1
|
Rungruangsaphakun J, Ayimbila F, Nakphaichit M, Keawsompong S. Simulated Swine Digestion and Gut Microbiota Fermentation of Hydrolyzed Copra Meal. Animals (Basel) 2024; 14:1677. [PMID: 38891724 PMCID: PMC11171118 DOI: 10.3390/ani14111677] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/25/2024] [Revised: 05/20/2024] [Accepted: 05/22/2024] [Indexed: 06/21/2024] Open
Abstract
This study aimed to compare the effects of hydrolyzed copra meal (HCM) inclusion at 1% on its in vitro digestibility and the microbiota and cecum fermentation using the gut microbiota of weaned swine, targeting microbial community and short-chain fatty acids (SCF). For this reason, three treatments were considered: control (no copra meal), 1% non-hydrolyzed copra meal (CM), and 1% HCM. Non-defatted copra meal was hydrolyzed and analyzed (reducing sugars and total carbohydrates) in our laboratory. For digestion, microbiota identification, and fermentation assays, fresh fecal samples from two weaned pigs (1 month old) were used. Three replicates of each treatment were employed. HCM was more digestible, with approximately 0.68 g of hydrolysate recovered after simulated digestion compared to 0.82 g of hydrolysate recovered from CM. This was shown by Scanning Electron Microscope (SEM) images. Also, the three swine shared the majority of microbial species identified at the phylum and family levels. There were no differences (p > 0.05) between treatments in the microbial community and SCFA during fermentation. However, higher Chao-1 and Shannon indexes were observed in CM and HCM treatments. HCM was also found to be capable of preserving Actinobacterota and Proteobacteria at the phylum level, while at the family level, both treatments may help Lactobacillaceae, Peptostreptococcaceae, Lachnospiraceae, and Ruminococcaceae survive in the long term. Also, there was a potential trend of increasing acetic acid and butyric acid in the CM and HCM treatments. While HCM shows promise in potentially modulating the gut microbiota of weaned swine, additional research is required to investigate the effects of higher doses of HCM on swine performance parameters.
Collapse
Affiliation(s)
- Jurairat Rungruangsaphakun
- Specialized Research Unit: Prebiotics and Probiotics for Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University (CASAF, NRU-KU), Bangkok 10900, Thailand; (J.R.); (F.A.); (M.N.)
| | - Francis Ayimbila
- Specialized Research Unit: Prebiotics and Probiotics for Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University (CASAF, NRU-KU), Bangkok 10900, Thailand; (J.R.); (F.A.); (M.N.)
- Center for Advanced Studies for Agriculture and Food, KU Institute of Advanced Studies, Kasetsart University (CASAF, NRU-KU), Bangkok 10900, Thailand
| | - Massalin Nakphaichit
- Specialized Research Unit: Prebiotics and Probiotics for Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University (CASAF, NRU-KU), Bangkok 10900, Thailand; (J.R.); (F.A.); (M.N.)
- Center for Advanced Studies for Agriculture and Food, KU Institute of Advanced Studies, Kasetsart University (CASAF, NRU-KU), Bangkok 10900, Thailand
| | - Suttipun Keawsompong
- Specialized Research Unit: Prebiotics and Probiotics for Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University (CASAF, NRU-KU), Bangkok 10900, Thailand; (J.R.); (F.A.); (M.N.)
- Center for Advanced Studies for Agriculture and Food, KU Institute of Advanced Studies, Kasetsart University (CASAF, NRU-KU), Bangkok 10900, Thailand
| |
Collapse
|
2
|
Zhou T, Ju X, Yan L, Fang R, Xu X, Li L. Production of mannooligosaccharides from orange peel waste with β-mannanase expressed in Trichosporonoides oedocephalis. BIORESOURCE TECHNOLOGY 2024; 395:130373. [PMID: 38278453 DOI: 10.1016/j.biortech.2024.130373] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/08/2023] [Revised: 01/09/2024] [Accepted: 01/21/2024] [Indexed: 01/28/2024]
Abstract
A large quantity of orange peel waste (OPW) is generated per year, yet effective biorefinery methods are lacking. In this study, Trichosporonoides oedocephalis ATCC 16958 was employed for hydrolyzing OPW to produce soluble sugars. Glycosyl hydrolases from Paenibacillussp.LLZ1 which can hydrolyze cellulose and hemicellulose were mined and characterized, with the highest β-mannanase activity of 39.1 U/mg at pH 6.0 and 50 ℃. The enzyme was overexpressed in T. oedocephalis and the sugar production was enhanced by 16 %. The accumulated sugar contains 57 % value-added mannooligosaccharides by the hydrolysis of mannans. The process was intensified by a pretreatment combining H2O2 submergence and steam explosion to remove potential inhibitors. The mannooligosaccharides yield of 6.5 g/L was achieved in flask conversion and increased to 9.7 g/L in a 5-L fermenter. This study improved the effectiveness of orange peel waste processing, and provided a hydrolysis-based methodology for the utilization of fruit wastes.
Collapse
Affiliation(s)
- Taotao Zhou
- School of Chemistry and Life Sciences, Suzhou University of Science and Technology, Suzhou 215009, PR China
| | - Xin Ju
- School of Chemistry and Life Sciences, Suzhou University of Science and Technology, Suzhou 215009, PR China
| | - Lishi Yan
- School of Chemistry and Life Sciences, Suzhou University of Science and Technology, Suzhou 215009, PR China
| | - Ruiqi Fang
- School of Chemistry and Life Sciences, Suzhou University of Science and Technology, Suzhou 215009, PR China
| | - Xinqi Xu
- Fujian Key Laboratory of Marine Enzyme Engineering, Fuzhou University, Fujian 350116, PR China
| | - Liangzhi Li
- School of Chemistry and Life Sciences, Suzhou University of Science and Technology, Suzhou 215009, PR China.
