1
|
El-Mansi M, Afolabi O, Phue JN, Shiloach J. Coordinated expression of acetyl CoA synthetase and the ace operon enzymes in Escherichia coli in preparation for adaptation to acetate. MICROBIOLOGY (READING, ENGLAND) 2022; 168. [PMID: 36048631 DOI: 10.1099/mic.0.001230] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
Abstract
Successful adaptation of Escherichia coli to constant environmental challenges demands the operation of a wide range of regulatory control mechanisms, some of which are global, while others are specific. Here, we show that the ability of acetate-negative phenotype strains of E. coli devoid of acetate kinase (AK) and phosphotransacetylase (PTA) to assimilate acetate when challenged at the end of growth on acetogenic substrates is explicable by the co-expression of acetyl CoA-synthetase (AcCoA-S) and acetate permease (AP). Furthermore, mRNA transcript measurements for acs and aceA, together with the enzymatic activities of their corresponding enzymes, acetyl CoA synthetase (AcCoA-S) and isocitrate lyase (ICL), clearly demonstrate that the expression of the two enzymes is inextricably linked and triggered in response to growth rate threshold signal (0.4 h-1± 0.03: n4). Interestingly, further restriction of carbon supply to the level of starvation led to the repression of acs (AcCoA-S), ackA (AK) and pta (PTA). Further, we provide evidence that the reaction sequence catalysed by PTA, AK and AcCoA-S is not in operation at low growth rates and that the reaction catalysed by AcCoA-S is not merely an ATP-dissipating reaction but rather advantageous, as it elevates the available free energy (ΔG°) in central metabolism. Moreover, the transcriptomic data reinforce the view that the expression of PEP carboxykinase is essential in gluconeogenic phenotypes.
Collapse
Affiliation(s)
- Mansi El-Mansi
- Bio-Ed, Scotland UK, 17/7 Watson Crescent, Edinburgh EH11 1HA, Scotland, UK.,Departments of Biochemistry, Faculty of Science, University of Africa, Toru-Orua, Bayelsa State, Nigeria
| | - Olumide Afolabi
- Departments of Biochemistry, Faculty of Science, University of Africa, Toru-Orua, Bayelsa State, Nigeria
| | - Je-Nie Phue
- Biotechnology Lab, National Institute of Diabetes and Digestive and Kidney Diseases, National Institutes of Health, Building 14A, Room 173, 9000 Rockville Pike, Bethesda MD 20892, USA.,Present address: Facility for Biotechnology Resources, Centre for Biologics Evaluation and Research. U.S. Food and Drug Administration 10903 New Hampshire Ave., MD 20993, Silver Spring, USA
| | - Joseph Shiloach
- Biotechnology Lab, National Institute of Diabetes and Digestive and Kidney Diseases, National Institutes of Health, Building 14A, Room 173, 9000 Rockville Pike, Bethesda MD 20892, USA
| |
Collapse
|
2
|
Liu M, Guo L, Fu Y, Huo M, Qi Q, Zhao G. Bacterial protein acetylation and its role in cellular physiology and metabolic regulation. Biotechnol Adv 2021; 53:107842. [PMID: 34624455 DOI: 10.1016/j.biotechadv.2021.107842] [Citation(s) in RCA: 21] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/24/2021] [Revised: 09/22/2021] [Accepted: 10/03/2021] [Indexed: 12/28/2022]
Abstract
Protein acetylation is an evolutionarily conserved posttranslational modification. It affects enzyme activity, metabolic flux distribution, and other critical physiological and biochemical processes by altering protein size and charge. Protein acetylation may thus be a promising tool for metabolic regulation to improve target production and conversion efficiency in fermentation. Here we review the role of protein acetylation in bacterial physiology and metabolism and describe applications of protein acetylation in fermentation engineering and strategies for regulating acetylation status. Although protein acetylation has become a hot topic, the regulatory mechanisms have not been fully characterized. We propose future research directions in protein acetylation.
Collapse
Affiliation(s)
- Min Liu
- State Key Laboratory of Microbial Technology, Shandong University, 266237 Qingdao, China; CAS Key Laboratory of Biobased Materials, Qingdao Institute of Bioenergy and Bioprocess Technology, Chinese Academy of Sciences, Qingdao, 266101, China
| | - Likun Guo
- State Key Laboratory of Microbial Technology, Shandong University, 266237 Qingdao, China
| | - Yingxin Fu
- State Key Laboratory of Microbial Technology, Shandong University, 266237 Qingdao, China
| | - Meitong Huo
- State Key Laboratory of Microbial Technology, Shandong University, 266237 Qingdao, China
| | - Qingsheng Qi
- State Key Laboratory of Microbial Technology, Shandong University, 266237 Qingdao, China
| | - Guang Zhao
- State Key Laboratory of Microbial Technology, Shandong University, 266237 Qingdao, China; CAS Key Laboratory of Biobased Materials, Qingdao Institute of Bioenergy and Bioprocess Technology, Chinese Academy of Sciences, Qingdao, 266101, China.
| |
Collapse
|
3
|
Ortega-Quintana FA, Trujillo-Roldán MA, Botero-Castro H, Alvarez H. Modeling the interaction between the central carbon metabolism of Escherichia coli and bioreactor culture media. Biochem Eng J 2020. [DOI: 10.1016/j.bej.2020.107753] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/23/2022]
|
4
|
Schütze A, Benndorf D, Püttker S, Kohrs F, Bettenbrock K. The Impact of ackA, pta, and ackA-pta Mutations on Growth, Gene Expression and Protein Acetylation in Escherichia coli K-12. Front Microbiol 2020; 11:233. [PMID: 32153530 PMCID: PMC7047895 DOI: 10.3389/fmicb.2020.00233] [Citation(s) in RCA: 32] [Impact Index Per Article: 8.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/19/2019] [Accepted: 01/31/2020] [Indexed: 01/06/2023] Open
Abstract
Acetate is a characteristic by-product of Escherichia coli K-12 growing in batch cultures with glucose, both under aerobic as well as anaerobic conditions. While the reason underlying aerobic acetate production is still under discussion, during anaerobic growth acetate production is important for ATP generation by substrate level phosphorylation. Under both conditions, acetate is produced by a pathway consisting of the enzyme phosphate acetyltransferase (Pta) producing acetyl-phosphate from acetyl-coenzyme A, and of the enzyme acetate kinase (AckA) producing acetate from acetyl-phosphate, a reaction that is coupled to the production of ATP. Mutants in the AckA-Pta pathway differ from each other in the potential to produce and accumulate acetyl-phosphate. In the publication at hand, we investigated different mutants in the acetate pathway, both under aerobic as well as anaerobic conditions. While under aerobic conditions only small changes in growth rate were observed, all acetate mutants showed severe reduction in growth rate and changes in the by-product pattern during anaerobic growth. The AckA- mutant showed the most severe growth defect. The glucose uptake rate and the ATP concentration were strongly reduced in this strain. This mutant exhibited also changes in gene expression. In this strain, the atoDAEB operon was significantly upregulated under anaerobic conditions hinting to the production of acetoacetate. During anaerobic growth, protein acetylation increased significantly in the ackA mutant. Acetylation of several enzymes of glycolysis and central metabolism, of aspartate carbamoyl transferase, methionine synthase, catalase and of proteins involved in translation was increased. Supplementation of methionine and uracil eliminated the additional growth defect of the ackA mutant. The data show that anaerobic, fermentative growth of mutants in the AckA-Pta pathway is reduced but still possible. Growth reduction can be explained by the lack of an important ATP generating pathway of mixed acid fermentation. An ackA deletion mutant is more severely impaired than pta or ackA-pta deletion mutants. This is most probably due to the production of acetyl-P in the ackA mutant, leading to increased protein acetylation.
