Aspergillus steynii and Aspergillus westerdijkiae as potential risk of OTA contamination in food products in warm climates

The effect of the interactions of water activity, and temperature on OTA, OTB, and OTα produced by Penicillium verrucosum in a mini silo of natural and inoculated wheat using CO2 production as fungal activity sentinel

Ochratoxin A (OTA) is a nephrotoxin that contaminates grains in storage. Moisture and temperature sensors give delayed responses due to their slow kinetic movement within the silo. This study examines if CO2 production could predict OTA contamination and identify storage conditions exceeding the maximum limit (5 μg/kg). The impact of water activity levels (0.70-0.90 aw), temperatures (15 and 20 °C), and storage duration on (a)Penicillium verrucosum population, (b)CO2 respiration rates (RR), and (c)ochratoxins concentrations in stored wheat was investigated. 96 samples were analysed for ochratoxins with LCMS-MS. RR was >7 times higher at wetter conditions than at drier aw levels. A positive correlation between CO2, OTA, OTB, and OTα was observed at the wettest conditions. OTA exceeded the limit at >0.80 aw (16% moisture content) with RR > 0.01 mg CO2 kg-1 h-1. The knowledge of the RR of stored grain would alert grain farmers/managers to improve grain storage management.

Ochratoxin A Contamination of California Pistachios and Identification of Causal Agents

Ochratoxin A (OTA) is a potent mycotoxin produced by Aspergillus and Penicillium spp., which contaminates many crops, including pistachios. Pistachios contaminated with OTA may be subjected to border rejections resulting in significant economic losses to the United States agricultural revenues. The current study examined prevalence of OTA in California-grown pistachios and identified its causal agents. OTA was detected in 20% of samples from 2018 to 2021 (n = 809), with 18% of samples exceeding the European Union regulatory limit of 5 μg/kg. Fungi potentially responsible for OTA contamination were isolated from leaves, nuts, and soil collected from 14 pistachio orchards across California. A total of 1,882 isolates of Aspergillus section Nigri and 85 isolates of section Circumdati were recovered. Within section Nigri, 216 (11.5%) isolates were identified as potential OTA producers using a boscalid-resistance assay. Phylogenetic analyses of partial gene sequences for β-tubulin and calmodulin genes resolved section Circumdati into four species: A. ochraceus (33%), A. melleus (28%), A. bridgeri (21%), and A. westerdijkiae (19%). A. westerdijkiae produced the highest levels of OTA in inoculated pistachios (47 μg/g), followed by A. ochraceus (9.6 μg/g) and A. melleus (3.3 μg/g). A. bridgeri did not produce OTA. OTA production by section Circumdati was optimal from 20 to 30°C. All 216 boscalid-resistant isolates from section Nigri were identified as A. tubingensis, and representative isolates (n = 130) produced 3.8 μg/kg OTA in inoculated pistachios. This is the first detailed report on OTA contamination and causal fungi in California pistachios and will be helpful in devising effective management strategies.

Occurrence of ochratoxin A in Sichuan bacon from different geographical regions and characterization and biocontrol of ochratoxigenic Aspergillus westerdijkiae strain 21G2-1A

Sichuan bacon represents the most prevalent dry-cured meat product across Southwest China, but it is vulnerable to fungal spoilage. In the present study, a total of 47 Sichuan bacons were obtained from different regions of the Sichuan Province and analyzed for the presence of ochratoxin A (OTA), yielding a positive rate of 23.4 % (11/47). All the observed OTA concentrations exceeded the maximum admissible dose in meat products (1 μg/kg) established by some EU countries, with the highest OTA concentration being 250.75 μg/kg, which raises a food safety concern and reveals the need for a standardized scientific processing protocol. Then, an OTA-producing fungus named 21G2-1A was isolated from positive samples and found to be Aspergillus westerdijkiae. Further characterization suggested a positive correlation between fungal growth and OTA production. The optimal temperature for the former was 25 °C, while it was 20 °C for the latter. Although the A. westerdijkiae strain 21G2-1A demonstrated greater mycelium growth in the presence of NaCl, OTA production was significantly dismissed when the salinity was greater than 5 %. Four lactic acid bacteria (LAB) were screened out as antagonists against the ochratoxigenic fungus. In vitro evaluation of the antagonists revealed that live cells inhibited fungal growth, and adsorption also contributed to OTA removal at different levels. This study sheds some light on OTA control in Sichuan bacon through a biological approach.

