Repetitive pulsed light treatment at certain interval on fresh-cut cantaloupe (Cucumis melo L. reticulatus cv. Glamour)

Inactivation of murine norovirus and hepatitis A virus on various frozen fruits using pulsed light

The frozen fruit sector has experienced significant growth due to improved product quality as well as the advantage of long-term preservation. However, freezing alone does not eliminate foodborne viruses, a major public health concern and considerable economic burden. One promising disinfecting treatment is pulsed light, shown previously to inactivate hepatitis A virus (HAV) and murine norovirus-1 (MNV-1) on the surface of fresh berries. Viral loads were reduced by 1-2 log, with minor visual quality deterioration observed. In this study, an FDA-compliant pulsed light treatment (11.52 J/cm2) was applied to frozen fruits and berries. Infectious MNV-1 and HAV titers were reduced by 1-2 log on most frozen fruits. A noteworthy finding was that reductions of both viruses on cranberries exceeded 3.5 log cycles. Although pulsed light caused a measurable rise in temperature on the product surface, no visible physical changes (e.g., color) were observed, and the fruit pieces were still frozen after treatment. Although the reduction of infectious titer by pulsed light alone was not large (1-2 log), considering the low amount of virus typically found on fruit, it may be beneficial in the frozen fruit sector. It would be easy to combine with other treatments, and synergic interactions might increase virus inactivation.

Transcriptome analysis reveals ozone treatment maintains ascorbic acid content in fresh-cut kiwifruit by regulating phytohormone signalling pathways

Ascorbic acid (AsA) is an indicator of the nutritional value of freshly cut kiwifruit during storage at 4℃, and its degradation can be inhibited after ozone treatment (1 mg/L, 10 min). The aim of this study was to elucidate the regulatory mechanism affecting AsA metabolism in fresh-cut kiwifruit after ozone treatment. In this study, ozone treatment not only prevented the decrease in AsA/dehydroascorbic acid and delayed the accumulation of total soluble solids/titratable acidity, but also altered phytohormone levels differently. Transcriptomic profiling combined with cis-acting element and correlation analysis were performed to reveal that abscisic acid and salicylic acid synergistically delay AsA degradation under ozone-treatment conditions. Actinidia03760, encoding ascorbate peroxidase, could be specifically recognized by the bZIP transcription factor and is considered a key candidate gene for further research. Collectively, ozone treatment is a promising method for preserving AsA content and improving the nutrition of fresh-cut kiwifruit.

Pulsed light of near-infrared and visible light wavelengths induces the accumulation of carotenoids in tomato fruits during post-treatment time

Pulsed light (PL) is proposed as a novel strategy for the food industry to enhance the antioxidant potential of fruits and vegetables for industrial uses. The main aim of this work is to evaluate the impact of postharvest PL treatments of different spectral ranges on the carotenoid concentration as well as quality attributes of tomatoes during post-treatment time. Doses of wide-spectrum light (180-1100 nm), full-spectrum without ultraviolet (UV)-C wavelengths (305-1100 nm), and visible (VIS) + near-infrared light (NIR) (400-1100 nm) were compared. Total carotenoids, lycopene, and chlorophyll contents were spectrophotometrically assessed just after treatments and 1, 5, and 10 days post-treatment. PL treatments accelerated the accumulation of both total carotenoids and lycopene concentrations in tomato fruits. Nevertheless, the efficacy of PL depended on the applied spectral range. Tomato subjected to VIS + NIR treatment exhibited the greatest enhancement in total carotenoids (31 %) and lycopene (35 %) content at day 5 post-treatment and quality attributes were not affected. Conversely, UV-light exposure did not enhance carotenoid concentrations. These results evidenced that VIS + NIR treatments induced a faster accumulation of carotenoids without negatively affecting tomato quality attributes. PRACTICAL APPLICATION: The integration of visible and near-infrared (VIS + NIR) light filters in pulsed light (PL) processing allows enhancing the accumulation of bioactive compounds in tomato tissues in a sustainable way, which can be processed to obtain derived products (e.g., juices, purees) with health-promoting properties. PL technology is characterized by a lack of residual compounds and the absence of applying chemicals potentially harmful to humans. Industries can attract the attention of consumers through their application, which allows offering this added value.