Collapse
Affiliation(s)
- Andrea Schütze
- Max Planck Institute for Dynamics of Complex Technical Systems, Magdeburg, Germany
| | - Dirk Benndorf
- Bioprocess Engineering, Otto von Guericke University, Magdeburg, Germany
| | - Sebastian Püttker
- Bioprocess Engineering, Otto von Guericke University, Magdeburg, Germany
| | - Fabian Kohrs
- Bioprocess Engineering, Otto von Guericke University, Magdeburg, Germany
| | - Katja Bettenbrock
- Max Planck Institute for Dynamics of Complex Technical Systems, Magdeburg, Germany
| |
Collapse
|
5
|
Han Q, Eiteman MA. Acetate formation during recombinant protein production in Escherichia coli K-12 with an elevated NAD(H) pool. Eng Life Sci 2019; 19:770-780. [PMID: 32624970 DOI: 10.1002/elsc.201900045] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/08/2019] [Revised: 08/15/2019] [Accepted: 08/21/2019] [Indexed: 12/14/2022] Open
Abstract
Acetate formation is a disadvantage in the use of Escherichia coli for recombinant protein production, and many studies have focused on optimizing fermentation processes or altering metabolism to eliminate acetate accumulation. In this study, E. coli MEC697 (MG1655 nadR nudC mazG) maintained a larger pool of NAD(H) compared to the wild-type control, and also accumulated lower concentrations of acetate when grown in batch culture on glucose. In steady-state cultures, the elevated total NAD(H) found in MEC697 delayed the threshold dilution rate for acetate formation to a growth rate of 0.27 h-1. Batch and fed-batch processes using MEC697 were examined for the production of β-galactosidase as a model recombinant protein. Fed-batch culture of MEC697/pTrc99A-lacZ compared to MG1655/pTrc99A-lacZ at a growth rate of 0.22 h-1 showed only a modest increase of protein formation. However, 1 L batch growth of MEC697/pTrc99A-lacZ resulted in 50% lower acetate formation compared to MG1655/pTrc99A-lacZ and a two-fold increase in recombinant protein production.
Collapse
Affiliation(s)
- Qi Han
- School of Chemical Materials and Biomedical Engineering University of Georgia Athens GA USA
| | - Mark A Eiteman
- School of Chemical Materials and Biomedical Engineering University of Georgia Athens GA USA
| |
Collapse
|
6
|
High-cell density culture of poly(lactate-co-3-hydroxybutyrate)-producing Escherichia coli by using glucose/xylose-switching fed-batch jar fermentation. J Biosci Bioeng 2018; 127:721-725. [PMID: 30573386 DOI: 10.1016/j.jbiosc.2018.11.006] [Citation(s) in RCA: 15] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/04/2018] [Revised: 11/02/2018] [Accepted: 11/11/2018] [Indexed: 11/23/2022]
Abstract
Poly(lactate-co-3-hydroxybutyrate) [P(LA-co-3HB)] is produced in engineered Escherichia coli harboring the genes encoding an LA-polymerizing enzyme (LPE) and monomer-supplying enzymes. In this study, high cell-density fed-batch jar fermentation was developed using xylose and/or glucose as the carbon source. Fed-batch fermentation was initially performed with 20 g/L sugar during the batch phase for 24 h, and subsequent sugar feeding from 24 to 86 h. The feeding rate was increased in a stepwise manner. When xylose alone was used for cultivation, the cells produced the polymer at 11.6 g/L, which was higher than the 4.3 g/L obtained using glucose as the sole carbon source. However, in the first 24 h the growth in the glucose culture was greater than in the xylose culture. Based on these results, glucose was used for cell growth (at the initial stage) and xylose was used for polymer production (at the feeding stage). As expected, in the glucose/xylose switching fermentation method, polymer production was significantly enhanced, eventually reaching 26.7 g/L. The enhanced polymer production obtained by using xylose was presumably due to overflow metabolism. In fact, during xylose feeding, acetic acid excretion was greater than that in case of the glucose grown culture, suggesting the channeling of the metabolic flux from acetyl-CoA towards polymer production over into the tricarboxylic acid cycle in the xylose-fed cultures. Therefore, this sequential glucose/xylose feed strategy is potentially useful for production of acetyl-CoA derived compounds in E. coli.
Collapse
|
7
|
Liu C, Ding Y, Xian M, Liu M, Liu H, Ma Q, Zhao G. Malonyl-CoA pathway: a promising route for 3-hydroxypropionate biosynthesis. Crit Rev Biotechnol 2017; 37:933-941. [PMID: 28078904 DOI: 10.1080/07388551.2016.1272093] [Citation(s) in RCA: 28] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/14/2022]
Abstract
3-Hydroxypropionate (3HP) is an attractive platform chemical, serving as a precursor to a variety of commodity chemicals like acrylate and acrylamide, as well as a monomer of a biodegradable plastic. To establish a sustainable way to produce these commercially important chemicals and materials, fermentative production of 3HP is widely investigated in recent years. It is reported that 3HP can be produced from several intermediates, such as glycerol, malonyl-CoA, and β-alanine. Among all these biosynthetic routes, the malonyl-CoA pathway has some distinct advantages, including a broad feedstock spectrum, thermodynamic feasibility, and redox neutrality. To date, this pathway has been successfully constructed in various species including Escherichia coli, yeast and cyanobacteria, and optimized through carbon flux redirection, enzyme screening and engineering, and an increasing supply of energy and cofactors, resulting in significantly enhanced 3HP titer up to 40 g/L. These results show the feasibility of commercial manufacturing of 3HP and its derivatives in the future.
Collapse
Affiliation(s)
- Changshui Liu
- a CAS Key Lab of Biobased Materials , Qingdao Institute of Bioenergy and Bioprocess Technology, Chinese Academy of Sciences , Qingdao , China.,b Institute of Oceanology , Chinese Academy of Sciences , Qingdao , China
| | - Yamei Ding
- b Institute of Oceanology , Chinese Academy of Sciences , Qingdao , China
| | - Mo Xian
- a CAS Key Lab of Biobased Materials , Qingdao Institute of Bioenergy and Bioprocess Technology, Chinese Academy of Sciences , Qingdao , China
| | - Min Liu
- a CAS Key Lab of Biobased Materials , Qingdao Institute of Bioenergy and Bioprocess Technology, Chinese Academy of Sciences , Qingdao , China
| | - Huizhou Liu
- a CAS Key Lab of Biobased Materials , Qingdao Institute of Bioenergy and Bioprocess Technology, Chinese Academy of Sciences , Qingdao , China
| | - Qingjun Ma
- b Institute of Oceanology , Chinese Academy of Sciences , Qingdao , China
| | - Guang Zhao
- a CAS Key Lab of Biobased Materials , Qingdao Institute of Bioenergy and Bioprocess Technology, Chinese Academy of Sciences , Qingdao , China
| |
Collapse
|
8
|
A Comparison of the ATP Generating Pathways Used by S. Typhimurium to Fuel Replication within Human and Murine Macrophage and Epithelial Cell Lines. PLoS One 2016; 11:e0150687. [PMID: 26930214 PMCID: PMC4773185 DOI: 10.1371/journal.pone.0150687] [Citation(s) in RCA: 14] [Impact Index Per Article: 1.8] [Reference Citation Analysis] [Abstract] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/20/2015] [Accepted: 02/18/2016] [Indexed: 12/21/2022] Open
Abstract
The metabolism of S. Typhimurium within infected host cells plays a fundamental role in virulence since it enables intracellular proliferation and dissemination and affects the innate immune response. An essential requirement for the intracellular replication of S. Typhimurium is the need to regenerate ATP. The metabolic route used to fulfil this requirement is the subject of the present study. For infection models we used human and murine epithelial and macrophage cell lines. The epithelial cell lines were mICc12, a transimmortalised murine colon enterocyte cell line that shows many of the characteristics of a primary epithelial cell line, and HeLa cells. The model macrophage cell lines were THP-1A human monocyte/macrophages and RAW 264.7 murine macrophages. Using a mutational approach combined with an exometabolomic analysis, we showed that neither fermentative metabolism nor anaerobic respiration play major roles in energy generation in any of the cell lines studied. Rather, we identified overflow metabolism to acetate and lactate as the foremost route by which S. Typhimurium fulfils its energy requirements.