| |
Collapse
|
3
|
Zheng F, Basit A, Wang J, Zhuang H, Chen J, Zhang J. Biochemical analyses of a novel acidophilic GH5 β-mannanase from Trichoderma asperellum ND-1 and its application in mannooligosaccharides production from galactomannans. Front Microbiol 2023; 14:1191553. [PMID: 37362936 PMCID: PMC10288326 DOI: 10.3389/fmicb.2023.1191553] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/24/2023] [Accepted: 05/09/2023] [Indexed: 06/28/2023] Open
Abstract
In this study, an acidophilic GH5 β-mannanase (TaMan5) from Trichoderma asperellum ND-1 was efficiently expressed in Pichia pastoris (a 2.0-fold increase, 67.5 ± 1.95 U/mL). TaMan5 displayed the highest specificity toward locust bean gum (Km = 1.34 mg/mL, Vmax = 749.14 μmol/min/mg) at pH 4.0 and 65°C. Furthermore, TaMan5 displayed remarkable tolerance to acidic environments, retaining over 80% of its original activity at pH 3.0-5.0. The activity of TaMan5 was remarkably decreased by Cu2+, Mn2+, and SDS, while Fe2+/Fe3+ improved the enzyme activity. A thin-layer chromatography (TLC) analysis of the action model showed that TaMan5 could rapidly degrade mannan/MOS into mannobiose without mannose via hydrolysis action as well as transglycosylation. Site-directed mutagenesis results suggested that Glu205, Glu313, and Asp357 of TaMan5 are crucial catalytic residues, with Asp152 playing an auxiliary function. Additionally, TaMan5 and commercial α-galactosidase displayed a remarkable synergistic effect on the degradation of galactomannans. This study provided a novel β-mannanase with ideal characteristics and can be considered a potential candidate for the production of bioactive polysaccharide mannobiose.
Collapse
Affiliation(s)
- Fengzhen Zheng
- College of Biological and Environmental Engineering, Zhejiang Shuren University, Hangzhou, China
| | - Abdul Basit
- Department of Microbiology, University of Jhang, Jhang, Pakistan
| | - Jiaqiang Wang
- College of Biological and Environmental Engineering, Zhejiang Shuren University, Hangzhou, China
| | - Huan Zhuang
- Department of ENT and Head and Neck Surgery, The Children's Hospital Zhejiang University School of Medicine, Hangzhou, Zhejiang, China
| | - Jun Chen
- Interdisciplinary Research Academy, Zhejiang Shuren University, Hangzhou, China
| | - Jianfen Zhang
- College of Biological and Environmental Engineering, Zhejiang Shuren University, Hangzhou, China
| |
Collapse
|
4
|
Yan S, Duan B, Liu C, Liu G, Kang L, Sun L, Yi L, Zhang Z, Liu Z, Yuan S. Heterologous Expression, Purification and Characterization of an Alkalic Thermophilic β-Mannanase CcMan5C from Coprinopsis cinerea. J Fungi (Basel) 2023; 9:jof9030378. [PMID: 36983546 PMCID: PMC10056200 DOI: 10.3390/jof9030378] [Citation(s) in RCA: 5] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 01/28/2023] [Revised: 03/15/2023] [Accepted: 03/15/2023] [Indexed: 03/30/2023] Open
Abstract
A endo-1,4-β-mannanase (CcMan5C) gene was cloned from Coprinopsis cinerea and heterologously expressed in Pichia pastoris, and the recombinant enzyme was purified by Ni-affinity chromatography and identified by matrix-assisted laser desorption/ionization time-of-flight mass spectrometry (MALDI-TOF/TOF-MS). CcMan5C hydrolyzed only locust bean gum galactomannan (LBG) but not α-mannan from S. cerevisiae or Avicel cellulose, oat spelt xylan, or laminarin from Laminaria digitata. CcMan5C exhibited distinctive catalytic features that were different from previously reported β-mannanases. (1) CcMan5C is the first reported fungal β-mannase with an optimal alkalic pH of 8.0-9.0 for hydrolytic activity under assay conditions. (2) CcMan5C is the first reported alkalic fungal β-mannase with an optimal temperature of 70 °C for hydrolytic activity under assay conditions. (3) The organic solvents methanol, ethanol, isopropanol, and acetone at concentrations of 10% or 20% did not inhibit CcMan5C activity, while 10% or 20% isopropanol and acetone even enhanced CcMan5C activity by 9.20-34.98%. Furthermore, CcMan5C tolerated detergents such as Tween 20 and Triton X-100, and its activity was even enhanced to 26.2-45.6% by 1% or 10% Tween 20 and Triton X-100. (4) CcMan5C solution or lyophilized CcMan5C exhibited unchanged activity and even increasing activity after being stored at -20 °C or -80 °C for 12 months and retained above 50% activity after being stored at 4 °C for 12 months. These features make CcMan5C a suitable candidate for the detergent industry and paper and pulp industry.
Collapse
Affiliation(s)
- Songling Yan
- Jiangsu Key Laboratory for Microbes and Microbial Functional Genomics, Jiangsu Engineering and Technology Research Center for Industrialization of Microbial Resources, College of Life Science, Nanjing Normal University, 1 Wenyuan Road, Nanjing 210023, China
| | - Baiyun Duan
- Jiangsu Key Laboratory for Microbes and Microbial Functional Genomics, Jiangsu Engineering and Technology Research Center for Industrialization of Microbial Resources, College of Life Science, Nanjing Normal University, 1 Wenyuan Road, Nanjing 210023, China
| | - Cuicui Liu
- Jiangsu Key Laboratory for Microbes and Microbial Functional Genomics, Jiangsu Engineering and Technology Research Center for Industrialization of Microbial Resources, College of Life Science, Nanjing Normal University, 1 Wenyuan Road, Nanjing 210023, China
| | - Guiyou Liu
- School of Life Science and Chemical Engineering, Jiangsu Second Normal University, Nanjing 211200, China
| | - Liqin Kang
- School of Life Science and Chemical Engineering, Jiangsu Second Normal University, Nanjing 211200, China
| | - Lei Sun
- School of Life Science and Chemical Engineering, Jiangsu Second Normal University, Nanjing 211200, China
| | - Lin Yi
- Jiangsu Key Laboratory of Translational Research and Therapy for Neuro-Psycho-Diseases and College of Pharmaceutical Sciences, Soochow University, Suzhou 215021, China
| | - Zhenqing Zhang
- Jiangsu Key Laboratory of Translational Research and Therapy for Neuro-Psycho-Diseases and College of Pharmaceutical Sciences, Soochow University, Suzhou 215021, China
| | - Zhonghua Liu
- Jiangsu Key Laboratory for Microbes and Microbial Functional Genomics, Jiangsu Engineering and Technology Research Center for Industrialization of Microbial Resources, College of Life Science, Nanjing Normal University, 1 Wenyuan Road, Nanjing 210023, China
| | - Sheng Yuan
- Jiangsu Key Laboratory for Microbes and Microbial Functional Genomics, Jiangsu Engineering and Technology Research Center for Industrialization of Microbial Resources, College of Life Science, Nanjing Normal University, 1 Wenyuan Road, Nanjing 210023, China
