1
|
Yang Z, Cui J, Yun Y, Xu Y, Tan CP, Zhang W. Effect of different gelators on the physicochemical properties and microstructure of coconut oleogels. JOURNAL OF THE SCIENCE OF FOOD AND AGRICULTURE 2024; 104:5139-5148. [PMID: 38284624 DOI: 10.1002/jsfa.13338] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Grants] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/02/2023] [Revised: 01/13/2024] [Accepted: 01/26/2024] [Indexed: 01/30/2024]
Abstract
BACKGROUND The inherent properties of coconut oil (CO), including its elevated saturated fatty acid content and low melting point, make it suitable for application in plastic fat processing. The present study explores the physicochemical characteristics, micromorphology and oxidative stability of oleogels produced from CO using various gelators [ethylcellulose (EC), β-sitosterol/γ-oryzanol (PS) and glyceryl monostearate (MG)] to elucidate the formation mechanisms of coconut oleogels (EC-COO, PS-COO and MG-COO). RESULTS Three oleogel systems exhibited a solid-like behavior, with the formation of crystalline forms dominated by β and β'. Among them, PS-COO exhibited enhanced capability with respect to immobilizing liquid oils, resulting in solidification with high oil-binding capacity, moderate hardness and good elasticity. By contrast, MG-COO demonstrated inferior stability compared to PS-COO and EC-COO. Furthermore, MG-COO and PS-COO demonstrated antioxidant properties against CO oxidation, whereas EC-COO exhibited the opposite effect. PS-COO and EC-COO exhibited superior thermodynamic behavior compared to MG-COO. CONCLUSION Three oleogels based on CO were successfully prepared. The mechanical strength, storage modulus and thermodynamic stability of the CO oleogel exhibited concentration dependence with increasing gelling agent addition. PS-COO demonstrated relatively robust oil-binding capacity and oxidative stability, particularly with a 15% PS addition. This information contributes to a deeper understanding of CO-based oleogels and offers theoretical insights for their application in food products. © 2024 Society of Chemical Industry.
Collapse
Affiliation(s)
- Zihan Yang
- School of Food Science and Engineering, Hainan University, Haikou, China
| | - Jingtao Cui
- School of Food Science and Engineering, Hainan University, Haikou, China
| | - Yonghuan Yun
- School of Food Science and Engineering, Hainan University, Haikou, China
| | - Yongjiang Xu
- State Key Laboratory of Food Science and Resources, School of Food Science and Technology, Jiangnan University, Wuxi, China
| | - Chin-Ping Tan
- Department of Food Technology, Faculty of Food Science and Technology, University Putra Malaysia, Serdang, Malaysia
| | - Weimin Zhang
- School of Food Science and Engineering, Hainan University, Haikou, China
| |
Collapse
|
2
|
Simoes S, Rousseau D. A hybrid approach to oil structuring - combining wax oleogels and capillary suspensions. SOFT MATTER 2024; 20:4329-4336. [PMID: 38742675 DOI: 10.1039/d3sm01619f] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 05/16/2024]
Abstract
There is continuing interest in finding new approaches to gel liquid oil for processed food applications. Here, we combined oleogels and capillary suspensions to generate model oil-continuous networks consisting of a wax oleogel and a water-bridged, glass particle network. The composition map tested comprised 30 vol% polar or non-polar glass beads dispersed in a 70 vol% non-particle phase consisting of water (≤9 vol%) as well as 2 wt% hexatriacontane as oleogelator in canola oil. While the hexatriacontane wax alone gelled the oil, presence of the glass beads (but no water) prevented oleogelation. Self-supporting capillary networks formed with polar particles and 1 vol% water or non-polar glass beads and 3 vol% water in canola oil. The capillary suspensions demonstrated significant differences in rheological behaviour as the polar particles yielded much higher elastic moduli than their non-polar particle counterparts. Polar hybrids were weakened by inclusion of the wax whereas the non-polar particle hybrid network displayed elastic moduli greater than the respective contributions of both capillary and wax gel networks. This hybrid method of oleogelation can be applied to virtually any food particles and uses minimal water and wax.
Collapse
Affiliation(s)
- Selvyn Simoes
- Food and Soft Materials Research Group, Department of Chemistry and Biology, Toronto Metropolitan University, 350 Victoria St, Toronto, Canada.
| | - Dérick Rousseau
- Food and Soft Materials Research Group, Department of Chemistry and Biology, Toronto Metropolitan University, 350 Victoria St, Toronto, Canada.
| |
Collapse
|
3
|
Dimakopoulou-Papazoglou D, Zampouni K, Prodromidis P, Moschakis T, Katsanidis E. Microstructure, Physical Properties, and Oxidative Stability of Olive Oil Oleogels Composed of Sunflower Wax and Monoglycerides. Gels 2024; 10:195. [PMID: 38534613 DOI: 10.3390/gels10030195] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/14/2024] [Revised: 03/08/2024] [Accepted: 03/11/2024] [Indexed: 03/28/2024] Open
Abstract
The utilization of natural waxes to form oleogels has emerged as a new and efficient technique for structuring liquid edible oil into solid-like structures for diverse food applications. The objective of this study was to investigate the interaction between sunflower wax (SW) and monoglycerides (MGs) in olive oil oleogels and assess their physical characteristics and storage stability. To achieve this, pure SW and a combination of SW with MGs in a 1:1 ratio were examined within a total concentration range of 6-12% w/w. The formed oleogels were characterized based on their microstructure, melting and crystallization properties, textural characteristics, and oxidative stability during storage. All the oleogels were self-standing, and, as the concentration increased, the hardness of the oleogels also increased. The crystals of SW oleogels were long needle-like, while the combination of SW and MGs led to the formation of crystal aggregates and rosette-like crystals. Differential scanning calorimetry and FTIR showed that the addition of MGs led to different crystal structures. The oxidation results revealed that oleogels had low peroxide and TBARS values throughout the 28-day storage period. These results provide useful insights about the utilization of SW and MGs oleogels for potential applications in the food industry.
Collapse
Affiliation(s)
- Dafni Dimakopoulou-Papazoglou
- Department of Food Science and Technology, School of Agriculture, Faculty of Agriculture, Forestry and Natural Environment, Aristotle University of Thessaloniki, 54124 Thessaloniki, Greece
| | - Konstantina Zampouni
- Department of Food Science and Technology, School of Agriculture, Faculty of Agriculture, Forestry and Natural Environment, Aristotle University of Thessaloniki, 54124 Thessaloniki, Greece
| | - Prodromos Prodromidis
- Department of Food Science and Technology, School of Agriculture, Faculty of Agriculture, Forestry and Natural Environment, Aristotle University of Thessaloniki, 54124 Thessaloniki, Greece
| | - Thomas Moschakis
- Department of Food Science and Technology, School of Agriculture, Faculty of Agriculture, Forestry and Natural Environment, Aristotle University of Thessaloniki, 54124 Thessaloniki, Greece
| | - Eugenios Katsanidis
- Department of Food Science and Technology, School of Agriculture, Faculty of Agriculture, Forestry and Natural Environment, Aristotle University of Thessaloniki, 54124 Thessaloniki, Greece
| |
Collapse
|
4
|
Szymanska I, Zbikowska A, Onacik-Gür S. New Insight into Food-Grade Emulsions: Candelilla Wax-Based Oleogels as an Internal Phase of Novel Vegan Creams. Foods 2024; 13:729. [PMID: 38472842 DOI: 10.3390/foods13050729] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/25/2024] [Revised: 02/22/2024] [Accepted: 02/24/2024] [Indexed: 03/14/2024] Open
Abstract
Cream-type emulsions containing candelilla wax-based oleogels (EC) were analyzed for their physicochemical properties compared to palm oil-based creams (EP). The microstructure, rheological behavior, stability, and color of the creams were determined by means of non-invasive and invasive techniques. All the formulations exhibited similar color parameters in CIEL*a*b* space, unimodal-like size distribution of lipid particles, and shear-thinning properties. Oleogel-based formulations were characterized by higher viscosity (consistency index: 172-305 mPa·s, macroscopic viscosity index: 2.19-3.08 × 10-5 nm-2) and elasticity (elasticity index: 1.09-1.45 × 10-3 nm-2), as well as greater resistance to centrifugal force compared to EP. Creams with 3, 4, or 5% wax (EC3-5) showed the lowest polydispersity indexes (PDI: 0.80-0.85) 24 h after production and the lowest instability indexes after environmental temperature changes (heating at 90 °C, or freeze-thaw cycle). EC5 had particularly high microstructural stability. In turn, candelilla wax content ≥ 6% w/w accelerated the destabilization processes of the cream-type emulsions due to disintegration of the interfacial layer by larger lipid crystals. It was found that candelilla wax-based lipids had great potential for use as palm oil substitutes in the development of novel vegan cream analogues.
