Identification and quantification of fungi and mycotoxins from Pu-erh tea

In silico evaluation of the potential allergenicity of a fungal biomass from Rhizomucor pusillus for use as a novel food ingredient

The world's hunger for novel food ingredients drives the development of safe, sustainable, and nutritious novel food products. For foods containing novel proteins, potential allergenicity of the proteins is a key safety consideration. One such product is a fungal biomass obtained from the fermentation of Rhizomucor pusillus. The annotated whole genome sequence of this strain was subjected to sequence homology searches against the AllergenOnline database (sliding 80-amino acid windows and full sequence searches). In a stepwise manner, proteins were designated as potentially allergenic and were further compared to proteins from commonly consumed foods and from humans. From the sliding 80-mer searches, 356 proteins met the conservative >35% Codex Alimentarius threshold, 72 of which shared ≥50% identity over the full sequence. Although matches were identified between R. pusillus proteins and proteins from allergenic food sources, the matches were limited to minor allergens from these sources, and they shared a greater degree of sequence homology with those from commonly consumed foods and human proteins. Based on the in silico analysis and a literature review for the source organism, the risk of allergenic cross-reactivity of R. pusillus is low.

Comprehensive and cumulative risk evaluation of dietary exposure to aflatoxins and ochratoxin A on fermented teas worldwide by a new assessment model

Recently, mycotoxin risks in fermented tea have received high attention, but mycotoxin transfer rates from tealeaf to infusion during brewing were rarely considered. In addition, the assessment data (i.e., mycotoxin occurrences and tea consumption) in previous assessments were usually limited. Here, a comprehensive and cumulative risk assessment of aflatoxins and ochratoxin A was performed using a tea assessment model, by which mycotoxin transfer rates were included and the assessment data were collected worldwide. By 10 times of brewing, the aflatoxin transfer rate was only 2.94% and OTA was 63.65%. Besides the extreme case, hazard quotients (HQs) from all consumers were lower than the threshold of 1.0, indicating no noncarcinogenic risk; the P95 cumulative margin of exposure (1/MoET) values were 2.52E-04 (30-39 years of age) and 2.42E-04 (≥50 years of age) for two high exposure groups under the upper bound scenario, which a little higher than the carcinogenic risk threshold of 1.00E-04. Notably, the P95 cumulative 1/MoET values (3.24E-03 -7.95E-03) by food assessment model were ten times higher than those of by tea assessment model. The comparative results showed that mycotoxin dietary risks on tea consumption by food assessment model were much overestimated. The result of this study indicated that the contaminants transfer rates should be considered for risk assessment on tea consumption in future work.

In silico and in vitro safety assessment of a fungal biomass from Rhizomucor pusillus for use as a novel food ingredient

To address the growing world population and reduce the impact of environmental changes on the global food supply, ingredients are being produced using microorganisms to yield sustainable and innovative products. Food ingredients manufactured using modern biotechnology must be produced by non-toxigenic and nonpathogenic production organisms that do not harbor antimicrobial resistance (AMR). Several fungal species represent attractive targets as sources of alternative food products. One such product is a fungal biomass obtained from the fermentation of Rhizomucor pusillus strain CBS 143028. The whole genome sequence of this strain was annotated and subjected to sequence homology searches and in silico phenotype prediction tools to identify genetic elements encoding for protein toxins active via oral consumption, virulence factors associated with pathogenicity, and determinants of AMR. The in silico investigation revealed no genetic elements sharing significant sequence homology with putative virulence factors, protein toxins, or AMR determinants, including the absence of mucoricin, an essential toxin in the pathogenesis of mucormycosis. These in silico findings were corroborated in vitro based on the absence of clinically relevant mycotoxin or antibacterial secondary metabolites. Consequently, it is unlikely that R. pusillis strain CBS 143028 would pose a safety concern for use in food for human consumption.

B-Type Fumonisins in Post-Fermented Tea: Occurrence and Consumer Dietary Exposure in Guangxi, China

Post-fermented tea (PFT), a commonly consumed beverage worldwide, is characterized by the rapid growth of its microbial groups and the substantial changes they undergo. Consequently, PFT may contain mycotoxins such as B-type fumonisins (FBs). This study aimed to assess the intake of FBs through the consumption of PFT among consumers in Guangxi, China. A novel quantitative method using high-performance liquid chromatography-mass spectrometry was used to determine the FB concentration in PFT products. Additionally, a PFT consumption survey was conducted using a face-to-face questionnaire, recording their body weight and PFT consumption patterns based on a three-day dietary recall method. Finally, hazard index was calculated to estimate the health risk of FBs from the consumption of PFT products in Guangxi. The results revealed that the occurrence of FBs in PFT was 20% (24/120), with a concentration ranging from 2.14 to 18.28 μg/kg. The results of the survey showed that the average daily consumption of PFT by consumers was 9.19 ± 11.14 g. The deterministic risk assessment revealed that only 0.026% of the provisional maximum tolerable daily intake of FBs was consumed through PFT, indicating that FB contamination in PFT is not a public health risk.