| |
Collapse
|
5
|
Characteristics and bioactive properties of agro-waste and yeast derived manno-oligosaccharides. BIOCATALYSIS AND AGRICULTURAL BIOTECHNOLOGY 2022. [DOI: 10.1016/j.bcab.2022.102522] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/05/2022]
|
6
|
Long C, Qi XL, Venema K. Chemical and nutritional characteristics, and microbial degradation of rapeseed meal recalcitrant carbohydrates: A review. Front Nutr 2022; 9:948302. [PMID: 36245487 PMCID: PMC9554435 DOI: 10.3389/fnut.2022.948302] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/19/2022] [Accepted: 08/31/2022] [Indexed: 11/13/2022] Open
Abstract
Approximately 35% of rapeseed meal (RSM) dry matter (DM) are carbohydrates, half of which are water-soluble carbohydrates. The cell wall of rapeseed meal contains arabinan, galactomannan, homogalacturonan, rhamnogalacturonan I, type II arabinogalactan, glucuronoxylan, XXGG-type and XXXG-type xyloglucan, and cellulose. Glycoside hydrolases including in the degradation of RSM carbohydrates are α-L-Arabinofuranosidases (EC 3.2.1.55), endo-α-1,5-L-arabinanases (EC 3.2.1.99), Endo-1,4-β-mannanase (EC 3.2.1.78), β-mannosidase (EC 3.2.1.25), α-galactosidase (EC 3.2.1.22), reducing-end-disaccharide-lyase (pectate disaccharide-lyase) (EC 4.2.2.9), (1 → 4)-6-O-methyl-α-D-galacturonan lyase (pectin lyase) (EC 4.2.2.10), (1 → 4)-α-D-galacturonan reducing-end-trisaccharide-lyase (pectate trisaccharide-lyase) (EC 4.2.2.22), α-1,4-D-galacturonan lyase (pectate lyase) (EC 4.2.2.2), (1 → 4)-α-D-galacturonan glycanohydrolase (endo-polygalacturonase) (EC 3.2.1.15), Rhamnogalacturonan hydrolase, Rhamnogalacturonan lyase (EC 4.2.2.23), Exo-β-1,3-galactanase (EC 3.2.1.145), endo-β-1,6-galactanase (EC 3.2.1.164), Endo-β-1,4-glucanase (EC 3.2.1.4), α-xylosidase (EC 3.2.1.177), β-glucosidase (EC 3.2.1.21) endo-β-1,4-glucanase (EC 3.2.1.4), exo-β-1,4-glucanase (EC 3.2.1.91), and β-glucosidase (EC 3.2.1.21). In conclusion, this review summarizes the chemical and nutritional compositions of RSM, and the microbial degradation of RSM cell wall carbohydrates which are important to allow to develop strategies to improve recalcitrant RSM carbohydrate degradation by the gut microbiota, and eventually to improve animal feed digestibility, feed efficiency, and animal performance.
Collapse
Affiliation(s)
- Cheng Long
- Animal Science and Technology College, Beijing University of Agriculture, Beijing, China
- Faculty of Science and Engineering, Centre for Healthy Eating and Food Innovation, Maastricht University - Campus Venlo, Venlo, Netherlands
| | - Xiao-Long Qi
- Animal Science and Technology College, Beijing University of Agriculture, Beijing, China
| | - Koen Venema
- Faculty of Science and Engineering, Centre for Healthy Eating and Food Innovation, Maastricht University - Campus Venlo, Venlo, Netherlands
- *Correspondence: Koen Venema
| |
Collapse
|
7
|
Selection of pretreatment method and mannanase enzyme to improve the functionality of palm kernel cake. J Biosci Bioeng 2022; 134:301-306. [PMID: 35970725 DOI: 10.1016/j.jbiosc.2022.06.016] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/19/2021] [Revised: 06/28/2022] [Accepted: 06/29/2022] [Indexed: 11/22/2022]
Abstract
Palm kernel cake (PKC) is a by-product of palm kernel oil extraction with moderate nutritional value, containing 30-35% β-mannan, which is indigestible, slows growth, and reduces feed efficiency. PKC can be improved by mannanase hydrolysis, but the effectiveness of mannanase is dependent on the microbial source. Thus, the effect of steam pretreatment and bacterial mannanases on PKC quality was investigated. PKC was pretreated by steaming and hydrolyzed in the small intestine by various mannanases. The contents of reducing sugar, total sugar, and protein release were measured. Steamed PKC had a significant increase in protein (16.95 ± 0.14 to 20.98 ± 0.13%) and a substantial decrease in hemicellulose (29.52 ± 0.44 to 3.46 ± 0.88%) and lignin (8.94 ± 0.28 to 1.40 ± 0.22%). Mannanases from Escherichia coli-KMAN-3 and E. coli-Man6.7 recorded the highest activities, followed by commercial mannanase, Bacillus circulans NT6.7 and B. amyloliquefaciens NT6.3 mannanases, orderly. B. circulans NT6.7 and B. amyloliquefaciens NT6.3 had multi-activities that include glucanase (3.10 ± 0.04% and 2.47 ± 0.02%) and amylase (1.74 ± 0.03% and 1.38 ± 0.04%), respectively. B. amyloliquefaciens NT6.3 mannanase hydrolyzed steamed PKC to release more reducing sugar, total sugar, and protein than hydrolyzed raw PKC. In raw and steamed PKC, B. amyloliquefaciens NT6.3 mannanase produced the highest reducing sugar release. As a result, steam pretreatment and mannanase hydrolysis, particularly from B. amyloliquefaciens, can be used to increase the functioning of PKC and develop new feed ingredients for monogastric animals at a reasonable cost.
Collapse
|
8
|
Sun D, Li C, Cui P, Zhang J, Zhou Y, Wu M, Li X, Wang TF, Zeng Z, Qin HM. Reshaping the binding channel of a novel GH113 family β-mannanase from Paenibacillus cineris (PcMan113) for enhanced activity. BIORESOUR BIOPROCESS 2022; 9:17. [PMID: 38647808 PMCID: PMC10992819 DOI: 10.1186/s40643-022-00505-7] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/15/2021] [Accepted: 02/13/2022] [Indexed: 11/10/2022] Open
Abstract
Endo-β-mannanases are important enzymes for degrading lignocellulosic biomass to generate mannan, which has significant health effects as a prebiotic that promotes the development of gut microbiota. Here, a novel endo-β-mannanase belonging to glycoside hydrolase (GH) family 113 from Paenibacillus cineris (PcMan113) was cloned, expressed and characterized, as one of only a few reported GH113 family β-mannanases. Compared to other functionally and structurally characterized GH113 mannanases, recombinant PcMan113 showed a broader substrate spectrum and a better performance. Based on a structural homology model, the highly active mutant PcMT3 (F110E/N246Y) was obtained, with 4.60- and 5.53-fold increases of enzyme activity (towards KG) and catalytic efficiency (kcat/Km, against M5) compared with the WT enzyme, respectively. Furthermore, molecular dynamics (MD) simulations were conducted to precisely explore the differences of catalytic activity between WT and PcMT3, which revealed that PcMT3 has a less flexible conformation, as well as an enlarged substrate-binding channel with decreased steric hindrance and increased binding energy in substrate recognition. In conclusion, we obtained a highly active variant of PcMan113 with potential for commercial application in the manufacture of manno-oligosaccharides.