Comparison of ultrasound and ethanol pretreatments before catalytic infrared drying on physicochemical properties, drying, and contamination of Chinese ginger (Zingiber officinale Roscoe)

This study aimed to investigate the effects of different pretreatment methods on the drying process and quality of catalytic infrared dried ginger slices, particularly the safety quality. Four different pretreatments strategies were used: sample submerged in distilled water, water + US pretreatment, ethanol pretreatment, and ethanol + US pretreatment. The results showed that all pretreatments reduced drying time, and sample pretreatment by ethanol + US had the highest drying efficiency, hardness, highest total phenolic content, and total flavonoid content retention. However, these pretreatments slightly decreased the rehydration ratio and gingerol content. The possible explanation for these results has been put forward by microstructure analysis. CIR-dried ginger samples were pretreated by four methods required by the agricultural standards of China. This study provides a new perspective on the commercial application of ethanol + US pretreatment for CIR-dried ginger slices.

Cell wall composition of alginate coated and pulsed light treated fresh-cut cantaloupes (Cucumis melo L. Var. Reticulatus Cv. Glamour) during chilled storage

This study was to investigate the effects of optimised alginate coating combined with repetitive pulsed light (RPL) on cell wall composition of fresh-cut cantaloupes during chilled storage. Fresh-cut cantaloupes were coated with alginate (1.86%, w/v) followed by RPL treatment (0.9 J cm^-2 at every 48 h up to 26 days) during storage of 36 days. Cell wall composition of fresh-cut cantaloupes was determined at every 12 days while microscopic analysis was conducted on day 2 and day 36. Alginate was effective in maintaining high pectin fractions of fresh-cut cantaloupes while RPL showed greater contribution in maintaining hemicellulose fraction. However, the combination of alginate and RPL was the most effective treatment to maintain the overall cell wall fractions that contributed to the cell wall integrity of fresh-cut cantaloupes during storage. The alginate + RPL samples also had the greatest cell turgidity and shape with well-defined cell walls at the end of storage.

Effect of pulsed light on postharvest disease control-related metabolomic variation in melon (Cucumis melo) artificially inoculated with Fusarium pallidoroseum

Pulsed light, as a postharvest technology, is an alternative to traditional fungicides, and can be used on a wide variety of fruit and vegetables for sanitization or pathogen control. In addition to these applications, other effects also are detected in vegetal cells, including changes in metabolism and secondary metabolite production, which directly affect disease control response mechanisms. This study aimed to evaluate pulsed ultraviolet light in controlling postharvest rot, caused by Fusarium pallidoroseum in 'Spanish' melon, in natura, and its implications in disease control as a function of metabolomic variation to fungicidal or fungistatic effects. The dose of pulsed light (PL) that inhibited F. pallidoroseum growth in melons (Cucumis melo var. Spanish) was 9 KJ m-2. Ultra-performance liquid chromatography (UPLC) coupled to a quadrupole-time-of-flight (QTOF) mass analyzer identified 12 compounds based on tandem mass spectrometry (MS/MS) fragmentation patterns. Chemometric analysis by Principal Components Analysis (PCA) and Orthogonal Partial Least Squared Discriminant Analysis (OPLS-DA) and corresponding S-Plot were used to evaluate the changes in fruit metabolism. PL technology provided protection against postharvest disease in melons, directly inhibiting the growth of F. pallidoroseum through the upregulation of specific fruit biomarkers such as pipecolic acid (11), saponarin (7), and orientin (3), which acted as major markers for the defense system against pathogens. PL can thus be proposed as a postharvest technology to prevent chemical fungicides and may be applied to reduce the decay of melon quality during its export and storage.

Xenon lamps used for fruit surface sterilization can increase the content of total flavonols in leaves of Lactuca sativa L. without any negative effect on net photosynthesis

One (1P), two (2P), three (3P) or four (4P) pulses of light supplied by a xenon lamp, were applied to young lettuce plants grown in pots. The lamp used in the trial was similar to those used for fruit surface sterilization. Total flavonols were measured in leaves using the Dualex method. In a first trial conducted in greenhouse conditions, 6 days after the pulsed light (PL) treatment, flavonols were increased by 312% and 525% in the 3P and 4P treatments, respectively, in comparison to the those in the untreated control. Changes in the chlorophyll fluorescence parameters suggest that the PL treatment may induce limited and transient damage to the photosynthetic machinery and that the damage increases with the increasing number of pulses. The performance parameters were not significantly affected by PL and recovered fully by 6 days after the treatments. The 1P and the 2P treatments 6 days after the treatment showed a 28.6% and a 32.5% increase, respectively, in net photosynthetic assimilation, when compared to that of the control. However, 8 days after the treatment, there was no longer a difference between the treatments and the control in net photosynthetic assimilation. Eight days after the light treatment, the 3P treatment showed a 38.4% increase in maximal net photosynthetic assimilation over that of the control, which is an indication of positive long-term adaptation of photosynthetic capacity. As a whole, our observations suggest that PL could be used on field or greenhouse crops to increase their phytochemical content. No long-lasting or strong negative effects on photosynthesis were associated with PL within the range of doses we tested; some observations even suggest that certain treatments could result in an additional positive effect. This conclusion is supported by a second trial conducted in phytotrons. More studies are required to better understand the roles of the different wavelengths supplied by PL and their interactions.

