Sterol enriched fractions obtained from Agaricus bisporus fruiting bodies and by-products by compressed fluid technologies (PLE and SFE)

Emerging technologies for the extraction of bioactives from mushroom waste

Extraction of bioactive compounds for application in nutraceuticals is gaining popularity. For this, there is a search for low-cost substrates that would make the end product and the process more economical. Mushroom waste (stalk, cap, stem etc.) is one such high valued substrate that has received much attention recently due to its rich reserves of terpenoids, polyphenols, sesquiterpenes, alkaloids, lactones, sterols, antioxidative vitamins, anthocyanidins, glycoproteins and polysaccharides, among others. However, there is a need to identify green and hybrid technologies that could make the bioactive extraction process from these substrates safe, efficient and sustainable. To this effect, many emerging technologies (supercritical fluid, ultrasound-, enzyme- and microwave-assisted extraction) have been explored in the last decade which have shown potential for scale-up with high productivity. This review systematically discusses such technologies highlighting the current challenges faced during waste processing and the research directives needed for further advancements in the field.

Pressurized Liquid (PLE) Truffle Extracts Have Inhibitory Activity on Key Enzymes Related to Type 2 Diabetes (α-Glucosidase and α-Amylase)

An optimized PLE method was applied to several truffle species using three different solvent mixtures to obtain bioactive enriched fractions. The pressurized water extracts contained mainly (1 → 3),(1 → 6)-β-D-glucans, chitins, and heteropolymers with galactose and mannose in their structures. The ethanol extracts included fatty acids and fungal sterols and others such as brassicasterol and stigmasterol, depending on the species. They also showed a different fatty acid lipid profile depending on the solvent utilized and species considered. Ethanol:water extracts showed interesting lipids and many phenolic compounds; however, no synergic extraction of compounds was noticed. Some of the truffle extracts were able to inhibit enzymes related to type 2 diabetes; pressurized water extracts mainly inhibited the α-amylase enzyme, while ethanolic extracts were more able to inhibit α-glucosidase. Tuber brumale var. moschatum and T. aestivum var. uncinatum extracts showed an IC₅₀ of 29.22 mg/mL towards α-amylase and 7.93 mg/mL towards α-glucosidase. Thus, use of the PLE method allows o bioactive enriched fractions to be obtained from truffles with antidiabetic properties.

Sterols and pentacyclic triterpenoids from nettle root: content and composition as affected by pressurized liquid extraction

BACKGROUND

Nettle is a medicinal plant rich in bioactive molecules. The composition of nettle leaves and stems has been extensively studied, whereas the root has been insufficiently investigated. Therefore, the present study aimed to optimize the parameters of advanced extraction technique, pressurized liquid extraction (PLE), for the lipid fraction of nettle root rich in triterpenoid derivatives and to compare the efficiency of isolation under optimal conditions with conventional Soxhlet extraction (SE).

RESULTS

The PLE yields ranged from 0.39-1.63%, whereas the total content of triterpenoid derivatives ranged from 43.50-78.26 mg 100 g^-1 , with nine sterols and three pentacyclic triterpenoids identified and quantified within a total range of 42.81-76.57 mg 100 g^-1 and 0.69-1.68 mg 100 g^-1 dried root, respectively. The most abundant sterol and pentacyclic triterpenoid were β-sitosterol and β-amyrin acetate, with mean values of 50.21 mg 100 g^-1 and 0.56 mg 100 g^-1 dried root.

CONCLUSION

The optimal PLE conditions were 150 °C/5 min/four cycles and showed significantly better performance compared to SE (68 °C, 8 h), establishing an excellent technique for the isolation of the nettle root lipid fraction. Also, triterpenoid derivatives from nettle could be used as functional ingredients for the development of new foods and dietary supplements. © 2022 Society of Chemical Industry.

Ergosterol fraction from Agaricus bisporus modulates adipogenesis and skeletal glucose uptake in high fat diet induced obese C57BL/6 mice

AIM

The study aimed to optimize a method of extracting ergosterol rich concentrate (ECF) and to evaluate its significant impact on adipogenesis and associated complications in high-fat diet (HFD) induced obese mice.

METHODS

A comparative analysis (soxhlet and ultra sound assisted extraction) was done to obtain the highest yield of ergosterol from Agaricus bisporus. The ECF was evaluated for the biological effect on 3T3-L1 pre-adipocytes in-vitro and in male C57BL/6 mice model in-vivo.

