Cutting-edge design to improve cell viability in osteochondral grafts

Osteochondral Allograft Reaming Significantly Affects Chondrocyte Viability

BACKGROUND

Chondrocyte viability is associated with the clinical success of osteochondral allograft (OCA) transplantation.

PURPOSE

To investigate the effect of distal femoral OCA plug harvest and recipient site preparation on regional cell viability using traditional handheld saline irrigation versus saline submersion.

STUDY DESIGN

Controlled laboratory study.

METHODS

For each of 13 femoral hemicondyles, 4 cartilage samples were harvested: (1) 5-mm control cartilage, (2) 15-mm OCA donor plug harvested with a powered coring reamer and concurrent handheld saline irrigation ("traditional"), (3) 15-mm OCA donor plug harvested while submerged under normal saline ("submerged"), and (4) 5-mm cartilage from the peripheral rim of a recipient socket created with a 15-mm cannulated counterbore reamer to a total depth of 7 mm with concurrent handheld saline irrigation ("recipient"). The 15 mm-diameter plugs were divided into the central 5 mm and the peripheral 5 mm (2 edges) for comparisons. Samples were stained using calcein and ethidium, and live/dead cell percentages were calculated and compared across groups.

RESULTS

Compared with the submerged group, the traditional group had significantly lower percentages of live cells across the whole plug (71.54% ± 4.82% vs 61.42% ± 4.98%, respectively; P = .003), at the center of the plug (72.76% ± 5.87% vs 62.30% ± 6.11%, respectively; P = .005), and at the periphery of the plug (70.93% ± 4.51% vs 60.91% ± 4.75%, respectively; P = .003). The traditional group had significantly fewer live cells in all plug regions compared with the control group (77.51% ± 9.23%; P < .0001). There were no significant differences in cell viability between the control and submerged groups (whole: P = .590; center: P = .713; periphery: P = .799). There were no differences between the central and peripheral 5-mm plug regions for the traditional (62.30% ± 6.11% vs 60.91% ± 4.75%, respectively; P = .108) and submerged (72.76% ± 5.87% vs 70.93% ± 4.51%, respectively; P = .061) groups. The recipient group (61.10% ± 5.02%) had significantly lower cell viability compared with the control group (P < .0001) and the periphery of the submerged group (P = .009) but was equivalent to the periphery of the traditional group (P = .990).

CONCLUSION

There was a significant amount of chondrocyte death induced by OCA donor plug harvesting using a powered coring reamer with traditional handheld saline irrigation, which was mitigated by harvesting the plug while the allograft was submerged under saline.

CLINICAL RELEVANCE

Mitigating this thermally induced damage by harvesting the OCA plug while the allograft was submerged in saline maintained chondrocyte viability throughout the plug and may help to improve the integration and survival of OCAs.

Harvest Technique Does Affect the Quality of Osteochondral Grafts: Histologic Evaluation Comparing Commercial Standards versus Scalpel Blade Technique

OBJECTIVE

While the percentage of viable cells is a major determinant of graft performance during osteochondral allograft (OCA) transplantation, the baseline chondrocyte viability at the periphery of osteochondral plugs is defined at the time of harvest. In this laboratory study, we aimed to determine the optimal technique for OCA plug harvest by evaluating commercial standard techniques compared to sharp blade harvest technique.

DESIGN

Osteochondral explants were harvested from bovine and human samples using 3 different techniques: (1) standard OATS manual punch device (Osteochondral Autograft Transplant System OATS; Arthrex, Naples, FL), (2) powered trephine device, and (3) fresh scalpel blade. Chondrocyte viability and the dead area at the periphery of the tissue were evaluated by LIVE/DEAD staining. Safranin-O and fast-green were performed for structural evaluation.

RESULTS

For both bovine and human samples, the dead area at the periphery of the explant was significantly smaller after scalpel blade preparation compared to harvest with OATS (P < 0.001) and powered trephine devices (P < 0.001). In addition, while powered device had a smaller remaining dead area compared to the OATS device (P < 0.001), there was significantly greater tissue loss and peripheral contour change for plugs harvested with the powered trephine device.

