Phytate-degrading enzymes in pig nutrition

Effects of Dietary Multi-Carbohydrase and Phytase Complex Supplementation on Nutrient Digestibility, Bone Mineralization and Puberty Onset in Gilts

The study was conducted to determine the effects of multi-carbohydrase and phytase complex (MCPC) supplementation in standard and commercial diets on growth performance, nutrient digestibility, bone mineralization, blood biochemical parameters and puberty onset in gilts. A total of 144 healthy gilts (Duroc × (Landrace × York)) were assigned randomly to four treatments (n = 36), with 10 replicate pens (6 pens, each containing 4 gilts, and 4 pens, each containing 3 gilts). The trial consisted of two phases (phase 1: 70-100 kg; phase 2: 100-140 kg). The commercial diet (COM) had 33% higher calcium (Ca) and phosphorus (P) levels than the standard diet (CON) across all phases. The four treatment diets were as follows: CON (phase 1: 0.56 g/kg Ca and 0.49 g/kg P; phase 2: 0.49 g/kg Ca and 0.45 g/kg P), COM (phase 1: 0.75 g/kg Ca and 0.65 g/kg P; phase 2: 0.65 g/kg Ca and 0.60 g/kg P), CON + MCPC and COM + MCPC, where both the CON and COM diets were supplemented with 100 mg/kg of MCPC, respectively. The commercial diet significantly (p < 0.05) increased the total number of follicles and the number of follicles < 4 mm and tended to reduce (p = 0.07) the age at puberty compared to the standard diet. Besides, MCPC supplementation improved the apparent total-tract digestibility (ATTD) of Ca (p < 0.05), P (p < 0.05) and Ash (p = 0.07) in gilts during phase 1, compared to the basal diets without MCPC supplementation. Additionally, MCPC supplementation significantly elevated serum creatinine (CREA, p < 0.05) concentrations and had a tendency to increase serum Ca (p = 0.07) concentrations in gilts. Specifically, COM + MCPC supplementation significantly increased the osteocalcin (OCN) concentration compared with the COM treatment. Moreover, dietary MCPC supplementation significantly improved the bone strength (p < 0.05) compared to the basal diets without MCPC supplementation. In conclusion, dietary MCPC supplementation increased the ATTD of Ca and P in gilts, while also improving bone strength. This improvement not only extends the reproductive lifespan of sows, but it also allows for reduced supplementation levels of Ca and P in the dietary formula.

The Antinutritional Factors and Technological Processing of Sorghum and Its Application in Pig Production

Sorghum ranks as the fifth largest grain crop globally, and it has similar levels of crude protein and leucine compared to corn, making it a viable substitute for full or partial corn in pig diets. Sorghum is produced around the world like corn, which is the energy source in pig diets. However, sorghum contains antinutritional factors that adversely affect nutrient absorption, energy, and amino acid availability. Additionally, the low content of essential amino acids, such as lysine (Lys) and methionine (Met), limits its feeding value. Consequently, this paper primarily discusses the antinutritional factors present in sorghum and elaborates on methods to enhance the nutritional value of forage sorghum through processes such as crushing, extrusion, and enzymatic hydrolysis. The nutritional value of sorghum could be improved by adding protease, by extrusion, and by reducing the grain size. Furthermore, this paper summarizes the application of sorghum in pig production to enhance the understanding of forage sorghum among feed enterprises and to provide a theoretical reference for the rational formulation of pig diets.

Fungal Phytase Increased Ileal and Total Tract Digestibility of Phosphorus of Cold-Pressed Canola Cake and Canola Meal Diets in Growing Pigs

The co-product canola meal contains little fat and has been used in swine production as a protein source for several decades. More recently, locally produced canola cake has also become available that contains important quantities of residual oil. Both canola co-products contain a considerable quantity of phosphorus (P) with low availability. Phytase supplementation can increase P digestibility in canola meal but its efficacy remains unclear for canola cake containing high residual oil. To explore whether phytase supplementation can increase digestibility of P and other nutrients in canola cake, four diets containing 500 g of locally produced cold-pressed canola cake or canola meal, with or without supplemental phytase (Ronozyme HiPhos; Aspergillus oryzae origin)/kg, were fed to seven pigs (initial body weight; 55.9 ± 3.8 kg) in four 9-day periods following a 4 × 4 Latin square plus a 4 × 3 Youden square. Phytase supplementation increased phytase activity from below the detection limit to reach a minimum of 1000 phytase units/kg in the canola meal and cake diets; respectively. Phytase supplementation increased (p < 0.05) coefficients of ileal and total tract digestibility of P by 60% and 46% for canola meal and 76% and 57% for canola cake, respectively, but did not affect the digestibility of crude protein or gross energy. Ileal or total tract digestibility of P did not differ between the canola cake and canola meal diets in growing-finishing pigs. In conclusion, fungal phytase is effective in increasing the P digestibility of canola cake similar to in canola meal fed to growing-finishing pigs. The similar ileal or total tract digestibility of P in canola meal and cake diets either with or without phytase supplementation indicated that the residual oil in canola cake did not affect P digestion and did not affect the efficacy of phytase in increasing P digestibility.

Effects of phosphorus and calcium depletion on growth performances and bone mineralisation in growing pigs

The use of P nowadays is raising environmental (eutrophication) and sustainability (limited resource) concerns in the swine industry, but initial trials have shown that similar growth performance can be achieved between pigs fed on a requirement basis and those fed using a P depletion-repletion strategy. To optimise the use of dietary P by pigs, three feeding strategies were studied according to a 3-phase feeding programme: (1) C-C-C providing 100% of the P and Ca requirements, (2) C-LNormal-C, providing 100% of the P and Ca requirements in phases 1 and 3 (C) with a depletion in phase 2 with 60% of the P requirements combined with a normal Ca:digP ratio of 2.6 (LNormal), and 3) C-LHigh-C, providing 100% of the P and Ca requirements in phases 1 and 3 (C) with a depletion in phase 2 with 60% of the P requirements combined with a high Ca:digP ratio of 3.3 (LHigh). Bone mineral content (BMC) and BW were measured at the beginning and end of each phase. BMC gain, average daily gain, average daily feed intake and feed efficiency were calculated for each phase. In phase 1, all pigs received the same diet. At the end of phase 2, the C-LNormal-C and C-LHigh-C groups had similar BMCs compared to the C-C-C group. Finally, at the end of phase 3, the BMC gain was numerically higher in the C-LNormal-C group than in the C-C-C group (25.4 vs 18.7 g/d, P = 0.10). Although depletion did not cause a decrease in BMC in the C-LNormal-C and C-LHigh-C groups (versus C-C-C), it did result in better P use during repletion. These results demonstrate the value of a depletion-repletion strategy to reduce P intake and excretion without compromising the final performance.

Dosing of Bacterial Phytase (EC 3.1.3.26) in Laying Hens' Diets

Despite the acknowledged advancements in the utilization of phytase dosing, limited research has been conducted on commercial laying hens. To assess the effectiveness of doses of exogenous phytase, a total of 320 laying hens aged between 44 and 64 weeks were utilized. These hens were divided into five treatments, which were then distributed using a completely randomized design with eight replicates, each containing eight birds. The treatments consisted of phytase supplementation levels of 0, 500, 1000, 1500, and 3000 FTU/kg. Quadratic regression equations were utilized to determine the maximum and minimum values for the levels of phytase supplementation. A significant difference was observed in the levels of phytase supplementation, where a quadratic model was fitted to various variables including egg weight (g), egg mass (g/bird/day), feed conversion per egg mass (g/g), yolk concentration (%), albumen concentration (%), shell thickness (μm), shell strength (kgf), specific gravity, and yolk color. Further, an increased supplementation improved the digestive tract of the hens, thereby providing a better villus-crypt ratio. Considering the advantageous effects of phytase dosing, it is recommended to supplement corn and soybean meal-based diets with 1500 FTU/kg of bacterial phytase for laying hens during the 44- to 64-week production period.

Modern feeding strategies for breeding boars

Feeding of breeding boars in artificial insemination (AI) centers is critical to maintaining and improving breeding quality and performance in agriculture. Modern feeding strategies for AI boars are aiming towards maximizing their lifetime semen dose output. Given the high growth potential of modern swine genetics, AI boars should be controlled in their daily gain to reduce stress factors for the locomotion system, final body weights, and improve their survivability but also the ease of handling boars. The feeding program should be designed in such a way that young boars (up to 7 months of age) are limited to a daily gain of 400-600 g. Mature boars should be fed towards a body condition score of '2'. Aside from energy intake, protein sources should provide 0.62% SID lysine. As far as minerals and vitamins, special attention should be given to Calcium and Phosphorus as they play a crucial role in bone mineralization. A standardized total tract digestible Calcium-Phosphorus ratio between 1.75:1 and 1.82:1 seems to be most favorable. While certain nutritional requirements are needed to enable the production of ejaculates eligible for AI, considerations should be given to the mitigation of risk factors like mycotoxins, herbicides, and pesticides. Most feed additives and supplements lack consistency in their effect across studies evaluated in this review.

Effects of enzyme supplementation on growth performance, digestibility of phosphorus, femur parameters and fecal microbiota in growing pigs fed different types of diets

A 42-days study was conducted to evaluate the effects of different dietary types (corn-or wheat-soybean meal-based diet) and phytase (Phy) or a multi-carbohydrase and phytase complex (MCPC) supplementation on growth performance, digestibility of phosphorus (P), intestinal transporter gene expression, plasma indexes, bone parameters, and fecal microbiota in growing pigs. Seventy-two barrows (average initial body weight of 24.70 ± 0.09 kg) with a 2 × 3 factorial arrangement of treatments and main effects of diet type (corn-or wheat-soybean meal-based-diets) and enzyme supplementation (without, with Phy or with MCPC). Each group was designed with 6 replicate pens. The MCPC increased (p < 0.05) average daily gain (ADG) and final body weight (BW). A significant interaction (p = 0.01) was observed between diet type and enzyme supplementation on apparent total tract digestibility (ATTD) of P. The ATTD of P was higher (p < 0.05) in wheat soybean meal-based diets compared to corn-soybean meal-based diets. Compared with the corn-soybean meal-based diet, the relative expression of SLC34A2 and VDR genes in the ileum and SLC34A3 in jejunum of growing pigs fed the wheat-soybean meal based diet was lower (p < 0.05). The MCPC significantly reduced (p < 0.05) the relative expression of TRPV5 and CALB1 genes in the ileum and increased the expression of CALB1 in the duodenum compared to control diet. The phytase increased (p < 0.05) the relative expression of SLC34A1 gene in the duodenum in comparison to control diet and MCPC-supplemented diet. The Ca and P contents in plasma from pigs fed corn-soybean meal-based diet were higher (p < 0.05) than those from pigs fed wheat-soybean meal-based diet, and the parathyroid hormone (PTH) and calcitonin (CT) concentrations were lower (p < 0.05) than those fed wheat-soybean meal-based diet. The content of Ca and P in the femur and the bone strength of pigs in the corn-soybean meal group were significantly higher (p < 0.05) than those in the wheat-soybean meal groups. The phytase increased (p < 0.05) the Ca and P content and bone strength of the femur. Additionally, diet type and both enzymes significantly improved fecal microbial diversity and composition. Taken together, diet type and exogenous enzymes supplementation could differently influence the growth performance, utilization of phosphorus, intestinal transporter gene expression, bone mineralization and microbial diversity and composition in growing pigs.