Deciphering Staphylococcus xylosus and Staphylococcus equorum mode of action against Penicillium nordicum in a dry-cured ham model system

Penicillium nordicum is one of the major producers of ochratoxin A (OTA) in dry-cured ham. Staphylococcus xylosus Sx8 and Staphylococcus equorum Se31 have been previously proposed as biocontrol agents (BCAs) to prevent the OTA contamination, although their antifungal mode of action has not been established yet. Thus, the aim of this work was to elucidate their mode of action against P. nordicum in a dry-cured ham model system. For this, the effect of live cells, dead cells, and cell-free broth; the nutritional utilisation pattern, niche overlap index (NOI), interactions by dual-culture assays, antifungal effect of volatile compounds, OTA detoxification, and effect on fungal proteome were determined. No fungal growth was observed after 14 days of co-culture with live cells of each staphylococcus at 15 or 20 °C. However, such inhibition was not observed with either dead cells or extracellular extracts. The number of carbon sources utilised by P. nordicum was higher than those used by both cocci at 20 °C, whilst the opposite occurred at 15 °C. According to NOI, nutritional dominance depends on temperature, at 20 °C P. nordicum dominated the niche, but at 15 °C the mould is dominated by the BCAs. The volatile pattern generated by each coccus did not show antifungal effect, and both staphylococci failed to degrade or adsorb OTA. However, in the interaction assay, S. xylosus and S. equorum were able to decrease the fungal growth and its OTA production. In addition, proteomic analyses showed changes in the abundance of proteins related to the cell wall integrity (CWI), carbohydrate metabolism and the biosynthesis of secondary metabolites such as OTA. In conclusion, overall, the antagonistic effects of the two studied cocci against P. nordicum are greater at 15 °C than at 20 °C, being linked to competition for space and nutrients, triggering alterations in CWI pathway, OTA biosynthesis, and carbohydrate metabolism.

Current Insights in Fungal Importance-A Comprehensive Review

Besides plants and animals, the Fungi kingdom describes several species characterized by various forms and applications. They can be found in all habitats and play an essential role in the excellent functioning of the ecosystem, for example, as decomposers of plant material for the cycling of carbon and nutrients or as symbionts of plants. Furthermore, fungi have been used in many sectors for centuries, from producing food, beverages, and medications. Recently, they have gained significant recognition for protecting the environment, agriculture, and several industrial applications. The current article intends to review the beneficial roles of fungi used for a vast range of applications, such as the production of several enzymes and pigments, applications regarding food and pharmaceutical industries, the environment, and research domains, as well as the negative impacts of fungi (secondary metabolites production, etiological agents of diseases in plants, animals, and humans, as well as deteriogenic agents).

SakA Regulates Morphological Development, Ochratoxin A Biosynthesis and Pathogenicity of Aspergillus westerdijkiae and the Response to Different Environmental Stresses

Ochratoxin A (OTA), as a common mycotoxin, has seriously harmful effects on agricultural products, livestock and humans. There are reports on the regulation of SakA in the MAPK pathway, which regulates the production of mycotoxins. However, the role of SakA in the regulation of Aspergillus westerdijkiae and OTA production is not clear. In this study, a SakA deletion mutant (ΔAwSakA) was constructed. The effects of different concentrations of D-sorbitol, NaCl, Congo red and H₂O₂ on the mycelia growth, conidia production and biosynthesis of OTA were investigated in A. westerdijkiae WT and ΔAwSakA. The results showed that 100 g/L NaCl and 3.6 M D-sorbitol significantly inhibited mycelium growth and that a concentration of 0.1% Congo red was sufficient to inhibit the mycelium growth. A reduction in mycelium development was observed in ΔAwSakA, especially in high concentrations of osmotic stress. A lack of AwSakA dramatically reduced OTA production by downregulating the expression of the biosynthetic genes otaA, otaY, otaB and otaD. However, otaC and the transcription factor otaR1 were slightly upregulated by 80 g/L NaCl and 2.4 M D-sorbitol, whereas they were downregulated by 0.1% Congo red and 2 mM H₂O₂. Furthermore, ΔAwSakA showed degenerative infection ability toward pears and grapes. These results suggest that AwSakA is involved in the regulation of fungal growth, OTA biosynthesis and the pathogenicity of A. westerdijkiae and could be influenced by specific environmental stresses.

The Mechanism of Ochratoxin Contamination of Artificially Inoculated Licorice Roots

Ochratoxin (OT) contamination of medicinal herbs is a serious threat to human health. This study was performed to investigate the mechanism of OT contamination of licorice (Glycyrrhiza sp.) root. Licorice root samples were cut into eight parts, which were placed separately on sucrose-free Czapek Dox agar medium, inoculated with the spores of ochratoxigenic Aspergillus westerdijkiae. After incubation for 10 and 20 days, the OT contents of the samples were determined by high-performance liquid chromatography, and microtome sections prepared from the samples were analyzed by desorption electrospray ionization tandem mass spectrometry, to visualize OT localization. The same sections were further examined by light microscopy and scanning electron microscopy, to investigate the path of fungal mycelial penetration of the inner roots. OT concentrations tended to increase from the upper- to the middle-root parts. OTs were located in cut areas and areas of cork layer damage; they were not present in the undamaged cork layer, indicating that the structure of this layer prevents OT contamination of the licorice root.