Aflatoxins and Ochratoxin A in Tea Sold in Lebanon: Effects of Type, Packaging, and Origin

Tea is among the oldest and most-known beverages around the world, and it has many flavors and types. Tea can be easily contaminated in any of its production steps, especially with mycotoxins that are produced particularly in humid and warm environments. This study aims to examine the level of ochratoxin A (OTA) and total aflatoxin (AF) contamination in black and green tea sold in Lebanon, evaluate its safety compared to international standards, and assess the effect of different variables on the levels of OTA and AFs. For this, the Lebanese market was screened and all tea brands (n = 37; 24 black and 13 green) were collected twice. The Enzyme-Linked Immunoassay (ELISA) method was used to determine OTA and AFs in the samples. AFs and OTA were detected in 28 (75.7%) and 31 (88.6%) samples, respectively. The average of AFs in the positive (above detection limit: 1.75 μg/kg) samples was 2.66 ± 0.15 μg/kg, while the average of OTA in the positive (above detection limit: 1.6 μg/kg) samples was 3.74 ± 0.72 μg/kg. The mean AFs in black and green tea were 2.65 ± 0.55 and 2.54 ± 0.40 μg/kg, respectively, while for OTA, the mean levels were 3.67 ± 0.96 and 3.46 ± 1.09 μg/kg in black and green tea samples, respectively. Four brands (10.8%) contained total aflatoxin levels above the EU limit (4 μg/kg). As for OTA, all samples had OTA levels below the Chinese limit (5 μg/kg). No significant association (p > 0.05) was found between OTA and tea type, level of packaging, country of origin, country of packing, and country of distribution. However, AF contamination was significantly (p < 0.05) higher in unpacked tea, and in brands where the country of origin, packing, and distributor was in Asia. The results showed that the tea brands in Lebanon are relatively safe in terms of AFs and OTA.

Untargeted metabolomics and quantification analysis reveal the shift of chemical constituents between instant dark teas individually liquid-state fermented by Aspergillus cristatus, Aspergillus niger, and Aspergillus tubingensis

Instant dark teas (IDTs) were individually liquid-state fermented using the fungi Aspergillus cristatus, Aspergillus niger, and Aspergillus tubingensis. To understand how the chemical constituents of IDTs were affected by the fungi, samples were collected and measured by liquid chromatography-tandem mass-tandem mass spectrometry (LC-MS/MS). Untargeted metabolomics analysis revealed that 1,380 chemical constituents were identified in positive and negative ion modes, and 858 kinds of chemical components were differential metabolites. Through cluster analysis, IDTs were different from the blank control, and their chemical constituents mostly included carboxylic acids and their derivatives, flavonoids, organooxygen compounds, and fatty acyls. And the metabolites of IDTs fermented by A. niger and A. tubingensis had a high degree of similarity and were classified into one category, which showed that the fungus used to ferment is critical to the formation of certain qualities of IDTs. The biosynthesis of flavonoids and phenylpropanoid, which involved nine different metabolites such as p-coumarate, p-coumaroyl-CoA, caffeate, ferulate, naringenin, kaempferol, leucocyanidin, cyanidin, and (-)-epicatechin, were significant pathways influencing the quality formation of IDTs. Quantification analysis indicated that the A. tubingensis fermented-IDT had the highest content of theaflavin, theabrownin, and caffeine, while the A. cristatus fermented-IDT had the lowest content of theabrownin, and caffeine. Overall, the results provided new insights into the relationship between the quality formation of IDTs and the microorganisms used in liquid-state fermentation.

Rapid Identification and Analysis of Ochratoxin-A in Food and Agricultural Soil Samples Using a Novel Semi-Automated In-Syringe Based Fast Mycotoxin Extraction (FaMEx) Technique Coupled with UHPLC-MS/MS

In this work, a fast mycotoxin extraction (FaMEx) technique was developed for the rapid identification and quantification of carcinogenic ochratoxin-A (OTA) in food (coffee and tea) and agricultural soil samples using ultra-high-performance liquid chromatography-tandem mass spectrometry (UHPLC-MS/MS) detection. The FaMEx technique advancement is based on two plastic syringes integrated setup for rapid extraction and its subsequent controlled clean-up process. In the extraction process, a 0.25-g sample and extraction solvent were added to the first syringe barrel for the vortex-based extraction. Then, the extraction syringe was connected to a clean-up syringe (pre-packed with C18, activated carbon, and MgSO₄) with a syringe filter. Afterward, the whole set-up was placed in an automated programmable mechanical set-up for controlled elution. To enhance FaMEx technology performance, the various influencing sample pretreatment parameters were optimized. Furthermore, the developed FaMEx method indicated excellent linearity (0.9998 and 0.9996 for coffee/tea and soil) with highly sensitive detection (0.30 and 0.29 ng/mL for coffee/tea and soil) and quantification limits (1.0 and 0.96 for coffee/tea and soil), which is lower than the toxicity limit compliant with the European Union regulation for OTA (5 ng/g). The method showed acceptable relative recovery (84.48 to 100.59%) with <7.34% of relative standard deviation for evaluated real samples, and the matrix effects were calculated as <-13.77% for coffee/tea and -9.7 for soil samples. The obtained results revealed that the developed semi-automated FaMEx/UHPLC-MS/MS technique is easy, fast, low-cost, sensitive, and precise for mycotoxin detection in food and environmental samples.

Reviews of fungi and mycotoxins in Chinese dark tea

The fermentation is the main process to form the unique flavor and health benefits of dark tea. Numerous studies have indicated that the microorganisms play a significant part in the fermentation process of dark tea. Dark tea has the quality of "The unique flavor grows over time," but unscientific storage of dark tea might cause infestation of harmful microorganisms, thereby resulting in the remaining of fungi toxins. Mycotoxins are regarded as the main contributor to the quality of dark tea, and its potential mycotoxin risk has attracted people's attention. This study reviews common and potential mycotoxins in dark tea and discusses the possible types of masked mycotoxins in dark tea. A summary of the potential risks of mycotoxins and masked mycotoxins in dark tea is presented, intending to provide a reference for the prevention and risk assessment of harmful fungi in dark tea.