Collapse
Affiliation(s)
- Dengyue Sun
- State Key Laboratory of Biobased Material and Green Papermaking, College of Bioengineering, Qilu University of Technology, Shandong Academy of Sciences, Jinan, 250100, People's Republic of China
- School of Bioengineering, Qilu University of Technology, Shandong Province, Jinan, 250353, People's Republic of China
| | - Chao Li
- College of Biotechnology, Tianjin University of Science and Technology, Tianjin, 300457, People's Republic of China
| | - Pengpeng Cui
- School of Bioengineering, Qilu University of Technology, Shandong Province, Jinan, 250353, People's Republic of China
| | - Jie Zhang
- School of Bioengineering, Qilu University of Technology, Shandong Province, Jinan, 250353, People's Republic of China
| | - Yaolin Zhou
- School of Bioengineering, Qilu University of Technology, Shandong Province, Jinan, 250353, People's Republic of China
| | - Mian Wu
- College of Biotechnology, Tianjin University of Science and Technology, Tianjin, 300457, People's Republic of China
| | - Xia Li
- School of Bioengineering, Qilu University of Technology, Shandong Province, Jinan, 250353, People's Republic of China
| | - Teng-Fei Wang
- State Key Laboratory of Biobased Material and Green Papermaking, College of Bioengineering, Qilu University of Technology, Shandong Academy of Sciences, Jinan, 250100, People's Republic of China
- School of Bioengineering, Qilu University of Technology, Shandong Province, Jinan, 250353, People's Republic of China
| | - Zhixiong Zeng
- School of Bioengineering, Qilu University of Technology, Shandong Province, Jinan, 250353, People's Republic of China.
| | - Hui-Min Qin
- State Key Laboratory of Biobased Material and Green Papermaking, College of Bioengineering, Qilu University of Technology, Shandong Academy of Sciences, Jinan, 250100, People's Republic of China.
- College of Biotechnology, Tianjin University of Science and Technology, Tianjin, 300457, People's Republic of China.
| |
Collapse
|
9
|
Pongsapipatana N, Charoenwattanasatien R, Pramanpol N, Nguyen TH, Haltrich D, Nitisinprasert S, Keawsompong S. Crystallization, structural characterization and kinetic analysis of a GH26 β-mannanase from Klebsiella oxytoca KUB-CW2-3. ACTA CRYSTALLOGRAPHICA SECTION D-STRUCTURAL BIOLOGY 2021; 77:1425-1436. [PMID: 34726170 DOI: 10.1107/s2059798321009992] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/14/2021] [Accepted: 09/25/2021] [Indexed: 11/10/2022]
Abstract
β-Mannanase (EC 3.2.1.78) is an enzyme that cleaves within the backbone of mannan-based polysaccharides at β-1,4-linked D-mannose residues, resulting in the formation of mannooligosaccharides (MOS), which are potential prebiotics. The GH26 β-mannanase KMAN from Klebsiella oxytoca KUB-CW2-3 shares 49-72% amino-acid sequence similarity with β-mannanases from other sources. The crystal structure of KMAN at a resolution of 2.57 Å revealed an open cleft-shaped active site. The enzyme structure is based on a (β/α)8-barrel architecture, which is a typical characteristic of clan A glycoside hydrolase enzymes. The putative catalytic residues Glu183 and Glu282 are located on the loop connected to β-strand 4 and at the end of β-strand 7, respectively. KMAN digests linear MOS with a degree of polymerization (DP) of between 4 and 6, with high catalytic efficiency (kcat/Km) towards DP6 (2571.26 min-1 mM-1). The predominant end products from the hydrolysis of locust bean gum, konjac glucomannan and linear MOS are mannobiose and mannotriose. It was observed that KMAN requires at least four binding sites for the binding of substrate molecules and hydrolysis. Molecular docking of mannotriose and galactosyl-mannotetraose to KMAN confirmed its mode of action, which prefers linear substrates to branched substrates.
Collapse
Affiliation(s)
- Nawapan Pongsapipatana
- Specialized Research Unit: Prebiotics and Probiotics for Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok 10900, Thailand
| | - Ratana Charoenwattanasatien
- Synchrotron Light Research Institute (Public Organization), 111 University Avenue, Nakhon Ratchasima 30000, Thailand
| | - Nuttawan Pramanpol
- National Center for Genetic Engineering and Biotechnology, 113 Thailand Science Park, Phahonyothin Road, Klong Nueng, Klong Luang, Pathumthani 12120, Thailand
| | - Thu Ha Nguyen
- Food Biotechnology Laboratory, Department of Food Science and Technology, BOKU - University of Natural Resources and Life Sciences, Vienna, Austria
| | - Dietmar Haltrich
- Food Biotechnology Laboratory, Department of Food Science and Technology, BOKU - University of Natural Resources and Life Sciences, Vienna, Austria
| | - Sunee Nitisinprasert
- Specialized Research Unit: Prebiotics and Probiotics for Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok 10900, Thailand
| | - Suttipun Keawsompong
- Specialized Research Unit: Prebiotics and Probiotics for Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok 10900, Thailand
| |
Collapse
|
10
|
Hernández-Macias S, Comas-Basté O, Jofré A, Bover-Cid S, Latorre-Moratalla ML, Vidal-Carou MC. Growth-Promoting Effect of Cava Lees on Lactic Acid Bacteria Strains: A Potential Revalorization Strategy of a Winery By-Product. Foods 2021; 10:foods10071636. [PMID: 34359506 PMCID: PMC8306662 DOI: 10.3390/foods10071636] [Citation(s) in RCA: 6] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 06/07/2021] [Revised: 07/09/2021] [Accepted: 07/12/2021] [Indexed: 12/17/2022] Open
Abstract
The growing trend of circular economy has prompted the design of novel strategies for the revalorization of food industry by-products. Cava lees, a winery by-product consisting of non-viable cells of Saccharomyces cerevisiae rich in β-glucans and mannan-oligosaccharides, can be used as a microbial growth promoter, with potential food safety and health applications. The aim of this study was to assess in vitro the effect of cava lees on the growth of 21 strains of lactic acid bacteria (LAB) species commonly used as starter cultures and/or probiotics. Firstly, 5% of cava lees was selected as the most effective amount for enhancing microbial counts. After screening different LAB, statistically significantly (p < 0.05) higher microbial counts were found in 12 strains as a consequence of cava lees supplementation. Moreover, a greater and faster reduction in pH was observed in most of these strains. The growth-promoting effects of cava lees on LAB strains supports the potential revalorization of this winery by-product, either to improve the safety of fermented products or as a health-promoting prebiotic that may be selectively fermented by probiotic species.
