Enhanced biogas production from municipal solid waste via co-digestion with sewage sludge and metabolic pathway analysis

Strategies of managing solid waste and energy recovery for a developing country - A review

Solid waste is considered one of the major pollutants of both water and surface worldwide. The growing global population, urban expansion, and industrial growth are the main reasons for solid waste generation. This has become a major challenge with both regional and worldwide consequences. The yearly generation of municipal solid wastes around the world is 2.01 BT (billion tons) among which about 33 % are not ecologically handled. To address this, proper solid waste management, especially recycling waste products, is crucial to achieving sustainability. High-income countries are able to recycle 51 % of their waste, while low-income countries only recycle 16 % of their waste. Inadequate solid waste management practices can only compound environmental and social problems. To handle these issues thermochemical and biochemical methods are used to convert solid waste to energy. Thermochemical method is suitable for developing countries though it is energy extensive. This review provides a detailed analysis of developing countries' solid waste management and energy recovery. It explores energy recovery technologies, including thermochemical and biochemical waste conversion processes.

Life Cycle Assessment of sewage sludge mono-digestion and co-digestion with the organic fraction of municipal solid waste at a wastewater treatment plant

Wastewater treatment plants (WWTPs) aim to increase energy independence by intensifying biogas production. The study involved Life Cycle Assessment (LCA) comparing sewage sludge (SS) anaerobic co-digestion (AcD) with the organic fraction of municipal solid waste (OFMSW) at WWTP against SS anaerobic mono-digestion (AD). The LCA was based on the authors' research showing that methane production related to wet mass in AcD was higher than in AD by 86.4, 225.8, and 354.3 % for SS:OFMSW mixing ratios of 75:25, 50:50, and 25:75, respectively. The LCA was conducted for 1 kWh of biogas energy produced at a WWTP and included two subsystems: energy production (AD/AcD and CHP) and associated digestate management (drying, incineration with energy reuse, residual landfilling). CML-IA baseline 2013 and Recipe 2016 Midpoint (H) LCIA methodologies indicated the environmental impacts on abiotic depletion - fossil fuels (fossil resource scarcity), global warming, human toxicity (non-carcinogenic), freshwater, and marine aquatic ecotoxicity. AD of SS in all categories was characterized by the highest impact. The impact decreased with an increase in the OFMSW rate. Both methodologies showed a significant impact of AD and AcD on global warming, which indicated the need for the determination of the carbon footprint (CF) of 1kWh biogas energy production (gCO2 kWh-1) at WWTP, using IPCC 2021 GWP100 (incl. CO2 uptake). The CF was the highest for biogas energy production in SS AD (1509 gCO2 kWh-1) and it decreased with the increase of OFMSW content in AcD (872-481 gCO2 kWh-1). This was also observed for the management of associated digestate. CF changed from 1508 gCO2 kWh-1 for SS AD to 396 gCO2 kWh-1 for SS: OFMSW mixing ratio of 25: 75 in AcD. The environmental burdens associated with biogas energy production and digestate management were equally significant. Finally, the formula for economic and ecological comparison of SS AD and AcD with OFMSW was proposed.

Top-down and bottom-up microbiome engineering approaches to enable biomanufacturing from waste biomass

Growing environmental concerns and the need to adopt a circular economy have highlighted the importance of waste valorization for resource recovery. Microbial consortia-enabled biotechnologies have made significant developments in the biomanufacturing of valuable resources from waste biomass that serve as suitable alternatives to petrochemical-derived products. These microbial consortia-based processes are designed following a top-down or bottom-up engineering approach. The top-down approach is a classical method that uses environmental variables to selectively steer an existing microbial consortium to achieve a target function. While high-throughput sequencing has enabled microbial community characterization, the major challenge is to disentangle complex microbial interactions and manipulate the structure and function accordingly. The bottom-up approach uses prior knowledge of the metabolic pathway and possible interactions among consortium partners to design and engineer synthetic microbial consortia. This strategy offers some control over the composition and function of the consortium for targeted bioprocesses, but challenges remain in optimal assembly methods and long-term stability. In this review, we present the recent advancements, challenges, and opportunities for further improvement using top-down and bottom-up approaches for microbiome engineering. As the bottom-up approach is relatively a new concept for waste valorization, this review explores the assembly and design of synthetic microbial consortia, ecological engineering principles to optimize microbial consortia, and metabolic engineering approaches for efficient conversion. Integration of top-down and bottom-up approaches along with developments in metabolic modeling to predict and optimize consortia function are also highlighted.

ONE-SENTENCE SUMMARY

This review highlights the microbial consortia-driven waste valorization for biomanufacturing through top-down and bottom-up design approaches and describes strategies, tools, and unexplored opportunities to optimize the design and stability of such consortia.

