1
|
Zhao X, Wu F, Hu H, Li J, Sun Y, Wang J, Zou G, Chen X, Wang Y, Fernandez C, Peng Q. N-Decorated Main-Group MgAl 2O 4 Spinel: Unlocking Exceptional Oxygen Reduction Activity for Zn-Air Batteries. SMALL (WEINHEIM AN DER BERGSTRASSE, GERMANY) 2024; 20:e2311268. [PMID: 38342592 DOI: 10.1002/smll.202311268] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/04/2023] [Revised: 01/15/2024] [Indexed: 02/13/2024]
Abstract
The development of economical and efficient oxygen reduction reaction (ORR) catalysts is crucial to accelerate the widespread application rhythm of aqueous rechargeable zinc-air batteries (ZABs). Here, a strategy is reported that the modification of the binding energy for reaction intermediates by the axial N-group converts the inactive spinel MgAl2O4 into the active motif of MgAl2O4-N. It is found that the introduction of N species can effectively optimize the electronic configuration of MgAl2O4, thereby significantly reducing the adsorption strength of *OH and boosting the reaction process. This main-group MgAl2O4-N catalyst exhibits a high ORR activity in a broad pH range from acidic and alkaline environments. The aqueous ZABs assembled with MgAl2O4-N shows a peak power density of 158.5 mW cm-2, the long-term cyclability over 2000 h and the high stability in the temperature range from -10 to 50 °C, outperforming the commercial Pt/C in terms of activity and stability. This work not only serves as a significant candidate for the robust ORR electrocatalysts of aqueous ZABs, but also paves a new route for the effective reutilization of waste Mg alloys.
Collapse
Affiliation(s)
- Xue Zhao
- State Key Laboratory of Metastable Materials Science and Technology, Yanshan University, Qinhuangdao, 066004, P.R. China
| | - Fengqi Wu
- State Key Laboratory of Metastable Materials Science and Technology, Yanshan University, Qinhuangdao, 066004, P.R. China
| | - Haidong Hu
- State Key Laboratory of Metastable Materials Science and Technology, Yanshan University, Qinhuangdao, 066004, P.R. China
| | - Jinyu Li
- State Key Laboratory of Metastable Materials Science and Technology, Yanshan University, Qinhuangdao, 066004, P.R. China
| | - Yong Sun
- State Key Laboratory of Metastable Materials Science and Technology, Yanshan University, Qinhuangdao, 066004, P.R. China
| | - Jing Wang
- State Key Laboratory of Metastable Materials Science and Technology, Yanshan University, Qinhuangdao, 066004, P.R. China
| | - Guodong Zou
- State Key Laboratory of Metastable Materials Science and Technology, Yanshan University, Qinhuangdao, 066004, P.R. China
| | - Xiaobo Chen
- School of Engineering, RMIT University, Carlton, VIC, 3053, Australia
| | - Yong Wang
- College of Chinese Medicine, Beijing University of Chinese Medicine, Beijing, 100029, P.R. China
| | - Carlos Fernandez
- School of Pharmacy and life sciences, Robert Gordon University, Aberdeen, AB107GJ, UK
| | - Qiuming Peng
- State Key Laboratory of Metastable Materials Science and Technology, Yanshan University, Qinhuangdao, 066004, P.R. China
| |
Collapse
|
2
|
Cui M, Yuan Y, Wu Y, Che Z, Li P, Yang X, Chen Y, Hu W, Wang J, Wang S, Guo Y, Wu Z. Graphdiyne-Induced CoN/CoS 2 Heterojunction: Boosting Efficiency for Bifunctional Oxygen Electrochemistry in Zinc-Air Batteries. CHEMSUSCHEM 2024:e202400832. [PMID: 38845094 DOI: 10.1002/cssc.202400832] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/17/2024] [Revised: 05/25/2024] [Indexed: 08/09/2024]
Abstract
The performance of zinc-air battery is constrained by the sluggish rate of oxygen electrode reaction, particularly under high current discharge conditions where the kinetic process of the oxygen reduction reaction (ORR) decelerates significantly. To address this challenge, we present a novel phase transition strategy that facilitates the creation of a heteroatom-doped heterointerface (CoN/CoS2). The meticulously engineered CoN/CoS2/NC electrocatalyst displays a superior ORR half-wave potential of 0.87 V and an OER overpotential of 320 mV at 10 mA cm-2. Experimental and computational analysis confirm that the CoN/CoS2 heterostructure optimizes local charge distribution, accelerates electron transfer, and tunes active sites for enhanced catalysis. Notably, this heterojunction improves stability by resisting corrosion and degradation under harsh alkaline conditions, thus demonstrating superior performance and longevity in a custom-made liquid zinc-air battery. This research provides valuable practical and theoretical foundations for designing efficient heterointerfaces in electrocatalysis applications.
Collapse
Affiliation(s)
- Min Cui
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Yanan Yuan
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Yue Wu
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Zhongmei Che
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Peixuan Li
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Xiaochen Yang
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Yuqi Chen
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Wei Hu
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Jingui Wang
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Shuai Wang
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
- Nankai University, Key Laboratory of Advanced Energy Materials Chemistry (Ministry of Education), College of Chemistry, Tianjin, 300071, P.R. China
| | - Yingshu Guo
- Qilu University of Technology (Shandong Academy of Sciences), Shandong Provincial Key Laboratory of Molecular Engineering, School of Chemistry and Chemical Engineering, Jinan, 250353, Shandong, P.R. China
| | - Zexing Wu
- Qingdao University of Science and Technology, Key Laboratory of Eco-Chemical Engineering, College of Chemistry and Molecular Engineering, Qingdao, 266042, Shandong, P.R. China
| |
Collapse
|
3
|
Zhu Q, Xiang T, Chen C, Zhang J, Wu Z, Rao S, Li B, Yang J. Enhancing activity and stability of FeNC catalysts through co incorporation for oxygen reduction reaction. J Colloid Interface Sci 2024; 663:53-60. [PMID: 38387186 DOI: 10.1016/j.jcis.2024.02.144] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/03/2024] [Revised: 02/14/2024] [Accepted: 02/19/2024] [Indexed: 02/24/2024]
Abstract
FeNC single atom catalysts (SACs) have attracted great interest due to their highly active FeN4 sites. However, the pyrolysis treatment often leads to inevitable metal migration and aggregation, which reduces the catalytic activity. Moreover, due to the Fenton reaction caused by FeNC in alkaline and acidic solutions, the presence of Fe and peroxide in electrodes may generate free radicals, resulting in serious degradation of the organic ionomer and the membrane. Herein, we report an original strategy of introducing Co single atoms into FeNC catalysts, forming atomically dispersed bimetallic active sites (FeCoNC) and improving the activity and stability of the catalyst. Benefiting from this strategy, FeCoNC catalyst exhibits excellent oxygen reduction reaction (ORR) activity in alkaline media (E1/2 = 0.88 V) and in acidic media (E1/2 = 0.77 V). As the cathode of Zn-air battery (ZAB), FeCoNC shows an excellent peak power density of 142.8 mW cm-2 and a specific capacity of 806.6 mAh/gZn. This work provides a novel avenue to optimize and enhance the ORR performance of atomic dispersed FeNC catalysts.
Collapse
Affiliation(s)
- Qingchao Zhu
- School of Materials Science and Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Tingting Xiang
- School of Materials Science and Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Chenglong Chen
- School of Materials Science and Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Jiali Zhang
- School of Materials Science and Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Zirui Wu
- School of Materials Science and Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Shaosheng Rao
- School of Materials Science and Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Bing Li
- School of Materials Science and Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Juan Yang
- School of Materials Science and Engineering, Jiangsu University, Zhenjiang 212013, China.
| |
Collapse
|
4
|
Tian X, Xu M, Ma X, Mu G, Xiao J, Wang S. General and Facile Synthesis of Co/CoO Nanoparticals Supported by Nitrogen-Doped Graphenic Networks as Efficient Oxygen Electrocatalyst for Zn-Air Batteries. CHEMSUSCHEM 2024:e202400570. [PMID: 38610068 DOI: 10.1002/cssc.202400570] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/16/2024] [Accepted: 04/12/2024] [Indexed: 04/14/2024]
Abstract
Reasonable design of low-cost, high-efficiency and stable bifunctional oxygen electrocatalysts is of great significance to improve the reaction efficiency of Zn-air batteries, which is still a huge challenge. Here, we report a highly efficient bifunctional oxygen electrocatalyst with three-dimensional (3D) N-doped graphene network-supported cobalt and cobalt oxide nanoparticles (Co/CoO-NG), which can be in situ synthesized by inducing metal ions on metal plates via graphene oxide as an inducer. This 3D network structure and open active center show excellent bifunctional oxygen electrocatalytic activity under alkaline conditions, and can be used as an air electrode in rechargeable Zn-air batteries, with significantly better power density (244.28 mW cm-2) and stability (over 340 h) than commercial Pt/C+RuO2 mixtures. This work is conducive to advancing the practical application of graphene-based materials as air electrodes for rechargeable zinc-air batteries.
Collapse
Affiliation(s)
- Xin Tian
- Key Laboratory of Material Chemistry for Energy Conversion and Storage, Ministry of Education, School of Chemistry and Chemical Engineering, Huazhong University of Science and Technology, Wuhan, 430074, P. R. China
| | - Mengnan Xu
- Key Laboratory of Material Chemistry for Energy Conversion and Storage, Ministry of Education, School of Chemistry and Chemical Engineering, Huazhong University of Science and Technology, Wuhan, 430074, P. R. China
| | - Xin Ma
- Key Laboratory of Material Chemistry for Energy Conversion and Storage, Ministry of Education, School of Chemistry and Chemical Engineering, Huazhong University of Science and Technology, Wuhan, 430074, P. R. China
| | - Guanyu Mu
- Key Laboratory of Material Chemistry for Energy Conversion and Storage, Ministry of Education, School of Chemistry and Chemical Engineering, Huazhong University of Science and Technology, Wuhan, 430074, P. R. China
| | - Junwu Xiao
- Key Laboratory of Material Chemistry for Energy Conversion and Storage, Ministry of Education, School of Chemistry and Chemical Engineering, Huazhong University of Science and Technology, Wuhan, 430074, P. R. China
| | - Shuai Wang
- Key Laboratory of Material Chemistry for Energy Conversion and Storage, Ministry of Education, School of Chemistry and Chemical Engineering, Huazhong University of Science and Technology, Wuhan, 430074, P. R. China
- Key Laboratory of Advanced Energy Materials Chemistry (Ministry of Education), Nankai University, Tianjin, 300071, P. R. China
| |
Collapse
|
5
|
Nazir G, Rehman A, Lee JH, Kim CH, Gautam J, Heo K, Hussain S, Ikram M, AlObaid AA, Lee SY, Park SJ. A Review of Rechargeable Zinc-Air Batteries: Recent Progress and Future Perspectives. NANO-MICRO LETTERS 2024; 16:138. [PMID: 38421464 PMCID: PMC10904712 DOI: 10.1007/s40820-024-01328-1] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/18/2023] [Accepted: 12/14/2023] [Indexed: 03/02/2024]
Abstract
Zinc-air batteries (ZABs) are gaining attention as an ideal option for various applications requiring high-capacity batteries, such as portable electronics, electric vehicles, and renewable energy storage. ZABs offer advantages such as low environmental impact, enhanced safety compared to Li-ion batteries, and cost-effectiveness due to the abundance of zinc. However, early research faced challenges due to parasitic reactions at the zinc anode and slow oxygen redox kinetics. Recent advancements in restructuring the anode, utilizing alternative electrolytes, and developing bifunctional oxygen catalysts have significantly improved ZABs. Scientists have achieved battery reversibility over thousands of cycles, introduced new electrolytes, and achieved energy efficiency records surpassing 70%. Despite these achievements, there are challenges related to lower power density, shorter lifespan, and air electrode corrosion leading to performance degradation. This review paper discusses different battery configurations, and reaction mechanisms for electrically and mechanically rechargeable ZABs, and proposes remedies to enhance overall battery performance. The paper also explores recent advancements, applications, and the future prospects of electrically/mechanically rechargeable ZABs.
