Quantitative assessment of mineralization in distraction osteogenesis

A Novel Method to Assess Healing of Segmental Bone Defects using the Induced Membrane Technique

OBJECTIVE

Clinical concerns exist regarding the quality of bony consolidation in the context of the induced membrane technique. This study evaluates the clinical process of bone grafting in the second stage of induced membrane bone union in patients with tibial bone defects to infer the possibility of non-union and establish a reliable and effective evaluation method combined with computed tomography (CT) to assess fracture healing.

METHODS

Patients with tibial bone defects who underwent the induced membrane technique at our hospital between February 2017 and February 2020 were retrospectively analyzed. The Hounsfield unit (HU) values of the patients were evaluated at different times during the second stage of bone grafting. Bone healing at the boundary value of the 120 HU output threshold (-1024 HU-3071 HU) was directionally selected, and the changes in the growth volume of union (new bone volume [selected according to HU value]/bone defect volume) were compared with analyzing individual class bone union. Method 1 involved X-rays revealing that at least three of the four cortices were continuous and at least 2 mm thick, with the patient being pain free. For Method 2, new bone volume (selected according to HU value/bone defect volume) at the stage was compared with analyzing individual class healing. Receiver operating characteristic curve analysis was used for Methods 1 and 2.

RESULTS

A total of 42 patients with a segmental bone defect with a mean age of 40.5 years (40.5 ± 8.3 years) were included. The relationship between bone graft volume and time variation was analyzed by single factor repeated variable analysis (F = 6.477, p = 0.016). Further, curve regression analysis showed that the change in bone graft volume over time presented a logarithmic curve pattern (Y = 0.563 + 0.086 × ln(X), Ra2 = 0.608, p = 0.041). ROC curve analysis showed that Method 2 is superior to Method 1 (AUC: 86.3% vs. 68.3%, p < 0.05).

CONCLUSION

The induced membrane technique could be used to treat traumatic long bone defects, with fewer complications and a higher healing rate. The proposed imaging grading of HU (new bone volume/bone defect volume) can be used as a reference for the quality of bony consolidation with the induced membrane technique.

Bone Regenerate Evaluation Methods

Since its introduction by Ilizarov, the distraction osteogenesis technique has been used to treat trauma-related conditions, infections, bone tumors, and congenital diseases, either as methods of bone transport or elongation. One of the major dilemmas for the orthopedic surgeon who performs osteogenic distraction is establishing a reproducible method of assessing the progression of the osteogenesis, enabling the early detection of regenerate failures, in order to effectively interfere during treatment, and to determine the appropriate time to remove the external fixator. Several quantitative monitoring methods to evaluate the structural recovery and biomechanical properties of the bone regenerate at different stages, as well as the bone healing process, are under study. These methods can reveal data on bone metabolism, stiffness, bone mineral content, and bone mineral density. The present review comprehensively summarizes the most recent techniques to assess bone healing during osteogenic distraction, including conventional radiography and pixel values in digital radiology, ultrasonography, bone densitometry and scintigraphy, quantitative computed tomography, biomechanical evaluation, biochemical markers, and mathematical models. We believe it is crucial to know the different methods currently available, and we understand that using several monitoring methods simultaneously can be an ideal solution, pointing to a future direction in the follow-up of osteogenic distraction.

Experimental study on determining the degree of bone healing by wall thickness ratio analysis

To verify the reliability and accuracy of wall thickness ratio analysis to determine the degree of bone healing, fracture models were established with 6 beagles. X-ray, micro-CT, and CT scans were performed at 24 weeks. The healthy side and the affected side were used to simulate the three-dimensional geometric model after internal fixation, and the mesh was divided. The mean and median CT wall thickness values were obtained through the wall thickness analysis. X-ray, CT, micro-CT, and gross appearance were used to determine the degree of bone healing, which was compared with wall thickness analysis. There was a positive correlation between the average CT value and the median wall thickness. The correlation coefficient analysis of the median wall thickness ratio (R2) and healing index ratio (R3) showed a positive correlation. The results of the wall thickness ratio (R2) and the healing index ratio (R3) were used to determine bone healing, and the results were consistent with the results of the actual mechanical test and image analysis. The results of wall thickness ratio analysis were significantly correlated with the degree of bone healing. This method is simple, rapid, and practical to analyze and judge the degree of bone healing.

The early posterior cortex pixel value ratio: a novel reliable indicator for distraction osteogenesis

Aims

We aimed to explore the associations of the early PVR in four cortices with Healing Index (HI), Lengthening Index (LI), and External Fixator Index (EFI) in the bone union and non-union groups.

Methods

A total of 52 patients, including 39 bone union and 13 bone non-union subjects, were recruited in this study. The general characteristics and PVR in four cortices in each group were explored. Afterward, the early PVR in four cortices, including medial, lateral, anterior, and posterior sides, were compared. Finally, the associations of the early PVR in four cortices with HI, LI, and EFI were also investigated.

Results

The general characteristics of these patients were consistent, except for HI (31.54 ± 12.24 vs. 45.08 ± 27.10, P = 0.018) and EFI (57.63 ± 18.15 vs. 71.29 ± 24.60, P = 0.046). The growth of regenerated callus was asymmetrical in the bone union group (the posterior PVR seems to grow faster), whereas no statistical difference was obtained in the bone non-union group. Furthermore, the posterior PVR in the bone union group was significantly higher than that in the bone non-union group (the first month: 0.96 ± 0.17 vs. 0.86 ± 0.06, p = 0.047; the second month: 0.98 ± 0.14 vs. 0.89 ± 0.09, p = 0.041; the third month: 1.00 ± 0.12 vs. 0.92 ± 0.09, p = 0.039). Most importantly, the posterior PVR was inversely associated with HI, LI, and EFI (the first month: r = -0.343, p = 0.041; r = -0.346, p = 0.042; r = -0.352, p = 0.041; the second month: r = -0.459, p = 0.004; r = -0.277, p = 0.101; r = -0.511, p = 0.002; the third month: r = -0.479, p = 0.003; r = -0.398, p = 0.018; r = -0.551, p = 0.001) in the bone union group, respectively. However, this finding was lost in the bone non-union group.