KEY FINDINGS

Ultra sound assisted extraction method using the solvent n-hexane resulted in highest ergosterol yield. ECF treatment significantly reduced the differentiation and lipid accumulation in pre-adipocyte cells without any cytotoxicity. In-vivo study illustrated beneficial impact on cholesterol metabolism by down regulating the hepatic gene expression of LXR-α, HMG-CoR and up-regulating LDL-R expression. Significant increase in fecal excretion of cholesterol and bile acids have also been observed among the ECF treated animals compared to high fat diet (HFD) fed mice. ECF had an anti-adipogenic activity in-vivo mainly by inhibiting the activity of PPAR-γ, C/EBP-α and SREBP-1c. The results also depicted the improvement of obesity associated insulin resistance by ECF treatment manly via decrease in plasma resistin and up-regulation in skeletal GLUT4 protein expression.

SIGNIFICANCE

Our study illustrated diverse activity of ECF in the therapeutic management of obesity associated metabolic complications mainly by reducing adipogenesis and improving glucose uptake in skeletal muscle in conjunction with improved cholesterol metabolism.

Extraction and trapping of truffle flavoring compounds into food matrices using supercritical CO2

A supercritical fluid extraction methodology was used to extract flavoring and bioactive compounds from truffles. Some parameters such as CO₂ flow rate (1-3 mg/mL), extraction time (15-90 min) and different trapping food matrices (grape seed oil, gelatin, agar agar and water) were optimized using response surface methodology to enhance extraction and trapping yields. The optimal conditions (2.27 mg/mL CO₂ flow rate, 82.5 min when using 40 °C and 30 MPa, with 1 mL grape seed oil as trapping matrix) obtained with Tuber melanosporum were applied to three different truffle species: Terfezia claveryi, Tuber aestivum and Tuber indicum. A total of 32 metabolites were profiled in the extracts using ultra-high-performance supercritical fluid chromatography coupled to quadrupole time-of-flight mass spectrometry. Compounds such as brassicasterol ergosta-7,22-dienol, oleic and linoleic acid were found at similar amounts in all the extracts but other molecules (e.g. fungal sterols) showed a particular distribution depending on the specie studied and whether a trapping matrix was used at the SFE outlet.

Extraction and utilization of active substances from edible fungi substrate and residue: A review

The expansion of the edible fungi industry has resulted in the production of large amounts of edible fungus residues, causing great pressure on environmental protection.Therefore, research on edible fungus residue utilization has become a controversial issue. Thus far, numerous efforts have been devoted to separate active substances from edible fungus substrates and residues for high application value utilization. Building upon this, the main methods for extracting active substances from edible mushroom residues are reviewed, and the mechanisms, influencing factors, and trade-offs of the various methods are analysed. Furthermore, the existing and possible directions of utilization of the extracted active substances are reviewed and discussed. Finally, challenges and prospects for the extraction and utilization of different substances in edible fungus residues are proposed. This review provides an effective strategy for protecting the ecological environment and promoting the sustainable development of human society.

Valorization of mushroom by-products: a review

With the rapid growth of the global economy and the global population, the production of solid waste has increased remarkably. Mushrooms are gaining popularity among researchers for their ability to turn waste into nutrients. However, a large number of by-products are produced during the industrial processing of mushrooms. Traditional waste management, focusing on the utilization and disposal of mushroom by-products, has attracted the attention of researchers. Meanwhile, the circular economy has become a multidisciplinary research field, and the valorization of mushroom by-products is a very important part of circular economy research. Various mushroom by-products of mushroom are reviewed in this paper. By-products are used in food as raw materials or functional components, in livestock and poultry feed after grinding/fermentation, and as electrochemical materials and papermaking materials. The by-products can also be used to produce ethanol and other biological sources of energy, as absorbing substances in sewage treatment, and as fertilizer in soil amendment. Mushroom processing by-products can be applied in various fields. To improve production efficiency, new extraction technology (including supercritical fluid technology and microwave extraction technology) can be adopted to increase the bioactive substance content in the by-products. Choosing appropriate processing temperature, time, and other processing conditions can also enhance product quality. Finally, more research is needed on the cost-effective utilization of the by-products and the feasibility of industrialization. © 2022 Society of Chemical Industry.

