Enhanced biofuel production potential with nutritional stress amelioration through optimization of carbon source and light intensity in Scenedesmus sp. CCNM 1077

Mixotrophic Cultivation of Microalgae Using Biogas as the Substrate

Biogas utilization through biotechnology represents a potential and novel technology. We propose the microalgal mixotrophic cultivation to convert biogas to microalgae-based biodiesel, in which methanotroph was co-cultured to convert CH₄ to organic intermediate (and CO₂) for microalgal mixotrophic growth. This study constructed a co-culture of Methylocystis bryophila (methanotroph) and Scenedesmus obliquus (microalgae) with biogas feeding. Compared with the single culture of S. obliquus, higher microalgal biomass but a lower chlorophyll concentration was observed. The organic metabolism-related genes were upregulated, verifying microalgal mixotrophic growth. The stoichiometric calculation of M. bryophila culture shows that M. bryophila tends to release organic matter rather than grow under a low O₂ content. M. bryophila rarely grew under five different light intensities, indicating that M. bryophila acts as a biocatalyst in the co-culture. The organic intermediate released by methanotroph increased the maximum biomass of microalgal culture, accelerated nitrogen absorption, accumulated more monounsaturated fatty acids, and improved the adaptation to light. The co-culture of microalgae and methanotroph may provide new opportunities for microalgae-based biodiesel production using biogas as a substrate.

Physiological Response of an Oil-Producing Microalgal Strain to Salinity and Light Stress

By separating and extracting algae from the collected water samples, an oil-producing diatom strain was obtained. Microscopic observation of the strain revealed that its morphological characteristics were highly similar to those of the genus Cyclotella. The cloning of 18S rDNA and phylogenetic analysis showed that the algae were clustered with Cyclotella menegheniana with a high support rate, indicating that the alga was C. menegheniana. The fatty acid content of the alga was determined and found to be mainly C14, C16, and C18 fatty acids, which were in accordance with the relevant standards for edible oil. In this study, different gradient levels of salinity and light were set to investigate the culture and bioactive substance production of C. menegheniana. The results showed that the best growth condition was achieved when the salinity was 15 g·L⁻¹, and its biomass and oil content were the highest at 0.27 g·L⁻¹ and 21%, respectively. The final biomass was the highest when the light intensity was 2000 Lux and the oil content was 18.7%. The results of the study provided a basis for the large-scale production of edible oils and biodiesel.

Phosphorus uptake, distribution and transformation with Chlorella vulgaris under different trophic modes

Phosphorus (P) uptake, distribution and transformation are important processes associated with the growth and metabolism of microalgae. In this study, the fate of P in soluble microbial products (SMP), extracellular polymeric substances (EPS), and intracellular polymeric substances (IPS) of Chlorella vulgaris C7 in the form of inorganic P (IP) and organic P (OP) was studied under different trophic modes, including photoautotrophy, heterotrophy and mixotrophy. The results showed that mixotrophic cultivation of microalgae brought highest biomass yield, which was 2.09 times and 11.10 times higher than that of the photoautotrophic and heterotrophic conditions. Regarding P distribution and transformation, the trophic modes affected the transformation trends and rates of P in the form of IP and OP among SMP, EPS and IPS. Under photoautotrophic condition, EPS was the main P pool, and most of P in C. vulgaris was IP. While, under mixotrophic condition, IPS was the main P pool, and most of P was transformed to OP. The addition of glucose promoted the uptake of P by algal cells and the transformation of IP to OP, which accounted for 79.32% of total phosphorus at the end of cultivation. Collectively, mixotrophic cultivation was regarded as the optimum approach for microalgae cultivation and nutrient recovery.

Resource recovery through bioremediation of wastewaters and waste carbon by microalgae: a circular bioeconomy approach