Collapse
Affiliation(s)
- Iwona Szymanska
- Department of Food Technology and Assessment, Institute of Food Science, Warsaw University of Life Sciences-SGGW, 159C Nowoursynowska Street, 02-776 Warsaw, Poland
| | - Anna Zbikowska
- Department of Food Technology and Assessment, Institute of Food Science, Warsaw University of Life Sciences-SGGW, 159C Nowoursynowska Street, 02-776 Warsaw, Poland
| | - Sylwia Onacik-Gür
- Department of Meat and Fat Technology, Prof. Waclaw Dabrowski Institute of Agriculture and Food Biotechnology-State Research Institute, 36 Rakowiecka Street, 02-532 Warsaw, Poland
| |
Collapse
|
5
|
Cheng K, Pan Y, Han Z, Wang Z, Sun Q, Wei S, Xia Q, Liu Y, Liu S, Shao JH. A sight of self-assembly mechanism in fish oil oleogels: Phase transition, crystal structure and non-covalent interaction. Food Chem 2024; 433:137323. [PMID: 37678124 DOI: 10.1016/j.foodchem.2023.137323] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/31/2023] [Revised: 08/17/2023] [Accepted: 08/28/2023] [Indexed: 09/09/2023]
Abstract
Fish oils contain ω-3 polyunsaturated fatty acids (PUFAs), but easily cause quality deterioration due to the oxidation. Beeswax-based oleogels could wrap fish oils by beeswax self-assembly. The phase transition, crystal structure and non-covalent interaction were investigated to reveal the self-assembly mechanism from the perspective of beeswax and oil phase characteristics. The results indicated that high unsaturation degree, PUFAs and beeswax additions promoted phase transition, SFC and stable crystal networks. The changes of crystal structures were ascribed to the polymorphism and polymorphic transition. β-Polymorphs could form crystal networks, and β'-polymorphs could influence the size of crystal chains or clusters as well as crystalline domains. Crystalline domain sizes affected crystal morphologies and network structures, including plate-like structures and multi-layer porous structures. UFAs could involve the beeswax self-assembly to change structure characteristics by van der Waals forces and π-π stacking. The OBC remained 100%, when beeswax additions reached more than 6%. Hence, beeswax additions, PUFA contents and unsaturation degree all influenced the self-assembly mechanism and adjusted the macroscopic properties of oleogels.
Collapse
Affiliation(s)
- Kaixing Cheng
- College of Food Science and Technology, Guangdong Ocean University, Guangdong Provincial Key Laboratory of Aquatic Product Processing and Safety, Guangdong Province Engineering Laboratory for Marine Biological Products, Guangdong Provincial Engineering Technology Research Center of Seafood, Key Laboratory of Advanced Processing of Aquatic Product of Guangdong Higher Education Institution, Zhanjiang 524088, China
| | - Yanmo Pan
- College of Food Science and Technology, Guangdong Ocean University, Guangdong Provincial Key Laboratory of Aquatic Product Processing and Safety, Guangdong Province Engineering Laboratory for Marine Biological Products, Guangdong Provincial Engineering Technology Research Center of Seafood, Key Laboratory of Advanced Processing of Aquatic Product of Guangdong Higher Education Institution, Zhanjiang 524088, China
| | - Zongyuan Han
- College of Food Science and Technology, Guangdong Ocean University, Guangdong Provincial Key Laboratory of Aquatic Product Processing and Safety, Guangdong Province Engineering Laboratory for Marine Biological Products, Guangdong Provincial Engineering Technology Research Center of Seafood, Key Laboratory of Advanced Processing of Aquatic Product of Guangdong Higher Education Institution, Zhanjiang 524088, China.
| | - Zefu Wang
- College of Food Science and Technology, Guangdong Ocean University, Guangdong Provincial Key Laboratory of Aquatic Product Processing and Safety, Guangdong Province Engineering Laboratory for Marine Biological Products, Guangdong Provincial Engineering Technology Research Center of Seafood, Key Laboratory of Advanced Processing of Aquatic Product of Guangdong Higher Education Institution, Zhanjiang 524088, China
| | - Qinxiu Sun
- College of Food Science and Technology, Guangdong Ocean University, Guangdong Provincial Key Laboratory of Aquatic Product Processing and Safety, Guangdong Province Engineering Laboratory for Marine Biological Products, Guangdong Provincial Engineering Technology Research Center of Seafood, Key Laboratory of Advanced Processing of Aquatic Product of Guangdong Higher Education Institution, Zhanjiang 524088, China
| | - Shuai Wei
- College of Food Science and Technology, Guangdong Ocean University, Guangdong Provincial Key Laboratory of Aquatic Product Processing and Safety, Guangdong Province Engineering Laboratory for Marine Biological Products, Guangdong Provincial Engineering Technology Research Center of Seafood, Key Laboratory of Advanced Processing of Aquatic Product of Guangdong Higher Education Institution, Zhanjiang 524088, China
| | - Qiuyu Xia
- College of Food Science and Technology, Guangdong Ocean University, Guangdong Provincial Key Laboratory of Aquatic Product Processing and Safety, Guangdong Province Engineering Laboratory for Marine Biological Products, Guangdong Provincial Engineering Technology Research Center of Seafood, Key Laboratory of Advanced Processing of Aquatic Product of Guangdong Higher Education Institution, Zhanjiang 524088, China
| | - Yang Liu
- College of Food Science and Technology, Guangdong Ocean University, Guangdong Provincial Key Laboratory of Aquatic Product Processing and Safety, Guangdong Province Engineering Laboratory for Marine Biological Products, Guangdong Provincial Engineering Technology Research Center of Seafood, Key Laboratory of Advanced Processing of Aquatic Product of Guangdong Higher Education Institution, Zhanjiang 524088, China
| | - Shucheng Liu
- College of Food Science and Technology, Guangdong Ocean University, Guangdong Provincial Key Laboratory of Aquatic Product Processing and Safety, Guangdong Province Engineering Laboratory for Marine Biological Products, Guangdong Provincial Engineering Technology Research Center of Seafood, Key Laboratory of Advanced Processing of Aquatic Product of Guangdong Higher Education Institution, Zhanjiang 524088, China; Collaborative Innovation Center of Seafood Deep Processing, Dalian Polytechnic University, Dalian 116034, China.
| | - Jun-Hua Shao
- College of Food Science, Shenyang Agricultural University, Shenyang, Liaoning 110866, China.
| |
Collapse
|
6
|
Kouider Amar M, Rahal S, Laidi M, Kouar I, Bourahla RFEK, Akouche Y, Bouaraba R. Balancing competing objectives in bigel formulations using many-objective optimization algorithms and different decision-making methods. Eur J Pharm Biopharm 2024; 195:114167. [PMID: 38122946 DOI: 10.1016/j.ejpb.2023.12.007] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/16/2023] [Revised: 11/25/2023] [Accepted: 12/14/2023] [Indexed: 12/23/2023]
Abstract
Many-objective optimization, which deals with balancing multiple competing objectives to find compromised solutions, is essential for solving complex problems. This study explores evolutionary algorithms for optimizing the microstructural, rheological, stability, and drug release properties of bigel systems formulated using structured almond oil, mixed organogelators, and carbopol. The oleogel was identified as the dispersed phase, with droplet sizes ranging from 1.43 µm to 7.37 µm, indicating improved characteristics compared to other bigels. Each formulation exhibited non-Newtonian shear-thinning and thixotropic behaviors, which were positively influenced by the proportions of the excipients. After undergoing multiple stress cycles, highly concentrated bigels exhibited phase separation. Unexpectedly, bigels with lower viscosity exhibited reduced rates of drug release. FT-IR and HPLC analyses confirmed the compatibility and stability of drug-excipient interactions, with impurities remaining below 4%. This study emphasizes the complex interactions within mixed lipid-based bigels, requiring many-objective optimization techniques to address conflicting objectives. The objectives of optimization involve simultaneously minimizing microstructural properties while maximizing structural recovery and drug release properties. This led to conflicting objectives, where achieving higher structural recovery did not align with the desired drug release rate. Additionally, more stable formulations did not meet the optimal microstructural objectives. To resolve these conflicts, an RSM-MaOEAs approach was applied, employing various decision-making methods. Among EAs, RSM-RVEA notably achieved exceptional convergence. Furthermore, three MaOEAs-integrated decision-making methods-WSM, WPM, NED-and the RSM-desirability, offered potential solutions. Overall, this research proposes a robust framework for compromising the bigels' performance and stability, with broader applications in drug delivery and related fields.
Collapse
Affiliation(s)
- Mohamed Kouider Amar
- Biomaterials and Transport Phenomena Laboratory (LBMPT), University Dr., Yahia Fares of Medea, Medea 26000, Algeria; Department of Process Engineering, Institute of Technology, University Dr., Yahia Fares of Medea, Medea 26000, Algeria; Laboratory of Quality Control, Physico-Chemical Department, SAIDAL of Medea, Medea 26000, Algeria; Faculty of Technology, University Dr., Yahia Fares of Medea, Medea 26000, Algeria.
| | - Soufiane Rahal
- Faculty of Technology, University Dr., Yahia Fares of Medea, Medea 26000, Algeria
| | - Maamar Laidi
- Biomaterials and Transport Phenomena Laboratory (LBMPT), University Dr., Yahia Fares of Medea, Medea 26000, Algeria; Faculty of Technology, University Dr., Yahia Fares of Medea, Medea 26000, Algeria
| | - Ibtihal Kouar
- Department of Process Engineering, Institute of Technology, University Dr., Yahia Fares of Medea, Medea 26000, Algeria; Faculty of Technology, University Dr., Yahia Fares of Medea, Medea 26000, Algeria
| | - Rym Farah El-Khansaa Bourahla
- Department of Process Engineering, Institute of Technology, University Dr., Yahia Fares of Medea, Medea 26000, Algeria; Faculty of Technology, University Dr., Yahia Fares of Medea, Medea 26000, Algeria
| | - Youcef Akouche
- Laboratory of Quality Control, Physico-Chemical Department, SAIDAL of GDC, Algiers 16000, Algeria
| | - Razki Bouaraba
- Laboratory of Quality Control, Physico-Chemical Department, SAIDAL of GDC, Algiers 16000, Algeria
| |
Collapse
|
7
|
Ferdaus MJ, Barman B, Mahmud N, da Silva RC. Oleogels as a Promising Alternative to Animal Fat in Saturated Fat-Reduced Meat Products: A Review. Gels 2024; 10:92. [PMID: 38391422 PMCID: PMC10888177 DOI: 10.3390/gels10020092] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/24/2023] [Revised: 01/22/2024] [Accepted: 01/22/2024] [Indexed: 02/24/2024] Open
Abstract
The surge in chronic diseases is closely linked to heightened levels of saturated and trans fatty acids in processed foods, particularly meat products. Addressing this concern, various strategies have been employed to alleviate the impact of these detrimental fats. Among these, oleogels have emerged as a novel and promising approach in the food industry. As restructured fat systems, oleogels offer a unique opportunity to enhance the nutritional profile of meat products while providing distinct health and environmental advantages. This comprehensive review explores the transformative role of oleogels as innovative substitutes for traditional animal fats in a variety of meat products. Utilizing materials such as hydroxypropyl methylcellulose (HPMC), sterols, beeswax, γ-oryzanol, β-sitosterol, and others, oleogels have been investigated in diverse studies. The examination encompasses their impact on the textural, nutritional, and oxidative dimensions of meat patties, pork patties, pork liver pâtés, beef heart patties, and meat batters. An in-depth exploration is undertaken into the influence of various elements, including the type of oil, gelling agents, and processing methods, on the stability and physicochemical attributes of oleogels. Additionally, the paper scrutinizes the potential effects of oleogels on sensory attributes, texture, and the shelf life of meat products. In conclusion, this collective body of research emphasizes the versatility and efficacy of oleogels as viable replacements for traditional animal fats across a spectrum of meat products. The documented improvements in nutritional quality, oxidative stability, and sensory attributes pave the way for the development of healthier and more sustainable formulations in the meat industry.