Conclusion

The early posterior cortex PVR seems to grow faster than the medial, lateral, and anterior sides in the bone union group, which represents an asymmetrical development pattern. Moreover, the posterior cortex PVR was negatively associated with HI, LI, and EFI, respectively. The posterior cortex PVR may be a novel and reliable detection index in the process of DO.

A comparative study of bone union and nonunion during distraction osteogenesis

BACKGROUND

The clinical characteristics of bone nonunion during distraction osteogenesis (DO) were rarely discussed. This study was employed to specify the difference between bone union and nonunion during DO.

METHODS

The patients with bone lengthening were recruited in our study. The bone union cases indicated the ones that remove the external fixator successfully, whereas the bone nonunion represented the bridging callus did not appear even after 9 months (an absence of bridging callus for at least three out of four cortices on plain radiographs) that needs autogenous bone transplantation. The differences in the pixel value ratio (PVR) growth of regenerated callus, lengthening index (LI), healing index (HI), external fixation index (EFI) and blood biochemical indexes between bone union and nonunion were analyzed.

RESULTS

A total of 8 bone nonunion and 27 bone union subjects were included in this study. The PVR growth in bone nonunion was significantly lower than that in bone union (0.19 ± 0.06 vs. 0.32 ± 0.16, P = 0.048). Interestingly, the HI and EFI in bone nonunion was significantly higher than that in bone union (62.0 ± 31.4 vs. 37.0 ± 27.4, P = 0.036; 75.0 ± 30.9 vs. 49.9 ± 16.1, P = 0.006). However, no significant difference with regard to LI was identified (0.76 ± 0.52 vs. 0.77 ± 0.32, P = 0.976). Moreover, the circulating level of urea and lymphocyte count in bone union was significantly lower than that in bone nonunion (4.31 ± 1.05 vs. 5.17 ± 1.06, P = 0.049; 2.08 ± 0.67 vs. 2.73 ± 0.54, P = 0.018). On the contrary, the circulating level of magnesium in bone union was significantly higher than that in bone nonunion (0.87 ± 0.07 vs. 0.80 ± 0.07, P = 0.014).

CONCLUSION

Compared to the bone union, the PVR growth was significantly lower, whereas the HI and EFI was significantly higher in the bone nonunion. Moreover, the circulating level of urea, magnesium and lymphocyte count was also different between these two. Therefore, the PVR, HI and EFI seems to be reliable and sensitive indicators to reflect the bone nonunion during DO, which might be considered in bone lengthening. Further prospective studies are still needed to elaborate the concerned issues.

Early Weight-bearing Accelerates Regenerate Bone Mineralisation: A Pilot Study Comparing Two Post-operative Weight-bearing Protocols Following Intramedullary Limb Lengthening Using the Pixel Value Ratio

Introduction

Limb lengthening is increasingly accomplished by internal lengthening nails. Previous versions of the magnetic lengthening nails made from titanium alloy allowed limited weight-bearing. In contrast, the newer nails made of stainless steel allow increased weight-bearing. An objective comparison of the rate of healing of the regenerate bone based on the weight-bearing capabilities of these two types of lengthening nails has not been evaluated. The hypothesis for the study is that earlier commencement of full weight-bearing in patients treated with the stainless steel STRYDE® nail will lead to faster healing of the regenerate bone during intramedullary limb lengthening compared with those treated with the titanium PRECICE® nail.

Materials and methods

Thirty patients, divided into two groups of 15 each, underwent antegrade intramedullary lengthening of the femur using a magnetic lengthening nail between May 2017 and November 2020. The pixel value ratio (PVR) obtained from serial digital radiographs was used to quantitatively determine the regenerate bone's mineralisation rate. We compared the rate of healing of the regenerate bone in both groups of patients using the PVR.

Results

Patients treated with the STRYDE® nail achieved unassisted full weight-bearing significantly earlier than patients treated with the PRECICE® nail (12 weeks vs 17 weeks for STRYDE® and PRECICE® nail-lengthened patients, respectively, p = 0.003). There was no difference in the PVR between both groups of patients at the time of full weight-bearing (p = 0.0857). However, patients treated with the STRYDE® nail attained a PVR of 1 significantly earlier than those treated with the PRECICE® nail (0.0317).

Conclusion

The STRYDE® nail provides an earlier return of function and full weight-bearing compared with the PRECICE® lengthening nail. Earlier commencement of weight-bearing ambulation leads to more rapid mineralisation of the regenerate bone in patients undergoing intramedullary limb lengthening.

How to cite this article

Bafor A, Duncan ME, Iobst CA, et al. Early Weight-bearing Accelerates Regenerate Bone Mineralisation: A Pilot Study Comparing Two Post-operative Weight-bearing Protocols Following Intramedullary Limb Lengthening Using the Pixel Value Ratio. Strategies Trauma Limb Reconstr 2022;17(3):148-152.

Early Pixel Value Ratios to Assess Bone Healing During Distraction Osteogenesis

Background: Distraction osteogenesis (DO) is an approach for bone lengthening and reconstruction. The pixel value ratio (PVR), an indicator calculated from X-ray images, is reported to assess the final timing for the external fixator removal. However, the early PVR and its potential influencing factors and the relationship between the early PVR and clinical outcomes are rarely discussed. Therefore, this study was employed to address these issues.

Methods: A total of 125 patients with bone lengthening were investigated retrospectively. The early PVR of regenerated bone was monitored in the first 3 months after osteotomy. The potential effect of sex, chronological age, BMI, lengthening site, and involvement of internal fixation during the consolidation period was analyzed. Moreover, the associations of the healing index (HI) and lengthening index (LI) with early PVR were also investigated.