High-Pressure Technologies for the Recovery of Bioactive Molecules from Agro-Industrial Waste

Large amounts of food waste are produced each year. These residues require appropriate management to reduce their environmental impact and, at the same time, economic loss. However, this waste is still rich in compounds (e.g., colorants, antioxidants, polyphenols, fatty acids, vitamins, and proteins) that can find potential applications in food, pharmaceutical, and cosmetic industries. Conventional extraction techniques suffer some drawbacks when applied to the exploitation of food residues, including large amounts of polluting solvents, increased time of extraction, possible degradation of the active molecules during extraction, low yields, and reduced extraction selectivity. For these reasons, advanced extraction techniques have emerged in order to obtain efficient residue exploitation using more sustainable processes. In particular, performing extraction under high-pressure conditions, such as supercritical fluids and pressurized liquid extraction, offers several advantages for the extraction of bioactive molecules. These include the reduced use of toxic solvents, reduced extraction time, high selectivity, and the possibility of being applied in combination in a cascade of progressive extractions. In this review, an overview of high-pressure extraction techniques related to the recovery of high added value compounds from waste generated in food industries is presented and a critical discussion of the advantages and disadvantages of each process is reported. Furthermore, the possibility of combined multi-stage extractions, as well as economic and environmental aspects, are discussed in order to provide a complete overview of the topic.

Supercritical CO2 Extraction of Triterpenoids from Chaga Sterile Conk of Inonotus obliquus

Triterpenoids are among the bioactive components of Chaga, the sterile conk of the medicinal fungus Inonotus obliquus. Supercritical fluid extraction of Chaga triterpenoids was carried out with supercritical CO₂, while a modified Folch method was used as a comparison. Three temperature-pressure combinations were tested varying between 314–324 K (40–50 °C) and 281–350 bars, using time- and volume-limited extractions. Six triterpenoids were identified with GC-MS and quantified with GC-FID: ergosterol, lanosterol, β-sitosterol, stigmastanol, betulin, and inotodiol. The Folch extraction resulted in recovery of trametenolic acid, which was not extracted by supercritical CO₂. Inotodiol was the major triterpenoid of all the extracts, with a yield of 87–101 mg/100 g and 139 mg/100 g, for SFEs and the Folch method, respectively. The contents of other major triterpenoids, lanosterol and ergosterol, varied in the ranges 59–63 mg/100 g and 17–18 mg/100 g by SFE, respectively. With the Folch method, the yields were 81 mg/100 g and 40 mg/100 g, respectively. The highest recovery of triterpenoids with SFE in relation to Folch was 56% and it was obtained at 324 K (50 °C) and 350 bar, regardless of extraction time or volume of CO₂. The recoveries of lanosterol and stigmastanol were unaffected by SFE conditions. Despite the lower yield, SFE showed several advantages including shorter extraction time and less impact on the environment. This work could be a starting point for further studies on green extraction methods of bioactive triterpenoids from Chaga.

Application of Pressurized Liquid Extractions to Obtain Bioactive Compounds from Tuber aestivum and Terfezia claveryi

A PLE (pressurized liquid extraction) method was adjusted following a full-factorial experimental design to obtain bioactive-enriched fractions from Tuber aestivum and Terfezia claveryi. Temperature, time and solvent (water, ethanol and ethanol–water 1:1) parameters were investigated. The response variables investigated were: obtained yield and the levels of total carbohydrate (compounds, β-glucans, chitin, proteins, phenolic compounds and sterols). Principal component analysis indicated water solvent and high temperatures as more adequate parameters to extract polysaccharide-rich fractions (up to 68% of content), whereas ethanol was more suitable to extract fungal sterols (up to 12.5% of content). The fractions obtained at optimal conditions (16.7 MPa, 180 °C, 30 min) were able to protect Caco2 cells from free radical exposure, acting as antioxidants, and were able to reduce secretion of pro-inflammatory cytokines in vitro: IL-6 (50%), and TNFα (80% only T. claveryi ethanol extract), as well as reduce high inhibitory activity (T. aestivum IC50: 9.44 mG/mL).

Potential role of mycosterols in hyperlipidemia - A review

Cardiovascular diseases associated with obesity are alarmingly increasing in both developed and developing countries. Obesity is mainly ascribed to higher lipid accumulation in the body. There are several simple approaches to treat this condition like lifestyle modification, dietary intervention, physical activities, drug treatment etc. There are many drugs available in the market to treat hyperlipidemia condition, but those drugs have many fatal adverse effects on human health. In view of this, it is reasonable to suggest some preventive measures by functional food ingredients as human health has acclimatized to these since thousands of years. Phytosterols have been studied since decades for its hypocholesterolemic effect in human nutrition. Although the mycosterols from fungi are still under- exploited, ergosterol and derivatives from fungal source have promising health beneficial effects in obesity associated cardiovascular diseases. This review aims to summarise the investigations on mycosterol with respect to obesity in the last decade and also scope of future research on its application in functional food supplements.