Collapse
Affiliation(s)
- Ghazanfar Nazir
- Department of Nanotechnology and Advanced Materials Engineering, Hybrid Materials Research Center (HMC), Sejong University, Seoul, 05006, Republic of Korea
| | - Adeela Rehman
- Department of Chemical and Biomolecular Engineering, Yonsei University, 50 Yonsei-Ro, Seodaemun-Gu, Seoul, 03722, Republic of Korea
| | - Jong-Hoon Lee
- Department of Chemistry, Inha University, Incheon, 22212, Republic of Korea
| | - Choong-Hee Kim
- Department of Chemistry, Inha University, Incheon, 22212, Republic of Korea
| | - Jagadis Gautam
- Department of Chemistry, Inha University, Incheon, 22212, Republic of Korea
| | - Kwang Heo
- Department of Nanotechnology and Advanced Materials Engineering, Hybrid Materials Research Center (HMC), Sejong University, Seoul, 05006, Republic of Korea.
| | - Sajjad Hussain
- Department of Nanotechnology and Advanced Materials Engineering, Hybrid Materials Research Center (HMC), Sejong University, Seoul, 05006, Republic of Korea
| | - Muhammad Ikram
- Solar Cell Applications Research Lab, Department of Physics, Government College University Lahore, Lahore, 54000, Punjab, Pakistan
| | - Abeer A AlObaid
- Department of Chemistry, College of Science, King Saud University, P.O. Box 2455, Riyadh, 11451, Saudi Arabia
| | - Seul-Yi Lee
- Department of Chemistry, Inha University, Incheon, 22212, Republic of Korea.
| | - Soo-Jin Park
- Department of Chemistry, Inha University, Incheon, 22212, Republic of Korea.
| |
Collapse
|
6
|
Wang H, Pei Y, Wang K, Zuo Y, Wei M, Xiong J, Zhang P, Chen Z, Shang N, Zhong D, Pei P. First-Row Transition Metals for Catalyzing Oxygen Redox. SMALL (WEINHEIM AN DER BERGSTRASSE, GERMANY) 2023; 19:e2304863. [PMID: 37469215 DOI: 10.1002/smll.202304863] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/09/2023] [Revised: 07/09/2023] [Indexed: 07/21/2023]
Abstract
Rechargeable zinc-air batteries are widely recognized as a highly promising technology for energy conversion and storage, offering a cost-effective and viable alternative to commercial lithium-ion batteries due to their unique advantages. However, the practical application and commercialization of zinc-air batteries are hindered by the sluggish kinetics of the oxygen reduction reaction (ORR) and oxygen evolution reaction (OER). Recently, extensive research has focused on the potential of first-row transition metals (Mn, Fe, Co, Ni, and Cu) as promising alternatives to noble metals in bifunctional ORR/OER electrocatalysts, leveraging their high-efficiency electrocatalytic activity and excellent durability. This review provides a comprehensive summary of the recent advancements in the mechanisms of ORR/OER, the performance of bifunctional electrocatalysts, and the preparation strategies employed for electrocatalysts based on first-row transition metals in alkaline media for zinc-air batteries. The paper concludes by proposing several challenges and highlighting emerging research trends for the future development of bifunctional electrocatalysts based on first-row transition metals.
Collapse
Affiliation(s)
- Hengwei Wang
- School of Mechanical Engineering, Beijing Institute of Technology, Beijing, 100081, China
| | - Yu Pei
- Department of Chemical and Biological Engineering, The University of British Columbia, 2360 East Mall, Vancouver, BC, V6T 1Z3, Canada
| | - Keliang Wang
- School of Mechanical Engineering, Beijing Institute of Technology, Beijing, 100081, China
- State Key Laboratory of Automotive Safety and Energy, Tsinghua University, Beijing, 100084, China
| | - Yayu Zuo
- School of Mechanical Engineering, Beijing Institute of Technology, Beijing, 100081, China
| | - Manhui Wei
- School of Mechanical Engineering, Beijing Institute of Technology, Beijing, 100081, China
| | - Jianyin Xiong
- School of Mechanical Engineering, Beijing Institute of Technology, Beijing, 100081, China
| | - Pengfei Zhang
- School of Mechanical Engineering, Beijing Institute of Technology, Beijing, 100081, China
| | - Zhuo Chen
- School of Mechanical Engineering, Beijing Institute of Technology, Beijing, 100081, China
| | - Nuo Shang
- School of Mechanical Engineering, Beijing Institute of Technology, Beijing, 100081, China
| | - Daiyuan Zhong
- School of Mechanical Engineering, Beijing Institute of Technology, Beijing, 100081, China
| | - Pucheng Pei
- State Key Laboratory of Automotive Safety and Energy, Tsinghua University, Beijing, 100084, China
| |
Collapse
|
7
|
Liu Y, Fan X, Zhang Z, Li C, Zhang S, Li Z, Liu L. Oxygen-doped NiCoP derived from Ni-MOFs for high performance asymmetric supercapacitor. NANOTECHNOLOGY 2023; 34:475702. [PMID: 37579745 DOI: 10.1088/1361-6528/acefd7] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/15/2023] [Accepted: 08/14/2023] [Indexed: 08/16/2023]
Abstract
Oxygen doping strategy is one of the most effective methods to improve the electrochemical properties of nickel-cobalt phosphide (NiCoP)-based capacitors by adjusting its inherent electronic structure. In this paper, O-doped NiCoP microspheres derived from porous nanostructured nickel metal-organic frameworks (Ni-MOFs) were constructed through solvothermal method followed by phosphorization treatment. The O-doping concentration has a siginificant influence on the rate performance and cycle stability. The optimized O-doped NiCoP electrode material shows a specific capacitance of 632.4 F-g-1at 1 A-g-1and a high retention rate of 56.9% at 20 A g-1. The corresponding NiCoP-based asymmetric supercapacitor exhibits a high energy density of 30.1 Wh kg-1when the power density is 800.9 W kg-1, and can still maintain 82.1% of the initial capacity after 10 000 cycles at 5 A g-1.
Collapse
Affiliation(s)
- Yan Liu
- School of Mathematics and Physics, Qingdao University of Science and Technology, Qingdao 266061, Shandong, People's Republic of China
| | - Xiaoyan Fan
- School of Mathematics and Physics, Qingdao University of Science and Technology, Qingdao 266061, Shandong, People's Republic of China
| | - Zikun Zhang
- School of Mathematics and Physics, Qingdao University of Science and Technology, Qingdao 266061, Shandong, People's Republic of China
| | - Chun Li
- College of Physics and Optoelectronic Engineering, Ocean University of China, Qingdao 266100, Shandong, People's Republic of China
| | - Shuaiyi Zhang
- School of Mathematics and Physics, Qingdao University of Science and Technology, Qingdao 266061, Shandong, People's Republic of China
| | - Zhenjiang Li
- College of Materials Science and Engineering, Qingdao University of Science and Technology, Qingdao 266061, Shandong, People's Republic of China
| | - Lin Liu
- College of Polymer Science and Engineering, Qingdao University of Science and Technology, Qingdao 266061, Shandong, People's Republic of China
| |
Collapse
|
8
|
Guo J, He B, Gong W, Xu S, Xue P, Li C, Sun Y, Wang C, Wei L, Zhang Q, Li Q. Emerging Amorphous to Crystalline Conversion Chemistry in Ca-Doped VO 2 Cathodes for High-Capacity and Long-Term Wearable Aqueous Zinc-Ion Batteries. ADVANCED MATERIALS (DEERFIELD BEACH, FLA.) 2023:e2303906. [PMID: 37560808 DOI: 10.1002/adma.202303906] [Citation(s) in RCA: 4] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/26/2023] [Revised: 08/03/2023] [Indexed: 08/11/2023]
Abstract
Amorphous transition metal oxides have attracted significant attention in energy storage devices owing to their potentially desirable electrochemical properties caused by abundant unsaturated dangling bonds. However, the amorphization further amplifies the shortcoming of the poor intrinsic electronic conductivity of the metal oxides, resulting in unsatisfying rate capability and power density. Herein, freestanding amorphous Ca-doped V2 O5 (a-Ca-V2 O5 ) cathodes are successfully prepared via in situ electrochemical oxidation of Ca-doped VO2 nanoarrays for wearable aqueous zinc-ion batteries. The doping of Ca and construction of freestanding structure effectively uncover the potential of amorphous V2 O5 , which can make full use of the abundant active sites for high volumetric capacity and simultaneously achieve fast reaction kinetics for excellent rate performance. More importantly, the introduction of Ca can notably reduce the formation energy of VO2 according to theoretical calculation results and realizes amorphous to crystalline reversible conversion chemistry in the charge/discharge procedure, thereby facilitating the reversible capacity of the newly developed a-Ca-V2 O5 . This work provides an innovative design strategy to construct high-rate capacity amorphous metal oxides as freestanding electrodes for low-cost and high-safe wearable energy-storage technology.
Collapse
Affiliation(s)
- Jiabin Guo
- School of Electronic Science & Engineering, Southeast University, Nanjing, 210096, China
- Key Laboratory of Multifunctional Nanomaterials and Smart Systems, Suzhou Institute of Nano-Tech and Nano-Bionics, Chinese Academy of Sciences, Suzhou, 215123, China
| | - Bing He
- School of Electrical and Electronic Engineering, Nanyang Technological University, 50 Nanyang Avenue, Singapore, 639798, Singapore
| | - Wenbin Gong
- School of Physics and Energy, Xuzhou University of Technology, Xuzhou, 221018, China
| | - Shuhong Xu
- School of Electronic Science & Engineering, Southeast University, Nanjing, 210096, China
| | - Pan Xue
- School of Chemistry and Chemical Engineering, Yangzhou University, Yangzhou, 225002, China
| | - Chunsheng Li
- School of Chemistry and Life Sciences, Suzhou University of Science and Technology, Suzhou City, Jiangsu Province, 215009, China
- Key Laboratory of Advanced Electrode Materials for Novel Solar Cells for Petroleum and Chemical Industry of China, Suzhou University of Science and Technology, Suzhou City, Jiangsu Province, 215009, China
| | - Yan Sun
- School of Chemistry and Life Sciences, Suzhou University of Science and Technology, Suzhou City, Jiangsu Province, 215009, China
- Key Laboratory of Advanced Electrode Materials for Novel Solar Cells for Petroleum and Chemical Industry of China, Suzhou University of Science and Technology, Suzhou City, Jiangsu Province, 215009, China
| | - Chunlei Wang
- School of Electronic Science & Engineering, Southeast University, Nanjing, 210096, China
| | - Lei Wei
- School of Electrical and Electronic Engineering, Nanyang Technological University, 50 Nanyang Avenue, Singapore, 639798, Singapore
| | - Qichong Zhang
- Key Laboratory of Multifunctional Nanomaterials and Smart Systems, Suzhou Institute of Nano-Tech and Nano-Bionics, Chinese Academy of Sciences, Suzhou, 215123, China
| | - Qingwen Li
- Key Laboratory of Multifunctional Nanomaterials and Smart Systems, Suzhou Institute of Nano-Tech and Nano-Bionics, Chinese Academy of Sciences, Suzhou, 215123, China
| |
Collapse
|
9
|
Lignin-based nitrogen/sulfur dual-doped nanosheets decorated with Co 1-xS nanoparticles as efficient bifunctional oxygen electrocatalysts. J Colloid Interface Sci 2023; 634:469-480. [PMID: 36542976 DOI: 10.1016/j.jcis.2022.12.070] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/12/2022] [Revised: 12/08/2022] [Accepted: 12/14/2022] [Indexed: 12/23/2022]
Abstract
The development of efficient, cost-effective, bifunctional cathode catalyst materials to replace precious metals is highly attractive for the fabrication of Zn-air battery. Here, the three-dimensional N and S co-doped carbon nanosheets loaded with cobalt sulfide nanoparticles (Co1-xS@SNFC) for bifunctional oxygen electrocatalysis were synthesized with Co(NO3)2·6H2O as the Co source, lignin as the carbon source, thiourea as the nitrogen/ sulfur source, and MgO as the template. The synergistic effect of multiple active sites gives the Co1-xS@SNFC fast electrochemical kinetic properties and excellent stability to oxygen reduction reactions (ORR) and oxygen evolution reactions (OER). The half-wave potential and overpotential of Co1-xS@SNFC were 0.84 mV and 306 mV, respectively, which is closed to commercial noble metal catalysts. In addition, Co1-xS@SNFC exhibited four-electron transfer characteristics and ultra-low tafel slope. Compared with commercial Pt/C, the Zn-air battery assembled from Co1-xS@SNFC exhibited a low voltage gap of polarization curve (0.75 V) between charging and discharge and high power density (207 mWcm-2) in alkaline electrolyte. This work developed a green and novel fabrication approach for the synthesis of bifunctional electrocatalyst and provides a new idea for high-value utilization of biomass.
