Assessment of respiratory hypersensitivity in guinea-pigs sensitized to diphenylmethane-4,4'-diisocyanate (MDI) and challenged with MDI, acetylcholine or MDI-albumin conjugate

Evaluation of animal toxicity studies with diisocyanates regarding presence of thresholds for induction and elicitation of respiratory allergy by quantitative weight of evidence

Animal toxicity studies on diisocyanates were evaluated using quantitative weight of evidence (QWoE) to test the hypothesis that the dose-response curve shows a threshold for the induction and/or elicitation of respiratory sensitization. A literature search identified 59 references that included at least two concentration groups of the diisocyanate and a vehicle-exposed concurrent control in the study design. These studies were subjected to a QWoE-assessment applying scoring criteria for quality and relevance/strength of effects relevant to the selected endpoint of respiratory sensitization. Overall, the studies assessing dose/concentration-response for diisocyanates with the endpoint, respiratory sensitization, were heterogenous regarding study design, animal models used, endpoints assessed, and quality. Only a limited number of the studies subjected to the QWoE-assessment allowed drawing conclusions about possible thresholds for respiratory sensitization. Highest quality and relevance/strength of effects scores were obtained by a series of studies specifically designed to investigate a potential threshold for elicitation of respiratory sensitization in the Brown Norway (BN) rat. These studies applied an elaborate study design to optimize induction of respiratory sensitization and reduce interference by respiratory tract irritation. In summary, the available studies provided moderate to good support for the existence of a threshold for elicitation and limited to moderate support for a threshold regarding induction of respiratory allergy by diisocyanates in experimental animals. However, a quantitative extrapolation of threshold values established in rodents to humans remains complex.

Azodicarbonamide (ADCA): A reconsideration of classification as a respiratory sensitiser

Azodicarbonamide (ADCA) is widely used by industry in the manufacture of a variety of products. ADCA has been classified as a respiratory allergen, and the purpose of this article was to consider whether this classification is appropriate based upon the available data. Here both clinical experience and relevant experimental data have been reviewed. Although there have been reports of an association between workplace exposure to ADCA and symptoms of respiratory allergy and occupational asthma, the evidence is less than persuasive, with in many instances a lack of properly controlled and executed diagnostic procedures. In addition, ADCA fails to elicit positive responses in mouse and guinea pig predictive tests for skin sensitisation; a lack of activity that is regarded as being inconsistent with respect to respiratory sensitising potential. Collectively, the data reviewed here do not provide an adequate basis for the classification of ADCA as a respiratory allergen.

Residual Isocyanates in Medical Devices and Products: A Qualitative and Quantitative Assessment

We conducted a pilot qualitative and quantitative assessment of residual isocyanates and their potential initial exposures in neonates, as little is known about their contact effect. After a neonatal intensive care unit (NICU) stockroom inventory, polyurethane (PU) and PU foam (PUF) devices and products were qualitatively evaluated for residual isocyanates using Surface SWYPE™. Those containing isocyanates were quantitatively tested for methylene diphenyl diisocyanate (MDI) species, using UPLC-UV-MS/MS method. Ten of 37 products and devices tested, indicated both free and bound residual surface isocyanates; PU/PUF pieces contained aromatic isocyanates; one product contained aliphatic isocyanates. Overall, quantified mean MDI concentrations were low (4,4'-MDI = 0.52 to 140.1 pg/mg) and (2,4'-MDI = 0.01 to 4.48 pg/mg). The 4,4'-MDI species had the highest measured concentration (280 pg/mg). Commonly used medical devices/products contain low, but measurable concentrations of residual isocyanates. Quantifying other isocyanate species and neonatal skin exposure to isocyanates from these devices and products requires further investigation.