Dietary assessment of ochratoxin A in Chinese dark tea and inhibitory effects of tea polyphenols on ochratoxigenic Aspergillus niger

In recent years, there has been an increasingly heated debate on whether Chinese dark tea is contaminated with mycotoxins and whether it poses health risks to consumers. In this study, a rapid method based on high-performance liquid chromatography was used to detect ochratoxin A (OTA) in Chinese dark tea samples from different regions of China and different years. Of the 228 Chinese dark tea samples tested, 21 were detected for OTA contamination, with a concentration ranging from 2.51 ± 0.16 to 12.62 ± 0.72 μg/kg. Subsequently, a dark tea drinking risk assessment was conducted, and the hazard quotient for each group was far below the acceptable level of 1.0. Of the 12 Aspergillus spp. strains isolated, one strain of Aspergillus niger had the ability to produce OTA. We also found that tea polyphenols and epigallocatechin gallate inhibited the growth of ochratoxin-producing Aspergillus niger and the expression of non-ribosomal peptide synthetase (NRPS), a key gene for ochratoxin synthesis. Thus, OTA contamination of dark tea is at an acceptable risk level, and the inhibition of ochratoxigenic Aspergillus niger by polyphenols provides new insights into the safety of dark tea consumption.

Regulation of fungal community and the quality formation and safety control of Pu-erh tea

Pu-erh tea belongs to dark tea among six major teas in China. As an important kind of post-fermented tea with complex microbial composition, Pu-erh tea is highly praised by many consumers owing to its unique and rich flavor and taste. In recent years, Pu-erh tea has exhibited various physiological activities to prevent and treat metabolic diseases. This review focuses on the fungi in Pu-erh tea and introduces the sources, types, and functions of fungi in Pu-erh tea, as well as the influence on the quality of Pu-erh tea and potential safety risks. During the process of fermentation and aging of Pu-erh tea, fungi contribute to complex chemical changes in bioactive components of tea. Therefore, we examine the important role that fungi play in the quality formation of Pu-erh tea. The associations among the microbial composition, chemicals excreted, and potential food hazards are discussed during the pile-fermentation of Pu-erh tea. The quality of Pu-erh tea has exhibited profound changes during the process of pile-fermentation, including color, aroma, taste, and the bottom of the leaves, which are inseparable from the fungus in the pile-fermentation of Pu-erh tea. Specifically, the application prospects of various detection methods of mycotoxins in assessing the safety of Pu-erh tea are proposed. This review aims to fully understand the importance of fungi in the production of Pu-erh tea and further provides new insights into subtly regulating the piling process to improve the nutritional properties and guarantee the safety of Pu-erh tea.

Expression of citrinin biosynthesis gene in Liupao tea and effect of Penicillium citrinum on tea quality

Similar to Pu-erh tea, Liupao tea is a post-fermented tea that is produced through natural fermentation by microorganisms. Penicillium citrinum is involved in multiple production processes of Liupao tea that can produce citrinin, a secondary metabolite with renal toxicity; however, the effect of P. citrinum on the quality of Liupao tea has not been investigated yet. Citrinin production is regulated by approximately 16 biosynthesis genes. However, little is known about the genetic background of citrinin in the complex Liupao tea system. In the present study, we cultured P. citrinum on potato dextrose agar and Liupao tea powder media and analyzed the changes of its nutritional components in Liupao tea. We selected six citrinin biosynthesis genes identified in Monascus exhibiting homology and high sequence similarity to those in P. citrinum and further analyzed the expression of citrinin biosynthesis genes in Liupao tea and the changes in citrinin yield. The results showed that the changes in nutritional components of Liupao tea were closely related to the growth and metabolism of P. citrinum and the quality of the tea. Decreases in the contents of soluble sugars (from 10.29% to 9.58%), soluble pectins (from 3.71% to 3.13%), free amino acids (from 3.84% to 3.14%), and tea polyphenols (from 22.84% to 18.78%) were noted. The Spearman's correlation analysis indicated that P. citrinum growth can improve the tea quality to some extent. Quantitative real-time PCR demonstrated that ctnA gene was a positive regulator of citrinin production regardless of the culture medium used. ctnA and orf5 expressions greatly influenced the metabolism of citrinin by P. citrinum in Liupao tea. In conclusion, the citrinin biosynthesis genes, ctnA and orf5, may be the promising targets for developing strategies to control P. citrinum infection and citrinin biosynthesis in Liupao tea.

An Improved Method of Theabrownins Extraction and Detection in Six Major Types of Tea (Camellia sinensis)

Tea pigments consisting of theabrownins (TBs), theaflavins (TFs), and thearubigins (TRs) affect the color and taste of tea. TBs include a variety of water-soluble compounds, but do not dissolve in n-butanol and ethyl acetate. Previously, the traditional method of TB extraction only mixed tea with n-butanol, and TBs were retained in the water phase. However, without ethyl acetate extraction, TFs and TRs remained in the water phase and affected the detection of TB content. Although an improved method had been devised by adding an ethyl acetate extraction step between tea production and n-butanol extraction, the proportional equation for calculating TB content (%) was not yet developed. In this study, we compared the absorbance at 380 nm (A380) of TB solutions from six major types of tea (green, yellow, oolong, white, black, and dark teas) extracted by improved and traditional methods from the same tea samples. Significantly lower A380 values were obtained from TB solutions via the improved method compared to the traditional method for six major types of tea, and the highest and lowest slops in TB concentrations from A380 analyses were from dark tea and green tea, respectively. Moreover, newly developed equations for TB content in those six tea types extracted by the improved methods were also established.