Effects of gamma irradiation on the shelf-life and bioactive compounds of Tuber aestivum truffles packaged in passive modified atmosphere

The effects of gamma irradiation (0.5, 1.0, 1.5 and 2.5 kGy doses) on Tuber aestivum packaged under modified atmosphere was evaluated. The respiration rate, microbial populations, sensory characteristics and content of bioactive compounds (total carbohydrates, chitins, β-glucans, proteins, total phenols and sterols) were monitored from immediately after treatment up to day 42 of storage at 4 °C. All the irradiation treatments tested reduced the microbial groups studied by more than 3 log cfu/g. Increasing irradiation doses slowed down the subsequent microbial development throughout the conservation period for all the groups studied. The irradiation treatments did not negatively affect truffle sensory characteristics. Only a slight visible superficial yeast growth was detected at the end of the shelf-life in all doses applied. Total carbohydrate content, chitins, β-glucans and proteins levels were not affected after irradiation. However, sterols, particularly stigmasterol, slightly decreased after irradiation, while levels of phenolic compounds doubled during storage. Gamma irradiation (2.5 kGy) could be used to extend the shelf-life of summer truffles packaged under modified atmosphere, since no remarkable reduction of bioactive compounds were noticed after 42 days of storage, and their sensory and microbial parameters were of higher quality than those of non-irradiated controls.

M. B. Morais A, Freitas AC, C. F. R. Ferreira I, Pintado M. Valorization of Mushroom By-Products as a Source of Value-Added Compounds and Potential Applications

Nowadays, the food sector is highly concerned with environmental issues and foreseen to develop strategies to reduce waste and losses resulting from activities developed in the food system. An approach is to increment added value to the agro-industrial wastes, which might provide economic growth and environmental protection, contributing to a circular economy. Mushroom by-products represent a disposal problem, but they are also promising sources of important compounds, which may be used due to their functional and nutritional properties. Research has been developed in different fields to obtain value added solutions for the by-products generated during mushroom production and processing. Bioactive compounds have been obtained and applied in the development of nutraceutical and pharmaceutical formulations. Additionally, other applications have been explored and include animal feed, fertilizer, bioremediation, energy production, bio-based materials, cosmetics and cosmeceuticals. The main purpose of this review is to highlight the relevant composition of mushroom by-products and discuss their potential as a source of functional compounds and other applications. Future research needs to explore pilot and industrial scale extraction methods to understand the technological feasibility and the economic sustainability of the bioactive compounds extraction and valorization towards different applications.

Optimization of ergosterol extraction from Pleurotus mushrooms using response surface methodology

In this study, heat-assisted extraction (HAE) was used to optimise the extraction of ergosterol from Pleurotus ostreatus (PO) and Pleurotus eryngii (PE) using response surface methodology (RSM).

In vitro and in vivo testing of the hypocholesterolemic activity of ergosterol- and β-glucan-enriched extracts obtained from shiitake mushrooms (Lentinula edodes)

Herein, two shiitake fractions were obtained: the ergosterol-enriched fraction exerted higher in vitro hypocholesterolemic activity and the β-glucan-enriched fraction reduced the cholesterol levels in mice.

Extraction of bioactive compounds against cardiovascular diseases from Lentinula edodes using a sequential extraction method

Three extraction methods were sequentially combined to obtain fractions from Lentinula edodes (shiitake mushrooms) containing bioactive compounds against cardiovascular diseases (CVDs). Fruiting bodies were first extracted with plain water, obtained residue was then submitted to supercritical fluid extraction (SFE) and remaining residue submitted to hot water extraction. Sequential design allowed reutilization of the nonextracted material as raw material for the successive extractions increasing extraction yields and separating interesting compounds. Obtained fractions contained different amounts of ß-glucans, chitins, eritadenine, lenthionine, ergosterol, proteins/peptides and phenolic compounds conferring them different bioactivities. Water soluble fractions showed high antioxidant activities (ABTS^+• and DPPH^• scavenging capacity and reducing power), they were also able to inhibit one of the main enzymes involved in hypertension (angiotensin-I converting enzyme) and the key enzyme of cholesterol metabolism (3-hydroxy-3-methylglutaryl coenzyme A reductase). The latter inhibitory activity was also noticed in SFE extracts although ergosterol and other lipid-like molecules were isolated. Dietary fibers were separated in the third extraction. Therefore, with this sequential extraction procedure bioactive compounds against CVDs can be selectively separated from a single batch of shiitake powder. © 2018 American Institute of Chemical Engineers Biotechnol. Prog., 34:746-755, 2018.

