Stability of aerobic granular sludge under condition of low influent C/N ratio: Correlation of sludge property and functional microorganism

Surface-programmed microbiome assembly in phycosphere to microplastics contamination

Recalcitrance in microplastics accounts for ubiquitous white pollution. Of special interest are the capabilities of microorganisms to accelerate their degradation sustainably. Compared to the well-studied pure cultures in degrading natural polymers, the algal-bacterial symbiotic system is considered as a promising candidate for microplastics removal, cascading bottom-up impacts on ecosystem-scale processes. This study selected and enriched the algae-associated microbial communities hosted by the indigenous isolation Desmodesmus sp. in wastewater treatment plants with micro-polyvinyl chloride, polyethylene terephthalate, polyethylene, and polystyrene contamination. Results elaborated that multiple settled and specific affiliates were recruited by the uniform algae protagonist from the biosphere under manifold microplastic stress. Alteration of distinct chemical functionalities and deformation of polymers provide direct evidence of degradation in phycosphere under illumination. Microplastic-induced phycosphere-derived DOM created spatial gradients of aromatic protein, fulvic and humic acid-like and tryptophan components to expanded niche-width. Surface thermodynamic analysis was conducted to simulate the reciprocal and reversible interaction on algal-bacterial and phycosphere-microplastic interface, revealing the enhancement of transition to stable and irreversible aggregation for functional microbiota colonization and microplastics capture. Furthermore, pangenomic analysis disclosed the genes related to the chemotaxis and the proposed microplastics biodegradation pathway in enriched algal-bacterial microbiome, orchestrating the evidence for common synthetic polymer particles and ultimately to confirm the effectiveness and potential. The present study emphasizes the necessity for future endeavors aimed at fully leveraging the potential of algal-bacterial mutualistic systems within sustainable bioremediation strategies targeting the eradication of microplastic waste.

Potential for curdlan recovery from aerobic granular sludge wastewater treatment systems - A review

The aerobic granular sludge (AGS) biotechnology has been explored for wastewater treatment for over two decades. AGS is gaining increased interest due to its enhanced treatment performance ability and the potential for resource recovery from AGS-based wastewater treatment systems. Resource recovery from AGS is a promising approach to sustainable wastewater treatment and attaining a circular economy in the wastewater management industry. Currently, research is at an advanced stage on recovering value-added resources such as phosphorus, polyhydroxyalkanoates, alginate-like exopolysaccharides, and tryptophan from waste aerobic granules. Recently, other value-added resources, including curdlan, have been identified in the aerobic granule matrix, and this may increase the sustainability of biotechnology in the wastewater industry. This paper provides an overview of AGS resource recovery potential. In particular, the potential for enhanced curdlan biosynthesis in the granule matrix and its recovery from AGS wastewater treatment systems is outlined.

Enhanced granulation of activated sludge in an airlift reactor for organic carbon removal and ammonia retention from industrial fermentation wastewater: A comparative study

Ammonia retention and recovery from high-nitrogenous wastewater are new concepts being used for nitrogen management. A microaerophilic activated sludge system was developed to convert organic nitrogen into ammonia and retain it for its recovery; however, the settleability of activated sludge remains a challenge. Therefore, this study proposed an aerobic granular sludge system as a potential solution. Two types of sequencing batch reactors-airlift and upflow reactors-were operated to investigate the feasibility of fast granule formation, the performance of organic carbon removal and ammonia retention, and the dynamics of microbial community composition. The operation fed with industrial fermentation wastewater demonstrated that the airlift reactor ensured a more rapid granule formation than the upflow reactor because of the high shear force, and it maintained a superior ammonia retention stability of approximately 85 %. Throughout the operational period, changes in hydraulic retention time (HRT), settling time, and exchange ratio altered the granular particle sizes and microbial community compositions. Rhodocyclaceae were replaced with Comamonadaceae, Methylophilaceae, Xanthomonadaceae, and Chitinophagaceae as core taxa instrumental in granulation, likely because of their extracellular polymeric substance secretion. As the granulation process progressed, a significant decrease in the relative abundances of nitrifying bacteria-Nitrospiraceae and Nitrosomonadaceae-was observed. The reduction of settling time and HRT enhanced granulation and inhibited the activity of nitrifying bacteria. The success in granulation for ammonia conversion and retention in this study accelerates the paradigm shift from ammonia removal to ammonia recovery from industrial fermentation wastewater.

Formation of autotrophic nitrogen removal granular sludge driven by the dual-partition airlift internal circulation: Insights from performance assessment, community succession, and metabolic mechanism

Granular sludge has been recognized as an effective method for the application and industrialization of the anammox-based process due to its good biomass retention capacity and environmental tolerance. In this study, a one-stage autotrophic nitrogen removal (ANR) dual-partition system with airlift internal circulation was implemented for 320 days. A high nitrogen removal efficiency of 84.6% was obtained, while the nitrogen removal rate reached 1.28 g-N/L/d. ANR granular sludge dominated by Nitrosomonas and Candidatus Brocadia was successfully cultivated. Results showed that activity and abundance of functional flora first increased with granulation process, but eventually declined slightly when particle size exceeded the optimal range. Total anammox activity was observed to be significantly correlated with protein content (R2 = 0.9623) and nitrogen removal performance (R2 = 0.8796). Correlation network revealed that AnAOB had complex interactions with other bacteria, both synergy for nitrogen removal and competition for substrate. Changes in abundances of genes encoding the Carbohydrate Metabolism, Energy Metabolism, and Membrane Transport suggested energy production and material transfer were possibly blocked with further sludge granulation. Formation of ANR granular sludge promoted the interactions and metabolism of functional microorganisms, and the complex nitrogen metabolic pathways improved the performance stability. These results validated the feasibility of granule formation in the airlift dual-partition system and revealed the response of the ANR system to sludge granulation.

N-methyl pyrrolidone manufacturing wastewater as the electron donor for denitrification: From bench to pilot scale

Actual wastewater generated from N-methylpyrrolidone (NMP) manufacture was used as electron donor for tertiary denitrification. The organic components of NMP wastewater were mainly NMP and monomethylamine (CH3NH2), and their biodegradation released ammonium that was nitrified to nitrate that also had to be denitrified. Bench-scale experiments documented that alternating denitrification and nitrification realized effective total‑nitrogen removal. Ammonium released from NMP was nitrified in the aerobic reactor and then denitrified when actual NMP wastewater was used as the electron donor for endogenous and exogenous nitrate. Whereas TN and NMP removals occurred in the denitrification step, dissolved organic carbon (DOC) and CH3NH2 removals occurred in the denitrification and nitrification stages. The genera Thauera and Paracoccus were important for NMP biodegradation and denitrification in the denitrification reactor; in the nitrification stage, Amaricoccus and Sphingobium played key roles for biodegrading intermediates of NMP, while Nitrospira was responsible for NH4+ oxidation to NO3-. Pilot-scale demonstration was achieved in a two-stage vertical baffled bioreactor (VBBR) in which total‑nitrogen removal was realized sequential anoxic-oxic treatment without biomass recycle. Although the bench-scale reactors and the VBBR had different configurations, both effectively removed total nitrogen through the same mechanisms. Thus, an N-containing organic compound in an industrial wastewater could be used to drive total-N removal in a tertiary-treatment scenario.