Collapse
|
10
|
Hong R, Liu Q, Cao Q, Xu J, Xiao R, Zhang H. Catalytic upcycling of waste polypropylene for gram-scale production of FeCo@N-doped carbon nanotubes toward efficient oxygen reduction electrocatalysis. J Electroanal Chem (Lausanne) 2023. [DOI: 10.1016/j.jelechem.2023.117394] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 03/30/2023]
|
11
|
FeNi coordination polymer based highly efficient and durable bifunction oxygen electrocatalyst for rechargeable zinc-air battery. Sep Purif Technol 2023. [DOI: 10.1016/j.seppur.2022.122974] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/24/2022]
|
12
|
Feng J, Qi J. Facile synthesis of graphene oxide coated 3D bimetallic oxide MnO2/Bi2O3 microspheres for voltammetric detection of cadmium ion in water. J SOLID STATE CHEM 2023. [DOI: 10.1016/j.jssc.2023.124007] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 03/29/2023]
|
13
|
Ye C, Cheng H, Zheng L, Lin J, Xu Q, Qiu Y, Pan Z, Qiu Y. Tailoring Metal-Oxygen Bonds Boosts Oxygen Reaction Kinetics for High-Performance Zinc-Air Batteries. NANO LETTERS 2023; 23:1573-1581. [PMID: 36724081 DOI: 10.1021/acs.nanolett.3c00053] [Citation(s) in RCA: 3] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/18/2023]
Abstract
Metal-oxygen bonds significantly affect the oxygen reaction kinetics of metal oxide-based catalysts but still face the bottlenecks of limited cognition and insufficient regulation. Herein, we develop a unique strategy to accurately tailor metal-oxygen bond structure via amorphous/crystalline heterojunction realized by ion-exchange. Compared with pristine amorphous CoSnO3-y, iron ion-exchange induced amorphous/crystalline structure strengthens the Sn-O bond, weakens the Co-O bond strength, and introduces additional Fe-O bond, accompanied by abundant cobalt defects and optimal oxygen defects with larger pore structure and specific surface area. The optimization of metal-oxygen bond structure is dominated by the introduction of crystal structure and further promoted by the introduction of Fe-O bond and rich Co defect. Remarkably, the Fe doped amorphous/crystalline catalyst (Co1-xSnO3-y-Fe0.021-A/C) demonstrates excellent oxygen evolution reaction and oxygen reduction reaction activities with a smaller potential gap (ΔE = 0.687 V), and the Zn-air battery based with Co1-xSnO3-y-Fe0.021-A/C exhibits excellent output power density, cycle performance, and flexibility.
Collapse
Affiliation(s)
- Changchun Ye
- Interdisciplinary Materials Research Center, School of Materials Science and Engineering, Tongji University, Shanghai201804, P. R. China
- School of Environment and Energy, State Key Laboratory of Luminescent Materials and Devices, Guangdong Provincial Key Laboratory of Atmospheric Environment and Pollution Control, South China University of Technology, Guangzhou510000, Guangdong, P. R. China
| | - Hongfei Cheng
- Interdisciplinary Materials Research Center, School of Materials Science and Engineering, Tongji University, Shanghai201804, P. R. China
| | - Lirong Zheng
- Beijing Synchrotron Radiation Facility, Institute of High Energy Physics, Chinese Academy of Sciences, Beijing100049, P. R. China
| | - Jiajin Lin
- School of Environment and Energy, State Key Laboratory of Luminescent Materials and Devices, Guangdong Provincial Key Laboratory of Atmospheric Environment and Pollution Control, South China University of Technology, Guangzhou510000, Guangdong, P. R. China
| | - Qingshuai Xu
- School of Environment and Energy, State Key Laboratory of Luminescent Materials and Devices, Guangdong Provincial Key Laboratory of Atmospheric Environment and Pollution Control, South China University of Technology, Guangzhou510000, Guangdong, P. R. China
| | - Yongfu Qiu
- School of Environment and Civil Engineering, Dongguan University of Technology, Dongguan523808, Guangdong, P. R. China
| | - Zhenghui Pan
- Interdisciplinary Materials Research Center, School of Materials Science and Engineering, Tongji University, Shanghai201804, P. R. China
| | - Yongcai Qiu
- School of Environment and Energy, State Key Laboratory of Luminescent Materials and Devices, Guangdong Provincial Key Laboratory of Atmospheric Environment and Pollution Control, South China University of Technology, Guangzhou510000, Guangdong, P. R. China
| |
Collapse
|
14
|
Xiao X, Zheng Z, Zhong X, Gao R, Piao Z, Jiao M, Zhou G. Rational Design of Flexible Zn-Based Batteries for Wearable Electronic Devices. ACS NANO 2023; 17:1764-1802. [PMID: 36716429 DOI: 10.1021/acsnano.2c09509] [Citation(s) in RCA: 23] [Impact Index Per Article: 23.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/18/2023]
Abstract
The advent of 5G and the Internet of Things has spawned a demand for wearable electronic devices. However, the lack of a suitable flexible energy storage system has become the "Achilles' Heel" of wearable electronic devices. Additional problems during the transformation of the battery structure from conventional to flexible also present a severe challenge to the battery design. Flexible Zn-based batteries, including Zn-ion batteries and Zn-air batteries, have long been considered promising candidates due to their high safety, eco-efficiency, substantial reserve, and low cost. In the past decade, researchers have come up with elaborate designs for each portion of flexible Zn-based batteries to improve the ionic conductivities, mechanical properties, environment adaptabilities, and scalable productions. It would be helpful to summarize the reported strategies and compare their pros and cons to facilitate further research toward the commercialization of flexible Zn-based batteries. In this review, the current progress in developing flexible Zn-based batteries is comprehensively reviewed, including their electrolytes, cathodes, and anodes, and discussed in terms of their synthesis, characterization, and performance validation. By clarifying the challenges in flexible Zn-based battery design, we summarize the methodology from previous investigations and propose challenges for future development. In the end, a research paradigm of Zn-based batteries is summarized to fit the burgeoning requirement of wearable electronic devices in an iterative process, which will benefit the future development of Zn-based batteries.
Collapse
Affiliation(s)
- Xiao Xiao
- Tsinghua-Berkeley Shenzhen Institute & Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, People's Republic of China
| | - Zhiyang Zheng
- Tsinghua-Berkeley Shenzhen Institute & Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, People's Republic of China
| | - Xiongwei Zhong
- Tsinghua-Berkeley Shenzhen Institute & Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, People's Republic of China
| | - Runhua Gao
- Tsinghua-Berkeley Shenzhen Institute & Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, People's Republic of China
| | - Zhihong Piao
- Tsinghua-Berkeley Shenzhen Institute & Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, People's Republic of China
| | - Miaolun Jiao
- Tsinghua-Berkeley Shenzhen Institute & Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, People's Republic of China
| | - Guangmin Zhou
- Tsinghua-Berkeley Shenzhen Institute & Tsinghua Shenzhen International Graduate School, Tsinghua University, Shenzhen 518055, People's Republic of China
| |
Collapse
|
15
|
Bo L, Shi W, Nian F, Hu Y, Pu L, Li P, Zhang Z, Tong J. Interface engineering of Co3S4@Co3O4/N, S-doped carbon core@shell nanostructures serve as an excellent bifunctional ORR/OER electrocatalyst for rechargeable Zn-air battery. Sep Purif Technol 2022. [DOI: 10.1016/j.seppur.2022.122536] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
16
|
Xing G, Tong M, Yu P, Wang L, Zhang G, Tian C, Fu H. Reconstruction of Highly Dense Cu−N
4
Active Sites in Electrocatalytic Oxygen Reduction Characterized by Operando Synchrotron Radiation. Angew Chem Int Ed Engl 2022; 61:e202211098. [PMID: 35993239 DOI: 10.1002/anie.202211098] [Citation(s) in RCA: 29] [Impact Index Per Article: 14.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/27/2022] [Indexed: 11/06/2022]
Abstract
The emerging star of single atomic site (SAS) catalyst has been regarded as the most promising Pt-substituted electrocatalyst for oxygen reduction reaction (ORR) in anion-exchange membrane fuel cells (AEMFCs). However, the metal loading in SAS directly affects the whole device performance. Herein, we report a dual nitrogen source coordinated strategy to realize high dense Cu-N4 SAS with a metal loading of 5.61 wt% supported on 3D N-doped carbon nanotubes/graphene structure wherein simultaneously performs superior ORR activity and stability in alkaline media. When applied in H2 /O2 AEMFC, it could reach an open-circuit voltage of 0.90 V and a peak power density of 324 mW cm-2 . Operando synchrotron radiation analyses identify the reconstruction from initial Cu-N4 to Cu-N4 /Cu-nanoclusters (NC) and the subsequent Cu-N3 /Cu-NC under working conditions, which gradually regulate the d-band center of central metal and balance the Gibbs free energy of *OOH and *O intermediates, benefiting to ORR activity.
Collapse
Affiliation(s)
- Gengyu Xing
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Miaomiao Tong
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Peng Yu
- Key Laboratory for Photonic and Electronic Bandgap Materials Ministry of Education, School of Physics and Electronic Engineering Harbin Normal University Harbin 150025 China
| | - Lei Wang
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Guangying Zhang
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Chungui Tian
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Honggang Fu
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| |
Collapse
|
17
|
Li G, Qi X, Xiao Y, Zhao Y, Li K, Xia Y, Wan X, Wu J, Yang C. An Efficient Voltammetric Sensor Based on Graphene Oxide-Decorated Binary Transition Metal Oxides Bi 2O 3/MnO 2 for Trace Determination of Lead Ions. NANOMATERIALS (BASEL, SWITZERLAND) 2022; 12:3317. [PMID: 36234444 PMCID: PMC9565483 DOI: 10.3390/nano12193317] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 08/22/2022] [Revised: 09/18/2022] [Accepted: 09/20/2022] [Indexed: 06/16/2023]
Abstract
Herein we present a facile synthesis of the graphene oxide-decorated binary transition metal oxides of Bi2O3 and MnO2 nanocomposites (Bi2O3/MnO2/GO) and their applications in the voltammetric detection of lead ions (Pb2+) in water samples. The surface morphologies, crystal structures, electroactive surface area, and charge transferred resistance of the Bi2O3/MnO2/GO nanocomposites were investigated through the scanning electron microscopy (SEM), power X-ray diffraction (XRD), cyclic voltammetry (CV), and electrochemical impedance spectroscopy (EIS) techniques, respectively. The Bi2O3/MnO2/GO nanocomposites were further decorated onto the surface of a glassy carbon electrode (GCE), and Pb2+ was quantitatively analyzed by using square-wave anodic stripping voltammetry (SWASV). We explored the effect of the analytical parameters, including deposition potential, deposition time, and solution pH, on the stripping peak current of Pb2+. The Bi2O3/MnO2/GO nanocomposites enlarged the electroactive surface area and reduced the charge transferred resistance by significant amounts. Moreover, the synergistic enhancement effect of MnO2, Bi2O3 and GO endowed Bi2O3/MnO2/GO/GCE with extraordinary electrocatalytic activity toward Pb2+ stripping. Under optimal conditions, the Bi2O3/MnO2/GO/GCE showed a broad linear detection range (0.01-10 μM) toward Pb2+ detection, with a low limit of detection (LOD, 2.0 nM). The proposed Bi2O3/MnO2/GO/GCE electrode achieved an accurate detection of Pb2+ in water with good recoveries (95.5-105%).