Mutual effects on mycotoxin production during co-culture of ochratoxigenic and aflatoxigenic Aspergillus strains

Mycotoxin co-occurrence compromises the safety of food crops worldwide. Environmental factors, as well as fungal interaction, can substantially influence the infectivity of mycotoxigenic fungi and their subsequent production of multi-mycotoxin. Here, we investigated the mutual effects of the co-culture of ochratoxigenic and aflatoxigenic Aspergillus strains on the co-production of ochratoxin A (OTA) and aflatoxin B1 (AFB1). Single cultures of ochratoxigenic A. carbonarius and A. alliaceus grew optimally at 25 °C, whereas aflatoxigenic A. flavus grew optimally at 35 °C. The maximum levels of OTA and AFB1 were achieved at 25 °C, whereas mycotoxin production decreased at 35 °C. During competitive growth of the ochratoxigenic and aflatoxigenic isolates, inhibition or stimulation of mycotoxin production was dependent on the fungal strain, temperature, and the ratio of the spore concentration. Aspergillus carbonarius and A. alliaceus generally produced OTA, with similar patterns of relative OTA levels at all temperatures. AFB1 production by A. flavus in the presence of ochratoxigenic Aspergillus species was inhibited at 25 °C and stimulated at 35 °C. These results indicated that the temperature, presence of other mycotoxigenic Aspergillus species, and ratio of the initial spore concentration significantly contributed to the co-production of OTA and AFB1.

Production of Aflatoxin B1 by Aspergillus parasiticus Grown on a Novel Meat-Based Media

The aim of the present study was to develop meat-based media with compositions similar to those of dry-fermented meat products and to evaluate their use in studying the growth of Aspergillus parasiticus and the kinetics of aflatoxin B1 (AFB1) production. In our previous experiments, we found that the strain A. parasiticus ŽMJ7 produced a high amount of AFB1. Cooked meat agar (CMA2) was used as a novel complex meat-based medium with four variations: CMA2G (CMA2 supplemented with 1% glucose), CMA2YE (CMA2 supplemented with 0.2% yeast extract), and CMA2GYE (CMA2 supplemented with 1% glucose and 0.2% yeast extract). Media were inoculated with an A. parasiticus spore suspension (105 spores/mL) and incubated at 25 °C for up to 15 days. The A. parasiticus lag phase lasted less than 1 day, irrespective of the growth medium, with the exception of control medium CMA1 (cooked meat agar) as an already known meat-based medium. The highest mean colony growth rate was observed on CMA2 and CMA2G. Reversed-phase UPLC-MS/MS analysis was performed to determine the AFB1 concentration in combination with solid phase extraction (SPE). The highest AFB1 concentration in meat-based media was detected in CMA2GYE after 15 days of incubation (13,502 ± 2367 ng/mL media). The results showed that for studying AFB1 production in dry-fermented meat products, novel suitable media such as CMA2-based media are required. This finding could represent a potential concern with regard to the production of dry-fermented meat products.

Lactic Acid Bacteria as Potential Agents for Biocontrol of Aflatoxigenic and Ochratoxigenic Fungi

Aflatoxins (AF) and ochratoxin A (OTA) are fungal metabolites that have carcinogenic, teratogenic, embryotoxic, genotoxic, neurotoxic, and immunosuppressive effects in humans and animals. The increased consumption of plant-based foods and environmental conditions associated with climate change have intensified the risk of mycotoxin intoxication. This study aimed to investigate the abilities of eleven selected LAB strains to reduce/inhibit the growth of Aspergillus flavus, Aspergillus parasiticus, Aspergillus carbonarius, Aspergillus niger, Aspergillus welwitschiae, Aspergillus steynii, Aspergillus westerdijkiae, and Penicillium verrucosum and AF and OTA production under different temperature regiments. Data were treated by ANOVA, and machine learning (ML) models able to predict the growth inhibition percentage were built, and their performance was compared. All factors LAB strain, fungal species, and temperature significantly affected fungal growth and mycotoxin production. The fungal growth inhibition range was 0-100%. Overall, the most sensitive fungi to LAB treatments were P. verrucosum and A. steynii, while the least sensitive were A. niger and A. welwitschiae. The LAB strains with the highest antifungal activity were Pediococcus pentosaceus (strains S11sMM and M9MM5b). The reduction range for AF was 19.0% (aflatoxin B1)-60.8% (aflatoxin B2) and for OTA, 7.3-100%, depending on the bacterial and fungal strains and temperatures. The LAB strains with the highest anti-AF activity were the three strains of P. pentosaceus and Leuconostoc mesenteroides ssp. dextranicum (T2MM3), and those with the highest anti-OTA activity were Leuconostoc paracasei ssp. paracasei (3T3R1) and L. mesenteroides ssp. dextranicum (T2MM3). The best ML methods in predicting fungal growth inhibition were multilayer perceptron neural networks, followed by random forest. Due to anti-fungal and anti-mycotoxin capacity, the LABs strains used in this study could be good candidates as biocontrol agents against aflatoxigenic and ochratoxigenic fungi and AFL and OTA accumulation.

