiometric expression and assembly of p35 and p40, we expressed a single-chain version of MuIL-12. Plant-derived single-chain MuIL-12 was characterized and purified for in vitro bioactivity assays. Our results demonstrated precise cleavage of the endogenous mouse p40 signal peptide in plants as well as addition of N-linked glycans. Plant-derived MuIL-12 triggered induction of interferon-gamma (IFN-gamma) secretion from mouse splenocytes and stimulated splenocyte proliferation with comparable activities to those observed for commercially available animal cell-derived MuIL-12. These studies indicate that plants produce fully functional MuIL-12 at levels compatible with commercial production and may serve as an effective bioproduction platform for bioactive IL-12s from other species for human or veterinary vaccine and therapeutic applications.
Collapse
Affiliation(s)
- Jianyun Liu
- Arkansas Biosciences Institute, Arkansas State University, Jonesboro, AR 72467, USA
| | | | | | | |
Collapse
|
79
|
Plant cell culture technology–harnessing a biological approach for competitive cyclotides production. Biotechnol Lett 2008; 30:1311-21. [DOI: 10.1007/s10529-008-9704-7] [Citation(s) in RCA: 19] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/25/2008] [Accepted: 03/14/2008] [Indexed: 10/22/2022]
|
80
|
Kolewe ME, Gaurav V, Roberts SC. Pharmaceutically Active Natural Product Synthesis and Supply via Plant Cell Culture Technology. Mol Pharm 2008; 5:243-56. [DOI: 10.1021/mp7001494] [Citation(s) in RCA: 189] [Impact Index Per Article: 11.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
Affiliation(s)
- Martin E. Kolewe
- Department of Chemical Engineering, University of Massachusetts, Amherst, 686 North Pleasant Street, Amherst, Massachusetts 10003
| | - Vishal Gaurav
- Department of Chemical Engineering, University of Massachusetts, Amherst, 686 North Pleasant Street, Amherst, Massachusetts 10003
| | - Susan C. Roberts
- Department of Chemical Engineering, University of Massachusetts, Amherst, 686 North Pleasant Street, Amherst, Massachusetts 10003
| |
Collapse
|
81
|
Veena. Engineering plants for future: tools and options. PHYSIOLOGY AND MOLECULAR BIOLOGY OF PLANTS : AN INTERNATIONAL JOURNAL OF FUNCTIONAL PLANT BIOLOGY 2008; 14:131-5. [PMID: 23572880 PMCID: PMC3550667 DOI: 10.1007/s12298-008-0012-4] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/02/2023]
Abstract
The availability of efficient techniques for genetic engineering of plants across taxonomic boundaries is a must to address the challenges posed by the global growth of the human population. This will shorten the time and accelerate the entire process needed for inclusion of novel traits in plants with potential to increase agricultural productivity, improved nutritional quality as well as processing characteristics. This mini-review summarizes current understanding, latest advancements and comparisons of various methods used to date to generate transgenic plants with a special focus on the biological model of gene delivery into plants.
Collapse
Affiliation(s)
- Veena
- Donald Danforth Plant Science Center, 975 North Warson Road, Saint Louis, MO USA
| |
Collapse
|
82
|
Analysis of hairy root culture ofRauvolfia serpentina using direct analysis in real time mass spectrometric technique. Biomed Chromatogr 2008; 22:596-600. [DOI: 10.1002/bmc.974] [Citation(s) in RCA: 43] [Impact Index Per Article: 2.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/07/2022]
|
83
|
Lee SY, Xu H, Kim YK, Park SU. Rosmarinic acid production in hairy root cultures of Agastache rugosa Kuntze. World J Microbiol Biotechnol 2007. [DOI: 10.1007/s11274-007-9560-y] [Citation(s) in RCA: 36] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/24/2022]
|
84
|
Chun JA, Lee WH, Han MO, Lee JW, Yi YB, Park GY, Chung CH. Optimization of abiotic factors for improved growth and extracellular production of recombinant fungal phytase in sesame hairy root cultures. BIOTECHNOL BIOPROC E 2007. [DOI: 10.1007/bf02931099] [Citation(s) in RCA: 4] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/21/2022]
|
85
|
Georgiev MI, Pavlov AI, Bley T. Hairy root type plant in vitro systems as sources of bioactive substances. Appl Microbiol Biotechnol 2007; 74:1175-85. [PMID: 17294182 DOI: 10.1007/s00253-007-0856-5] [Citation(s) in RCA: 159] [Impact Index Per Article: 9.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/30/2006] [Revised: 01/15/2007] [Accepted: 01/21/2007] [Indexed: 10/23/2022]
Abstract
"Hairy root" systems, obtained by transforming plant tissues with the "natural genetic engineer" Agrobacterium rhizogenes, have been known for more than three decades. To date, hairy root cultures have been obtained from more than 100 plant species, including several endangered medicinal plants, affording opportunities to produce important phytochemicals and proteins in eco-friendly conditions. Diverse strategies can be applied to improve the yields of desired metabolites and to produce recombinant proteins. Furthermore, recent advances in bioreactor design and construction allow hairy root-based technologies to be scaled up while maintaining their biosynthetic potential. This review highlights recent progress in the field and outlines future prospects for exploiting the potential utility of hairy root cultures as "chemical factories" for producing bioactive substances.
Collapse
Affiliation(s)
- Milen I Georgiev
- Institute of Food Technology and Bioprocess Engineering, Dresden University of Technology, 01069 Dresden, Germany.
| | | | | |
Collapse
|
86
|
Sivakumar G. Bioreactor technology: a novel industrial tool for high-tech production of bioactive molecules and biopharmaceuticals from plant roots. Biotechnol J 2007; 1:1419-27. [PMID: 17136730 DOI: 10.1002/biot.200600117] [Citation(s) in RCA: 34] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/12/2022]
Abstract
Plants are the richest source for different bioactive molecules. Because of the vast number of side effects associated with synthetic pharmaceuticals, medical biotechnologists turned to nature to provide new promising therapeutic molecules from plant biofactories. The large-scale availability of the disease- and pesticide-free raw material is, however, restricted in vivo. Many bioactive plant secondary metabolites are accumulated in roots. Engineered plants can also produce human therapeutic proteins. Vaccines and diagnostic monoclonal antibodies can be won from their roots, so that engineered plants hold immense potential for the biopharmaceutical industry. To obtain sufficient amounts of the plant bioactive molecules for application in human therapy, adventitious and hairy roots have to be cultured in in vitro systems. High-tech pilot-scale bioreactor technology for the establishment of a long-term adventitious root culture from biopharmaceutical plants has recently been established. In this review, I briefly discuss a technology for cultivating bioactive molecule-rich adventitious and hairy roots from plants using a high-tech bioreactor system, as well as the principles and application of genome-restructuring mechanisms for plant-based biopharmaceutical production from roots. High-tech bioreactor-derived bioactive phytomolecules and biopharmaceuticals hold the prospect of providing permanent remedies for improving human well-being.
Collapse
|