CONCLUSION

Our study demonstrated that OCA plugs harvested with OATS and powered device lead to a significant mechanical injury at the periphery of the explants compared to a scalpel. We propose that the optimal technique for OCA harvest utilizes a combined approach incorporating a scalpel blade/circular scalpel to prepare the chondral surface and a powered trephine to prepare the osseous surface.

Fresh Osteochondral and Chondral Allograft Preservation and Storage Media: A Systematic Review of the Literature

BACKGROUND

Storage procedures and parameters have a significant influence on the health of fresh osteochondral allograft (OCA) cartilage. To date, there is a lack of agreement on the optimal storage conditions for OCAs.

PURPOSE

To systematically review the literature on (1) experimental designs and reporting of key variables of ex vivo (laboratory) studies, (2) the effects of various storage solutions and conditions on cartilage health ex vivo, and (3) in vivo animal studies and human clinical studies evaluating the effect of fresh OCA storage on osteochondral repair and outcomes.

STUDY DESIGN

Systematic review; Level of evidence, 5.

METHODS

A systematic review was performed using the PubMed, Embase, and Cochrane databases. The inclusion criteria were laboratory studies (ex vivo) reporting cartilage health outcomes after prolonged storage (>3 days) of fresh osteochondral or chondral tissue explants and animal studies (in vivo) reporting outcomes of fresh OCA. The inclusion criteria for clinical studies were studies (>5 patients) that analyzed the relationship of storage time or chondrocyte viability at time of implantation to patient outcomes. Frozen, cryopreserved, decellularized, synthetic, or tissue-engineered grafts were excluded.

RESULTS

A total of 55 peer-reviewed articles met the inclusion criteria. Ex vivo studies reported a spectrum of tissue sources and storage solutions and conditions, although the majority of studies lacked complete reporting of key variables, including storage solution formula and environmental conditions. The effect of various conditions (eg, temperature) and storage solutions on cartilage health were inconsistent. Although 60% of animal models suggest that storage time may influence outcomes and 80% indicate inferior outcomes with frozen OCA as compared with fresh OCA, 75% of clinical studies report no correlation between storage time and outcomes.

CONCLUSION

Given the variability in experimental designs and lack of reporting across studies, it is still not possible to determine optimal storage conditions, although animal studies suggest that storage time and chondrocyte viability influence osteochondral repair outcomes. A list of recommendations was developed to encourage reporting of key variables, such as media formulation, environmental factors, and methodologies used. High-quality clinical data are needed to investigate the effects of storage and graft health on outcomes.

Acute Cartilage Injury Induced by Trans-Articular Sutures

OBJECTIVE

To determine the extent of acute cartilage injury by using trans-articular sutures.

METHODS

Five different absorbable sutures, monofilament polydioxanone (PDS) and braided polyglactin (Vicryl), were compared on viable human osteochondral explants. An atraumatic needle with 30 cm of thread was advanced through the cartilage with the final thread left in the tissue. A representative 300 μm transversal slice from the cartilage midportion was stained with Live/Dead probes, scanned under the confocal laser microscope, and analyzed for the diameters of (a) central "Black zone" without any cells, representing in situ thread thickness and (b) "Green zone," including the closest Live cells, representing the maximum injury to the tissue. The exact diameters of suture needles and threads were separately measured under an optical microscope.

RESULTS

The diameters of the Black (from 144 to 219 µm) and the Green zones (from 282 to 487 µm) varied between the different sutures (P < 0.001). The Green/Black zone ratio remained relatively constant (from 1.9 to 2.2; P = 0.767). A positive correlation between thread diameters and PDS suturing material, toward the Black and Green zone, was established, but needle diameters did not reveal any influence on the zones.

CONCLUSIONS

The width of acute cartilage injury induced by the trans-articular sutures is about twice the thread thickness inside of the tissue. Less compressible monofilament PDS induced wider tissue injury in comparison to a softer braided Vicryl. Needle diameter did not correlate to the extent of acute cartilage injury.

Optimization and Validation of a Human Ex Vivo Femoral Head Model for Preclinical Cartilage Research and Regenerative Therapies

OBJECTIVE

Articular cartilage is incapable of effective repair following injury or during osteoarthritis. While there have been developments in cartilage repair technologies, there is a need to advance biologically relevant models for preclinical testing of biomaterial and regenerative therapies. This study describes conditions for the effective ex vivo culture of the whole human femoral head.