Collapse
Affiliation(s)
- Guangli Li
- College of Life Sciences and Chemistry, Hunan University of Technology, Zhuzhou 412007, China
| | - Xiaoman Qi
- College of Life Sciences and Chemistry, Hunan University of Technology, Zhuzhou 412007, China
| | - Yang Xiao
- College of Life Sciences and Chemistry, Hunan University of Technology, Zhuzhou 412007, China
| | - Yuchi Zhao
- College of Life Sciences and Chemistry, Hunan University of Technology, Zhuzhou 412007, China
| | - Kanghua Li
- Department of Neurology, Zhuzhou People’s Hospital, Zhuzhou 412008, China
| | - Yonghui Xia
- Zhuzhou Institute for Food and Drug Control, Zhuzhou 412011, China
| | - Xuan Wan
- College of Life Sciences and Chemistry, Hunan University of Technology, Zhuzhou 412007, China
| | - Jingtao Wu
- College of Life Sciences and Chemistry, Hunan University of Technology, Zhuzhou 412007, China
| | - Chun Yang
- College of Life Sciences and Chemistry, Hunan University of Technology, Zhuzhou 412007, China
| |
Collapse
|
18
|
Xing G, Tong M, Yu P, Wang L, Zhang G, Tian C, Fu H. Reconstruction of Highly Dense Cu−N4 Active Sites in Electrocatalytic Oxygen Reduction Characterized by Operando Synchrotron Radiation. Angew Chem Int Ed Engl 2022. [DOI: 10.1002/ange.202211098] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022]
Affiliation(s)
- Gengyu Xing
- Heilongjiang University Key Laboratory of Functional Inorganic Materials Chemistry, Ministry of Education of the People’s Republic of China CHINA
| | - Miaomiao Tong
- Heilongjiang University Key Laboratory of Functional Inorganic Materials Chemistry, Ministry of Education of the People’s Republic of China CHINA
| | - Peng Yu
- Harbin Normal University Key Laboratory for Photonic and Electronic Bandgap Materials, Ministry of Education, School of Physics and Electronic Engineering CHINA
| | - Lei Wang
- Heilongjiang University Key Laboratory of Functional Inorganic Materials Chemistry, Ministry of Education of the People’s Republic of China CHINA
| | - Guangying Zhang
- Heilongjiang University Key Laboratory of Functional Inorganic Materials Chemistry, Ministry of Education of the People’s Republic of China CHINA
| | - Chungui Tian
- Heilongjiang University Key Laboratory of Functional Inorganic Materials Chemistry, Ministry of Education of the People’s Republic of China CHINA
| | - Honggang Fu
- Heilongjiang University Key Laboratory of Functional Inorganic Material Chemistry, Ministry of Education of the People’s Republic of China Xuefu Road 150080 Harbin CHINA
| |
Collapse
|
19
|
Xiang W, Li Y, Wu M, Ma J, Sheng Z. Co-doped CeO 2/N-C nanorods as a bifunctional oxygen electrocatalyst and its application in rechargeable Zn-air batteries. NANOTECHNOLOGY 2022; 33:415404. [PMID: 35793593 DOI: 10.1088/1361-6528/ac7ed1] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/03/2022] [Accepted: 07/05/2022] [Indexed: 06/15/2023]
Abstract
The development of electrocatalysts for both oxygen reduction reaction (ORR) and oxygen evolution reaction (OER) with high-activity and atability still remain great challenges for rechargeable Zn-air batteries. Herein, a new type of Co-doped Ce-N-C bifunctional electrocatalyst has been synthesized through a simple two-step method, which realizes the high dispersion of Co3O4on the CeO2carbon frame and stabilizes its specific surface area. Benefiting from the synergistic interaction between Co3O4and CeO2, the conductivity of the electrocatalyst is improved and the oxygen reduction reaction/oxygen storage properties are promoted. The resultant Co3O4-CeO2@N-C catalyst shows remarkable ORR activity with the high initial potential (E0 = 0.8 V), the large limiting current density (jL = 6 mA cm-2), and a low Tafel slope (81 mV dec-1). In full cell tests, Co3O4-CeO2@NC as the oxygen electrode exhibites superior charge/discharge capacity and excellent cycle stability. The assembled Zn-air battery achieves a maximum power density of 110 mW cm-2at a current density of 180 mA cm-2, and a high specific capacity of 780 mAh g-1at a discharge current density of 10 mA cm-2.
Collapse
Affiliation(s)
- Wenjuan Xiang
- School of Chemistry and Chemical Engineering, North Minzu University, Yinchuan 750021, People's Republic of China
- Ningxia Research Center of Silicon Target and Silicon-Carbon Negative Material Engineering Technology, Yinchuan 750021, People's Republic of China
| | - Yanling Li
- Ningxia Research Center of Silicon Target and Silicon-Carbon Negative Material Engineering Technology, Yinchuan 750021, People's Republic of China
| | - Mengxue Wu
- Ningxia Research Center of Silicon Target and Silicon-Carbon Negative Material Engineering Technology, Yinchuan 750021, People's Republic of China
| | - Jinfu Ma
- School of Chemistry and Chemical Engineering, North Minzu University, Yinchuan 750021, People's Republic of China
- Ningxia Research Center of Silicon Target and Silicon-Carbon Negative Material Engineering Technology, Yinchuan 750021, People's Republic of China
| | - Zhilin Sheng
- Ningxia Research Center of Silicon Target and Silicon-Carbon Negative Material Engineering Technology, Yinchuan 750021, People's Republic of China
| |
Collapse
|
20
|
Hang X, Xue Y, Zhao J, Yang R, Pang H. In Situ Generation of NiCoP Nanoparticles on a Bimetal-Organic Framework for High-Performance Supercapacitors. Inorg Chem 2022; 61:10435-10441. [PMID: 35767374 DOI: 10.1021/acs.inorgchem.2c01239] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
Abstract
The rational exploration of hybrid materials with well-defined compositions and structures/morphologies is essential for achieving high-performance electrodes for supercapacitors. Here, in situ dispersion and anchoring of NiCoP nanoparticles (NPs) on a bimetal-organic framework (Co1Ni2-MOF) by a controllable partial phosphorization approach are reported. The phosphating temperature and time significantly affect the specific capacitance of NiCoP/Co1Ni2-MOF-X-Y (where X and Y represent the phosphating temperature and time, respectively). Co1Ni2-MOF provides anchoring sites for confining NiCoP NPs, effectively improving the stability of NiCoP NPs. Highly dispersed NiCoP NPs facilitate OH- adsorption, boosting the redox reaction kinetics. NiCoP/Co1Ni2-MOF-350-2 with optimized phosphating conditions exhibits a high specific capacitance of 525 F g-1 at 0.5 A g-1, which is superior to that of the precursor of Co1Ni2-MOF. Moreover, a hybrid supercapacitor constructed with NiCoP/Co1Ni2-MOF-350-2 and activated carbon shows a high specific capacitance and outstanding long-term stability.
Collapse
Affiliation(s)
- Xinxin Hang
- School of Chemistry and Chemical Engineering, Institute for Innovative Materials and Energy, Yangzhou University, Yangzhou 225002, Jiangsu, P. R. China
| | - Yadan Xue
- School of Chemistry and Chemical Engineering, Institute for Innovative Materials and Energy, Yangzhou University, Yangzhou 225002, Jiangsu, P. R. China
| | - Jiawei Zhao
- School of Chemistry and Chemical Engineering, Institute for Innovative Materials and Energy, Yangzhou University, Yangzhou 225002, Jiangsu, P. R. China
| | - Rui Yang
- School of Chemistry and Chemical Engineering, Institute for Innovative Materials and Energy, Yangzhou University, Yangzhou 225002, Jiangsu, P. R. China
| | - Huan Pang
- School of Chemistry and Chemical Engineering, Institute for Innovative Materials and Energy, Yangzhou University, Yangzhou 225002, Jiangsu, P. R. China
| |
Collapse
|
21
|
Sim WJ, Nguyen MT, Huang Z, Kheawhom S, Wattanakit C, Yonezawa T. Efficient iron-cobalt oxide bifunctional electrode catalysts in rechargeable high current density zinc-air batteries. NANOSCALE 2022; 14:8012-8022. [PMID: 35612908 DOI: 10.1039/d2nr01258h] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/15/2023]
Abstract
Iron-cobalt (FeCo) oxides dispersed on reduced graphene oxide (rGO) were synthesized from nitrate precursors at loading levels from 10 wt% to 60 wt%. These catalysts were tested in lab-scale zinc-air batteries (ZABs) at a high current density of 100 mA cm-2 of the cathode area for the first time, cycling between 60 min of discharging and 60 min of charging. The optimum loading level for the best ZAB cycling performance was found to be 40 wt%, at which CoFe2O4 and CoO nanocrystals were detected. A discharge capacity of at least 90% was maintained for about 60 cycles with FeCo 40 wt%, demonstrating superior stability over amorphous FeCo oxides with FeCo 10 wt% despite similar performance at electrochemical tests. At a high current density of 100 mA cm-2, OER catalytic activity was found to be the limiting factor in ZAB's cyclability. The discrepancies between the ORR/OER catalytic activities by electrochemical and battery cycling test results highlight the role and importance of rGO in improving electrical conductivity and activation of metal oxide electrocatalysts under high current density conditions. The difference of battery cycling test results from traditional electrochemical test results suggests that electrochemical tests conducted at low current densities may be inadequate in predicting practical battery cycling performance.
Collapse
Affiliation(s)
- Wei Jian Sim
- Division of Materials Science and Engineering, Faculty of Engineering, Hokkaido University, Kita 13 Nishi 8, Kita-ku, Sapporo, Hokkaido 060-8628, Japan.
| | - Mai Thanh Nguyen
- Division of Materials Science and Engineering, Faculty of Engineering, Hokkaido University, Kita 13 Nishi 8, Kita-ku, Sapporo, Hokkaido 060-8628, Japan.
| | - Zixuan Huang
- Division of Materials Science and Engineering, Faculty of Engineering, Hokkaido University, Kita 13 Nishi 8, Kita-ku, Sapporo, Hokkaido 060-8628, Japan.
| | - Soorathep Kheawhom
- Department of Chemical Engineering, Faculty of Engineering, Chulalongkorn University, Payathai Road Pathumwan, Bangkok 10330, Thailand
| | - Chularat Wattanakit
- Vidyasirimedhi Institute of Science and Technology (VISTEC), Wangchan Valley 555 Moo 1 Payupnai, Wangchan, Rayong 21210, Thailand
| | - Tetsu Yonezawa
- Division of Materials Science and Engineering, Faculty of Engineering, Hokkaido University, Kita 13 Nishi 8, Kita-ku, Sapporo, Hokkaido 060-8628, Japan.
| |
Collapse
|
22
|
He Y, Yin Z, Wang Z, Wang H, Xiong W, Song B, Qin H, Xu P, Zeng G. Metal-organic frameworks as a good platform for the fabrication of multi-metal nanomaterials: design strategies, electrocatalytic applications and prospective. Adv Colloid Interface Sci 2022; 304:102668. [PMID: 35489143 DOI: 10.1016/j.cis.2022.102668] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/17/2021] [Revised: 04/01/2022] [Accepted: 04/06/2022] [Indexed: 11/01/2022]
Abstract
MOF-derived multi-metal nanomaterials are attracting numerous attentions in widespread applications such as catalysis, sensors, energy storage and conversion, and environmental remediation. Compared to the monometallic counterparts, the presence of foreign metal is expected to bring new physicochemical properties, thus exhibiting synergistic effect for enhanced performance. MOFs have been proved as a good platform for the fabrication of polymetallic nanomaterials with requisite features. Herein, various design strategies related to constructing multi-metallic nanomaterials from MOFs are summarized for the first time, involving metal nodal substitution, seed epitaxial growth, ion-exchange strategy, guest species encapsulation, solution impregnation and combination with extraneous substrate. Afterwards, the recent advances of multi-metallic nanomaterials for electrocatalytic applications, including oxygen reduction reaction (ORR), oxygen evolution reaction (OER) and hydrogen evolution reaction (HER), are systematically discussed. Finally, a personal outlook on the future trends and challenges are also presented with hope to enlighten deeper understanding and new thoughts for the development of multi-metal nanomaterials from MOFs.
Collapse
|
23
|
Lv D. Layered double hydroxides functionalized by carbonaceous materials: from preparation to energy and environmental applications. ENVIRONMENTAL SCIENCE AND POLLUTION RESEARCH INTERNATIONAL 2022; 29:30865-30891. [PMID: 35094279 DOI: 10.1007/s11356-021-18179-7] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/26/2021] [Accepted: 12/14/2021] [Indexed: 06/14/2023]
Abstract
Along with the exponential demand for energy and pollution-free-environment, layered double hydroxides (LDHs) have gained extensive explorations because of their diverse nanostructures and tunable elemental compositions. However, the applications of LDHs are hindered by their poor activity, sluggish mass transfer, and aggregation. LDHs functionalized by carbonaceous materials (CMs) (LDH-CM) are expected to overcome the above disadvantages and even generate more excellent performance. This review first analyzes the research evolvement of LDH-CM composites during the past 25 years. Next, the advantages of LDH-CM composites are highlighted, such as morphology optimization, high electrical conductivity, more stable, good heat, and mass transfer performance. Following the synthetic strategies, including chemical assembly of LDHs and CMs, direct growth of LDH on CMs (two-step nucleation and growth and surface-confined growth) and direct CM formation on LDHs are fully discussed. Then, the recent progress achieved in LDH-CM composites for the application of energy storage and environmental protection is summarized in detail. In particular, the review illustrates the reasons why these constructing strategies can improve the performance of LDH-CM composites. Finally, challenges and future research prospects of LDH-CM composites are highlighted.