Effect of C/N on the microbial interactions of aerobic granular sludge system

The main focus of this study was to evaluate the operational stability and changes in microbial interactions of aerobic granular sludge (AGS) systems at reduced C/N (16, 8 and 4). The results showed that the removal efficiency of total nitrogen and total phosphorus decreased from 95.99 ± 0.93% and 84.44 ± 0.67% to 48.46 ± 1.92% and 50.93 ± 2.67%, respectively, when C/N was reduced from 16 to 4. The granule settling performance and stability also deteriorated. Molecular ecological network analysis showed that the reduction of the C/N ratio made the overall network as well as the subnetworks of the Proteobacteria and Bacteroidota more complex and tightly connected. Similarly, the subnetworks of two dominant genera (Thiothrix and Defluviicoccus) became more complex as the C/N decreased. Meanwhile, the decreased C/N ratio might promote competition among microbes in these overall networks and subnetworks. In conclusion, reduced C/N added complexity and tightness to microbial linkages within the AGS system, while increased competition between species might have contributed to the deterioration in pollutant removal performance. This study adds a new dimension to our understanding of the effects of C/N on the microbial community of AGS using a molecular ecological network approach.

Effect of ultrasound on the stability of partial nitrification: Under the interference of aeration rate

The fluctuation of dissolved oxygen is one of the primary cause of disruptions to the consistent operation of partial nitrification, and the level of dissolved oxygen is mainly controlled by the aeration rate. This study investigated the influence of ultrasonic treatment on the stability of partial nitrification of activated sludge under different aeration conditions. After being treated with ultrasound (energy density = 0.20 W·mL-1, treatment time = 10 min), partial nitrification process operated stably for 67 days, with the nitrite accumulation rate above 83.89 %. The effluent contained 42.50 mg·L-1 of nitrite, much higher than the control reactor (0.30 mg·L-1). The gap between the specific ammonia and nitrite oxidation rates widened continuously as the aeration rate increased, and nitrite-oxidizing bacteria activity did not recover even under conditions with a very high oxygen content. Further analysis showed that ultrasonic treatment had obvious stripping effect on excess extracellular polymeric substances (EPS), especially loosely bound EPS and protein. Additionally, long-term ultrasonic treatment promoted the enrichment of Nitrosomonas and strongly inhibited Nitrotoga. Based on these findings, it appears that under conditions of high aeration rate, ultrasound effectively suppress the recovery of Nitrotoga activity and improve the stability of partial nitrification.

The shock of benzalkonium chloride on aerobic granular sludge system and its microbiological mechanism

Quaternary ammonium compounds (QACs) are a kind of biocides and surfactants widely used around the world and wastewater treatment systems were identified as its largest pool. QACs could significantly inhibit microbial activity in biological treatment. Aerobic granular sludge (AGS) is an emerging wastewater biological treatment technology with high efficiency and resistance, but it is still unclear if AGS system could tolerate QACs shock. In this study, a typical QAC (benzalkonium chloride (BACC12)) was selected to investigate its effect on AGS system. Results indicate that BAC could inhibit the pollutants removal performance of AGS system, including COD, NH4+-N and PO43- in the short term and the inhibition ratio had positive correlation with BAC concentration. However, AGS system could gradually adapt to the BAC stress and recover its original performance. BAC shock could destroy AGS structure by decreasing its particle size and finally leading to particle disintegration. Although AGS could secret more EPS to resist the stress, BAC still had significant inhibition on cell activity. Microbial community analysis illustrated that after high BAC concentration shock in short term, Thauera decreased significantly while Flavobacterium became the dominant genus. However, after the performance of AGS system recovered the dominant genus returned to Thauera and relevant denitrifiers Phaeodactylibacter, Nitrosomonas and Pseudofulvimonas also increased. The typical phosphorous removal microorganism Rubrivivax and Leadbetterella also showed the similar trend. The variation of denitrification and phosphorus removal microbial community was consistent with AGS system performance indicating the change of functional microorganism played key role in the AGS response to BAC stress.

Study on the formation process and mechanism of aerobic granular sludge in the sequencing batch biofilter granular reactor

Sequencing batch biofilter granular reactor (SBBGR) is a promising wastewater treatment technology owing to its low sludge yield and good toxicity tolerance. However, little attention has been paid to the formation process and mechanism of aerobic granular sludge in SBBGR. This study systematically investigated the formation process and mechanism of aerobic granular sludge in an SBBGR to provide a theoretical basis for optimizing the culture of aerobic granular sludge. Aerobic granular sludge with good performance was successfully cultivated after 40 days of incubation using synthetic wastewater as feed: the mixed liquid suspended solids and mixed liquor volatile suspended solids increased from 3.85 and 1.85 g/L to 31.38 and 24.74 g/L respectively, and the COD, TN, and TP removal efficiencies were 91.21%, 84.99%, and 58.14%, respectively. The experimental results showed that Amoebacteria and Bacteroides played an important role in the formation of aerobic granular sludge, filamentous bacteria acted as a three-dimensional skeleton surrounded by filling bacilli and rod-shaped bacteria, and proteins played a dominant role in promoting granulation during the culture process.

Insights into the life-cycle of aerobic granular sludge in a continuous flow membrane bioreactor by tracing its heterogeneous properties at different stages

This work gave insights into the life-cycle of aerobic granular sludge (AGS) by tracing its heterogeneity in the basic properties at different stages in a closed system (a continuous flow membrane bioreactor, MBR), including physical and chemical characteristics and microbial communities. The results indicate that the entire life-cycle consists of the following four stages, namely, the initial, growing, mature and cleaved stages, where multiple AGS properties synergistically affect the rheological properties of the AGS over its life-cycle. The storage modulus (G') of AGS reached its maximum value at the mature stage, whose value was significantly and positively correlated with the protein (PN) in extracellular polymeric substances (EPS) and granule size, specifically the peak area of granule size distribution, but this value was strongly and negatively correlated with the roughness. The AGS at the mature stage would be more vulnerable to be destroyed than that at other stages under the condition of higher shear strain, such as γ = 50%, which was associated with larger granule size and fewer polysaccharide (PS)-related functional groups (especially in the soluble microbial products (SMPs) in the outermost layer of AGS), and the decrease in PS was correlated with a higher relative abundance of Chloroflexi. Additionally, the value of shear strain that AGS was subjected to had a good linear correlation (R2=0.993) with the Young's modulus, which indicated the ability of AGS to resist deformation improved with increasing values of shear strain.