DESIGN

Fresh, viable femoral heads were obtained from femoral neck fractures and cultured for up to 10 weeks in (a) Dulbecco's modified Eagle's medium (DMEM); (b) DMEM + mixing; (c) DMEM + 10% human serum (HS); (d) DMEM + 10% HS + mixing. The viability, morphology, volume, and density of fluorescently labelled in situ chondrocytes and cartilage surface roughness were assessed by confocal microscopy. Cartilage histology was studied for glycosaminoglycan content using Alcian blue and collagen content using picrosirius red.

RESULTS

Chondrocyte viability remained at >95% in DMEM + 10% HS. In DMEM alone, viability remained high for ~4 weeks and then declined. For the other conditions, superficial zone chondrocyte viability fell to <35% at 10 weeks with deeper zones being relatively unaffected. In DMEM + 10% HS at 10 weeks, the number of chondrocytes possessing cytoplasmic processes increased compared with DMEM (P = 0.017). Alcian blue labeling decreased (P = 0.02) and cartilage thinned (P ≤ 0.05); however, there was no change to surface roughness, chondrocyte density, chondrocyte volume, or picrosirius red labeling (P > 0.05).

CONCLUSIONS

In this ex vivo model, chondrocyte viability was maintained in human femoral heads for up to 10 weeks in culture, a novel finding not previously reported. This human model could prove invaluable for the exploration, development, and assessment of preclinical cartilage repair and regenerative therapies.

Biomechanical assessment of the stability of osteochondral grafts implanted in porcine and bovine femoral condyles

Osteochondral grafts are used clinically to repair cartilage and bone defects and to restore the congruent articulating surfaces of the knee joint following cartilage damage or injury. The clinical success of such osteochondral grafts is heavily reliant on the biomechanical and tribological properties of the surgical repair; however, a limited number of studies have investigated these factors. The aim of this study was to evaluate the influence of graft harvesting and implantation technique as well as bone properties on the primary stability of press-fit implanted osteochondral grafts using a series of uniaxial experimental push-in and push-out tests. Animal (porcine and bovine) knees were used to deliver models of different bone properties (elastic modulus and yield stress). The study showed the graft harvesting method using either a chisel or drill-aided trephine to have no influence on primary graft stability; however, the preparation technique for the graft recipient site was shown to influence the force required to push the graft into the host tissue. For example, when the length of the graft was equal to the recipient site (bottomed), the graft was more stable and dilation of the recipient site was shown to reduce short-term graft stability especially in immature or less dense bone tissue. The push-out tests which compared tissue of different skeletal maturities demonstrated that the maturity of both the graft and host bone tissue to influence the stability of the graft. A higher force was required to push out more skeletally mature grafts from mature bone tissue. The study demonstrates the importance of surgical technique and bone quality/properties on the primary stability and ultimately, the success of osteochondral grafts in the knee.

In vivo evaluation of porous hydrogel pins to fill osteochondral defects in rabbits

Objective

This experimental study aimed to evaluate the biological performance of poly (l-co-D, l-lactic acid)-co-trimetilene carbonate/poly (vinyl alcohol) (PLDLA-co TMC/PVA), hydrogel scaffolds, as an implant in the filling (and not in the repair) of osteochondral defects in New Zealand rabbits, assessing the influence of the material in tissue protection in vivo.

Methods

Twelve rabbits were divided into groups of nine and 16 weeks. In each animal, an osteochondral defect was created in both medial femoral condyles. In one knee, a hydrogel scaffold was implanted (pin group) and in the other, the defect was maintained (control group). A histological analysis of the material was performed after euthanasia.

Results

The condyles of the pin group showed no inflammatory reaction and were surrounded by a fibrous capsule. The control group presented higher bone growth in the areas of the defect, but with disorganized articular cartilage, evident fibrosis, bone exposure, atrophy, and proliferation of synovial membrane.

Conclusion

The hydrogel pins are promising in filling osteochondral defects, generally do not cause inflammatory reactions, and are not effective in the repair of osteochondral defects.