Collapse
Affiliation(s)
- Md Jannatul Ferdaus
- Family and Consumer Sciences Department, College of Agriculture and Environmental Sciences (CAES), North Carolina A&T State University, Greensboro, NC 27411, USA
| | - Bishal Barman
- Family and Consumer Sciences Department, College of Agriculture and Environmental Sciences (CAES), North Carolina A&T State University, Greensboro, NC 27411, USA
| | - Niaz Mahmud
- Family and Consumer Sciences Department, College of Agriculture and Environmental Sciences (CAES), North Carolina A&T State University, Greensboro, NC 27411, USA
| | - Roberta Claro da Silva
- Family and Consumer Sciences Department, College of Agriculture and Environmental Sciences (CAES), North Carolina A&T State University, Greensboro, NC 27411, USA
| |
Collapse
|
8
|
Stahl MA, Lüdtke FL, Grimaldi R, Gigante ML, Ribeiro APB. Characterization and stability of solid lipid nanoparticles produced from different fully hydrogenated oils. Food Res Int 2024; 176:113821. [PMID: 38163721 DOI: 10.1016/j.foodres.2023.113821] [Citation(s) in RCA: 1] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/27/2023] [Revised: 11/28/2023] [Accepted: 12/02/2023] [Indexed: 01/03/2024]
Abstract
The use of lipids from conventional oils and fats to produce solid lipid nanoparticles (SLN) attracting interest from the food industry, since due their varying compositions directly affects crystallization behavior, stability, and particle sizes (PS) of SLN. Thus, this study aimed evaluate the potential of fully hydrogenated oils (hardfats) with different hydrocarbon chain lengths to produce SLN using different emulsifiers. For that, fully hydrogenated palm kern (FHPkO), palm (FHPO), soybean (FHSO), microalgae (FHMO) and crambe (FHCO) oils were used. Span 60 (S60), soybean lecithin (SL), and whey protein isolate (WPI) were used as emulsifiers. The physicochemical characteristics and crystallization properties of SLN were evaluated during 60 days. Results indicates that the crystallization properties were more influenced by the hardfat used. SLN formulated with FHPkO was more unstable than the others, and hardfats FHPO, FHSO, FHMO, and FHCO exhibited the appropriate characteristics for use to produce SLN. Concerning emulsifiers, S60- based SLN showed high instability, despite the hardfat used. SL-based and WPI-based SLN formulations, showed a great stability, with crystallinity properties suitable for food incorporation.
Collapse
Affiliation(s)
- Marcella Aparecida Stahl
- Department of Food Engineering and Technology, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, Brazil.
| | - Fernanda Luisa Lüdtke
- Department of Food Engineering and Technology, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, Brazil; CEB - Centre of Biological Engineering, University of Minho, 4710-057 Braga, Portugal; LABBELS - Associate Laboratory, Braga/Guimarães, Portugal
| | - Renato Grimaldi
- Department of Food Engineering and Technology, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, Brazil
| | - Mirna Lúcia Gigante
- Department of Food Engineering and Technology, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, Brazil
| | - Ana Paula Badan Ribeiro
- Department of Food Engineering and Technology, Faculty of Food Engineering, University of Campinas, 13083-862 Campinas, Brazil
| |
Collapse
|
9
|
Dimakopoulou-Papazoglou D, Giannakaki F, Katsanidis E. Structural and Physical Characteristics of Mixed-Component Oleogels: Natural Wax and Monoglyceride Interactions in Different Edible Oils. Gels 2023; 9:627. [PMID: 37623082 PMCID: PMC10454151 DOI: 10.3390/gels9080627] [Citation(s) in RCA: 6] [Impact Index Per Article: 6.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/05/2023] [Revised: 07/17/2023] [Accepted: 08/02/2023] [Indexed: 08/26/2023] Open
Abstract
Waxes and monoglycerides (MGs) added in edible oils form oleogels that can be used as an alternative structured fat, providing healthier substitutes to saturated and trans fats in foods. This study aimed to investigate the properties of oleogels formed by the interaction between monoglycerides and different waxes in various edible oils. For this purpose, waxes, namely rice bran (RBW), candelilla (CDW), sunflower (SW), and beeswax (BW), together with MGs in a total concentration level of 15% (w/w) were dissolved in several edible oils (olive, sunflower, sesame, and soybean). The structure and physical properties of oleogels were investigated using texture analysis, polarized light microscopy, melting point measurements, and Fourier-transform infrared spectroscopy (FTIR). The hardest structure was produced by SW/MG (5.18 N), followed by CDW (2.87 N), RBW (2.34 N), BW (2.24 N) and plain MG (1.92 N). Furthermore, RBW and SW led to a higher melting point (69.2 and 67.3 °C) than the plain MG oleogels (64.5 °C). Different crystallization structures, i.e., needle-like crystals and spherulites, were observed depending on the type of wax, its concentration, and the oil used. These results can be used to control the properties of oleogels by adjusting the gelator composition for a variety of potential food applications.
Collapse
Affiliation(s)
| | | | - Eugenios Katsanidis
- Department of Food Science and Technology, School of Agriculture, Faculty of Agriculture, Forestry and Natural Environment, Aristotle University of Thessaloniki, 54124 Thessaloniki, Greece; (D.D.-P.); (F.G.)
| |
Collapse
|
10
|
Sagiri SS, Samateh M, Pan S, Maldarelli C, John G. A Heat Transfer Model and Supporting Experiments to Guide the Uniform Gelation of Molecular Oleogels During Scale-up. J AM OIL CHEM SOC 2023; 100:539-550. [PMID: 37720415 PMCID: PMC10501409 DOI: 10.1002/aocs.12689] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/07/2022] [Accepted: 02/16/2023] [Indexed: 03/06/2023]
Abstract
The quest for novel vegetable oil structuring strategies has been progressing since the discovery of the deleterious impacts of trans fats. Although oleogelation using bioderived molecular gelators has been proven to be successful as an alternative to traditional hydrogenation methods, efforts are needed to meet the industrial requirements. A major constraint during the fabrication of oleogels is to achieve consistency in physical properties during scale-up. Experiments showed that gelation fails to occur when larger volumes were prepared based on the minimum gelation concentration (MGC) of gelators, determined using the smallest oil volume (1 mL), a general laboratory practice. This observation was consistent with all the molecular gelators used in this study; sorbitol dioctanoate, mannitol dioctanoate, and 12-hydroxystearic acid. To understand this behavior, a mathematical model was developed since gelator network propagation is governed by the cooling rate. The model indicates that maintenance of a minimal thermal gradient via uniform heat dissipation and gelation time is necessary to achieve homogeneous gel propagation across the vial. With these predictions, we hypothesized and confirmed that oleogels with constant surface area-to-volume ratio could result in identical gelation times and consistent physical properties (MGC, melting temperature, melting enthalpy, yield stress, solid phase content, and oil binding capacity) during scale-up.
Collapse
Affiliation(s)
- Sai S Sagiri
- Department of Chemistry & Biochemistry, The City College of New York, New York, NY 10031, USA
| | - Malick Samateh
- Department of Chemistry & Biochemistry, The City College of New York, New York, NY 10031, USA
- Doctoral Program in Chemistry, The City University of New York, Graduate Center, New York, NY 10016
| | - Shihao Pan
- Department of Chemical Engineering, The City College of New York, New York, NY 10031, USA
| | - Charles Maldarelli
- Department of Chemical Engineering, The City College of New York, New York, NY 10031, USA
| | - George John
- Department of Chemistry & Biochemistry, The City College of New York, New York, NY 10031, USA
- Doctoral Program in Chemistry, The City University of New York, Graduate Center, New York, NY 10016
| |
Collapse
|
11
|
Perez-Santana M, Cedeno-Sanchez V, Carriglio JC, MacIntosh AJ. The Effects of Emulsifier Addition on the Functionalization of a High-Oleic Palm Oil-Based Oleogel. Gels 2023; 9:522. [PMID: 37504401 PMCID: PMC10379819 DOI: 10.3390/gels9070522] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/18/2023] [Revised: 06/21/2023] [Accepted: 06/23/2023] [Indexed: 07/29/2023] Open
Abstract
Alternatives to oils with high saturated fatty acid content are often liquid oils (high in unsaturated fatty acids) that have a modified structure created either through additives or processing. Emulsifiers are additives that can be used as structuring agents of liquid fats; this process results in products such as oleogels, which can broaden the applications of these oils. This study assessed and compared the effects of mono- and diglycerides at 3%, 5%, 7% and 10% w/w on the mechanical and thermal properties of high-oleic palm oil (HOPO) oleogels. HOPO was heated to 75 °C and mixed with mono- or diglycerides at those four concentrations. The thermomechanical properties of the melted oleogels were assessed using differential scanning calorimetry (DSC). The melted oleogels were cooled to final temperatures of 5 °C, 10 °C and 15 °C under identical cooling rates, after which a puncture test (via a texture analyzer) was used to assess their textures. Finally, polarized light microscopy was used to assess the mechanical changes induced through emulsifier addition. The results showed that the use of mono- and diglycerides significantly modified the thermal and mechanical properties of the oleogels. The addition of saturated monoglycerides promoted a higher-temperature nucleation stage that did not previously occur in HOPO. The onset crystallization temperature increased with the addition of diglycerides, promoting crystallization at higher temperatures of the high-melting fraction of HOPO. The hardness of the oleogel generally increased with emulsifier addition and a reduction of the temperature. The effect of the temperature on the hardness was significantly greater in the diglyceride oleogel than in the monoglyceride oleogel. This study shows that the addition of mono- and diglycerides allows companies to customize their formulations to achieve desired results that may not previously have been possible, thereby facilitating novel uses for these oils within the industry.