Improved Thermal Stability of a Novel Acidophilic Phytase

Phytase increases the availability of phosphate and trace elements by hydrolyzing the phosphomonoester bond in phytate present in animal feed. It is also an important enzyme from an environmental perspective because it not only promotes the growth of livestocks but also prevents phosphorus contamination released into the environment. Here we present a novel phytase derived from Turicimonas muris, TmPhy, which has distinctive structure and properties compared to other previously known phytases. TmPhy gene expressed in the Pichia system was confirmed to be 41 kDa in size and was used in purified form to evaluate optimal conditions for maximum activity. TmPhy has a dual optimum pH at pH3 and pH6.8 and exhibited the highest activity at 70°C. However, the heat tolerance of the wildtype was not satisfactory for feed application. Therefore, random mutation, disulfide bond introduction, and N-terminal mutation were performed to improve the thermostability of the TmPhy. Random mutation resulted in TmPhyM with about 45% improvement in stability at 60°C. Through further improvements, a total of three mutants were screened and their heat tolerance was evaluated. As a result, we obtained TmPhyMD1 with 46.5% residual activity, TmPhyMD2 with 74.1%, and TmPhyMD3 with 66.8% at 80°C heat treatment without significant loss of or with increased activity.

Basis for the diversity and extent in loss of digestible nutrients created by dietary phytin: Emphasis on fowl and swine

Phytin is the Ca2+-Mg2+-K+ salt of phytic acid that is created and deposited in the aleurone layer and/or germ of grains and legumes. Its high presence in feedstuffs for fowl and swine diets results in it being a universal and significant impediment to optimum performance. Phytin impairs gastrointestinal recovery of a wide array of nutrients, the effect varying with the nutrient concerned. On exposure to low pH during gastric digestion, phytin dissociates into phytic acid and solubilized Ca2+. Even at low gastric pH, phytic acid is negatively charged which forms the basis of its anti-nutritive behavior. Pepsinogen has extensive basic amino acids on its activation peptide that are presented as cations at low pH which are targeted by pepsin for activation. Partially crystalized Ca2+ near the enzyme's active site further stabilizes its newly formed structure. Thus, phytic acid appears to interfere with gastric digestion by several mechanisms; interfering with pepsinogen activation by binding to the polypeptide's basic amino acids; coordinating free Ca2+, destabilizing pepsin; binding some dietary proteins directly, further compromising gastric proteolysis. Upon digesta attaining neutrality in the duodenum, Ca2+ and other cations re-bind with accessible anions, phytic acid being a significant contender. Phytate not only binds free cations but can also strip them from enzymes (e.g. Ca2+, Zn2+) which reduces their structural resistance to autolysis and ability as co-factors (e.g. Zn2+) to increase enzyme activity. Goblet cells initially employ Ca2+ as an electronic shield between mucin layers enabling granule formation and cell storage. After mucin granule release, Ca2+ is progressively displaced by Na+ to free the viscous mucins enabling its translocation. Mucin entangles with the glycocalyx of adjacent enterocytes thereby constructing the unstirred water layer (USWL). Excessive removal of Ca2+ from mucin by phytic acid increases its fluidity facilitating its loss from the USWL with its associated Na+. This partly explains increased mucin and Na+ losses noted with high phytate diets. This review suggests that phytic acid binding of Ca2+ and less so Zn2+ is the basis for the diversity in nutrient losses encountered and that such losses are in proportion to dietary phytate content.

Carbohydrases and Phytase in Poultry and Pig Nutrition: A Review beyond the Nutrients and Energy Matrix

This review aimed to clarify the mechanisms through which exogenous enzymes (carbohydrases and phytase) influence intestinal health, as well as their effects on the nutrients and energy matrix in diets fed to poultry and pigs reared under sanitary challenging conditions. Enzyme supplementation can positively affect intestinal microbiota, immune system, and enhance antioxidant status. Although enzymes have been shown to save energy and nutrients, their responses under sanitary challenging conditions are poorly documented. Immune system activation alters nutrient partitioning, which can affect the matrix values for exogenous enzymes on commercial farms. Notably, the carbohydrases and phytase supplementation under sanitary challenging conditions align with energy and nutritional valorization matrices. Studies conducted under commercial conditions have shown that matrices containing carbohydrases and phytase can maintain growth performance and health in poultry and pigs. However, these studies have predominantly focused on assessing a single level of reduction in energy and/or available phosphorus and total calcium, limiting our ability to quantify potential energy and nutrient savings in the diet. Future research should delve deeper into determining the extent of energy and nutrient savings and understanding the effects of alone or blended enzymes supplementation to achieve more specific insights.

Phosphorus equivalency of exogenous phytase relative to phosphorus in monosodium phosphate in broiler chickens

The objective of this study was to estimate phosphorus (P) equivalency of exogenous phytase relative to P from monosodium phosphate (MSP) in broiler chickens. To attain this objective, the impact of dietary MSP or exogenous phytase on growth performance, ileal digestibility of P, and bone characteristics in broiler chickens was assessed. Six experimental diets consisting of a P-deficient basal diet based on corn and soybean meal, basal diet plus 0.9 or 1.8 g/kg of inorganic P from MSP, and basal diet plus 500, 1,000, or 2,000 FYT/kg of exogenous phytase. Calcium to P ratio in all diets was maintained at 1.5:1. A total of 576 male broiler chickens (Cobb 500; initial BW = 190 ± 17 g) on d 8 post hatching were allotted to the 6 dietary treatments in a randomized complete block design using BW as a blocking factor. Each dietary treatment contained 8 replicate cages with 12 birds per cage. On d 11 post hatching, 7 birds from each cage were euthanized by CO2 asphyxiation and dissected for the collection of ileal digesta. On d 18, ileal digesta were also collected from the remaining 5 birds in each cage. The left femur and tibia were collected from the bird with the median BW on d 11 and 18 from each cage, and analyzed for bone breaking strength and bone ash. Weight gain and gain-to-feed ratio linearly or quadratically increased (P < 0.05) in every period as the inclusion rate of MSP or phytase increased. Ileal digestibility of P linearly increased (P < 0.05) on d 11 with increasing MSP, but there was no significant effect on d 18. Increasing phytase concentration linearly increased (P < 0.05) ileal digestibility of P on d 11 and 18. Increasing dietary MSP or phytase linearly increased ileal digestible P concentration in diets (P < 0.05). Bone breaking strength and bone ash linearly or quadratically increased (P < 0.05) with increasing inclusion rate of MSP or phytase on d 11 and 18. The equivalency of 1,000 FYT/kg of exogenous phytase based on dietary ileal digestible P concentration was 1.5 and 1.2 g/kg of inorganic P in diets on d 11 and 18, respectively. The current results showed that the supplementation of MSP or exogenous phytase can increase growth performance, ileal P digestibility, bone breaking strength, and bone ash in young broiler chickens.

Determining the phosphorus release curve for Sunphase HT phytase in nursery pig diets

A total of 280 pigs (DNA 241 × 600, initially 10.4 ± 0.24 kg) were used in a 21-d study to determine the available P (aP) release curve for Sunphase HT phytase (Wuhan Sunhy Biology Co., Ltd., Wuhan, P.R. China) when fed diets with a high phytate concentration. On day 21 post-weaning, considered day 0 of the study, pigs were blocked by average pen body weight (BW) and randomly allotted to 1 of 7 dietary treatments with 5 pigs per pen and 8 pens per treatment. Dietary treatments were derived from a single basal diet, and ingredients including phytase, monocalcium P, limestone, and sand were added to create the treatment diets. Treatments included three diets with increasing (0.11%, 0.19%, and 0.27%) aP from monocalcium P, or four diets with increasing phytase (250, 500, 1,000, or 2,000 phytase unit (FTU)/kg) added to the diet formulated to 0.11% aP. All diets were corn-soybean meal-canola meal-based and were formulated to contain 1.24% SID Lys, a 1.10:1 total calcium-to-phosphorus ratio, and a calculated 0.32% phytate P. Prior to the beginning of the study, all pigs were fed a diet containing 0.11% aP from days 18 to 21 post-weaning. At the conclusion of the study, 1 pig, closest to the mean weight of each pen, was euthanized, and the right fibula, 10th rib, and metacarpal were collected to determine bone ash and density. After cleaning, bones were submerged in ultra-purified water under a vacuum for 4 h and then weighed to calculate the density (Archimedes principle). For bone ash, bones were processed using the non-defatted method. From days 0 to 21, increasing aP from monocalcium P increased (linear, P ≤ 0.014) average daily gain (ADG), gain-to-feed (G:F), and final BW. Pigs fed increasing phytase had increased (linear, P ≤ 0.045) ADG, final BW, and plasma inositol concentration as well as improved (quadratic, P = 0.023) G:F. For bone characteristics, pigs fed increasing aP from inorganic P had a linear improvement (P ≤ 0.019) in fibula bone ash weight and percentage bone ash, rib bone ash weight and bone density, and all metacarpal bone properties, with a quadratic response (P ≤ 0.030) for fibula bone density and rib percentage ash. Additionally, pigs fed increasing phytase had increased (P < 0.05) bone ash weight, percentage bone ash, and bone density in either a linear or quadratic fashion depending on the bone analyzed. The available P release curve generated for Sunphase HT phytase for percentage bone ash combining values from the right fibula, 10th rib, and metacarpal is aP release, % = (0.360 × FTU) ÷ (2,330.250 + FTU).