Mapping Chondrocyte Viability, Matrix Glycosaminoglycan, and Water Content on the Surface of a Bovine Metatarsophalangeal Joint

OBJECTIVE

The purpose of this study was to determine if there were variations in chondrocyte viability, matrix glycosaminoglycan (GAG), and water content between different areas of the articular surface of a bovine metatarsophalangeal joint, a common and reliable source of articular cartilage for experimental study, which may compromise the validity of using multiple samples from different sites within the joint.

METHODS

Nine fresh cadaveric bovine metatarsophalangeal joints were obtained. From each joint, 16 osteochondral explants were taken from 4 facets, yielding a total of 144 cartilage specimens for evaluation of chondrocyte viability, matrix GAG, and water content. A less invasive method for harvesting osteochondral explants and for processing the biopsy for the assessment of chondrocyte viability was developed, which maintained maximal viability within each cartilage explant.

RESULTS

There was no significant difference between the 16 biopsy sites from the different areas of the joint surface with respect to chondrocyte viability, matrix GAG and water content. Pooled data of all samples from each joint established the baseline values of chondrocyte viability to be 89.4% ± 3.8%, 94.4% ± 2.2%, and 77.9% ± 7.8%, in the superficial quarter, central half, and deep quarter (with regard to depth from the articular surface), respectively. The matrix GAG content of bovine articular cartilage was 6.06 ± 0.41 μg/mg cartilage, and the cartilage water content was 72.4% ± 1.5%. There were also no significant differences of these 3 variables between the different joints.

CONCLUSION

It is thus reasonable to compare biopsies obtained from different sites, as a biopsy from one site would be considered representative of the whole joint.

In vitro models for the study of osteoarthritis

Osteoarthritis (OA) is a prevalent disease of most mammalian species and is a significant cause of welfare and economic morbidity in affected individuals and populations. In vitro models of osteoarthritis are vital to advance research into the causes of the disease, and the subsequent design and testing of potential therapeutics. However, a plethora of in vitro models have been used by researchers but with no consensus on the most appropriate model. Models attempt to mimic factors and conditions which initiate OA, or dissect the pathways active in the disease. Underlying uncertainty as to the cause of OA and the different attributes of isolated cells and tissues used mean that similar models may produce differing results and can differ from the naturally occurring disease. This review article assesses a selection of the in vitro models currently used in OA research, and considers the merits of each. Particular focus is placed on the more prevalent cytokine stimulation and load-based models. A brief review of the mechanism of these models is given, with their relevance to the naturally occurring disease. Most in vitro models have used supraphysiological loads or cytokine concentrations (compared with the natural disease) in order to impart a timely response from the cells or tissue assessed. Whilst models inducing OA-like pathology with a single stimulus can answer important biological questions about the behaviour of cells and tissues, the development of combinatorial models encompassing different physiological and molecular aspects of the disease should more accurately reflect the pathogenesis of the naturally occurring disease.

The osteotome: a design by Sir William Macewen

The osteotome is ostensibly a simple surgical instrument. In fact it was carefully designed to allow accurate aseptic osteotomy for deformities around the knee. Here we outline William Macewen's classic work on the design of this tool and set this work in the context of his life.

Knee chondral injuries: clinical treatment strategies and experimental models

Articular cartilage has a very limited capacity to repair and as such premature joint degeneration is often the end point of articular injuries. Patients with chondral injury have asymptomatic periods followed by others in which discomfort or pain is bearable. The repair of focal cartilage injuries requires a precise diagnosis, a completed knee evaluation to give the correct indication for surgery proportional to the damage and adapted to each patient. Many of the surgical techniques currently performed involve biotechnology. The future of cartilage repair should be based on an accurate diagnosis using new MRI techniques. Clinical studies would allow us to establish the correct indications and surgical techniques implanting biocompatible and biodegradable matrices with or without stem cells and growth factors. Arthroscopic techniques with the design of new instruments can facilitate repair of patella and tibial plateau lesions.