Collapse
Affiliation(s)
- Dong Lv
- National Natural Science Foundation of China, Beijing, 100085, People's Republic of China.
| |
Collapse
|
24
|
Li G, Qi X, Zhang G, Wang S, Li K, Wu J, Wan X, Liu Y, Li Q. Low-cost Voltammetric Sensors for Robust Determination of Toxic Cd(II) and Pb(II) in Environment and Food Based on Shuttle-like α-Fe2O3 Nanoparticles Decorated β-Bi2O3 Microspheres. Microchem J 2022. [DOI: 10.1016/j.microc.2022.107515] [Citation(s) in RCA: 15] [Impact Index Per Article: 7.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/12/2022]
|
25
|
Zhao CX, Liu JN, Wang J, Wang C, Guo X, Li XY, Chen X, Song L, Li BQ, Zhang Q. A clicking confinement strategy to fabricate transition metal single-atom sites for bifunctional oxygen electrocatalysis. SCIENCE ADVANCES 2022; 8:eabn5091. [PMID: 35294235 PMCID: PMC8926326 DOI: 10.1126/sciadv.abn5091] [Citation(s) in RCA: 54] [Impact Index Per Article: 27.0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/01/2021] [Accepted: 01/25/2022] [Indexed: 05/20/2023]
Abstract
Rechargeable zinc-air batteries call for high-performance bifunctional oxygen electrocatalysts. Transition metal single-atom catalysts constitute a promising candidate considering their maximum atom efficiency and high intrinsic activity. However, the fabrication of atomically dispersed transition metal sites is highly challenging, creating a need for for new design strategies and synthesis methods. Here, a clicking confinement strategy is proposed to efficiently predisperse transitional metal atoms in a precursor directed by click chemistry and ensure successful construction of abundant single-atom sites. Concretely, cobalt-coordinated porphyrin units are covalently clicked on the substrate for the confinement of the cobalt atoms and affording a Co-N-C electrocatalyst. The Co-N-C electrocatalyst exhibits impressive bifunctional oxygen electrocatalytic performances with an activity indicator ΔE of 0.79 V. This work extends the approach to prepare transition metal single-atom sites for efficient bifunctional oxygen electrocatalysis and inspires the methodology on precise synthesis of catalytic materials.
Collapse
Affiliation(s)
- Chang-Xin Zhao
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing 100084, China
| | - Jia-Ning Liu
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing 100084, China
| | - Juan Wang
- Advanced Research Institute of Multidisciplinary Science, Beijing Institute of Technology, Beijing 100081, China
- School of Materials Science and Engineering, Beijing Institute of Technology, Beijing 100081, China
| | - Changda Wang
- National Synchrotron Radiation Laboratory, CAS Center for Excellence in Nanoscience, University of Science and Technology of China, Hefei 230029, Anhui, China
| | - Xin Guo
- National Synchrotron Radiation Laboratory, CAS Center for Excellence in Nanoscience, University of Science and Technology of China, Hefei 230029, Anhui, China
| | - Xi-Yao Li
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing 100084, China
| | - Xiao Chen
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing 100084, China
| | - Li Song
- National Synchrotron Radiation Laboratory, CAS Center for Excellence in Nanoscience, University of Science and Technology of China, Hefei 230029, Anhui, China
| | - Bo-Quan Li
- Advanced Research Institute of Multidisciplinary Science, Beijing Institute of Technology, Beijing 100081, China
- School of Materials Science and Engineering, Beijing Institute of Technology, Beijing 100081, China
- Corresponding author. (B.-Q.L.); (Q.Z.)
| | - Qiang Zhang
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing 100084, China
- Corresponding author. (B.-Q.L.); (Q.Z.)
| |
Collapse
|
26
|
Deng S, Tie Z, Yue F, Cao H, Yao M, Niu Z. Rational Design of ZnMn 2 O 4 Quantum Dots in a Carbon Framework for Durable Aqueous Zinc-Ion Batteries. Angew Chem Int Ed Engl 2022; 61:e202115877. [PMID: 34989074 DOI: 10.1002/anie.202115877] [Citation(s) in RCA: 26] [Impact Index Per Article: 13.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/22/2021] [Indexed: 11/07/2022]
Abstract
Manganese oxides are promising cathode materials for aqueous zinc-ion batteries (ZIBs) due to their high energy density and low cost. However, in their discharging processes, the Jahn-Teller effect and Mn3+ disproportionation often lead to irreversible structural transformation and Mn2+ dissolution, deteriorating the cycling stability of ZIBs. Herein, ZnMn2 O4 quantum dots (ZMO QDs) were introduced into a porous carbon framework by in-situ electrochemically inducing Mn-MIL-100-derived Mn3 O4 quantum dots and the carbon composite. In such ZMO QDs and carbon composite, the quantum dot structure endows ZnMn2 O4 with a shorter ion diffusion route and more active sites for Zn2+ . The conductive carbon framework is beneficial to the fast transport of electrons. Furthermore, at the interface between the ZMO QDs and the carbon matrix, the Mn-O-C bonds are formed. They can effectively suppress the Jahn-Teller effect and manganese dissolution of discharge products. Therefore, Zn/ZMO QD@C batteries display remarkably enhanced electrochemical performance.
Collapse
Affiliation(s)
- Shenzhen Deng
- Key Laboratory of Advanced Energy Materials Chemistry (Ministry of Education), Renewable Energy Conversion and Storage Center, College of Chemistry, Nankai University, Tianjin, 300071, P. R. China
| | - Zhiwei Tie
- Key Laboratory of Advanced Energy Materials Chemistry (Ministry of Education), Renewable Energy Conversion and Storage Center, College of Chemistry, Nankai University, Tianjin, 300071, P. R. China
| | - Fang Yue
- Key Laboratory of Advanced Energy Materials Chemistry (Ministry of Education), Renewable Energy Conversion and Storage Center, College of Chemistry, Nankai University, Tianjin, 300071, P. R. China
| | - Hongmei Cao
- Key Laboratory of Advanced Energy Materials Chemistry (Ministry of Education), Renewable Energy Conversion and Storage Center, College of Chemistry, Nankai University, Tianjin, 300071, P. R. China
| | - Minjie Yao
- Key Laboratory of Advanced Energy Materials Chemistry (Ministry of Education), Renewable Energy Conversion and Storage Center, College of Chemistry, Nankai University, Tianjin, 300071, P. R. China
| | - Zhiqiang Niu
- Key Laboratory of Advanced Energy Materials Chemistry (Ministry of Education), Renewable Energy Conversion and Storage Center, College of Chemistry, Nankai University, Tianjin, 300071, P. R. China
| |
Collapse
|
27
|
Javed O, Abd Aziz R. Bimetallic Prussian Blue Analogues: An Efficient Electrode Alternative for Energy Storage Applications. MATERIALS SCIENCE FORUM 2022; 1056:45-52. [DOI: 10.4028/p-tb6bwr] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 09/01/2023]
Abstract
In the past few years Prussian Blue Analogues (PBAs), as advanced metal organic framework compounds, have gathered a lot of attention due to its three-dimensional structural network and properties. PBAs are famous for their multitasking ability as they have shown an efficient role in scientific research and development with their excellent performance in various fields like, electrochemical sensors, photocatalysis, electrocatalysis, and energy storage applications. Apart from their high-tech productivity, PBAs also have some other advantages associated to them such as benign nature, economical and facile synthesis, extensive surface properties, higher theoretical capacity and exceptional electrochemical behavior which makes it more promising material for energy storage application. To further tune its properties according to the application of interest, the chemical modification by metal incorporation is the most commonly adopted strategy. For this purpose, the major research is done in the synthesis of bimetallic PBAs. The presence of metal atoms with different oxidation states can bring about dramatic reinforcements like finer microstructures with better crystallographic features, ultimately giving rise to more stable electrochemical behavior. In this article, we aim to list out all the bimetallic PBAs with focus on the synergistic effect of more than one metal within the structure of PBA and thorough analysis of their Electrochemical properties in energy storage applications.
Collapse
|
28
|
Najam T, Ahmad Khan N, Ahmad Shah SS, Ahmad K, Sufyan Javed M, Suleman S, Sohail Bashir M, Hasnat MA, Rahman MM. Metal-Organic Frameworks Derived Electrocatalysts for Oxygen and Carbon Dioxide Reduction Reaction. CHEM REC 2022; 22:e202100329. [PMID: 35119193 DOI: 10.1002/tcr.202100329] [Citation(s) in RCA: 9] [Impact Index Per Article: 4.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/18/2021] [Revised: 01/22/2022] [Indexed: 12/26/2022]
Abstract
The increasing demands of energy and environmental concerns have motivated researchers to cultivate renewable energy resources for replacing conventional fossil fuels. The modern energy conversion and storage devices required high efficient and stable electrocatalysts to fulfil the market demands. In previous years, we are witness for considerable developments of scientific attention in Metal-organic Frameworks (MOFs) and their derived nanomaterials in electrocatalysis. In current review article, we have discussed the progress of optimistic strategies and approaches for the manufacturing of MOF-derived functional materials and their presentation as electrocatalysts for significant energy related reactions. MOFs functioning as a self-sacrificing template bid different benefits for the preparation of metal nanostructures, metal oxides and carbon-abundant materials promoting through the porous structure, organic functionalities, abundance of metal sites and large surface area. Thorough study for the recent advancement in the MOF-derived materials, metal-coordinated N-doped carbons with single-atom active sites are emerging candidates for future commercial applications. However, there are some tasks that should be addressed, to attain improved, appreciative and controlled structural parameters for catalytic and chemical behavior.
Collapse
Affiliation(s)
- Tayyaba Najam
- College of Chemistry and Environmental Engineering, Shenzhen University, Shenzhen, 518060, China
| | - Naseem Ahmad Khan
- Institute of Chemistry, The Islamia University of Bahawalpur, Bahawalpur, 63100, Pakistan
| | - Syed Shoaib Ahmad Shah
- Institute of Chemistry, The Islamia University of Bahawalpur, Bahawalpur, 63100, Pakistan.,Hefei National Laboratory for Physical Sciences at the Microscale, CAS Key Laboratory of Soft Matter Chemistry, Department of Chemistry, University of Science and Technology of China, Hefei, Anhui 230026, P.R. China
| | - Khalil Ahmad
- Institute of Chemistry, The Islamia University of Bahawalpur, Bahawalpur, 63100, Pakistan
| | - Muhammad Sufyan Javed
- School of Physical Science and Technology, Lanzhou University, Lanzhou, 730000, China
| | - Suleman Suleman
- Hefei National Laboratory for Physical Sciences at the Microscale, CAS Key Laboratory of Soft Matter Chemistry, Department of Chemistry, University of Science and Technology of China, Hefei, Anhui 230026, P.R. China
| | - Muhammad Sohail Bashir
- Hefei National Laboratory for Physical Sciences at the Microscale, CAS Key Laboratory of Soft Matter Chemistry, Department of Polymer Science and Engineering, University of Science and Technology of China, Hefei, Anhui 230026, P.R. China
| | - Mohammad A Hasnat
- Electrochemistry & Catalysis Research Laboratory (ECRL), Department of Chemistry, School of Physical Sciences, Shahjalal University of Science and Technology, Sylhet, 3100, Bangladesh
| | - Mohammed M Rahman
- Center of Excellence for Advanced Materials Research (CEAMR) & Department of Chemistry, Faculty of Science, King Abdulaziz University, Jeddah, 21589, Jeddah, Saudi Arabia
| |
Collapse
|
29
|
Deng S, Tie Z, Yue F, Cao H, Yao M, Niu Z. Rational Design of ZnMn2O4 Quantum Dots in Carbon Framework for Durable Aqueous Zinc‐Ion Batteries. Angew Chem Int Ed Engl 2022. [DOI: 10.1002/ange.202115877] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/12/2022]
Affiliation(s)
| | - Zhiwei Tie
- Nankai University College of Chemistry CHINA
| | - Fang Yue
- Nankai University College of Chemistry CHINA
| | - Hongmei Cao
- Nankai University College of Chemistry CHINA
| | - Minjie Yao
- Nankai University College of Chemistry CHINA
| | - Zhiqiang Niu
- Nankai University No.94, Weijin Road 300071 Tianjin CHINA
| |
Collapse
|
30
|
Pen-drawn air cathode featuring graphite felt substrate modified with MnO2-decorated graphene flakes and PEDOT network for rechargeable zinc–air battery. J IND ENG CHEM 2022. [DOI: 10.1016/j.jiec.2022.01.019] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
|
31
|
Yu Z, Liu C, Chen J, Yuan Z, Chen Y, Wei L. High-performance Fe–N–C electrocatalysts with a “chain mail” protective shield. NANO MATERIALS SCIENCE 2021. [DOI: 10.1016/j.nanoms.2021.05.008] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/26/2022]
|
32
|
Zhang T, Bian J, Zhu Y, Sun C. FeCo Nanoparticles Encapsulated in N-Doped Carbon Nanotubes Coupled with Layered Double (Co, Fe) Hydroxide as an Efficient Bifunctional Catalyst for Rechargeable Zinc-Air Batteries. SMALL (WEINHEIM AN DER BERGSTRASSE, GERMANY) 2021; 17:e2103737. [PMID: 34553487 DOI: 10.1002/smll.202103737] [Citation(s) in RCA: 19] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/26/2021] [Indexed: 06/13/2023]
Abstract
Low-cost bifunctional nonprecious metal catalysts toward oxygen reduction reaction (ORR) and oxygen evolution reaction (OER) are critical for the commercialization of rechargeable zinc-air batteries (ZABs). However, the preparation of highly active and durable bifunctional catalysts is still challenging. Herein, an efficient catalyst is reported consisting of FeCo nanoparticles embedded in N-doped carbon nanotubes (FeCo NPs-N-CNTs) by an in situ catalytic strategy. Due to the encapsulation and porous structure of N-doped carbon nanotubes, the catalyst shows high activity toward ORR and excellent durability. Furthermore, to enhance the OER activity, CoFe-layer double hydroxide (CoFe-LDH) is coupled with FeCo NPs-N-CNTs by in situ reaction approach. As the air electrode for rechargeable ZABs, the cell with CoFe-LDH@FeCo NPs-N-CNTs catalyst exhibits high open-circuit potential (OCP) of 1.51 V, high power density of 116 mW cm-2 , and remarkable durability up to 100 h, demonstrating its great promise for the practical application of the rechargeable ZABs.