Immunotoxicology and its application in risk assessment

Immunotoxicology is the study of undesired modulation of the immune system by extrinsic factors. Toxicological assessments have demonstrated that the immune system is a target following exposure to a diverse group of xenobiotics including ultraviolet radiation, chemical pollutants, therapeutics, and recreational drugs. There is a well-established cause and effect relationship between suppression of the immune response and reduced resistance to infections and certain types of neoplasia. In humans, mild-to-moderate suppression of the immune response is linked to reduced resistance to common community-acquired infections, whereas opportunistic infections, which are very rare in the general population, are common in individuals with severe suppression. Xenobiotic exposure may also result in unintended stimulation of immune function. Although a cause and effect relationship between unintended stimulation of the immune response and adverse consequences has yet to be established, evidence does suggest that hypersensitivity, autoimmunity, and pathological inflammation may be exacerbated in susceptible populations exposed to certain xenobiotics. Xenobiotics can act as allergens and elicit hypersensitivity responses, or they can modulate hypersensitivity responses to other allergens such as pollen or dust mite by acting as adjuvants, enhancing the development or expression of hypersensitivity. Allergic contact dermatitis, allergic rhinitis, and asthma are the most commonly encountered types of hypersensitivity reactions resulting from chemical exposure. The immunologic effectors and mechanisms involved in autoimmune reactions are the same as those associated with responses to foreign antigens; however, the reactions are directed against the host's own cells. Thus, chemicals that induce immune suppression, nonspecific immunostimulation, or hypersensitivity may also impact autoimmunity. Risk assessment for immunotoxicity should be performed using the same approaches and principles for other noncancer effects. However, since xenobiotics may have effects on more than one aspect of immune function, immunotoxicity data should be evaluated separately for evidence of suppression, stimulation, hypersensitivity, and autoimmunity.

Connecting glutathione with immune responses to occupational methylene diphenyl diisocyanate exposure

Methylene diphenyl diisocyanate (MDI) is among the leading chemical causes of occupational asthma world-wide, however, the mechanisms of disease pathogenesis remain unclear. This study tests the hypothesis that glutathione (GSH) reacts with MDI to form quasi-stable conjugates, capable of mediating the formation of MDI-conjugated "self" protein antigens, which may participate in pathogenic inflammatory responses. To test this hypothesis, an occupationally relevant dose of MDI (0.1%w/v) was reacted with varying concentrations of GSH (10μM-10mM), and the reaction products were characterized with regard to mass/structure, and ability to carbamoylate human albumin, a major carrier protein for MDI in vivo. LC-MS/MS analysis of GSH-MDI reaction products identified products possessing the exact mass of previously described S-linked bis(GSH)-MDI and its partial hydrolysis product, as well as novel cyclized GSH-MDI structures. Upon co-incubation of GSH-MDI reaction products with human albumin, MDI was rapidly transferred to specific lysines of albumin, and the protein's native conformation/charge was altered, based on electrophoretic mobility. Three types of modification were observed, intra-molecular MDI cross-linking, addition of partially hydrolyzed MDI, and addition of "MDI-GSH", where MDI's 2nd NCO had reacted with GSH's "N-terminus". Importantly, human albumin carbamoylated by GSH-MDI was specifically recognized by serum IgG from MDI exposed workers, with binding dependent upon the starting GSH concentration, pH, and NaCl levels. Together, the data define a non-enzymatic, thiol-mediated transcarbamoylating mechanism by which GSH may promote immune responses to MDI exposure, and identify specific factors that might further modulate this process.

Determination of isocyanate specific albumin-adducts in workers exposed to toluene diisocyanates

Toluene diisocyanates (2,4-TDI and 2,6-TDI) are important intermediates in the chemical industry. Among the main damages after low levels of TDI exposure are lung sensitization and asthma. It is therefore necessary to have sensitive and specific methods to monitor isocyanate exposure of workers. Urinary metabolites or protein adducts have been used as biomarkers in workers exposed to TDI. However, with these methods it was not possible to determine if the biomarkers result from exposure to TDI or to the corresponding toluene diamines (TDA). This work presents a new procedure for the determination of isocyanate-specific albumin adducts. Isotope dilution mass spectrometry was used to measure the adducts in albumin present in workers exposed to TDI. 2,4-TDI and 2,6-TDI formed adducts with lysine: N(ϵ)-[({3-amino-4-methylphenyl}amino)carbonyl]-lysine, N(ϵ)-[({5-amino-2-methylphenyl}amino)carbonyl]-lysine, and N(ϵ)- [({3-amino-2-methylphenyl}amino)carbonyl]-lysine. In future studies, this new method can be applied to measure TDI-exposures in workers.