How β-Cyclodextrin-Functionalized Biochar Enhanced Biodenitrification in Low C/N Conditions via Regulating Substrate Metabolism and Electron Utilization

Biodenitrification plays a vital role in the remediation of nitrogen-contaminated water. However, influent with a low C/N ratio limits the efficiency of denitrification and causes the accumulation/emission of noxious intermediates. In this study, β-cyclodextrin-functionalized biochar (BC@β-CD) was synthesized and applied to promote the denitrification performance of Paracoccus denitrificans when the C/N was only 4, accompanied by increased nitrate reduction efficiency and lower nitrite accumulation and nitrous oxide emission. Transcriptomic and enzymatic activity analyses showed BC@β-CD enhanced glucose degradation by promoting the activities of glycolysis (EMP), the pentose phosphate pathway (PPP), and the tricarboxylic acid (TCA) cycle. Notably, BC@β-CD drove a great generation of electron donors by stimulating the TCA cycle, causing a greater supply of substrate metabolism to denitrification. Meanwhile, the promotional effect of BC@β-CD on oxidative phosphorylation accelerates electron transfer and ATP synthesis. Moreover, the presence of BC@β-CD increased the intracellular iron level, causing further improved electron utilization in denitrification. BC@β-CD helped to remove metabolites and induced positive feedback on the metabolism of P. denitrificans. Collectively, these effects elevated the glucose utilization for supporting denitrification from 36.37% to 51.19%. This study reveals the great potential of BC@β-CD for enhancing denitrification under low C/N conditions and illustrates a potential application approach for β-CD in wastewater bioremediation.

Start-up phase optimization of pyrite-intensified hybrid sequencing batch biofilm reactor (PIHSBBR): Mixotrophic denitrification performance and mechanism

Pyrite-based autotrophic denitrification (PAD) is an emerging biological process to diminish nitrate pollution, but the relatively low NO₃^--N removal rate limits its practical application. In this research, a pyrite-intensified hybrid sequencing batch biofilm reactor (PIHSBBR) was designed to treat low C/N ratio domestic wastewater. The results showed that PIHSBBR could achieve optimal removal of COD, NH₄⁺-N, and TN under the aeration rate of 1.0 L/L∙min and the hydraulic retention time (HRT) of 8 h, with removal rates of 69.67 ± 4.37%, 77.04 ± 4.84%, and 63.92 ± 6.66%, respectively. The PAD efficiency in PIHSBBR during the stable operation was not high (13.05-31.01%), and the main nitrogen removal pathway in PIHSBBR, especially in the aerobic zone, was simultaneous nitrification and denitrification (SND). High-throughput sequencing analysis unraveled that Planctomycetota (3.65%) had a high abundance in the anoxic zone of PIHSBBR, implying that anaerobic ammonium oxidation (anammox) might have occurred in the anoxic zone. In addition, the nitrogen cycle function gene with the highest abundance was nirBD, indicating the possible presence of dissimilatory nitrate reduction to ammonium (DNRA) within the system (aerobic and anoxic zones). Our research can provide useful information for the improvement and future application of PIHSBBR.

Influence of salt addition to stimulating biopolymers production in aerobic granular sludge systems

The influence of salt addition to stimulating biopolymers production in aerobic granular sludge (AGS) systems was evaluated. The control systems (R1: acetate and R2: propionate) initially obtained less accumulation of mixed liquor volatile suspended solids (MLVSS), indicating that the osmotic pressure in the salt-supplemented systems (R3: acetate and R4: propionate) contributed to biomass growth. However, the salt-supplemented systems collapsed between days 110 and 130 of operation. R3 and R4 showed better performance regarding nutrients removal due to the greater abundance of nitrifying and denitrifying bacteria and phosphate-accumulating organisms. Salt also contributed to the higher production of biopolymers such as alginate-like exopolymers (ALE) per gram of volatile suspended solids (VSS) (R1: 397 mgALE∙gVSS^-1, R2: 140 mgALE∙gVSS^-1, R3: 483 mgALE∙gVSS^-1, R4: 311 mgALE∙gVSS^-1). Amino acids like tyrosine and tryptophan were better identified in extracellular polymeric substances extract from salt-operated reactors. This study brings important results in the context of resource recovery by treating saline effluents.

Positive effects of magnetic Fe3O4@polyaniline on aerobic granular sludge: Aerobic granulation, granule stability and pollutants removal performance

The magnetic material has been determined to have a positive effect on sludge granulation and wastewater treatment performance. In this study, the effect of magnetic Fe₃O₄@polyaniline (Fe₃O₄@PANI) on aerobic granulation, granule stability, and pollutants removal performance was evaluated by adding it into a sequencing batch reactor to cultivate aerobic granular sludge (AGS). The results indicated that the composite combined the advantages of PANI and Fe₃O₄ to promote the formation of AGS during the granulation period. The Fe₃O₄@PANI stimulated the granules to secrete extracellular polymeric substances with a higher proteins/polysaccharides ratio, thus enhancing the stability of the AGS. In addition, microbial community analysis revealed that the great performance of the AGS on denitrification and phosphorus removal could be attributed to the enrichment of denitrifying bacteria, phosphorus accumulating organisms (PAO), and denitrifying PAO by Fe₃O₄@PANI. Thus, Fe₃O₄@PANI has been demonstrated to have a positive effect on the formation and stability of AGS.

Responses of various carbon to nitrogen ratios to microbial communities, kinetics, and nitrogen metabolic pathways in aerobic granular sludge reactor

The role of different ammonia concentrations (mg N/L) (of 100 (carbon to nitrogen ratio (C/N) = 12; Stage I), 200 (C/N = 6; Stage II), 400 (C/N = 3; Stage III) and 200 (C/N = 6; Stage IV)) in nitrogen metabolic pathways, microbial community, and specific microbial activity were investigated in an aerobic granular sludge reactor. Heterotrophic ammonia oxidizing bacteria (HAOB) showed higher ammonia oxidation rates (AORs) than autotrophic ammonia oxidizing bacteria (AAOB) at higher C/N conditions (Stages I and II). Paracoccus was the dominant HAOB. AAOB, with only 0.2-0.3 % in relative abundance, showed 2.7-fold higher AORs than HAOB at elevated ammonia and free ammonia (FA) concentrations with C/N at 3. Nitrosomonas and a genus in Nitrosomondaceae family were the major AAOB. This study proposed that FA inhibition on heterotrophic bacteria might be the mechanism that contributes to the development of the autotrophic ammonia oxidation pathway and enrichment of AAOB.

Effect of flow regime on mass transfer diffusion and stability of aerobic granular sludge (AGS) in view of interfacial thermodynamic

Aerobic granular sludge (AGS) technology has been widely studied as "The Next Generation Wastewater Treatment technology". The effect of hydraulic conditions on the structural stability of AGS has been widely studied. However, the function of flow regime on the AGS stability, especially dissolved oxygen (DO) mass transfer, is still unknown. In this study, we used the Reynolds number (Re) to quantify the flow regime and selected different stages of AGS as experimental subjects. Results showed that the relatively suitable Re (Re = 150) could create lower DO mass transfer limitation (Lc = 27.4 μm) and increase protein (PN) contents and the abundance of hydrophobic functional groups in AGS. At this condition (Re = 150), the interfacial Gibbs free energy of sludge-water (ΔG_LS^a) was at a lower state (-129.75 ± 2.15 mJ·m^-2), which favored the stability of AGS. Principal component analysis (PCA) and correlation analysis indicated that the response of ΔG_LS^a was affected by Lc, PN, and hydrophobic groups. In addition, results obtained for unstable AGS further verified that suitable Re regulates the structural stability of AGS. This study deepens the understanding of Re as an important hydraulic parameter for structural stability of AGS, which is also of great significance for energy saving of sequential batch reactors (SBRs) with agitation in practical engineering.