Collapse
Affiliation(s)
- Tongrui Zhang
- School of Chemistry and Chemical Engineering, Guangxi University, Nanning, Guangxi, 530004, P. R. China
- School of Chemical and Environmental Engineering, China University of Mining & Technology (Beijing), Beijing, 100083, China
- CAS Center for Excellence in Nanoscience, Beijing Institute of Nanoenergy and Nanosystems, Chinese Academy of Sciences, Beijing, 100083, China
| | - Juanjuan Bian
- School of Nanoscience and Technology, University of Chinese Academy of Sciences, Beijing, 100049, China
- CAS Center for Excellence in Nanoscience, Beijing Institute of Nanoenergy and Nanosystems, Chinese Academy of Sciences, Beijing, 100083, China
| | - Yuanqin Zhu
- School of Chemistry and Chemical Engineering, Guangxi University, Nanning, Guangxi, 530004, P. R. China
| | - Chunwen Sun
- School of Chemistry and Chemical Engineering, Guangxi University, Nanning, Guangxi, 530004, P. R. China
- School of Chemical and Environmental Engineering, China University of Mining & Technology (Beijing), Beijing, 100083, China
- School of Nanoscience and Technology, University of Chinese Academy of Sciences, Beijing, 100049, China
- CAS Center for Excellence in Nanoscience, Beijing Institute of Nanoenergy and Nanosystems, Chinese Academy of Sciences, Beijing, 100083, China
| |
Collapse
|
33
|
CoFe2O4 nanoparticles@N-doped carbon coupled with N-doped graphene toward efficient electrochemical water oxidation. Colloids Surf A Physicochem Eng Asp 2021. [DOI: 10.1016/j.colsurfa.2021.126898] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/22/2022]
|
34
|
Sheng K, Yi Q, Chen AL, Wang Y, Yan Y, Nie H, Zhou X. CoNi Nanoparticles Supported on N-Doped Bifunctional Hollow Carbon Composites as High-Performance ORR/OER Catalysts for Rechargeable Zn-Air Batteries. ACS APPLIED MATERIALS & INTERFACES 2021; 13:45394-45405. [PMID: 34519493 DOI: 10.1021/acsami.1c10671] [Citation(s) in RCA: 16] [Impact Index Per Article: 5.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/13/2023]
Abstract
Searching for high-quality air electrode catalysts is the long-term goal for the practical application of Zn-air batteries. Here, a series of coexistent composite materials (CoNi/NHCS-TUC-x) of cobalt-nickel supported on nitrogen-doped hollow spherical carbon and tubular carbon are obtained using a simple pyrolysis strategy. Co and Ni in the composites are mainly present in the form of alloy nanoparticles, M-Nx and M-Cx (M = Co or Ni) species, with high oxygen reduction reaction (ORR)/oxygen evolution reaction (OER) electroactivity. The materials containing different proportions of spherical carbon and tubular carbon obtained by simply adjusting the raw materials for generating tubular carbon exhibit interesting bifunctional performance: samples with an abundant tubular content have the highest ORR onset potential (0.91 V vs reversible hydrogen electrode), while those with a rich spherical content have the highest ORR current density (5.13 mA·cm-2). Furthermore, CoNi/NHCS-TUC-3 provides the lowest potential difference (ΔE = Ej=10 - E1/2) of 0.806 V. We then test the potential possibility of CoNi/NHCS-TUC-3 as an air electrode for primary and rechargeable Zn-air batteries. The primary battery delivers an open-circuit potential of 1.59 V, a peak power density of 361.8 mA·cm-2, and a specific capacity of 756.5 mA h·gZn-1. The rechargeable battery could be cycled stably for more than 55 h at 10 mA·cm-2. These characteristics make CoNi/NHCS-TUC-3 a superior electrocatalyst for both the ORR and OER, as well as a suitable bifunctional electrode applied to a rechargeable Zn-air battery.
Collapse
Affiliation(s)
- Kuang Sheng
- School of Chemistry and Chemical Engineering, Hunan University of Science and Technology, Xiangtan 411201, Hunan, China
| | - Qingfeng Yi
- School of Chemistry and Chemical Engineering, Hunan University of Science and Technology, Xiangtan 411201, Hunan, China
- Hunan Provincial Key Laboratory of Advanced Materials for New Energy Storage and Conversion, Xiangtan 411201, China
| | - A-Ling Chen
- School of Chemistry and Chemical Engineering, Hunan University of Science and Technology, Xiangtan 411201, Hunan, China
| | - Yuebing Wang
- School of Chemistry and Chemical Engineering, Hunan University of Science and Technology, Xiangtan 411201, Hunan, China
| | - Yuhui Yan
- School of Chemistry and Chemical Engineering, Hunan University of Science and Technology, Xiangtan 411201, Hunan, China
| | - Huidong Nie
- School of Chemistry and Chemical Engineering, Hunan University of Science and Technology, Xiangtan 411201, Hunan, China
| | - Xiulin Zhou
- School of Chemistry and Chemical Engineering, Hunan University of Science and Technology, Xiangtan 411201, Hunan, China
| |
Collapse
|
35
|
Cui X, Liu Y, Han G, Cao M, Han L, Zhou B, Mehdi S, Wu X, Li B, Jiang J. Wood-Derived Integral Air Electrode for Enhanced Interfacial Electrocatalysis in Rechargeable Zinc-Air Battery. SMALL (WEINHEIM AN DER BERGSTRASSE, GERMANY) 2021; 17:e2101607. [PMID: 34365727 DOI: 10.1002/smll.202101607] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/03/2021] [Revised: 06/05/2021] [Indexed: 06/13/2023]
Abstract
Zinc-air batteries (ZABs) are promising as energy storage devices owing to their high energy density and the safety of electrolytes. Construction of abundant triple-phase boundary (TPB) effectively facilitates cathode reactions occurring at TPB. Herein, a wood-derived integral air electrode containing Co/CoO nanoparticles and nitrogen-doped carbonized wood (Co/CoO@NWC) is constructed with a dual catalytic function. The potential gap between oxygen reduction and evolution is shortened to 0.77 V. Liquid ZABs using Co/CoO@NWC as cathode exhibit high discharge specific capacity (800 mAh gZn-1 ), low charge-discharge gap (0.84 V), and long-term cycling stability (270 h). Co/CoO@NWC also shows distinguished catalytic activity and stability in all-solid-state ZABs. The inherent layered porous and pipe structures of wood are well maintained in catalytically active carbon. The different hydrophilicity of carbonized wood and Co/CoO endow abundant TPBs for battery reaction. The Co/CoO located on TPB provides main active sites for oxygen reactions. The inherent pipe structures of wood carbon and the interaction between Co/CoO and NWC effectively prevent nanoparticles from aggregation. The design and preparation of this monolithic electrocatalyst contribute to the broad-scale application of ZABs and promote the development of next-generation biomass-based storage devices.
Collapse
Affiliation(s)
- Xingyu Cui
- Research Center of Green Catalysis, College of Chemistry, Zhengzhou University, 100 Science Road, Zhengzhou, 450001, P. R. China
| | - Yanyan Liu
- Research Center of Green Catalysis, College of Chemistry, Zhengzhou University, 100 Science Road, Zhengzhou, 450001, P. R. China
- Institute of Chemical Industry of Forest Products, CAF, National Engineering Lab for Biomass Chemical Utilization, Nanjing, 210042, P. R. China
- College of Science, Henan Agricultural University, Zhengzhou, 450002, P.R. China
| | - Guosheng Han
- Research Center of Green Catalysis, College of Chemistry, Zhengzhou University, 100 Science Road, Zhengzhou, 450001, P. R. China
| | - Mengmeng Cao
- Research Center of Green Catalysis, College of Chemistry, Zhengzhou University, 100 Science Road, Zhengzhou, 450001, P. R. China
| | - Lei Han
- Research Center of Green Catalysis, College of Chemistry, Zhengzhou University, 100 Science Road, Zhengzhou, 450001, P. R. China
| | - Benji Zhou
- Research Center of Green Catalysis, College of Chemistry, Zhengzhou University, 100 Science Road, Zhengzhou, 450001, P. R. China
| | - Sehrish Mehdi
- Research Center of Green Catalysis, College of Chemistry, Zhengzhou University, 100 Science Road, Zhengzhou, 450001, P. R. China
- Department of Chemistry, The Women University, Kutchery Campus, L.M.Q. Road, Multan, 66000, Pakistan
| | - Xianli Wu
- Research Center of Green Catalysis, College of Chemistry, Zhengzhou University, 100 Science Road, Zhengzhou, 450001, P. R. China
| | - Baojun Li
- Research Center of Green Catalysis, College of Chemistry, Zhengzhou University, 100 Science Road, Zhengzhou, 450001, P. R. China
| | - Jianchun Jiang
- Institute of Chemical Industry of Forest Products, CAF, National Engineering Lab for Biomass Chemical Utilization, Nanjing, 210042, P. R. China
| |
Collapse
|
36
|
Chen M, Qiu Y, Wang W, Li X, Wang J, Wen H, Yang Z, Wang P. Engineering oxygen vacancies via amorphization in conjunction with W-doping as an approach to boosting catalytic properties of Pt/Fe-W-O for formaldehyde oxidation. JOURNAL OF HAZARDOUS MATERIALS 2021; 416:126224. [PMID: 34492978 DOI: 10.1016/j.jhazmat.2021.126224] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/09/2021] [Revised: 05/07/2021] [Accepted: 05/23/2021] [Indexed: 06/13/2023]
Abstract
Engineering functional defects in support materials has gained ever-increasing attention as a novel approach to boosting the catalytic performance of oxide-supported catalysts. Herein, we demonstrate the feasibility of engineering oxygen vacancy in iron oxide through amorphization in conjunction with foreign cation doping and elucidate the important role of support functionality in the catalytic oxidation of formaldehyde (HCHO). A supported Pt catalyst on Fe-W-O amorphous nanosheets (denoted as Pt/a-Fe-W-O) was synthesized using a one-step solvothermal method. This simple method allowed us to simultaneously create abundant oxygen vacancies in the substrate and to ensure uniform dispersion of tiny Pt nanoparticles with an average diameter of 1.4 nm on the high-surface-area substrate. This renders an increased possibility of Pt/O-vacancy coexistence in close proximity, which synergistically boosts the formation of active oxygen and surface hydroxyl species. Consequently, the Pt/a-Fe-W-O catalyst with an optimal W/Fe molar ratio of 0.08:1 and a 1.51 wt% Pt loading exhibited a high specific reaction rate of 68.3 μmol gPt-1 s-1 and excellent stability during 24 h continuous test, outperforming most existing HCHO oxidation catalysts. Our study highlights the importance of functional oxygen defects in construction of synergistic active sites for promoting the reactions requiring multiple active species.