A natural food ingredient based on ergosterol: optimization of the extraction fromAgaricus blazei, evaluation of bioactive properties and incorporation in yogurts

A. blazeibioresidues can be used to obtain promising high value-added food additives, following a circular bioeconomy concept.

Water-Soluble Compounds from Lentinula edodes Influencing the HMG-CoA Reductase Activity and the Expression of Genes Involved in the Cholesterol Metabolism

A water extract from Lentinula edodes (LWE) showed HMG-CoA reductase inhibitory activity but contained no statins. NMR indicated the presence of water-soluble α- and β-glucans and fucomannogalactans. Fractions containing derivatives of these polysaccharides with molecular weight down to approximately 1 kDa still retained their inhibitory activity. Once digested LWE was applied to Caco2 in transport experiments, no significant effect was noticed on the modulation of cholesterol-related gene expression. But, when the lower compartment of the Caco2 monolayer was applied to HepG2, some genes were modulated (after 24 h). LWE was also administrated to normo- and hypercholesterolemic mice, and no significant lowering of serum cholesterol levels was observed; but reduction of triglycerides in liver was observed. However, LWE supplementation modulated the transcriptional profile of some genes involved in the cholesterol metabolism similarly to simvastatin, suggesting that it could hold potential as a hypolipidemic/hypocholesterolemic extract, although further dose-dependent studies should be carried out.

Plasma Cholesterol-Lowering Activity of Lard Functionalized with Mushroom Extracts Is Independent of Niemann-Pick C1-like 1 Protein and ABC Sterol Transporter Gene Expression in Hypercholesterolemic Mice

Interest in food matrices supplemented with mushrooms as hypocholesterolemic functional foods is increasing. This study was to (i) investigate the hypocholesterolemic activity of lard functionalized with mushroom extracts (LF) including fungal β-glucans, water-soluble polysaccharides, or ergosterol and (ii) examine the LF influence on transcriptional mechanisms involved in cholesterol metabolism. mRNA levels of 17 cholesterol-related genes were evaluated in jejunum, cecum, and liver of high cholesterol-fed mice. The four tested LFs decreased plasma cholesterol by 22-42%, HDLc by 18-40%, and LDLc by 27-51%, and two of them increased mRNA levels of jejunal Npc1l1 and Abcg5 and hepatic Npc1l1. mRNA levels of other cholesterol-related genes were unchanged. These findings suggest that LF may have potential as a dietary supplement for counteracting diet-induced hypercholesterolemia and could be a source for the development of novel cholesterol-lowering functional foods. However, the cholesterol-lowering effect was unrelated to transcriptional changes, suggesting that post-transcriptional mechanisms could be involved.

Modulation of Cholesterol-Related Gene Expression by Dietary Fiber Fractions from Edible Mushrooms

Mushrooms are a source of dietary fiber (DF) with a cholesterol-lowering effect. However, their underlying mechanisms are poorly understood. The effect of DF-enriched fractions from three mushrooms species on cholesterol-related expression was studied in vitro. The Pleurotus ostreatus DF fraction (PDF) was used in mice models to assess its potential palliative or preventive effect against hypercholesterolemia. PDF induced a transcriptional response in Caco-2 cells, suggesting a possible cholesterol-lowering effect. In the palliative setting, PDF reduced hepatic triglyceride likely because Dgat1 was downregulated. However, cholesterol-related biochemical data showed no changes and no relation with the observed transcriptional modulation. In the preventive setting, PDF modulated cholesterol-related genes expression in a manner similar to that of simvastatin and ezetimibe in the liver, although no changes in plasma and liver biochemical data were induced. Therefore, PDF may be useful reducing hepatic triglyceride accumulation. Because it induced a molecular response similar to hypocholesterolemic drugs in liver, further dose-dependent studies should be carried out.