Collapse
Affiliation(s)
- Melissa Perez-Santana
- Food Science and Human Nutrition Department, University of Florida, Gainesville, FL 32611, USA
| | - Victor Cedeno-Sanchez
- Food Science and Human Nutrition Department, University of Florida, Gainesville, FL 32611, USA
| | - John C Carriglio
- Food Science and Human Nutrition Department, University of Florida, Gainesville, FL 32611, USA
| | - Andrew J MacIntosh
- Food Science and Human Nutrition Department, University of Florida, Gainesville, FL 32611, USA
| |
Collapse
|
12
|
da Silva TLT, Danthine S. Sucrose Esters as Oleogelators in Mono or Binary Structured Oleogels Using Different Oleogelation Routes. Gels 2023; 9:gels9050399. [PMID: 37232991 DOI: 10.3390/gels9050399] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/13/2023] [Revised: 04/30/2023] [Accepted: 05/04/2023] [Indexed: 05/27/2023] Open
Abstract
Sucrose esters (SE) have been investigated as structuring agents in oleogels. Due to the low structuration power of SE as single agent, this component has recently been explored in combination with other oleogelators to form multicomponent systems. This study aimed to evaluate binary blends of SEs with different hydrophilic-lipophilic balances (HLBs) with lecithin (LE), monoglycerides (MGs) and hard-fat (HF), according to their physical properties. The following SEs, SP10-HLB2, SP30-HLB6, SP50-HLB11, and SP70-HLB15, were structured using three different routes: "traditional", "ethanol" and "foam-template". All binary blends were made using a 10% oleogelator in 1:1 proportion for binary mixtures; they were then evaluated for their microstructure, melting behavior, mechanical properties, polymorphism and oil-binding capacity. SP10 and SP30 did not form well-structure and self-standing oleogels in any combination. Although SP50 showed some potential blends with HF and MG, their combination with SP70 led to even more well-structured oleogels, with a higher hardness (~0.8 N) and viscoelasticity (160 kPa), and 100% oil-binding capacity. This positive result might be attributed to the reinforcement of the H-bond between the foam and the oil by MG and HF.
Collapse
Affiliation(s)
| | - Sabine Danthine
- Science des Aliments et Formulation, Gembloux Agro-Bio Tech, ULiège, 5030 Gembloux, Belgium
| |
Collapse
|
13
|
Oleogel-structured emulsions: A review of formation, physicochemical properties and applications. Food Chem 2023; 404:134553. [DOI: 10.1016/j.foodchem.2022.134553] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/05/2022] [Revised: 09/30/2022] [Accepted: 10/06/2022] [Indexed: 11/06/2022]
|
14
|
da Silva RC, Ferdaus MJ, Foguel A, da Silva TLT. Oleogels as a Fat Substitute in Food: A Current Review. Gels 2023; 9:gels9030180. [PMID: 36975629 PMCID: PMC10048032 DOI: 10.3390/gels9030180] [Citation(s) in RCA: 8] [Impact Index Per Article: 8.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/01/2023] [Revised: 02/14/2023] [Accepted: 02/22/2023] [Indexed: 03/03/2023] Open
Abstract
Fats and oils in food give them flavor and texture while promoting satiety. Despite the recommendation to consume predominantly unsaturated lipid sources, its liquid behavior at room temperature makes many industrial applications impossible. Oleogel is a relatively new technology applied as a total or partial replacement for conventional fats directly related to cardiovascular diseases (CVD) and inflammatory processes. Some of the complications in developing oleogels for the food industry are finding structuring agents Generally Recognized as Safe (GRAS), viable economically, and that do not compromise the oleogel palatability; thus, many studies have shown the different possibilities of applications of oleogel in food products. This review presents applied oleogels in foods and recent proposals to circumvent some disadvantages, as reaching consumer demand for healthier products using an easy-to-use and low-cost material can be intriguing for the food industry.
Collapse
Affiliation(s)
- Roberta Claro da Silva
- Family and Consumer Sciences Department, College of Agriculture and Environmental Sciences (CAES), North Carolina A&T State University, Greensboro, NC 27411, USA
| | - Md. Jannatul Ferdaus
- Family and Consumer Sciences Department, College of Agriculture and Environmental Sciences (CAES), North Carolina A&T State University, Greensboro, NC 27411, USA
| | - Aline Foguel
- Department of Biochemical-Pharmaceutical Technology, Faculty of Pharmaceutical Sciences, University of Sao Paulo, Sao Paulo 05508-000, Brazil
| | | |
Collapse
|
15
|
Dhal S, Alhamidi A, Al-Zahrani SM, Anis A, Pal K. The Influence of Emulsifiers on the Physiochemical Behavior of Soy Wax/Rice Bran Oil-Based Oleogels and Their Application in Nutraceutical Delivery. Gels 2023; 9:gels9010047. [PMID: 36661813 PMCID: PMC9858175 DOI: 10.3390/gels9010047] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/19/2022] [Revised: 12/14/2022] [Accepted: 12/14/2022] [Indexed: 01/11/2023] Open
Abstract
This research evaluated the influence of stearic acid, sunflower lecithin, and sorbitan monooleate on soy wax (SYW)/rice bran oil (RBO)-based oleogels. The physiochemical behavior of oleogel samples was evaluated using colorimetry, microscopy, FTIR, mechanical, crystallization kinetics, X-ray diffraction, and a drug release investigation. The prepared oleogels were light yellow, and adding emulsifiers did not change their appearance. All oleogels showed an oil binding capacity of >98%, independent of emulsifier treatment. The surface topography revealed that emulsifiers smoothed the surface of the oleogels. Bright-field and polarized micrographs showed the presence of wax grains and needles. FTIR spectra indicated that oleogel samples had the same functional group diversity as the raw materials. The oleogel samples lacked a hydrogen-bonding peak. Hence, we postulated that non-covalent interactions were involved in the oleogel preparation. According to stress relaxation studies, the firmness and elastic component of oleogels were unaffected by emulsifiers. However, EML3 (oleogel containing sorbitan monooleate) showed lower relaxing characteristics than the others. EML3 exhibited the slowest crystallization profile. Due to its low d-spacing, EML3 was found to have densely packed crystal molecules and the largest crystallite size. The in vitro drug release studies showed that emulsifier-containing oleogels dramatically affected curcumin release. These results may help customize oleogels properties to adjust bioactive component release in the food and pharmaceutical industries.
Collapse
Affiliation(s)
- Somali Dhal
- Department of Biotechnology and Medical Engineering, National Institute of Technology Rourkela, Rourkela 769008, India
| | - Abdullah Alhamidi
- SABIC Polymer Research Center (SPRC), Department of Chemical Engineering, College of Engineering, King Saud University, Riyadh 11421, Saudi Arabia
| | - Saeed M. Al-Zahrani
- SABIC Polymer Research Center (SPRC), Department of Chemical Engineering, College of Engineering, King Saud University, Riyadh 11421, Saudi Arabia
| | - Arfat Anis
- SABIC Polymer Research Center (SPRC), Department of Chemical Engineering, College of Engineering, King Saud University, Riyadh 11421, Saudi Arabia
- Correspondence: (A.A.); (K.P.)
| | - Kunal Pal
- Department of Biotechnology and Medical Engineering, National Institute of Technology Rourkela, Rourkela 769008, India
- Correspondence: (A.A.); (K.P.)
| |
Collapse
|
16
|
Physicochemical study of aqueous dispersions of organogel particles: Role of the ingredients and formulation process leading to colloidal hydrogels. Colloids Surf A Physicochem Eng Asp 2023. [DOI: 10.1016/j.colsurfa.2022.130905] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/07/2023]
|
17
|
Al-Saedi ZHF, Salih ZT, Ahmed KK, Ahmed RA, Jasim SA. Formulation and Characterization of Oleogel as a Topical Carrier of Azithromycin. AAPS PharmSciTech 2022; 24:17. [DOI: 10.1208/s12249-022-02481-9] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/08/2022] [Accepted: 12/03/2022] [Indexed: 12/23/2022] Open
|
18
|
Frolova Y, Sarkisyan V, Sobolev R, Kochetkova A. Ultrasonic Treatment of Food Colloidal Systems Containing Oleogels: A Review. Gels 2022; 8:gels8120801. [PMID: 36547325 PMCID: PMC9777715 DOI: 10.3390/gels8120801] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/18/2022] [Revised: 12/05/2022] [Accepted: 12/05/2022] [Indexed: 12/12/2022] Open
Abstract
The use of oleogels as an alternative to solid fats to reduce the content of saturated and trans-isomeric fatty acids is a developing area of research. Studies devoted to the search for methods of obtaining oleogels with given properties are of current interest. Ultrasonic treatment as a method for modifying oleogel properties has been used to solve this problem. The number of publications on the study of the effect of ultrasonic treatment on oleogel properties is increasing. This review aimed to systematize and summarize existing data. It allowed us to identify the incompleteness of this data, assess the effect of ultrasonic treatment on oleogel properties, which depends on various factors, and identify the vector of this direction in the food industry. A more detailed description of the parameters of ultrasonic treatment is needed to compare the results between various publications. Ultrasonic treatment generally leads to a decrease in crystal size and an increase in oil-binding capacity, rheological properties, and hardness. The chemical composition of oleogels and the concentration of gelators, the amplitude and duration of sonication, the cooling rate, and the crystallization process stage at which the treatment occurs are shown to be the factors influencing the efficiency of the ultrasonic treatment.