Determining the phosphorus release curve for Smizyme TS G5 2,500 phytase from 500 to 2,500 FTU/kg in nursery pig diets

A total of 320 pigs (Line 241 × 600, DNA, Columbus, NE; initially 11.9 ± 0.22 kg) were used in a 21-d growth study to determine the available P (aP) release curve for Smizyme TS G5 2,500 (Barentz, Woodbury, MN). At approximately 19 d of age, pigs were weaned, randomly allotted to pens, and fed common starter diets. Pigs were blocked by average pen body weight (BW) and randomly allotted to one of eight dietary treatments on day 18 postweaning, considered day 0 of the study. Dietary treatments were derived from a single basal diet and ingredients including phytase, monocalcium P, limestone, and sand were added to create the treatment diets. Treatments included three diets containing increasing inorganic P from monocalcium P (0.11%, 0.20%, and 0.28% aP), or five diets with increasing phytase (500, 1,000, 1,500, 2,000, or 2,500 FTU/kg) added to the diet containing 0.11% aP. All diets were corn-soybean meal-canola meal-based and were formulated to contain 1.24% standardized ileal digestibility Lys, 0.30% phytate P, and an analyzed Ca:P ratio of 1.10:1. Prior to the beginning of the study, all pigs were fed a diet containing 0.11% aP for a 2-d period (days 16 to 18 postweaning). At the conclusion of the study, one pig, closest to the mean weight of each pen, was euthanized and the right fibula, rib, and metacarpal were collected to determine bone ash, density, and total bone P. Bones were weighed while suspended in a vessel of water and the weights used to calculate bone density (Archimedes' principle). For bone ash, bones were processed using the non-defatted method. For the overall experimental period, pigs fed increasing inorganic P had increased (quadratic, P ≤ 0.033) average daily gain (ADG), average daily feed intake (ADFI), and final BW and a tendency for increased (quadratic, P ≤ 0.090) gain:feed ratio (G:F). Pigs fed increasing phytase had increased (quadratic, P ≤ 0.004) ADG, G:F, and final BW and increased (linear, P = 0.019) ADFI. For fibula, rib, and metacarpal characteristics, pigs fed increasing aP from inorganic P had increased (linear, P < 0.001) bone ash weight, percentage bone ash, bone density, and bone P concentration. Additionally, pigs fed increasing phytase had increased (linear or quadratic, P < 0.05) bone ash weight, percentage bone ash, bone density, and bone P. TheaP release curve generated for Smizyme TS G5 2,500 for percentage bone ash using data generated from all three bones is aP = (0.228 × FTU/kg) ÷ (998.065 + FTU/kg).

Stepwise Reduction of Dietary Phosphorus in Diets for Piglets and Fattening Pigs of Different Genetic Origin Housed under Various Station Environments-A Ringtest

The reduction of emissions of nutrients from livestock is one of the main topics in areas with intensive animal husbandry. In order to minimize the loss of nutrients into the environment, it is common practice to feed animals as close as possible to metabolic demands. For phosphorus (P), there are various studies for swine and poultry, which showed that a reduction of dietary P levels is possible, if a sufficient level of phytase is added to the diet. The supplementation of a sufficient dosage of phytase to plant-based diets leads to an increase in digestible phosphorus (dP) upon the hydrolisation of phytate (InsP6) to P and lower inositol-phosphates. However, most of these studies were conducted under standardized experimental conditions. In terms of transfer to practical conditions with varying housing, management and genetics, there are concerns that have led to speculation by farmers and veterinarians whether the reduction of dietary P could negatively affect bone health and therefore animal welfare. In order to test whether a reduction of dietary P according to the recommendations for dP of the German Society of Nutrition Physiology (GfE) affects bone mineralization and growth performance, a ringtest was conducted where piglets and fattening pigs were fed at four experimental stations with three centrally produced diets from the same batches. The diets contained three different levels of P and were designed to reflect practical diets. The P level decreased from diet one to three, respectively. Diets one and two were calculated to contain P levels, which are typically fed under practical conditions in Germany. The third diet was optimized to fulfill the requirements of dP by the GfE. The animals were fed in two phases as post-weaning piglets (8-15 kg and 15-28 kg BW) followed by a three-phase fattening regime (28-60 kg, 60-90 kg and 90-120 kg BW). Individual body weight and feed consumption (pen basis or individually, depending on the experimental station) were recorded for every feeding phase. At the end of the experiment, animals were slaughtered. At one experimental station, additional blood serum, metatarsi of the left leg and kidney tissue were sampled to analyze serum P concentration, expression of P transporters in the kidney and bone traits. In two experimental stations, femur and vertebra were sampled, and bone ash was determined. Overall, animal performance and all other traits analyzed did not differ between the treatment with the highest and the treatment with the lowest dietary P concentration. The results demonstrate that it is possible to decrease dietary P according to the recommendations for dP of the GfE, without impairing the animals' performance or mineral homeostasis and health. A reduction of total P by reducing mineral P to the levels of the present study require the supplementation of phytase to achieve sufficient concentrations of dP.

Efficacy of a bacterial 6-phytase supplemented beyond traditional dose levels on jejunal mucosa-associated microbiota, ileal nutrient digestibility, bone parameters, and intestinal health, and growth performance of nursery pigs

This study aimed to determine the efficacy of a bacterial 6-phytase (Buttiauxella spp.) supplemented beyond traditional dose levels based on jejunal mucosa-associated microbiota, apparent ileal digestibility (AID), intestinal health and bone parameters, and growth performance of nursery pigs. Seventy-two weaned pigs (36 barrows and 36 gilts at 21 d of age with 5.8 ± 0.5 kg BW) were allotted to six treatments based on randomized complete block design with sex and initial BW as blocks and fed in three dietary phases (phase 1 for 14 d, phase 2 for 10 d, and phase 3 for 14 d). The treatments included a negative control (NC) diet without phytase formulated meeting nutrient requirements by NRC and the other five treatments were deficient in calcium (Ca) and phosphorus (P) by 0.12% with increasing levels of a bacterial 6-phytase (0, 500, 1,000, 2,000, and 5,000 FTU/kg feed). Titanium dioxide (0.4%) was added to phase 3 diets as an indigestible marker to measure AID of nutrients. On day 45, all pigs were euthanized to collect ileal digesta to measure AID, the third metacarpus to measure bone parameters, and jejunal mucosa to evaluate intestinal health and microbiota. Data were analyzed using the MIXED procedure for polynomial contrasts and the NLMIXED procedure for broken line analysis using the SAS 9.4. Broken line analysis demonstrated that 948 FTU/kg feed increased (P < 0.05) the ADG and the bone P content. Increasing phytase supplementation increased (linear, P < 0.05) AID of CP, bone P, and ash content. Increasing phytase supplementation reduced (P < 0.05) the fecal score during phases 2 and 3. Broken line analysis demonstrated that 1,889 FTU/kg feed increased (P < 0.05) bone breaking strength. Increasing phytase supplementation (PC vs. Phy) increased (P < 0.05) AID of ether extract (EE) and P. The supplementation of phytase at 2,000 FTU/kg feed tended (P = 0.087) to reduce the relative abundance of Prevotellaceae. In conclusion, the supplementation of a bacterial 6-phytase beyond traditional dose levels improved bone breaking strength, bone ash, and P content, AID of CP, EE, and P, and growth performance of nursery pigs with reduced relative abundance of Bacteroidetes specifically Prevotellaceae in the jejunal mucosa. Supplementation of a bacterial 6-phytase between 1,000 and 2,000 FTU/kg feed provided benefits associated with growth performance and bone parameters of nursery pigs.

Short communication: commercial diets for pigs in the United States contain more calcium than formulated

Data from Europe indicate that commercial diets for pigs and poultry contain significantly more Ca than formulated. Therefore, a survey of commercial pig diets used in the United States was conducted to test the hypothesis that the analyzed concentrations of total Ca and total P in commercial pig diets in the United States are not greater than formulated values. A total of 103 diet samples from the commercial swine industry in the United States were collected between 2019 and 2021. Diet samples were provided by feed mills, feed companies, or swine farms located in major swine-producing states in the United States including NC, TN, IA, IN, KS, MN, NE, and IL. Diets were formulated for nursery pigs, growing-finishing pigs, or sows. Each company provided formulated values for total Ca and P in all samples. Samples were sent to the University of Illinois where they were ground and analyzed for Ca and P by inductively coupled plasma-optical emission spectrometry. The formulated values for Ca and P were regressed against analyzed values, and the intercept was considered the estimated under- or over-supply of each mineral. Results indicated that there was an average of 0.19 percentage units more Ca (model; P < 0.001) in the diets than formulated, whereas, for total P, the average oversupply was only 0.06 percentage units (model; P < 0.001). In conclusion, diets used in the U.S. swine industry contain more total Ca than formulated, whereas total P is close to formulated values, which indicates that greater importance is given to P than to Ca in formulation. However, the current data indicate that more attention should be given to the actual concentration of Ca in all Ca-containing feed ingredients to avoid Ca oversupply and its detrimental effect on P digestibility and growth performance of pigs fed diets that do not contain excess P.