Microalgal biomass-based biofuels are a promising alternative to fossil fuels. Microalgal biofuels' major obstacles are the water and carbon sources for their cultivation and biomass harvest from the liquid medium. To date, an economically viable process is not available for algal based biofuels. The circular bioeconomy is an attractive concept for reuse, reduce, and recycle resources. The recovery of nutrients from waste and effluents by microalgae could significantly impact the escalating demands of energy and nutraceutical source to the growing population. Wastewaters from different sources are enriched with nutrients and carbon, and these resources can be recovered and utilized for the circular bioeconomy approach. However, the utilization of wastewaters and waste seems to be an essential strategy for mass cultivation of microalgae to minimizing freshwater consumption, carbon, nutrients cost, nitrogen, phosphorus removal, and other pollutants loads from wastewater and generating sustainable biomass for value addition for either biofuels or other chemicals. Hence, the amalgamation of wastewater treatment with the mass cultivation of microalgae improved the conventional treatment process and environmental impacts. This review provides complete information on the latest progress and developments of microalgae as potential biocatalyst for the remediation of wastewaters and waste carbon to recover resources through biomass with metabolites for various industrial applications and large-scale cultivation in wastewaters, and future perspectives are discussed.

An approach for dairy wastewater remediation using mixture of microalgae and biodiesel production for sustainable transportation

The aim of this work is remediation of dairy wastewater (DWW) for biodiesel feedstock production using poly-microalgae cultures of four microalgae namely Chlorella minutissima (C. minutissima), Scenedesmus abundans (S. abundans), Nostoc muscorum (N. muscorum) and Spirulina sp. The poly-microalgae cultures were prepared as C. minutissima + N. muscorum (CN), C. minutissima + N. muscorum + Spirulina sp. (CNSS) and S. abundans + N. muscorum + Spirulina sp. (SNSS). Poly-microalgae culture CNSS cultivated on 70% DWW achieved 75.16, 61.37, 58.76, 84.48 and 84.58%, removals of biological oxygen demand (BOD), chemical oxygen demand (COD), total nitrogen (TN), total phosphorus (TP), and suspended solids (SS), respectively, at 12:12 h photoperiod that resulted into total biomass and lipid yield of 3.47 ± 0.07 g/L and 496.32± 0.065 mg/L. However, maximum biomass and lipid yields of 5.76 ± 0.06 and 1152.37 ± 0.065 mg/L were achieved by poly-microalgae culture CNSS cultivated on 70% DWW + 10 g/L of glucose at 18:6 h photoperiod. Fatty acid methyl ester (FAME) analysis shown presence of C14:0 (myristic acid) C16:0 (palmitic acid), C16:1 (palmitoleic acid), C18:0 (stearic acid), C18:2 (linoleic acid) and C18:3 (linolenic acid), it indicates that the lipids produced from poly-microalgae cultures are suitable for biodiesel production. Thus, poly-microalgae cultures could be more efficient than mono-microalgae cultures in the remediation of DWW and for biodiesel feedstock production.

Enhancing growth and oil accumulation of a palmitoleic acid-rich Scenedesmus obliquus in mixotrophic cultivation with acetate and its potential for ammonium-containing wastewater purification and biodiesel production

A palmitoleic acid-rich Scenedesmus obliquus strain SXND-02 was isolated from ammonium-containing wastewater. Biomass and lipid production were examined for this microalgal strain in photoautotrophic, heterotrophic, and mixotrophic cultivations, respectively, in order to extend its application in wastewater purification coupled with production of valued bio-products. Among the tested conditions, the microalga had better growth and higher lipid accumulation in mixotrophy. NH₄Cl inhibited the microalgal growth in photoautotrophic cultivation. However, NaAc alleviated this inhibition in both heterotrophy and mixotrophy. Using 7 g L^-1 NaAc and 0.5 g L^-1 NH₄Cl as carbon and nitrogen sources significantly increased the algal biomass and lipid yields under mixotrophic cultivation, with the highest levels up to 1.0 g L^-1 and 59.88%, respectively. Fatty acid profiling indicated that palmitoleic acid was 23% in the S. obliquus SXND-02 under mixotrophic condition, which was about 21-fold higher than that in the control S. obliquus. Furthermore, this microalgal strain was tested in the chicken farm wastewater (CFW) containing high ammonium. Compared with other treatments, the S. obliquus SXND-02 cultivated in the 1/2 CFW + NaAc medium produced larger amounts of biomass (2.18 g L^-1) and lipids (50.22%), and simultaneously higher removal rates of total nitrogen (TN) (80%), total ammonium nitrogen (TAN) (68%), total phosphate (TP) (82%), biological oxygen demand (BOD) (86%) and chemical oxygen demand (COD) (89%) from wastewater. The present data indicate that this excellent microalga can be used in mixotrophic cultivation for wastewater purification coupled with commercial production of valued biomass and high-quality algal oils.