Collapse
Affiliation(s)
- Muhua Chen
- School of Materials Science and Engineering, Key Laboratory of Advanced Energy Storage Materials of Guangdong Province, South China University of Technology, Guangzhou 510641, PR China
| | - Yuping Qiu
- School of Materials Science and Engineering, Key Laboratory of Advanced Energy Storage Materials of Guangdong Province, South China University of Technology, Guangzhou 510641, PR China
| | - Weizhen Wang
- Shenyang National Laboratory for Materials Science, Institute of Metal Research, Chinese Academy of Sciences, Shenyang 110016, PR China
| | - Xinyan Li
- School of Materials Science and Engineering, Key Laboratory of Advanced Energy Storage Materials of Guangdong Province, South China University of Technology, Guangzhou 510641, PR China
| | - Jiajun Wang
- School of Materials Science and Engineering, Key Laboratory of Advanced Energy Storage Materials of Guangdong Province, South China University of Technology, Guangzhou 510641, PR China
| | - He Wen
- School of Materials Science and Engineering, Key Laboratory of Advanced Energy Storage Materials of Guangdong Province, South China University of Technology, Guangzhou 510641, PR China
| | - Zhiqing Yang
- Shenyang National Laboratory for Materials Science, Institute of Metal Research, Chinese Academy of Sciences, Shenyang 110016, PR China
| | - Ping Wang
- School of Materials Science and Engineering, Key Laboratory of Advanced Energy Storage Materials of Guangdong Province, South China University of Technology, Guangzhou 510641, PR China.
| |
Collapse
|
37
|
Building CoP/Co-MOF heterostructure in 2D nanosheets for improving electrocatalytic hydrogen evolution over a wide pH range. J Electroanal Chem (Lausanne) 2021. [DOI: 10.1016/j.jelechem.2021.115514] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/02/2023]
|
38
|
Wang H, Chen BH, Liu DJ. Metal-Organic Frameworks and Metal-Organic Gels for Oxygen Electrocatalysis: Structural and Compositional Considerations. ADVANCED MATERIALS (DEERFIELD BEACH, FLA.) 2021; 33:e2008023. [PMID: 33984166 DOI: 10.1002/adma.202008023] [Citation(s) in RCA: 38] [Impact Index Per Article: 12.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/27/2020] [Revised: 02/26/2021] [Indexed: 06/12/2023]
Abstract
Increasing demand for sustainable and clean energy is calling for the next-generation energy conversion and storage technologies such as fuel cells, water electrolyzers, CO2 /N2 reduction electrolyzers, metal-air batteries, etc. All these electrochemical processes involve oxygen electrocatalysis. Boosting the intrinsic activity and the active-site density through rational design of metal-organic frameworks (MOFs) and metal-organic gels (MOGs) as precursors represents a new approach toward improving oxygen electrocatalysis efficiency. MOFs/MOGs afford a broad selection of combinations between metal nodes and organic linkers and are known to produce electrocatalysts with high surface areas, variable porosity, and excellent activity after pyrolysis. Some recent studies on MOFs/MOGs for oxygen electrocatalysis and their new perspectives in synthesis, characterization, and performance are discussed. New insights on the structural and compositional design in MOF/MOG-derived oxygen electrocatalysts are summarized. Critical challenges and future research directions are also outlined.
Collapse
Affiliation(s)
- Hao Wang
- Chemical Sciences and Engineering Division, Argonne National Laboratory, Lemont, IL, 60439, USA
| | - Biao-Hua Chen
- College of Environmental and Energy Engineering, Beijing University of Technology, Beijing, 100124, China
| | - Di-Jia Liu
- Chemical Sciences and Engineering Division, Argonne National Laboratory, Lemont, IL, 60439, USA
- Pritzker School of Molecular Engineering, The University of Chicago, Chicago, IL, 60637, USA
| |
Collapse
|
39
|
Tong M, Sun F, Xie Y, Wang Y, Yang Y, Tian C, Wang L, Fu H. Operando Cooperated Catalytic Mechanism of Atomically Dispersed Cu−N
4
and Zn−N
4
for Promoting Oxygen Reduction Reaction. Angew Chem Int Ed Engl 2021; 60:14005-14012. [DOI: 10.1002/anie.202102053] [Citation(s) in RCA: 128] [Impact Index Per Article: 42.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/09/2021] [Revised: 03/23/2021] [Indexed: 11/05/2022]
Affiliation(s)
- Miaomiao Tong
- Key Laboratory of Superlight Materials and Surface Technology of the Ministry of Education of the People's Republic of China Harbin Engineering University Harbin 150080 China
| | - Fanfei Sun
- Shanghai Synchrotron Radiation Facility Zhangjiang Laboratory Shanghai Advanced Research Institute Chinese Academy of Sciences Shanghai 201210 China
- Shanghai Institute of Applied Physics Chinese Academy of Sciences Shanghai 201204 China
| | - Ying Xie
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Ying Wang
- Key Laboratory of Superlight Materials and Surface Technology of the Ministry of Education of the People's Republic of China Harbin Engineering University Harbin 150080 China
| | - Yuqi Yang
- Shanghai Synchrotron Radiation Facility Zhangjiang Laboratory Shanghai Advanced Research Institute Chinese Academy of Sciences Shanghai 201210 China
- Shanghai Institute of Applied Physics Chinese Academy of Sciences Shanghai 201204 China
| | - Chungui Tian
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Lei Wang
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Honggang Fu
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| |
Collapse
|
40
|
Tong M, Sun F, Xie Y, Wang Y, Yang Y, Tian C, Wang L, Fu H. Operando Cooperated Catalytic Mechanism of Atomically Dispersed Cu−N
4
and Zn−N
4
for Promoting Oxygen Reduction Reaction. Angew Chem Int Ed Engl 2021. [DOI: 10.1002/ange.202102053] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/14/2022]
Affiliation(s)
- Miaomiao Tong
- Key Laboratory of Superlight Materials and Surface Technology of the Ministry of Education of the People's Republic of China Harbin Engineering University Harbin 150080 China
| | - Fanfei Sun
- Shanghai Synchrotron Radiation Facility Zhangjiang Laboratory Shanghai Advanced Research Institute Chinese Academy of Sciences Shanghai 201210 China
- Shanghai Institute of Applied Physics Chinese Academy of Sciences Shanghai 201204 China
| | - Ying Xie
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Ying Wang
- Key Laboratory of Superlight Materials and Surface Technology of the Ministry of Education of the People's Republic of China Harbin Engineering University Harbin 150080 China
| | - Yuqi Yang
- Shanghai Synchrotron Radiation Facility Zhangjiang Laboratory Shanghai Advanced Research Institute Chinese Academy of Sciences Shanghai 201210 China
- Shanghai Institute of Applied Physics Chinese Academy of Sciences Shanghai 201204 China
| | - Chungui Tian
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Lei Wang
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| | - Honggang Fu
- Key Laboratory of Functional Inorganic Materials Chemistry Ministry of Education of the People's Republic of China Heilongjiang University Harbin 150080 China
| |
Collapse
|
41
|
Zou L, Wei YS, Hou CC, Li C, Xu Q. Single-Atom Catalysts Derived from Metal-Organic Frameworks for Electrochemical Applications. SMALL (WEINHEIM AN DER BERGSTRASSE, GERMANY) 2021; 17:e2004809. [PMID: 33538109 DOI: 10.1002/smll.202004809] [Citation(s) in RCA: 68] [Impact Index Per Article: 22.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 08/07/2020] [Revised: 09/18/2020] [Indexed: 05/23/2023]
Abstract
Single-atom catalysts (SACs) have received tremendous attention due to their extraordinary catalytic performances. The synthesis of this kind of catalysts is highly desired and challenging. In the last few years, metal-organic frameworks (MOFs) have been demonstrated as a promising precursor for fabricating SACs. In this review, the progress and recent advances in the synthesis of MOF-derived SACs and their electrochemical applications are summarized. First, the synthetic approaches based on MOFs and accessible characterization techniques for SACs as well as their advantages/disadvantages are discussed. Then, the electrochemical applications of these MOF-derived SACs including the oxygen reduction reaction (ORR), oxygen evolution reaction (OER), hydrogen evolution reaction (HER), CO2 reduction reaction (CO2 RR), nitrogen reduction reaction (NRR), and other energy-related reactions are reviewed. Finally, insights into the current challenges and future prospects of this field are briefly presented.
Collapse
Affiliation(s)
- Lianli Zou
- AIST-Kyoto University Chemical Energy Materials Open Innovation Laboratory (ChEM-OIL), National Institute of Advanced Industrial Science and Technology (AIST), Yoshida, Sakyo-ku, Kyoto, 606-8501, Japan
| | - Yong-Sheng Wei
- AIST-Kyoto University Chemical Energy Materials Open Innovation Laboratory (ChEM-OIL), National Institute of Advanced Industrial Science and Technology (AIST), Yoshida, Sakyo-ku, Kyoto, 606-8501, Japan
| | - Chun-Chao Hou
- AIST-Kyoto University Chemical Energy Materials Open Innovation Laboratory (ChEM-OIL), National Institute of Advanced Industrial Science and Technology (AIST), Yoshida, Sakyo-ku, Kyoto, 606-8501, Japan
| | - Caixia Li
- AIST-Kyoto University Chemical Energy Materials Open Innovation Laboratory (ChEM-OIL), National Institute of Advanced Industrial Science and Technology (AIST), Yoshida, Sakyo-ku, Kyoto, 606-8501, Japan
| | - Qiang Xu
- AIST-Kyoto University Chemical Energy Materials Open Innovation Laboratory (ChEM-OIL), National Institute of Advanced Industrial Science and Technology (AIST), Yoshida, Sakyo-ku, Kyoto, 606-8501, Japan
- School of Chemistry and Chemical Engineering, Yangzhou University, Yangzhou, Jiangsu, 225009, P. R. China
| |
Collapse
|
42
|
Zhao CX, Liu JN, Wang J, Ren D, Yu J, Chen X, Li BQ, Zhang Q. A ΔE = 0.63 V Bifunctional Oxygen Electrocatalyst Enables High-Rate and Long-Cycling Zinc-Air Batteries. ADVANCED MATERIALS (DEERFIELD BEACH, FLA.) 2021; 33:e2008606. [PMID: 33656780 DOI: 10.1002/adma.202008606] [Citation(s) in RCA: 60] [Impact Index Per Article: 20.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/21/2020] [Revised: 01/15/2021] [Indexed: 05/25/2023]
Abstract
Rechargeable zinc-air batteries constitute promising next-generation energy storage devices due to their intrinsic safety, low cost, and feasibility to realize high cycling current density and long cycling lifespan. Nevertheless, their cathodic reactions involving oxygen reduction and oxygen evolution are highly sluggish in kinetics, requiring high-performance noble-metal-free bifunctional electrocatalysts that exceed the current noble-metal-based benchmarks. Herein, a noble-metal-free bifunctional electrocatalyst is fabricated, which demonstrates ultrahigh bifunctional activity and renders excellent performance in rechargeable zinc-air batteries. Concretely, atomic Co-N-C and NiFe layered double hydroxides (LDHs) are respectively selected as oxygen reduction and evolution active sites and are further rationally integrated to afford the resultant CoNC@LDH composite electrocatalyst. The CoNC@LDH electrocatalyst exhibits remarkable bifunctional activity delivering an indicator ΔE of 0.63 V, far exceeding the noble-metal-based Pt/C+Ir/C benchmark (ΔE = 0.77 V) and most reported electrocatalysts. Correspondingly, ultralong lifespan (over 3600 cycles at 10 mA cm-2 ) and excellent rate performances (cycling current density at 100 mA cm-2 ) are achieved in rechargeable zinc-air batteries. This work highlights the current advances of bifunctional oxygen electrocatalysis and endows high-rate and long-cycling rechargeable zinc-air batteries for efficient sustainable energy storage.