Results: The early PVRs were 0.78 ± 0.10, 0.87 ± 0.06, and 0.93 ± 0.06 in the first 3 months after osteotomy, respectively. Moreover, the PVR in juvenile was significantly higher than that in adults in the first 3 months after osteotomy (0.80 ± 0.09 vs. 0.74 ± 0.10; p = 0.008), (0.89 ± 0.06 vs. 0.83 ± 0.06; p = 0.018), and (0.94 ± 0.05 vs. 0.87 ± 0.05; p = 0.003). In addition, the PVR in males was significantly higher than that in females in the first month after osteotomy (0.80 ± 0.09 vs. 0.76 ± 0.10; p = 0.015), and the PVR in femur site was significantly higher than that in the tibia site in the second and third months after osteotomy (0.88 ± 0.07 vs. 0.87 ± 0.06; p = 0.015) and (0.93 ± 0.06 vs. 0.92 ± 0.06, p = 0.037). However, the BMI and involvement of the internal fixator during the consolidation period seem to not influence the early PVR of regenerated callus during DO. Interestingly, the early PVR seems to be moderately inversely associated with HI (mean = 44.98 ± 49.44, r = -0.211, and p = 0.029) and LI (mean = 0.78 ± 0.77, r = -0.210, and p = 0.029), respectively.

Conclusion: The early PVR is gradually increasing in the first 3 months after osteotomy, which may be significantly influenced by chronological age, sex, and the lengthening site. Moreover, the early PVR of callus may reflect the potential clinical outcome for DO. Our results may be beneficial to the clinical management of the subjects with bone lengthening.

Is a staged reloading protocol effective to time the removal of circular frames?

Aims

The timing of when to remove a circular frame is crucial; early removal results in refracture or deformity, while late removal increases the patient morbidity and delay in return to work. This study was designed to assess the effectiveness of a staged reloading protocol. We report the incidence of mechanical failure following both single-stage and two stage reloading protocols and analyze the associated risk factors.

Methods

We identified consecutive patients from our departmental database. Both trauma and elective cases were included, of all ages, frame types, and pathologies who underwent circular frame treatment. Our protocol is either a single-stage or two-stage process implemented by defunctioning the frame, in order to progressively increase the weightbearing load through the bone, and promote full loading prior to frame removal. Before progression, through the process we monitor patients for any increase in pain and assess radiographs for deformity or refracture.

Results

There were 244 frames (230 patients) included in the analyses, of which 90 were Ilizarov type frames and 154 were hexapods. There were 149 frames which underwent single-stage reloading and 95 frames which underwent a two-stage reloading protocol. Mechanical failure occurred after frame removal in 13 frames (5%), which suffered refracture. There were no cases of change in alignment. There was no difference between refracture patients who underwent single-stage or two-stage reloading protocols (p = 0.772). In all, 14 patients had failure prevented through identification with the reloading protocol.

Conclusion

Our reloading protocol is a simple and effective way to confirm the timing of frame removal and minimize the rate of mechanical failure. Similar failure rates occurred between patients undergoing single-stage and two-stage reloading protocols. If the surgeon is confident with clinical and radiological assessment, it may be possible to progress directly to stage two and decrease frame time and patient morbidity.

Cite this article: Bone Jt Open 2022;3(5):359–366.

Use of the Pixel Value Ratio Following Intramedullary Limb Lengthening: Uncomplicated Full Weight-bearing at Lower Threshold Values

Aims

The pixel value ratio (PVR) can be used to assess regenerate consolidation after lengthening and guide advice for full weight-bearing (FWB). This study aimed to analyse the PVR in adults having femoral lengthening, the time to FWB and compare findings with the reported values in the literature.

Materials and methods

A retrospective database review identified 100 eligible patients who underwent lengthening using the PRECICE nail (68 antegrade and 32 retrograde). The PVR was calculated in each cortex on plain radiographs at every visit. The ratio between the regenerate and an average from the adjacent normal bone was calculated and plotted against the clinical decision to allow FWB.

Results

Eighty-seven patients (58 men and 29 women) were assessed; eleven had bilateral lengthening and two patients underwent lengthening twice. The median age was 30.5 years. The underlying cause of shortening was post-traumatic in 46%, with the remaining due to a wide variety of causes, including congenital 16%, syndromic 12% and other causes. The median lengthening achieved was 45 mm, at a median of 57.5 days. The PVR increased with each visit (p <0.0001). FWB was allowed at a median of 42 days after the last day of lengthening, with PVR values of 0.83, 0.84, 0.93 and 0.84 for the anterior, posterior, medial and lateral cortex noted, respectively (average 0.85). There were no implant failures, shortening or regenerate fractures. No differences were detected between antegrade and retrograde nails or with lengthening greater or less than 45 mm. One surgeon allowed earlier FWB at median 31 days with no nail failures.

Conclusion

PVR is a valuable tool that quantifies regenerate maturity and provides objectivity in deciding when to allow FWB after intramedullary lengthening with the PRECICE nail. FWB was permitted at an earlier time point, corresponding with lower PVR values than have been reported in the literature and with no mechanical failure or regenerate deformation.

How to cite this article

Elsheikh AA, Wright J, Stoddart MT, et al. Use of the Pixel Value Ratio Following Intramedullary Limb Lengthening: Uncomplicated Full Weight-bearing at Lower Threshold Values. Strategies Trauma Limb Reconstr 2022;17(1):14-18.

Bone reconstruction: Subjective evaluation and objective analysis based on conventional digital X-rays - a retrospective evaluation

BACKGROUND

Various approaches have been used to evaluate callus stiffness in distraction osteogenesis. This assessment becomes even more critical as inadequate corticalization and premature removal of the frame lead to bending, refracture, and loss of length. This study aimed to verify the objective Pixel Value Ratio (PVR) and define an evaluation scheme to assess callus tissue development during internal and external bone lengthening.

HYPOTHESIS

There are no differences between subjective parameters and objective evaluation for external and internal bone lengthening.

PATIENTS AND METHODS

We included 24 patients in this retrospective study, treated by distraction osteogenesis of the lower limb. Ten patients were treated with external ring fixators and 14 with intramedullary lengthening devices. The minimum distraction distance was 3cm. Callus tissue was evaluated with the PVR, using digital X-rays during and after treatment. We combined this method with subjective evaluation parameters, including the continuity, signal intensity, and the regeneration tissue's homogeneity, presented in the X-ray Evaluation System for Distraction Osteogenesis (XESDO).

RESULTS

The subjective evaluation showed an increase of continuity and signal-intensity between 4th postoperative weeks and complete healing with significant differences between the external and internal groups for homogeneity only after four weeks and for all parameters at 3C (p<0.05). The PVR showed an increase during consolidation with values between 0.7 and 1.0 for both groups with almost perfect interobserver agreement. Significant lower values were found in the anterior tibial cases.