Hyperosmolarity protects chondrocytes from mechanical injury in human articular cartilage

The aim of this study was to determine whether exposure of human articular cartilage to hyperosmotic saline (0.9%, 600 mOsm) reduces in situ chondrocyte death following a standardised mechanical injury produced by a scalpel cut compared with the same assault and exposure to normal saline (0.9%, 285 mOsm). Human cartilage explants were exposed to normal (control) and hyperosmotic 0.9% saline solutions for five minutes before the mechanical injury to allow in situ chondrocytes to respond to the altered osmotic environment, and incubated for a further 2.5 hours in the same solutions following the mechanical injury.

Using confocal laser scanning microscopy, we identified a sixfold (p = 0.04) decrease in chondrocyte death following mechanical injury in the superficial zone of human articular cartilage exposed to hyperosmotic saline compared with normal saline.

These data suggest that increasing the osmolarity of joint irrigation solutions used during open and arthroscopic articular surgery may reduce chondrocyte death from surgical injury and could promote integrative cartilage repair.

Chondrocyte repopulation of the zone of death induced by osteochondral harvest

OBJECTIVE

Harvesting osteochondral grafts results in a zone of chondrocyte death (ZCD) in and around the periphery of the graft, creating a barrier for chondrocytes to migrate to the graft periphery, thus limiting cartilage-to-cartilage healing. The purpose of this study was to repopulate the induced ZCD through the combined effects of collagenase treatment and delivery of a chemotactic agent.

DESIGN

In bovine cartilage, the ZCD induced by the OATS™ osteochondral harvesting system was determined, followed by a corresponding collagenase treatment to penetrate the developed ZCD. The chemotactic potential of platelet derived growth factor (PDGF-bb), insulin-like growth factor I (IGF-I), and basic fibroblast growth factor (bFGF) (2.5-100 ng/mL) was then assessed using a modified Boyden chamber assay to select an appropriate agent to induce chondrocyte migration. Afterwards, the combined effects of collagenase treatment and chondrocyte chemotaxis on the repopulation of an induced ZCD were examined in cartilage explants over a 4-week-period.

RESULTS

The OATS™ osteochondral harvesting system induced a significant ZCD (173 μm, 95% CI: [72-274 μm]) in the grafts. Chondrocyte chemotaxis was induced by all agents investigated at concentrations greater than 25 ng/mL. After 4 weeks in culture, collagenase treatment alone reduced the ZCD by approximately 40% relative to untreated explants. Coupling the collagenase treatment with 25 ng/mL IGF-I reduced the ZCD by approximately 80% relative to untreated explants, and 65% relative to explants treated only with collagenase.

CONCLUSION

Treating cartilage explants with collagenase and 25 ng/mL IGF-I resulted in a decreased ZCD after a 4-week-period, and increased chondrocyte density within the induced ZCD.

Evaluation of subsidence, chondrocyte survival and graft incorporation following autologous osteochondral transplantation

PURPOSE

The aim of this study was to evaluate subsidence tendency, surface congruency, chondrocyte survival and plug incorporation after osteochondral transplantation in an animal model. The potential benefit of precise seating of the transplanted osteochondral plug on the recipient subchondral host bone ('bottoming') on these parameters was assessed in particular.

METHODS

In 18 goats, two osteochondral autografts were harvested from the trochlea of the ipsilateral knee joint and inserted press-fit in a standardized articular cartilage defect in the medial femoral condyle. In half of the goats, the transplanted plugs were matched exactly to the depth of the recipient hole (bottomed plugs; n = 9), whereas in the other half of the goats, a gap of 2 mm was left between the plugs and the recipient bottom (unbottomed plugs; n = 9). After 6 weeks, all transplants were evaluated on gross morphology, subsidence, histology, and chondrocyte vitality.

RESULTS

The macroscopic morphology scored significantly higher for surface congruency in bottomed plugs as compared to unbottomed reconstructions (P = 0.04). However, no differences in histological subsidence scoring between bottomed and unbottomed plugs were found. The transplanted articular cartilage of both bottomed and unbottomed plugs was vital. Only at the edges some matrix destaining, chondrocyte death and cluster formation was observed. At the subchondral bone level, active remodeling occurred, whereas integration at the cartilaginous surface of the osteochondral plugs failed to occur. Subchondral cysts were found in both groups.