Denitrification for acidic wastewater treatment: Long-term performance, microbial communities, and nitrous oxide emissions

Acidic nitrogenous wastewater often requires alkali pretreatment before biological treatment, which results in increased system complexity and operating costs. The demonstration of denitrification under acidic conditions would provide a theoretical basis for the direct treatment of such wastewater. In this study, the denitrification performance, microbial community, and nitrous oxide (N₂O) emissions under acidic conditions were investigated using a sequencing batch reactor. When the influent pH decreased from 5.5 to 4.5, the sequencing batch reactor removed 99.8 ± 0.2% of the nitrate and 92.5 ± 1.6% (n = 171) of the chemical oxygen demand, and the production efficiency of N₂O increased significantly to 11.45%. This was 2.6-fold higher than that observed at pH 5.5. The long-term denitrification treatment of acidic wastewater (pH 4.5) led to the formation of granular sludge, and Thauera, Allorhizobium-Neorhizobium-Parararhizobium-Rhizobium, and Diaphorobacter became the dominant microbes with a collective abundance of 81.3%. More importantly, only 0.25% of the nitrate was denitrified as N₂O, and the batch test revealed that the emissions of N₂O decreased with the increase in sludge size. These results indicate that denitrifying granular sludge formed under acidic conditions and denitrifying bacteria capable of N₂O reduction proliferated, which both resulted in a significant reduction in the release of N₂O.

Molecular mechanisms through which different carbon sources affect denitrification by Thauera linaloolentis: Electron generation, transfer, and competition

Characterizing the molecular mechanism through which different carbon sources affect the denitrification process would provide a basis for the proper selection of carbon sources, thus avoiding excessive carbon source dosing and secondary pollution while also improving denitrification efficiency. Here, we selected Thauera linaloolentis as a model organism of denitrification, whose genomic information was elucidated by draft genome sequencing and KEGG annotations, to investigate the growth kinetics, denitrification performances and characteristics of metabolic pathways under diverse carbon source conditions. We reconstructed a metabolic network of Thauera linaloolentis based on genomic analysis to help develop a systematic method of researching electron pathways. Our findings indicated that carbon sources with simple metabolic pathways (e.g., ethanol and sodium acetate) promoted the reproduction of Thauera linaloolentis, and its maximum growth density reached OD₆₀₀ = 0.36 and maximum specific growth rate reached 0.145 h^-1. These carbon sources also accelerated the denitrification process without the accumulation of intermediates. Nitrate could be reduced completely under any carbon source condition; but in the "glucose group", the maximum accumulation of nitrite was 117.00 mg/L (1.51 times more than that in the "ethanol group", which was 77.41 mg/L), the maximum accumulation of nitric oxide was 363.02 μg/L (7.35 times more than that in the "ethanol group", which was 49.40 μg/L), and the maximum accumulation of nitrous oxide was 22.58 mg/L (26.56 times more than that in the "ethanol group", which was 0.85 mg/L). Molecular biological analyses demonstrated that diverse types of carbon sources directly induced different carbon metabolic activities, resulting in variations in electron generation efficiency. Furthermore, the activities of the electron transport system were positively correlated with different carbon metabolic activities. Finally, these differences were reflected in the phenomenon of electronic competition between denitrifying reductases. Thus we concluded that this was the main molecular mechanism through which the carbon source type affected the denitrification process. In brief, carbon sources with simple metabolic pathways induced higher efficiency of electron generation, transfer, and competition, which promoted rapid proliferation and complete denitrification; otherwise Thauera linaloolentis would grow slowly and intermediate products would accumulate seriously. Our study established a method to evaluate and optimize carbon source utilization efficiency based on confirmed molecular mechanisms.

Adaptive regulation of activated sludge's core functional flora based on granular internal spatial microenvironment

A great deal of efforts has been put into studying the influence of the external macroenvironment for activated sludge to survive on microbial community succession, while granular internal spatial microenvironment should be given equal attention, because it is more directly involved in the information exchange and material transfer among microorganisms. This study systematically investigated the effects of granular microenvironment on spatial colonization and composition of sludge's core functional flora, and the corresponding difference of biological treatment performance. High content of extracellular-proteins (67.53 mg/gVSS) or extracellular-polysaccharide (65.02 mg/gVSS) stimulated the microbial flocculation and aggregation of 0.5-1.5 mm granules (GS) or 1.5-3.0 mm granules (GM), respectively, which was resulted from excellent cell hydrophobicity (59.26%) or viscosity (3.47 mPa s), therefore, constituted relatively dense porous frame. More hollow space existed in 3.0-5.0 mm granules (GL), which formed loose skeleton with 0.213 mL/g of total pore volume and 17.21 nm of average pore size. Combining scanning electron microscope images and fluorescent in-situ hybridization based microbiological analysis, aerobic nitrifiers were observed to wrap or surround anaerobic bacteria, or facultative/anaerobic bacteria were self-encapsulated, which created granule's unique microenvironment with alternating aerobic and anaerobic zones. GS has the most rich organic matter degrading bacteria and anaerobic heterotrophic denitrifiers, while GM and GL presented the greatest relative abundance of facultative and aerobic denitrifiers, respectively. The activity of dehydrogenase and nitrogen invertase of GM showed be 1.32-3.09 times higher than those of GS and GL, contributing to its higher carbon and nitrogen removal. These findings highlight the importance of granular microenvironment to adaptive regulation of activated sludge's core functional flora and corresponding pollutant removal performance.

The formation and distinct characteristics of aerobic granular sludge with filamentous bacteria in low strength wastewater

In low strength wastewater, aerobic granular sludge (AGS) with filamentous bacteria is often found and regarded as unstable AGS. However, in this study, a new view is proposed that AGS with filamentous bacteria (FAGS) may be the result of low strength wastewater selection. FAGS was found when AGS was cultivated for 30 days. By increasing the settling time, FAGS could keep the mixed liquid suspension (MLSS) at 0.89 g/L. FAGS showed excellent ammonia nitrogen removal performance. The ammonia nitrogen oxidation rate and denitrification rate of FAGS were 1.72 and 1.20 times higher than that of AGS, respectively. FAGS have large specific surface area (15.99 m²/g), high extracellular polymeric substances (EPS) content (>200 mg/gVSS), and strong stability (integrity coefficient: 2 ∼ 8%). Furthermore, FAGS showed higher potential than AGS in many aspects such as carbon metabolism, nitrogen metabolism, and toxicant degradation.

Carbon source affects the resource recovery in aerobic granular sludge systems treating wastewater

This study evaluated the influence of carbon sources on alginate-like exopolymers (ALE) and tryptophan (Trp) biosynthesis in the aerobic granular sludge (AGS). With acetate, the highest biopolymers levels, per gram of volatile suspended solids (VSS) (418.7 mgALE∙g^-1 and 4.1 mgTrp∙gVSS^-1), were found likely due to biomass loss throughout the operation, which resulted in lower sludge age (4-7 days) and shorter famine period. During granulation, encouraging results on ALE production were obtained with propionate (>250 mgALE∙gVSS^-1), significantly higher than those found with glycerol, glucose, and sucrose. Regarding tryptophan production, propionate and glycerol proved to be good substrates, although the content was still lower than acetate (1.6 mgTrp∙gVSS^-1). Granules fed with glucose showed the worst results compared to the other substrates (38.5 mgALE∙VSS^-1 and 0.6 mgTrp∙gVSS^-1) due to the filamentous microorganisms' abundance found. Therefore, this study provides insights to value the production of compounds of industrial interest in AGS systems.