Collapse
Affiliation(s)
- Salvador Hernández-Macias
- Departament de Nutrició, Ciències de l’Alimentació i Gastronomia, Facultat de Farmàcia i Ciències de l’Alimentació, Campus de l’Alimentació de Torribera, Universitat de Barcelona (UB), Av. Prat de la Riba 171, 08921 Santa Coloma de Gramenet, Spain; (S.H.-M.); (O.C.-B.); (M.L.L.-M.)
- Institut de Recerca en Nutrició i Seguretat Alimentària (INSA·UB), Universitat de Barcelona (UB), Av. Prat de la Riba 171, 08921 Santa Coloma de Gramenet, Spain
- Xarxa d’Innovació Alimentària (XIA), C/Baldiri Reixac 4, 08028 Barcelona, Spain
| | - Oriol Comas-Basté
- Departament de Nutrició, Ciències de l’Alimentació i Gastronomia, Facultat de Farmàcia i Ciències de l’Alimentació, Campus de l’Alimentació de Torribera, Universitat de Barcelona (UB), Av. Prat de la Riba 171, 08921 Santa Coloma de Gramenet, Spain; (S.H.-M.); (O.C.-B.); (M.L.L.-M.)
- Institut de Recerca en Nutrició i Seguretat Alimentària (INSA·UB), Universitat de Barcelona (UB), Av. Prat de la Riba 171, 08921 Santa Coloma de Gramenet, Spain
- Xarxa d’Innovació Alimentària (XIA), C/Baldiri Reixac 4, 08028 Barcelona, Spain
| | - Anna Jofré
- Food Safety and Functionality Programme, Institute of Agrifood Research and Technology (IRTA), Finca Camps i Armet s/n, 17121 Monells, Spain; (A.J.); (S.B.-C.)
| | - Sara Bover-Cid
- Food Safety and Functionality Programme, Institute of Agrifood Research and Technology (IRTA), Finca Camps i Armet s/n, 17121 Monells, Spain; (A.J.); (S.B.-C.)
| | - M. Luz Latorre-Moratalla
- Departament de Nutrició, Ciències de l’Alimentació i Gastronomia, Facultat de Farmàcia i Ciències de l’Alimentació, Campus de l’Alimentació de Torribera, Universitat de Barcelona (UB), Av. Prat de la Riba 171, 08921 Santa Coloma de Gramenet, Spain; (S.H.-M.); (O.C.-B.); (M.L.L.-M.)
- Institut de Recerca en Nutrició i Seguretat Alimentària (INSA·UB), Universitat de Barcelona (UB), Av. Prat de la Riba 171, 08921 Santa Coloma de Gramenet, Spain
- Xarxa d’Innovació Alimentària (XIA), C/Baldiri Reixac 4, 08028 Barcelona, Spain
| | - M. Carmen Vidal-Carou
- Departament de Nutrició, Ciències de l’Alimentació i Gastronomia, Facultat de Farmàcia i Ciències de l’Alimentació, Campus de l’Alimentació de Torribera, Universitat de Barcelona (UB), Av. Prat de la Riba 171, 08921 Santa Coloma de Gramenet, Spain; (S.H.-M.); (O.C.-B.); (M.L.L.-M.)
- Institut de Recerca en Nutrició i Seguretat Alimentària (INSA·UB), Universitat de Barcelona (UB), Av. Prat de la Riba 171, 08921 Santa Coloma de Gramenet, Spain
- Xarxa d’Innovació Alimentària (XIA), C/Baldiri Reixac 4, 08028 Barcelona, Spain
- Correspondence: ; Tel.: +34-934-031-984
| |
Collapse
|
11
|
Zhang R, Li XY, Cen XL, Gao QH, Zhang M, Li KY, Wu Q, Mu YL, Tang XH, Zhou JP, Huang ZX. Enzymatic preparation of manno-oligosaccharides from locust bean gum and palm kernel cake, and investigations into its prebiotic activity. ELECTRON J BIOTECHN 2021. [DOI: 10.1016/j.ejbt.2020.11.001] [Citation(s) in RCA: 7] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/06/2023] Open
|
12
|
Jana UK, Suryawanshi RK, Prajapati BP, Kango N. Prebiotic mannooligosaccharides: Synthesis, characterization and bioactive properties. Food Chem 2020; 342:128328. [PMID: 33257024 DOI: 10.1016/j.foodchem.2020.128328] [Citation(s) in RCA: 37] [Impact Index Per Article: 9.3] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/07/2020] [Revised: 08/08/2020] [Accepted: 10/05/2020] [Indexed: 12/13/2022]
Abstract
Functional oligosaccharides are non-digestible food ingredients that confer numerous health benefits. Among these, mannooligosaccharides (MOS) are emerging prebiotics that have characteristic potential bio-active properties. Microbial mannanases can be used to break down mannan rich agro-residues to yield MOS. Various applications of MOS as health promoting functional food ingredient may open up newer opportunities in food and feed industry. Enzymatic hydrolysis is the widely preferred method over chemical hydrolysis for MOS production. Presently, commercial MOS is being derived from yeast cell wall mannan and is widely used as prebiotic in feed supplements for poultry and aquaculture. Apart from stimulating the growth of probiotic microflora, MOS impart anticancer and immunomodulatory effects by inducing different gene markers in colon cells. This review summarizes recent developments and future prospects of enzymatic synthesis of MOS from various mannans, their structural characteristics and their potential health benefits.