Evaluation of a novel phytase derived from Citrobacter braakii and expressed in Aspergillis oryzae on growth performance and bone mineralization indicators in nursery pigs

A total of 297 pigs (DNA 241 × 600; initially 8.64 ± 0.181 kg) were used in a 21-d trial to determine the efficacy of a novel phytase derived from Citrobacter braakii and expressed in Aspergillis oryzae (HiPhorius; DSM Nutritional Products, Animal Nutrition & Health, Parsippany, NJ) on pig growth and bone mineralization indicators. Pens of pigs were assigned to 1 of 5 dietary treatments in a randomized complete block design with 5 pigs per pen and 12 pens per treatment. The trial was initiated 14-d after weaning. The first three treatments were formulated to contain 0.09% aP; without added phytase (control), or the control diet with 600 or 1,000 FYT/kg of added phytase (considering a release of 0.15% or 0.18% aP, respectively). The remaining two treatments were formulated to contain 0.27% aP, one without added phytase and the other with 1,000 FYT/kg. From days 0 to 21, pigs fed increasing phytase in diets containing 0.09% aP had increased (linear, P ≤ 0.002) ADG, ADFI, and G:F, but added phytase in the 0.27% aP diet did not impact growth performance. Increasing phytase in diets containing 0.09% aP increased percentage bone ash in metacarpals and 10th ribs (linear, P < 0.001; quadratic, P = 0.004, respectively), and increased grams of Ca and P in metacarpals, 10th ribs, and fibulas (linear, P ≤ 0.027). Adding 1,000 FYT/kg phytase in diets with 0.27% aP increased (P ≤ 0.05) percentage bone ash and grams of Ca and P in fibulas and 10th ribs compared with pigs fed 0.27% aP without added phytase. Increasing aP from 0.09% to 0.27% in diets without added phytase increased (P < 0.001) ADG, ADFI, and G:F. Increasing aP from 0.09% to 0.27% in diets without added phytase increased bone density (P ≤ 0.002) in fibulas and metacarpals, percentage bone ash in all bones (P ≤ 0.074), and increased (P < 0.05) grams of Ca and P in fibulas and 10th ribs. Pigs fed diets containing 0.09 or 0.27% aP, both with 1,000 FYT added phytase, had increased (P < 0.05) bone density in fibulas and metacarpals, percentage bone ash in all bones, and increased grams of Ca and P in fibulas and 10th ribs. For growth performance (average of ADG and G:F), aP release was calculated to be 0.170% for 600 FYT/kg and 0.206% for 1,000 FYT/kg. For the average of all bone measurements (average of 3 bones for both bone density and percentage bone ash), aP release was calculated to be 0.120% and 0.125% for 600 and 1,000 FYT/kg, respectively.

Isolation and characterization of a novel hydrolase-producing probiotic Bacillus licheniformis and its application in the fermentation of soybean meal

Soybean meal (SBM) is one of the most important sources of plant-based protein in the livestock and poultry industry. However, SBM contains anti-nutritional factors (ANFs) such as glycinin, β-conglycinin, trypsin inhibitor and phytic acid that can damage the intestinal health of animals, inevitably reducing growth performance. Fermentation using microorganisms with probiotic potential is a viable strategy to reduce ANFs and enhance the nutritional value of SBM. In this study, a novel potential probiotic Bacillus licheniformis (B4) with phytase, protease, cellulase and xylanase activity was isolated from camel feces. The ability of B4 to tolerate different pH, bile salts concentrations and temperatures were tested using metabolic activity assay. It was found that B4 can survive at pH 3.0, or 1.0% bile salts for 5 h, and displayed high proliferative activity when cultured at 50°C. Furthermore, B4 was capable of degrading glycinin, β-conglycinin and trypsin inhibitor which in turn resulted in significant increases of the degree of protein hydrolysis from 15.9% to 25.5% (p < 0.01) and crude protein from 44.8% to 54.3% (p < 0.001). After fermentation with B4 for 24 h, phytic acid in SBM was reduced by 73.3% (p < 0.001), the neutral detergent fiber (NDF) and the acid detergent fiber of the fermented SBM were significantly decreased by 38.40% (p < 0.001) and 30.20% (p < 0.05), compared to the unfermented SBM sample. Our results suggested that the effect of solid-state fermented SBM using this novel B. licheniformis (B4) strain, could significantly reduce phytic acid concentrations whilst improving the nutritional value of SBM, presenting itself as a promising alternative to phytase additives.

Ileal and total tract digestibility of energy and nutrients in pig diets supplemented with a novel consensus bacterial 6-phytase variant

An experiment was conducted to test the hypothesis that increasing levels of a novel phytase increases the apparent ileal digestibility (AID) and apparent total tract digestibility (ATTD) of nutrients in diets fed to young pigs. A negative control (NC) diet based on corn, soybean meal, and canola meal that contained approximately 0.83% phytate (i.e., 0.23% phytate-bound P) was formulated to be deficient in Ca, P, and standardized ileal digestible amino acids (AA). Five additional diets were formulated by adding 250, 500, 1,000, 2,000, or 4,000 phytase units/kg of the novel phytase to the NC diets. Eighteen ileal-cannulated pigs (17.81 ± 1.71 kg) were allotted to a 6 × 3 incomplete Latin square design with six diets and three 11-day periods. There were three pigs per diet in each period; therefore, there were nine replicate pigs per diet. The initial 5 d of each period was considered an adaptation period to the diet. For each period, fecal samples were collected via anal stimulation on days 6, 7, 8, and 9, whereas ileal digesta were collected on days 10 and 11 using standard procedures. Results indicated that the AID of crude protein, indispensable AA, and dispensable AA was increased (quadratic, P < 0.05) as the concentration of microbial phytase increased in the diets. Dietary inclusion of the novel phytase at 1,000 or 2,000 FTU/kg increased the AID of total AA from 73.7% to 79.8%. Increasing levels of microbial phytase increased (quadratic, P < 0.05) the AID of dry matter and minerals (i.e., Ca, P, K, Mg, Cu) in the diets. Likewise, a linear increase (P < 0.05) in the AID of ash and Na was observed as the inclusion level of phytase increased in the diets. Increasing levels of microbial phytase increased (linear, P < 0.01) the AID of gross energy (GE) and starch in the diets. A quadratic (P < 0.05) increase in the ATTD of ash, Ca, P, K, and Cu in experimental diets was observed as the concentration of microbial phytase increased in the diets. The ATTD of Mg and GE also increased (linear; P < 0.05) as concentration of dietary phytase increased. In conclusion, the novel microbial phytase used in this experiment was effective in increasing the AID of dry matter, GE, starch, minerals, and AA, as well as the ATTD of gross energy and minerals in diets formulated to be deficient in Ca, P, and AA.

Environmental impacts of eco-nutrition swine feeding programs in spatially explicit geographic regions of the United States

This study was conducted to determine greenhouse gas (GHG) emissions, water consumption, land use, as well as nitrogen (N), phosphorus (P), and carbon (C) balance of five diet formulation strategies and feeding programs for growing-finishing pigs (25-130 kg body weight) in the three spatially explicit geographic regions where the majority of U.S. pork production occurs. Feeding programs evaluated consisted of 1) standard corn-soybean meal (CSBM) diets, 2) CSBM containing 15% corn distillers dried grains with solubles (DDGS), 3) CSBM with 8.6% thermally processed supermarket food waste (FW), 4) low crude protein CSBM diets supplemented with synthetic amino acids (SAA), and 5) CSBM with phytase enzyme (PHY) added at 600 FTU (phytase units)/kg of diet. An attributional Life Cycle Assessment approach using a highly specialized, spatially explicit Food System Supply-Chain Sustainability (FoodS3) model was used to quantify GHG emissions, water consumption, and land use of corn, soybean meal, and DDGS based on county level sourcing. The DDGS, FW, and SAA feeding programs had less estimated N and P intake and excretion than CSBM, and the PHY feeding program provided the greatest reduction in P excretion. The FW feeding program had the least overall GHG emissions (319.9 vs. 324.6 to 354.1 kg CO2 equiv./market hog), land use (331.5 vs. 346.5 to 385.2 m2/market hog), and water consumption (7.64 vs. 7.70 to 8.30 m3/market hog) among the alternatives. The DDGS feeding program had the greatest GHG emissions (354.1 kg CO2 equiv./market hog) among all programs but had less impacts on water consumption (7.70 m3) and land use (346.5 m2) per market hog than CSBM and PHY. The SAA feeding program provided a 6.5-7.4% reduction in land use impacts compared with CSBM and PHY, respectively. Regardless of feeding program, the Midwest had the least contributions to GHG emissions and land use attributed to feed and manure among regions. Water consumption per market hog associated with feeding programs was much greater in the Southwest (59.66-63.58 m3) than in the Midwest (4.45-4.88 m3) and Mid-Atlantic (1.85-2.14 m3) regions. Results show that diet composition and U.S. geographic region significantly affect GHG emissions, water consumption, and land use of pork production systems, and the potential use of thermally processed supermarket food waste at relatively low diet inclusion rates (<10%) can reduce environmental impacts compared with other common feeding strategies.

Nutritional and Functional Roles of Phytase and Xylanase Enhancing the Intestinal Health and Growth of Nursery Pigs and Broiler Chickens

This review paper discussed the nutritional and functional roles of phytase and xylanase enhancing the intestinal and growth of nursery pigs and broiler chickens. There are different feed enzymes that are currently supplemented to feeds for nursery pigs and broiler chickens. Phytase and xylanase have been extensively studied showing consistent results especially related to enhancement of nutrient digestibility and growth performance of nursery pigs and broiler chickens. Findings from recent studies raise the hypothesis that phytase and xylanase could play functional roles beyond increasing nutrient digestibility, but also enhancing the intestinal health and positively modulating the intestinal microbiota of nursery pigs and broiler chickens. In conclusion, the supplementation of phytase and xylanase for nursery pigs and broiler chickens reaffirmed the benefits related to enhancement of nutrient digestibility and growth performance, whilst also playing functional roles benefiting the intestinal microbiota and reducing the intestinal oxidative damages. As a result, it could contribute to a reduction in the feed costs by allowing the use of a wider range of feedstuffs without compromising the optimal performance of the animals, as well as the environmental concerns associated with a poor hydrolysis of antinutritional factors present in the diets for swine and poultry.

Apparent digestibility of energy and nutrients and efficiency of microbial phytase is influenced by body weight of pigs

An experiment was conducted to test the hypothesis that regardless of pig body weight (BW), increasing dietary phytase results in increased phytate degradation and improved digestibility of minerals, amino acids (AA), and gross energy (GE). Eighteen pigs were equipped with a T-cannula in the distal ileum and allotted to a triplicated 6 × 3 Youden square design with six diets and three collection periods of 7 d, for a total of nine replicate pigs per diet. This design was repeated four times to simulate four production phases, and there was a 7-d resting period before each collection phase started (BW at start of collections: 29.3, 53.6, 85.1, and 114.4 kg for phases 1, 2, 3, and 4, respectively). Six corn-soybean meal diets were formulated by including 0, 250, 500, 1,000, 2,000, or 4,000 phytase units/kg feed (FTU). The six diets were used throughout the experiment. Samples of feces and ileal digesta were collected in each period. Results indicated that regardless of pig BW, increasing inclusion of phytase increased (quadratic; P < 0.05) apparent ileal digestibility (AID) of crude protein (CP) and most AA, increased apparent total tract digestibility (ATTD) of Ca, P, K, Mg (linear and quadratic; P < 0.05), and Na (linear; P < 0.05), but decreased (linear and quadratic; P < 0.05) AID and ATTD of GE. In all phases, ileal concentrations of inositol phosphate (IP) 6, IP5, IP4, and IP3 decreased (linear and quadratic; P < 0.05), whereas ileal inositol increased (linear and quadratic; P < 0.05) with increasing dietary phytase. However, as pig BW increased, AID of GE, CP, and AA increased (linear, P < 0.05), and the AID of a few AA (Met, Phe, Thr, Trp, Ala, Asp, Gly, and Ser) also increased quadratically (P < 0.05). The ATTD of GE, K, and Mg increased (linear and quadratic; P < 0.05), but ATTD of Ca and Na (linear; P < 0.05) and of P (linear and quadratic; P < 0.05) decreased as pig BW increased. Ileal IP6 and IP3 (linear and quadratic; P < 0.05) and ileal IP5 and IP4 (linear; P < 0.05) increased, whereas ileal inositol decreased (linear; P < 0.05) as pig BW increased. In conclusion, regardless of pig BW, increasing dietary phytase increased phytate degradation and inositol release in the small intestine, and consequently increased mineral and AA digestibility. Older pigs have reduced Ca, P, and Na digestibility, but increased K, Mg, AA, and GE digestibility compared with younger pigs. The efficiency of dietary phytase to degrade phytate appears to decrease as pigs get older.