CONCLUSION

PVR appears to be a practical tool for radiological evaluation of callus tissue development. In combination with the newly introduced XESDO and the surgeon's experience, these methods can be helpful for decisions during all phases of distraction osteogenesis. It is important for adapting alignment or distraction-rate, as various potential complications can be detected early. However, further studies are necessary to assess the image-based determination of callus tissue stability.

LEVEL OF EVIDENCE

III; cohort study.

The effect of topical administration of simvastatin on entochondrostosis and intramembranous ossification: An animal experiment

Background

Simvastatin, a drug for lowering serum cholesterol, has been shown to enhance bone regeneration, but few studies have qualitatively and quantitatively tested its effect when used topically in different animal models. This study aims to investigate topical administration of simvastatin as a bone regeneration inducer by testing its effect on bone formation in both long tubular bone and flat bone defect, and the mechanism involved.

Methods

Two animal models were used for testing the effect of simvastatin on entochondrostosis and intramembranous ossification respectively. Simvastatin of different dosages combined with poly lactic acid were implanted in extreme radial defects of 12 adult male New Zealand rabbits. Bone formation was monitored using x-ray and CT-scan and measured using x-ray scales, pixel values and spiral CT-scan for 16 weeks before being subject to histological and immunohistochemistry examination. The result was compared with that of autograft and blank control groups. Simvastatin with thrombin and fibrin sealant were implanted in calvarial defects of three Rhesus monkeys and monitored for 18 weeks. Bone formation was compared between the simvastatin and the blank control group using spiral CT-scan and histological examination.

Results

Both visual and quantitative measurements by x-ray and spiral CT-scan indicated significant bone formation in radial defects in all simvastatin groups and the autograft group whereas no bone formation was found in control groups. There was no significant difference in bone formation quantity between 100 ​mg simvastatin and autograft. Histological and immunohistochemistry examination indicated entochondrostosis in association with positive expression of BMP-2 and HIF-1 alpha. Spiral CT-scan and histological examination of calvarial defects of monkeys showed intramembranous ossification after simvastatin implantation. No change was found in the control group.

Conclusions

Topical administration of simvastatin induces entochondrostosis and intramembranous ossification by enhancing expression of BMP-2 and HIF-1 alpha. The effect of simvastatin on bone regeneration is comparable to autograft.

The translational potential of this article

Topical administration of simvastatin can repair bone defect in both long tubular bones and flat bones of rabbits and monkeys as effectively as autograft. Given that it is cheap, safe and already in clinical use, simvastatin might be considered as a bone regeneration inducer with great potential.

External fixators: looking beyond the hardware maze

External fixation has a wide variety of orthopedic applications. Although external fixator frames may have a complex appearance, these constructs are formed from several basic components and can be broadly categorized into unilateral, circular, or hybrid designs. The introduction of computer-aided circular external fixation devices (hexapod frames) has simplified the treatment of multiaxial and especially rotational deformities. Serial radiography plays a central role in the evaluation of callus formation (at the level of treated fracture or nonunion as well as the regenerate and docking site with distraction osteogenesis), tailoring the rate and rhythm of distraction during distraction osteogenesis, evaluation of frame complications, and determination of the timing of frame removal. The goals of this article are to review: the components, types, and relevant terminology of external fixator constructs with special emphasis on the Taylor spatial frame, the principles and techniques of distraction osteogenesis, and complications of external fixation.

Evaluating the Utility of the Pixel Value Ratio in the Determination of Time to Full Weight-bearing in Patients Undergoing Intramedullary Limb Lengthening

Introduction

Limb lengthening using intramedullary nails is an increasingly popular method of achieving limb length equalisation. Currently, the decision regarding when to commence full weight-bearing (FWB) remains largely subjective. Objective criteria for determining the proper timing of FWB would be helpful to limb lengthening surgeons. This study examines using the pixel value ratio (PVR) as an objective method to determine the time to FWB for patients being lengthened with an intramedullary nail.

Materials and methods

A retrospective chart review of 42 patients who underwent unilateral lengthening of the femur was undertaken. The PVR of all four cortices of the regenerate bone was monitored throughout the distraction and consolidation stages to determine the ratio at the time of FWB.

Results

Clinically and radiologically determined FWB was achieved at a mean time of 125.7 ± 30.1 days from surgery. The mean PVR at the time of FWB was 0.94. The medial cortex healed fastest with a mean PVR of 0.96, while the posterior cortex healed slowest with a mean PVR of 0.92.

Conclusion

The PVR is a quick and reliable method to objectively assess the state of healing of the regenerate bone during distraction osteogenesis. We observed that there were no adverse effects when subjects commenced FWB when three out of the four cortices had a PVR of at least 0.93.

How to cite this article

Bafor A, Duncan ME, Iobst CA. Evaluating the Utility of the Pixel Value Ratio in the Determination of Time to Full Weight-bearing in Patients Undergoing Intramedullary Limb Lengthening. Strategies Trauma Limb Reconstr 2020;15(2):74-78.

Radiomorphological Manifestations of Femoral and Tibial Cortical Bones at Different Stages of Limb Lengthening

BACKGROUND

There has been a lot of research done on Ilizarov's limb lengthening; however, very few publications focus on the quantitative assessment of the distractional bone regeneration in tibial and femur lengthening. Data regarding quality of the bone after lengthening are needed to consider the time of frame removal and develop a rehabilitation program.

MATERIALS AND METHODS

Computed tomography (CT) assessment of a parent bone was performed on 136 patients with limb length discrepancy and bone deformity of various etiologies before and after lengthening. Transosseous osteosynthesis technique with the Ilizarov's external fixation was used for limb lengthening and deformity correction in all the cases. A 64-slice scanner was used for CT assessments. Specific Roentgen-negative units of the Ilizarov apparatus and techniques for interpreting CT findings were employed for artifact-free densitometric assessment.

RESULTS

Cortical density of the femur and tibia in patients with limb length discrepancy and bone deformity of various etiologies was shown to have differences as compared to the contralateral limb. The lengthening process was accompanied by decreased cortical density of the segment being lengthened, and the decrease in the density was greater in the areas adjacent to the distractional bone regeneration. The cortical structure underwent characteristic changes. Osteonal density of the cortical bone was higher in the norm and at long term followup as compared to the density of external and internal plates.