Anaerobic Co-digestion of sewage sludge and organic fraction of municipal solid waste: Focus on mix ratio optimization and synergistic effects

The utilization of municipal solid waste (MSW) and sewage sludge (SS) as a source of renewable energy is crucial in achieving sustainable and integrated MSW management. SS and organic fraction of municipal solid waste (OFMSW) can be anaerobically digested to produce methane for energy. However, anaerobic digestion of specific substrates is challenging with respect to substrate characteristics. The problem of mono-digestion can be mitigated by co-digestion of these two major organic wastes because of their complementary characteristics. Moreover, there is a lack of studies on optimization of different mix ratios of organic fraction of municipal solid waste (OFMSW) and sewage sludge (SS) based on total solids (TS). The study aims to optimize the mix ratio for anaerobic co-digestion of OFMSW and SS. The study further elucidates synergistic effects associated with the co-digestion process. Different mix ratios of SS and OFMSW (0:100, 20:80, 40:60, 60:40, 80:20, 100:0) at 5, 7.5 and 10% TS were assessed for biomethane potential assessment. The results showed that with an increase in SS in the mix ratio feed the methane yield increased by 91% and 50% as compared to mono digestion of sewage sludge and OFMSW respectively at TS 7.5%. Based on the kinetic analysis, it was observed that the lag phase reduced for 60:40 mix ratio leading to higher rate of biodegradation. Positive synergistic effects were observed for 40:60, 60:40 and 80:20 mix ratio of SS:OFMSW based on co-digestion impact factor value. Response surface modelling was used to get the optimized mix ratio and TS %. The optimum mix ratio with the highest methane yield (388 ml/gVS added) was 70:30 (SS: OFMSW) at TS 7.5% with a desirability value of 0.98. These findings demonstrate that co-digesting SS and OFMSW is a preferable alternative for harnessing renewable energy and managing organic waste in a sustainable manner.

Effects of landfill food waste diversion: a focus on microbial populations and methane generation

The early stages of municipal solid waste degradation in landfills are complex harmonies of physical, biological, and chemical interactions that all work in concert to degrade trash into smaller and more stable materials. While many approaches have been taken to understand parts of this process, this new work attempted to simulate the early stages of landfills in controlled laboratory environments while observing the impacts of food waste content at different concentrations. This was completed by operating landfill lysimeters in a laboratory for approximately 1000 days, simulating landfill interior conditions while measuring the gas and liquid byproducts to study the impact of food waste presence in these environments. Metagenomic analysis after the experiment identified over 18,000 individual species and allowed comparison with past studies while also surveying microorganisms present in landfills. Similar populations found in past studies suggested the current experiments successfully replicated landfill conditions. While food waste diversion had a discernable impact on gas production, it did not show a clear and consistent impact on the microbiomes identified in this study.

Evaluation of different composting systems on an industrial scale as a contribution to the circular economy and its impact on human health

Due to the production of volatile organic compounds (VOCs), large-scale composting can cause air pollution and occupational health issues. Due to this, it is necessary to determine if the amount generated poses a health risk to plant workers, which can be a starting point for those in charge of composting plant facilities. As a result, the goal of this work is to conduct a thorough analysis of both the physicochemical features and the VOC generation of three large-scale systems. For ten weeks, the three different composting plants were monitored weekly, and VOC identification and quantification were performed using GC-MS gas chromatography. It has been observed that the biggest risk related with VOC formation occurs between the fourth and fifth weeks, when microbial activity is at its peak. Similarly, it has been demonstrated that xylenes and toluene are the ones that are produced in the greatest quantity. Finally, after ten weeks of processing, it was discovered that the material obtained complies with the regulations for the sale of an amendment.Implications: The evaluation and monitoring of the composting processes at an industrial scale is very important, due to the implications they bring. VOCs are produced by the operation of composting facilities with substantial amounts of solid waste, such as the companies in this study. These may pose a health risk to those working in the plants; thus, it is critical to understand where the VOCs occur in the process in order to maintain workers' occupational health measures. This form of evaluation is rare or nonexistent in Colombia, which is why conducting this type of study is critical, as it will provide crucial input into determining when the highest levels of VOC generation occur. These are the ones that may pose a risk at some point, but with proper occupational safety planning, said risk may be avoided. This work has evaluated three composting systems, with different types of waste and mixtures. According to reports, while composting systems continue to produce VOCs and their generation is unavoidable, the potential risk exists only within the plant. These findings can pave the way for the implementation of public policies that will improve the design and operation of composting plants. There is no specific legislation in Colombia for the design and execution of this sort of technology, which allows the use of organic waste.

Impact of municipal solid waste landfill leachate on biogas production rate

Landfills/open dump sites are the final disposal facilities for municipal solid waste (MSW). These sites undergo continuous process of biochemical reactions and anaerobic degradation, which make them prone to generation of landfill gas (LFG) and leachate. Worldwide, the quantitative and qualitative assessment for leachate treatment and management has been a growing concern. The present study investigated the physico-chemical characteristics and heavy metal parameters for fresh, 3-month, 6-month and 3-year old landfill leachate samples. The total dissolved solids (13280 mg/l), alkalinity (13000 mg/l), chemical oxygen demand (42000 mg/l) and total organic carbon (16500 mg/l) was found to be maximum in 3-year old leachate sample. While, the 3 and 6-month old leachate samples had maximum heavy metal concentration. The attempt was also made to identify the key parameters responsible to enhance biogas production yield from different ages of MSW. The substrate combinations of MSW and 3-year old leachate samples was prepared at varying proportion. The study was performed in three cycles and the volume of leachate diffused in each cycle was kept constant. The control samples with no leachate diffusion was also prepared to compare the percentage increase in biogas production rate. It was found that the cumulative methane (CH₄) production from fresh (358 ml/g) and 3-month old MSW (273 ml/g) was maximum, and the overall percentage increase was 43% and 32%. It was also conclusive that the excess leachate diffusion of >15 ml results in low calcination behaviour and CH₄ production rate. The response surface methodology was used to correlate and validate independent input variables (volatile solids, C/N ratio and leachate concentration) responsible for maximum CH₄ yield.