Growth and toxin production of phomopsin A and ochratoxin A forming fungi under different storage conditions in a pea (Pisum sativum) model system

Phomopsins are mycotoxins mainly infesting lupines, with phomopsin A (PHOA) being the main mycotoxin. PHOA is produced by Diaporthe toxica, formerly assigned as toxigenic Phomopsis leptostromiformis, causing infections in lupine plants and harvested seeds. However, Diaporthe species may also grow on other grain legumes, similar to Aspergillus westerdijkiae as an especially potent ochratoxin A (OTA) producer. Formation of PHOA and OTA was investigated on whole field peas as model system to assess fungal growth and toxin production at adverse storage conditions. Field pea samples were inoculated with the two fungal strains at two water activity (aw) values of 0.94 and 0.98 and three different levels of 30, 50, and 80% relative air humidity.After 14 days at an aw value of 0.98, the fungi produced 4.49 to 34.3 mg/kg PHOA and 1.44 to 3.35 g/kg OTA, respectively. Strains of D. toxica also tested showed higher PHOA concentrations of 28.3 to 32.4 mg/kg.D. toxica strains did not grow or produce PHOA at an aw values of 0.94, while A. westerdijkiae still showed growth and OTA production.Elevated water activity has a major impact both on OTA and, even more pronouncedly, on PHOA formation and thus, proper drying and storage of lupins as well as other grain legumes is crucial for product safety.

Predictive Modeling and Validation on Growth, Production of Asexual Spores and Ochratoxin A of Aspergillus Ochraceus Group under Abiotic Climatic Variables

This study aimed to generate predictive models for growth, sporulation, and ochratoxin A (OTA) production under abiotic climatic variables, including temperatures (15-35 °C) and water activity levels (0.99-0.90 aw) by Aspergillus ochraceus group. The data were divided into three sets: one for training, one for testing, and the third one for model validation. Optimum growth occurred at 0.95 aw and 25 °C and 0.95 aw and 30 °C for A. westerdijkiae and A. steynii, respectively. Significantly improved A. westerdijkiae and A. steynii spore production occurred at 0.95 aw and 20 °C and 0.90 aw and 35 °C, respectively. A. steynii and A. westerdijkiae produced the majority of OTA at 35 °C and 0.95 aw and 25-30 °C at 0.95-0.99 aw, respectively. The accuracy of the third-order polynomial regression model reached 96% in growth cases, 94.7% in sporulation cases, and 90.9% in OTA production cases; the regression coefficients (R2) ranged from 0.8819 to 0.9978 for the Aspergillus ochraceus group. A reliable agreement was reached between the predicted and observed growth, sporulation, and OTA production. The effects of abiotic climatic variables on growth, sporulation, and OTA production of A. ochraceus group have been effectively defined, and the models generated were responsible for adequately predicted and validated models against data from other strains within A. ochraceus group that had been published in the literature under the current treatments. These models could be successfully implemented to predict fungal growth and OTA contamination on food matrices for these strains under these conditions.

A PCR method to identify ochratoxin A-producing Aspergillus westerdijkiae strains on dried and aged foods

Ochratoxins are a group of mycotoxins that frequently occur as contaminants in agricultural commodities and foods, including dry-cured meats and cheeses. The fungus Aspergillus westerdijkiae is frequently isolated from aged foods and can produce ochratoxin A (OTA). However, individual strains of the fungus can have one of two OTA production phenotypes (chemotypes): OTA production and OTA nonproduction. Monitoring and early detection of OTA-producing fungi in food are the most effective strategies to manage OTA contamination. Therefore, we examined genome sequence data from five A. westerdijkiae strains isolated from the surface of cheese from southern Italy to identify genetic markers indicative of the twoOTA chemotypes. This analysis revealed a naturally occurring deletion of the OTA regulatory gene, otaR, in an OTA-nonproducing isolate.We used this information to design a polymerase chain reaction (PCR) method that could identify A. westerdijkiae and distinguish between the two OTA chemotypes. In this method, the PCR primers were complementary to conserved sequences flanking otaR and yielded different-sized amplicons from strains with the different chemotypes. The primers did not yield ota-region-specific amplicons from other OTA-producing species. Because the method is specific to A. westerdijkiae and can distinguish between the two OTA chemotypes, it has potential to significantly improve OTA monitoring programs.

Functional Role of Aspergillus carbonariusAcOTAbZIP Gene, a bZIP Transcription Factor within the OTA Gene Cluster

Aspergillus carbonarius is the principal fungal species responsible for ochratoxin A (OTA) contamination of grapes and derived products in the main viticultural regions worldwide. In recent years, co-expressed genes representing a putative-OTA gene cluster were identified, and the deletion of a few of them allowed the partial elucidation of the biosynthetic pathway in the fungus. In the putative OTA-gene cluster is additionally present a bZIP transcription factor (AcOTAbZIP), and with this work, A. carbonarius ΔAcOTAbZIP strains were generated to study its functional role. According to phylogenetic analysis, the gene is conserved in the OTA-producing fungi. A Saccharomyces cerevisiae transcription factor binding motif (TFBM) homolog, associated with bZIP transcription factors was present in the A. carbonarius OTA-gene cluster no-coding regions. AcOTAbZIP deletion results in the loss of OTA and the intermediates OTB and OTβ. Additionally, in ΔAcOTAbZIP strains, a down-regulation of AcOTApks, AcOTAnrps, AcOTAp450, and AcOTAhal genes was observed compared to wild type (WT). These results provide evidence of the direct involvement of the AcOTAbZIP gene in the OTA biosynthetic pathway by regulating the involved genes. The loss of OTA biosynthesis ability does not affect fungal development as demonstrated by the comparison of ΔAcOTAbZIP strains and WT strains in terms of vegetative growth and asexual sporulation on three different media. Finally, no statistically significant differences in virulence were observed among ΔAcOTAbZIP strains and WT strains on artificially inoculated grape berries, demonstrating that OTA is not required by A. carbonarius for the pathogenicity process.