Collapse
|
9
|
Basan M, Hui S, Okano H, Zhang Z, Shen Y, Williamson JR, Hwa T. Overflow metabolism in Escherichia coli results from efficient proteome allocation. Nature 2016; 528:99-104. [PMID: 26632588 PMCID: PMC4843128 DOI: 10.1038/nature15765] [Citation(s) in RCA: 431] [Impact Index Per Article: 53.9] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/21/2015] [Accepted: 10/01/2015] [Indexed: 12/27/2022]
Abstract
Overflow metabolism refers to the seemingly wasteful strategy in which cells use fermentation instead of the more efficient respiration to generate energy, despite the availability of oxygen. Known as Warburg effect in the context of cancer growth, this phenomenon occurs ubiquitously for fast growing cells, including bacteria, fungi, and mammalian cells, but its origin has remained mysterious despite decades of research. Here we study metabolic overflow in E. coli and show that it is a global physiological response used to cope with changing proteomic demands of energy biogenesis and biomass synthesis under different growth conditions. A simple model of proteomic resource allocation can quantitatively account for all of the observed behaviors and accurately predict responses to novel perturbations. The key hypothesis of the model, that the proteome cost of energy biogenesis by respiration exceeds that by fermentation, is quantitatively confirmed by direct measurement of protein abundances via quantitative mass spectrometry.
Collapse
Affiliation(s)
- Markus Basan
- Department of Physics, University at San Diego, La Jolla, of California California 92093-0374, USA.,Institute of Molecular Systems Biology, ETH Zürich, 8093 Zürich, Switzerland
| | - Sheng Hui
- Department of Physics, University at San Diego, La Jolla, of California California 92093-0374, USA
| | - Hiroyuki Okano
- Department of Physics, University at San Diego, La Jolla, of California California 92093-0374, USA.,Section of Molecular Biology, Division of Biological Sciences, University of California at San Diego, La Jolla, California 92093 USA
| | - Zhongge Zhang
- Section of Molecular Biology, Division of Biological Sciences, University of California at San Diego, La Jolla, California 92093 USA
| | - Yang Shen
- Section of Molecular Biology, Division of Biological Sciences, University of California at San Diego, La Jolla, California 92093 USA
| | - James R Williamson
- Department of Integrative Structural and Computational Biology, Department of Chemistry, The Skaggs Institute for Chemical Biology, The Scripps Research Institute, La Jolla, CA 92037, USA
| | - Terence Hwa
- Department of Physics, University at San Diego, La Jolla, of California California 92093-0374, USA.,Section of Molecular Biology, Division of Biological Sciences, University of California at San Diego, La Jolla, California 92093 USA.,Institute for Theoretical Studies, ETH Zürich, 8092 Zürich, Switzerland
| |
Collapse
|
10
|
Liu M, Feng X, Ding Y, Zhao G, Liu H, Xian M. Metabolic engineering of Escherichia coli to improve recombinant protein production. Appl Microbiol Biotechnol 2015; 99:10367-77. [DOI: 10.1007/s00253-015-6955-9] [Citation(s) in RCA: 22] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/19/2015] [Revised: 08/18/2015] [Accepted: 08/22/2015] [Indexed: 01/13/2023]
|
11
|
Quorum Sensing Is Accompanied by Global Metabolic Changes in the Opportunistic Human Pathogen Pseudomonas aeruginosa. J Bacteriol 2015; 197:2072-82. [PMID: 25868647 DOI: 10.1128/jb.02557-14] [Citation(s) in RCA: 57] [Impact Index Per Article: 6.3] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/15/2014] [Accepted: 04/07/2015] [Indexed: 02/05/2023] Open
Abstract
UNLABELLED Pseudomonas aeruginosa uses N-acyl-homoserine lactone (AHL)-dependent quorum sensing (QS) systems to control the expression of secreted effectors. These effectors can be crucial to the ecological fitness of the bacterium, playing roles in nutrient acquisition, microbial competition, and virulence. In this study, we investigated the metabolic consequences of AHL-dependent QS by monitoring the metabolic profile(s) of a lasI rhlI double mutant (unable to make QS signaling molecules) and its wild-type progenitor as they progressed through the growth curve. Analysis of culture supernatants by (1)H-nuclear magnetic resonance ((1)H-NMR) spectroscopy revealed that at the point where AHL concentrations peaked in the wild type, the metabolic footprints (i.e., extracellular metabolites) of the wild-type and lasI rhlI mutant diverged. Subsequent gas chromatography-mass spectrometry (GC-MS)-based analysis of the intracellular metabolome revealed QS-dependent perturbations in around one-third of all identified metabolites, including altered concentrations of tricarboxylic acid (TCA) cycle intermediates, amino acids, and fatty acids. Further targeted fatty acid methyl ester (FAME) GC-MS-based profiling of the cellular total fatty acid pools revealed that QS leads to changes associated with decreased membrane fluidity and higher chemical stability. However, not all of the changes we observed were necessarily a direct consequence of QS; liquid chromatography (LC)-MS analyses revealed that polyamine levels were elevated in the lasI rhlI mutant, perhaps a response to the absence of QS-dependent adaptations. Our data suggest that QS leads to a global readjustment in central metabolism and provide new insight into the metabolic changes associated with QS during stationary-phase adaptation. IMPORTANCE Quorum sensing (QS) is a transcriptional regulatory mechanism that allows bacteria to coordinate their gene expression profile with the population cell density. The opportunistic human pathogen Pseudomonas aeruginosa uses QS to control the production of secreted virulence factors. In this study, we show that QS elicits a global "metabolic rewiring" in P. aeruginosa. This metabolic rerouting of fluxes is consistent with a variety of drivers, ranging from altered QS-dependent transcription of "metabolic genes" through to the effect(s) of global "metabolic readjustment" as a consequence of QS-dependent exoproduct synthesis, as well as a general stress response, among others. To our knowledge, this is the first study of its kind to assess the global impact of QS on the metabolome.
Collapse
|
12
|
Modelling of the oxygen level response to feed rate perturbations in an industrial scale fermentation process. Process Biochem 2015. [DOI: 10.1016/j.procbio.2015.01.009] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Submit a Manuscript] [Subscribe] [Scholar Register] [Indexed: 11/17/2022]
|
13
|
Bakhtiari N, Mirshahi M, Babaeipour V, Maghsoudi N, Tahzibi A. Down Regulation of ackA-pta Pathway in Escherichia coli BL21 (DE3): A Step Toward Optimized Recombinant Protein Expression System. Jundishapur J Microbiol 2014; 7:e8990. [PMID: 25147677 PMCID: PMC4138692 DOI: 10.5812/jjm.8990] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/29/2012] [Revised: 12/01/2012] [Accepted: 02/19/2013] [Indexed: 01/27/2023] Open
Abstract
Background: One of the most important problems in production of recombinant protein is to attain over-expression of the target gene and high cell density. In such conditions, the secondary metabolites of bacteria become toxic for the medium and cause cells to die. One of these aforementioned metabolites is acetate, which enormously accumulated in the medium, so that both cell and protein yields are affected. Objectives: To overcome this problem, several strategies applied. In this research we used antisense RNA strategy, where the transcription of phosphotransacetylase (PTA) and acetate kinase (ACK), two acetate pathway key enzymes, could be controlled, which led to reduced acetate production. Materials and Methods: In order to achieve this, recombinant plasmid harboring antisense sequences targeting both of pta and ackA was assembled, after transfecting to the cells, its effects on the cell growth and acetate accumulation in the minimal media was assessed and compared with the control, the plasmid without antisense cassette, in presence and absence of IPTG in Escherichia coli BL21 (DE3). Results: It was observed that the mentioned strategy partially affect the growth and amount of excreted acetate in comparison with the control. In addition it was found that high down-regulation of the acetate production pathway reduces the growth rate of E. coli BL21 (DE3). Conclusions: The study principally proved the importance of this strategy in acetate excretion control.