Current and prognostic overview on the strategic exploitation of anaerobic digestion and digestate: A review

The depletion of fossil fuels and increasing demand for energy are encountered by generating renewable biogas. Anaerobic digestion (AD) produces not only biogas, also other value-added products from the digestate using various organic, municipal and industrial wastes which have several benefits like remediating waste, reduces greenhouse gas emissions, renewable energy generation and securing socio-economic status of bio-based industries. This review work critically analyzes the biorefinery approaches on AD process for the production of biogas and digestate, and their direct and indirect utilization. The left-out residue obtained from AD is called 'digestate' which enriched with organic matter, nitrogen, heavy metals and other valuable micronutrients. However, the direct disposal of digestate to the land as fertilizer/landfills creates various environmental issues. Keeping this view, the digestate should be upgraded or transformed into high valued products such as biofertilizer, pyrochar, biodiesel, syngas and soil conditioner that can aid to enrich the soil nutrients and ensures the safe environment as well. In this context, the present review focused to illustrate the current techniques and different strategic exploitations on AD proper management of digestate products for storage and further applications. Such a technology transfer provides a proven strategic mechanism towards the enhancement of the sustainability of bio-based industries, attaining the energy demand, safest waste management, protection of environment and reduces the socio-economic issues of the industrial sector.

Utilization of nanoparticles for biogas production focusing on process stability and effluent quality

Abstract

One of the most important techniques for converting complex organic waste into renewable energy in the form of biogas and effluent is anaerobic digestion. Several issues have been raised related to the effectiveness of the anaerobic digestion process in recent years. Hence nanoparticles (NPs) have been used widely in anaerobic digestion process for converting organic wastes into useful biogas and effluent in an effective way. This review addresses the knowledge gaps and summarizes recent researchers’ findings concentrating on the stability and effluent quality of the cattle manure anaerobic digestion process using single and combinations nanoparticle. In summary, the utilization of NPs have beneficial effects on CH4 production, process optimization, and effluent quality. Their function, as key nutrient providers, aid in the synthesis of key enzymes and co-enzymes, and thus stimulate anaerobic microorganism activities when present at an optimum concentration (e.g., Fe NPs 100 mg/L; Ni NPs 2 mg/L; Co NPs 1 mg/L). Furthermore, utilizing Fe NPs at concentrations higher than 100 mg/L is more effective at reducing H2S production than increasing CH4, whereas Ni NPs and Co NPs at concentrations greater than 2 mg/L and 1 mg/L, respectively, reduce CH4 production. Effluent with Fe and Ni NPs showed stronger fertilizer values more than Co NPs. Fe/Ni/Co NP combinations are more efficient in enhancing CH4 production than single NPs. Therefore, it is possible to utilize NPs combinations as additives to improve the effectiveness of anaerobic digestion.

Article highlights

Recent advances in biogas production using Agro-Industrial Waste: A comprehensive review outlook of Techno-Economic analysis

Agrowaste sources can be utilized to produce biogas by anaerobic digestion reaction. Fossil fuels have damaged the environment, while the biogas rectifies the issues related to the environment and climate change problems. Techno-economic analysis of biogas production is followed by nutrient recycling, reducing the greenhouse gas level, biorefinery purpose, and global warming effect. In addition, biogas production is mediated by different metabolic reactions, the usage of different microorganisms, purification process, upgrading process and removal of CO₂ from the gas mixture techniques. This review focuses on pre-treatment, usage of waste, production methods and application besides summarizing recent advancements in biogas production. Economical, technical, environmental properties and factors affecting biogas production as well as the future perspective of bioenergy are highlighted in the review. Among all agro-industrial wastes, sugarcane straw produced 94% of the biogas. In the future, to overcome all the problems related to biogas production and modify the production process.