Ochratoxin A contamination of the casing and the edible portion of artisan salamis produced in two Italian regions

The purpose of this study was to provide data on the presence of ochratoxin A (OTA) in artisan salamis produced in the Campania and Marche regions (Italy). For this aim, 96 different salamis were purchased from farms and small salami factories. Analysis were carried out firstly on the casings of all samples, and in a second step, in the outer and inner edible parts of those samples whose casings were found positive for OTA at concentration levels above the Italian guideline value established for OTA in pork meat (1 μg/kg). The analytical method, based on a sample preparation procedure with immunoaffinity columns, together with analysis by LC-MS/MS, has guaranteed average recoveries between 79.4 and 89.0%, limits of detection (LOD) and quantification (LOQ) of 0.10 and 0.25 μg/kg, respectively. OTA was detected in 25.0% of the analysed casings (24 samples) at concentration ranging from 0.25 to 98.52 μg/kg. Ten of these samples were from the same production plant in which an additional sampling was carried out, and where a problem of environmental contamination by ochratoxigenic moulds probably exists. The edible parts were mostly uncontaminated, except in 3 samples, 2 of which showed OTA contamination levels above 1 μg/kg. The presence of OTA on the casing does not seem to be cause for alarm about the safety of this type of product but it should in any case be monitored. Before slicing the meat for consumption, it is always good practice to peel the casing even if reported as edible on salami label.

Effect of a Debaryomyces hansenii and Lactobacillus buchneri Starter Culture on Aspergillus westerdijkiae Ochratoxin A Production and Growth during the Manufacture of Short Seasoned Dry-Cured Ham

Recently, specific dry-cured hams have started to be produced in San Daniele and Parma areas. The ingredients are similar to protected denomination of origin (PDO) produced in San Daniele or Parma areas, and include pork leg, coming from pigs bred in the Italian peninsula, salt and spices. However, these specific new products cannot be marked as a PDO, either San Daniele or Parma dry cured ham, because they are seasoned for 6 months, and the mark PDO is given only to products seasoned over 13 months. Consequently, these products are called short-seasoned dry-cured ham (SSDCH) and are not branded PDO. During their seasoning period, particularly from the first drying until the end of the seasoning period, many molds, including Eurotium spp. and Penicillium spp., can grow on the surface and work together with other molds and tissue enzymes to produce a unique aroma. Both of these strains typically predominate over other molds. However, molds producing ochratoxins, such as Aspergillus ochraceus and Penicillium nordicum, can simultaneously grow and produce ochratoxin A (OTA). Consequently, these dry-cured hams may represent a potential health risk for consumers. Recently, Aspergillus westerdijkiae has been isolated from SSDCHs, which could represent a potential problem for consumers. Therefore, the aim of this study was to inhibit A. westerdijkiae using Debaryomyces hansenii or Lactobacillus buchneri or a mix of both microorganisms. Six D. hansenii and six L. buchneri strains were tested in vitro for their ability to inhibit A. westerdijkiae. The strains D. hansenii (DIAL)1 and L. buchneri (Lb)4 demonstrated the highest inhibitory activity and were selected for in situ tests. The strains were inoculated or co-inoculated on fresh pork legs for SSDCH production with OTA-producing A. westerdijkiae prior to the first drying and seasoning. At the end of seasoning (six months), OTA was not detected in the SSDCH treated with both microorganisms and their combination. Because both strains did not adversely affect the SSDCH odor or flavor, the combination of these strains are proposed for use as starters to inhibit OTA-producing A. westerdijkiae.

Efficacy of the Combined Protective Cultures of Penicillium chrysogenum and Debaryomyces hansenii for the Control of Ochratoxin A Hazards in Dry-Cured Ham

The ecological conditions during the ripening of dry-cured ham favour the development of moulds on its surface, being frequently the presence of Penicillium nordicum, a producer of ochratoxin A (OTA). Biocontrol using moulds and yeasts usually found in dry-cured ham is a promising strategy to minimize this hazard. The aim of this work is to evaluate the effect of previously selected Debaryomyces hansenii and Penicillium chrysogenum strains on growth, OTA production, and relative expression of genes involved in the OTA biosynthesis by P. nordicum. P. nordicum was inoculated against the protective cultures individually and combined on dry-cured ham for 21 days at 20 °C. None of the treatments reduced the growth of P. nordicum, but all of them decreased OTA concentration. The lower production of OTA could be related to significant repression of the relative expression of otapksPN and otanpsPN genes of P. nordicum. The efficacy of the combined protective cultures was tested in 24 dry-cured hams in industrial ripening (an 8 month-long production). OTA was detected in nine of the 12 dry-cured hams in the batch inoculated only with P. nordicum. However, in the batch inoculated with both P. nordicum and the combined protective culture, a considerable reduction of OTA contamination was observed. In conclusion, although the efficacy of individual use P. chrysogenum is great, the combination with D. hansenii enhances its antifungal activity and could be proposed as a mixed protective culture to control the hazard of the presence of OTA in dry-cured ham.