Occupational exposure to HDI: progress and challenges in biomarker analysis

1,6-Hexamethylene diisocyanate (HDI) is extensively used in the automotive repair industry and is a commonly reported cause of occupational asthma in industrialized populations. However, the exact pathological mechanism remains uncertain. Characterization and quantification of biomarkers resulting from HDI exposure can fill important knowledge gaps between exposure, susceptibility, and the rise of immunological reactions and sensitization leading to asthma. Here, we discuss existing challenges in HDI biomarker analysis including the quantification of N-acetyl-1,6-hexamethylene diamine (monoacetyl-HDA) and N,N'-diacetyl-1,6-hexamethylene diamine (diacetyl-HDA) in urine samples based on previously established methods for HDA analysis. In addition, we describe the optimization of reaction conditions for the synthesis of monoacetyl-HDA and diacetyl-HDA, and utilize these standards for the quantification of these metabolites in the urine of three occupationally exposed workers. Diacetyl-HDA was present in untreated urine at 0.015-0.060 μg/l. Using base hydrolysis, the concentration range of monoacetyl-HDA in urine was 0.19-2.2 μg/l, 60-fold higher than in the untreated samples on average. HDA was detected only in one sample after base hydrolysis (0.026 μg/l). In contrast, acid hydrolysis yielded HDA concentrations ranging from 0.36 to 10.1 μg/l in these three samples. These findings demonstrate HDI metabolism via N-acetylation metabolic pathway and protein adduct formation resulting from occupational exposure to HDI.

Quantitative plasma biomarker analysis in HDI exposure assessment

Quantification of amines in biological samples is important for evaluating occupational exposure to diisocyanates. In this study, we describe the quantification of 1,6-hexamethylene diamine (HDA) levels in hydrolyzed plasma of 46 spray painters applying 1,6-hexamethylene diisocyanate (HDI)-containing paint in vehicle repair shops collected during repeated visits to their workplace and their relationship with dermal and inhalation exposure to HDI monomer. HDA was detected in 76% of plasma samples, as heptafluorobutyryl derivatives, and the range of HDA concentrations was < or =0.02-0.92 microg l(-1). After log-transformation of the data, the correlation between plasma HDA levels and HDI inhalation exposure measured on the same workday was low (N = 108, r = 0.22, P = 0.026) compared with the correlation between plasma HDA levels and inhalation exposure occurring approximately 20 to 60 days before blood collection (N = 29, r = 0.57, P = 0.0014). The correlation between plasma HDA levels and HDI dermal exposure measured on the same workday, although statistically significant, was low (N = 108, r = 0.22, P = 0.040) while the correlation between HDA and dermal exposure occurring approximately 20 to 60 days before blood collection was slightly improved (N = 29, r = 0.36, P = 0.053). We evaluated various workplace factors and controls (i.e. location, personal protective equipment use and paint booth type) as modifiers of plasma HDA levels. Workers using a downdraft-ventilated booth had significantly lower plasma HDA levels relative to semi-downdraft and crossdraft booth types (P = 0.0108); this trend was comparable to HDI inhalation and dermal exposure levels stratified by booth type. These findings indicate that HDA concentration in hydrolyzed plasma may be used as a biomarker of cumulative inhalation and dermal exposure to HDI and for investigating the effectiveness of exposure controls in the workplace.