Microbial shifts in anaerobic digestion towards phenol inhibition with and without hydrochar as revealed by metagenomic binning

The inhibition of anaerobic digestion (AD) by phenolic compounds is an obstacle to the efficient treatment of organic wastes. Besides, hydrochar produced from hydrothermal liquefaction of biomass has been previously reported to enhance AD. The present study aimed to provide deep insights into the microbial shifts at the species level to phenol (0-1.5 g/L) inhibition in AD of glucose with and without hydrochar by metagenomic analysis. Phenol higher than 1 g/L had severe inhibition on both the amount and rate of methane production in control experiments, while hydrochar significantly enhanced methane production, especially at phenol 1 g/L and 1.5 g/L. From metagenomic analysis, 78 High-quality metagenome-assembled genomes (MAGs) were obtained. Principal components analysis showed that the microbial communities were shifted when phenol concentration was increased to 0.25 g/L in control experiments and 1 g/L in hydrochar experiments. In control experiments, no MAGs involved in acetogenesis were found at phenol 1.5 g/L and Methanothrix sp.FDU243 was also inhibited. However, hydrochar resulted in the maintenance of several MAGs involved in acetogenesis and Methanothrix sp.FDU243 even at phenol 1.5 g/L, ensuring a persistent methane production. Furthermore, 6 phenol-degrading MAGs were identified, shifting dependent on the concentrations of phenol and the presence of hydrochar.

Comprehensively understanding metabolic pathways of protein during the anaerobic digestion of waste activated sludge

The metabolic pathways of protein during anaerobic digestion (AD) of waste activated sludge (WAS) were comprehensively investigated. Results showed that 100 kinds of peptidases were involved in the hydrolysis and acidogenesis processes. Serine endopeptidases (EC 3.4.21.53) and serine-type carboxypeptidases (EC 3.4.16.4) were the key enzymes of endopeptidases and exopeptidases, respectively. The pathways of ko00250 (alanine, aspartate and glutamate metabolism), ko00260 (glycine, serine and threonine metabolism), ko00270 (cysteine and methionine metabolism), ko00280 (valine, leucine and isoleucine degradation), ko00360 (phenylalanine metabolism) and ko00310 (lysine degradation) were the critical metabolic pathways of amino acids during AD of WAS, since they have complete pathways from amino acids to vital intermediates (pyruvate or acetyl-CoA). l-aspartate, l-alanine, threonine, glycine, serine, l-cysteine were the intermediate products in the conversion of protein to pyruvate, while l-leucine, l-isoleucine, phenylalanine, lysine could be directly metabolized to acetyl-CoA. Dechloromonas and Thauera played major roles in the crucial metabolic pathways of amino acids (ko00250, ko00260, ko00280 and ko00270). These important discoveries could provide a new biological perspective for improving AD performance.

Biogeochemical profiling and taxonomic characterization of municipal landfill site by metagenomic sequencing

Most of the discarded waste material paves their way to the utmost common dumping grounds, Landfills. Despite their widespread use, the landfill microbiomes are still not well characterized. Metagenomics approach provides insight into the identification of operational parameters influencing the microbiome composition and their biodegradation competencies. The metagenomic DNA was prepared to explore taxonomical community structure, phylogenetic relationships, and functional profile at the same time. A total of 100,021,052 high-quality filtered reads were acquired with a GC abundance of 62.59%. Taxonomical abundance revealed the dominance of phylum Proteobacteria and genes involved in biomolecules metabolism, aromatic compound degradation, stress tolerance, xenobiotic biodegradation etc. were revealed functionally. The intricate heterogeneous environment of landfill revealed well flourished biogeochemical metabolic profiles including nitrogen metabolism. This is the first study for the generated metagenome of Ghazipur landfill and the obtained results propose that microbial communities in landfill settings are far more intricate than expected. It remain mostly unexplored which demands the usage of multiple platforms for a better understanding.

Anaerobic digestion of sugarcane bagasse for biogas production and digestate valorization

Sugarcane bagasse is an abundantly available agricultural waste having high potential that is still underutilized and mostly burnt as fuel. There are various processes available for bagasse utilization in improved ways and one such process is anaerobic digestion (AD) of bagasse for biogas production. The complex structure of biomass is recalcitrant to degradation and is a major hindrance for the anaerobic digestion, so different pretreatment methods are applied to deconstruct the bagasse for microbial digestion. In this review, different processes developed for the pretreatment of bagasse and their effect on biogas production have been extensively covered. Moreover, combination of pretreatment methods, co-digestion of bagasse with other waste (nitrogen rich or easily digestible) for enhanced biogas production and biomethane generation along with other value-added products has also been reviewed. The digestate contains a significant amount of organics with partial recovery of energy and products and is generated in huge amount that further creates disposal problem. Therefore, integration of digestate valorization with AD through gasification, pyrolysis, hydrothermal carbonization and use of microalgae for maximum recovery of energy and value-added products have also been evaluated. Thus, this review highlights major emerging area of research for improvement in bagasse based processes for enhanced biogas production along with digestate valorization to make the overall process economical and sustainable.