Collapse
Affiliation(s)
- Nahid Bakhtiari
- Biochemistry Department, Faculty of Biological Sciences, Tarbiat Modares University, Tehran, IR Iran
| | - Manouchehr Mirshahi
- Biochemistry Department, Faculty of Biological Sciences, Tarbiat Modares University, Tehran, IR Iran
| | - Valiollah Babaeipour
- Department of Bioscience and Biotechnology, Malek Ashtar University of Technology, Tehran, IR Iran
- Corresponding author: Valiollah Babaeipour, Department of Bioscience and Biotechnology, Malek Ashtar University of Technology, Tehran, IR Iran. Tel: +98-2122974614; Fax: +98-2122974614, E-mail:
| | - Nader Maghsoudi
- Neuroscience Research Center, Shahid Beheshti University of Medical Sciences, Tehran, IR Iran
| | - Abbas Tahzibi
- Food and Drug Organization, Ministry of Health of Iran, Tehran, IR Iran
| |
Collapse
|
14
|
Gottlieb K, Albermann C, Sprenger GA. Improvement of L-phenylalanine production from glycerol by recombinant Escherichia coli strains: the role of extra copies of glpK, glpX, and tktA genes. Microb Cell Fact 2014; 13:96. [PMID: 25012491 PMCID: PMC4227036 DOI: 10.1186/s12934-014-0096-1] [Citation(s) in RCA: 44] [Impact Index Per Article: 4.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/26/2014] [Accepted: 06/24/2014] [Indexed: 11/10/2022] Open
Abstract
Background For the production of L-phenylalanine (L-Phe), two molecules of phosphoenolpyruvate (PEP) and one molecule erythrose-4-phosphate (E4P) are necessary. PEP stems from glycolysis whereas E4P is formed in the pentose phosphate pathway (PPP). Glucose, commonly used for L-Phe production with recombinant E. coli, is taken up via the PEP-dependent phosphotransferase system which delivers glucose-6-phosphate (G6P). G6P enters either glycolysis or the PPP. In contrast, glycerol is phosphorylated by an ATP-dependent glycerol kinase (GlpK) thus saving one PEP. However, two gluconeogenic reactions (fructose-1,6-bisphosphate aldolase, fructose-1,6-bisphosphatase, FBPase) are necessary for growth and provision of E4P. Glycerol has become an important carbon source for biotechnology and reports on production of L-Phe from glycerol are available. However, the influence of FBPase and transketolase reactions on L-Phe production has not been reported. Results L-Phe productivity of parent strain FUS4/pF81 (plasmid-encoded genes for aroF, aroB, aroL, pheA) was compared on glucose and glycerol as C sources. On glucose, a maximal carbon recovery of 0.19 mM CPhe/CGlucose and a maximal space-time-yield (STY) of 0.13 g l−1 h−1 was found. With glycerol, the maximal carbon recovery was nearly the same (0.18 mM CPhe/CGlycerol), but the maximal STY was higher (0.21 g l−1 h−1). We raised the chromosomal gene copy number of the genes glpK (encoding glycerol kinase), tktA (encoding transketolase), and glpX (encoding fructose-1,6-bisphosphatase) individually. Overexpression of glpK (or its feedback-resistant variant, glpKG232D) had little effect on growth rate; L-Phe production was about 30% lower than in FUS4/pF81. Whereas the overexpression of either glpX or tktA had minor effects on productivity (0.20 mM CPhe/CGlycerol; 0.25 g l−1 h−1 and 0.21 mM CPhe/CGlycerol; 0.23 g l−1 h−1, respectively), the combination of extra genes of glpX and tktA together led to an increase in maximal STY of about 80% (0.37 g l−1 h−1) and a carbon recovery of 0.26 mM CPhe/CGlycerol. Conclusions Enhancing the gene copy numbers for glpX and tktA increased L-Phe productivity from glycerol without affecting growth rate. Engineering of glycerol metabolism towards L-Phe production in E. coli has to balance the pathways of gluconeogenesis, glycolysis, and PPP to improve the supply of the precursors, PEP and E4P.
Collapse
|
15
|
Johnsson O, Andersson J, Lidén G, Johnsson C, Hägglund T. Feed rate control in fed-batch fermentations based on frequency content analysis. Biotechnol Prog 2013; 29:817-24. [DOI: 10.1002/btpr.1727] [Citation(s) in RCA: 10] [Impact Index Per Article: 0.9] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/11/2013] [Revised: 02/27/2013] [Indexed: 11/06/2022]
Affiliation(s)
- Ola Johnsson
- Dept. of Automatic Control; Faculty of Engineering LTH; Lund University; Sweden
| | | | - Gunnar Lidén
- Dept. of Chemical Engineering; Faculty of Engineering LTH; Lund University; Sweden
| | - Charlotta Johnsson
- Dept. of Automatic Control; Faculty of Engineering LTH; Lund University; Sweden
| | - Tore Hägglund
- Dept. of Automatic Control; Faculty of Engineering LTH; Lund University; Sweden
| |
Collapse
|
16
|
Ruiz JA, de Almeida A, Godoy MS, Mezzina MP, Bidart GN, Méndez BS, Pettinari MJ, Nikel PI. Escherichia coli redox mutants as microbial cell factories for the synthesis of reduced biochemicals. Comput Struct Biotechnol J 2013; 3:e201210019. [PMID: 24688679 PMCID: PMC3962086 DOI: 10.5936/csbj.201210019] [Citation(s) in RCA: 24] [Impact Index Per Article: 2.2] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/19/2012] [Revised: 12/09/2012] [Accepted: 12/13/2012] [Indexed: 11/23/2022] Open
Abstract
Bioprocesses conducted under conditions with restricted O2 supply are increasingly exploited for the synthesis of reduced biochemicals using different biocatalysts. The model facultative aerobe Escherichia coli, the microbial cell factory par excellence, has elaborate sensing and signal transduction mechanisms that respond to the availability of electron acceptors and alternative carbon sources in the surrounding environment. In particular, the ArcBA and CreBC two-component signal transduction systems are largely responsible for the metabolic regulation of redox control in response to O2 availability and carbon source utilization, respectively. Significant advances in the understanding of the biochemical, genetic, and physiological duties of these regulatory systems have been achieved in recent years. This situation allowed to rationally-design novel engineering approaches that ensure optimal carbon and energy flows within central metabolism, as well as to manipulate redox homeostasis, in order to optimize the production of industrially-relevant metabolites. In particular, metabolic flux analysis provided new clues to understand the metabolic regulation mediated by the ArcBA and CreBC systems. Genetic manipulation of these regulators proved useful for designing microbial cells factories tailored for the synthesis of reduced biochemicals with added value, such as poly(3-hydroxybutyrate), under conditions with restricted O2 supply. This network-wide strategy is in contrast with traditional metabolic engineering approaches, that entail direct modification of the pathway(s) at stake, and opens new avenues for the targeted modulation of central catabolic pathways at the transcriptional level.