Uncover the secret of the stability and interfacial Gibbs free energy of aerobic granular sludge

Interfacial Gibbs free energy (IGFE) as a thermodynamic indicator characterize the stability of the natural system. For aerobic granular sludge (AGS), how IGFE determines the stability of sludge remains to be determined. The Gibbs free energy change at the AGS-water interface (ΔG_sw^a) and AGS interfaces (ΔG_s^c) were selected as the main interfacial thermodynamic factors. Results indicated that the stable AGS was guaranteed with ΔG_s^c at the range of -31 to - 46 J m^-2. Pearson correlation coefficients between ΔG_sw^a/ ΔG_s^c and relative hydrophobicity, water content, SVI₃₀, integrity coefficient were -0.9, 0.8, 0.85, and 0.84, which illustrated that the IGFE could be a more comprehensive thermodynamic indicator. Microbial community and EPS analysis verified the importance of denitrifiers, Amide III, protein-like substances for AGS stability. This work offers a new insight into the development of AGS stability based on IGFE.

Rapid start-up of photo-granule process in a photo-sequencing batch reactor under low aeration conditions: Effect of inoculum AGS size

The photo-granule process is an effective and economically feasible alternative for wastewater treatment, but little information is available regarding how to speed up the photo-granulation process. In this study, the effect of inoculum aerobic granular sludge (AGS) size on the start-up of the photo-granule process was investigated under low aeration conditions (superficial gas velocity of 0.5 cm/s). For this purpose, the inoculum AGS was sorted into various size-categories (0.4-0.8 mm, 0.8-1.4 mm, 1.4-2.2 mm, and > 2.2 mm) to serve as individual inoculum sludge. The excellent settling properties (SVI₅ of 39.3 mL/g), strong mechanical strength, efficient nutrient removal (COD: 94.2-97.1%; TN: 80.1-84.8%; TP: 60.4-91.5%), and high biodiesel yields (12.11 mg/g MLSS) were rapidly achieved in the system inoculated with 0.8-1.4 mm AGS. The granulation process was facilitated by filamentous algae as the nucleus, extracellular polymeric substances as the backbone, and the enrichment of functional bacteria (such as Thauera and Sphingorhabdus). Furthermore, the inherent influencing mechanisms of inoculum AGS size on the photo-granulation were revealed from cellular hydrophobicity, surface thermodynamics, and sludge aggregation behavior. This study provides a novel start-up approach of the photo-granule process by inoculating with the optimal AGS size, which is convenient, practically feasible and significantly reduced the aeration consumption.

Promoting the granulation process of aerobic sludge via a sustainable strategy of effluent reflux in view of AHLs-mediated quorum sensing

Aerobic granular sludge (AGS) has excellent performance in wastewater treatment. However, the formation and mechanism of AGS by effluent reflux are not fully understood in sequential batch reactors (SBRs). In this study, two reactors were constructed, among which R1 was the control group, and the R2 reactor refluxed one-fourth of the supernatant of the effluent to the influent water. In the reactor of R2, the granules had better COD and TN removal efficiencies and resistance to external shocks, and AGS produced more extracellular polymeric substances (EPS). Analysis of microbial community indicated that AHLs-mediated microbes, denitrifying microbes, and EPS producers were enriched. At the same time, the correlation between 3OC6-HSL, C8-HSL, C12-HSL and PN was 0.89*, 0.94** and 0.92* respectively, the possible mechanism of enhanced granulation was mainly the promotion of AHLs by effluent reflux. Therefore, the effluent reflux strategy could be an innovative and sustainable strategy that validates the function of AHLs-mediated QS to accelerate aerobic sludge granulation and maintain its structural stability.

Identification of partial denitrification granulation enhanced by low C/N ratio in the aspect of metabolomics and quorum sensing

Partial denitrification granular sludge (PDGS) and denitrification granular sludge (DGS) play an important role in nitrogen removal from wastewater. However, the inherent cause of aggregation capacity related to the ratio of COD to nitrogen (COD/N) is still unclear. In this study, metabolomics analysis was combined with microbiological analyses, granular performance and extracellular polymeric substances (EPS) structure to explore the granulation mechanism at different influent COD/N ratios. The results showed that the higher COD/N ratio selectively enhanced the gluconeogenesis pathway, purine and pyrimidine metabolism pathway, resulting in more extracellular polysaccharide (PS) excretion and floc sludge. The absence of carbon source weakened tricarboxylic acid cycle (TCA) reaction, resulting in NAD⁺ and ADP decrease, nitrite accumulation and change of microbial community structure. The amino acids biosynthesis pathway was enhanced under low COD/N ratio, which promoted the hydrophobicity of EPS. PDGS had stronger Acyl-homoserine lactones (AHLs)-based quorum sensing (QS) than DGS during the operational period. CO8-HSL, C8-HSL and C6-HSL, as the main form of AHLs, played a dominating role in DGS and PDGS. Batch tests illustrated that adding AHLs obviously improved the synthesis of the amino acids, threonine (Thr), tryptophan (Trp), methionine (Met) and glycine (Gly). Dosing AHLs regulated PS synthesis only at a high COD/N ratio. The glucose-6P, glycerate-3p and UDP-Glc were up-regulated only in DSG, which increased the hydrophilic groups in EPS. The results not only provided the new insights into the metabolism of denitrifying granular sludge, but also indicated the application potential of the technologies regarding start-up and operation of granule sludge.

Diversified metabolism makes novel Thauera strain highly competitive in low carbon wastewater treatment

Thauera, as one of the core members of wastewater biological treatment systems, plays an important role in the process of nitrogen and phosphorus removal from low-carbon source sewage. However, there is a lack of systematic understanding of Thauera's metabolic pathway and genomics. Here we report on the newly isolated Thauera sp. RT1901, which is capable of denitrification using variety carbon sources including aromatic compounds. By comparing the denitrification processes under the conditions of insufficient, adequate and surplus carbon sources, it was found that strain RT1901 could simultaneously use soluble microbial products (SMP) and extracellular polymeric substances (EPS) as electron donors for denitrification. Strain RT1901 was also found to be a denitrifying phosphate accumulating bacterium, able to use nitrate, nitrite, or oxygen as electron acceptors during poly-β-hydroxybutyrate (PHB) catabolism. The annotated genome was used to reconstruct the complete nitrogen and phosphorus metabolism pathways of RT1901. In the process of denitrifying phosphorus accumulation, glycolysis was the only pathway for glycogen metabolism, and the glyoxylic acid cycle replaced the tricarboxylic acid cycle (TCA) to supplement the reduced energy. In addition, the abundance of conventional phosphorus accumulating bacteria decreased significantly and the removal rates of total nitrogen (TN) and chemical oxygen demand (COD) increased after the addition of RT1901 in the low carbon/nitrogen (C/N) ratio of anaerobic aerobic anoxic-sequencing batch reactor (AOA-SBR). This research indicated that the diverse metabolic capabilities of Thauera made it more competitive than other bacteria in the wastewater treatment system.