The Potential of the Co-Recycling of Secondary Biodegradable Household Resources Including Wild Plants to Close Nutrient and Carbon Cycles in Agriculture in Germany

The aim of this study is to evaluate the potential for conserving natural resources (fossil resources, mineral fertilizer, fertile soil and biodiversity) with alternative circular concepts in order to contribute to the achievement of global sustainability goals. This study examines the potential contribution of substituting conventional products for three alternative circular economy concepts. This includes the household resources black water, kitchen and green waste for the production of design fertilizer, plant charcoal, biopolymers (concept 1) and biogas (concept 2), as well as the combination of household kitchen waste with wild plants for the production of biogas (concept 3). For evaluation, literature values were combined with analyzed parameters of input streams and biogas tests. The production and consumption values determined all relate to the functional unit of a person and year in Germany. Concept 1 has the highest potential for substitution in terms of the amount of recycled products. Co-recycling of organic household waste can account for 20% of NPK (nitrogen, phosphorus, potassium) mineral fertilizer, 19% of plastic consumption and 11% as a soil improving measure in soils in agriculture that are at risk of degradation. Concept 2 has the potential to contribute 12% of the final energy consumption in private households, which is an alternative solution regarding energy recovery due to the extensive practical experience. The joint recycling generates 141 kWh without, and 174 kWh with, fermentable green waste. If 75%, by weight, of fresh wild plants are added to the kitchen waste in concept 3, a wild plant area of 5 m2 is required, which could replace 41% of the biogas corn area, which is concept 3. This mix generates 193 kWh with the potential to reach 78% of corn energy production. The share of wild plants in kitchen waste of 50 or 25% by weight has the potential to achieve 115 or 104% of the corn energy yield, which is a promising concept for rural areas regarding energy recovery from an ecological point of view. The results show a considerable contribution potential of household resources in alternative cycle concepts to increase resource efficiency, and indirectly to diversify the agricultural landscape.

Feasibility Study of Anaerobic Codigestion of Municipal Organic Waste in Moderately Pressurized Digesters: A Case for the Russian Federation

Anaerobic digestion (AD) is a promising option to obtain renewable energy in the form of biogas and reduce the anthropogenic impact on the environment. In recent years there has been increasing interest in using pressurized digesters to improve the quality of biogas. However, maintaining high overpressure increases the requirements for the explosion safety of digesters. Consequently, there are natural limitations in the available technologies and facilities suitable for full-scale operation. In this work, we aimed to evaluate the possibility of using overpressure in the digester to improve the efficiency of codigestion of common municipal organic waste–sewage sludge and the organic fraction of municipal solid waste. Three levels of moderate excess pressure (100, 150 and 200 kPa) were used to meet requirements of existing block-modular anaerobic bioreactors based on railway tanks, which are widely utilized for AD in the Russian Federation. There was no significant change in methane content in biogas (65% ± 3%) at different values of overpressure, hydraulic retention time (HRT) and organic loading rate (OLR). The maximum methane and energy production rates (2.365 L/(L·day) and 94.27 kJ/(L·day), respectively) were obtained at an overpressure of 200 kPa, HRT of 5 days and OLR of 14 kg VS/(m3·day). However, the maximum methane yield (202.44 mL/g VS), energy yield (8.07 kJ/g VS) and volatile solids (VS) removal (63.21%) were recorded at an overpressure of 150 kPa, HRT of 7 days and OLR of 10.4 kg VS/(m3·day). The pressured conditions showed better performance in terms of AD stability at high OLRs.

Study on anaerobic co-digestion of municipal sewage sludge and fruit and vegetable wastes: Methane production, microbial community and three-dimension fluorescence excitation-emission matrix analysis

Constantly increased sewage sludge (SS) and fruit and vegetable wastes (FVW) are becoming the major organic solid wastes in human society. Thus, anaerobic digestion is employed as a low carbon energy strategy to reduce their environmental pollution risk. Anaerobic co-digestion system was developed based on the carbon to nitrogen ratio strategy. Results showed that the daily biogas production was higher in co-digester, and the volumetric biogas production rate (VBPR) significantly enhanced for 1.3 ∼ 3 folds, and the highest VBPR was 2.04 L/L • day with optimal OLR of 2.083 Kg L^-1 d^-1. Analytic results indicated that co-digestion could improve the biodegradable of feedstocks, which transforming to more VFAs and biogas. Compared with mono SS digester, mixed substrates relieved ammonia nitrogen inhibition and enhanced the hydrolytic acidification and methanogenesis. Meanwhile, the excessive humification of organics was suppressed. This study supported the concepts of improving carbon recovery from SS and FVW.

Assessment of the Possibilities for the Use of Selected Waste in Terms of Biogas Yield and Further Use of Its Digestate in Agriculture

The utilization of municipal waste and sewage sludge as a source of energy is technically very difficult due to high variability of their physical and chemical properties. The aim of this study was to evaluate the efficiency of the conversion of biomass contained in the whitewater fraction of municipal waste and sewage sludge by means of methanogenesis. The second objective was to assess the chemical composition of the digestate in the context of its use for fertilizer purposes. The whitewater fraction of municipal waste and sewage sludge was subjected to methanogenesis under static experimental conditions, according to DIM DIN 38414 methodology. The methanogenesis of concentrated substrates used in agricultural biogas plants was taken as a reference to evaluate the efficiency of the process. The organic fraction of the municipal waste was characterized by approximately 30% lower value of the soluble COD, with a comparable level of total COD compared to other materials. The total biogas yield, i.e., 404 dm³ per 1 kg of dry weight of the batch, was measured in the facility with sewage sludge. In COD value, this is 0.232 dm³·g O₂ COD. In the case of corn, these values were, respectively, 324 dm³ and 0.193, and for the organic sub-sieve fraction of municipal waste, 287 dm³·kg⁻¹ dw or 0.178 dm³·g O₂ COD, respectively. The type of fermented material did not affect the intensity of biogas production. The maximum level of biogas production occurred between the 13th and 15th day of the process. The digestate obtained in the process of methanogenesis of corn silage and the organic fraction of municipal waste was characterized by good parameters in terms of possible use for fertilization purposes.