Collapse
Affiliation(s)
- Jimena A Ruiz
- Departamento de Química Biológica (IQUIBICEN-CONICET), Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Buenos Aires, Argentina ; Instituto de Biociencias Agrícolas y Ambientales (INBA-CONICET), Facultad de Agronomía, Universidad de Buenos Aires, Buenos Aires, Argentina
| | - Alejandra de Almeida
- Departamento de Química Biológica (IQUIBICEN-CONICET), Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Buenos Aires, Argentina
| | - Manuel S Godoy
- Departamento de Química Biológica (IQUIBICEN-CONICET), Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Buenos Aires, Argentina
| | - Mariela P Mezzina
- Departamento de Química Biológica (IQUIBICEN-CONICET), Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Buenos Aires, Argentina
| | - Gonzalo N Bidart
- Instituto de Investigaciones Biotecnológicas "Dr. Rodolfo A. Ugalde" (IIB-CONICET), Universidad Nacional de San Martín, San Martín, Buenos Aires, Argentina
| | - Beatriz S Méndez
- Departamento de Química Biológica (IQUIBICEN-CONICET), Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Buenos Aires, Argentina
| | - M Julia Pettinari
- Departamento de Química Biológica (IQUIBICEN-CONICET), Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Buenos Aires, Argentina
| | - Pablo I Nikel
- Departamento de Química Biológica (IQUIBICEN-CONICET), Facultad de Ciencias Exactas y Naturales, Universidad de Buenos Aires, Buenos Aires, Argentina ; Instituto de Investigaciones Biotecnológicas "Dr. Rodolfo A. Ugalde" (IIB-CONICET), Universidad Nacional de San Martín, San Martín, Buenos Aires, Argentina
| |
Collapse
|
17
|
Liu D, Chen Y, Li A, Zhao T, Zhou T, Li B, Xie J, Chen X, Bai J, Hu Y, He B, Ying H. Adaptation of glycolysis and growth to acetate in Sporolactobacillus sp. Y2-8. Appl Biochem Biotechnol 2012; 168:455-63. [PMID: 22798166 DOI: 10.1007/s12010-012-9789-2] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/26/2011] [Accepted: 07/03/2012] [Indexed: 10/28/2022]
Abstract
Exogenous addition of a low concentration of acetate (2 g/L sodium acetate) effectively decreased acetic acid excretion and lowered the ATP content in Sporolactobacillus sp. Y2-8 without any growth defect although the acetate could not be utilized at an initial glucose concentration of 150 g/L. This induced an enhanced glycolytic flux with increased specific activities of hexokinase and phosphofructokinase, probably to compensate for the lowered efficiency of ATP production. However, with increasing concentrations (5 g/L sodium acetate), acetate was utilized first before being produced again, causing a growth lag at the transition. Glucose consumption was also reduced at high acetate concentrations, resulting in decreased D-lactic acid production. These results demonstrate that acetate plays a significant role in regulating glycolysis and growth of Sporolactobacillus.
Collapse
Affiliation(s)
- Dong Liu
- State Key Laboratory of Materials-Oriented Chemical Engineering, College of Life Science and Pharmaceutical Engineering, Nanjing University of Technology, Nanjing 210009, Peoples' Republic of China
| | | | | | | | | | | | | | | | | | | | | | | |
Collapse
|
18
|
Carlson RP, Oshota OJ, Taffs RL. Systems analysis of microbial adaptations to simultaneous stresses. Subcell Biochem 2012; 64:139-57. [PMID: 23080249 DOI: 10.1007/978-94-007-5055-5_7] [Citation(s) in RCA: 5] [Impact Index Per Article: 0.4] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/04/2022]
Abstract
Microbes live in multi-factorial environments and have evolved under a variety of concurrent stresses including resource scarcity. Their metabolic organization is a reflection of their evolutionary histories and, in spite of decades of research, there is still a need for improved theoretical tools to explain fundamental aspects of microbial physiology. Using ecological and economic concepts, this chapter explores a resource-ratio based theory to elucidate microbial strategies for extracting and channeling mass and energy. The theory assumes cellular fitness is maximized by allocating scarce resources in appropriate proportions to multiple stress responses. Presented case studies deconstruct metabolic networks into a complete set of minimal biochemical pathways known as elementary flux modes. An economic analysis of the elementary flux modes tabulates enzyme atomic synthesis requirements from amino acid sequences and pathway operating costs from catabolic efficiencies, permitting characterization of inherent tradeoffs between resource investment and phenotype. A set of elementary flux modes with competitive tradeoffs properties can be mathematically projected onto experimental fluxomics datasets to decompose measured phenotypes into metabolic adaptations, interpreted as cellular responses proportional to the experienced culturing stresses. The resource-ratio based method describes the experimental phenotypes with greater accuracy than other contemporary approaches and further analysis suggests the results are both statistically and biologically significant. The insight into metabolic network design principles including tradeoffs associated with concurrent stress adaptation provides a foundation for interpreting physiology as well as for rational control and engineering of medically, environmentally, and industrially relevant microbes.
Collapse
Affiliation(s)
- Ross P Carlson
- Chemical and Biological Engineering Department, Center for Biofilm Engineering, Montana State University, Bozeman, MT, 59717-3920, USA,
| | | | | |
Collapse
|
19
|
Valgepea K, Adamberg K, Nahku R, Lahtvee PJ, Arike L, Vilu R. Systems biology approach reveals that overflow metabolism of acetate in Escherichia coli is triggered by carbon catabolite repression of acetyl-CoA synthetase. BMC SYSTEMS BIOLOGY 2010; 4:166. [PMID: 21122111 PMCID: PMC3014970 DOI: 10.1186/1752-0509-4-166] [Citation(s) in RCA: 150] [Impact Index Per Article: 10.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 06/16/2010] [Accepted: 12/01/2010] [Indexed: 11/20/2022]
Abstract
Background The biotechnology industry has extensively exploited Escherichia coli for producing recombinant proteins, biofuels etc. However, high growth rate aerobic E. coli cultivations are accompanied by acetate excretion i.e. overflow metabolism which is harmful as it inhibits growth, diverts valuable carbon from biomass formation and is detrimental for target product synthesis. Although overflow metabolism has been studied for decades, its regulation mechanisms still remain unclear. Results In the current work, growth rate dependent acetate overflow metabolism of E. coli was continuously monitored using advanced continuous cultivation methods (A-stat and D-stat). The first step in acetate overflow switch (at μ = 0.27 ± 0.02 h-1) is the repression of acetyl-CoA synthethase (Acs) activity triggered by carbon catabolite repression resulting in decreased assimilation of acetate produced by phosphotransacetylase (Pta), and disruption of the PTA-ACS node. This was indicated by acetate synthesis pathways PTA-ACKA and POXB component expression down-regulation before the overflow switch at μ = 0.27 ± 0.02 h-1 with concurrent 5-fold stronger repression of acetate-consuming Acs. This in turn suggests insufficient Acs activity for consuming all the acetate produced by Pta, leading to disruption of the acetate cycling process in PTA-ACS node where constant acetyl phosphate or acetate regeneration is essential for E. coli chemotaxis, proteolysis, pathogenesis etc. regulation. In addition, two-substrate A-stat and D-stat experiments showed that acetate consumption capability of E. coli decreased drastically, just as Acs expression, before the start of overflow metabolism. The second step in overflow switch is the sharp decline in cAMP production at μ = 0.45 h-1 leading to total Acs inhibition and fast accumulation of acetate. Conclusion This study is an example of how a systems biology approach allowed to propose a new regulation mechanism for overflow metabolism in E. coli shown by proteomic, transcriptomic and metabolomic levels coupled to two-phase acetate accumulation: acetate overflow metabolism in E. coli is triggered by Acs down-regulation resulting in decreased assimilation of acetic acid produced by Pta, and disruption of the PTA-ACS node.