Enterococcus faecium: a promising protective culture to control growth of ochratoxigenic moulds and mycotoxin production in dry-fermented sausages

Moulds positively contribute to the development of typical characteristic flavour and aroma of dry-fermented sausages. However, some mould species, such as Penicillium nordicum and Penicillium verrucosum, may contaminate this product with ochratoxin A (OTA). For this reason, the control of toxigenic moulds is needed. Strategies based on the use of antifungal microorganisms present in the native microbial population in the dry-fermented sausage processing could be a promising strategy. The aim of this work was to study the effect of Enterococcus faecium strains on P. nordicum and P. verrucosum growth and OTA production in a dry-fermented sausage-based medium at conditions of temperature and water activity similar to those occurring during the ripening of these meat products. Six strains were screened to evaluate their growth capacity and antifungal activity against P. nordicum and P. verrucosum at three fixed temperatures related to the sausage ripening. The two E. faecium strains that decreased growth of both species were chosen to further evaluate their effect on growth of P. verrucosum and P. nordicum and their mycotoxin production under conditions simulating the dry-fermented sausage ripening. The presence of E. faecium SE920 significantly reduced OTA production of P. nordicum although it did not affect P. verrucosum. E. faecium SE920, isolated from dry-fermented sausages, could be a good candidate to reduce OTA production by P. nordicum in dry-fermented sausages.

Effects of environmental conditions and substrate on growth and ochratoxin A production by Penicillium verrucosum and Penicillium nordicum: Relative risk assessment of OTA in dry-cured meat products

Ecological conditions during ripening of dry-cured meat products favour the growth of an uncontrolled mould population that could suppose a risk of ochratoxin A (OTA) production. In this work the influence of water activity (a_w), temperature and substrate composition on fungal growth and OTA production by Penicillium nordicum and Penicillium verrucosum isolated from dry-cured meat products have been studied. In addition, the relative risk of OTA presence on dry-cured meat products has been evaluated using the Risk Ranger software. Fungal growth was observed in the range of 0.99-0.90 a_w and 15-25 °C being mainly temperature-dependent. P. nordicum and P. verrucosum were able to produce OTA in every substrate in these ranges of a_w and temperature. The production of OTA by P. verrucosum was mainly influenced by temperature and media composition. However, P. nordicum it is affected mainly by substrate or temperature depending on the strain studied. Both species produce a large amount of OTA on dry-cured ham and on dry-cured fermented sausage "salchichón" in environmental conditions usually found throughout the ripening of these products. The Risk Ranger software reveals that the relative risk of OTA on dry-cured meat products is 75%. Thus, control measures during dry-cured meat products processing to prevent OTA risk should be established.

Differentiation and quantification of the ochratoxin A producers Aspergillus ochraceus and Aspergillus westerdijkiae using PCR-DGGE

Ochratoxin A (OTA) is a nephrotoxic, teratogenic, immunotoxic, and carcinogenic mycotoxin which is produced in tropical zones mainly by Aspergillus carbonarius, A. niger, A. ochraceus, and A. westerdijkiae. A. ochraceus and A. westerdijkiae species are phenotypically and genomically very close but A. westerdijkiae produce OTA at a very higher level than A. ochraceus. These species have been differentiated recently. The DNA primer pairs which were drawn so far are not specific and a genomic region of the same size is amplified for both species or they are too specific, and in this case, the DNA of a single species is amplified. To help preventing OTA contamination of foodstuffs, the PCR-DGGE (Denaturing Gradient Gel Electrophoresis) method was used to discriminate between A. ochraceus and A. westerdijkiae DNA fragments of the same size but with different sequences and thus faster access to a diagnosis of the toxigenic potential of the fungal microflora. The proposed methodology was able to differentiate A. westerdijkiae from A. ochraceus with only one primer pairs in a single run. A calibration based on initial DNA content was obtained from image analysis of the DGGE gels and a method of quantification of the two strains was proposed.