Microbial phytase reduces basal endogenous loss of calcium in pigs fed diets containing phytate phosphorus at commercial levels

The objective of this experiment was to test the hypothesis that increasing dietary phytase reduces basal endogenous loss of Ca and increases P balance in pigs. Seventy barrows (initial body weight: 17.66 ± 1.69 kg) were allotted to seven Ca-free diets using a randomized complete block design with two blocks and five pigs per diet in each block. All diets were based on corn, potato protein concentrate, and full-fat rice bran. A positive control (PC) diet was formulated to contain P at the requirement for standardized total tract digestible (STTD) P by 11 to 25 kg pigs. Six negative control (NC) diets were formulated by reducing the provision of digestible P by 0.15% and adding 0, 250, 500, 1,000, 2,000, or 4,000 phytase units/kg diet. Pigs were housed individually in metabolism crates that allowed for total, but separate, collection of urine and feces. Daily feed allowance was 3.0 times the maintenance requirement for metabolizable energy and was divided into two equal meals. Diets were fed for 12 d with the first 5 d considered the adaptation period. Urine collections started on day 6 in the morning and ceased on day 10 in the morning. Fecal markers were also included in the morning meals on day 6 and day 10 and feces were collected according to the marker-to-marker procedure. Results indicated that the apparent total tract digestibility of dry matter was not affected by dietary P or phytase levels. The basal endogenous loss of Ca was not affected by dietary P, but exponentially decreased (P = 0.030) as phytase level increased in the diets. Phosphorus retention (g/d) and standardized total tract digestibility of phosphorus were greater (P < 0.05) in pigs fed the PC diet compared with pigs fed the NC diet with no phytase. The STTD of P exponentially (P < 0.001) increased as phytase level increased in the diets, but because of the lack of Ca, retention of P (% of absorbed) linearly decreased (P = 0.006) as phytase increased. In conclusion, basal endogenous loss of Ca decreased as dietary phytase increased demonstrating that endogenous Ca can be bound to phytate in the intestinal tract of pigs. However, STTD of P increased as phytase level in the diets increased.

Effect of Fiber Fermentation and Protein Digestion Kinetics on Mineral Digestion in Pigs

Nutrient kinetic data and the timing of nutrient release along the gastrointestinal tract (GIT), are not yet widely used in current feed formulations for pigs and poultry. The present review focuses on interactions between fermentable substrates (e.g., starch, fiber, and protein) and selected minerals on nutrient digestion and absorption to determine nutritional solutions to maximize animal performance, principally in the grower-finisher phase, with the aim of minimizing environmental pollution. For phosphorus (P), myo-inositol 1,2,3,4,5,6-hexakis (dihydrogen phosphate) (InsP6), copper (Cu), and zinc (Zn), no standardized methodologies to assess in vitro mineral digestion exist. The stepwise degradation of InsP6 to lower inositol phosphate (InsP) forms in the GIT is rare, and inositol phosphate4 (InsP4) might be the limiting isomer of InsP degradation in diets with exogenous phytase. Furthermore, dietary coefficients of standardized total tract digestibility (CSTTD) of P might be underestimated in diets with fermentable ingredients because of increased diet-specific endogenous P losses (EPL), and further clarification is required to better calculate the coefficients of true total tract digestibility (CTTTD) of P. The quantification of fiber type, composition of fiber fractions, their influence on digestion kinetics, effects on digesta pH, and nutrient solubility related to fermentation should be considered for formulating diets. In conclusion, applications of nutrient kinetic data should be considered to help enhance nutrient digestion and absorption in the GIT, thereby reducing nutrient excretion.

Effects of particle size and phytase supplementation on apparent and standardized total tract digestibility of phosphorus in hybrid rye fed to growing pigs

An experiment was conducted to investigate the effects of particle size (PS) and levels of phytase supplementation on the apparent (ATTD) and standardized (STTD) total tract digestibility of P in hybrid rye fed to growing pigs. Thirty-six growing barrows (23.6 ± 1.5 kg initial BW) were individually housed in metabolism crates and randomly allotted to one of six dietary treatments to give six replicates per treatment. The six dietary treatments were arranged in a 2 × 3 factorial with main effects of PS and phytase supplementation levels (0, 500, or 2,500 FTU/kg). Hybrid rye was ground using a hammermill mounted with 4.0-mm and 3.2-mm screens to obtain material with coarse and fine PS, respectively. Pigs were fed experimental diets for 11 d, including 5 d for adaptation and 6 d for total collection of feces. All data were analyzed using the MIXED procedure of SAS with PS, phytase, and their interaction as fixed effects. Orthogonal polynomial contrasts were used to test linear and quadratic effects of phytase level in both coarse and fine hybrid rye diets. The ATTD and STTD of P were greater (P < 0.05) in diets with fine than in those with coarse hybrid rye. Increasing levels of phytase supplementation linearly (P < 0.01) and quadratically (P < 0.01) improved the ATTD and STTD of P in hybrid rye diets. There were no interaction effects between PS and phytase supplementation on the ATTD and STTD of P in hybrid rye diets. In conclusion, PS reduction improved the digestibility of P in hybrid rye, and supplementing increasing levels of phytase improved P digestibility in linear and quadratic manner in growing pigs fed hybrid rye diets.

Phosphorus nutrition of growing pigs

Phosphorus (P) is an essential nutrient for diverse biological processes, which aggregate to the animal's requirement for P, and nutritionists strive to meet this requirement accurately. The P demand for a growing pig comprises requirements for maintenance and tissue deposition. The P in feed ingredients, however, must be digested and absorbed before its ultimate partition between the 2 aforementioned requirement components. Phosphorus from various sources could behave differently during digestion and absorption, which results in their disparate bioavailability for pigs. The system of standardized total tract digestibility reflects true total tract digestibility of P and feed ingredient effects on specific endogenous P loss with relative ease of implementation, and this system guarantees satisfactory additivity in digestible P among the ingredients in a diet-the foundation for diet formulation. The basal endogenous P loss, which is much easier to measure than the specific endogenous P loss, is considered as part of the pig's maintenance requirement. With this arrangement, a digestibility framework is established both for measuring the P-providing capacity of various feed ingredients and for describing the pig's P requirement. This framework entails basic understanding of the function, digestion, absorption, excretion, and homeostasis of P as support pillars. Understanding the workings of this framework enables potential integration of factors such as environment conditions and disease status in future P requirement models. The current review discusses dietary sources, digestion, absorption, bioavailability and requirement of P for growing pigs to understand the status quo, revealing the points of consensus as well as those of debate, and to encourage further investigation to provide more clarity.

Effect of Microbial Phytase on Ileal Digestibility of Minerals, Plasma and Urine Metabolites, and Bone Mineral Concentrations in Growing-Finishing Pigs

The study was conducted to evaluate the effects of added phytase in the diet of pigs on utilization of minerals and to determine the essential levels of this supplement in compound feed. An additional aim of the study was a critical assessment of current recommendations regarding the level of phosphorus in the diet of pigs, taking into account the use of phytase. A total of 432 pigs were allotted to six dietary treatments, with nine replicate pens per treatment according to body weight (BW) and sex. The treatments included a negative control (NC) with reduced content of digestible phosphorus; the NC diet supplemented with 6-phytase produced by a genetically modified strain of Aspergillus oryzae in the amount of 250 (NC + 250), 500 (NC + 500), 1000 (NC + 1000), or 1500 (NC + 1500) FTU/kg of feed; and a positive control (PC) diet formulated to meet NCR nutrient requirements for pigs. The results showed that, the higher the phytase activity in the diet (NC+), the lower the concentration of P, Ca, and Mg in the chyme (p < 0.05). Pigs fed the PC and NC+ diets had higher plasma levels of P and Ca than group NC in both fattening periods (p < 0.05). The content of phosphorus in the femur of pigs increased with the level of phytase added to the diet (p < 0.05). The content of Cu and Zn in the femur of pigs in the growing period was higher in groups NC + 500 and NC + 1000 than in the remaining experimental groups (p < 0.001). The content of P and Ca in the feces was higher in pigs fed the PC diet in comparison to the remaining experimental groups in both fattening periods (p < 0.001). There was a decrease in the content of P, Ca, and Mg in the excreta of pigs fed NC+ diets in both fattening periods (p < 0.05). A linear decrease in excretion of zinc in the feces was noted in the case of high levels of phytase, i.e., 1000 and 1500 FTU (p < 0.001). Increasing the level of phytase decreased the Cu (p < 0.001) content in the urine of growing−finishing pigs. In conclusion, the analysis of the effects of the use of phytase in a range of 0−1500 FTU/kg in low-phosphorus diets for fattening pigs indicates that 1000 FTU is the most effective level of phytase for increasing utilization of minerals and reducing excretion of elements into the environment.