Collapse
Affiliation(s)
- Kaspar Valgepea
- Tallinn University of Technology, Department of Chemistry, Akadeemia tee 15, 12618 Tallinn, Estonia
| | | | | | | | | | | |
Collapse
|
20
|
Jian J, Zhang SQ, Shi ZY, Wang W, Chen GQ, Wu Q. Production of polyhydroxyalkanoates by Escherichia coli mutants with defected mixed acid fermentation pathways. Appl Microbiol Biotechnol 2010; 87:2247-56. [PMID: 20535465 DOI: 10.1007/s00253-010-2706-0] [Citation(s) in RCA: 35] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/04/2010] [Revised: 05/27/2010] [Accepted: 05/28/2010] [Indexed: 10/19/2022]
Abstract
A series of Escherichia coli BW25113 mutants with reduced mixed acid fermentation were constructed. Genes ackA-pta, poxB, ldhA, adhE, and pflB encoding acetate kinase, phosphate acetyltransferase, pyruvate oxidase, D: -lactate dehydrogenase, acetaldehyde dehydrogenase, and pyruvate formate-lyase, respectively, were deleted successively. When grown under microaerobic condition, the mutants reduced approximately 90% acetate excretion after the deletion of genes ackA-pta and poxB. Production of lactate, ethanol, and formate was also significantly reduced after the deletion of genes ldhA, adhE, and pflB, respectively. The accumulation of biomass and poly(3-hydroxybutyrate) (PHB) were significantly enhanced after deleting the mixed acid fermentation. E. coli mutant BWapld with deletions of ackA-pta, poxB, ldhA, and adhE produced twice the cell dry weight (CDW) and 3.5 times of PHB compared with its wild-type under microaerobic conditions. E. coli mutant BWapl with deletions of ackA-pta, poxB, and ldhA also achieved nearly twice CDW and three times of PHB content in comparison to the wild-type during 48 h static cultivation. Production of poly(3-hydroxybutyrate-co-3-hydroxyvalerate) [P(3HB-co-3HV)] was observed in the mutants under static cultivation. E. coli mutant BWapld could produce approximately 50 wt.% P(3HB-co-3HV) consisting of 5 mol% of 3-hydroxyvalerate (3HV) under aerobic conditions, when the seed culture was inoculated at an appropriate time. When ackA-pta, poxB, ldhA, adhE, and pflB were deleted, E. coli mutant BWapldf accumulated over 70 wt.% P(3HB-co-3HV) consisting of 8 mol% 3HV under aerobic conditions.
Collapse
Affiliation(s)
- Jia Jian
- Department of Biology, Tsinghua University, Beijing, China
| | | | | | | | | | | |
Collapse
|
21
|
Wolfe AJ. Physiologically relevant small phosphodonors link metabolism to signal transduction. Curr Opin Microbiol 2010; 13:204-9. [PMID: 20117041 PMCID: PMC2847653 DOI: 10.1016/j.mib.2010.01.002] [Citation(s) in RCA: 111] [Impact Index Per Article: 7.9] [Reference Citation Analysis] [Abstract] [MESH Headings] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/30/2009] [Revised: 01/04/2010] [Accepted: 01/07/2010] [Indexed: 11/17/2022]
Abstract
Recent reports support the long-standing hypothesis that acetyl phosphate, a physiologically relevant small molecule, can serve as a phosphoryl donor to a subset of two-component response regulators that regulate diverse cellular processes. Since acetyl phosphate is a central metabolite, this ability would link nutritional status to global signaling. This review will first introduce acetyl phosphate and its pathway. It will then summarize the most compelling evidence supporting the hypothesis and list predicted properties of an acetyl phosphate-sensitive pathway. Next, it will describe emerging evidence that acetyl phosphate and/or its pathway can influence diverse cellular processes across a broad spectrum of bacteria. Finally, the review will explore the possibility that other metabolites can function in a capacity similar to acetyl phosphate.
Collapse
Affiliation(s)
- Alan J Wolfe
- Department of Microbiology and Immunology, Loyola University Chicago, Stritch School of Medicine, 2160 S. First Ave., Bldg. 105, Maywood, IL 60153, USA
| |
Collapse
|
22
|
Toward systematic metabolic engineering based on the analysis of metabolic regulation by the integration of different levels of information. Biochem Eng J 2009. [DOI: 10.1016/j.bej.2009.06.006] [Citation(s) in RCA: 32] [Impact Index Per Article: 2.1] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/19/2022]
|
23
|
Lüders S, Fallet C, Franco-Lara E. Proteome analysis of the Escherichia coli heat shock response under steady-state conditions. Proteome Sci 2009; 7:36. [PMID: 19772559 PMCID: PMC2758844 DOI: 10.1186/1477-5956-7-36] [Citation(s) in RCA: 43] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/27/2009] [Accepted: 09/21/2009] [Indexed: 11/17/2022] Open
Abstract
In this study a proteomic approach was used to investigate the steady-state response of Escherichia coli to temperature up-shifts in a cascade of two continuously operated bioreactors. The first reactor served as cell source with optimal settings for microbial growth, while in the second chemostat the cells were exposed to elevated temperatures. By using this reactor configuration, which has not been reported to be used for the study of bacterial stress responses so far, it is possible to study temperature stress under well-defined, steady-state conditions. Specifically the effect on the cellular adaption to temperature stress using two-dimensional gel electrophoresis was examined and compared at the cultivation temperatures of 37 degrees C and 47.5 degrees C. As expected, the steady-state study with the double bioreactor configuration delivered a different protein spectrum compared to that obtained with standard batch experiments in shaking flasks and bioreactors. Setting a high cut-out spot-to-spot size ratio of 5, proteins involved in defence against oxygen stress, functional cell envelope proteins, chaperones and proteins involved in protein biosynthesis, the energy metabolism and the amino acid biosynthesis were found to be differently expressed at high cultivation temperatures. The results demonstrate the complexity of the stress response in a steady-state culture not reported elsewhere to date.
Collapse
Affiliation(s)
- Svenja Lüders
- Institute of Biochemical Engineering, Technische Universität Braunschweig, Gausstrasse 17, 38106 Braunschweig, Germany
| | - Claas Fallet
- Institute of Biochemical Engineering, Technische Universität Braunschweig, Gausstrasse 17, 38106 Braunschweig, Germany
| | - Ezequiel Franco-Lara
- Institute of Biochemical Engineering, Technische Universität Braunschweig, Gausstrasse 17, 38106 Braunschweig, Germany
| |
Collapse
|
24
|
Sanchez S, Demain AL. Metabolic regulation and overproduction of primary metabolites. Microb Biotechnol 2008; 1:283-319. [PMID: 21261849 PMCID: PMC3815394 DOI: 10.1111/j.1751-7915.2007.00015.x] [Citation(s) in RCA: 75] [Impact Index Per Article: 4.7] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/27/2007] [Revised: 10/04/2007] [Accepted: 10/23/2007] [Indexed: 12/01/2022] Open
Abstract
Overproduction of microbial metabolites is related to developmental phases of microorganisms. Inducers, effectors, inhibitors and various signal molecules play a role in different types of overproduction. Biosynthesis of enzymes catalysing metabolic reactions in microbial cells is controlled by well-known positive and negative mechanisms, e.g. induction, nutritional regulation (carbon or nitrogen source regulation), feedback regulation, etc. The microbial production of primary metabolites contributes significantly to the quality of life. Fermentative production of these compounds is still an important goal of modern biotechnology. Through fermentation, microorganisms growing on inexpensive carbon and nitrogen sources produce valuable products such as amino acids, nucleotides, organic acids and vitamins which can be added to food to enhance its flavour, or increase its nutritive values. The contribution of microorganisms goes well beyond the food and health industries with the renewed interest in solvent fermentations. Microorganisms have the potential to provide many petroleum-derived products as well as the ethanol necessary for liquid fuel. Additional applications of primary metabolites lie in their impact as precursors of many pharmaceutical compounds. The roles of primary metabolites and the microbes which produce them will certainly increase in importance as time goes on. In the early years of fermentation processes, development of producing strains initially depended on classical strain breeding involving repeated random mutations, each followed by screening or selection. More recently, methods of molecular genetics have been used for the overproduction of primary metabolic products. The development of modern tools of molecular biology enabled more rational approaches for strain improvement. Techniques of transcriptome, proteome and metabolome analysis, as well as metabolic flux analysis. have recently been introduced in order to identify new and important target genes and to quantify metabolic activities necessary for further strain improvement.