Risk management of ochratoxigenic fungi and ochratoxin A in maize grains by bioactive EVOH films containing individual components of some essential oils

Aspergillus steynii and Aspergillus tubingensis are possibly the main ochratoxin A (OTA) producing species in Aspergillus section Circumdati and section Nigri, respectively. OTA is a potent nephrotoxic, teratogenic, embryotoxic, genotoxic, neurotoxic, carcinogenic and immunosuppressive compound being cereals the first source of OTA in the diet. In this study bioactive ethylene-vinyl alcohol copolymer (EVOH) films containing cinnamaldehyde (CINHO), linalool (LIN), isoeugenol (IEG) or citral (CIT) which are major components of some plant essential oils (EOs) were produced and tested against A. steynii and A. tubingensis growth and OTA production in partly milled maize grains. Due to the favourable safety profile, these bioactive compounds are considered in the category "GRAS". The study was carried out under different water activity (0.96 and 0.99 a_w), and temperature (24 and 32 °C) conditions. ANOVA showed that class of film, fungal species, a_w and temperature and their interactions significantly affected growth rates (GR), ED₅₀ and ED₉₀ and the doses for total fungal growth inhibition and OTA production. The most effective EVOH films against both species were those containing CINHO. ED₅₀, ED₉₀ and doses for total growth and OTA inhibition were 165-405, 297-614, 333-666 μg of EVOH-CINHO/plate (25 g of maize grains), respectively, depending on environmental conditions. The least efficient were EVOH-LIN films. ED₅₀, ED₉₀ and doses for total growth and OTA inhibition were 2800->3330, >3330 and >3330 μg of EVOH-LIN/plate (25 g of maize grains), respectively. The effectiveness of the bioactive films increased with increasing doses. Overall, A. tubingensis was less sensitive to treatments than A. steynii. Depending on the species, a_w and temperature affected GR and OTA production in a different way. In A. steynii cultures, optimal growth occurred at 0.96 a_w and 32 °C while optimal OTA production happened at 0.99 a_w and 32 °C. In A. tubingensis cultures optimal growth happened at 0.99 a_w and 32 °C, although the best conditions for OTA production were 0.99 a_w and 24 °C. Thus, these species can be very competitive in warm climates and storage conditions. The EVOH-CINHO films followed by EVOH-IEG and EVOH-CIT films, designed in this study and applied in vapour phase, can be potent antifungal agents against A. steynii and A. tubingensis and strong inhibitors of OTA biosynthesis in maize grains at very low doses. This is the first study on the impact that interacting environmental conditions and bioactive films containing individual components of EOs have on the growth of these ochratoxigenic fungi and on OTA production in maize grains.

Multilocus Phylogeny and Antifungal Susceptibility of Aspergillus Section Circumdati from Clinical Samples and Description of A. pseudosclerotiorum sp. nov

A multilocus phylogenetic study was carried out to assess species identity of a set of 34 clinical isolates from Aspergillus section Circumdati from the United States and to determine their in vitro antifungal susceptibility against eight antifungal drugs. The genetic markers used were the internal transcribed spacer (ITS) region, and fragments of the beta-tubulin (BenA), calmodulin (CaM), and RNA polymerase II second largest subunit (RPB2) genes. The drugs tested were amphotericin B, itraconazole, posaconazole, voriconazole, anidulafungin, caspofungin, micafungin, and terbinafine. The most common species sampled was A. westerdijkiae (29.4%), followed by a novel species, which was described here as A. pseudosclerotiorum (23.5%). Other species identified were A. sclerotiorum (17.6%), A. ochraceus (8.8%), A. subramanianii (8.8%), and A. insulicola and A. ochraceopetaliformis, with two isolates (5.9%) of each. The drugs that showed the most potent activity were caspofungin, micafungin, and terbinafine, while amphotericin B showed the least activity.

Modelling climate change impacts on mycotoxin contamination

Projected climate change effects will influence primary agricultural systems and thus food security, directly via impacts on yields, and indirectly via impacts on its safety, with mycotoxins considered as crucial hazards. Mycotoxins are produced by a wide variety of fungal species, each having their own characteristics and requirements. The geographic distribution of toxigenic fungi reflects their ecological needs, with thermophilic fungi prevalent at lower latitudes and psychrophiles at the higher latitudes. A resulting gradient of mycotoxin contamination has been repeatedly stressed. Changes in climatic conditions will lead to shifts in the fungal population and the mycotoxin patterns. In general, climate change is expected to increase mycotoxin contamination of crops, but due to the complexity of mycoflora associated to each crop and its interaction with the environment, it appears rash to draw conclusions without specific studies. Very recently first quantitative estimations of impacts of climate change on mycotoxin occurrence have been made. Two studies each applied models of different disciplines including climate projection, crop phenology and fungal/mycotoxin prediction to cereals cultivated in Europe. They were followed by a case study on climate change effects on Alternaria moulds and their mycotoxins in tomato. Results showed that DON contamination of wheat grown in Europe was, in general, expected to increase. However, variation was large, and in some years and some regions a decrease in DON contamination was expected. Regarding aflatoxin contamination of maize grown in Europe, an increase was estimated, mainly in the +2 °C scenario. Two main research gaps were identified related to the (limited) number of existing quantitative models taking into account climate change and their validation in limited areas. Efforts are therefore mandatory to be prepared for future changes and challenges on model validation and limited mycotoxin-crop combinations.