Multiplex PCR Identification of Aspergillus cristatus and Aspergillus chevalieri in Liupao Tea Based on Orphan Genes

“Golden flower” fungi in dark tea are beneficial to human health. The rapid identification method of “golden flower” fungi can verify the quality of dark tea products and ensure food safety. In this study, 6 strains were isolated from Liupao tea. They were respectively identified as A. cristatus, A. chevalieri, and A. pseudoglaucus. A. pseudoglaucus was reported as Liupao tea “golden flower” fungus for the first time. It was found that the ITS and BenA sequences of A. cristatus and A. chevalieri were highly conserved. It is difficult to clearly distinguish these closely related species by ITS sequencing. To rapidly identify species, multiplex PCR species-specific primers were designed based on orphan genes screened by comparative genomics analysis. Multiplex PCR results showed that orphan genes were specific and effective for the identification of A. cristatus and A. chevalieri isolated from Liupao tea and Fu brick tea. We confirmed that orphan genes can be used for identification of closely related Aspergillus species. Validation showed that the method is convenient, rapid, robust, sequencing-free, and economical. This promising method will be greatly beneficial to the dark tea processing industry and consumers.

Mycotoxins in raw materials, beverages and supplements of botanicals: A review of occurrence, risk assessment and analytical methodologies

Over recent years, consumer interest in natural products, such as botanicals has increased considerably. One of the factors affecting their quality is the presence of mycotoxins. This review focuses on exploring the mycotoxin occurrence in botanicals (raw material and ready-to-eat forms such as infusions or tablets) and the risk assessment due to their ingestion. Aflatoxins, Ochratoxin A, and Fumonisins are the most commonly studied mycotoxins and data in the literature report levels ranging from traces to 1000 μg/kg in raw materials. In general, the highest contents observed in raw materials decreased to unconcerning levels after the preparation of the infusions, reaching values that generally do not exceed 100 μg/L. Regarding botanical dietary supplements, the levels observed were lower than those reported for other matrices, although higher levels (of up to 1000 μg/kg) have been reported in some cases. Risk assessment studies in botanicals revealed a higher risk when they are consumed as tablets compared to infusions. Analytical methodologies implied in mycotoxin determination have also been contemplated. In this sense, liquid chromatography coupled to fluorescence detection has been the most frequently employed analytical technique, although in recent years tandem mass spectrometry has been widely used.

Chromatographic Determination of the Mycotoxin Patulin in 219 Chinese Tea Samples and Implications for Human Health

Patulin (PAT) is a mycotoxin, with several acute, chronic, and cellular level toxic effects, produced by various fungi. A limit for PAT in food of has been set by authorities to guarantee food safety. Research on PAT in tea has been very limited although tea is the second largest beverage in the world. In this paper, HPLC−DAD and GC−MS methods for analysis of PAT in different tea products, such as non-fermented (green tea), partially fermented (oolong tea, white tea, yellow tea), completely fermented (black tea), and post-fermented (dark tea and Pu-erh tea) teas were developed. The methods showed good selectivity with regard to tea pigments and 5-hydroxymethylfurfural (5-HMF) and a recovery of 90–102% for PAT at a 10–100 ppb spiking level. Limit of detection (LOD) and limit of quantification (LOQ) in tea were 1.5 ng/g and 5.0 ng/g for HPLC−UV, and 0.25 ng/g and 0.83 ng/g for GC−MS. HPLC was simpler and more robust, while GC−MS showed higher sensitivity and selectivity. GC−MS was used to validate the HPLC−UV method and prove its accuracy. The PAT content of 219 Chinese tea samples was investigated. Most tea samples contained less than 10 ng/g, ten more than 10 ng/g and two more than 50 ng/g. The results imply that tea products in China are safe with regard to their PAT content. Even an extreme daily consumption of 25 g of the tea with the highest PAT content (124 ng/g), translates to an intake of only 3 μg/person/day, which is still an order of magnitude below the maximum allowed daily intake of 30 µg for an adult.

Mycotoxins along the tea supply chain: A dark side of an ancient and high valued aromatic beverage

ABSTRACTSTea (Camellia sinensis L.) is a high valued beverage worldwide since ancient times; more than three billion cups of tea are consumed each day. Leaf extracts of the plant are used for food preservation, cosmetics, and medicinal purposes. Nevertheless, tea contaminated with mycotoxins poses a serious health threat to humans. Mycotoxin production by tea fungi is induced by a variety of factors, including poor processing methods and environmental factors such as high temperature and humidity. This review summarizes the studies published to date on mycotoxin prevalence, toxicity, the effects of climate change on mycotoxin production, and the methods used to detect and decontaminate tea mycotoxins. While many investigations in this domain have been carried out on the prevalence of aflatoxins and ochratoxins in black, green, pu-erh, and herbal teas, much less information is available on zearalenone, fumonisins, and Alternaria toxins. Mycotoxins in teas were detected using several methods; the most commonly used being the High-Performance Liquid Chromatography (HPLC) with fluorescence detection, followed by HPLC with tandem mass spectrometry, gas chromatography and enzyme-linked immunosorbent assay. Further, mycotoxins decontamination methods for teas included physical, chemical, and biological methods, with physical methods being most prevalent. Finally, research gaps and future directions have also been discussed.

Development of a Novel UPLC-MS/MS Method for the Simultaneous Determination of 16 Mycotoxins in Different Tea Categories

The contamination of potential mycotoxins in tea production and consumption has always been a concern. However, the risk monitoring on multiple mycotoxins remains a challenge by existing methods due to the high cost and complex operation in tea matrices. This research has developed a simple ultra-performance liquid chromatography-tandem mass spectrometry strategy based on our homemade purification column, which can be applied in the detections of mycotoxins in complex tea matrices with high-effectively purifying and removing pigment capacity for 16 mycotoxins. The limits of detection and the limits of quantification were in the ranges of 0.015~15.00 and 0.03~30.00 µg·kg⁻¹ for 16 mycotoxins, respectively. Recoveries from mycotoxin-fortified tea samples (0.13~1200 µg·kg⁻¹) in different tea matrices ranged from 61.27 to 118.46%, with their relative standard deviations below 20%. Moreover, this method has been successfully applied to the analysis and investigation of the levels of 16 mycotoxins in major categories of tea and the monitoring of multiple mycotoxins in processed samples of ripened Pu-erh. In conclusion, the proposed strategy is simple, effective, time-saving, and low-cost for the determination of a large number of tea samples.