Dose-Response Relationships and Threshold Levels in Skin and Respiratory Allergy

A literature study was performed to evaluate dose-response relationships and no-effect levels for sensitization and elicitation in skin- and respiratory allergy. With respect to the skin, dose-response relationships and no-effect levels were found for both intradermal and topical induction, as well as for intradermal and topical elicitation of allergenic responses in epidemiological, clinical, and animal studies. Skin damage or irritation may result in a significant reduction of the no-effect level for a specific compound. With respect to the respiratory tract, dose-response relationships and no-effect levels for induction were found in several human as well as animal studies. Although dose-response relationships for elicitation were found in some epidemiological studies, concentration-response relationships were present only in a limited number of animal studies. Reported results suggest that especially relatively high peak concentrations can induce sensitization, and that prevention of such concentrations will prevent workers from developing respiratory allergy. Moreover, induction of skin sensitization may result in subsequent heightened respiratory responsiveness following inhalation exposure. The threshold concentration for the elicitation of allergic airway reactions in sensitized subjects is generally lower than the threshold to induce sensitization. Therefore, it is important to consider the low threshold levels for elicitation for recommendation of health-based occupational exposure limits, and to avoid high peak concentrations. Notwithstanding the observation of dose-response relationships and no-effect levels, due to a number of uncertainties, no definite conclusions can be drawn about absolute threshold values for allergens with respect to sensitization of and elicitation reactions in the skin and respiratory tract. Most predictive tests are generally meant to detect the potential of a chemical to induce skin and/or respiratory allergy at relatively high doses. Consequently, these tests do not provide information of dose-response relationships at lower doses such as found in, for example, occupational situations. In addition, the observed dose-response relationships and threshold values have been obtained by a wide variety of test methods using different techniques, such as intradermal exposure versus topical or inhalation exposure at the workplace, or using different endpoints, which all appear important for the outcome of the test. Therefore, especially with regard to respiratory allergy, standardized and validated dose-response test methods are urgently required in order to be able to recommend safe exposure levels for allergens at the workplace.

Respiratory sensitization and allergy: current research approaches and needs

There are currently no accepted regulatory models for assessing the potential of a substance to cause respiratory sensitization and allergy. In contrast, a number of models exist for the assessment of contact sensitization and allergic contact dermatitis (ACD). Research indicates that respiratory sensitizers may be identified through contact sensitization assays such as the local lymph node assay, although only a small subset of the compounds that yield positive results in these assays are actually respiratory sensitizers. Due to the increasing health concerns associated with occupational asthma and the impending directives on the regulation of respiratory sensitizers and allergens, an approach which can identify these compounds and distinguish them from contact sensitizers is required. This report discusses some of the important contrasts between respiratory allergy and ACD, and highlights several prominent in vivo, in vitro and in silico approaches that are being applied or could be further developed to identify compounds capable of causing respiratory allergy. Although a number of animal models have been used for researching respiratory sensitization and allergy, protocols and endpoints for these approaches are often inconsistent, costly and difficult to reproduce, thereby limiting meaningful comparisons of data between laboratories and development of a consensus approach. A number of emerging in vitro and in silico models show promise for use in the characterization of contact sensitization potential and should be further explored for their ability to identify and differentiate contact and respiratory sensitizers. Ultimately, the development of a consistent, accurate and cost-effective model will likely incorporate a number of these approaches and will require effective communication, collaboration and consensus among all stakeholders.

Animal models to test respiratory allergy of low molecular weight chemicals: a guidance

At present, there are no widely applied or fully validated test methods to identify respiratory LMW allergens, i.e. compounds that are considered capable of inducing allergic asthma. Most tests have been investigated using strong respiratory allergens. Moreover, they are meant to detect the potential of a chemical to induce respiratory sensitisation at relatively high doses. Consequently, the sensitivity of the tests is not well-known, and they do not provide information on low doses such as generally found in occupational situations, and on threshold levels to be used in risk assessment. In addition, the various test methods use different application routes, i.e. intradermal, topical or inhalation exposure, and different parameters. Therefore standardised and validated dose-response test methods are urgently required in order to be able to identify respiratory allergens and to recommend safe exposure levels for consumers and workers. In the present paper, methods or testing strategies are described to detect respiratory sensitisation and/or allergy. Overall, assays that utilize only an induction phase may serve as indicators of respiratory sensitisation potential whereas assays that use both an induction and an elicitation or challenge phase may provide information on potency and presence of thresholds. The dermal route as sensitisation route has the advantage of the respiratory tract not being exposed to the allergen prior to challenge which facilitates the distinction between irritant and allergic effects.

Approaches to induce and elicit respiratory allergy: impact of route and intensity of exposure

Although a number of test protocols have been developed to predict respiratory allergenic potential, none of these are widely applied or fully accepted. However, given the serious health problems caused by respiratory allergy and the ever-increasing stream of new chemicals into workplaces, early identification of chemical respiratory allergens is important. Inhalation exposure as well as skin application have been used in predictive tests to induce respiratory tract sensitisation. While there are good indications in laboratory animals and humans that skin exposure can act as a route for respiratory tract sensitisation and vice versa, less is known about the effect of the route on the type of allergy evoked and on dose-response relationships. Although, the responses were in general more vigorous after dermal sensitisation than after inhalation sensitisation, the nature of the immune responses seemed to be qualitatively comparable. As to the intensity of exposure, dose or concentration-response relationships have been observed both during respiratory sensitisation and challenge, suggesting that assessment of safe exposure levels is feasible. Finally, a correct distinction between respiratory allergens and non-sensitising airway irritants is needed for effective risk assessment and management.