Sequencing and functional annotation of the whole genome of the filamentous fungus Aspergillus westerdijkiae

BACKGROUND

Aspergillus westerdijkiae produces ochratoxin A (OTA) in Aspergillus section Circumdati. It is responsible for the contamination of agricultural crops, fruits, and food commodities, as its secondary metabolite OTA poses a potential threat to animals and humans. As a member of the filamentous fungi family, its capacity for enzymatic catalysis and secondary metabolite production is valuable in industrial production and medicine. To understand the genetic factors underlying its pathogenicity, enzymatic degradation, and secondary metabolism, we analysed the whole genome of A. westerdijkiae and compared it with eight other sequenced Aspergillus species.

RESULTS

We sequenced the complete genome of A. westerdijkiae and assembled approximately 36 Mb of its genomic DNA, in which we identified 10,861 putative protein-coding genes. We constructed a phylogenetic tree of A. westerdijkiae and eight other sequenced Aspergillus species and found that the sister group of A. westerdijkiae was the A. oryzae - A. flavus clade. By searching the associated databases, we identified 716 cytochrome P450 enzymes, 633 carbohydrate-active enzymes, and 377 proteases. By combining comparative analysis with Kyoto Encyclopaedia of Genes and Genomes (KEGG), Conserved Domains Database (CDD), and Pfam annotations, we predicted 228 potential carbohydrate-active enzymes related to plant polysaccharide degradation (PPD). We found a large number of secondary biosynthetic gene clusters, which suggested that A. westerdijkiae had a remarkable capacity to produce secondary metabolites. Furthermore, we obtained two more reliable and integrated gene sequences containing the reported portions of OTA biosynthesis and identified their respective secondary metabolite clusters. We also systematically annotated these two hybrid t1pks-nrps gene clusters involved in OTA biosynthesis. These two clusters were separate in the genome, and one of them encoded a couple of GH3 and AA3 enzyme genes involved in sucrose and glucose metabolism.

CONCLUSIONS

The genomic information obtained in this study is valuable for understanding the life cycle and pathogenicity of A. westerdijkiae. We identified numerous enzyme genes that are potentially involved in host invasion and pathogenicity, and we provided a preliminary prediction for each putative secondary metabolite (SM) gene cluster. In particular, for the OTA-related SM gene clusters, we delivered their components with domain and pathway annotations. This study sets the stage for experimental verification of the biosynthetic and regulatory mechanisms of OTA and for the discovery of new secondary metabolites.

Ochratoxin A Producing Fungi, Biosynthetic Pathway and Regulatory Mechanisms

Ochratoxin A (OTA), mainly produced by Aspergillus and Penicillum species, is one of the most important mycotoxin contaminants in agricultural products. It is detrimental to human health because of its nephrotoxicity, hepatotoxicity, carcinogenicity, teratogenicity, and immunosuppression. OTA structurally consists of adihydrocoumarin moiety linked with l-phenylalanine via an amide bond. OTA biosynthesis has been putatively hypothesized, although several contradictions exist on some processes of the biosynthetic pathway. We discuss recent information on molecular studies of OTA biosynthesis despite insufficient genetic background in detail. Accordingly, genetic regulation has also been explored with regard to the interaction between the regulators and the environmental factors. In this review, we focus on three aspects of OTA: OTA-producing strains, OTA biosynthetic pathway and the regulation mechanisms of OTA production. This can pave the way to assist in protecting food and feed from OTA contamination by understanding OTA biosynthetic pathway and regulatory mechanisms.

Effect of post-harvest treatments on the occurrence of ochratoxin A in raw cocoa beans

Cocoa beans are the principal raw material for chocolate manufacture. Moulds have an important place in the change in the quality of cocoa beans due to their role in the production of free fatty acids and mycotoxins, namely ochratoxin A (OTA). This study investigated the impact of the key post-harvest treatments, namely the fermentation and drying methods on OTA contamination of raw cocoa beans. Analytical methods for OTA detection were based on solid-liquid extraction, clean-up using an immunoaffinity column, and identification by reversed-phase HPLC with fluorescence detection. Of a total of 104 randomly selected cocoa samples analysed, 32% had OTA contents above 2 µg kg(-1). Cocoa sourced from pods in a bad state of health had a maximum OTA content of 39.2 µg kg(-1), while that obtained from healthy pods recorded 11.2 µg kg(-1). The production of OTA in cocoa beans increased according to the pod-opening delay and reached 39.2 µg kg(-1) after an opening delay of 7 days after harvest, while 6.1 and 11.2 µg kg(-1) were observed when pods were opened after 0 and 4 days. OTA production also seemed to depend considerably to the cocoa fermentation materials. When using plastic boxes for bean fermentation, the OTA production was enhanced and reached an average OTA content of about 4.9 µg kg(-1), while the raw cocoa treated in banana leaves and wooden boxes recorded 1.6 and 2.2 µg kg(-1) on average respectively. In parallel, the OTA production was not really influenced by either the mixing or the duration of the fermentation or the drying materials.