Collapse
Affiliation(s)
- Sergio Sanchez
- Departamento de Biologia Molecular y Biotecnologia, Instituto de Investigaciones Biomedicas, Universidad Nacional Autonoma de Mexico (UNAM), Mexico City, Mexico
| | - Arnold L. Demain
- Research Institute for Scientists Emeriti (RISE), Drew University, Madison, NJ 07940, USA
| |
Collapse
|
25
|
Tippkötter N, Deterding A, Ulber R. Determination of Acetic Acid in Fermentation Broth by Gas-Diffusion Technique. Eng Life Sci 2008. [DOI: 10.1002/elsc.200820227] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.1] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022] Open
|
26
|
Signal integration by the two-component signal transduction response regulator CpxR. J Bacteriol 2008; 190:2314-22. [PMID: 18223085 DOI: 10.1128/jb.01906-07] [Citation(s) in RCA: 96] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/20/2022] Open
Abstract
The CpxAR two-component signal transduction system in Escherichia coli and other pathogens senses diverse envelope stresses and promotes the transcription of a variety of genes that remedy these stresses. An important member of the CpxAR regulon is cpxP. The CpxA-dependent transcription of cpxP has been linked to stresses such as misfolded proteins and alkaline pH. It also has been proposed that acetyl phosphate, the intermediate of the phosphotransacetylase (Pta)-acetate kinase (AckA) pathway, can activate the transcription of cpxP in a CpxA-independent manner by donating its phosphoryl group to CpxR. We tested this hypothesis by measuring the transcription of cpxP using mutants with mutations in the CpxAR pathway, mutants with mutations in the Pta-AckA pathway, and mutants with a combination of both types of mutations. From this epistasis analysis, we learned that CpxR integrates diverse stimuli. The stimuli that originate in the envelope depend on CpxA, while those associated with growth and central metabolism depend on the Pta-AckA pathway. While CpxR could receive a phosphoryl group from acetyl phosphate, this global signal was not the primary trigger for CpxR activation associated with the Pta-AckA pathway. On the strength of these results, we contend that the interactions between central metabolism and signal transduction can be quite complex and that successful investigations of such interactions must include a complete epistatic analysis.
Collapse
|
27
|
Spencer CC, Bertrand M, Travisano M, Doebeli M. Adaptive diversification in genes that regulate resource use in Escherichia coli. PLoS Genet 2007; 3:e15. [PMID: 17238290 PMCID: PMC1779306 DOI: 10.1371/journal.pgen.0030015] [Citation(s) in RCA: 50] [Impact Index Per Article: 2.9] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/02/2006] [Accepted: 12/08/2006] [Indexed: 11/18/2022] Open
Abstract
While there has been much recent focus on the ecological causes of adaptive diversification, we know less about the genetic nature of the trade-offs in resource use that create and maintain stable, diversified ecotypes. Here we show how a regulatory genetic change can contribute to sympatric diversification caused by differential resource use and maintained by negative frequency-dependent selection in Escherichia coli. During adaptation to sequential use of glucose and acetate, these bacteria differentiate into two ecotypes that differ in their growth profiles. The "slow-switcher" exhibits a long lag when switching to growth on acetate after depletion of glucose, whereas the "fast-switcher" exhibits a short switching lag. We show that the short switching time in the fast-switcher is associated with a failure to down-regulate potentially costly acetate metabolism during growth on glucose. While growing on glucose, the fast-switcher expresses malate synthase A (aceB), a critical gene for acetate metabolism that fails to be properly down-regulated because of a transposon insertion in one of its regulators. Swapping the mutant regulatory allele with the ancestral allele indicated that the transposon is in part responsible for the observed differentiation between ecological types. Our results provide a rare example of a mechanistic integration of diversifying processes at the genetic, physiological, and ecological levels.
Collapse
Affiliation(s)
- Christine C Spencer
- Department of Zoology, University of British Columbia, Vancouver, British Columbia, Canada.
| | | | | | | |
Collapse
|
28
|
Kern A, Tilley E, Hunter IS, Legisa M, Glieder A. Engineering primary metabolic pathways of industrial micro-organisms. J Biotechnol 2007; 129:6-29. [PMID: 17196287 DOI: 10.1016/j.jbiotec.2006.11.021] [Citation(s) in RCA: 81] [Impact Index Per Article: 4.8] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/11/2005] [Revised: 07/04/2006] [Accepted: 08/18/2006] [Indexed: 01/01/2023]
Abstract
Metabolic engineering is a powerful tool for the optimisation and the introduction of new cellular processes. This is mostly done by genetic engineering. Since the introduction of this multidisciplinary approach, the success stories keep accumulating. The primary metabolism of industrial micro-organisms has been studied for long time and most biochemical pathways and reaction networks have been elucidated. This large pool of biochemical information, together with data from proteomics, metabolomics and genomics underpins the strategies for design of experiments and choice of targets for manipulation by metabolic engineers. These targets are often located in the primary metabolic pathways, such as glycolysis, pentose phosphate pathway, the TCA cycle and amino acid biosynthesis and mostly at major branch points within these pathways. This paper describes approaches taken for metabolic engineering of these pathways in bacteria, yeast and filamentous fungi.
Collapse
Affiliation(s)
- Alexander Kern
- Institute for Molecular Biotechnology, TU Graz, Petersgasse 14, 8010 Graz, Austria
| | | | | | | | | |
Collapse
|
29
|
Veit A, Polen T, Wendisch VF. Global gene expression analysis of glucose overflow metabolism in Escherichia coli and reduction of aerobic acetate formation. Appl Microbiol Biotechnol 2006; 74:406-21. [PMID: 17273855 DOI: 10.1007/s00253-006-0680-3] [Citation(s) in RCA: 74] [Impact Index Per Article: 4.1] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/17/2006] [Revised: 09/13/2006] [Accepted: 09/13/2006] [Indexed: 11/25/2022]
Abstract
During aerobic growth on glucose, Escherichia coli produces acetate in the so-called overflow metabolism. DNA microarray analysis was used to determine the global gene expression patterns of chemostat cultivations of E. coli MG1655 that were characterized by different acetate formation rates during aerobic growth on glucose. A correlation analysis identified that expression of ten genes (sdhCDAB, sucB, sucC, acnB, lpdA, fumC and mdh) encoding the TCA cycle enzymes succinate dehydrogenase, alpha-ketoglutarate dehydrogenase, succinyl-CoA synthetase, aconitase, fumarase and malate dehydrogenase, respectively, and of the acs-yjcH-actP operon for acetate utilization correlated negatively with acetate formation. Relieving transcriptional control of the sdhCDAB-b0725-sucABCD operon by chromosomal promoter exchange mutagenesis yielded a strain with increased specific activities of the TCA cycle enzymes succinate dehydrogenase, alpha-ketoglutarate dehydrogenase and succinyl-CoA synthetase, which are encoded by this operon. The resulting strain produced less acetate and directed more carbon towards carbon dioxide formation than the parent strain MG1655 while maintaining high growth and glucose consumption rates.