CONCLUSION

Cortical bone of the femur and tibia in patients with limb length discrepancy and bone deformity of various etiologies showed various preoperative local densities of external, internal, and osteon layers. The cortical bone demonstrated heterogenic structures with resorption areas of various magnitude and density, with minimal values at the boundary with regenerate bone during distraction and fixation with frame on and at short-term followup. Complete organotypical restructuring of the bone was shown to occur at a 1-to-3-year followup depending on the etiology of the disease and amount of lengthening performed.

Assessment of Bone Healing During Antegrade Intramedullary Rod Femur Lengthening Using Radiographic Pixel Density

INTRODUCTION

Premature full weight bearing after femur lengthening can lead to implant failure, telescopic nail shortening, and regenerate fracture. This study aimed at performing a retrospective analysis of the correlation between pixel density ratio (PDR) calculations and clinical readiness for weight bearing in patients undergoing intramedullary nail-mediated femoral distraction osteogenesis.

METHODS

Thirty-two patients who underwent antegrade femur lengthening were included in this study. The PDR was calculated on femur radiographs in a picture archiving and communication system for each cortex (ie, medial, lateral, anterior, and posterior) at each postoperative visit. These values were then correlated with subjective evaluation of bone healing by the treating physician with expertise in bone lengthening.

RESULTS

Bone regenerate healing was clinically declared by the treating surgeons (S.R.R. and A.T.F.) at a mean of 8.5 weeks (range, 4 to 18 weeks). No implant failure, nail shortening, or regenerate fracture was observed. The overall mean PDR corresponding to clinical bone healing was 0.90, which was significantly (P < 0.001) greater than the mean value at the previous visit (0.82), when the bone was not clinically declared to be healed. The PDR increased in all cortices at all postoperative visits.

CONCLUSIONS

The findings of the present study suggest that there may be a correlation between the PDR and clinical bone healing. This observational pilot study should be followed by additional studies to understand the relationship between the PDR and bony union.

Can Pixel Value Ratio be Used in the Assessment of Ceramic Bone Substitute Incorporation? Observations from a Pilot Study

Background

Assessment of bone graft substitute incorporation is critical in the clinical decision making process and requires special investigations. We examined if the pixel value ratio (PVR) obtained in routine follow-up digital radiographs could be used for such assessment.

Material/Methods

Radiographic images were acquired using either computed radiography or flat panel digital radiography systems. The PVR from radiographs of thirty children with ceramic bone substitute grafting were analyzed using the software from the picture archival and communication system (PACS) workstation. Graft incorporation was also assessed using the van Hemert scale. Three independent observers (A, B, C) measured PVRs at two different time points during the first and the last follow-up visits. PVR was compared with the van Hemert scale scores and analyzed using Spearman's rank correlation.

Results

The mean intra-observer reliability was 0.8996, and inter-observer reliabilities were 0.69 (A vs. C), 0.78 (A vs. B), and 0.85 (B vs. C) for the first follow-up visit and 0.74 (A vs. C), 0.82 (A vs. B), and 0.70 (B vs. C) for the last follow-up measurements. Spearman's correlation showed a strong negative association between PVR values and van Hemert scale scores, as the healing process advanced on serial measurements at each follow-up (r=-0.94, n=60, z=-7.24, p≤0.0001). The reliability of the PVR measurements was assessed using an aluminum step wedge and ceramic graft.

Conclusions

PVR is potentially a reliable indicator of bone graft incorporation and can aid in clinical decision making provided standard radiographic techniques are used.

Determining When It Is Safe to Remove the External Fixator: Results From a Survey of the Limb Lengthening and Reconstruction Society

Thousands of external fixators are applied for distraction osteogenesis each year. Determining when it is safe to remove the fixator can be difficult. The purpose of this study was to survey an international group of external fixation surgeons to determine their current practice patterns surrounding external fixator removal. A 10-question, open-ended survey was emailed to members of the Limb Lengthening and Reconstruction Society. Responses were recorded, and statistical analysis was performed. Pearson's chi-square test and likelihood ratio were used when indicated. A total of 124 surveys were sent, and 44 responses were received (35% response rate). The top 5 responses for determining when it is safe to remove a fixator were full weight bearing (75%), 3 cortices (71%), no pain (55%), after dynamization (55%), and duration of time (30%). Forty-eight percent of respondents routinely dynamized the frame prior to removal. Significantly fewer surgeons who dynamized the frame protected the limb after removal (P=.046). Physicians who dynamized the frame tended to use a less-constricting device for protection (boot or brace vs cast) than those who did not dynamize (P=.016). This study showed that most surgeons used radiographs and clinical evaluation to determine timing of fixator removal. Only 23% reported using computed tomography. Most surgeons dynamized the fixator prior to removal. Those who dynamized the frame were more confident in the regenerate healing. Although this study offers insight into what experienced surgeons do in their daily practice, it reveals many areas for improvement in the literature. [Orthopedics. 2017; 40(5):e876-e879.].

Femoral lengthening in children and adolescents

Current lengthening techniques are still based on the Ilizarov method and the concept of callotasis. Research and progress in medical devices have led to constant improvement in results. Hexapod fixators allow more precise correction of complex deformities, with shorter learning curve. Associating lengthening by external fixation (EF) to internal fixation (K-wire, intramedullary nail or locking plate) has reduced EF times and complications rates, while improving anatomic and functional results. Lengthening nails provides faster recovery of range of motion and return to activity during lengthening and consolidation, with better psychological tolerance. Lengthening with deformity correction by retrograde nailing has no impact on consolidation. Monolateral EF is a reliable and easy-to-implement technique that is well tolerated by patients. Association to internal fixation gives promising results. Bone healing solidity assessment on plain X-ray is highly subjective, with wide inter- and intra-observer variation; bone mineralization is better assessed in terms of pixel-value ratio (PVR: ratio of pixel value of regenerate to adjacent bone) on picture archiving and communication system (PACS) digitized radiographs, providing objective assessment of callus solidity.