Collapse
Affiliation(s)
- Uttam Kumar Jana
- Department of Microbiology, Dr. Harisingh Gour Vishwavidyalaya (A Central University), Sagar, MP 470003, India.
| | - Rahul Kumar Suryawanshi
- Department of Microbiology, Dr. Harisingh Gour Vishwavidyalaya (A Central University), Sagar, MP 470003, India.
| | - Bhanu Pratap Prajapati
- Department of Microbiology, Dr. Harisingh Gour Vishwavidyalaya (A Central University), Sagar, MP 470003, India.
| | - Naveen Kango
- Department of Microbiology, Dr. Harisingh Gour Vishwavidyalaya (A Central University), Sagar, MP 470003, India.
| |
Collapse
|
13
|
Expression, Characterization and Structure Analysis of a New GH26 Endo-β-1, 4-Mannanase (Man26E) from Enterobacter aerogenes B19. APPLIED SCIENCES-BASEL 2020. [DOI: 10.3390/app10217584] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/15/2022]
Abstract
β-mannanase is one of the key enzymes to hydrolyze hemicellulose. At present, most β-mannanases are not widely applied because of their low enzyme activity and unsuitable enzymatic properties. In this work, a new β-mannanase from Enterobacter aerogenes was studied, which laid the foundation for its further application. Additionally, we will further perform directed evolution of the enzyme to increase its activity, improve its temperature and pH properties to allow it more applications in industry. A new β-mannanase (Man26E) from Enterobacter aerogenes was successfully expressed in Escherichia coli. Man26E showed about 40 kDa on SDS-PAGE gel. The SWISS-MODEL program was used to model the tertiary structure of Man26E, which presented a core (α/β)8-barrel catalytic module. Based on the binding pattern of CjMan26 C, Man26E docking Gal1Man4 was investigated. The catalytic region consisted of a surface containing four solvent-exposed aromatic rings, many hydrophilic and charged residues. Man26E displayed the highest activity at pH 6.0 and 55 °C, and high acid and alkali stability in a wide pH range (pH 4–10) and thermostability from 40 to 50 °C. The enzyme showed the highest activity on locust bean gum, and the Km and Vmax were 7.16 mg mL−1 and 508 U mg−1, respectively. This is the second β-mannanase reported from Enterobacter aerogenes B19. The β-mannanase displayed high enzyme activity, a relatively high catalytic temperature and a broad range of catalytic pH values. The enzyme catalyzed both polysaccharides and manno-oligosaccharides.
Collapse
|
14
|
Liu S, Cui T, Song Y. Expression, homology modeling and enzymatic characterization of a new β-mannanase belonging to glycoside hydrolase family 1 from Enterobacter aerogenes B19. Microb Cell Fact 2020; 19:142. [PMID: 32665004 PMCID: PMC7362650 DOI: 10.1186/s12934-020-01399-w] [Citation(s) in RCA: 6] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 04/25/2020] [Accepted: 07/07/2020] [Indexed: 02/01/2023] Open
Abstract
BACKGROUND β-mannanase can hydrolyze β-1,4 glycosidic bond of mannan by the manner of endoglycosidase to generate mannan-oligosaccharides. Currently, β-mannanase has been widely applied in food, medicine, textile, paper and petroleum exploitation industries. β-mannanase is widespread in various organisms, however, microorganisms are the main source of β-mannanases. Microbial β-mannanases display wider pH range, temperature range and better thermostability, acid and alkali resistance, and substrate specificity than those from animals and plants. Therefore microbial β-mannanases are highly valued by researchers. Recombinant bacteria constructed by gene engineering and modified by protein engineering have been widely applied to produce β-mannanase, which shows more advantages than traditional microbial fermentation in various aspects. RESULTS A β-mannanase gene (Man1E), which encoded 731 amino acid residues, was cloned from Enterobacter aerogenes. Man1E was classified as Glycoside Hydrolase family 1. The bSiteFinder prediction showed that there were eight essential residues in the catalytic center of Man1E as Trp166, Trp168, Asn229, Glu230, Tyr281, Glu309, Trp341 and Lys374. The catalytic module and carbohydrate binding module (CBM) of Man1E were homologously modeled. Superposition analysis and molecular docking revealed the residues located in the catalytic module of Man1E and the CBM of Man1E. The recombinant enzyme was successfully expressed, purified, and detected about 82.5 kDa by SDS-PAGE. The optimal reaction condition was 55 °C and pH 6.5. The enzyme exhibited high stability below 60 °C, and in the range of pH 3.5-8.5. The β-mannanase activity was activated by low concentration of Co2+, Mn2+, Zn2+, Ba2+ and Ca2+. Man1E showed the highest affinity for Locust bean gum (LBG). The Km and Vmax values for LBG were 3.09 ± 0.16 mg/mL and 909.10 ± 3.85 μmol/(mL min), respectively. CONCLUSIONS A new type of β-mannanase with high activity from E. aerogenes is heterologously expressed and characterized. The enzyme belongs to an unreported β-mannanase family (CH1 family). It displays good pH and temperature features and excellent catalysis capacity for LBG and KGM. This study lays the foundation for future application and molecular modification to improve its catalytic efficiency and substrate specificity.
Collapse
Affiliation(s)
- Siyu Liu
- School of Biological Science and Bioengineering, South China University of Technology, Guangzhou, 510006, China
| | - Tangbing Cui
- School of Biological Science and Bioengineering, South China University of Technology, Guangzhou, 510006, China.
| | - Yan Song
- School of Biological Science and Bioengineering, South China University of Technology, Guangzhou, 510006, China
| |
Collapse
|
15
|
Kumar Suryawanshi R, Kango N. Production of mannooligosaccharides from various mannans and evaluation of their prebiotic potential. Food Chem 2020; 334:127428. [PMID: 32688173 DOI: 10.1016/j.foodchem.2020.127428] [Citation(s) in RCA: 27] [Impact Index Per Article: 6.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/04/2019] [Revised: 06/23/2020] [Accepted: 06/23/2020] [Indexed: 12/18/2022]
Abstract
Aspergillus quadrilineatus endo-β-mannanase effectively degraded konjac glucomannan (66.09% w/v), copra meal (38.99% w/v) and locust bean galactomannan (20.94% w/v). High performance liquid chromatography (HPLC) analysis of KG hydrolysate indicated its mannooligosaccharides (MOS) content (656.38 mg/g) with high amounts of DP 5 oligosaccharide. Multi-scale characterization of mannan hydrolysate was done using FTIR and 13C NMR which revealed α and β form of galactose or glucose in MOS, respectively. CM and LBG hydrolysates (1 mg/mL) have shown cytotoxic effect and reduced cell viability of Caco-2 cells by 45% and 62%, respectively. MOS DP (1-4) derived from LBG supported better Lactobacilli biofilm formation as compared to KG hydrolysate containing high DP MOS (5-7). Lactobacilli effectively fermented MOS to generate acetate and propionate as main short chain fatty acids. Lactobacilli produced leucine, isoleucine and valine as branched chain amino acids when grown on LBG hydrolysate.