Collapse
|
19
|
Liu Y, Binks BP. Fabrication of Stable Oleofoams with Sorbitan Ester Surfactants. LANGMUIR : THE ACS JOURNAL OF SURFACES AND COLLOIDS 2022; 38:14779-14788. [PMID: 36410861 PMCID: PMC9730906 DOI: 10.1021/acs.langmuir.2c02413] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 09/02/2022] [Revised: 11/09/2022] [Indexed: 06/16/2023]
Abstract
Sorbitan esters have been extensively used as surfactants to stabilize emulsions in many fields. However, the preparation of an oleofoam with sorbitan ester alone has not been reported. Here, we apply a novel protocol to fabricate stable oleofoams of high air volume fraction from mixtures of vegetable oil and sorbitan ester. To incorporate more air bubbles into the oil matrix, aeration is first carried out in the one-phase region at high temperatures, during which the highest over-run can reach 280%. Due to foam instability at high temperatures, the foam is then submitted to rapid cooling, followed by storage at low temperatures. For high-melting sorbitan monostearate, the resulting foams containing many crystal-encased air bubbles are ultrastable to drainage, coarsening, and coalescence for several months. On the contrary, the cooled foams with low-melting sorbitan monooleate go through a gradual decay lasting for more than 1 month. We highlight the importance of hydrogen bond formation between surfactant and oil in enhancing foam stability. The generic nature of the above findings is demonstrated by preparing oil foams with various vegetable oils and sorbitan monooleate.
Collapse
|
20
|
Onacik-Gür S, Zbikowska A. The effect of green tea extract and oleogels on the physico-chemical properties and oxidative stability of short-dough biscuits during storage. Lebensm Wiss Technol 2022. [DOI: 10.1016/j.lwt.2022.114197] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
|
21
|
Habibi A, Dekiwadia C, Kasapis S, Truong T. Fabrication of double emulsion gel using monoacylglycerol and whey protein concentrate: The effects of primary emulsion gel fraction and particle size. J FOOD ENG 2022. [DOI: 10.1016/j.jfoodeng.2022.111350] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/08/2022]
|
22
|
Suriaini N, Arpi N, Syamsuddin Y, Supardan MD. Characteristics of palm oil-based oleogel and its potency as a shortening replacer. SOUTH AFRICAN JOURNAL OF CHEMICAL ENGINEERING 2022. [DOI: 10.1016/j.sajce.2022.11.003] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Submit a Manuscript] [Subscribe] [Scholar Register] [Indexed: 11/11/2022] Open
|
23
|
Assessment of Natural Waxes as Stabilizers in Peanut Butter. Foods 2022; 11:foods11193127. [PMID: 36230203 PMCID: PMC9562660 DOI: 10.3390/foods11193127] [Citation(s) in RCA: 4] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/01/2022] [Revised: 09/30/2022] [Accepted: 10/03/2022] [Indexed: 11/21/2022] Open
Abstract
Manufacturers add sugar and fully hydrogenated vegetable oils to peanut butter to avoid its oil separation during storage. Unfortunately, hydrogenated oils are significant sources of saturated fats, and reducing their consumption is challenging for food scientists without affecting the desired characteristics of food products. Therefore, in a preliminary study, 1%, 1.5%, and 2% of three natural waxes (rice bran, carnauba, and beeswax) were added to the natural peanut butter to test their efficacy as a stabilizer. Rice bran and carnauba wax added to peanut butter presented a higher elastic modulus (G’) and lower oil separation percentages than beeswax. However, no significant differences were found between the different percentages of waxes. Thus, in the final experiments, 1% of these selected waxes (rice bran and carnauba waxes) were added directly to the roasted ground peanut. Due to the difficulty of adding high melting point waxes to the peanut butter, a second experiment added wax oleogel (rice-bran and carnauba wax) to defatted peanut flour. After four weeks of storage, all of the samples were examined for their texture (TPA) and oil separation. The sample with directly added bran wax had the highest values for spreadability and firmness, and the lowest oil separation, which was 11.94 ± 0.90 N·s−1, 19.60 ± 0.71 N·s−1, and 0.87 ± 0.05%, respectively. In the peanut flour sample, the spreadability, firmness, and separated oil of the rice bran wax oleogel added sample were 46.95 ± 0.99 N·s−1, 66.61 ± 0.93 N, and 1.57 ± 0.07%, respectively. However, the textural properties of the rice bran wax oleogel added sample were close to the commercial peanut butter (natural and creamy). Therefore, the results indicate that the rice bran wax oleogel could be the potential replacement of the fully hydrogenated oil as a stabilizer.
Collapse
|
24
|
Variations in Microstructural and Physicochemical Properties of Soy Wax/Soybean Oil-Derived Oleogels Using Soy Lecithin. Polymers (Basel) 2022; 14:polym14193928. [PMID: 36235877 PMCID: PMC9570507 DOI: 10.3390/polym14193928] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/19/2022] [Revised: 09/07/2022] [Accepted: 09/16/2022] [Indexed: 11/22/2022] Open
Abstract
Emerging natural-based polymers and materials progress and new technology innovations open the way for unique food products with high nutritional value development. In this regard, oleogel may be essential in replacing fatty acids from food products. In this study, we researched the effects of varied soy lecithin (SYL) concentrations on the various physicochemical characteristics of soy wax (SW)/refined soybean oil (RSO) oleogels. These oleogels had a soft texture. The microscopic analysis of the oleogels suggested that the thickness, length, and density of the wax crystals (needle-shaped) varied as the SYL content was changed. Colorimetric analysis indicated that the oleogels were slightly yellowish. FTIR spectrometry helped analyze the functional groups of the raw materials and the oleogels. All the functional groups present in the raw materials could be accounted for within the oleogels. The only exception is the hydrogen-bonding peak in SW, which was not seen in the FTIR spectrum of the oleogels. It was found that at a critical SYL content, the oleogel showed a stable and repeatable wax network structure. This can be described by the presence of the uniformly distributed fat crystal network in the sample. The DSC analysis revealed that the oleogel samples were thermo-reversible, with their melting and crystallization temperatures ~43 °C and ~22 °C, respectively. In gist, it can be concluded that the incorporation of SYL can impact the color, wax crystal network characteristics, thermal characteristics, and mechanical characteristics of the oleogels in a composition-dependent manner.
Collapse
|
25
|
Qiu C, Wang S, Wang Y, Lee WJ, Fu J, Binks BP, Wang Y. Stabilisation of oleofoams by lauric acid and its glycerol esters. Food Chem 2022; 386:132776. [PMID: 35509162 DOI: 10.1016/j.foodchem.2022.132776] [Citation(s) in RCA: 7] [Impact Index Per Article: 3.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/28/2022] [Revised: 03/16/2022] [Accepted: 03/21/2022] [Indexed: 11/19/2022]
Abstract
Four types of pure lipid, namely lauric acid (LA), glycerol monolaurate (MAG), diglycerol laurate (DAG) and triglyceride laurate (TAG) were used to prepare oleofoams. The relationship between crystal profiles and their performance in oleofoams was established. DAG formed small needle-like crystals while MAG formed large flake-like crystals in oleogels, and crystal shells around air bubbles were observed in LA-, MAG- and DAG-based oleofoams. LA and DAG displayed higher over-run whereas DAG-stabilised foam possessed smaller bubbles and higher physical stability due to the presence of small β and β' crystals. Upon heating, DAG and TAG-based foams showed varying extents of oil drainage indicating the crystals were distributed in a different manner. Therefore, DAG was shown to be an excellent gelator in the fabrication of ultra-stable oleofoams. This work extends the lipid varieties with nutritional features and allows a better understanding on the stabilization mechanisms of lauric acid lipids in oleofoams.
Collapse
Affiliation(s)
- Chaoying Qiu
- JNU-UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering, Jinan University, Guangzhou 510632, China; Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery, Guangzhou 510632, China
| | - Shaolin Wang
- JNU-UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering, Jinan University, Guangzhou 510632, China; Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery, Guangzhou 510632, China; National R&D Center for Freshwater Fish Processing, Jiangxi Normal University, Nanchang, Jiangxi 330022, China
| | - Ying Wang
- JNU-UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering, Jinan University, Guangzhou 510632, China; Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery, Guangzhou 510632, China
| | - Wan Jun Lee
- JNU-UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering, Jinan University, Guangzhou 510632, China; Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery, Guangzhou 510632, China
| | - Junning Fu
- JNU-UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering, Jinan University, Guangzhou 510632, China; Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery, Guangzhou 510632, China
| | - Bernard P Binks
- Department of Chemistry, University of Hull, Hull HU6 7RX, UK.
| | - Yong Wang
- JNU-UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering, Jinan University, Guangzhou 510632, China; Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery, Guangzhou 510632, China.
| |
Collapse
|
26
|
Wang X, Ma D, Liu Y, Wang Y, Qiu C, Wang Y. Physical properties of oleogels fabricated by the combination of diacylglycerols and monoacylglycerols. J AM OIL CHEM SOC 2022. [DOI: 10.1002/aocs.12622] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/12/2022]
Affiliation(s)
- Xiaochen Wang
- JNU‐UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering Jinan University Guangzhou China
- Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery Guangzhou China
- National R&D Center for Freshwater Fish Processing Jiangxi Normal University Nanchang China
| | - Da Ma
- JNU‐UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering Jinan University Guangzhou China
- Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery Guangzhou China
| | - Yingwei Liu
- JNU‐UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering Jinan University Guangzhou China
- Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery Guangzhou China
| | - Ying Wang
- JNU‐UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering Jinan University Guangzhou China
- Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery Guangzhou China
| | - Chaoying Qiu
- JNU‐UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering Jinan University Guangzhou China
- Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery Guangzhou China
| | - Yong Wang
- JNU‐UPM International Joint Laboratory on Plant Oil Processing and Safety (POPS), Department of Food Science and Engineering Jinan University Guangzhou China
- Guangdong Engineering Technology Research Center for Cereal and Oil Byproduct Biorefinery Guangzhou China
| |
Collapse
|
27
|
Podchong P, Aumpai K, Sonwai S, Rousseau D. Rice bran wax effects on cocoa butter crystallisation and tempering. Food Chem 2022; 397:133635. [PMID: 35901611 DOI: 10.1016/j.foodchem.2022.133635] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/22/2022] [Revised: 06/08/2022] [Accepted: 07/02/2022] [Indexed: 11/04/2022]
Abstract
The effects of up to 5 wt% rice bran wax (RBX) on the crystallisation, tempering and storage stability of cocoa butter (CB) and a model dark chocolate were assessed. Presence of RBX significantly accelerated tempering and the formation of the desirable form V polymorph in CB. The form V to VI transition in both CB and chocolate was slowed in the presence of RBX during temperature-cycling, with addition of 1 wt% wax effectively reducing the extent of bloom formation in model chocolate following two weeks of temperature-cycling from 25 to 29 °C. Overall, this study has shown that RBX may be considered a viable seed material to accelerate tempering of CB and retard fat bloom in chocolate.