Extracellular hydrolytic potential drives microbiome shifts during anaerobic co-digestion of sewage sludge and food waste

Bacterial community structure and dynamics in anaerobic digesters are primarily influenced by feedstock composition. It is therefore important to unveil microbial traits that explain microbiome variations in response to substrate changes. Here, gene and genome-centric metagenomics were used to examine microbiome dynamics in four laboratory-scale reactors, in which sewage sludge was co-digested with increasing amounts of food waste. A co-occurrence network revealed microbiome shifts in response to changes in substrate composition and concentration. Food waste concentration correlated with extracellular enzymes and metagenome-assembled genomes (MAGs) involved in the degradation of complex carbohydrates commonly found in fruits and plant cell walls as well as with the abundance of hydrolytic MAGs. A key role was attributed to Proteiniphillum for being the only bacteria that encoded the complete pectin degradation pathway. These results suggest that changes of feedstock composition establish new microbial niches for bacteria with the capacity to degrade newly added substrates.

Enhancing biogas production of anaerobic co-digestion of industrial waste and municipal sewage sludge with mechanical, chemical, thermal, and hybrid pretreatment

This study presents the effect of mechanical, chemical, thermal, and hybrid pretreatment on anaerobic digestion of fruit-juice industrial waste (FW) co-digested with municipal sewage sludge (MSS). The pretreatment of the substrates with ultrasonication, microwave, weak alkali-acid caused an increase in cumulative biogas production of approximately 20.9, 14.9, 8.1, and 5.2%, respectively. Beside this, thermal and strong acid-alkali pretreatment reduced biogas production. The highest cumulative biogas and methane yield was increased with hybrid pretreatment which contains ultrasonication (US) and alkali (AL) pretreatment by 36% and 49%, respectively. Also, compared to untreated mixture, the soluble COD, carbohydrate, and protein removal efficiencies were increased from 42.6% to 65.6%, 65.1% to 86.6%, and 17.3% to 62.4%, respectively for US-AL pretreatment. The kinetic parameters of cumulative biogas production for the selected reactors were further estimated with Monod, Cone, and Transference Function models.

The metabolic process of methane production by combined fermentation of coal and corn straw

The anaerobic degradation of coal combined with straw biomass can promote the methane production. The biogas production potential and metabolic pathway were explored via the co-digestion simulation experiment of coal and corn straw. The results showed that 2 g of corn straw combined respectively with 4 g of bituminous coal A, 6 g of bituminous coal B and 4 g of bituminous coal C resulted in highest methane yields. The structure of lignocellulose in corn straw was partially degraded into guaiacyl and syringyl units. Meanwhile, the content of biodegradable tyrosine like protein and soluble microbial by-products in liquid phase significantly decreased. Significantly, the structure of archaea altered from aceticlastic to hydrogenotrophic methanogens when the fermentation substrate changed from high to low rank coal. The proportion of hydrogenotrophic methanogens was significantly higher than that of aceticlastic and methylotrophic methanogens, and the hydrogenotrophic pathway was dominant than the aceticlastic pathway.

The role of conductive nanoparticles in anaerobic digestion: Mechanism, current status and future perspectives

In the current scenario, alternative energy sources are the need of the hour. Organic wastes having a larger fraction of biodegradable constituents present a sustainable bioenergy source. It has been reported that the calorific value of biogas generated by anaerobic digestion (AD) is 21-25 MJ/m³ with the treatment which makes it an excellent replacement of natural gas and fossil fuels and can reduce more than 80% greenhouse gas emission to the surroundings. However, there are some limitations associated with the AD process for instance ammonia build-up at the first stage reduces the rate of hydrolysis of biomass, whereas, in the last stage it interferes with methane formation. Owing to special physicochemical properties such as high activity, high reactive surface area, and high specificity, tailor-made conductive nanoparticles can improve the performance of the AD process. In the AD process, H₂ is used as an electron carrier, referred as mediated interspecies electron transfer (MIET). Due to the diffusion limitation of these electron carriers, the MIET efficiency is relatively low that limits the methanogenesis. Direct interspecies electron transfer (DIET), which enables direct cell-to-cell electron transport between bacteria and methanogen, has been considered an alternative efficient approach to MIET that creates metabolically favorable conditions and results in faster conversion of organic acids and alcohols into methane. This paper discusses in detail the application of conductive nanoparticles to enhance the AD process efficiency. Interaction between microbes in anaerobic conditions for electron transfer with the help of CNPs is discussed. Application of a variety of conductive nanomaterials as an additive is discussed with their potential biogas production and treatment enhancement in the anaerobic digestion process.