Collapse
Affiliation(s)
- Andrea Veit
- Institute of Biotechnology 1, Research Center Juelich, 52428 Juelich, Germany
| | | | | |
Collapse
|
30
|
Vemuri GN, Eiteman MA, Altman E. Increased recombinant protein production inEscherichia coli strains with overexpressed water-forming NADH oxidase and a deleted ArcA regulatory protein. Biotechnol Bioeng 2006; 94:538-42. [PMID: 16496400 DOI: 10.1002/bit.20853] [Citation(s) in RCA: 54] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/12/2022]
Abstract
Glycolytic flux is increased and acetate production is reduced in Escherichia coli by the expression of heterologous NADH oxidase (NOX) from Streptococcus pneumoniae coupled with the deletion of the arcA gene, which encodes the ArcA regulatory protein. In this study, we examined the overproduction of a model recombinant protein in strains of E. coli expressing NOX with or without an arcA mutation. The presence of NOX or the absence of ArcA reduced acetate by about 50% and increased beta-galactosidase production by 10-20%. The presence of NOX in the arcA strain eliminated acetate production entirely in batch fermentations and resulted in a 120% increase in beta-galactosidase production.
Collapse
Affiliation(s)
- G N Vemuri
- Department of Biological and Agricultural Engineering, Center for Molecular BioEngineering, University of Georgia, Athens, Georgia 30602, USA
| | | | | |
Collapse
|
31
|
El-Mansi M, Cozzone AJ, Shiloach J, Eikmanns BJ. Control of carbon flux through enzymes of central and intermediary metabolism during growth of Escherichia coli on acetate. Curr Opin Microbiol 2006; 9:173-9. [PMID: 16530464 DOI: 10.1016/j.mib.2006.02.002] [Citation(s) in RCA: 62] [Impact Index Per Article: 3.4] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/05/2005] [Accepted: 02/21/2006] [Indexed: 11/17/2022]
Abstract
During aerobic growth of Escherichia coli on acetate, the component parts of the 'acetate switch' are turned-on as a consequence of direct competition, on the one hand, between phosphotransacetylase (PTA) and alpha-ketoglutarate dehydrogenase (alpha-KGDH) for their common co-factor free-CoA (HS-CoA) and, on the other hand, between isocitrate lyase (ICL) and isocitrate dehydrogenase (ICDH) for their common substrate isocitrate. Flux analysis revealed that competitions at both junctions in central metabolism are resolved in a precise way, so that the fraction of HS-CoA flux processed through PTA for biosynthesis relative to that processed through alpha-KGDH for energy generation, matches that observed for isocitrate flux through ICL relative to ICDH at the junction of isocitrate. Whereas the mechanism involved in the partition of carbon flux at the level of HS-CoA in central metabolism remains to be unravelled, the competition at the junction of isocitrate is resolved by the reversible phosphorylation/inactivation of ICDH and the operation of the glyoxylate bypass, the expression of which is subject to regulation at the transcriptional and translational levels as well as being dependent on growth rate.
Collapse
Affiliation(s)
- Mansi El-Mansi
- School of Life Sciences, Faculty of Health and Life Sciences, Napier University, Edinburgh, EH10 5DT, Scotland, UK.
| | | | | | | |
Collapse
|
32
|
El-Mansi M. Free CoA-mediated regulation of intermediary and central metabolism: an hypothesis which accounts for the excretion of alpha-ketoglutarate during aerobic growth of Escherichia coli on acetate. Res Microbiol 2005; 156:874-9. [PMID: 16171983 DOI: 10.1016/j.resmic.2005.04.008] [Citation(s) in RCA: 15] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/11/2005] [Revised: 04/12/2005] [Accepted: 04/14/2005] [Indexed: 10/25/2022]
Abstract
During growth of Escherichia coli on acetate, phosphotransacetylase and alpha-ketoglutarate dehydrogenase are in direct competition for their common co-factor, HS-CoA. Such competition is resolved in favour of phosphotransacetylase, thus rendering alpha-ketoglutarate dehydrogenase rate-limiting (controlling) and, in turn, creating a bottleneck at the level of alpha-ketoglutarate in the Krebs cycle. Accumulation of alpha-ketoglutarate is then balanced by its excretion. Addition of pyruvate, glucose or any glycolytic intermediate to acetate-grown culture relieves such a bottleneck by reversing carbon flow through phosphotransacetylase to give acetyl phosphate and much-needed HS-CoA. The urgent need for HS-CoA by the primordial organism might therefore have provided the selective pressure that led to the co-evolution of phosphotransacetylase and the two-malate synthase isoenzymes.
Collapse
Affiliation(s)
- Mansi El-Mansi
- School of Life Sciences, Faculty of Health and Life Sciences, Napier University, Edinburgh, EH10 5DT, Scotland, UK
| |
Collapse
|
33
|
Abstract
To succeed, many cells must alternate between life-styles that permit rapid growth in the presence of abundant nutrients and ones that enhance survival in the absence of those nutrients. One such change in life-style, the "acetate switch," occurs as cells deplete their environment of acetate-producing carbon sources and begin to rely on their ability to scavenge for acetate. This review explains why, when, and how cells excrete or dissimilate acetate. The central components of the "switch" (phosphotransacetylase [PTA], acetate kinase [ACK], and AMP-forming acetyl coenzyme A synthetase [AMP-ACS]) and the behavior of cells that lack these components are introduced. Acetyl phosphate (acetyl approximately P), the high-energy intermediate of acetate dissimilation, is discussed, and conditions that influence its intracellular concentration are described. Evidence is provided that acetyl approximately P influences cellular processes from organelle biogenesis to cell cycle regulation and from biofilm development to pathogenesis. The merits of each mechanism proposed to explain the interaction of acetyl approximately P with two-component signal transduction pathways are addressed. A short list of enzymes that generate acetyl approximately P by PTA-ACKA-independent mechanisms is introduced and discussed briefly. Attention is then directed to the mechanisms used by cells to "flip the switch," the induction and activation of the acetate-scavenging AMP-ACS. First, evidence is presented that nucleoid proteins orchestrate a progression of distinct nucleoprotein complexes to ensure proper transcription of its gene. Next, the way in which cells regulate AMP-ACS activity through reversible acetylation is described. Finally, the "acetate switch" as it exists in selected eubacteria, archaea, and eukaryotes, including humans, is described.
Collapse
Affiliation(s)
- Alan J Wolfe
- Department of Microbiology and Immunology, Stritch School of Medicine, Loyola University Chicago, Maywood, IL 60153, USA.
| |
Collapse
|
34
|
Calhoun KA, Swartz JR. Energizing cell-free protein synthesis with glucose metabolism. Biotechnol Bioeng 2005; 90:606-13. [PMID: 15830344 DOI: 10.1002/bit.20449] [Citation(s) in RCA: 118] [Impact Index Per Article: 6.2] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/06/2022]
Abstract
In traditional cell-free protein synthesis reactions, the energy source (typically phosphoenolpyruvate (PEP) or creatine phosphate) is the most expensive substrate. However, for most biotechnology applications glucose is the preferred commercial substrate. Previous attempts to use glucose in cell-free protein synthesis reactions have been unsuccessful. We have now developed a cell-free protein synthesis reaction where PEP is replaced by either glucose or glucose-6-phosphate (G6P) as the energy source, thus allowing these reactions to compete more effectively with in vivo protein production technologies. We demonstrate high protein yields in a simple batch-format reaction through pH control and alleviation of phosphate limitation. G6P reactions can produce high protein levels ( approximately 700 microg/mL of chloramphenical acetyl transferase (CAT)) when pH is stabilized through replacement of the HEPES buffer with Bis-Tris. Protein synthesis with glucose as an energy source is also possible, and CAT yields of approximately 550 mug/mL are seen when both 10 mM phosphate is added to alleviate phosphate limitations and the Bis-Tris buffer concentration is increased to stabilize pH. By following radioactivity from [U-(14)C]-glucose, we find that glucose is primarily metabolized to the anaerobic products, acetate and lactate. The ability to use glucose as an energy source in cell-free reactions is important not only for inexpensive ATP generation during protein synthesis, but also as an example of how complex biological systems can be understood and exploited through cell-free biology.
Collapse
Affiliation(s)
- Kara A Calhoun
- Department of Chemical Engineering, Stanford University, Stanford, California 94305-5025, USA
| | | |
Collapse
|