Effect of inoculation with Penicillium chrysogenum on chemical components and fungal communities in fermentation of Pu-erh tea

Developing an effective method to improve the quality of Pu-erh tea is of great scientific and commercial interest. In this work, Penicillium chrysogenum P1 isolated from Pu-erh tea was inoculated in sterilized or unsterilized sun-dreid green tea leaves to develop pure-culture fermentation (PF) and enhanced fermentation (EF) of Pu-erh tea. Spectrophotometry and high performance liquid chromatography determined that contents of free amino acids (FAA), total tea polyphenols and eight polyphenolic compounds in PF were significantly lower than these in non-inoculation control test (CK) (P < 0.05), whereas the contents of soluble sugars and theabrownins (TB) in PF were significantly higher (P < 0.05) than in CK. A total of 416 volatile compounds were detected by headspace solid-phase micro-extraction combined with gas chromatography-mass spectrometry. Comparison to CK, 124 compounds in PF were degraded or decreased significantly [Variable importance in projection [(VIP) > 1.0, P < 0.05, fold change (FC) < 0.5], whereas 110 compounds in PF were formed or increased significantly (VIP > 1.0, P < 0.05, FC > 2). Compared with normal fermentation (NF), the levels of gallic acid, (+)-catechin, (-)-epicatechin and 64 volatile compounds in EF were significantly lower (VIP > 1.0, P < 0.05, FC < 0.5), whereas the levels of FAA and 39 volatile compounds were significantly higher (VIP > 1.0, P < 0.05, FC > 2). Amplicon sequencing of fungal internal transcribed spacer 1 (ITS1) revealed that P. chrysogenum P1 didn't become the dominant fungus in EF; while the fungal communities in EF were different from those in NF, in that the relative abundances of Blastobotrys bambusae and P. chrysogenum in EF were higher, and the relative abundances of Aspergillus niger and Kluyveromyces marxianus in EF were lower. Overall, inoculation of P. chrysogenum in unsterilized sun-dreid green tea leaves changed the the fungal communities in fermentation of Pu-erh tea, and chemical compounds in fermented tea leaves, i.e., the levels of TB and the compounds responsible for the stale flavor, e.g., 2-amino-4-methoxybenzothiazole were increased, resulting in improvement of the sensory quality, including mellower taste and stronger stale flavor.

Effects and mechanisms of tea on obesity

Obesity has become a global health concern. It increases the risk of several diseases, such as type 2 diabetes mellitus, nonalcoholic fatty liver disease, and certain cancers, which threatens human health and increases social economic burden. As one of the most consumed beverages, tea contains various phytochemicals with potent bioactive properties and health-promoting effects, such as antioxidant, immune-regulation, cardiovascular protection and anticancer. Tea and its components are also considered as potential candidates for anti-obesity. Epidemiological studies indicate that regular consumption of tea is beneficial for reducing body fat. In addition, the experimental studies demonstrate that the potential anti-obesity mechanisms of tea are mainly involved in increasing energy expenditure and lipid catabolism, decreasing nutrient digestion and absorption as well as lipid synthesis, and regulating adipocytes, neuroendocrine system and gut microbiota. Moreover, most of clinical studies illustrate that the intake of green tea could reduce body weight and alleviate the obesity. In this review, we focus on the effect of tea and its components on obesity from epidemiological, experimental, and clinical studies, and discuss their potential mechanisms.

Determination and Comprehensive Risk Assessment of Dietary Exposure to Ochratoxin A on Fermented Teas

A specialized method for ochratoxin A (OTA) determination on fermented teas was developed and validated using ultraperformance liquid chromatography tandem mass spectrometry (UPLC-MS/MS). Methodology results showed that recovery, relative standard deviation, accuracy, and precision were qualified. The limits of detection and quantification were 0.32 and 0.96 μg/kg, respectively. Two of 158 collected samples were screened for OTA contamination. Comprehensive risk assessment based on OTA contaminations of this study and other peer-reviewed publications was performed. The highest hazard quotient (HQ) value (8.86 × 10^-2) and the highest 1/MoE value (8.61 × 10^-5) in probabilistic assessment were equally below the recommended non-neoplastic and neoplastic thresholds, indicating no health risks. However, the HQ and 1/MoE values of the 95th percentiles in 20-39 and ≥50 years of age were close to thresholds of 1.0 and 1.0 × 10^-4, respectively. Under the extreme case, there were only a few scenarios (e.g., 40-49 years of age) of HQ values below the non-neoplastic threshold, but the 1/MoE value of each group exceeded the neoplastic threshold. This is the first extensive risk assessment on OTA from fermented teas worldwide, but the sample size is still limited, and a large number of samples is encouraged in a future study for a more accurate assessment.

Aflatoxin B1 and sterigmatocystin: method development and occurrence in tea

Tea is one of the most popular beverage in the world and may be contaminated by fungi and mycotoxins during processing. To analyse aflatoxin B₁ (AFB₁) and sterigmatocystin (STC) in three types of tea, a simple, fast, sensitive and reliable method of these two myxotoxins was developed. Recoveries obtained ranged from 95.9% to 118.0% and the RSDs were between 0.3% and 11.2%. The range of LODs was 0.2-0.45 µg/kg for AFB₁ and 0.04-0.12 µg/kg for STC. The range of LOQs was 0.67-1.73 µg/kg for AFB₁ and 0.13-0.40 µg/kg for STC. The optimised procedure was applied to analyse 126 tea samples randomly collected from different markets in China. AFB₁ was not detected, but STC was determined in 17 samples with concentrations ranging from 0.13 to 4.48 µg/kg. The detection rate of STC was 5%, 8.9% and 33.3% in black tea, green tea and Oolong tea, respectively.