Reamed Intramedullary Nailing has an Adverse Effect on Bone Regeneration During the Distraction Phase in Tibial Lengthening

BACKGROUND

The lengthening over nail (LON) technique has gained popularity because it enables shorter periods of external fixation, prevents deformities during lengthening, and reduces the risk of refracture after removal of the frame compared with the classic Ilizarov method. However, it is not clear if the violation of endosteal blood supply by reamed intramedullary nailing in the LON technique has a negative effect on bone regeneration or a positive effect by compensatory enhancement of periosteal circulation.

QUESTIONS/PURPOSES

The purposes of this study were to (1) compare the amount of regenerate bone during the distraction phase between two tibial lengthening techniques, the LON technique and lengthening and then nail (LATN) technique; and (2) compare callus shape at the end of the distraction phase using the classification of Li et al.

METHODS

This is a retrospective study comparing two treatment groups. Between September 2011 and June 2013, 120 patients underwent bilateral lower leg lengthening for familial short stature with either the LON or LATN technique, and were considered potentially eligible for inclusion in this retrospective, comparative study. During this same period, LON and LATN techniques were used in other patient populations, but all patients with familial short stature were considered for inclusion in the study. The specific contraindications for LON were diameter of the isthmus of the tibia narrower than 8 mm, length of the tibia shorter than 270 mm, and alignment of the lower extremity in valgus; in patients without these specific contraindications to LON, patients were offered either LATN or LON after counseling regarding the advantages and disadvantages of each procedure. The proposed advantages of LATN were shorter healing index and more stable internal fixation which might lead to earlier full weightbearing, whereas proposed disadvantages were a greater chance for deep infection, more deformity during lengthening, and subsequently longer external fixator period for correction. The groups were comparable in terms of age, sex distribution, smoking history, BMI, distraction rate, and final length gain. A longer period of external fixation was necessary in the LATN group, related to the relative stability of the segment without an intramedullary nail. Patients with tibial lengthening with the LON technique (31 patients, 62 tibiae) were compared with patients who had the LATN technique (89 patients, 178 tibiae) regarding the amount of bone regeneration at the anterior, posterior, medial, and lateral cortices of the lengthened area for each at 4, 8, and 12 weeks postoperatively using a pixel value ratio method. In addition, both groups were compared for callus shape and type at the end of the distraction phase (LON, 3.4 ± 0.06 months; LATN, 4.2 ± 0.05 months).

RESULTS

The pixel value ratios of the anterior, posterior, medial, and lateral cortices in the LON and LATN groups were 0.78 ± 0.06 and 0.74 ± 0.05; 0.82 ± 0.08 and 0.76 ± 0.05; 0.75 ± 0.06 and 0.72 ± 0.05; and 0.85 ± 0.06 and 0.82 ± 0.06, respectively at 4 weeks postoperatively(p value > 0.500 for all); 0.75 ± 0.05 and 0.77 ± 0.04; 0.78 ± 0.05 and 0.89 ± 0.04; 0.73 ± 0.05 and 0.82 ± 0.05; and 0.78 ± 0.06 and 0.88 ± 0.03, respectively at 8 weeks postoperatively (p value < 0.001 for the posterior, medial, and lateral cortices); 0.72 ± 0.05 and 0.76 ± 0.03; 0.75 ± 0.07 and 0.89 ± 0.03; 0.71 ± 0.05 and 0.82 ± 0.03; and 0.78 ± 0.06 and 0.91 ± 0.03, respectively at 12 weeks postoperatively (p value < 0.001 for the posterior, medial, and lateral cortices). A greater percentage of tibiae having the generally favored fusiform-shaped callus were seen with the LATN technique (61 of 178 segments) than with the LON technique (four of 62 segments; p < 0.001). There were no tibia showing the inferior concave, lateral, or central-shaped callus with the LATN technique, whereas eight tibiae (eight of 62 segments) showed concave-shaped callus with the LON technique (p < 0.001).

CONCLUSIONS

The potentially negative effect on callus regeneration from the concomitant use of reamed intramedullary nailing during the LON technique should not be overlooked. Based on our study, LATN may be a better choice for patients willing to accept the longer period of external fixation.

LEVEL OF EVIDENCE

Level III, therapeutic study.

Limb Lengthening in Patients with Achondroplasia

PURPOSE

Although bilateral lower-limb lengthening has been performed on patients with achondroplasia, the outcomes for the tibia and femur in terms of radiographic parameters, clinical results, and complications have not been compared with each other. We proposed 1) to compare the radiological outcomes of femoral and tibial lengthening and 2) to investigate the differences of complications related to lengthening.

MATERIALS AND METHODS

We retrospectively reviewed 28 patients (average age, 14 years 4 months) with achondroplasia who underwent bilateral limb lengthening between 2004 and 2012. All patients first underwent bilateral tibial lengthening, and at 9-48 months (average, 17.8 months) after this procedure, bilateral femoral lengthening was performed. We analyzed the pixel value ratio (PVR) and characteristics of the callus of the lengthened area on serial radiographs. The external fixation index (EFI) and healing index (HI) were computed to compare tibial and femoral lengthening. The complications related to lengthening were assessed.

RESULTS

The average gain in length was 8.4 cm for the femur and 9.8 cm for the tibia. The PVR, EFI, and HI of the tibia were significantly better than those of the femur. Fewer complications were found during the lengthening of the tibia than during the lengthening of the femur.

CONCLUSION

Tibial lengthening had a significantly lower complication rate and a higher callus formation rate than femoral lengthening. Our findings suggest that bilateral limb lengthening (tibia, followed by femur) remains a reasonable option; however, we should be more cautious when performing femoral lengthening in selected patients.

Computed radiographic and ultrasonic evaluation of bone regeneration during tibial distraction osteogenesis in rabbits

Computed radiography (CR) and a combined ultrasound (US) approach involving two-dimensional (2-D) and three-dimensional (3-D) ultrasonography with ultrasonometry were employed to evaluate their respective efficacies in monitoring bone regeneration during rabbit tibial distraction osteogenesis (DO). Results demonstrated that 2-D and 3-D ultrasonography depicted bone callus growth changes during distraction while CR could not. Evaluation of callus speed of sound, acoustic reflection and attenuation showed significant linear changes over time during early DO stage (p < 0.05). However, surrogate measure of callus density by CR only showed such significant linear changes during consolidation (p < 0.05). Also, callus speed of sound and acoustic reflection during early DO stage showed strong predictions to the bone mineral density and microstructural properties (adjusted-R(2) = 0.43-0.67) of consolidated bone callus measured at the treatment end-point by microcomputed tomography. Findings of the present study indicated a preferred use of the combined US approach over CR in the early monitoring of bone regeneration during DO treatment.