Enhancing microalgae growth and product accumulation with carbon source regulation: New perspective for the coordination between photosynthesis and aerobic respiration

The coordination between photosynthesis and aerobic respiration under mixotrophic cultivation can make a difference to the growth and biochemical composition of microalgae. However, the response of carbon metabolism to carbon source composition under mixotrophic microalgae cultivation has not been well studied. In this study, the synergistic effects of inorganic carbon (IC) and organic carbon (OC) supply on the growth and carbon metabolism of Chlorella vulgaris under mixotrophic cultivation were investigated. The increase of the proportion of HCO₃^- had a positive effect on the expression of ribulose-1,5-bisphosphate carboxylase/oxygenase (RuBisCO), which promoted the biomass production and carbon fixing. The activity of citrate synthase was attenuated with the increase of IC/OC ratio, indicating that the energy needed for the biomass production in groups with high IC/OC ratio was contributed by photoreaction. Biochemical analysis showed that CO₃^2- was more efficient than HCO₃^- for carbohydrate and lipid accumulation of Chlorella vulgaris, and the highest amount of carbohydrate (30.2%) and lipid (35.8%) was recorded with the combined use of CO₃^2- and glucose. The results could provide a new perspective on carbon metabolism and enzyme regulation in mixotrophic microalgae cultivation.

Enhanced Production of Photosynthetic Pigments and Various Metabolites and Lipids in the Cyanobacteria Synechocystis sp. PCC 7338 Culture in the Presence of Exogenous Glucose

Synechocystis strains are cyanobacteria that can produce useful biomaterials for biofuel and pharmaceutical resources. In this study, the effects of exogenous glucose (5-mM) on cell growth, photosynthetic pigments, metabolites, and lipids in Synechocystis sp. PCC 7338 (referred to as Synechocystis 7338) were investigated. Exogenous glucose increased cell growth on days 9 and 18. The highest production (mg/L) of chlorophyll a (34.66), phycocyanin (84.94), allophycocyanin (34.28), and phycoerythrin (6.90) was observed on day 18 in Synechocystis 7338 culture under 5-mM glucose. Alterations in metabolic and lipidomic profiles under 5-mM glucose were investigated using gas chromatography-mass spectrometry (MS) and nanoelectrospray ionization-MS. The highest production (relative intensity/L) of aspartic acid, glutamic acid, glycerol-3-phosphate, linolenic acid, monogalactosyldiacylglycerol (MGDG) 16:0/18:1, MGDG 16:0/20:2, MGDG 18:1/18:2, neophytadiene, oleic acid, phosphatidylglycerol (PG) 16:0/16:0, and PG 16:0/17:2 was achieved on day 9. The highest production of pyroglutamic acid and sucrose was observed on day 18. We suggest that the addition of exogenous glucose to Synechocystis 7338 culture could be an efficient strategy for improving growth of cells and production of photosynthetic pigments, metabolites, and intact lipid species for industrial applications.

Potential Impact of Biodegradable Surfactants on Foam-Based Microalgal Cultures

Microalgae cultivation in liquid foams is a promising concept which requires the use of a surfactant as a foam stabilizing agent. The biodegradable character of a surfactant is a key aspect regarding its applicability in a liquid foam-bed photobioreactor (LF-PBR), since it might influence microalgal growth and the stability of the foam-based cultivation. In this work, the effects of the biodegradable surfactants bovine serum albumin (BSA), Saponin and Tween 20 on the whole microbial community of microalgal cultures (i.e., microalgal and bacterial populations) were studied. The three surfactants enhanced bacterial and microalgal growth in non-axenic microalgal cultures, but they differed in their efficiency to sustain bacterial growth. In this sense, Saponin was proven to enhance the growth of S. obliquus-associated bacteria in microalgae-free cultures, and to sustain it even when other nutrients were lacking, suggesting that Saponin can be used as an energy and nutrients source by these bacteria. The degradation and consumption of Saponin by S. obliquus-associated bacteria was also confirmed by the foaming capacity decrease in Saponin-added bacterial cultures. The biodegradable character of BSA, Saponin and Tween 20 reduces their suitability to be used in a LF-PBR since they would not be able to maintain stable foaming.