Collapse
Affiliation(s)
- Rahul Kumar Suryawanshi
- Department of Microbiology, Dr. Harisingh Gour Vishwavidyalaya (A Central University), Sagar, Madhya Pradesh 470003, India.
| | - Naveen Kango
- Department of Microbiology, Dr. Harisingh Gour Vishwavidyalaya (A Central University), Sagar, Madhya Pradesh 470003, India.
| |
Collapse
|
16
|
Zhao D, Zhang X, Wang Y, Na J, Ping W, Ge J. Purification, biochemical and secondary structural characterisation of β-mannanase from Lactobacillus casei HDS-01 and juice clarification potential. Int J Biol Macromol 2020; 154:826-834. [DOI: 10.1016/j.ijbiomac.2020.03.157] [Citation(s) in RCA: 8] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/11/2020] [Revised: 03/16/2020] [Accepted: 03/16/2020] [Indexed: 10/24/2022]
|
17
|
Rheological and physicochemical properties of polysaccharides extracted from stems of Dendrobium officinale. Food Hydrocoll 2020. [DOI: 10.1016/j.foodhyd.2020.105706] [Citation(s) in RCA: 28] [Impact Index Per Article: 7.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/12/2022]
|
18
|
Sritrakul N, Nitisinprasert S, Keawsompong S. Copra meal hydrolysis by the recombinant β-mannanase KMAN-3 and MAN 6.7 expressed in Escherichia coli. 3 Biotech 2020; 10:44. [PMID: 31988838 PMCID: PMC6954935 DOI: 10.1007/s13205-019-2005-0] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/22/2019] [Accepted: 12/02/2019] [Indexed: 10/25/2022] Open
Abstract
Hydrolysis products of defatted copra meal (DCM) hydrolysis were investigated with either recombinant β-mannanases from Klebsiella oxytoca KUB-CW2-3 (KMAN-3) or Bacillus circulans NT 6.7 (MAN 6.7). Morphological changes and functional groups of solid residues were also determined by scanning electron microscopy (SEM) and Fourier transform infrared (FTIR) spectroscopy. Results revealed that the Michaelis-Menten constant (K m) and maximum velocity (V max) values of KMAN-3 on DCM were 2.4 mg/ml and 5.4 U/mg, respectively, while MAN 6.7 recorded K m and V max at 2.0 mg/ml and 4.3 U/mg, respectively. Both enzymes efficiently randomly hydrolysed DCM and produced a range of different manno-oligosaccharides (MOS). The profile of hydrolysis products was different for each enzyme used. Main products from hydrolysis of DCM by KMAN-3 and MAN 6.7 were various MOS including mannobiose (M2), mannotriose (M3), mannotetraose (M4), and mannose, whereas mannopentaose (M5) was only found from KMAN-3. Amount of M3 produced by KMAN-3 was about three times higher than from MAN 6.7. Total MOS yield for KMAN-3 was 1.5-folds higher than for MAN 6.7. SEM analysis showed that enzymatic hydrolysis with KMAN-3 and MAN 6.7 resulted in deconstruction of the DCM structure which generated a variety of MOS products. FTIR spectra revealed that the properties of both hydrolysed solids were not significantly different compared to the original DCM. Results suggested that KMAN-3 was a promising candidate for production of high MOS content from copra meal.
Collapse
Affiliation(s)
- Nipat Sritrakul
- Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok, 10900 Thailand
- Center for Advanced Studies for Agriculture and Food, Kasetsart University Institute for Advanced Studies, Kasetsart University, Bangkok, 10900 Thailand
| | - Sunee Nitisinprasert
- Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok, 10900 Thailand
- Center for Advanced Studies for Agriculture and Food, Kasetsart University Institute for Advanced Studies, Kasetsart University, Bangkok, 10900 Thailand
| | - Suttipun Keawsompong
- Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok, 10900 Thailand
- Center for Advanced Studies for Agriculture and Food, Kasetsart University Institute for Advanced Studies, Kasetsart University, Bangkok, 10900 Thailand
| |
Collapse
|
19
|
Zhao D, Wang Y, Na J, Ping W, Ge J. The response surface optimization of β-mannanase produced by Lactobacillus casei HDS-01 and its potential in juice clarification. Prep Biochem Biotechnol 2019; 49:202-207. [PMID: 30734626 DOI: 10.1080/10826068.2019.1566151] [Citation(s) in RCA: 10] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/12/2022]
Abstract
Lactic acid bacteria (LAB) is an ideal mannanase source due to the bio-safety guarantee. LAB can heterogeneously express β-mannanase or be directly used as β-mannanase-producing strains. This research originally optimized the fermentation condition for β-mannanase produced by Lactobacillus casei HDS-01. The applicable potential of the crude enzyme in juice clarification was investigated. Two-factorial design screened out three factors, i.e., fermentation time (p = 0.0001), glucose (p = 0.0013), and initial pH (p = 0.0167), which significantly affected L. casei HDS-01 β-mannanase activity. Under the predicted conditions resulting from the central composite design (CCD), i.e., fermentation time 18.23 hr, glucose 12.65 g L-1, initial pH 5.18, the model reached maximal β-mannanase activity of 81.40 U mL-1. This model was validated by conducting six repeated experiments and subsequent t-test (p = 0.6308). RSM optimization obtained a 1.33-fold increase in β-mannanase activity. This increase could also be qualitatively detected by larger clearance zone on konjac powder-MRS agar through Congo Red dyeing. The yield and clarity of crude β-mannanase-treated juices from orange, apple, and pear were significantly higher than controls without enzyme treatment. This study conferred a relatively high β-mannanase-producing LAB strain with a high bio-safety level and easy and economical use in juice clarification as well as other food-level fields.