Collapse
Affiliation(s)
- Pawitchaya Podchong
- Department of Food Science and Technology, Faculty of Agricultural Technology and Agro-Industry, Rajamangala University of Technology Suvarnabhumi, Phra Nakhon Si Ayutthaya 13000, Thailand; Department of Chemistry and Biology, Toronto Metropolitan University, Toronto, ON M5B 2K3, Canada
| | - Kannika Aumpai
- Department of Food Technology, Faculty of Engineering and Industrial Technology, Silpakorn University, Nakhonpathom 73000, Thailand
| | - Sopark Sonwai
- Department of Food Technology, Faculty of Engineering and Industrial Technology, Silpakorn University, Nakhonpathom 73000, Thailand.
| | - Dérick Rousseau
- Department of Chemistry and Biology, Toronto Metropolitan University, Toronto, ON M5B 2K3, Canada.
| |
Collapse
|
28
|
Toro‐Vazquez JF, Bello‐Santillán MF, De la Peña‐Gil A, Aguilar‐Zárate M, Charó‐Alonso MA. Vegetable and mineral oil oleogels developed at different monoglyceride to lecithin molar ratios. J AM OIL CHEM SOC 2022. [DOI: 10.1002/aocs.12599] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/09/2022]
Affiliation(s)
- Jorge F. Toro‐Vazquez
- Facultad de Ciencias Químicas‐CIEP, Laboratorio de Fisicoquímica de Alimentos Universidad Autónoma de San Luis Potosí San Luis Potosí Mexico
| | - Maria. F. Bello‐Santillán
- Facultad de Ciencias Químicas‐CIEP, Laboratorio de Fisicoquímica de Alimentos Universidad Autónoma de San Luis Potosí San Luis Potosí Mexico
| | - Anaid De la Peña‐Gil
- Facultad de Ciencias Químicas‐CIEP, Laboratorio de Fisicoquímica de Alimentos Universidad Autónoma de San Luis Potosí San Luis Potosí Mexico
| | - Mayra Aguilar‐Zárate
- Facultad de Ciencias Químicas‐CIEP, Laboratorio de Fisicoquímica de Alimentos Universidad Autónoma de San Luis Potosí San Luis Potosí Mexico
| | - Miriam A. Charó‐Alonso
- Facultad de Ciencias Químicas‐CIEP, Laboratorio de Fisicoquímica de Alimentos Universidad Autónoma de San Luis Potosí San Luis Potosí Mexico
| |
Collapse
|
29
|
Sivakanthan S, Fawzia S, Madhujith T, Karim A. Synergistic effects of oleogelators in tailoring the properties of oleogels: A review. Compr Rev Food Sci Food Saf 2022; 21:3507-3539. [PMID: 35591753 DOI: 10.1111/1541-4337.12966] [Citation(s) in RCA: 10] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/28/2021] [Revised: 03/24/2022] [Accepted: 04/10/2022] [Indexed: 12/18/2022]
Abstract
Conventional solid fats play a crucial role as an ingredient in many processed foods. However, these fats contain a high amount of saturated fats and trans fats. Legislations and dietary recommendations related to these two types of fats set forth as a consequence of evidence showing their deleterious health impact have triggered the attempts to find alternate tailor-made lipids for these solid fats. Oleogels is considered as a novel alternative, which has reduced saturated fat and no trans fat content. In addition to mimicking the distinctive characteristics of solid fats, oleogels can be developed to contain a high amount of polyunsaturated fatty acids and used to deliver bioactives. Although there has been a dramatic rise in the interest in developing oleogels for food applications over the past decade, none of them has been commercially used in foods so far due to the deficiency in their crystal network structure, particularly in monocomponent gels. Very recently, there is a surge in the interest in using of combination of gelators due to the synergistic effects that aid in overcoming the drawbacks in monocomponent gels. However, currently, there is no comprehensive insight into synergism among oleogelators reported in recent studies. Therefore, a comprehensive intuition into the findings reported on synergism is crucial to fill this gap. The objective of this review is to give a comprehensive insight into synergism among gelators based on recent literature. This paper also identifies the future research propositions towards developing oleogels capable of exactly mimicking the properties of conventional solid fats to bridge the gap between laboratory research and the food industry.
Collapse
Affiliation(s)
- Subajiny Sivakanthan
- School of Mechanical, Medical and Process Engineering, Faculty of Engineering, Queensland University of Technology, Brisbane, Queensland, Australia.,Department of Agricultural Chemistry, Faculty of Agriculture, University of Jaffna, Kilinochchi, Sri Lanka.,Postgraduate Institute of Agriculture, University of Peradeniya, Peradeniya, Sri Lanka
| | - Sabrina Fawzia
- School of Civil and Environmental Engineering, Faculty of Engineering, Queensland University of Technology, Brisbane, Queensland, Australia
| | - Terrence Madhujith
- Department of Food Science and Technology, Faculty of Agriculture, University of Peradeniya, Peradeniya, Sri Lanka
| | - Azharul Karim
- School of Mechanical, Medical and Process Engineering, Faculty of Engineering, Queensland University of Technology, Brisbane, Queensland, Australia
| |
Collapse
|
30
|
Mosquera Narvaez LE, Ferreira LMDMC, Sanches S, Alesa Gyles D, Silva-Júnior JOC, Ribeiro Costa RM. A Review of Potential Use of Amazonian Oils in the Synthesis of Organogels for Cosmetic Application. Molecules 2022; 27:molecules27092733. [PMID: 35566084 PMCID: PMC9100349 DOI: 10.3390/molecules27092733] [Citation(s) in RCA: 11] [Impact Index Per Article: 5.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/15/2021] [Revised: 11/26/2021] [Accepted: 12/14/2021] [Indexed: 02/01/2023] Open
Abstract
New strategies for the delivery of bioactives in the deeper layers of the skin have been studied in recent years, using mainly natural ingredients. Among the strategies are organogels as a promising tool to load bioactives with different physicochemical characteristics, using vegetable oils. Studies have shown satisfactory skin permeation, good physicochemical stability mainly due to its three-dimensional structure, and controlled release using vegetable oils and low-molecular-weight organogelators. Within the universe of natural ingredients, vegetable oils, especially those from the Amazon, have a series of benefits and characteristics that make them unique compared to conventional oils. Several studies have shown that the use of Amazonian oils brings a series of benefits to the skin, among which are an emollient, moisturizing, and nourishing effect. This work shows a compilation of the main Amazonian oils and their nutraceutical and physicochemical characteristics together with the minority polar components, related to health benefits, and their possible effects on the synthesis of organogels for cosmetic purposes.
Collapse
Affiliation(s)
- Luis Eduardo Mosquera Narvaez
- Laboratory of Pharmaceutical Nanotechnology, College of Pharmacy, Federal University of Pará, Belém 66075-110, Brazil; (L.E.M.N.); (L.M.d.M.C.F.); (S.S.)
| | | | - Suellen Sanches
- Laboratory of Pharmaceutical Nanotechnology, College of Pharmacy, Federal University of Pará, Belém 66075-110, Brazil; (L.E.M.N.); (L.M.d.M.C.F.); (S.S.)
| | - Desireé Alesa Gyles
- Jamaica College of Health Sciences, School of Pharmacy, University of Technology, 237 Old Hope Road, Kinston 6, Jamaica;
| | | | - Roseane Maria Ribeiro Costa
- Laboratory of Pharmaceutical Nanotechnology, College of Pharmacy, Federal University of Pará, Belém 66075-110, Brazil; (L.E.M.N.); (L.M.d.M.C.F.); (S.S.)