The effects of exogenous cerium on photosystem II as probed by in vivo chlorophyll fluorescence and lipid production of Scenedesmus obliquus XJ002

Cerium is the most abundant rare earth metal in the earth's crust, and it has deleterious effects on aquatic ecosystems from fertilizer runoff. Scenedesmus obliquus is an oil-rich microalga that grows rapidly and is sensitive to many kinds of toxins. Given that microalgae are useful indicators of eutrophication and toxic stress, it was found that lower concentrations of cerium (0.50-5.00 mg·L^-1 ) stimulated algal growth and increased chlorophyll a content, whereas higher concentrations (above 50.00 mg·L^-1 ) had an inhibitory effect on algal growth and chlorophyll a content. The algal growth rate and chlorophyll a content peaked at a cerium concentration of 5.00 mg·L^-1 . Both the donor and acceptor sides of photosystem II (PSII) reaction centers were sensitive to cerium-induced stress. Specifically, high concentrations of cerium damaged the oxygen evolving complex and PSII reaction center and suppressed electron transport at the donor and receptor side of the reaction center, influencing the absorption, transfer, and application of light energy in S. obliquus XJ002. In addition, we established a simple method to quantify the intracellular lipid content of S. obliquus XJ002, and the optimum staining conditions for Nile red were as follows: volume percentage of dimethyl sulfoxide was 2%, the concentration of Nile red was 2.0 µg·mL^-1 , and the staining time of Nile red was 5 min. The addition of cerium resulted in a significant increase in the total lipid content of XJ002. When the concentration of cerium was 50 mg·L^-1 , the total lipid content was 16.26% higher than the control group. This information will enhance our ability to utilize microelement fertilizer in biomass accumulation programs and will help to further reveal the key regulatory factors in the lipid metabolism, and would lay the foundation for promoting the research of microalgae bioenergy.

Effects of light intensity on growth and lipid production in microalgae grown in wastewater

BACKGROUND

Cultivation of microalgae in wastewater could significantly contribute to wastewater treatment, biodiesel production, and thus the transition to renewable energy. However, more information on effects of environmental factors, including light intensity, on their growth and composition (particularly fatty acid contents) is required. Therefore, we investigated the biomass and fatty acid production of four microalgal species, isolated in the Northern hemisphere and grown at three light intensities (50, 150 and 300 μE m^-2 s^-1).

RESULTS

Increases in light intensities resulted in higher biomass of all four species and, importantly, raised fatty acid contents of both Desmodesmus sp. and Scenedesmus obliquus. Fourier-transform IR spectrometry analysis showed that the increases in fatty acid content were associated with reductions in protein, but not carbohydrate, contents. Assessment of fatty acid composition revealed that increasing light intensity led to higher and lower contents of oleic (18:1) and linolenic (18:3) acids, respectively. The microalgae consumed more than 75% of the nitrogen and phosphorus present in the wastewater used as growth medium.

CONCLUSION

The results show the importance of optimizing light intensities to improve fatty acid production by microalgae and their quality as sources of biodiesel. In addition, increase in fatty acid content is associated with decrease in protein content.

The effect of NaCl stress on photosynthetic efficiency and lipid production in freshwater microalga-Scenedesmus obliquus XJ002

Rapid industrialization and population growth have increased the world's energy demands, resulting in a shortage of conventional fossil fuels. Thus, there is an urgent need to develop sustainable and renewable forms of energy. Microalgae have emerged as a potential feedstock for biofuel production. Under stress conditions, lipid production is enhanced in algal cells due to changes in the lipid biosynthetic pathways that produce neutral lipids. In this study, we examined the physiological and biochemical effects of salinity stress (0.00, 0.01, 0.10, 0.15, 0.20M) on the freshwater microalga Scenedesmus obliquus XJ002. We found that the biomass and the content of chlorophyll a, b and carotenoids decreased with increasing NaCl concentration. NaCl stress damaged the oxygen evolving complex (OEC) and the PSII (photosystem II) reaction center and subsequently suppressed electron transport at the donor and receptor sides of the reaction center, influencing the absorption, transfer, and application of light energy. Additionally, the total lipid content of cells was significantly increased under NaCl stress treatment. The highest lipid content (32.26%) was found in cells cultured in the presence of 0.20M NaCl, which was about 2.52-fold higher than that of cells grown in medium lacking NaCl (12.82%). In addition to providing insight into the physiological and biochemical responses of S. obliquus XJ002 to salinity stress, these findings show that lipid production, and hence biofuel feedstock production, can be boosted by adjusting salt levels in the growth medium.