Cereal grain fiber composition modifies phosphorus digestibility in grower pigs

Increased fermentable carbohydrates (e.g., β-glucan, amylose) may increase endogenous losses including for P, and thereby reduce apparent total tract digestibility (ATTD) of P. The present study assessed effects of barley cultivars varying in fermentable starch and fiber on apparent ileal digestibility (AID) and ATTD of P, myo-inositol 1,2,3,4,5,6-hexakis (dihydrogen phosphate; InsP6) and Ca, and standardized total tract digestibility (STTD) of P and the presence of lower inositol phosphates (InsP) compared to wheat. In a 6 (period) × 5 (diet) Youden square, 7 ileal-cannulated barrows (initial BW, 27.7 kg) were fed diets containing 80% of 1 of 5 cereal grains differing in amylose, β-glucan, and fiber content: 1) high-fermentable, high-β-glucan, hull-less barley (HFB); 2) high-fermentable, high-amylose, hull-less barley (HFA); 3) moderate-fermentable, hull-less barley (MFB); 4) low-fermentable, hulled barley (LFB); and 5) low-fermentable, hard red spring wheat (LFW). On dry matter (DM) basis, cereal grains contained between 0.32 to 0.53% total P and 0.24 to 0.50% InsP6-P. The InsP6-2-P was calculated as the sum of all detected InsP-P (InsP6-P to InsP2-P) in the sample. The P release of degraded InsP-P was calculated by using the following equation: sum InsP6-2-Pdiet (g/kg DM) × (AID or ATTD sum InsP6-2-P (%) / 100). Data were analyzed using a mixed model with diet as fixed effect, and pig and period as random effects. On DM basis, diets contained 41.4 to 50.6% starch, 0.88 to 8.54% β-glucan, 0.81 to 0.89% total P, and 0.19 to 0.35% InsP6-P. The MFB, LFB, and LFW had greater (P &lt; 0.05) diet AID of P than HFB and HFA, and MFB had greater (P &lt; 0.05) diet ATTD and STTD of P than HFB. The ATTD of InsP6-P was greater (P &lt; 0.05) for HFB than LFB and the ATTD of the sum InsP6-2-P was greater (P &lt; 0.05) for HFB and HFA than LFB. Total tract P release was greater (P &lt; 0.001) for HFB, HFA, and LFW than MFB and LFB. The LFW had greater (P &lt; 0.05) ATTD of Ca than LFB. Diet β-glucan content was not correlated with STTD of P (R 2 = 0.03) or ATTD of InsP6 (R 2 = 0.05). In conclusion, cereal grains high in fermentable fiber, e.g., amylose and β-glucans included in specific hull-less barley cultivars, had lower diet AID, ATTD, and STTD of P, but greater ATTD of InsP6-P and sum InsP6-2-P. Carbohydrate fermentation thus results in greater total tract P release from InsP-P hydrolysis.

A time-series effect of phytase supplementation on phosphorus utilization in growing and finishing pigs fed a low-phosphorus diet

Two experiments were carried out to determine a time-series effect of phytase on phosphorus (P) utilization in growing and finishing pigs using growth performance, apparent total tract digestibility (ATTD) of nutrients, P excretion, and plasma concentrations of minerals as the response criteria for evaluation. In both experiments, treatments were arranged as a 3 × 4 factorial in a randomized complete block design with 3 corn-soybean meal-based diets including a P-adequate positive control (PC), a low-P negative control (NC; no inorganic P), and NC supplemented with phytase at 1,000 FYT/kg (NC + 1,000); and 4 sampling time points at days 7, 14, 21, and 28 in experiment 1, and days 14, 26, 42, and 55 in experiment 2. In both trials, 96 growing pigs with average body weight (BW) of 19.8 ± 1.16 and 49.8 ± 3.21 kg, respectively, were allocated to the 3 diets with 8 replicates pens (4 barrows and 4 gilts) and 4 pigs per pen. In experiment 1, pigs fed the PC had higher (P < 0.01) BW, average daily gain (ADG), average daily feed intake (ADFI), and gain-to-feed ratio (G:F) when compared with pigs fed the NC. There was an interaction (P < 0.01) between time and diet on the BW and ADG of pigs while a linear and quadratic increase (P < 0.01) was observed with the ADFI and G:F, respectively, over time. Phytase supplementation improved (P < 0.01) all growth performance responses. Pigs fed the PC had greater (P < 0.01) ATTD of P and Ca than pigs fed the NC. There was no interaction effect on the ATTD of nutrients. Phytase addition improved the ATTD of P and Ca over pigs fed the NC. There was an interaction (P < 0.01) between diet and time on the total and water-soluble P (WSP) excreted. There was a quadratic decrease (P < 0.01) in plasma concentration of Ca in pigs over time. In experiment 2, there was a quadratic increase (P < 0.01) in BW, ADG, and G:F of pigs over time. Similarly, the inclusion of phytase improved (P < 0.05) all growth performance parameters except ADFI. A linear increase (P < 0.05) in the ATTD of DM, P, and Ca occurred over time. Phytase inclusion improved (P < 0.01) the ATTD of P and Ca. Plasma concentrations of P were improved by phytase addition. Phytase supplementation of the NC reduced WSP excretion by 45%, 32%, and 35% over the growing, finishing, and entire grow-finish period, respectively. In conclusion, phytase improves the utilization of P in growing and finishing pigs; however, the magnitude of effect on responses may vary over time.

Dietary Phosphorus and Calcium Utilization in Growing Pigs: Requirements and Improvements

The sustainability of animal production relies on the judicious use of phosphorus (P). Phosphate, the mined source of agricultural phosphorus supplements, is a non-renewable resource, but phosphorus is essential for animal growth, health, and well-being. P must be provided by efficient and sustainable means that minimize the phosphorus footprint of livestock production by developing precise assessment of the bioavailability of dietary P using robust models. About 60% of the phosphorus in an animal's body occurs in bone at a fixed ratio with calcium (Ca) and the rest is found in muscle. The P and Ca requirements must be estimated together; they cannot be dissociated. While precise assessment of P and Ca requirements is important for animal well-being, it can also help to mitigate the environmental effects of pig farming. These strategies refer to multicriteria approaches of modeling, efficient use of the new generations of phytase, depletion and repletion strategies to prime the animal to be more efficient, and finally combining these strategies into a precision feeding model that provides daily tailored diets for individuals. The industry will need to use strategies such as these to ensure a sustainable plant-animal-soil system and an efficient P cycle.

Supplemental Effects of Phytase on Modulation of Mucosa-Associated Microbiota in the Jejunum and the Impacts on Nutrient Digestibility, Intestinal Morphology, and Bone Parameters in Broiler Chickens

This study aimed to determine supplemental effects of phytase on modulation of the mucosa-associated microbiota in the jejunum, intestinal morphology, nutrient digestibility, bone parameters, and growth performance of broiler chickens. Three hundred and sixty newly hatched broiler chickens (Ross 308) (44 ± 2 g BW) were randomly allotted in 6 treatments with 10 birds per cage based on a completely randomized design and fed for 27 d. The treatments consisted of one negative control (NC), diet formulated meeting the requirements suggested by Ross recommendations (2019), and without phytase supplementation. The other treatments consisted of a positive control diet (PC) formulated with 0.15% deficient Ca and P and split into 5 treatments with different phytase inclusion levels (0, 500, 1000, 2000, 4000 FTU/kg feed). Titanium dioxide (0.4%) was added to feeds as an indigestible marker to measure apparent ileal digestibility (AID) of nutrients. On d 27, 3 birds were randomly selected from each cage and euthanized to collect samples for analyzing the mucosa-associated microbiota in the jejunum, oxidative stress status, AID, and bone parameters. Data were analyzed using the proc Mixed of SAS 9.4. Phytase supplementation tended to have a quadratic effect (p = 0.078) on the overall ADG (maximum: 41 g/d at 2833 FTU/kg of feed). Supplementation of phytase at 2,000 FTU/kg increased (p < 0.05) the relative abundance of Lactobacillus and reduced (p < 0.05) Pelomonas. Moreover, it tended to reduce Helicobacter (p = 0.085), Pseudomonas (p = 0.090) Sphingomonas (p = 0.071). Phytase supplementation increased (p < 0.05) the villus height and the AID of CP; and tended to increase (p = 0.086) the AID of P. Phytase supplementation increased (p < 0.05) breaking strength and P content in the tibia. In conclusion, phytase supplementation showed potential benefits on the modulation of the mucosa-associated microbiota in the jejunum by tending to reduce harmful bacteria (Pelomonas, Helicobacter, and Pseudomonas) and increase beneficial bacteria (Lactobacillus). In addition, it showed positive effects increasing apparent ileal digestibility of CP and P, enhancing intestinal morphology (villus height), and improving the bone parameters (bone breaking strength, ash, and P content). Phytase supplementation at a range of 38 to 59 FTU/d or 600 to 950 FTU/kg of feed provided the most benefits related to nutrient digestibility.

A systematic-review on the role of exogenous enzymes on the productive performance at weaning, growing and finishing in pigs

•

Supplementation of exogenous enzymes in the general diet improves production characteristics in all stages of production.

•

Phytases are the most supplemented enzymes in all productive stages of pigs.

•

The inclusion of Phytases, used in the pig's diet showed an average dry matter digestibility (g/kg) 840.6 ± 25.5 in weaning, 862.5 ± 7.4 in growing and 802.0 ± 1.41 in finishing.

•

The inclusion of xylanases used in the pig's diet showed an average in dry matter digestibility (g/kg) 829.5 ± 7.14 in weaning and 759.1 ± 6.93 in finishing stages.

Supplementing exogenous enzymes in pig diets is an alternative solution to increase dietary energy and fiber digestibility to improve pig production performance at a low production cost and to reduce environmental impact with lower N and P excretions. The production stage, diet composition, enzyme source, amount and number of enzymes added, are factors to consider before using them. A database composed by 227 individual diets, resulting from 43 studies with 48 experimental records were divided in different production stages, with 19 records for weaning, 17 records for growing and 12 records for finishing. A descriptive statistical analysis of the chemical composition of the diets and enzyme doses was carried out. The data with normal distribution were analyzed calculating the mean, the minimum and maximum length, the standard deviation and the coefficient of variation. It was found that combined enzymes are the most widely reported enzyme combination in the supplementation of pigs at all stages of production. Phytases and Mannanases are commonly used at weaning and growing stages. Xylanases and Proteases have been reported to be used in all production stages. However, the highest yielding enzymes at weaning, growing and finishing stages were Phytases and Mannanases. Dietary supplementation of exogenous enzymes improves production characteristics at all stages of production. However, an improvement in growth performance and nutrient digestibility is not always observed. Future studies should focus on the interaction between production stages, composition of the diet, origin of the enzyme and the amount and number of enzymes added.