A new approach to evaluate and improve the stability of aerobic sludge systems based on maintenance coefficient

Stability is a key issue of wastewater treatment plants using either aerobic granular (AGS) or conventional activated sludge (CAS). The two forms of aerobic sludge were cultivated under different conditions to study the main factors affecting their stability. It was found that maintenance coefficient (m) describing the fraction of non-growth energy of granules increased significantly when the system became more stable during processes with the enhancement of granulation and the periodic short-term shock load. The yield coefficient (Y_H) was the main factor affecting the m value, and the inhibition in Y_H value was able to promote the maintenance potential according to the kinetic equation. Therefore, strategies that promote the maintenance coefficient could be applied to improve the stability of sludge systems, including inhibiting the yield rate and taking periodic short-term shock. Evaluation of stability based on the maintenance coefficient is a promising tool for ensuring the stable operation of wastewater treatment processes.

Structural Characteristics of Aerobic Granular Sludge and Factors That Influence Its Stability: A Mini Review

Current extensive research on aerobic granular sludge (AGS) largely focuses on improving its microbial biodiversity, settlement behavior, nitrogen and phosphorus removal efficiency, and shock load resistance. Great challenges that have to be faced are the bottleneck of slow-speed granulation and easy disintegration after granulation, which are key to the extended application of AGS technology. In the present review, the typical morphological structures of AGS are firstly summarized as well as the granulation model hypotheses, and then, we analyze the dominant microflora and their spatial distribution features. The influencing factors on particle structure stability are discussed thereafter on a macro and micro scale. Prospects and future research trends are also discussed based on the current study results for AGS technology.

Integrated review of resource recovery on aerobic granular sludge systems: Possibilities and challenges for the application of the biorefinery concept

Aerobic Granular Sludge (AGS) is a biological treatment technology that has been extensively studied in the last decade. The possibility of resource recovery has always been highlighted in these systems, but real-scale applications are still scarce. Therefore, this paper aimed to present a systematic review of resources recovery such as water, energy, chemicals, raw materials, and nutrients from AGS systems, also analyzing aspects of engineering and economic viability. In the solid phase, sludge application in agriculture is an interesting possibility. However, the biosolids' metal concentration (the granules have high adsorption capacity due to the high concentration of extracellular polymeric substances, EPS) may be an issue. Another possibility is the recovery of Polyhydroxyalkanoates (PHAs) and Alginate-like exopolymers (bio-ALE) in the solid phase, emphasizing the last one, which has already been made in some Wastewater Treatment Plants (WWTPs), named and patented as Kaumera® process. The Operational Expenditure (OPEX) can be reduced by 50% in the WWTP when recovery of ALE is made. The ALE recovery reduced sludge yield by up to 35%, less CO₂ emissions, and energy saving. Finally, the discharged sludge can also be evaluated to be used for energetic purposes via anaerobic digestion (AD) or combustion. However, the AD route has faced difficulties due to the low biodegradability of aerobic granules.

Resource recovery in aerobic granular sludge systems: is it feasible or still a long way to go?

Lately, wastewater treatment plants are much often being designed as wastewater-resource factories inserted in circular cities. Among biological treatment technologies, aerobic granular sludge (AGS), considered an evolution of activated sludge (AS), has received great attention regarding its resource recovery potential. This review presents the state-of-the-art concerning the influence of operational parameters on the recovery of alginate-like exopolysaccharides (ALE), tryptophan, phosphorus, and polyhydroxyalkanoates (PHA) from AGS systems. The carbon to nitrogen ratio was identified as a parameter that plays an important role for the optimal production of ALE, tryptophan, and PHA. The sludge retention time effect is more pronounced for the production of ALE and tryptophan. Additionally, salinity levels in the bioreactors can potentially be manipulated to increase ALE and phosphorus yields simultaneously. Some existing knowledge gaps in the scientific literature concerning the recovery of these resources from AGS were also identified. Regarding industrial applications, tryptophan has the longest way to go. On the other hand, ALE production/recovery could be considered the most mature process if we take into account that existing alternatives for phosphorus and PHA production/recovery are optimized for activated sludge rather than granular sludge. Consequently, to maintain the same effectiveness, these processes likely could not be applied to AGS without undergoing some modification. Therefore, investigating to what extent these adaptations are necessary and designing alternatives is essential.

The performance of aerobic granular sludge for simulated swine wastewater treatment and the removal mechanism of tetracycline

In this study, aerobic granular sludge (AGS) cultivated in a sequencing batch reactor (SBR) was employed to investigate its ability on the decontamination of tetracycline (TC) from swine wastewater (SWW). The removal mechanism of TC by AGS was studied. Results showed that the AGS process could effectively remove chemical oxygen demand (COD), ammonium nitrogen (NH_{+ 4}-N), total phosphorus (TP), and TC during operation. The removal of TC by AGS was mainly due to adsorption and biodegradation, and the contribution rate of biodegradation increased after AGS adaptation to TC. Twenty-two by-products were detected during biodegradation of TC, and accordingly the degradation pathway of TC was speculated. Compared to the control reactor, the microbe diversity in different levels of classification was richer in the TC fed reactor according to the LefSe analysis. The results revealed that enzymes that participated in the metabolic pathway of microbial biodegradation of polycyclic aromatic compounds were enriched and may have played a key role in the biodegradation of TC.

Biological nitrogen removal capability and pathways analysis of a novel low C/N ratio heterotrophic nitrifying and aerobic denitrifying bacterium (Bacillus thuringiensis strain WXN-23)

A novel heterotrophic nitrification and aerobic denitrification (HNAD) bacteria, identified as Bacillus thuringiensis strain WXN-23, was isolated from husk feed filtrate of a pig farm. It was the first report of Bacillus thuringiensis with the capability for HNAD and could adapt to the condition of low Carbon/Nitrogen (C/N) ratio. Nitrogen could be efficiently removed by the strain WXN-23 in simulated wastewater, be it in single or mixed form nitrogen sources. The nitrogen balance revealed that 63.5% of the initial nitrogen (5.32 mg) was lost in the form of N₂. The conditions for maximum total nitrogen (TN) removal efficiency (95.996%) were shaking speed of 126.89 r/min, a carbon C/N ratio of 5.91, the temperature of 32.81 °C, and a pH value of 8.17. The nitrification-denitrification metabolic pathway (NH₄⁺-N→NH₂OH→NO₂^--N→NO₃^--N→NO₂^--N→NO→N₂O→N₂) under aerobic conditions was determined on the basic of characteristic of N removal, N balance analysis, enzyme assay and functional genes amplification results. Strain WXN-23 was effective at wastewater treatment, with TN, NH₄⁺-N, NO₃^--N and NO₂^--N removal efficiencies of 82.12%, 86.74%, 90.74% and 100%, respectively.