Multidimensional approaches of biogas production and up-gradation: Opportunities and challenges

The expanding interest towards biogas generation from biowaste via complex anaerobic digestion (AD) opened new avenues in the improvement of biogas production processes and their up-gradation. The adsorption/removal of impurities particularly hydrogen sulfide (H₂S) and carbon dioxide (CO₂) from the biogas stream will significantly improve the efficiency of biogas for its further use as a renewable energy fuel. The production and up-gradation of biogas rely upon the types of feedstocks, AD condition, microbial diversity, purification methods along with the application of various additives. In that context, this review aims to emphasize the current state of the art in the field of biogas production via AD using diverse bio-waste. Further, this review will critically explore the biogas up-gradation technologies adopted so far and their pros and cons. Finally, techno-economic and environmental impact assessment of the biogas production process will be underlined to make the process cost-effective and environmentally sustainable.

Fungal dynamics during anaerobic digestion of sewage sludge combined with food waste at high organic loading rates in immersed membrane bioreactors

In this study, the influence of distinct hydraulic retention times (HRT) and organic loading rates (OLRs) on fungal dynamics during food waste anaerobic digestion in immersed membrane-based bio-reactors (iMBR) were investigated. The organic loading rate 4-8 g VS/L/d (R1) and 6-10 g VS/L/d (R2) were set in two iMBR. T1 (1d), T2 (15d) and T3 (34d) samples collected from each bioreactor were analyzed fungal community by using 18s rDNA. In R2, T2 had the most abundant Ascomycota, Basidiomycota, Chytridiomycota and Mucoromycota. As for R1, T3 also had the richest Cryptomycota except above four kinds of fungi. Subsequently, the Principal Component Analysis (PCA) and Non-Metric Multi-Dimensional Scaling (NMDS) indicated that fungal diversity was varied among the all three phases (T1, T2, and T3) and each treatment (R1 and R2). Finally, the results showed that different OLRs and HRT have significantly influenced the fungal community.

Enhancement of Biogas Production via Co-Digestion of Wastewater Treatment Sewage Sludge and Brewery Spent Grain: Physicochemical Characterization and Microbial Community

The present study intends to evaluate a synergy towards enhanced biogas production by co-digesting municipal sewage sludge (SS) with brewery spent grain (BSG). To execute this, physicochemical and metagenomics analysis was conducted on the sewage sludge substrate. The automatic methane potential test system II (AMPTS II) biochemical methane potential (BMP) batch setup was operated at 35 ± 5 °C, pH range of 6.5–7.5 for 30 days’ digestion time on AMPTS II and 150 days on semi-continuous setup, where the organic loading rate (OLR) was guided by pH and the volatile fatty acids to total alkalinity (VFA/TA) ratio. Metagenomics analysis revealed that Proteobacteria was the most abundant phyla, consisting of hydrolytic and fermentative bacteria. The archaea community of hydrogenotrophic methanogen genus was enriched by methanogens. The highest BMP was obtained with co-digestion of SS and BSG, and 9.65 g/kg of VS. This not only increased biogas production by 104% but also accelerated the biodegradation of organic matters. However, a significant reduction in the biogas yield, from 10.23 NL/day to 2.02 NL/day, was observed in a semi-continuous process. As such, it can be concluded that different species in different types of sludge can synergistically enhance the production of biogas. However, the operating conditions should be optimized and monitored at all times. The anaerobic co-digestion of SS and BSG might be considered as a cost-effective solution that could contribute to the energy self-efficiency of wastewater treatment works (WWTWs) and sustainable waste management. It is recommended to upscale co-digestion of the feed for the pilot biogas plant. This will also go a long way in curtailing and minimizing the impacts of sludge disposal in the environment.

Assessment of municipal solid waste management system in Lae City, Papua New Guinea in the context of sustainable development

ABSTRACT

Lae City (LC) of Morobe Province is the second-largest city in Papua New Guinea. Due to the abundant natural resources it inherits, the resultant urbanization has led to an influx of the human population. This increase in population as a result of industrialization has led to increased municipal solid waste (MSW) accumulation. To address this exigent issue, which affects the nation's carbon footprint, it is imperative to review socio-economic and geographic factors to establish a feasible approach for managing MSW efficiently and sustainably. In the quest to achieve the same, the present assessment focuses on the 3 core waste management hierarchy systems to support sustainable development for LC by reviewing existing opportunities and challenges associated with the current MSW management system and the associated policies. The result shows that as a sustainable approach to MSW management of LC, a zero-waste campaign for resource recovery engaging all stakeholders can be implemented since the organic content of MSW generated in LC is as high as 70%. Moreover, the dumping of MSW at the dedicated dumpsite site can be minimized if policies are strengthened and the proposed waste avoidance pathway is implemented strictly. In addition to this, to avoid the contamination of groundwater and recovery of methane, the use of the Fukuoka approach in the existing landfills has been suggested to capture leachate without any huge expenditure.