Comparison between upper and lower limb lengthening in patients with achondroplasia: a retrospective study

Lengthening of the humerus is now an established technique. We compared the complications of humeral lengthening with those of femoral lengthening and investigated whether or not the callus formation in the humerus proceeds at a higher rate than that in the femur. A total of 24 humeral and 24 femoral lengthenings were performed on 12 patients with achondroplasia. We measured the pixel value ratio (PVR) of the lengthened area on radiographs and each radiograph was analysed for the shape, type and density of the callus. The quality of life (QOL) of the patients after humeral lengthening was compared with that prior to surgery. The complication rate per segment of humerus and femur was 0.87% and 1.37%, respectively. In the humerus the PVR was significantly higher than that of the femur. Lower limbs were associated with an increased incidence of concave, lateral and central callus shapes. Humeral lengthening had a lower complication rate than lower-limb lengthening, and QOL increased significantly after humeral lengthening. Callus formation in the humerus during the distraction period proceeded at a significantly higher rate than that in the femur. These findings indicate that humeral lengthening has an important role in the management of patients with achondroplasia.

Serial bone mineral density ratio measurement for fixator removal in tibia distraction osteogenesis and need of a supportive method using the pixel value ratio

Distraction osteogenesis is one of the common procedures for limb lengthening. However, attempts are being made constantly to establish objective guidelines for early and safe removal of a fixator using a sensitive and quantitative measurement technique. Dual-energy X-ray absorptiometry (DEXA) has been evaluated in the past for understanding callus stiffness, and the present study is a step further in this direction. The purpose of this study was to evaluate the correlation between bone mineral density ratio (BMDR) obtained by a DEXA scan and the pixel value ratio (PVR) on plain digital radiographs at each cortex and various callus pathways and callus shapes as described by Ru-Li's classification. A retrospective analysis of 40 tibial segments in 23 patients operated upon for various indications for limb lengthening was carried out. There were 11 male and 12 female patients with a mean age of 18 years. The Ilizarov method was applied after monofocal osteotomy, and distraction and consolidation were monitored using digital radiographs and DEXA scanning. BMDR was positively correlated with PVR, and the optimal BMDR for removal of the fixator was found to be 0.511. PVR of all cortices, except the anterior cortex, showed significant positive correlation with BMDR of the regenerate. There was good correlation between BMDR and PVR in the homogenous or heterogenous pathway according to callus shape and pathway. Thus, this study shows that BMD measurement can provide an objective and noninvasive method for assessing the rate of new bone formation during tibial distraction osteogenesis. It can thus function as an effective adjunct to measure callus stiffness, along with PVR, using digital radiographs, especially in cases in which callus maturation and stiffness is doubtful. Further studies especially dealing with callus progression through the lucent pathway as well as those dealing with regenerate fractures may be needed to conclusively prove the efficacy of this method for measurement of callus maturation.

Comparative study of callus progression in limb lengthening with or without intramedullary nail with reference to the pixel value ratio and the Ru Li's classification

INTRODUCTION

Callus progression is a great concern during limb lengthening. In this study, we investigated the difference in callus progression between tibial lengthenings with and without intramedullary nail.

METHOD

Seventy tibiae in 38 patients with an average age of 24 years were lengthened with Ilizarov external fixator and nail; 56 tibiae in 40 patients with an average age of 28.6 years were lengthened with the same Ilizarov external fixator but without nail. The callus progression was compared with reference to pixel value ratio (PVR) and Ru Li's classification. Statistical analysis was performed to compare the variation trend of PVR and incidence of various callus pathways (particular patterns of callus progression as outlined in Ru Li's classification) and shapes of each aspect of callus between the two groups.

RESULTS

The trend of PVR was not statistically different in posterior, lateral and medial aspects of the callus between the two groups, but averagely lower in the anterior aspect in the group without nail than that with nail. The group without nail presented less incidence of homogeneous pathway, greater incidence of heterogeneous pathway; also greater incidence of fusiform callus, less incidence of cylindrical callus.

CONCLUSION

It was concluded that with nail, the callus underwent a more favorable progression and even longer lengthening could be allowed.

Callus patterns in femoral lengthening over an intramedullary nail

Our objectives were to evaluate callus patterns seen in femoral lengthening over an intramedullary nail by Li classification regarding shape and type and to predict the result while using the nail to reduce the external fixation period and its complications. Eight hundred digital radiographs of 15 patients with 15 segments of femur shortening who underwent femoral lengthening with a monolateral external fixator over an intramedullary nail were analyzed retrospectively by four observers. Each radiograph was studied for callus shape, feature type, and callus density using pixel values. The classification was tested for concurrence and reproducibility by interobserver studies and callus patterns were compared with treatment indices to evaluate how they correlated with the outcome. Mean length gained was 4.5 cm (range: 2-8 cm). External fixator index (EFI) was 21.68 days/cm. Average distraction consolidation index (DCI) was 48.49 days/cm. Fusiform callus was seen in three cases, cylindrical in seven, and lateral in five. The homogenous pathway had higher DCI (43.7) than the heterogeneous pathway (32.9), and mixed pathways making up the rest had a DCI of 50.1. Pixel value of callus showed gradual increase in density until 20-24 weeks, then density gradually fell for 8 weeks, again increased after 32 weeks, again gradually fell, and was comparable to adjacent normal bone by 44-48 weeks. Our results suggest that the Li classification can be satisfactorily applied to lengthening procedures over intramedullary nails. The radiologic pattern and pixel value of regenerate can be correlated with the clinical outcome and can be an aid of prognostic value for the surgeon.