Effect of calcinated pyrite on simultaneous ammonia, nitrate and phosphorus removal in the BAF system and the Fe2+ regulatory mechanisms: Electron transfer and biofilm properties

To efficiently remove nitrogen and phosphorus from secondary effluent with low values of COD/TN, a novel biological aerated filter (BAF) utilizing calcined pyrite with a large specific surface area (SSA) and pore diameter (PD) was designed to address this challenge. From the perspective of nutrients removal performance, and the corresponding effluent total nitrogen (TN) and PO₄^3--P in the calcined pyrite autotrophic denitrification (CPAD) process decreased from 40.21 to 1.07 mg/L to 1.22 and 0.14 mg/L, respectively. Furthermore, the nutrients removal kinetics analysis showed that the CPAD and pyrite autotrophic denitrification (PAD) processes could be fitted with Half-order and Zero-order reactions via kinetics analysis, respectively, indicating that the TN removal performance of CPAD processes was better than that of the PAD process. Moreover, CPAD combined with sulfur autotrophic denitrification (SAD) processes was fitted by First-order reaction, and the TN removal performance was further enhanced over the CPAD process. From the perspective of microregulation, Fe²⁺ production in the PAD and CPAD processes could accelerate the electron transfer rate by increasing electron transport system activity (ETSA) and reducing electrochemical impedance spectroscopy (EIS). Moreover, Fe²⁺ stimulated microbes to produce more proteins (PN) and C₁₀-HSL, which improved biofilm stability and interspecific communication processes. Notably, nitrifiers and autotrophic denitrifiers were simultaneously enriched via detection of high-throughput sequencing of 16 S rRNA genes, which verified the feasibility of simultaneous nitrification and autotrophic denitrification. Therefore, BAF with calcined pyrite and sulfur as composite fillers have a considerable advantage in nutrients removal.

Effective removal of odor substances using intimately coupled photocatalysis and biodegradation system prepared with the silane coupling agent (SCA)-enhanced TiO2 coating method

Intimately coupled photocatalysis and biodegradation (ICPB) combining photocatalysis with microbial degradation is an attractive wastewater treatment technology. However, when prepared in conventional ways, the supported-photocatalysts aggregate frequently, detach easily from carriers, and prohibit the colonization of microorganisms inside the carriers. To overcome these challenges, silane coupling agent (SCA)-enhanced TiO₂ coating method is developed in this study. The coupling agent γ-glycidoxypropyltrimethoxysilane (KH560) greatly enhanced the adhesion between photocatalysts and the carrier through ether and Ti-O-Si linkages. The dense TiO₂ layer was firmly adhered to the carrier outer surface, and the loading amount reached 351.8±8.2 mg/g, over ten times higher than using the powder sintering method (31.5±2.4 mg/g). In the ICPB system constructed with the KH560-enhanced TiO₂-supported polyurethane sponge (KH560-TiO₂-PU) carriers, removal efficiencies of two model odor substances, 2-methylisoborneol (2-MIB) and geosmin (GSM), reached 88.9±0.3% and 85.0±1.0% in 12 h at an initial concentration of 500 ng/L respectively, which were 17.7±0.6% and 19.4±0.4% greater than those of the ICPB system prepared with the powder sintering method. After 5 operating cycles, the novel ICPB system remained stable with high 2-MIB and GSM removal efficiencies, reaching 89.9±0.8% and 86.1±0.2% respectively after 12h, while TiO₂ peeling ratio was as low as 5.0±2.8%. Biofilms attached onto the carrier inner surface were resilient over the operating cycles with the increase of both richness and diversity of microbial communities. Analysis of biofilm microbial community and pollutant degradation pathways revealed the enhanced removal of 2-MIB and GSM in the novel ICPB system might be attributed to multiple factors. First, the alleviated aggregation and increased adhesion of photocatalysts onto carriers improved the overall photocatalysis efficiency. Second, biofilm inside of the carrier was protected and the microbial activity was well remained. Third, photocatalytic intermediate products were efficiently biodegraded by the enriched functional microbial populations, such as Thauera and Flavobacterium, with little concern of excessive oxidation. Collectively, this research provides a new technological solution that synergizes photocatalysis and biodegradation for effective removal of odorous substances in polluted natural water.

Evaluation of the production of alginate-like exopolysaccharides (ALE) and tryptophan in aerobic granular sludge systems

The engineering and microbiological aspects involved in the production of alginate-like exopolysaccharides (ALE) and tryptophan (TRY) in aerobic granular sludge systems were evaluated. The inclusion of short anoxic phase (A/O/A cycle-anaerobic, oxic, and anoxic phase) and the control of sludge retention time (SRT ≈ 10 days) proved to be an important strategy to increase the content of these bioproducts in granules. The substrate concentration also has a relevant impact on the production of ALE and TRY. The results of the microbiological analysis showed that slow-growing heterotrophic microbial groups (i.e., PAOs and GAOs) might be associated with the production of ALE, and the EPS-producing fermentative bacteria might be associated with the TRY production. The preliminary economic evaluation indicated the potential of ALE recovery in AGS systems in decreasing the OPEX (operational expenditure) of the treatment, especially for larger sewage treatment plants or industrial wastewaters with a high organic load.

Response of an aerobic granular and conventional flocculated reactors against changing feed composition from simple composition to more complex

This research evaluated the effect of changing feed composition on the performances of a conventional activated sludge (CAS) and an aerobic granular sludge (AGS) reactor operated simultaneously. Both reactors were initially fed with 100% synthetic feed. In a stepwise manner, the feed composition was slowly changed to real primary effluent collected from a local wastewater treatment plant. After an initial stabilization period, both reactors could achieve more than 90% NH₄⁺-N removal. However, PO₄^3--P removal eventually reached to a maximum of 92% in the AGS and 88% in the CAS. COD removal in both reactors was least affected, with the lowest percent removal of 81 ± 3% achieved in AGS and 62 ± 4% in CAS respectively when fed with 100% real wastewater. Despite granule breakage the AGS reactor was able to remove the pollutants (COD, N, P). The abundance of Candidatus Accumulibacter, a polyphosphate accumulating organism, in the AGS system increased over the operational phases: II (6.2%), III (10.32%), and IV (11.9%). While in CAS, it increased from phase I to phase II (12.6%), but decreased in phase III to 9.9%. Genus-based classification revealed a successive increase in the relative abundance of Nitrospira to 11.05% during Phase III and 10.3% during Phase IV in the AGS. In contrast with its presence in the CAS, which was, 3.4% during Phase III and 9.5% during Phase IV.

Enhancement of PPCPs removal by shaped microbial community of aerobic granular sludge under condition of low C/N ratio influent

The frequent occurrence of pharmaceuticals and personal care products (PPCPs) in domestic wastewater has caused great concern. In this study, the removal of two typical pharmaceuticals (Roxithromycin, ROX; Sulfamethoxazole, SMZ) in aerobic granular sludge (AGS) reactors was investigated under condition of different C/N (carbon to nitrogen) ratios. Results showed that higher removal efficiencies of ROX and SMZ (95.2 % and 92.9 %) were achieved in the AGS reactor fed with low C/N influent. Batch experiments further revealed that the removal of ROX was influenced by the adsorption ability of the AGS while SMZ removal was mainly enhanced by biodegradation process. Analysis of extracellular polymeric substances (EPS) showed that the humic acid-like substances were enriched under low C/N condition, which was in accordance with dynamic change of microbial community. The microbes, like Thauera spp. and Xanthomonadaceae, were highly enriched in the reactor with high nitrogen loading rate and functioned as refractory organics degrader. Overall, the AGS process could achieve enhanced pharmaceuticals removal performance by the regulation of microbial community under low C/N influent, which provides insights into a feasible solution for simultaneous removal of nitrogen and trace organic pollutants in AGS reactor.