Effects of bioactive components of Pu-erh tea on gut microbiomes and health: A review

Pu-erh tea is a post-fermentation tea with unique flavor and multiple health benefits. Due to the various microorganisms involved in the post-fermentation process, Pu-erh tea contains highly complex components, which have rich interactions with the gut microbiomes (GMs). Because the structure and homeostasis of GMs are closely related to human wellness and the various diseases progress, the beneficial effects of Pu-erh tea on GMs have a great potential for application in health care. However, there is no systematic summary of the bioactive components of Pu-erh tea, and their effects on the GMs. Here, we review the current studies on the effects of Pu-erh tea and its bioactive components on the structure of GMs as well as on health improvement, and further discuss the relevant quality indicators. This "components - function - indicators" clue will hopefully stimulate the standardization of Pu-erh tea fermentation process and the development of its functional products.

Comparison of characteristic components in tea-leaves fermented by Aspergillus pallidofulvus PT-3, Aspergillus sesamicola PT-4 and Penicillium manginii PT-5 using LC-MS metabolomics and HPLC analysis

Microbiota influenced quality formation of ripened Pu-erh tea. To understand the effect of each tea-derived fungal strain, tea-leaves were fermented by Aspergillus pallidofulvus PT-3 (ApaPT), Aspergillus sesamicola PT-4 (AsePT) and Penicillium manginii PT-5 (PmaPT), respectively. 14 Phenolic compounds, 3 purine alkaloids, 19 free amino acids and γ-aminobutyric acid contents were determined by HPLC and amino acid analyzer analysis. Additionally, UHPLC-Q-TOF/MS method was developed for LC-MS metabolomics analysis. Multivariate statistical analyses, such as PCA and HCA, exhibited that the chemical profile of PmaPT fermentation was similar to biocidal treatment, but had significant differences with ApaPT and AsePT fermentation. The differentiated metabolites (VIP > 1, p < 0.05 and FC > 1.50 or < 0.66) and one-way ANOVA revealed the impact of three fungal strains in tea-leaves fermentation. APaPT and AsePT contributed to biosynthesis of gallic acid and several flavonoids, such as kaempferol, quercetin and myricetin in the metabolism of phenolic compounds.

Drinking Green Tea: Despite the Risks Due to Mycotoxins, Is It Possible to Increase the Associated Health Benefits?

Tea has been consumed for thousands of years. Despite the different varieties, particular emphasis has been placed on green tea (GT), considering the associated health benefits following its regular consumption, some of which are due to its polyphenol constituents, such as epigallocatechin-3-gallate (EGCG). Tea is not prone to the growth of microorganisms, except fungus, when proper storage, handling, and packing conditions are compromised. Consequently, mycotoxins, secondary metabolites of fungi, could contaminate tea samples, affecting human health. In the present study, we aimed to assess the balance between risks (due to mycotoxins and high levels of EGCG) and benefits (due to moderate intake of EGCG) associated with the consumption of GT. For this, 20 GT samples (10 in bulk and 10 in bags) available in different markets in Lisbon were analyzed through a LC–MS/MS method, evaluating 38 different mycotoxins. Six samples revealed detectable values of the considered toxins. Current levels of mycotoxins and EGCG intake were not associated with health concerns. Scenarios considering an increasing consumption of GT in Portugal showed that drinking up to seven cups of GT per day should maximize the associated health benefits. The present study contributes to the future establishment of GT consumption recommendations in Portugal.

Evaluation of Mycoflora and Citrinin Occurrence in Chinese Liupao Tea

Citrinin (CIT), a known nephrotoxic mycotoxin, is mainly produced by Penicillium, Aspergillus, and Monascus species. It is a natural contaminant in cereal grains, foods, and feedstuff. Liupao tea (or Liubao tea) is a typical Chinese dark tea obtained via indigenous tea fermentation facilitated by microorganisms. Certain fungi present in Liupao tea that may produce CIT are a potential threat to consumer health. In the present study, various potential toxigenic mycoflora and the natural occurrence of CIT in Liupao tea were surveyed via the culture-dependent method, high performance liquid chromatography-fluorescence detection (HPLC-FLD), and ultrahigh performance liquid chromatography-tandem mass spectrometry (UHPLC-MS/MS). Total mold counts ranged from 3.5 × 10² CFU/g to 2.1 × 10⁶ CFU/g tea in 28 tea samples. A total of 218 fungal isolates belonging to five genera and 23 species were identified. Some of these strains, such as Aspergillus ochraceus, Aspergillus oryzae, Penicillium citrinum, and Penicillium chrysogenum, may potentially be a CIT-producing species. In addition, 32.7% of 113 Liupao tea samples were contaminated with CIT at concentrations ranging from 7.8 to 206.1 μg/kg. These CIT concentrations in Liupao tea are chiefly attributed to climatic conditions and water activity during storage that favor fungal proliferation and mycotoxin production. However, CIT could not be detected in Liupao tea stored for over 10 years. These results provide the first information about the potential toxigenic mycoflora and natural occurrence of CIT in Liupao tea. Therefore, storage conditions and fungal community must be monitored to ensure the quality of Liupao tea.