The Effect of Antibiotics on Mesophilic Anaerobic Digestion Process of Cattle Manure

This study explored the effect of eight antimicrobials on the efficiency of biogas production in the anaerobic digestion (AD) process of cattle manure. The microbiome involved in AD, presence and number of genes mcrA, MSC and MST specific for Archaea, and antibiotic resistance genes (ARGs) concentration in digestate (D) were examined. Supplementation of antibiotics to substrate significantly lowered biogas production. Amoxicillin caused a 75% decrease in CH4 production in comparison with the control samples. Enrofloxacin, tetracycline, oxytetracycline, and chlortetracycline reduced the amount of biogas produced by 36, 39, 45 and 53%, respectively. High-throughput sequencing of 16S rRNA results revealed that bacteria dominated the Archaea microorganisms in all samples. Moreover, antibiotics led to a decrease in the abundance of the genes mcrA, MSC, MST, and induced an increase in the number of tetracyclines resistance genes. Antibiotics decreased the efficiency of the AD process and lowered the quantity of CH4 obtained, while stimulating an increase in the number of ARGs in D. This work reveals how antimicrobials affect the cattle manure AD process and changes in microbial biodiversity, number of functional genes and ARGs in the digestate due to drugs exposure. It also, provides useful, practical information about the AD process.

Anaerobic co-digestion of chicken manure and cardboard waste: Focusing on methane production, microbial community analysis and energy evaluation

This study aimed to investigate the synergistic effect and microbial community changes between chicken manure (CM) and cardboard (CB) during anaerobic co-digestion. Meanwhile, the energy balance of biogas engineering was extrapolated based on the batch tests. In batch tests, co-digestion system achieved the highest improvement (14.2%) and produced 319.62 mL CH₄/gVS with a 65:35 ratio of CB: CM. More extracellular polymeric substance secretion promoted the electron transfer for acidogenesis and more hydrolase was provided with 31.6% improvement. The microbial analysis illustrated that higher acetoclastic Methanosaeta abundance was achieved, leading to 211% enhancement of acetoclastic pathway. Moreover, associated network illustrated that the higher methane production was mainly achieved through matching of hydrolytic bacteria and acidogenesis bacteria. As for energy balance, the synergistic effect increased the energy output by 38% and energy recovery to 46.4%.

Waste-to-energy nexus: A sustainable development

An upsurge in global population due to speedy urbanization and industrialization is facing significant challenges such as rising energy-demand, enormous waste-generation and environmental deterioration. The waste-to-energy nexus based on the 5R principle (Reduce, Reuse, Recycle, Recovery, and Restore) is of paramount importance in solving these Gordian knots. This review essentially concentrates on latest advancements in the field of 'simultaneous waste reduction and energy production' technologies. The waste-to-energy approaches (thermal and biochemical) for energy production from the agricultural residues are comprehensively discussed in terms environmental, techno-economic, and policy analysis. The review will assess the loopholes in order to come up with more sophisticated technologies that are not only eco-friendly and cost-effective, but also socially viable. The waste-to-energy nexus as a paradigm for sustainable development of restoring waste is critically discussed considering future advancement plans and agendas of the policy-makers.

Waste to Energy: A Focus on the Impact of Substrate Type in Biogas Production

Anaerobic digestion is an efficient technology for a sustainable conversion of various organic wastes such as animal manure, municipal solid waste, agricultural residues and industrial waste into biogas. This technology offers a unique set of benefits, some of which include a good waste management technique, enhancement in the ecology of rural areas, improvement in health through a decrease of pathogens and optimization of the energy consumption of communities. The biogas produced through anaerobic digestion varies in composition, but it consists mainly of carbon dioxide methane together with a low quantity of trace gases. The variation in biogas composition are dependent on some factors namely the substrate type being digested, pH, operating temperature, organic loading rate, hydraulic retention time and digester design. However, the type of substrate used is of greater interest due to the direct dependency of microorganism activities on the nutritional composition of the substrate. Therefore, the aim of this review study is to provide a detailed analysis of the various types of organic wastes that have been used as a substrate for the sustainable production of biogas. Biogas formation from various substrates reported in the literature were investigated, an analysis and characterization of these substrates provided the pro and cons associated with each substrate. The findings obtained showed that the methane yield for all animal manure varied from 157 to 500 mL/gVS with goat and pig manure superseding the other animal manure whereas lignocellulose biomass varied from 160 to 212 mL/gVS. In addition, organic municipal solid waste and industrial waste showed methane yield in the ranges of 143–516 mL/gVS and 25–429 mL/gVS respectively. These variations in methane yield are primarily attributed to the nutritional composition of the various substrates.

Valorization of agricultural waste for biogas based circular economy in India: A research outlook

Environmental deterioration and the need for energy security are intrinsic problems linked with the linear economy based on fossil fuels. Recently, a transformation to a sustainable circular bio-economy is being experienced where biomass waste is being valorized for energy production as well as minimization of waste and greenhouse gas emissions. The agricultural waste, generated in vast quantities in India is a prospective feedstock for biogas production. Agri-waste to biogas based circular economy requires an integration of agri-waste management, biogas production and utilization and policy support. This paper comprehensively discusses the potential of biogas production from agricultural waste, its upgradation and utilization along with the government initiatives, policy regulations. In addition, barriers that impede the development of an efficient agri-waste to biogas based circular economy, and the future research opportunities to meet the growing needs for agri-waste management, energy production and climate change mitigation are discussed.