- Correspondence: ; Tel.: +55-91-3201-7203
| |
Collapse
|
31
|
Utilising oleogel as a frying medium for deep fried Indian traditional product (Mathri) to reduce oil uptake. J INDIAN CHEM SOC 2022. [DOI: 10.1016/j.jics.2022.100378] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/23/2022]
|
32
|
Thakur D, Singh A, Prabhakar PK, Meghwal M, Upadhyay A. Optimization and characterization of soybean oil-carnauba wax oleogel. Lebensm Wiss Technol 2022. [DOI: 10.1016/j.lwt.2022.113108] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/26/2022]
|
33
|
Zampouni K, Soniadis A, Dimakopoulou-Papazoglou D, Moschakis T, Biliaderis C, Katsanidis E. Modified fermented sausages with olive oil oleogel and NaCl–KCl substitution for improved nutritional quality. Lebensm Wiss Technol 2022. [DOI: 10.1016/j.lwt.2022.113172] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/19/2022]
|
34
|
Zbikowska A, Kowalska M, Zbikowska K, Onacik-Gür S, Łempicka U, Turek P. Study on the Incorporation of Oat and Yeast β-Glucan into Shortbread Biscuits as a Basis for Designing Healthier and High Quality Food Products. Molecules 2022; 27:molecules27041393. [PMID: 35209183 PMCID: PMC8880506 DOI: 10.3390/molecules27041393] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 12/20/2021] [Revised: 01/28/2022] [Accepted: 02/14/2022] [Indexed: 02/06/2023] Open
Abstract
According to international health and food organizations and authorities, people should limit fat intake since fat is the most caloric component of food and it is often a source of unsafe saturated fatty acids (FA) and trans isomers. The greatest health benefits come from replacing shorts with dietary fiber molecules. The aim of the study was to determine the possibility of reducing shortening content, which has an undesirable profile of FA, by addition of β-glucan molecules in shortbread biscuits. The effect of oat and yeast β-glucan supplementation on physical and sensory quality of products with reduced fat content (max 15%) were studied. It was shown that the substitution of shortening by β-glucan in shortbread biscuits is possible to a limited extent. Reduction in product energy value (up to 36 kcal/100 g) and content of undesirable FA (maximum 2.1 g/100 g) and increased of β-glucan content, regardless of the type, caused deterioration of biscuits quality and affected changes during storage. The substitution of shortening by β-glucan in food is a good way to improve nutritional value by increasing the amount of dietary fiber molecules, reducing calories, and amount of SFA in diets.
Collapse
Affiliation(s)
- Anna Zbikowska
- Faculty of Food Assessment and Technology, Institute of Food Sciences, Warsaw University of Life Sciences (WULS-SGGW), Nowoursynowska St. 159c, 02-776 Warsaw, Poland;
- Correspondence: (A.Z.); (K.Z.)
| | - Malgorzata Kowalska
- Institute of Food Sciences, Faculty of Chemical Engineering and Commodity Science, Kazimierz Pulaski University of Technology and Humanities, Chrobrego St. 27, 26-600 Radom, Poland;
| | - Katarzyna Zbikowska
- Faculty of Medicine, Medical University of Warsaw, Żwirki i Wigury St. 61, 02-091 Warsaw, Poland
- Correspondence: (A.Z.); (K.Z.)
| | - Sylwia Onacik-Gür
- Department of Meat and Fat Technology, Prof. Waclaw Dabrowski Institute of Agriculture and Food Biotechnology—State Research Institute, Rakowiecka 36 St., 02-532 Warsaw, Poland;
| | - Urszula Łempicka
- Faculty of Food Assessment and Technology, Institute of Food Sciences, Warsaw University of Life Sciences (WULS-SGGW), Nowoursynowska St. 159c, 02-776 Warsaw, Poland;
| | - Paweł Turek
- Department of Non-Food Product Quality and Safety, Cracow University of Economics, Rakowicka St. 27, 31-510 Cracow, Poland;
| |
Collapse
|
35
|
l-Lysine-Based Gelators for the Formation of Oleogels in Four Vegetable Oils. MOLECULES (BASEL, SWITZERLAND) 2022; 27:molecules27041369. [PMID: 35209157 PMCID: PMC8876487 DOI: 10.3390/molecules27041369] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 01/14/2022] [Revised: 02/14/2022] [Accepted: 02/16/2022] [Indexed: 12/05/2022]
Abstract
Supramolecular oleogel is a soft material with a three-dimensional structure, formed by the self-assembly of low-molecular-weight gelators in oils; it shows broad application prospects in the food industry, environmental protection, medicine, and other fields. Among all the gelators reported, amino-acid-based compounds have been widely used to form organogels and hydrogels because of their biocompatibility, biodegradation, and non-toxicity. In this study, four Nα, Nε-diacyl-l-lysine gelators (i.e., Nα, Nε-dioctanoyl-l-lysine; Nα, Nε-didecanoyl-l-lysine; Nα, Nε-dilauroyl-l-lysine; and Nα, Nε-dimyristoyl-l-lysine) were synthesized and applied to prepare oleogels in four kinds of vegetable oils. Gelation ability is affected not only by the structure of the gelators but also by the composition of the oils. The minimum gel concentration (MGC) increased with the increase in the acyl carbon-chain length of the gelators. The strongest gelation ability was displayed in olive oil for the same gelator. Rheological properties showed that the mechanical strength and thermal stability of the oleogels varied with the carbon-chain length of the gelators and the type of vegetable oil. The microstructure of oleogels is closely related to the carbon-chain length of gelators, regardless of oil type. The highest oil-binding capacity (OBC) was obtained in soybean oil for all four gelators, and Nα, Nε-dimyristoyl-l-lysine showed the best performance for entrapping oils.
Collapse
|
36
|
Yu Y, Wang T, Gong Y, Wang W, Wang X, Yu D, Wu F, Wang L. Effect of ultrasound on the structural characteristics and oxidative stability of walnut oil oleogel coated with soy protein isolate-phosphatidylserine. ULTRASONICS SONOCHEMISTRY 2022; 83:105945. [PMID: 35149379 PMCID: PMC8841881 DOI: 10.1016/j.ultsonch.2022.105945] [Citation(s) in RCA: 8] [Impact Index Per Article: 4.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 12/23/2021] [Revised: 01/30/2022] [Accepted: 02/03/2022] [Indexed: 05/24/2023]
Abstract
In this study, the three-dimensional network system formed by rice bran wax (RBW) was used as the internal structure, and the external structure formed by soybean protein isolate (SPI) and phosphatidylserine (PS) was added on the basis of the internal structure to prepare walnut oil oleogel (SPI-PS-WOG). Ultrasonic treatment was applied to the mixed solution to make SPI-PS-WOG, on the basis, the effects of ultrasonic treatment on SPI-PS-WOG were investigated. The results showed that both β and β' crystalline forms were present in all SPI-PS-WOG samples. When the ultrasonic power was 450 W, the first weight loss peak in the thermogravimetric (TGA) curve appeared at 326 °C, which was shifted to the right compared to the peak that occurred when the ultrasonic power was 0 W, indicating that the thermal stability of the SPI-PS-WOG was improved by the ultrasonic treatment. Moreover, when the ultrasonic power was 450 W, the oil holding capacity (OHC) reached 95.3 %, which was the best compared with other groups. Both confocal laser scanning microscopy (CLSM) and scanning electron microscopy (SEM) showed that the ultrasonic treatment of appropriate power succeeded in making the SPI-PS-WOG samples more evenly dispersed in the internal structure and denser in the external structure. In terms of oxidative stability, it was found that the peroxide value of SPI-PS-WOG remained at 9.8 mmol/kg oil for 50 days under 450 W ultrasonic power treatment, which was significantly improved compared with liquid walnut oil (WO). These results provide a new idea for the preparation of oleogels, and also lay a theoretical foundation for the application of ultrasonic treatment in oleogels.
Collapse
Affiliation(s)
- Yingjie Yu
- School of Food Science, Northeast Agricultural University, Harbin 150030, China
| | - Tong Wang
- School of Food Science, Northeast Agricultural University, Harbin 150030, China
| | - Yuhang Gong
- School of Food Science, Northeast Agricultural University, Harbin 150030, China
| | - Weining Wang
- School of Computer and Information Engineering, Harbin University of Commerce, Harbin 150028, China
| | - Xue Wang
- School of Computer and Information Engineering, Harbin University of Commerce, Harbin 150028, China
| | - Dianyu Yu
- School of Food Science, Northeast Agricultural University, Harbin 150030, China.
| | - Fei Wu
- School of Food Science, Northeast Agricultural University, Harbin 150030, China.
| | - Liqi Wang
- School of Computer and Information Engineering, Harbin University of Commerce, Harbin 150028, China
| |
Collapse
|
37
|
Influence of sonocrystallization on lipid crystals multicomponent oleogels structuration and physical properties. Food Res Int 2022; 154:110997. [DOI: 10.1016/j.foodres.2022.110997] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/16/2021] [Revised: 12/20/2021] [Accepted: 01/03/2022] [Indexed: 11/19/2022]
|
38
|
Wang Z, Chandrapala J, Truong T, Farahnaky A. Oleogels prepared with low molecular weight gelators: Texture, rheology and sensory properties, a review. Crit Rev Food Sci Nutr 2022; 63:6069-6113. [PMID: 35057682 DOI: 10.1080/10408398.2022.2027339] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/03/2022]
Abstract
There is a growing need for healthier foods with no trans and reduced saturated fat. However, solid fats play critical roles in texture and sensory attributes of food products, making it challenging to eliminate them in foods. Recently, the concept of oleogelation as a novel oil structuring technique has received numerous attentions owing to their great potential to mimic the properties of solid fats. Understanding textural, rheological and sensory properties of oleogels helps predict the techno-functionalities of oleogels to replace solid fats in food products. This research critically reviews the textural and rheological properties of oleogels prepared by low molecular weight oleogelators (LMWGs) and functional characteristics of foods formulated by these oleogels. The mechanical properties of LMWG-containing oleogels are comprehensively discussed against conventional solid fats. The interactions between the oleogel and its surrounding food matrix are explained, and the sensory attributes of oleogel containing reformulated products are highlighted. Scientific insights into the texture and rheological properties of oleogels manufactured with a wide range of low molecular gelators and their related products are provided in order to boost their implication for creating healthier foods with high consumer acceptability. Future research opportunities on low molecular weight gelators are also discussed.