Determination of Fungi and Multi-Class Mycotoxins in Camelia Sinensis and Herbal Teas and Dietary Exposure Assessment

In this paper, a study of fungal and multi-mycotoxin contamination in 140 Camellia sinensis and 26 herbal teas marketed in Latvia is discussed. The analysis was performed using two-dimensional liquid chromatography with time-of-flight mass spectrometry (2D-LC-TOF-MS) and MALDI-TOF-MS. In total, 87% of the tea samples tested positive for 32 fungal species belonging to 17 genera, with the total enumeration of moulds ranging between 1.00 × 10¹ and 9.00 × 10⁴ CFU g⁻¹. Moreover, 42% of the teas (n = 70) were contaminated by 1 to 16 mycotoxins, and 37% of these samples were positive for aflatoxins at concentrations ranging between 0.22 and 41.7 µg kg⁻¹. Deoxynivalenol (DON) and its derivatives co-occurred in 63% of the tea samples, with their summary concentrations reaching 81.1 to 17,360 µg kg⁻¹. Ochratoxin A (OTA), enniatins, and two Alternaria toxins were found in 10–37% of the teas at low concentrations. The dietary exposure assessment based on the assumption of a probable full transfer of determined mycotoxins into infusions indicated that the analysed teas are safe for consumers: the probable maximum daily exposure levels to OTA and the combined DON mycotoxins were only 0.88 to 2.05% and 2.50 to 78.9% of the tolerable daily intake levels.

Mycotoxins Detection and Fungal Contamination in Black and Green Tea by HPLC-Based Method

The fungal contamination and total aflatoxins (AF) and ochratoxin A (OTA) of tea samples were examined. A total of 60 tea samples were extracted and treated with immunoaffinity columns. The amount of AF and OTA were determined by using high-performance liquid chromatography (HPLC) with a fluorescence detector (FD). Tea samples were cultured and the fungi were identified. The results showed that 24 (40%) samples were contaminated with AFs and none of the tea samples were above the acceptable limit of AFs (≥10 μg/kg). All of the samples were contaminated with OTA where only 3 black tea samples (6.6%) and 1 green tea sample (6.7%) were detected to have more than the standard limits of toxin (10 μg·kg⁻¹). The mean concentration of OTA in the black tea was higher than green tea. Aspergillus niger was the predominant fungi isolated from black and green tea samples. Considering the high contamination of mycotoxins in tea samples, regular monitoring in the tea process for improving quality is recommended.

Determination of six groups of mycotoxins in Chinese dark tea and the associated risk assessment

Chinese dark tea is widely enjoyed for its multiple health-promoting effects and pleasant taste. However, its production involves fermentation by microbiota in raw tea, some of which are filamentous fungi and thus potential mycotoxin producers. Accordingly, whether mycotoxins pose health risk on dark tea consumption has become a public concern. In this study, a cleaning method of multi-functional column (MFC) and immunoaffinity column (IAC) in tandem combined to HPLC detection was developed and validated for determining ten mycotoxins of six groups (i.e., aflatoxins of B₁, B₂, G₁ and G₂, ochratoxin A, zearalenone, deoxynivalenol, fumonisins of B₁, B₂, and T-2) in dark teas. The interferences from secondary metabolites were effectively reduced, and the sensitivities and recoveries of the method were qualified for tea matrices. Six groups mycotoxins were determined in 108 samples representing the major Chinese dark teas by using the new method. Subsequently, the dietary exposure and health risks were evaluated for different age and gender groups in Kunming and Pu'er in China and Ulan Bator in Mongolia. The occurrence of zearalenone was 4.63% and that of ochratoxin A was 1.85%, with the other four groups mycotoxins were below the limits of quantification. The hazard index values for the five groups' non-carcinogenic mycotoxins were far below 1.0. The deterministic risk assessment indicated no non-carcinogenic risks for dark tea consumption in the three areas. Probabilistic estimation showed that the maximum value of 95th percentile carcinogenic risk value for the aflatoxins was 2.12 × 10^-8, which is far below the acceptable carcinogenic risk level (10^-6). Hereby, six groups mycotoxins in Chinese dark tea showed no observed risk concern to consumers.

Risk assessment of ochratoxin A in food

The European Commission asked EFSA to update their 2006 opinion on ochratoxin A (OTA) in food. OTA is produced by fungi of the genus Aspergillus and Penicillium and found as a contaminant in various foods. OTA causes kidney toxicity in different animal species and kidney tumours in rodents. OTA is genotoxic both in vitro and in vivo; however, the mechanisms of genotoxicity are unclear. Direct and indirect genotoxic and non-genotoxic modes of action might each contribute to tumour formation. Since recent studies have raised uncertainty regarding the mode of action for kidney carcinogenicity, it is inappropriate to establish a health-based guidance value (HBGV) and a margin of exposure (MOE) approach was applied. For the characterisation of non-neoplastic effects, a BMDL 10 of 4.73 μg/kg body weight (bw) per day was calculated from kidney lesions observed in pigs. For characterisation of neoplastic effects, a BMDL 10 of 14.5 μg/kg bw per day was calculated from kidney tumours seen in rats. The estimation of chronic dietary exposure resulted in mean and 95th percentile levels ranging from 0.6 to 17.8 and from 2.4 to 51.7 ng/kg bw per day, respectively. Median OTA exposures in breastfed infants ranged from 1.7 to 2.6 ng/kg bw per day, 95th percentile exposures from 5.6 to 8.5 ng/kg bw per day in average/high breast milk consuming infants, respectively. Comparison of exposures with the BMDL 10 based on the non-neoplastic endpoint resulted in MOEs of more than 200 in most consumer groups, indicating a low health concern with the exception of MOEs for high consumers in the younger age groups, indicating a possible health concern. When compared with the BMDL 10 based on the neoplastic endpoint, MOEs were lower than 10,000 for almost all exposure scenarios, including breastfed infants. This would indicate a possible health concern if genotoxicity is direct. Uncertainty in this assessment is high and risk may be overestimated.