Modelling Tetraselmis sp. growth-kinetics and optimizing bioactive-compound production through environmental conditions

The aim of this study is to predict Tetraselmis cells growth-kinetic and to induce the synthesis of bioactive compounds (chlorophylls, carotenoids and starch) with high potential for biotechnological applications. Using the statistical criteria, the Baranyi-Roberts model has been selected to estimate the microalgae growth-kinetic values. The simultaneous effects of salinity, light intensity and pH of culture medium were investigated to maximize the production of total chlorophylls, carotenoids and starch. The optimal culture conditions for the production of these compounds were found using Box-Behnken Design. Results have shown that total chlorophyll and carotenoids were attained 21.6mg·g^-1DW and 0.042mg·g^-1DW, respectively. In addition, the highest starch content of 0.624g·g^-1DW has been obtained at neutral pH with high irradiance (182μmolphotonsm^-2 s^-1) and low salinity (20). A highly correlation (R² = 0.884) has been found between the gravimetric and flow cytometric measurements of chlorophyll content.

Abiotic stresses as tools for metabolites in microalgae

Microalgae, due to various environmental stresses, constantly tune their cellular mechanisms to cope with them. The accumulation of the stress metabolites is closely related to the changes occurring in their metabolic pathways. The biosynthesis of metabolites can be triggered by a number of abiotic stresses like temperature, salinity, UV- radiation and nutrient deprivation. Although, microalgae have been considered as an alternative sustainable source for nutraceutical products like pigments and omega-3 polyunsaturated fatty acids (PUFAs) to cater the requirement of emerging human population but inadequate biomass generation makes the process economically impractical. The stress metabolism for carotenoid regulation in green algae is a 2-step metabolism. There are a few major stresses which can influence the formation of phycobiliprotein in cyanobacteria. This review would primarily focus on the cellular level changes under stress conditions and their corresponding effects on lipids (including omega-3 PUFAs), pigments and polymers.

Salinity induced oxidative stress alters the physiological responses and improves the biofuel potential of green microalgae Acutodesmus dimorphus

The main aim of the present study was to analyze salinity stress induced physiological and biochemical changes in a freshwater microalgae Acutodesmus dimorphus. During single-stage cultivation, the accumulations of lipids and carbohydrates increased with an increase in an initial salinity of the culture medium. The carbohydrate and lipid accumulations of 53.30±2.76% and 33.40±2.29%, respectively, were observed in 200mM NaCl added culture. During two-stage cultivation, salinity stress of 200mM was favorable for the growth up to 2days, as suggested by higher biomass, lower levels of oxidative stress biomarkers and no significant changes in the biochemical composition of the cells. Extending the stress to 3days significantly increased the lipid accumulation by 43% without affecting the biomass production. This study, thus, provides the strategy to improve the biofuel potential of A. dimorphus along with presenting the physiological adaptive mechanisms of a cell against salinity stress.

Microalgae: a robust "green bio-bridge" between energy and environment

Microalgae are a potential candidate for biofuel production and environmental treatment because of their specific characteristics (e.g. fast growth, carbon neutral, and rich lipid accumulations). However, several primary bottlenecks still exist in current technologies, including low biomass conversion efficiency, bio-invasion from the external environment, limited or costly nutrient sources, and high energy and capital input for harvest, and stalling its industrial progression. Coupling biofuel production with environmental treatment renders microalgae a more feasible feedstock. This review focuses on microalgae biotechnologies for both bioenergy generation and environmental treatment (e.g. CO₂ sequestration and wastewater reclamation). Different intelligent technologies have been developed, especially during the last decade, to eliminate the bottlenecks, including mixotrophic/heterotrophic cultivation, immobilization, and co-cultivation. It has been realized that any single purpose for the cultivation of microalgae is not an economically feasible option. Combinations of applications in biorefineries are gradually reckoned to be necessary as it provides more economically feasible and environmentally sustainable operations. This presents microalgae as a special niche occupier linking the fields of energy and environmental sciences and technologies. The integrated application of microalgae is also proven by most of the life-cycle analysis studies. This study summarizes the latest development of primary microalgal biotechnologies in the two areas that will bring researchers a comprehensive view towards industrialization with an economic perspective.