Respiratory allergy and pulmonary irritation to trimellitic anhydride in Brown Norway rats

Occupational exposure to low-molecular-weight (LMW) allergens such as acid anhydrides can result in occupational asthma, an allergic disease characterized by episodic airway obstruction, airways inflammation, and non specific airways hyperresponsiveness. Since LMW irritants can provoke rather similar effects and since most, if not all, LMW allergens have irritant properties, this study addressed the distinction between allergenic and irritant effects of the respiratory allergen trimellitic anhydride (TMA). BN rats were sensitized by dermal application of TMA or vehicle alone and 3 weeks later were challenged by inhalation of a slightly irritating concentration of TMA or the vehicle. Lung function was measured before, during, and shortly after challenge. One day after challenge, in vivo and in vitro nonspecific airways hyperresponsiveness to methacholine was measured, and bronchoalveolar lavage was performed to measure total protein, lactate dehydrogenase, N-acetyl-glucosaminidase, and total and differential leukocyte numbers in the fluid. In addition, IgE measurements and histopathological examinations of the respiratory tract were carried out. TMA challenge of sensitized, but not sham-sensitized, BN rats reduced breathing frequency during challenge, elevated total and TMA-specific serum IgE levels, and caused a typical allergic asthma-associated airway pathology, as observed earlier. Vehicle challenge did not cause these effects, irrespective of sensitization. Hyperresponsiveness to methacholine was only seen in TMA-sensitized and -challenged rats. These rats also showed increased levels of the biochemical parameters and increased numbers of eosinophils and neutrophils in the lung lavage fluid; TMA challenge of sham-sensitized rats caused similar but markedly less pronounced effects. During TMA challenge of sham-sensitized rats, a breathing pattern typical of irritation was noticed but a clearly distinct pattern was seen upon TMA challenge of sensitized rats. In conclusion, TMA challenge of sensitized rats caused sensitization-dependent asthma-like early changes in breathing pattern that clearly could be distinguished from irritant-induced changes and non-specific airways hyperresponsiveness 24 h after challenge. Sensitization-dependent functional changes were accompanied by inflammatory changes characteristic of asthma and biochemical evidence of airway damage.

Latex sensitization by dermal exposure can lead to airway hyperreactivity

BACKGROUND

Using non-powdered, low-protein natural rubber latex (NRL) gloves has been shown to reduce the elicitation of respiratory symptoms in latex-allergic individuals; however, the role of dermal exposure in the induction of sensitization is not completely understood.

OBJECTIVE

These studies were conducted to (1) determine levels of NRL protein in gloves currently in use and (2) evaluate, using a murine model, the potential for dermal exposure to induce NRL sensitization and subsequent airway hyperreactivity upon respiratory challenge.

METHODS

Total extractable protein and NRL allergen levels were evaluated from 38 glove samples using the Lowry and CAP inhibition assays, respectively. BALB/c mice were dermally exposed to non-ammoniated latex (NAL, 6.25-25 microg) 5 days/week for 13 weeks and monitored weekly/biweekly for IgE levels. Airway hyperreactivity was determined following respiratory challenge with methacholine (MCH) or NAL proteins on days 60 and 93, respectively.

RESULTS

Glove total protein and NRL allergen levels ranged from below the limit of detection to 946 microg/g and from 0.002 to 112 microg/g, respectively. Mice demonstrated dose-dependent increases in total serum IgE levels by day 58 with increased airway hyperreactivity observed upon respiratory challenge with MCH (day 60) or NAL proteins (day 93).

CONCLUSIONS

These studies investigated the continued use of gloves with high levels of total extractable protein and NRL allergen. The potential for dermal exposure to induce NRL-specific IgE and airway hyperreactivity upon respiratory challenge suggests there should be continued concern regarding the induction of sensitization in individuals using non-powdered latex gloves.