Collapse
Affiliation(s)
- Dan Zhao
- a Engineering Research Center of Agricultural Microbiology Technology, Ministry of Education , Heilongjiang University , Harbin , China.,b Key Laboratory of Microbiology, College of Heilongjiang Province, School of Life Sciences , Heilongjiang University , Harbin , China
| | - Yao Wang
- a Engineering Research Center of Agricultural Microbiology Technology, Ministry of Education , Heilongjiang University , Harbin , China.,b Key Laboratory of Microbiology, College of Heilongjiang Province, School of Life Sciences , Heilongjiang University , Harbin , China
| | - Jin Na
- a Engineering Research Center of Agricultural Microbiology Technology, Ministry of Education , Heilongjiang University , Harbin , China.,b Key Laboratory of Microbiology, College of Heilongjiang Province, School of Life Sciences , Heilongjiang University , Harbin , China
| | - Wenxiang Ping
- a Engineering Research Center of Agricultural Microbiology Technology, Ministry of Education , Heilongjiang University , Harbin , China.,b Key Laboratory of Microbiology, College of Heilongjiang Province, School of Life Sciences , Heilongjiang University , Harbin , China
| | - Jingping Ge
- a Engineering Research Center of Agricultural Microbiology Technology, Ministry of Education , Heilongjiang University , Harbin , China.,b Key Laboratory of Microbiology, College of Heilongjiang Province, School of Life Sciences , Heilongjiang University , Harbin , China
| |
Collapse
|
20
|
Tuntrakool P, Keawsompong S. Kinetic properties analysis of beta-mannanase from Klebsiella oxytoca KUB-CW2-3 expressed in Escherichia coli. Protein Expr Purif 2018; 146:23-26. [PMID: 29378260 DOI: 10.1016/j.pep.2018.01.009] [Citation(s) in RCA: 10] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 11/07/2017] [Revised: 01/19/2018] [Accepted: 01/19/2018] [Indexed: 10/18/2022]
Abstract
Endo-1,4-β-mannanase is an enzyme that can catalyze the random hydrolysis of β-1,4-mannosidic linkages in the main chain of mannans, glucomannans and galactomannans and offers many applications in different biotechnology industries. Purification and kinetic properties of the endo-1,4-β-mannanase from recombinant Escherichia coli strain KMAN-3 were examined. Recombinant β-mannanase (KMAN-3) was purified 50.5 fold using Ni-NTA Agarose resin and specific activity of 11900 U/mg protein was obtained. Purified KMAN-3 showed a single band on SDS-PAGE with a molecular weight of 43 kDa. Km and Vmax values of KMAN-3 on ivory nut mannan, locust bean gum, defatted copra meal and konjac glucomannan were 243, 3.83 × 105 37 and 2.13 × 106 mg ml-1 and 2940, 61,100, 3930 and 1.56 × 1010 mg-1, respectively. Carboxymethyl cellulose was not digested by KMAN-3.
Collapse
Affiliation(s)
- Pirudee Tuntrakool
- Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok 10900, Thailand; Specialized Research Unit: Prebiotics and Probiotics or Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok 10900, Thailand
| | - Suttipun Keawsompong
- Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok 10900, Thailand; Specialized Research Unit: Prebiotics and Probiotics or Health, Department of Biotechnology, Faculty of Agro-Industry, Kasetsart University, Bangkok 10900, Thailand; Center for Advanced Studies for Agriculture and Food, KU Institute for Advanced Studies, Kasetsart University (CASAF, NRU-KU), Bangkok 10900, Thailand.
| |
Collapse
|
21
|
Trp residue at subsite − 5 plays a critical role in the substrate binding of two protistan GH26 β-mannanases from a termite hindgut. Appl Microbiol Biotechnol 2018; 102:1737-1747. [DOI: 10.1007/s00253-017-8726-2] [Citation(s) in RCA: 5] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/26/2017] [Revised: 11/28/2017] [Accepted: 12/11/2017] [Indexed: 10/18/2022]
|
22
|
Sakai K, Kimoto S, Shinzawa Y, Minezawa M, Suzuki K, Jindou S, Kato M, Shimizu M. Characterization of pH-tolerant and thermostable GH 134 β-1,4-mannanase SsGH134 possessing carbohydrate binding module 10 from Streptomyces sp. NRRL B-24484. J Biosci Bioeng 2017; 125:287-294. [PMID: 29153955 DOI: 10.1016/j.jbiosc.2017.10.009] [Citation(s) in RCA: 6] [Impact Index Per Article: 0.9] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 07/12/2017] [Revised: 09/25/2017] [Accepted: 10/15/2017] [Indexed: 10/18/2022]
Abstract
A GH 134 β-1,4-mannanase SsGH134 from Streptomyces sp. NRRL B-24484 possesses a carbohydrate binding module (CBM) 10 and a glycoside hydrolase 134 domain at the N- and C-terminal regions, respectively. Recombinant SsGH134 expressed in Escherichia coli. SsGH134 was maximally active within a pH range of 4.0-6.5 and retained >80% of this maximum after 90 min at 30°C within a pH range of 3.0-10.0. The β-1,4-mannanase activity of SsGH134 towards glucomannan was 30% of the maximal activity after an incubation at 100°C for 120 min, indicating that SsGH134 is pH-tolerant and thermostable β-1,4-mannanase. SsGH134, SsGH134-ΔCBM10 (CBM10-linker-truncated SsGH134) and SsGH134-G34W (substitution of Gly34 to Trp) bound to microcrystalline cellulose, β-mannan and chitin, regardless of the presence or absence of CBM10. These indicate that GH 134 domain strongly bind to the polysaccharides. Although deleting CBM10 increased the catalytic efficiency of the β-1,4-mannanase, its disruption decreased the pH, solvent and detergent stability of SsGH134. These findings indicate that CBM10 inhibits the β-1,4-mannanase activity of SsGH134, but it is involved in stabilizing its enzymatic activity within a neutral-to-alkaline pH range, and in the presence of various organic solvents and detergents. We believe that SsGH134 could be useful to a diverse range of industries.
Collapse
Affiliation(s)
- Kiyota Sakai
- Faculty of Agriculture, Meijo University, Nagoya, Aichi 468-8502, Japan
| | - Saran Kimoto
- Faculty of Agriculture, Meijo University, Nagoya, Aichi 468-8502, Japan
| | - Yuta Shinzawa
- Faculty of Agriculture, Meijo University, Nagoya, Aichi 468-8502, Japan
| | - Miho Minezawa
- Faculty of Agriculture, Meijo University, Nagoya, Aichi 468-8502, Japan
| | - Kengo Suzuki
- Faculty of Agriculture, Meijo University, Nagoya, Aichi 468-8502, Japan
| | - Sadanari Jindou
- Faculty of Science and Technology, Department of Culture Education, Meijo University, Nagoya, Aichi 468-8502, Japan
| | - Masashi Kato
- Faculty of Agriculture, Meijo University, Nagoya, Aichi 468-8502, Japan
| | - Motoyuki Shimizu
- Faculty of Agriculture, Meijo University, Nagoya, Aichi 468-8502, Japan.
| |
Collapse
|