Effect of salinity stress on growth, lipid productivity, fatty acid composition, and biodiesel properties in Acutodesmus obliquus and Chlorella vulgaris

Two microalgae strains including Chlorella vulgaris and Acutodesmus obliquus were grown on BG11 medium with salinity stress ranging from 0.06 to 0.4 M NaCl. Highest lipid content in C. vulgaris and A. obliquus was 49 and 43% in BG11 amended with 0.4 M NaCl. The microalgal strains C. vulgaris and A. obliquus grow better at 0.06 M NaCl concentration than control condition. At 0.06 M NaCl, improved dry biomass content in C. vulgaris and A. obliquus was 0.92 and 0.68 gL^-1, respectively. Stress biomarkers like reactive oxygen species, antioxidant enzyme catalase, and ascorbate peroxidase were also lowest at 0.06 M NaCl concentration revealing that both the microalgal strains are well acclimatized at 0.06 M NaCl concentration. The fatty acid composition of the investigated microalgal strains was also improved by increased NaCl concentration. At 0.4 M NaCl, palmitic acid (37%), oleic acid (15.5%), and linoleic acid (20%) were the dominant fatty acids in C. vulgaris while palmitic acid (54%) and stearic acid (26.6%) were major fatty acids found in A. obliquus. Fatty acid profiling of C. vulgaris and A. obliquus significantly varied with salinity concentration. Therefore, the study showed that salt stress is an effective stress that could increase not only the lipid content but also improved the fatty acid composition which could make C. vulgaris and A. obliquus potential strains for biodiesel production.

Salinity stress increases lipid, secondary metabolites and enzyme activity in Amphora subtropica and Dunaliella sp. for biodiesel production

Amphora subtropica and Dunaliella sp. isolated from Tunisian biotopes were retained for their high lipid contents. Respective optimized parameters for rapid growth were: pH 9 and 10, light period 21 and 24h and temperature 31 and 34°C, respectively. After optimization, Amphora subtropica growth rate increased from 0.2 to 0.5day(-1) and Dunaliella sp. growth rate increased from 0.38 to 0.7day(-1). Amphora subtropica biomass production, productivity and lipid content increased from 0.3 to 0.7gL(-1)(dw), 69-100mgL(-1)d(-1)(dw) and 150-190gkg(-1)(dw), respectively, and Dunaliella sp. from 0.5 to 1.4gL(-1)(dw), 124-200mgL(-1)d(-1) (dw) and 190-280gkg(-1)(dw), respectively. Often to overcome trade-off between microalgae rapid growth and high lipid content which are often conflicting and very difficult to obtain at the same time, separation in a growth stage and a lipid accumulation stage is obvious. Salinity stress in a single stage of culture was studied. Compared to the optimal concentration of growth, excess or deficiency of NaCl engendered the same cellular responses by implication of oxidative stress systems and reactivation of defense and storage systems. Indeed, increasing salinity from 1M to 2M for Amphora subtropica or decreasing salinity from 3M to 2M for Dunaliella sp. have both increased lipids content from (220 and 280) to (350 and 430)gkg(-1), carotenoids from (1.8 and 2.4) to (2.3 and 3.7)pgcell(-1), TBARS amount from (10.4 and 5.3) to (12.1 and 10.7)nmolmg(-1) proteins and SOD activity from of (46.6 and 61.8) to (71.6 and 79.4)Umg(-1) proteins, respectively. With further improved fatty acids profile, the microalgae strains could be potent candidates for biofuel production.

Strain variation in microalgal lipid production during mixotrophic growth with glycerol

Algal cultivation at high latitudes is challenged by the relatively low annual solar flux. One possible scenario to overcome this limitation is the use of mixotrophic growth to potentially boost biomass and lipid production. Here the effect of glycerol addition on the growth and lipid production by twelve indigenous microalgae was examined. The results show that there is considerable strain dependent variation in the maximum growth rate under mixotrophic conditions with the addition of glycerol causing in some cases up to a 2.4-fold increase in growth rate and a up to a 1.9-fold increase in biomass. In addition, glycerol increased total lipid production 40-60% in some strains. These results also show the value in screening culture collections for desired traits independent of strain identification since here one (PCH02) of the five Chlorella strains showed a large increase in lipid with glycerol.