Complications and outcome of tibial lengthening using the Ilizarov method with or without a supplementary intramedullary nail

We compared the complications and outcome of tibial lengthening using the Ilizarov method with and without the use of a supplementary intramedullary nail. In a retrospective case-matched series assembled from 176 patients with tibial lengthening, we matched 52 patients (26 pairs, group A with nail and group B without) according to the following criteria in order of importance: 1) difference in amount of lengthening (± 2 cm); 2) percentage difference in lengthening (± 5%); 3) difference in patient’s age (± seven years); 4) aetiology of the shortening, and 5) level of difficulty in obtaining the correction. The outcome was evaluated using the external fixator index, the healing index and an outcome score according to the criteria of Paley. It was found that some complications were specific to group A or B respectively, but others were common to both groups.

The outcome was generally better in lengthenings with a nail, although there was a higher incidence of rectifiable equinus deformity in these patients.

Analysis of corticalization using the pixel value ratio for fixator removal in tibial lengthening

BACKGROUND

It is important to define callus maturation and corticalization during distraction osteogenesis. Quantitative methods such as ultrasound and Q-computed tomography are sensitive but expensive. The pixel value ratio (PVR) obtained using a PACS (picture archiving and communication system) is a simple and cost-effective investigation tool. Recently, the issue of whether the PVR is correlated with quantitative methods has been studied. We investigated whether serial PVR is a useful technique for predicting corticalization in each callus segment of the regenerate, and can act as a guide for fixator removal in tibial lengthening without intramedullary nailing.

METHODS

A retrospective analysis of 30 tibial segments in 18 patients was performed. The mean age of the patients was 18 years (range 5-48 years). There were 6 male patients and 12 female patients, of whom 8 patients were skeletally mature. Indications for limb lengthening were achondroplasia (8 patients), limb length discrepancy (4 patients), and miscellaneous (6 patients). The interobserver variability of the PVR was measured at each callus segment of the regenerate. Serial PVR at each callus segment was classified according to the callus pathway.

RESULTS

The mean interobserver correlation coefficient at the regenerate was high in the posterior callus segment (0.92), the lateral callus segment (0.90), and the medial callus segment (0.70). However, there was low mean interobserver variability in the anterior callus segment (0.49) at the regenerate. A PVR of 1 at the regenerate was achieved first at the lateral callus segment, second at the posterior, third at the medial callus segment, and last at the anterior callus segment. There was no fracture at the regenerate or wire breakage in patients who began fixator removal and full weight bearing when the PVR was 1 in the three callus segments at the regenerate.

CONCLUSIONS

In tibial lengthening without nailing, serial measurement of the PVR is a reliable and cost-effective technique to assess the maturity of the callus, especially in the lateral and posterior callus segments, and assessment of the cortical pixel value can safely provide guidelines for fixator removal.

Analysis of callus pattern of tibia lengthening in achondroplasia and a novel method of regeneration assessment using pixel values

OBJECTIVE

To relate morphology of new bone formation to outcome after tibial lengthening performed in patients with achondroplasia.

MATERIAL AND METHODS

A retrospective analysis of 60 tibial segments in 30 achondroplasia patients was performed. There were 22 female patients and eight male patients, with a mean age of 9.8 years. New bone formation was classified by shape, homogeneity and density. Pixel values in relation to original bone were measured using a picture-archiving communication system (PACS). Clinical outcome was described by the external fixator and maturation indices.

RESULTS

Mean lengthening was 9.2 cm (range 3-12.7 cm). The mean external fixator index was 23.4 (range 15.1-50). The mean maturation index was 12.3 days/cm (range 6-40 days/cm). Homogeneous pathways were associated with the best clinical results (fixator index 20.4, maturation index 10.8), followed by heterogeneous pathway (external fixator index 26.5, maturation index 16.8) and radiolucent pathway (fixator index 31.2, maturation index 21.4). Both cylindrical (external fixator index 25.2, maturation index 14.5) and concave (external fixator index 26.6, maturation index 16.3) callus shapes were favourable. Mineralization of new bone became equal to that of normal bone within 16 weeks (mean) for homogeneous pathway, 12 weeks for heterogeneous pathway and 32 weeks for lucent pathway.

CONCLUSION

The type of new bone formation seen on radiographs is related to clinical outcome, with homogeneous pathways being the most favourable ones.

Noninvasive quantitative assessment of bone healing after distraction osteogenesis

One of the greatest challenges of limb lengthening and deformity correction is deciding when the bone has healed enough to remove the external fixator. Standard radiography is the most common imaging method used to assess bone healing after distraction osteogenesis because it is widely available, cheap, and relatively safe. However, other imaging technologies and methods are being investigated that will help quantify bone healing after distraction osteogenesis, providing an objective method for deciding when it is appropriate to remove an external fixator. This review will examine the latest techniques used to assess bone healing after distraction osteogenesis including dual-energy X-ray absorptiometry scans, ultrasound, quantitative computed tomography, and digital radiography (X-ray). Recommendations for clinical practice will be outlined.

Objective guidelines for removing an external fixator after tibial lengthening using pixel value ratio: a pilot study

During limb lengthening over an intramedullary nail, decisions regarding external fixator removal and weightbearing depend on the amount of callus seen at the lengthening area on radiographs. However, this method is subjective and objective evaluation of the amount of callus likely would minimize nail or interlocking screw breakage and refracture after fixator removal. We asked how many cortices with full corticalization of the newly formed bone at the lengthening area are needed to allow fixator removal and full weightbearing and how to radiographically determine the stage of corticalization. We retrospectively reviewed 17 patients (34 lengthenings) who underwent bilateral tibial lengthenings over an intramedullary nail. The average gain in length was 7.2 +/- 3.4 cm. We determined the pixel value ratio (ratio of pixel value of regenerate versus the mean pixel value of adjacent bone) of the lengthened area on radiographs. There were no nail or screw breakage and refracture. Partial weightbearing with crutches was permitted when the pixel value ratio was 1 in two cortices and full weightbearing without crutches was permitted when the pixel value ratio was 1 in three cortices. The pixel value ratio on radiographs can be an objective parameter for callus measurement and may provide guidelines for the timing of external fixator removal. We cannot determine from our limited data the minimum pixel value in how many cortices would suggest safe removal, but we can say our criteria were not associated with subsequent refracture.