Effects of thermostable phytase supplemented in diets on growth performance and nutrient utilization of broilers

Phytase is an enzyme that has the ability to release phosphorous (P) from phytate by hydrolyzing inositol-phosphate linkages. Recently, thermostable phytases have gained great consideration because the reduction in phytase activity was found when exposed to heat during feed pelleting. In this study, the effects of the granular thermostable phytase (Aspergillus niger) on growth performance and nutrient utilization of broilers were investigated. A total of 96 21-day-old Arbor Acres broilers were randomly distributed into six treatments including basal diet (control) and basal diet supplemented with 500, 1,000, 2,000, 4,000, 8,000 U of phytase/kg. In general, the metabolizable energy (ME) and the apparent and true availability of dry matter (DM), organic matter (OM), ether extract (EE), crude protein (CP), and amino acids (AA) showed both linearly (p < .01) and quadratically (p < .01) increase with increasing levels of phytase in the diet. Additionally, diet supplementation with phytase could improve (p < .05) body weight (BW), average daily gain (ADG), and feed/gain (F/G) on day 42 compared with the control. The results suggested that diet supplementation of the granular thermostable phytase in the crumbled pellets could improve chicken growth performance and nutrient utilization.

Influence of a novel consensus bacterial 6-phytase variant on mineral digestibility and bone ash in young growing pigs fed diets with different concentrations of phytate-bound phosphorus

A 20-d experiment was conducted to test the hypothesis that phytase increases nutrient digestibility, bone ash, and growth performance of pigs fed diets containing 0.23%, 0.29%, or 0.35% phytate-bound P. Within each level of phytate, five diets were formulated to contain 0, 500, 1,000, 2,000, or 4,000 phytase units (FTU)/kg of a novel phytase (PhyG). Three reference diets were formulated by adding a commercial Buttiauxella phytase (PhyB) at 1,000 FTU/kg to diets containing 0.23%, 0.29%, or 0.35% phytate-bound P. A randomized complete block design with 144 individually housed pigs (12.70 ± 4.01 kg), 18 diets, and 8 replicate pigs per diet was used. Pigs were adapted to diets for 15 d followed by 4 d of fecal collection. Femurs were collected on the last day of the experiment. Results indicated that diets containing 0.35% phytate-bound P had reduced (P < 0.01) digestibility of Ca, P, Mg, and K compared with diets containing less phytate-bound P. Due to increased concentration of total P in diets with high phytate, apparent total tract digestible P and bone ash were increased by PhyG to a greater extent in diets with 0.29% or 0.35% phytate-bound P than in diets with 0.23% phytate-bound P (interaction, P < 0.05). At 1,000 FTU/kg, PhyG increased P digestibility and bone P more (P < 0.05) than PhyB. The PhyG increased (P < 0.01) pig growth performance, and pigs fed diets containing 0.35% or 0.29% phytate-bound P performed better (P < 0.01) than pigs fed the 0.23% phytate-bound P diets. In conclusion, the novel phytase (i.e., PhyG) is effective in increasing bone ash, mineral digestibility, and growth performance of pigs regardless of dietary phytate level.

Effect of feeding acidified or fermented barley using Limosilactobacillus reuteri with or without supplemental phytase on diet nutrient digestibility in growing pigs

Fermentation of cereal grains may degrade myo-inositol 1,2,3,4,5,6-hexakis (dihydrogen phosphate) (InsP6) thereby increasing nutrient digestibility. Effects of chemical acidification or fermentation with Limosilactobacillus (L.) reuteri with or without phytase of high β-glucan hull-less barley grain on apparent ileal digestibility (AID) and apparent total tract digestibility (ATTD) of nutrients and gross energy (GE), standardized ileal digestibility (SID) of crude protein (CP) and amino acids (AAs), and standardized total tract digestibility (STTD) of P were assessed in growing pigs. Pigs were fed four mash barley-based diets balanced for water content: 1) unfermented barley (Control); 2) chemically acidified barley (ACD) with lactic acid and acidic acid (0.019 L/kg barley grain at a ratio of 4:1 [vol/vol]); 3) barley fermented with L. reuteri TMW 1.656 (Fermented without phytase); and 4) barley fermented with L. reuteri TMW 1.656 and phytase (Fermented with phytase; 500 FYT/kg barley grain). The acidification and fermentation treatments occurred for 24 h at 37 °C in a water bath. The four diets were fed to eight ileal-cannulated barrows (initial body weight [BW], 17.4 kg) for four 11-d periods in a double 4 × 4 Latin square. Barley grain InsP6 content of Control, ACD, Fermented without phytase, or Fermented with phytase was 1.12%, 0.59%, 0.52% dry matter (DM), or not detectable, respectively. Diet ATTD of DM, CP, Ca, and GE, digestible energy (DE), predicted net energy (NE) value, and urinary excretion of P were greater (P < 0.05) for ACD than Control. Diet ATTD of DM, CP, Ca, GE, DE and predicted NE value, urinary excretion of P was greater (P < 0.05), and diet AID of Ca and ATTD and STTD of P tended to be greater (P < 0.10) for Fermented without phytase than Control. Diet ATTD of GE was lower (P < 0.05) and diet ATTD and STTD of P, AID and ATTD of Ca was greater (P < 0.05) for Fermented with phytase than Fermented without phytase. Acidification or fermentation with/without phytase did not affect diet SID of CP and AA. In conclusion, ACD or Fermented without phytase partially degraded InsP6 in barley grain and increased diet ATTD of DM, CP, and GE, but not SID of CP and most AA in growing pigs. Fermentation with phytase entirely degraded InsP6 in barley grain and maximized P and Ca digestibility, thereby reducing the need to provide inorganic dietary P to meet P requirements of growing pigs.

Application of Creep Feed and Phytase Super-Dosing as Tools to Support Digestive Adaption and Feed Efficiency in Piglets at Weaning

A total of 64 piglets were used in a 35-day study to evaluate whether creep feeding piglets on the sow or super-dosing phytase to piglets post-weaning can be used as a tool to reduce stress and support adaption to weaning. Treatments consisted of creep or no creep feed being offered pre-weaning and with or without phytase supplementation at 2000 FTU/kg post-weaning. Blood samples were collected from eight piglets per treatment on days 0 (weaning), 7 and 21 post-weaning to determine plasma cortisol and myo-inositol concentrations. Four piglets per treatment (n = 16) were administered Heidelberg pH capsules 1 week prior to weaning, on the day of weaning, as well as 7 days and 21 days post-weaning, with readings monitored over a 3 h period. In the first week post-weaning, creep-fed piglets had higher daily gains (0.23 vs. 0.14 kg/d, p < 0.05) and a lower feed conversion ratio (FCR, 0.99 vs. 1.35, p < 0.01), compared to non-creep-fed pigs. At 21 days post-weaning, irrespective of creep feed, phytase supplementation reduced FCR (1.10 vs. 1.18, p = 0.05) of piglets. Average real-time stomach pH was lower in creep-fed piglets at 1 week prior to weaning (pH 3.2 vs. 4.6, p < 0.001) and on day of weaning (pH 3.1 vs. 3.7, p < 0.01). Following weaning, phytase reduced average stomach pH of piglets at days 7 (pH 2.6 vs. 3.3, p < 0.001) and 21 (pH 2.2 vs. 2.6, p < 0.01). Both cortisol and myo-inositol concentrations in plasma decreased with age; however, cortisol levels were unaffected by either treatment. Plasma myo-inositol concentrations were higher in creep-fed piglets at day of weaning (p < 0.05) and with phytase super-dosing on day 21 (p < 0.001). These findings demonstrate that both creep feeding and phytase super-dosing are useful practices to encourage better adaption to weaning and support piglet performance. This response was not related to reduced stress in piglets, as determined by cortisol levels, but instead appears to relate to improved gastric conditions for digestion, phytate degradation and myo-inositol provision in piglets.

Effect of a novel consensus bacterial 6-phytase variant in grower pigs fed corn-soybean meal-based diets formulated with a full nutrient matrix and no added inorganic phosphorus

The capacity of a novel consensus bacterial 6-phytase variant (PhyG) to entirely replace dietary inorganic phosphorus (Pi) source in grower pigs fed diets with reduction of calcium (Ca), net energy (NE), and digestible amino acids (AA) was evaluated, using growth performance and apparent total tract digestibility (ATTD) of nutrients as outcome measures. A total of 352 mixed-sex pigs (initial BW 23.4 kg) were randomized to 4 treatments, 8 pigs/pen, and 11 pens/treatment. Diets were corn-soybean meal-based and formulated by phase (grower 1, 25 to 50 and grower 2, 50 to 75 kg BW). The positive control diet (PC) provided adequate nutrients and a negative control diet (NC) was formulated without Pi (1.2 g/kg ATTD P) and reduced in Ca (-0.12 to -0.13 percentage points), NE (-32 kcal/kg), and digestible essential AA (-0.004 to -0.026 percentage points) vs. PC. Two further treatments comprised the NC plus 500 or 1,000 FTU/kg of PhyG. Data were analyzed by ANOVA, mean contrasts and orthogonal polynomial regression. Nutrient reductions in the NC reduced (P < 0.05) average daily gain (ADG) during grower 1 and overall (73 to 136 d of age), increased (P < 0.05) feed conversion ratio (FCR) during grower 1 and overall and tended to reduce (P < 0.1) average daily feed intake (ADFI) during grower 2 and overall, vs. PC. Phytase supplementation improved (P < 0.05) FCR during grower 1, ADG during grower 2 and overall, ATTD of DM and P, and tended to improve DE (P = 0.053) in a linear dose-dependent manner. PhyG at 1,000 FTU/kg resulted in growth performance (all measures, all phases) equivalent to PC. The findings demonstrate that PhyG at 1,000 FTU/kg totally replaced Pi in complex grower pig diets containing industrial co-products, compensated a full nutrient matrix reduction and maintained performance.