CONCLUSIONS

In this animal model, subsidence tendency was significantly lower after 'bottomed' versus 'unbottomed' osteochondral transplants on gross appearance, whereas for histological scoring no significant differences were encountered. Since the clinical outcome may be negatively influenced by subsidence, the use of 'bottomed' grafts is recommended for osteochondral transplantation in patients.

Increasing the osmolarity of joint irrigation solutions may avoid injury to cartilage: a pilot study

Saline (0.9%, 285 mOsm) and Hartmann's solution (255 mOsm) are two commonly used joint irrigation solutions that alter the extracellular osmolarity of in situ chondrocytes during articular surgery. We asked whether varying the osmolarity of these solutions influences in situ chondrocyte death in mechanically injured articular cartilage. We initially exposed osteochondral tissue harvested from the metacarpophalangeal joints of 3-year-old cows to solutions of 0.9% saline and Hartmann's solution of different osmolarity (100-600 mOsm) for 2 minutes to allow in situ chondrocytes to respond to the altered osmotic environment. The full thickness of articular cartilage then was "injured" with a fresh scalpel. Using confocal laser scanning microscopy, in situ chondrocyte death at the injured cartilage edge was quantified spatially as a function of osmolarity at 2.5 hours. Increasing the osmolarity of 0.9% saline and Hartmann's solution to 600 mOsm decreased in situ chondrocyte death in the superficial zone of injured cartilage. Compared with 0.9% saline, Hartmann's solution was associated with greater chondrocyte death in the superficial zone of injured cartilage, but not when the osmolarity of both solutions was increased to 600 mOsm. These experiments may have implications for the design of irrigation solutions used during arthroscopic and open articular surgery.

Tissue neogenesis and STRO-1 expression in immature and mature articular cartilage

This study determined the potential for neotissue formation and the role of STRO-1+ cells in immature versus mature articular cartilage. Cartilage explants from immature and mature bovine knee joints were cultured for up to 12 weeks and stained with safranin-O, for type II collagen and STRO-1. Bovine chondrocyte pellet cultures and murine knee joints at the age of 2 weeks and 3 months, and surgically injured cartilage, were analyzed for changes in STRO-1 expression patterns. Results show that immature explants contained more STRO-1+ cells than mature explants. After 8 weeks in culture, immature explants showed STRO-1+ cell proliferation and newly formed tissue, which contained glycosaminoglycan and type II collagen. Mature cartilage explants showed only minimal cell expansion and neotissue formation. Pellet cultures with chondrocytes from immature cartilage showed increased glycosaminoglycan synthesis and STRO-1+ staining, as compared to pellets with mature chondrocytes. The frequency of STRO-1+ cells in murine knee joints significantly declined with joint maturation. Following surgical injury, immature explants had higher potential for tissue repair than mature explants. In conclusion, these findings suggest that the high percentage of STRO-1+ cells in immature cartilage changes with joint maturation. STRO-1+ cells have the potential to form new cartilage spontaneously and after tissue injury.

Enhanced tissue integration during cartilage repair in vitro can be achieved by inhibiting chondrocyte death at the wound edge

OBJECTIVE

Experimental wounding of articular cartilage results in cell death at the lesion edge. The objective of this study was to investigate whether inhibition of this cell death results in enhanced integrative cartilage repair.

METHODS

Bovine articular cartilage discs (6 mm) were incubated in media containing inhibitors of necrosis (Necrostatin-1, Nec-1) or apoptosis (Z-VAD-FMK, ZVF) before cutting a 3 mm inner core. This core was left in situ to create disc/ring composites, cultured for up to 6 weeks with the inhibitors, and analyzed for cell death, sulfated glycosaminoglycan release, and tissue integration.

RESULTS

Creating the disc/ring composites resulted in a significant increase in necrosis. ZVF significantly reduced necrosis and apoptosis at the wound edge. Nec-1 reduced necrosis. Both inhibitors reduced the level of wound-induced sulfated glycosaminoglycan loss. Toluidine blue staining and electron microscopy of cartilage revealed significant integration of the wound edges in disc/ring composites treated with ZVF. Nec-1 improved integration, but to a lesser extent. Push-out testing revealed that ZVF increased adhesive strength compared to control composites.