Collapse
Affiliation(s)
- Ziyu Wang
- Biosciences and Food Technology, School of Science, RMIT University, Melbourne, VIC, Australia
| | - Jayani Chandrapala
- Biosciences and Food Technology, School of Science, RMIT University, Melbourne, VIC, Australia
| | - Tuyen Truong
- Biosciences and Food Technology, School of Science, RMIT University, Melbourne, VIC, Australia
| | - Asgar Farahnaky
- Biosciences and Food Technology, School of Science, RMIT University, Melbourne, VIC, Australia
| |
Collapse
|
39
|
Xia T, Wei Z, Xue C. Impact of composite gelators on physicochemical properties of oleogels and astaxanthin delivery of oleogel-based nanoemulsions. Lebensm Wiss Technol 2022. [DOI: 10.1016/j.lwt.2021.112454] [Citation(s) in RCA: 6] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/26/2022]
|
40
|
LIMA TLS, Costa GFD, ALVES RDN, ARAÚJO CDLD, SILVA GFGD, RIBEIRO NL, FIGUEIREDO CFVD, ANDRADE ROD. Vegetable oils in emulsified meat products: a new strategy to replace animal fat. FOOD SCIENCE AND TECHNOLOGY 2022. [DOI: 10.1590/fst.103621] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/22/2022]
|
41
|
Silva TLTD, Fernandes GD, Arellano DB. The combination of monoglycerides, wax and hardfat on oleogels structuration. BRAZILIAN JOURNAL OF FOOD TECHNOLOGY 2022. [DOI: 10.1590/1981-6723.13721] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 11/21/2022]
Abstract
Abstract This study aimed to develop multicomponent oleogels to achieve desirable technological properties, affordability, and enhanced sensory acceptance for future food applications. Two Central Composite Rotatable Designs (CCRD) were performed with three independent variables, monoacylglycerols (MG), candelilla wax (CLX), and hardfat (HF). One design used soybean oil oleogels (SB) and the other used high oleic sunflower oil oleogels (SF). The variable responses evaluated were hardness (N), oil loss (%), thermal stability, and visual strength. For SB oleogels, CLX was related to the variable that was superior concerning all technological properties as >2 N in hardness, no oil loss, and higher stability to thermal treatment. For SF oleogels, the MG and the interactions of MG, CLX, and HF showed significant technological properties, indicating that the three oleogelators can co-crystallize better together in this oil, thus obtaining the same results as CLX alone in higher amounts.
Collapse
|
42
|
Zampouni K, Soniadis A, Moschakis T, Biliaderis C, Lazaridou A, Katsanidis E. Crystalline microstructure and physicochemical properties of olive oil oleogels formulated with monoglycerides and phytosterols. Lebensm Wiss Technol 2022. [DOI: 10.1016/j.lwt.2021.112815] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/25/2022]
|
43
|
Khacef L, Legros P, Hervé P, Ovarlez G, Medina-Gonzalez Y. Effect of Solvent on the Mechanical and Structural Properties of N-Alkyldiamide Organogels. LANGMUIR : THE ACS JOURNAL OF SURFACES AND COLLOIDS 2021; 37:14898-14910. [PMID: 34905373 DOI: 10.1021/acs.langmuir.1c02743] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 06/14/2023]
Abstract
Here, we study organogels prepared thanks to a new organogelator, the N-oleyldiamide molecule, which shows a remarkable propensity to gelify a large scope of solvents, from aprotic to high protic solvents. The solvent plays a key role in the formation and stability of supramolecular self-assemblies. However, the understanding and the control of its effects can be complex as many parameters are a priori involved. This study aims to understand the effect of solvent on the structures of organogels and on their final mechanical properties. Five solvent classes have been selected ranking from low protic to high protic, according to the Hansen H-bond parameter δh. The solvent proticity appears to be one of the main parameters that affect the organogel internal structure and therefore the final rheological properties. For a given organogelator fraction, the terminal elastic modulus measured by oscillatory rheology is observed to increase significantly with the Hansen H-bond solvent parameter δh. Materials of different mechanical properties are then shown to display various structures, which are investigated thanks to cryo-SEM. Besides, wide-angle X-ray scattering (WAXS) has been used to probe the gelator organization at the molecular scale with regard to the solvent nature, to understand the supramolecular self-assembly of this promising molecule.
Collapse
Affiliation(s)
- Leïla Khacef
- University of Bordeaux, CNRS, Solvay, LOF, UMR 5258, 33608 Pessac, France
| | - Philippe Legros
- University of Bordeaux, CNRS, PLACAMAT, UMS 3626, 33608 Pessac, France
| | - Pascal Hervé
- University of Bordeaux, CNRS, Solvay, LOF, UMR 5258, 33608 Pessac, France
| | - Guillaume Ovarlez
- University of Bordeaux, CNRS, Solvay, LOF, UMR 5258, 33608 Pessac, France
| | | |
Collapse
|
44
|
Study of oleogel as a frying medium for deep-fried chicken. JOURNAL OF FOOD MEASUREMENT AND CHARACTERIZATION 2021. [DOI: 10.1007/s11694-021-01237-6] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 10/19/2022]
|
45
|
Liao Z, Guo S, Lu M, Xiao J, Cao Y, Lan Y. Tailoring Water-Induced Multi-Component (Ceramide and Lecithin) Oleogels: Influence of Solute Added in Water. FOOD BIOPHYS 2021. [DOI: 10.1007/s11483-021-09702-x] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/19/2022]
|
46
|
Abstract
Lecithin is a mixture of amphiphilic lipids with health benefits. In this study, four different fractions (ethanol soluble, ethanol insoluble, phospholipid and glycolipid fractions) from soy lecithin were obtained and evaluated as oleogelators. As with the parent lecithin, the ethanol insoluble fraction (EIF) was unable to function as an oleogelator. The ethanol soluble fraction (ESF) and phospholipid fraction (PLF) formed oleogels at 30% (wt%), while the glycolipid fraction (GLF) formed oleogels at 15%. ESF resulted in an oleogel with a similar appearance and microstructure, but a harder and less cohesive texture than the PLF-supported oleogel. The oleogels formed with GLF were different from those formed with ESF and PLF in appearance and microstructure. GLF at 20% formed an oleogel with better texture characteristics (in the light of hardness) and oil-holding capacity than those formed with 30% of ESF and PLF. This is the first study to investigate the oil-gelling properties of fractions from soy lecithin. Our results show that the naturally occurring glycolipids from soy lecithin exhibit great potential as oleogelators.
Collapse
Affiliation(s)
- Meizhen Xie
- School of Food Equipment Engineering and Science, Xi'an Jiaotong University, Xi'an 710049, China
| | - Yan Yu
- School of Public Health, Xi'an Jiaotong University, Xi'an, 710049, China.
| | - Luwei Zhang
- School of Food Equipment Engineering and Science, Xi'an Jiaotong University, Xi'an 710049, China
| |
Collapse
|
47
|
Comparative study of the micro-rheological properties and microstructure of edible oil gels prepared by amino acid gelator. Colloids Surf A Physicochem Eng Asp 2021. [DOI: 10.1016/j.colsurfa.2021.127421] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/18/2022]
|
48
|
Emami SZ, Golestan L, Khoshtinat K, Shahidi S, Mohammadi M. Optimization of the oleogel‐vanaspati formulation based on rice bran wax and sorbitan monostearate. J FOOD PROCESS PRES 2021. [DOI: 10.1111/jfpp.15913] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/20/2022]
Affiliation(s)
- Seyed Ziaoddin Emami
- Department of Food hygiene Ayatollah Amoli Branch Islamic Azad University Amol Iran
| | - Leila Golestan
- Department of Food hygiene Ayatollah Amoli Branch Islamic Azad University Amol Iran
| | - Khadijeh Khoshtinat
- Department of Food Technology Research Faculty of Nutrition Sciences and Food Technology National Nutrition and Food Technology Research InstituteShahid Beheshti University of Medical Sciences Tehran Iran
| | - Seyed‐Ahmad Shahidi
- Department of Food Science and Technology, Ayatollah Amoli Branch Islamic Azad University Amol Iran
| | - Mehrdad Mohammadi
- Department of Food Technology Research Faculty of Nutrition Sciences and Food Technology National Nutrition and Food Technology Research InstituteShahid Beheshti University of Medical Sciences Tehran Iran
| |
Collapse
|
49
|
Matsuo K, Ueno S. Formation and Physical Analysis of Oleogels Composed of Edible Oils and High-Melting Fat Crystals. J Oleo Sci 2021; 70:1381-1390. [PMID: 34497180 DOI: 10.5650/jos.ess21119] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/13/2022] Open
Abstract
This paper reports the preparation of oleogels composed of edible oils (olive oil, squalene, and caprylic/capric triglyceride) and high-melting fat crystals (tribehenoyl-glycerol (BBB)) to explore the potential use of BBB/edible oil mixtures as low-cost and stable gelators. These mixtures exhibited gel-like behaviors upon rapid cooling and subsequent heating. The mixtures of BBB in the liquid oils formed oleogels at BBB concentrations > 4.0 wt%. The thermal behaviors, crystal structures, and crystal morphologies of mixtures of BBB produced from 6.0 wt% BBB crystals in 94.0 wt% liquid oils were examined following the treatment of these systems according to different temperature regimes. In addition, rheological analysis was conducted to evaluate the physical properties and storage stabilities of the prepared oleogels. It was found that rapid cooling to the crystallization temperature (Tc) from 70°C and subsequent heating to the final temperature (Tf) were necessary to reveal the gel-like behavior. In addition, the crystals treated with rapid cooling were smaller and more uniform in size than those treated with a simple cooling procedure. The differential scanning calorimetry melting peaks were broad or split, and exhibited the eutectic mixing behavior of multi-component triacylglycerols. The X-ray diffraction spectra showed that the melt-mediated α to β transformation of the mixtures was a prerequisite for revealing the gel-like behavior. Moreover, the tempering procedure was found to influence the physical properties of the oleogels, wherein no visible changes were observed for any of the oleogels after rapid cooling and storage for 6 months at 25°C.
Collapse
Affiliation(s)
- Kazuki Matsuo
- Frontier Research Center, POLA Chemical Industries, Inc.,Graduate School of Integrated Sciences for Life, Hiroshima University
| | - Satoru Ueno
- Graduate School of Integrated Sciences for Life, Hiroshima University
| |
Collapse
|
50
|
|