Effects of Exogenous 6-Phytase (EC 3.1.3.26) Supplementation on Performance, Calcium and Phosphorous Digestibility, and Bone Mineralisation and Density in Weaned Piglets

Phosphorus (P) is an essential mineral for growing piglets, which is poorly accessible in vegetable feedstuffs as it is stored as phytates. Thus, phytase supplementation is essential to increase P availability. Two experiments were conducted to evaluate a novel 6-phytase (EC 3.1.3.26) in weaned pigs fed low-P diets. In each experiment, one hundred and twenty piglets were fed a positive control (PC; adequate in Ca and P), a negative control (NC; limiting in Ca and P), or NC supplemented with 125, 250, or 500 FTU/kg of phytase (NC125, NC250, and NC500, respectively). P content was lower in diets of Experiment 1 than diets of Experiment 2. In Experiment 1, piglets offered PC or phytase diets had higher growth and efficiency compared with NC diets. In Experiment 2, similar effects were obtained, but the effects were less significant. In both experiments, P and Ca ATTD and bone density were significantly increased with phytase supplementation. Moreover, PC and NC500 had higher P concentrations and lower alkaline phosphatase activity in plasma than NC. To conclude, supplementation with the new 6-phytase at doses up to 500 FTU/kg enhanced P utilization, growth performance, and bone density in piglets fed P-limiting diets.

Determining the phosphorus release of GraINzyme phytase in diets for nursery pigs

The objective of this study was to determine the available P (aP) release curve for a new phytase source, GraINzyme Phytase (Agrivida Inc., Woburn, MA), which is expressed in corn containing an engineered Escherichia coli phytase called Phy02. Plant-expressed phytases are created by inserting phytase-encoding genes into plants resulting in their ability to produce seeds with increased concentrations of phytase. A total of 360 pigs (Line 200 × 400, DNA, Columbus, NE, initially 9.9 ± 0.19 kg) were used in a 21-d growth study. Pigs were weaned at approximately 21 d of age, randomly allotted to pens based on initial body weight (BW) and fed common starter diets. From days 18 to 21 postweaning, all pigs were fed a diet containing 0.11% aP. On day 21 postweaning, considered day 0 of the study, pens were blocked by BW and randomly allotted to one of eight dietary treatments with five pigs per pen and nine pens per treatment. Dietary treatments were formulated to include increasing aP derived from either an inorganic P source (0.11%, 0.19%, or 0.27% from monocalcium P) or increasing phytase (150, 250, 500, 1,000, or 1,500 FTU/kg). Diets were corn-soybean meal-based and contained 1.24% standardized ileal digestible Lys. On day 21 of the trial, one pig per pen (weighing closest to the mean pen BW) was euthanized and the right fibula was collected to determine bone ash using the nondefatted processing method. Overall (days 0 to 21), pigs fed increasing aP from inorganic P or phytase had increased (linear, P < 0.002) average daily gain (ADG), average daily feed intake (ADFI), and gain-to-feed (G:F; quadratic, P < 0.05). Bone ash weight (g) and percentage bone ash increased (linear, P < 0.001), with increasing inorganic P or added phytase. Based on the composition of the diets used in this study, the release equations developed for GraINzyme for ADG, G:F, bone ash weight, and percentage bone ash are as follows: aP = (0.255 × FTU)/(1299.969 + FTU), aP = (0.233 × FTU)/(1236.428 + FTU), aP = (45999.949 × FTU)/(462529200 + FTU), and aP = (0.272 × FTU)/(2576.581 + FTU), respectively.

Inclusion of dicopper oxide instead of copper sulfate in diets for growing-finishing pigs results in greater final body weight and bone mineralization, but reduced accumulation of copper in the liver

An experiment was conducted to test the hypothesis that inclusion of Cu oxide (Cu2O) in diets for growing-finishing pigs improves body weight (BW) and bone mineralization, and reduces accumulation of Cu in the liver compared with pigs fed diets containing Cu sulfate (CuSO4). Two hundred growing pigs (initial BW: 11.5 ± 0.98 kg) were allotted to a randomized complete block design with 2 blocks of 100 pigs, 5 dietary treatments, 5 pigs per pen, and a total of 8 pens per treatment. Treatments included the negative control (NC) diet that contained 20 mg Cu/kg, and 4 diets in which 125 or 250 mg Cu/kg from CuSO4 or Cu2O were added to the NC diet. The experiment was divided into 4 phases and concluded when pigs reached market weight. Pig weights were recorded on day 1 and at the end of each phase and feed provisions were recorded throughout the experiment. On the last day of phases 1 and 4, 1 pig per pen was sacrificed to obtain samples of liver and spleen tissue, and the right metacarpal was collected. Results indicated that pigs fed diets containing 250 mg Cu/kg from CuSO4 had greater BW at the end of phases 1 and 2 than pigs fed NC diets. Pigs fed diets containing 250 mg Cu/kg from Cu2O had greater (P < 0.05) BW at the end of phases 1, 2, 3, and 4 compared with pigs fed NC diets, and these pigs also had greater BW at the end of phases 3 and 4 than pigs fed all other diets. Pigs fed the diets with 250 mg Cu/kg tended to have greater (P < 0.10) feed intake than pigs fed the NC diet at the end of phase 2, and for the overall experimental period, pigs fed diets containing 250 mg Cu/kg from Cu2O had greater (P < 0.05) feed intake than pigs on all other treatments. However, no differences in gain:feed ratio were observed among treatments. Copper accumulation in liver and spleen increased with Cu dose, but at the end of phase 1, pigs fed 250 mg Cu/kg from CuSO4 had greater (P < 0.05) Cu concentration in liver and spleen than pigs fed 250 mg Cu/kg from Cu2O. Pigs fed diets containing 250 mg Cu/kg from Cu2O had greater (P < 0.05) quantities of bone ash and greater (P < 0.05) concentrations of Ca, P, and Cu in bone ash than pigs fed NC diets or the 2 diets containing CuSO4, but Zn concentration in bone ash was less (P < 0.05) in pigs fed diets containing 250 mg Cu/kg from Cu2O. To conclude, supplementing diets for growing pigs with Cu2O improves growth performance and bone mineralization with less Cu accumulation in liver compared with pigs fed diets containing CuSO4.

Effects of supplementation of high-dosing Trichoderma reesei phytase in the corn-wheat-soybean meal-based diets on growth performance, nutrient digestibility, carcass traits, faecal gas emission, and meat quality in growing-finishing pigs

We conduct this study to investigate the effects of corn-wheat-soybean meal (SBM)-based diet supplemented with high-dosing Trichoderma reesei phytase on the growth performance, nutrient digestibility, carcass traits, faecal gas emission and meat quality in growing-finishing pigs (29.71-110.58 kg live weight; 70-day-old to 166-day-old). A total of 56 crossbred pigs [(Landrace × Yorkshire) × Duroc] were used in 96-day experiment with a completely randomized block design. The growing period was from day 0 to 42, and the finishing period was from day 43 to 96. Pigs were randomly allocated to one of two treatments with seven replicate pens and four pigs (two barrows and two gilts) per pen and fed corn-wheat-SBM-based nutrient adequate basal diet or the basal diet supplemented with 1500 FTU/kg diet Trichoderma reesei phytase. One phytase unit (FTU) was defined as the amount of enzyme that catalyses the release of one micromole phosphate from phytate per minute at 37°C and pH 5.5. Dietary supplement with Trichoderma reesei phytase had increased body weight on day 96 and average daily gain in days 0-96. Moreover, high apparent total tract digestibility (ATTD) of phosphorus (P) was observed in pigs fed with Trichoderma reesei phytase. However, the carcass traits, faecal gas emission and meat quality of pigs were unaffected by Trichoderma reesei phytase supplementation. In conclusion, supplementation of high-dosing Trichoderma reesei phytase (1500 FTU/kg diet) in the corn-wheat-SBM-based nutrient adequate basal diet increased body weight and the ATTD of P, while no adverse effects were observed on the production characteristics.

A Multicarbohydrase and Phytase Complex Is Able to Compensate a Nutrient-Deficiency in Growing-Finishing Pigs

Simple Summary

Phytate is the primary storage form of phosphorus in grain-based feedstuffs, which can reduce the utilization of the phosphorus, calcium, and other minerals. Additionally, non-starch polysaccha-rides can increase digesta viscosity and thus decrease the nutrient digestion and utilization. The current study has evaluated the effects of a next-generation multicarbohydrase and phytase com-plex on the growth performance, apparent total tract digestibility of nutrients, carcass traits, and meat quality in growing-finishing pigs fed a corn-wheat-soybean meal-based diet. The results showed that dietary supplementation of the multicarbohydrase and phytase complex improved the growth performance and nutrient digestibility but had little effect on carcass traits and meat quality in growing-finishing pigs fed a corn-soybean meal-wheat-based diet. These findings indi-cate that the multicarbohydrase and phytase complex could be used as a promising enzymes product to mitigate the negative effects of phytate and non-starch polysaccharides.

Abstract

The objective of this study was to evaluate the efficacy of supplementing a corn-wheat-soybean meal-based diet with a multicarbohydrase and phytase complex (MCPC) on growth performance, apparent total tract digestibility (ATTD) of nutrients, carcass traits, and meat quality in growing-finishing pigs. A total of 300 pigs (Duroc × Large White × Landrace; body weight = 25.3 ± 0.7 kg) were randomly allotted to three groups with 10 replicates of 10 pigs each. Pigs from three groups were fed positive control (PC) or negative control (NC), without or with MCPC diets, respectively. The MCPC supplied at least 1800, 1244, 6600, and 1000 units of xylanase, β-glucanase, α-arabinofuranosidase, and phytase per kilogram of diet, respectively. The NC diet was the PC diet but reduced in net energy (NE), digestible amino acids (dig. AA), digestible P (dig. P), and Ca by 74 kcal/kg, 7.0%, 0.134, and 0.119 percentage points, respectively. The diets were fed in 4 growth phases based on body weight (BW): phase 1: 25–50 kg, phase 2: 50–75 kg, phase 3: 75–100 kg, and phase 4: 100–135 kg. Compared to the PC, the NC diet decreased (p < 0.05) body weight gain, feed intake, and(or) feed to gain ratio during the growing/finishing phases 1, 2, 3, and 4. It also reduced (p < 0.05) the ATTD of crude protein, crude fat, P, and Ca of pigs. MCPC supplementation improved (p < 0.05) the body weight gain, feed intake, and(or) feed to gain ratio in phases 2, 3, and 4 and the ATTD of crude protein, crude fat, ash, P, and Ca for the NC diet. Additionally, dietary treatment had no effects on carcass traits and meat quality with the exception that the loin eye area in the NC plus MCPC diet was higher (p < 0.05) than the NC diet. In conclusion, the addition of MCPC to a corn-soybean meal-wheat-based diet reduced in energy and nutrients improved the growth performance and nutrient digestibility but had little effect on carcass traits and meat quality in growing-finishing pigs.