Comparative evaluation of chemical and enzymatic saccharification of mixotrophically grown de-oiled microalgal biomass for reducing sugar production

For the commercialization of microalgal based biofuels, utilization of de-oiled carbohydrate rich biomass is important. In the present study, chemo-enzymatic hydrolysis of mixotrophically grown Scenedesmus sp. CCNM 1077 de-oiled biomass is evaluated. Among the chemical hydrolysis, use of 0.5M HCl for 45 min at 121°C resulted in highest saccharification yield of 37.87% w/w of de-oiled biomass. However, enzymatic hydrolysis using Viscozyme L at loading rate of 20 FBGU/g of de-oiled biomass, pH 5.5 and temperature 45°C for 72 h resulted in saccharification yield of 43.44% w/w of de-oiled biomass. Further, 78% ethanol production efficiency was achieved with enzymatically hydrolyzed de-oiled biomass using yeast Saccharomyces cerevisiae ATCC 6793. These findings of the present study show application of mixotrophically grown de-oiled biomass of Scenedesmus sp. CCNM 1077 as promising feedstock for bioethanol production.

Two-phase photoperiodic cultivation of algal-bacterial consortia for high biomass production and efficient nutrient removal from municipal wastewater

This study investigated the photoperiodic effects on the biomass production and nutrient removal in the algal-bacterial wastewater treatment, under the following three conditions: (1) a natural 12h:12h LD cycle, (2) a dark-elongated 12h:60h LD cycle, and (3) a two-phase photoperiodic 12h:60h LD, followed by 12h:12h LD cycles. The two-phase photoperiodic operation showed the highest dry cell weight and lipid productivity (282.6mgL(-1)day(-1), 71.4mgL(-1)day(-1)) and most efficient nutrient removals (92.3% COD, 95.8% TN, 98.1% TP). The genetic markers and sequencing analyses indicated rapid increments of bacteria, subsequent growths of Scenedesmus, and stabilized population balances between algae and bacteria. In addition, the two-phase photoperiod provided a higher potential for the algal-bacterial consortia to utilize various organic carbon substrates.

Bicarbonate supplementation enhanced biofuel production potential as well as nutritional stress mitigation in the microalgae Scenedesmus sp. CCNM 1077

The aim of the present study was to find out the optimum sodium bicarbonate concentration to produce higher biomass with higher lipid and carbohydrate contents in microalgae Scenedesmus sp. CCNM 1077. The role of bicarbonate supplementation under different nutritional starvation conditions was also evaluated. The results clearly indicate that 0.6 g/L sodium bicarbonate was optimum concentration resulting in 20.91% total lipid and 25.56% carbohydrate along with 23% increase in biomass production compared to normal growth condition. Addition of sodium bicarbonate increased the activity of nutrient assimilatory enzymes, biomass, lipid and carbohydrate contents under different nutritional starvation conditions. Nitrogen starvation with bicarbonate supplementation resulted in 54.03% carbohydrate and 34.44% total lipid content in microalgae Scenedesmus sp. CCNM 1077. These findings show application of bicarbonate grown microalgae Scenedesmus sp. CCNM 1077 as a promising feedstock for biodiesel and bioethanol production.

Salinity induced oxidative stress enhanced biofuel production potential of microalgae Scenedesmus sp. CCNM 1077

Microalgal biomass is considered as potential feedstock for biofuel production. Enhancement of biomass, lipid and carbohydrate contents in microalgae is important for the commercialization of microalgal biofuels. In the present study, salinity stress induced physiological and biochemical changes in microalgae Scenedesmus sp. CCNM 1077 were studied. During single stage cultivation, 33.13% lipid and 35.91% carbohydrate content was found in 400 mM NaCl grown culture. During two stage cultivation, salinity stress of 400 mM for 3 days resulted in 24.77% lipid (containing 74.87% neutral lipid) along with higher biomass compared to single stage, making it an efficient strategy to enhance biofuel production potential of Scenedesmus sp. CCNM 1077. Apart from biochemical content, stress biomarkers like hydrogen peroxide, lipid peroxidation, ascorbate peroxidase, proline and mineral contents were also studied to understand the role of reactive oxygen species (ROS) mediated lipid accumulation in microalgae Scenedesmus sp. CCNM 1077.