Respiratory hypersensitivity to trimellitic anhydride in Brown Norway rats: a comparison of endpoints

A rat bioassay has been developed to provide an objective approach for the identification and classification of respiratory allergy using trimellitic anhydride (TMA), which is a known respiratory tract irritant and asthmagen. Particular emphasis was placed on the study of route-of-induction-dependent effects and their progression upon inhalation challenge with TMA (approximately 23 mg m(-3) for a duration of 30 min), which included analysis of specific and non-specific airway hyperreactivity and pulmonary inflammation initiated and sustained by immunological processes. Refinement of the bioassay focused on procedures to probe changes occurring upon challenge with TMA or methacholine aerosols using physiological, biochemical and immunological procedures. Following challenge with TMA, the rats sensitized to TMA showed marked changes in peak inspiratory and expiratory air flows and respiratory minute volume. In these animals, a sustained pulmonary inflammation occurred, characterized by specific endpoints determined in bronchoalveolar lavage (lactate dehydrogenase, protein, nitrite, eosinophil peroxidase, myeloperoxidase). When compared with the naive controls, lung weights were increased significantly, as were the weights of lung-associated lymph nodes following inhalation induction and auricular lymph nodes following topical induction. The extent of changes observed was equal or more pronounced in animals sensitized epicutaneously (day 0:150 microl vehicle/50% TMA on each flank, day 7; booster administration to the skin of the dorsum of both ears using half the concentration and volume used on day 0) when compared with rats sensitized by 5 x 3 h day(-1) inhalation exposures (low dose: 25 mg TMA m(-3), high dose: 120 mg TMA m(-3)). In summary, the findings support the conclusion that the Brown Norway rat model is suitable for identifying TMA as an agent that causes both an immediate-type change of breathing patterns and a delayed-type sustained pulmonary inflammatory response. However, it remains unresolved whether the marked effects observed in the topically sensitized rats are more related to a route-of-induction or dose-dependent phenomenon.

Respiratory hypersensitivity in guinea pigs sensitized to 1,6-hexamethylene diisocyanate (HDI): comparison of results obtained with the monomer and homopolymers of HDI

This study used guinea pigs that were sensitized to the biuret or isocyanurate type homopolymers of 1,6 hexamethylene diisocyanate (HDI). Induction was either by intradermal injection or repeated inhalation exposures. For comparison, groups of guinea pigs were sensitized to monomeric HDI. Naive animals served as negative controls. Two and three weeks following induction, animals were challenged by inhalation with the hapten and homologous protein conjugate of the hapten, respectively. Assessments were based on changes in respiratory rate, serum IgG(1)-antibody titer, and influx of eosinophilic granulocytes in airways. Guinea pigs induced and challenged with the HDI-monomer did not display appreciable changes in respiratory rate, whilst the re-challenge with the HDI-protein conjugate caused unequivocal changes in respiratory patterns, including a marked bronchial influx of eosinophilic granulocytes. In contrast, animals induced and challenged with either the free or conjugated aerosols of HDI-homopolymers failed to elicit specific physiological or morphological pulmonary responses. IgG(1) antibodies were observed in all groups receiving monomeric HDI or HDI-homopolymers. Based on the comparative assessment of antibody titers following intradermal injections, it appeared that monomeric HDI was more potent to induce specific IgG(1) antibodies than the homopolymers of HDI. In summary, with respect to induction of allergy and asthma, the data presented here suggest that the homopolymeric forms of HDI appear to be less potent asthmagens, if any, than monomeric HDI.

Synthesis of adducts with amino acids as potential dosimeters for the biomonitoring of humans exposed to toluenediisocyanate