LC-MS/MS-based metabolomic analysis of caffeine-degrading fungus Aspergillus sydowii during tea fermentation

Natural microorganisms involved in solid-state fermentation (SSF) of Pu-erh tea have a significant impact on its chemical components. Aspergillus sydowii is a fungus with a high caffeine-degrading capacity. In this work, A. sydowii was inoculated into sun-dried green tea leaves for SSF. Metabolomic analysis was carried out by using UPLC-QTOF-MS method, and caffeine and related demethylated products were determined by HPLC. The results showed that A. sydowii had a significant (P < 0.05) impact on amino acids, carbohydrates, flavonoids, and caffeine metabolism. Moreover, A. sydowii could promote the production of ketoprofen, baclofen, and tolbutamide. Along with caffeine degradation, theophylline, 3-methylxanthine, 1,7-dimethylxanthine, 1-methylxanthine, and 7-methylxanthine were increased significantly (P < 0.05) during inoculated fermentation, which showed that demethylation was the main pathway of caffeine degradation in A. sydowii secondary metabolism. The absolute quantification analysis showed that caffeine could be demethylated and converted to theophylline and 3-methylxanthine. Particularly, about 93.24% of degraded caffeine was converted to theophylline, 27.92 mg/g of theophylline was produced after fermentation. PRACTICAL APPLICATION: Aspergillus sydowii could cause caffeine degradation in Pu-erh tea solid-state fermentation and produce theophylline through the demethylation route. Using a starter strain to ferment tea leaves offers a more controllable, reproducible, and highly productive alternative for the biosynthesis of theophylline.

Health Functions and Related Molecular Mechanisms of Tea Components: An Update Review

Tea is widely consumed all over the world. Generally, tea is divided into six categories: White, green, yellow, oolong, black, and dark teas, based on the fermentation degree. Tea contains abundant phytochemicals, such as polyphenols, pigments, polysaccharides, alkaloids, free amino acids, and saponins. However, the bioavailability of tea phytochemicals is relatively low. Thus, some novel technologies like nanotechnology have been developed to improve the bioavailability of tea bioactive components and consequently enhance the bioactivity. So far, many studies have demonstrated that tea shows various health functions, such as antioxidant, anti-inflammatory, immuno-regulatory, anticancer, cardiovascular-protective, anti-diabetic, anti-obesity, and hepato-protective effects. Moreover, it is also considered that drinking tea is safe to humans, since reports about the severe adverse effects of tea consumption are rare. In order to provide a better understanding of tea and its health potential, this review summarizes and discusses recent literature on the bioactive components, bioavailability, health functions, and safety issues of tea, with special attention paid to the related molecular mechanisms of tea health functions.

Anti-obesity effects of instant fermented teas in vitro and in mice with high-fat-diet-induced obesity

Obesity is a chronic metabolic disorder that is associated with higher risks of developing diabetes and cardiovascular disease. Chinese dark tea is a fermented beverage with many biological effects and could be considered for the management of obesity. This study is aimed to assess the possible anti-obesity properties of instant dark tea (IDT) and instant pu-erh tea (PET) in high fat diet (HFD)-fed mice. Male C57BL/6 mice were divided into 5 groups. They received low-fat diet (LFD), HFD, HFD supplemented with drinking IDT infusion (5 mg mL-1), PET infusion (5 mg mL-1) or water for 8 weeks. The results showed IDT exhibited better inhibitory effect than PET on body weight gain and visceral fat weights. IDT also improved the serum high-density lipoprotein cholesterol (HDL-C) level, but decreased the low-density lipoprotein cholesterol (LDL-C) and leptin levels more effectively than PET. Both IDT and PET lowered the levels of aspartate aminotransferase (AST) and alanine aminotransferase (ALT) in the plasma and significantly increased the ratio of albumin to globin (A/G) in the serum compared to the control group. IDT treatment reduced the malondialdehyde (MDA) level in the liver. Histomorphology evidenced that the liver tissue architecture was well preserved by IDT administration. Moreover, IDT regulated the expression of obesity-related genes more effectively than PET. Overall, the present findings have provided the proof of concept that dietary IDT could provide a safer and cost-effective option for people with HFD-induced obesity.

Production of theophylline via aerobic fermentation of pu-erh tea using tea-derived fungi

Background

Caffeine is one of the most abundant methylxanthines in tea, and it remains stable in processing of general teas. In the secondary metabolism of microorganism, theophylline is the main conversion product in caffeine catabolism through demethylation. Microorganisms, involved in the solid-state fermentation of pu-erh tea, have a certain impact on caffeine level. Inoculating an appropriate starter strain that is able to convert caffeine to theophylline would be an alternative way to obtain theophylline in tea. The purpose of this study was to isolate and identify the effective strain converting caffeine to theophylline in pu-erh tea, and discuss the optimal conditions for theophylline production.

Results

Caffeine content was decreased significantly (p < 0.05) and theophylline content was increased significantly (p < 0.05) during the aerobic fermentation of pu-erh tea. Five dominant fungi were isolated from the aerobic fermentation and identified as Aspergillus niger, Aspergillus sydowii, Aspergillus pallidofulvus, Aspergillus sesamicola and Penicillium mangini, respectively. Especially, A. pallidofulvus, A. sesamicola and P. mangini were detected in pu-erh tea for the first time. All isolates except A. sydowii TET-2, enhanced caffeine content and had no significant influence on theophylline content. In the aerobic fermentation of A. sydowii TET-2, 28.8 mg/g of caffeine was degraded, 93.18% of degraded caffeine was converted to theophylline, and 24.60 mg/g of theophylline was produced. A. sydowii PET-2 could convert caffeine to theophylline significantly, and had application potential in the production of theophylline. The optimum conditions of theophylline production in the aerobic fermentation were 1) initial moisture content of 35% (w/w), 2) inoculation quantity of 8%, and 3) incubation temperature at 35 °C.

Conclusions

For the first time, we find that A. sydowii PET-2 could convert caffeine to theophylline, and has the potential value in theophylline production through aerobic fermentation.