Effect of gelatin supplementation on growth performance and blood metabolites of broiler chickens fed diets varying in crude protein

BSE risk posed by ruminant collagen and gelatine derived from bones

The European Commission requested an estimation of the BSE risk (C-, L- and H-BSE) from gelatine and collagen derived from ovine, caprine or bovine bones, and produced in accordance with Regulation (EC) No 853/2004, or Regulation (EC) No 1069/2009 and its implementing Regulation (EU) No 142/2011. A quantitative risk assessment was developed to estimate the BSE infectivity, measured in cattle oral infectious dose 50 (CoID50), in a small size batch of gelatine including one BSE-infected bovine or ovine animal at the clinical stage. The model was built on a scenario where all ruminant bones could be used for the production of gelatine and high-infectivity tissues remained attached to the skull (brain) and vertebral column (spinal cord). The risk and exposure pathways defined for humans and animals, respectively, were identified. Exposure routes other than oral via food and feed were considered and discussed but not assessed quantitatively. Other aspects were also considered as integrating evidence, like the epidemiological situation of the disease, the species barrier, the susceptibility of species to BSE and the assumption of an exponential dose-response relationship to determine the probability of BSE infection in ruminants. Exposure to infectivity in humans cannot be directly translated to risk of disease because the transmission barrier has not yet been quantified, although it is considered to be substantial, i.e. much greater amounts of infectivity would be needed to successfully infect a human and greater in the oral than in the parenteral route of exposure. The probability that no new case of BSE in the cattle or small ruminant population would be generated through oral exposure to gelatine made of ruminant bones is 99%-100% (almost certain) This conclusion is based on the current state of knowledge, the epidemiological situation of the disease and the current practices, and is also valid for collagen.

Potential BSE risk posed by the use of ruminant collagen and gelatine in feed for non-ruminant farmed animals

EFSA was requested to estimate the cattle bovine spongiform encephalopathy (BSE) risk (C-, L- and H-BSE) posed by ruminant collagen and gelatine produced from raw material fit for human consumption, or from material classified as Category 3 animal by-products (ABP), to be used in feed intended for non-ruminant animals, including aquaculture animals. Three risk pathways (RP) were identified by which cattle could be exposed to ruminant feed cross-contaminated with ruminant collagen or gelatine: 1) recycled former foodstuffs produced in accordance with Regulation (EC) No 853/2004 (RP1), 2) technological or nutritional additives or 3) compound feed, produced either in accordance with Regulation (EC) No 853/2004 (RP2a) or Regulation (EU) No 142/2011 (RP2b). A probabilistic model was developed to estimate the BSE infectivity load measured in cattle oral ID 50 (CoID 50)/kg, in the gelatine produced from the bones and hide of one infected animal older than 30 months with clinical BSE (worst-case scenario). The amount of BSE infectivity (50th percentile estimate) in a member state (MS) with negligible risk status was 7.6 × 10-2 CoID 50/kg, and 3.1 × 10-4 CoID 50/kg in a MS with controlled risk status. The assessment considered the potential contamination pathways and the model results (including uncertainties) regarding the current epidemiological situation in the EU and current statutory controls. Given the estimated amount of BSE infectivity to which cattle would be exposed in a single year, and even if all the estimated undetected BSE cases in the EU were used for the production of collagen or gelatine (either using raw materials fit for human consumption or Category 3 ABP raw materials), it was concluded that the probability that no new case of BSE in the cattle population would be generated through any of the three RP is 99-100% (almost certain).

Influence of feed provisioning prior to digesta sampling on precaecal amino acid digestibility in broiler chickens

A regression approach was applied to determine the influence of feed provisioning prior to digesta sampling on precaecal (pc) amino acid (AA) digestibility in broiler chickens. Soybean meal was used as an example test ingredient. Five feed-provisioning protocols were investigated, four with restricted provision and one with ad libitum provision. When provision was restricted, feed was provided for 30 min after a withdrawal period of 12 h. Digesta were sampled 1, 2, 4 and 6 h after feeding commenced. A diet containing 300 g maize starch/kg was prepared. Half or all the maize starch was replaced with soybean meal in two other diets. Average pc digestibility of all determined AA in the soybean meal was 86% for the 4 and 6-h protocols and 66% and 60% for the 2 and 1-h protocols, respectively. Average pc AA digestibility of soybean meal was 76% for ad libitum feed provision. Feed provisioning also influenced the determined variance. Variance in digestibility ranked in magnitude 1 h > ad libitum > 2 h > 6 h > 4 h for all AA. Owing to the considerable influence of feed-provisioning protocols found in this study, comparisons of pc AA digestibility between studies applying different protocols prior to digesta sampling must be treated with caution. Digestibility experiments aimed at providing estimates for practical feed formulation should use feed-provisioning procedures similar to those used in practice.