CONCLUSIONS

This study shows that treatment of articular cartilage with cell death inhibitors during wound repair increases the number of viable cells at the wound edge, prevents matrix loss, and results in a significant improvement in cartilage-cartilage integration.

Osmolarity influences chondrocyte death in wounded articular cartilage

BACKGROUND

Mechanical injury results in chondrocyte death in articular cartilage. The purpose of the present study was to determine whether medium osmolarity affects chondrocyte death in injured articular cartilage.

METHODS

Osteochondral explants (n = 48) that had been harvested from the metacarpophalangeal joints of three-year-old cows were exposed to media with varying osmolarity (0 to 480 mOsm) for ninety seconds to allow in situ chondrocytes to respond to the altered osmotic environment. Explants were then wounded with a scalpel through the full thickness of articular cartilage, incubated in the same media for 2.5 hours, and transferred to 340-mOsm Dulbecco's Modified Eagle Medium (control medium) with further incubation for seven days. The spatial distribution of in situ chondrocyte death, percentage cell death, and marginal cell death at the wounded cartilage edge were compared as a function of osmolarity and time (2.5 hours compared with seven days) with use of confocal laser scanning microscopy.

RESULTS

In situ chondrocyte death was mainly localized to the superficial tangential zone of injured articular cartilage for the range of medium osmolarities (0 to 480 mOsm) at 2.5 hours and seven days. Therefore, a sample of articular cartilage from the superficial region (which included the scalpel-wounded cartilage edge) was studied with use of confocal laser scanning microscopy to compare the effects of osmolarity on percentage and marginal cell death in the superficial tangential zone. Compared with the control explants exposed to 340-mOsm Dulbecco's Modified Eagle Medium, percentage cell death in the superficial tangential zone was greatest for explants exposed to 0-mOsm (distilled water) and least for explants exposed to 480-mOsm Dulbecco's Modified Eagle Medium at 2.5 hours (13.0% at 340 mOsm [control], 35.5% at 0 mOsm, and 4.3% at 480 mOsm; p <or= 0.02 for paired comparisons) and seven days (9.9% at 340 mOsm [control], 37.7% at 0 mOsm, and 3.5% at 480 mOsm; p <or= 0.01 for paired comparisons). Marginal cell death in the superficial tangential zone decreased with increasing medium osmolarity at 2.5 hours (p = 0.001) and seven days (p = 0.002). There was no significant change in percentage cell death from 2.5 hours to seven days for explants initially exposed to any of the medium osmolarities.

CONCLUSIONS

Medium osmolarity significantly affects chondrocyte death in wounded articular cartilage. The greatest chondrocyte death occurs at 0 mOsm. Conversely, increased medium osmolarity (480 mOsm) is chondroprotective. The majority of cell death occurs within 2.5 hours, with no significant increase over seven days.

Cartilage repair with osteochondral autografts in sheep: effect of biophysical stimulation with pulsed electromagnetic fields

The effect of pulsed electromagnetic fields (PEMFs) on the integration of osteochondral autografts was evaluated in sheep. After osteochondral grafts were performed, the animals were treated with PEMFs for 6 h/day or sham-treated. Six animals were sacrificed at 1 month. Fourteen animals were treated for 2 months and sacrificed at 6 months. At 1 month, the osteogenic activity at the transplant-host subchondral bone interface was increased in PEMF-treated animals compared to controls. Articular cartilage was healthy in controls and stimulated animals. At 6 months, complete resorption was observed in four control grafts only. Cyst-like resorption areas were more frequent within the graft of sham-treated animals versus PEMF-treated. The average volume of the cysts was not significantly different between the two groups; nevertheless, analysis of the variance of the volumes demonstrated a significant difference. The histological score showed no significant differences between controls and stimulated animals, but the percentage of surface covered by fibrous tissue was higher in the control group than in the stimulated one. Interleukin-1 and tumor necrosis factor-alpha concentration in the synovial fluid was significantly lower, and transforming growth factor-beta1 was significantly higher, in PEMF-treated animals compared to controls. One month after osteochondral graft implantation, we observed larger bone formation in PEMF-treated grafts which favors early graft stabilization. In the long term, PEMF exposure limited the bone resorption in subchondral bone; furthermore, the cytokine profile in the synovial fluid was indicative of a more favorable articular environment for the graft.