Effect of dissolved oxygen on simultaneous removal of ammonia, nitrate and phosphorus via biological aerated filter with sulfur and pyrite as composite fillers

A biological aerated filter (BAF) with sulfur and pyrite as fillers were structured to simultaneously remove NH₄⁺-N, NO₃^--N and PO₄^3--P from secondary effluent. When dissolved oxygen (DO) was 1.2-1.5 mg/L, effluent concentration of NH₄⁺-N, NO₃^--N and PO₄^3--P were below 0.65, 0.47 and 0.18 mg/L, respectively. Meanwhile, Fe²⁺ production via decomposing pyrite could improve autotrophic denitrification performance. Besides, sulfur and pyrite autotrophic denitrification process (PAD and SAD) aligned with the Zero-order and First-order kinetics models, respectively, indicating that the sulfur had excellent capability of providing electron. Moreover, there was a positive correlation between the nitrogen removal performance and protein-like substances in extracellular polymeric substances. Bacterial community analysis suggested the nitrifiers and autotrophic denitrifiers were simultaneously enriched. Principal component analysis indicated that the DO concentration and type of electron donors impacted bacterial community. Consequently, BAF combined with PAD and SAD processes provides an alternative method to remove nutrients.

Insights into the effects of carbon source on sequencing batch reactors: Performance, quorum sensing and microbial community

Effects of carbon source on the performance, quorum sensing (QS) and microbial communities in the sequencing batch reactors were investigated in this work. Among the chosen carbon source, sodium acetate (R1), glucose (R2), starch (R3) and Tween 80 (R4), sodium acetate was the best carbon source for nutrient removal, while starch was favorable for inducing the sludge bulking, and Tween 80 was beneficial to the production of extracellular polymeric substances (EPS) and proliferation of Microthrix parvicella. Additionally, the R² value of linear correlation between sludge settleability and particle size in four reactors followed an order of R1 > R2 > R3 > R4. Moreover, Person correlation analysis showed that various significant correlations were observed in reactors fed with different carbon sources and the QS mainly mediated the production and component of EPS. High-throughput sequencing analysis revealed that the carbon source affected microbial communities and the Canonical correspondence analysis results indicated that QS related to microbial communities. It was inferred that the interactions between microbial communities and QS affected system performance.

AHL-mediated quorum sensing regulates the variations of microbial community and sludge properties of aerobic granular sludge under low organic loading

Aerobic granular sludge (AGS) is promising in wastewater treatment. However, the formation and existence of AGS under low organic loading rate (OLR) is still not fully understood due to a knowledge gap in the variations and correlations of N-acyl-homoserine lactones (AHLs), the microbial community, extracellular polymeric substances (EPS) and other physiochemical granule properties. This study comprehensively investigated the AHL-mediated quorum sensing (QS) and microbial community characters in the AGS fed with ammonium-rich wastewater under a low OLR of 0.15 kg COD (m³ d)^-1. The results showed that the AGS appeared within 90 days, and the size of mature granules was over 700 μm with strong settleability and ammonium removal performance. More tightly-bound extracellular polysaccharide and tightly-bound extracelluar protein were produced in the larger AGS. C10-HSL and C12-HSL gradually became dominant in sludge, and short-chain AHLs dominated in water. EPS producers and autotrophic nitrifiers were successfully retained in the AGS under low OLR. AHL-mediated QS utilized C10-HSL, C12-HSL and 3OC6-HSL as the critical AHLs to regulate the TB-EPS in aerobic granulation, and autotrophic nitrifiers may perform interspecific communication with C10-HSL. The correlations of bacterial genera with AGS properties and AHLs were complex due to the dynamic fluctuations of microbial composition and other variable factors in the mixed-culture system. These findings confirmed the participation of AHL-mediated QS in the regulation of microbial community characters and AGS properties under low OLR, which may provide guidance for the operation of AGS systems under low OLR from a microbiological viewpoint.

Enhanced aerobic granulation by inoculating dewatered activated sludge under short settling time in a sequencing batch reactor

The effect of dewatered activated sludge on aerobic granulation was investigated in a sequencing batch reactor (SBR) under short settling time. The results showed that dewatered sludge accelerated aerobic granulation and the granulation was completed within 5 days. On day 5, the aerobic granules were regular, compact, fast-settling and high granular strength and possessed excellent removal performance of carbon and nitrogen. The change trend of extracellular polymeric substances (EPS) was basically consistent with granular strength and granulation rate, indicating that EPS in granules played a vital function for granulation. Microbial community succession was investigated by pyrosequencing. In 5 days, microbial diversity was reduced and certain strains were rapidly enriched in the granules to become dominant species, serving on a crucial role in rapid granulation and pollutant removal as they could secrete excess EPS and possess the excellentability removing carbon and nitrogen pollutants.

Effects of biomass pyrolysis derived wood vinegar on microbial activity and communities of activated sludge

The effects of wood vinegar (WVG) on microbial activity and communities of activated sludge were investigated in a sequencing batch reactor (SBR) process. Results showed that the optimal WVG concentration was 4 μL/L when the pollutants removal efficiency and microbial activity were promoted by a WVG dilution factor of 1000. WVG could reduce the increase in microbial species richness, which led to a more notable variety of microbial species diversity. The enhanced microbial activity and communities were addressed to the promotion of 7 main classes of microbes in Proteobacteria, Bacteroidetes, Acidobacteria, and Nitrospirae phyla. The growth of ammonia-oxidizing bacteria (AOB), nitrite-oxidizing bacteria (NOB), and main genera of denitrifying bacteria (DNB), phosphorus-accumulating organisms (PAOs), and glycogen-accumulating organisms (GAOs) could be promoted by WVG, which improved the sewage treatment effectiveness in a SBR.

Effect of nitrogen deficiency on the stability of aerobic granular sludge

To assess the stability of aerobic granular sludge (AGS) under nitrogen deficiency conditions, three sequence batch reactors were operated with chemical oxygen demand (COD) to nitrogen (N) ratios of 100/5, 100/2.5, and 100/2, while COD concentration was kept consistent. AGS variations in its physicochemical characteristics, microbial community, and treatment performance were investigated. The results indicated that good treatment performance and stable AGS were achieved under nitrogen deficiency. Extracellular polymeric substances (EPS) regulating mechanism preserved AGS stability under nitrogen deficiency, especially through increased secretion of polysaccharide. In addition, members of the Anaerolineaceae were the major filamentous bacteria, which are strictly anaerobic organism, providing a possible explanation to the lack of filamentous bacteria outgrowth under N deficient condition. Insights from this study could help lower chemical costs in AGS applications for specific industrial wastewater treatments.