Toluenediisocyanates (TDI) are important intermediates in the chemical industry. Among the main damages after low levels of TDI exposure are lung sensitization and asthma. Protein adducts of TDI might be involved in the etiology of sensitization reactions. Blood protein adducts are used as dosimeters for modifications of macromolecules in the target organs where the disease develops. The functional groups of cysteine, tyrosine, serine, lysine, tryptophan, histidine, and N-terminal amino acids are potential reaction sites for isocyanates. Especially the N-terminal amino acids, valine, and aspartic acid of hemoglobin and albumin, respectively, are reactive toward electrophilic xenobiotics. To develop methods for the quantitation of protein adducts of 2,4- and 2,6-TDI, we reacted 3-nitro-4-methylphenyl isocyanate (1a) with single amino acids and reduced the nitro group using catalytic hydrogenation or ammonium formate with palladium on carbon yielding N-[(3-amino-4-methylphenyl)carbamoyl]valine (2a), N-[(3-amino-4-methylphenyl)carbamoyl]aspartic acid (8a), N(alpha)-acetyl-N(epsilon)-[(3-amino-4-methylphenyl)carbamoyl]lysine (12a), and N(alpha)-acetyl-O-[(3-amino-4-methylphenyl)carbamoyl]serine (15a). The same reactions were performed with 5-nitro-2-methylphenyl isocyanate (1b) and 3-nitro-2-methylphenyl isocyanate (1c). The valine adducts were boiled in acid to obtain the corresponding hydantoins: 3-(3-amino-4-methylphenyl)-5-isopropylimidazoline-2,4-dione (5a), 3-(5-amino-2-methylphenyl)-5-isopropylimidazoline-2,4-dione (5b), and 3-(3-amino-2-methylphenyl)-5-isopropylimidazoline-2,4-dione (5c). A method for the detection of N-terminal adducts with valine in biological samples was developed. The tripeptide adduct N-[(3-amino-4-methylphenyl)carbamoyl]valyl-glycyl-glycine (19a) was hydrolyzed with acid in the presence of globin and the internal standard N-[(3-amino-4-methylphenyl-d(6))carbamoyl]valyl-glycyl-glycine (19d). The released hydantoins were determined by LC/MS/MS and after derivatization with pentafluoropropionic anhydride by GC/MS. The determination limit was 0.16 pmol/sample. The same N-terminal adduct with valine was found in globin of a TDI-worker and in two women with polyurethane covered breast implants.

A comparative respiratory sensitization study of 2,4- and 2,6-toluene diisocyanate using guinea pigs

The potential exposure of workers to both 2,4-toluene diisocyanate (2,4-TDI) and 2,6-TDI led to an investigation of the comparative respiratory sensitization potential of these two isomers. Separate groups of guinea pigs were either sham exposed or exposed to one of the isomers 3 h/day for 5 consecutive days (sensitization phase). The mean concentration during the sensitization phase ranged from 1. 29 to 1.40 ppm. The animals were then conventionally housed for 2 wk and challenged for 1 h on 3 subsequent weeks with either the same isomer or the alternate isomer. The first 2 wk of the challenge phase involved exposure to TDI vapor (18 to 46 ppb), whereas the third challenge was to an aerosol of TDI-guinea pig serum albumin (GPSA) conjugate (18 to 32 mg/m(3)). The endpoint used to detect both immediate-onset and delayed-onset hypersensitivity responses was respiratory rate. Body weights and clinical signs were also recorded. There were clear decrements in weight gain in response to the wk 1 exposure to either isomer of TDI, but no isomer-specific differences were observed. Clinical signs revealed irritation to the respiratory tract only during the sensitization phase. A single animal challenged with TDI-GPSA may have experienced a severe anaphylactic response during the challenge phase. The incidence of immediate-onset hypersensitivity responses resulting from challenge with TDI vapor was less robust and less consistent than that resulting from challenge with the TDI-GPSA conjugate. All groups sensitized with either isomer showed an increased incidence of responders. There was no apparent difference between the two isomers. The delayed-onset phase produced more spontaneous variability in spontaneous respiratory rates and was not amenable to analysis for response to TDI challenge. Thus, no isomer-dependent differences were observed.

Isocyanate-specific hemoglobin adduct in rats exposed to 4, 4'-methylenediphenyl diisocyanate