Fluorescent viability stains overestimate chondrocyte viability in osteoarticular allografts

BACKGROUND

Allografts from many tissue banks are carefully processed and stored with the goal of preserving chondrocyte viability. However, the importance of living chondrocytes for graft stability is unclear, in part because actual viabilities of individual allografts at the time of placement are seldom known.

HYPOTHESES

Cell yields from allograft and fresh cartilage differ significantly if chondrocyte viability in allografts is lower than indicated by fluorescence staining with conventional viability probes. In addition, transmission electron microscopy will show significant differences in the percentage of morphologically abnormal chondrocytes in allograft and fresh cartilage.

STUDY DESIGN

Controlled laboratory study.

METHODS

Fluorescence viability staining, chondrocyte yield, and chondrocyte characteristics were studied in 8 commercial osteochondral allografts (7 hemicondyles, 1 talus) and 4 freshly harvested cartilage samples from an adult distal femur (age, 46 years), from an adult talus (age, 51 years), and from an adult tibial plateau (age, 29 years) and from a juvenile distal tibia (age, 9 years). Selected fresh and allograft specimens were repeatedly frozen and thawed to deliberately kill chondrocytes by membrane disruption. The findings were analyzed to determine if allograft and fresh cartilage were significantly different with respect to each of the 3 different outcome measures.

RESULTS

Although fluorescent staining indicated that approximately 75% of chondrocytes were viable (calcein AM-labeled) in allograft cartilage, counterstaining with 4,'6-diamidino-2-phenylindole showed that fewer than 30% contained identifiable nuclei. In contrast, 100% of cells labeled as viable contained nuclei in fresh cartilage. Killing chondrocytes by freeze-thawing before staining did not diminish calcein AM staining in allograft cartilage but caused a significant reduction in fresh cartilage. The average yield of chondrocytes from allograft cartilage was less than 200,000/100 mg tissue, significantly lower than in fresh cartilage, which averaged more than 1.5 million/100 mg tissue. The yield from freeze-thawed controls was less than 24,000/100 mg. Cell numbers increased after 7 days of culture in all cases except for chondrocytes from freeze-thawed cartilage, an indication that the isolated cells were viable. Morphologic analysis by transmission electron microscopy revealed significant increases in the numbers of chondrocytes with pyknotic or absent nuclei or with disintegrated plasma membranes in allograft versus fresh cartilage.

CONCLUSION

Conventional fluorescence probes are unreliable for analyzing chondrocyte viability in osteoarticular allografts. Alternative methods for assessment of viability, such as cell culture and ultrastructural imaging, may provide more accurate assessment of viability in allografts.

CLINICAL RELEVANCE

Conventional staining methods that overestimate chondrocyte viability in osteoarticular allografts may mislead investigators attempting to assess the effects of chondrocyte viability on graft stability following implantation. A more reliable means to measure chondrocyte viability will be required to accurately assess these effects.

Influence of surgical preparation on the in-vivo response of osteochondral defects

Cartilage has an extremely poor capacity to heal, which has lead to intensive research into biomaterials and tissue engineering for the purpose of regenerating cartilage in vivo. Many of these techniques have shown great promise in vitro; however, the results do not always carry across to the in-vivo scenario. Healthy cartilage autografts often do not integrate with the adjacent cartilage, suggesting that cartilage is rarely capable of healing even under ideal conditions. It is hypothesized in this study that the surgical creation of defects in cartilage causes significant damage to the adjacent tissues, leading to further degradation of the cartilage and poor outcome for the repair in general. This study compares the healing response of osteochondral defects created with either a punch or a drill in the weight-bearing region of the sheep knee at 4 and 26 weeks following surgery. The use of a drill to create the defect creates a more aggressive inflammatory response at 4 weeks compared with a punch. However, by 26 weeks, defects created with a punch scored higher on the O'Driscoll cartilage grading scale. Tissue damage at the time of surgery plays an important part in the sequence of events for healing of cartilage defects. This knowledge will help to characterize and refine the ovine model for cartilage regeneration and may have an influence on surgical technique and instrumentation for clinical cartilage repair.