Sensory quality and flavour of alginate coated and repetitive pulsed light treated fresh-cut cantaloupes (Cucumis melo L. Var. Reticulatus Cv. Glamour) during storage

Fresh-cut fruits are popular due to the convenience provided. However, fresh-cut processes damage fruit tissues and reduce the shelf life of products. Pulsed light (PL) treatment is a decontamination method of foods. PL treatment given repetitively at a certain interval during storage could further extend the shelf life of fresh-cut fruits. Edible coating preserves fresh-cut fruits by providing mechanical strength and reducing respiration and water loss. This study was to evaluate the effects of alginate coating combined with repetitive pulsed light (RPL) on sensory quality and flavour of fresh-cut cantaloupes during storage. Cantaloupes were treated with alginate (1.86%, w/v) and RPL (0.9 J/cm² at every 48 h up to 26 days) alone or in combination. Flavour analysis of fresh-cut cantaloupes was carried out every 12 days during storage at 4 ± 1 °C while sensory analysis was performed on day 32. Alginate coating and/or RPL retained sugar contents (17.92-20.01 g/kg FW for fructose, 18.77-19.98 g/kg FW for glucose and 23.02-29.41 g/kg FW for sucrose) in fresh-cut cantaloupes during storage. Combination of alginate with RPL reduced accumulation of lactic acid although alginate coating was more effective to minimise changes of other organic acids in fresh-cut cantaloupes. The combined treatment was also more effective than individual treatment in retaining total aroma compound concentration of fresh-cut cantaloupes during storage with the highest relative concentration, i.e. 3.174 on day 36. Overall, the combined alginate coating and RPL was effective to maintain the fresh-like sensory quality of fresh-cut cantaloupes with insignificant overall acceptability compared to the control.

Microbes associated with fresh produce: Sources, types and methods to reduce spoilage and contamination

Global food security remains one of the most important challenges that needs to be addressed to ensure the increasing demand for food of the fast growing human population is satisfied. Fruits and vegetables comprise an essential component of a healthy balanced diet as they are the major source of both macro- and micronutrients. They are particularly important for communities in developing countries whose nutrition often relies solely on a plant-based diet. Recent advances in agriculture and food processing technologies have facilitated production of fresh, nutritious and safe food for consumers. However, despite the development of sophisticated chemical and physical methods of food and equipment disinfection, fresh-cut produce and fruit juice industry still faces significant economic losses due to microbial spoilage. Furthermore, fresh produce remains an important source of pathogens that have been causing outbreaks of human illness worldwide. This chapter characterizes common spoilage and human pathogenic microorganisms associated with fresh-cut produce and fruit juice products, and discusses the methods and technology that have been developed and utilized over the years to combat them. Substantial attention is given to highlight advantages and disadvantages of using these methods to reduce microbial spoilage and their efficacy to eliminate human pathogenic microbes associated with consumption of fresh-cut produce and fruit juice products.

Recent findings in pulsed light disinfection

Nonthermal disinfection technologies are gaining increasing interest in the field of minimally processed food in order to improve the microbial safety or to extend the shelf life. Especially fresh-cut produce or meat and fish products are vulnerable to microbial spoilage, but, due to their sensitivity, they require gentle preservation measures. The application of intense light pulses of a broad spectral range comprising ultraviolet, visible and near infrared irradiation is currently investigated as a potentially suitable technology to reduce microbial loads on different food surfaces or in beverages. Considerable research has been performed within the last two decades, in which the impact of various process parameters or microbial responses as well as the suitability of pulsed light (PL) for food applications has been examined. This review summarizes the outcome of the latest studies dealing with the treatment of various foods including the impact of PL on food properties as well as recent findings about the microbicidal action and relevant process parameters.