4,4'-Methylenediphenyl diisocyanate (MDI) is the most important of the isocyanates used as intermediates in the chemical industry. Among the main types of damage after exposure to low levels of MDI are lung sensitization and asthma. Protein adducts of MDI might be involved in the etiology of sensitization reactions. It is therefore necessary to have sensitive and specific methods for monitoring the isocyanate exposure of workers. To date, urine metabolites or protein adducts have been used as biomarkers in workers exposed to MDI. However, with these methods it is not possible to determine if the biomarkers result from exposure to MDI or to the parent aromatic amine 4,4'-methylenedianiline (MDA). This work presents a procedure for quantitating isocyanate-specific hemoglobin adducts. Blood proteins are used as markers of exposure and possibly as markers of dose size for the modifications of macromolecules in the target organs where the disease develops. For the quantitation of hemoglobin adducts, N(1)-[4-(4-isocyanatobenzyl)phenyl]acetamide (AcMDI) was reacted with the tripeptide valyl-glycyl-glycine and with valine yielding N-[4-(4-acetylaminobenzyl)phenyl]carbamoyl]valyl-glycyl-glycine and N-[4-[4-(acetylaminobenzyl)phenyl]carbamoyl]valine, respectively. N-[4-[4-(Acetylamino-3,5-dideuteriobenzyl)-2, 6-dideuteriophenyl]carbamoyl]valine was synthesized from valine, as was N(1)-[4-(4-isocyanato-3,5-dideuteriobenzyl)-2, 6-dideuteriophenyl]acetamide, for use as an internal standard. These adducts were cleaved in 2 M HCl to yield the corresponding hydantoins, 3-[4-(4-aminobenzyl)phenyl]-5-isopropyl-1, 3-imidazoline-2,4-dione (MDA-Val-Hyd) and 3-[4-(4-amino-3, 5-dideuteriobenzyl)-2,6-dideuteriophenyl]-5-isopropyl-1, 3-imidazoline-2,4-dione, respectively. In globin of rats exposed to MDI, MDA-Val-Hyd could be found in a dose-dependent manner. The adduct was identified by HPLC/MS/MS and quantified by GC/MS after derivatization with heptafluorobutyric anhydride. The amount of MDA-Val-Hyd found after acid hydrolysis of globin at 100 degrees C is about 12 times larger than the sum of N-acetyl-4, 4'-methylenedianiline (AcMDA) and MDA obtained from mild base hydrolysis of hemoglobin. The MDA-Val-Hyd is an isocyanate-specific adduct. MDA and AcMDA released after mild base hydrolyses result most likely from a sulfinamide adduct which is a typical adduct of arylamines. According to these results, higher amounts of isocyanate adducts than arylamine adducts should be expected in workers exposed to isocyanates.

Respiratory hypersensitivity to diphenylmethane-4,4'-diisocyanate in guinea pigs: comparison with trimellitic anhydride

Published evidence demonstrates successful induction and elicitation of respiratory hypersensitivity in guinea pigs by the known human respiratory allergens trimellitic anhydride (TMA) and diphenylmethane-4,4'-diisocyanate (MDI). From these data it is apparent that TMA-related respiratory hyperresponsiveness can be elicited readily in guinea pigs upon inhalation challenge with the free chemical. Despite the interlaboratory variability in methodological procedures used for the sensitization as well as elicitation of response and the wide range of concentrations of TMA employed for challenge exposures (6-57 mg/m(3) air), TMA had been unequivocally identified as a benchmark respiratory sensitizer by measurements of the respiratory rate during challenge. The protocols were duplicated to examine the respiratory sensitizer MDI. In intradermally sensitized guinea pigs, changes in immediate-onset-like respiratory response were observed when MDI challenge concentrations exceeded approximately 30 mg MDI/m(3) air. Collective experimental evidence suggests that the respiratory responses observed upon challenge with TMA were markedly more pronounced and easier to identify than those recorded following challenge with MDI or MDI conjugate. In contrast to TMA, irritant concentrations of MDI had to be used to elicit any respiratory response and the differentiation of irritant and allergic responsiveness became increasingly difficult. Despite the absence of unequivocal changes in breathing patterns upon MDI challenge, MDI-sensitized animals displayed elevated anti-MDI immunoglobulin G1 (IgG1) antibodies, and a significant influx of eosinophilic granulocytes in the bronchial wall and lung-associated lymph nodes. Therefore, it is believed that the robustness of this animal model to identify low-molecular-weight agents as respiratory sensitizer is increased when several endpoints are considered. These are (1) positive respiratory response upon challenge with the hapten, and if negative, also challenge with the conjugate of the hapten; (2) an influx of eosinophilic granulocytes; and (3) increased specific IgG1 response. Furthermore, it appears that particles in the range of approximately 2-6 microm evoke more consistent respiratory response upon challenge exposure than particles in the 1-2 microm range.