Collapse
Affiliation(s)
- Chang-Xin Zhao
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing, 100084, China
| | - Jia-Ning Liu
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing, 100084, China
| | - Juan Wang
- School of Materials Science and Engineering, Beijing Institute of Technology, Beijing, 100081, China
- Advanced Research Institute of Multidisciplinary Science, Beijing Institute of Technology, Beijing, 100081, China
| | - Ding Ren
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing, 100084, China
| | - Jia Yu
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing, 100084, China
| | - Xiao Chen
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing, 100084, China
| | - Bo-Quan Li
- School of Materials Science and Engineering, Beijing Institute of Technology, Beijing, 100081, China
- Advanced Research Institute of Multidisciplinary Science, Beijing Institute of Technology, Beijing, 100081, China
| | - Qiang Zhang
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering, Tsinghua University, Beijing, 100084, China
| |
Collapse
|
43
|
Xu J, Dou S, Wang Y, Yuan Q, Deng Y, Chen Y. Development of Metal and Metal-Based Composites Anode Materials for Potassium-Ion Batteries. ACTA ACUST UNITED AC 2021. [DOI: 10.1007/s12209-021-00281-z] [Citation(s) in RCA: 12] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
44
|
Zhao CX, Liu JN, Wang J, Ren D, Li BQ, Zhang Q. Recent advances of noble-metal-free bifunctional oxygen reduction and evolution electrocatalysts. Chem Soc Rev 2021; 50:7745-7778. [DOI: 10.1039/d1cs00135c] [Citation(s) in RCA: 134] [Impact Index Per Article: 44.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/16/2022]
Abstract
Bifunctional oxygen reduction and evolution constitute the core processes for sustainable energy storage. The advances on noble-metal-free bifunctional oxygen electrocatalysts are reviewed.
Collapse
Affiliation(s)
- Chang-Xin Zhao
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering
- Tsinghua University
- Beijing
- China
| | - Jia-Ning Liu
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering
- Tsinghua University
- Beijing
- China
| | - Juan Wang
- Advanced Research Institute of Multidisciplinary Science
- Beijing Institute of Technology
- Beijing 100081
- China
- School of Materials Science and Engineering
| | - Ding Ren
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering
- Tsinghua University
- Beijing
- China
| | - Bo-Quan Li
- Advanced Research Institute of Multidisciplinary Science
- Beijing Institute of Technology
- Beijing 100081
- China
- School of Materials Science and Engineering
| | - Qiang Zhang
- Beijing Key Laboratory of Green Chemical Reaction Engineering and Technology, Department of Chemical Engineering
- Tsinghua University
- Beijing
- China
| |
Collapse
|
45
|
Zhong Y, Dai J, Xu X, Su C, Shao Z. Facilitating Oxygen Redox on Manganese Oxide Nanosheets by Tuning Active Species and Oxygen Defects for Zinc‐Air Batteries. ChemElectroChem 2020. [DOI: 10.1002/celc.202001419] [Citation(s) in RCA: 14] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/20/2022]
Affiliation(s)
- Yijun Zhong
- Western Australian School of Mines: Minerals Energy and Chemical Engineering (WASM-MECE) Curtin University Perth Western Australia 6102 Australia
| | - Jie Dai
- State Key Laboratory of Materials-Oriented Chemical Engineering College of Chemical Engineering Nanjing Tech University Nanjing 211816 P. R. China
| | - Xiaomin Xu
- Western Australian School of Mines: Minerals Energy and Chemical Engineering (WASM-MECE) Curtin University Perth Western Australia 6102 Australia
| | - Chao Su
- Western Australian School of Mines: Minerals Energy and Chemical Engineering (WASM-MECE) Curtin University Perth Western Australia 6102 Australia
- School of Energy and Power Jiangsu University of Science and Technology Zhenjiang 212100 P. R. China
| | - Zongping Shao
- Western Australian School of Mines: Minerals Energy and Chemical Engineering (WASM-MECE) Curtin University Perth Western Australia 6102 Australia
- State Key Laboratory of Materials-Oriented Chemical Engineering College of Chemical Engineering Nanjing Tech University Nanjing 211816 P. R. China
| |
Collapse
|
46
|
Jeong H, Kwac LK, Hong CG, Kim HG. Direct growth of flower like-structured CuFe oxide on graphene supported nickel foam as an effective sensor for glucose determination. MATERIALS SCIENCE & ENGINEERING. C, MATERIALS FOR BIOLOGICAL APPLICATIONS 2020; 118:111510. [PMID: 33255067 DOI: 10.1016/j.msec.2020.111510] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/28/2020] [Revised: 08/19/2020] [Accepted: 09/03/2020] [Indexed: 12/23/2022]
Abstract
In this report, a novel flower like-structured CuFe oxides was directly grown on graphene nanosheets supported nickel foam substrates (CuFe-O/GR/NF) via a hydrothermal method followed by an additionally pyrolysis process. The different morphologies consistent with varied synthesis conditions, along with their catalytic activity were discussed. The CuFe-O/GR/NF material was successfully applied as an electrocatalyst for sensing glucose with a wide linear concentration range of 0.0079 μM-21.504 μM, sensitivity of 0.368 mA μM-1 cm-2, and limit of detection of 0.0079 μM. Impressively, the CuFe-O/GR/NF showed much higher electrocatalytic activity, lower overpotential and greater stability as compared to that of mono Cu-O/GR/NF or Fe-O/GR/NF synthesized by the same method. The higher electrocatalytic activity was due to the high electron conductivity, large surface area of CuFe-O/GR/NF and the fast ion/electron transport in the electrode and at the electrolyte-electrode interface. This is important for further development of high performance electrocatalysts for sensor application.
Collapse
Affiliation(s)
- Hun Jeong
- Institute of Carbon Technology, Jeonju University, Jeonju, Jeonbuk 55069, Republic of Korea.
| | - Lee Ku Kwac
- Institute of Carbon Technology, Jeonju University, Jeonju, Jeonbuk 55069, Republic of Korea
| | - Chang Gi Hong
- Institute of Carbon Technology, Jeonju University, Jeonju, Jeonbuk 55069, Republic of Korea
| | - Hong Gun Kim
- Institute of Carbon Technology, Jeonju University, Jeonju, Jeonbuk 55069, Republic of Korea.
| |
Collapse
|
47
|
|
48
|
Electrocatalysts optimized with nitrogen coordination for high-performance oxygen evolution reaction. Coord Chem Rev 2020. [DOI: 10.1016/j.ccr.2020.213468] [Citation(s) in RCA: 27] [Impact Index Per Article: 6.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022]
|
49
|
Zheng J, Wu Y, Sun Y, Rong J, Li H, Niu L. Advanced Anode Materials of Potassium Ion Batteries: from Zero Dimension to Three Dimensions. NANO-MICRO LETTERS 2020; 13:12. [PMID: 34138200 PMCID: PMC8187553 DOI: 10.1007/s40820-020-00541-y] [Citation(s) in RCA: 36] [Impact Index Per Article: 9.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/24/2020] [Accepted: 09/28/2020] [Indexed: 05/17/2023]
Abstract
Potassium ion batteries (PIBs) with the prominent advantages of sufficient reserves and economical cost are attractive candidates of new rechargeable batteries for large-grid electrochemical energy storage systems (EESs). However, there are still some obstacles like large size of K+ to commercial PIBs applications. Therefore, rational structural design based on appropriate materials is essential to obtain practical PIBs anode with K+ accommodated and fast diffused. Nanostructural design has been considered as one of the effective strategies to solve these issues owing to unique physicochemical properties. Accordingly, quite a few recent anode materials with different dimensions in PIBs have been reported, mainly involving in carbon materials, metal-based chalcogenides (MCs), metal-based oxides (MOs), and alloying materials. Among these anodes, nanostructural carbon materials with shorter ionic transfer path are beneficial for decreasing the resistances of transportation. Besides, MCs, MOs, and alloying materials with nanostructures can effectively alleviate their stress changes. Herein, these materials are classified into 0D, 1D, 2D, and 3D. Particularly, the relationship between different dimensional structures and the corresponding electrochemical performances has been outlined. Meanwhile, some strategies are proposed to deal with the current disadvantages. Hope that the readers are enlightened from this review to carry out further experiments better.
Collapse
Affiliation(s)
- Jiefeng Zheng
- Department of Materials Science and Engineering, College of Chemistry and Materials Science, Jinan University, Guangzhou, 510632, People's Republic of China
| | - Yuanji Wu
- Department of Materials Science and Engineering, College of Chemistry and Materials Science, Jinan University, Guangzhou, 510632, People's Republic of China
| | - Yingjuan Sun
- Department of Materials Science and Engineering, College of Chemistry and Materials Science, Jinan University, Guangzhou, 510632, People's Republic of China
| | - Jianhua Rong
- Department of Materials Science and Engineering, College of Chemistry and Materials Science, Jinan University, Guangzhou, 510632, People's Republic of China
| | - Hongyan Li
- Department of Materials Science and Engineering, College of Chemistry and Materials Science, Jinan University, Guangzhou, 510632, People's Republic of China.
| | - Li Niu
- Center for Advanced Analytical Science, c/o School of Chemistry and Chemical Engineering, Guangzhou University, Guangzhou, 510006, People's Republic of China
| |
Collapse
|
50
|
Jiang T, Hu H, Lei F, Hu J, Wu M, Ho D. Concurrently Realizing Geometric Confined Growth and Doping of Transition Metals within Graphene Hosts for Bifunctional Electrocatalysts toward a Solid-State Rechargeable Micro-Zn-Air Battery. ACS APPLIED MATERIALS & INTERFACES 2020; 12:38031-38044. [PMID: 32799437 DOI: 10.1021/acsami.0c08676] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/11/2023]
Abstract
The simultaneous realization of confined growth and doping of transition metals within carbon hosts promises to deliver unusual bifunctional catalytic activity but still remains challenging due to the difficulty in achieving synchronous nucleation and diffusion of metallic ions in a single synthesis step. Herein, we present a simple synthesis strategy capable of concurrently realizing geometric confined growth and doping of transition metals within graphene hosts, demonstrated in Co,N-codoped graphene-confined FeNi nanoparticles (Co,N-GN-FeNi). The obtained Co,N-GN-FeNi can take full advantage of the hierarchy of interactions between the confined-grown FeNi nanoparticles (for high oxygen evolution reaction (OER) activity) and the Co,N-codoped graphene hosts (for high oxygen reduction reaction (ORR) activity). The overall structure is a rationally designed synergy that simultaneously realizes (i) adequate exposure of electroactive sites, (ii) effective protection against corrosion/aggregation of FeNi nanoparticles, and (iii) rapid transport of ions/electrons between the interfaces. As a result, Co,N-GN-FeNi exhibits excellent bifunctional electrocatalytic activity relying on a low ORR/OER subtraction (ΔE = 0.81 V). Subsequent combination with a planar electrode configuration and a solid polymer electrolyte further demonstrates the utilization of Co,N-GN-FeNi as air cathode bifunctional electrocatalysts in a solid-state rechargeable micro-Zn-air battery (SR-MZAB), which exhibits a large open-circuit voltage of 1.39 V, a high power density/specific capacity of 62.3 mW cm-2/763 mAh g-1, excellent durability (126 cycles/42 h), and mechanical flexibility. This work demonstrates an effective synthesis strategy for concurrently realizing geometric confined growth and doping of transition metals within carbon hosts, for enhanced bifunctional catalytic activity toward novel SR-MZABs with high energy efficiency, security, and flexibility for wearable micropower sources.
Collapse
Affiliation(s)
- Tongtong Jiang
- School of Physics and Materials Science, Key Laboratory of Structure and Functional Regulation of Hybrid Materials, Anhui University, Ministry of Education, Hefei 230601, China
| | - Haibo Hu
- School of Physics and Materials Science, Key Laboratory of Structure and Functional Regulation of Hybrid Materials, Anhui University, Ministry of Education, Hefei 230601, China
| | - Fengcai Lei
- College of Chemistry, Chemical Engineering and Materials Science, Shandong Normal University, Jinan 250014, China
| | - Junjie Hu
- School of Physics and Materials Science, Key Laboratory of Structure and Functional Regulation of Hybrid Materials, Anhui University, Ministry of Education, Hefei 230601, China
| | - Mingzai Wu
- School of Physics and Materials Science, Key Laboratory of Structure and Functional Regulation of Hybrid Materials, Anhui University, Ministry of Education, Hefei 230601, China
| | - Derek Ho
- Department of Materials Science and Engineering, City University of Hong Kong, Kowloon, Hong Kong 999077, China
| |
Collapse
|