1
|
Kafle SR, Adhikari S, Shrestha R, Ban S, Khatiwada G, Gaire P, Tuladhar N, Jiang G, Tiwari A. Advancement of membrane separation technology for organic pollutant removal. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2024; 89:2290-2310. [PMID: 38747950 DOI: 10.2166/wst.2024.117] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/30/2023] [Accepted: 03/11/2024] [Indexed: 05/25/2024]
Abstract
In the face of growing global freshwater scarcity, the imperative to recycle and reuse water becomes increasingly apparent across industrial, agricultural, and domestic sectors. Eliminating a range of organic pollutants in wastewater, from pesticides to industrial byproducts, presents a formidable challenge. Among the potential solutions, membrane technologies emerge as promising contenders for treating diverse organic contaminants from industrial, agricultural, and household origins. This paper explores cutting-edge membrane-based approaches, including reverse osmosis, nanofiltration, ultrafiltration, microfiltration, gas separation membranes, and pervaporation. Each technology's efficacy in removing distinct organic pollutants while producing purified water is scrutinized. This review delves into membrane fouling, discussing its influencing factors and preventative strategies. It sheds light on the merits, limitations, and prospects of these various membrane techniques, contributing to the advancement of wastewater treatment. It advocates for future research in membrane technology with a focus on fouling control and the development of energy-efficient devices. Interdisciplinary collaboration among researchers, engineers, policymakers, and industry players is vital for shaping water purification innovation. Ongoing research and collaboration position us to fulfill the promise of accessible, clean water for all.
Collapse
Affiliation(s)
- Saroj Raj Kafle
- Department of Chemical Engineering, Texas A&M University, College Station, TX, USA; Equally contributed to this work
| | - Sangeet Adhikari
- School of Sustainable Engineering and the Built Environment, Tempe, AZ 85281, USA; Equally contributed to this work
| | - Rakesh Shrestha
- Department of Chemical Science and Engineering, Kathmandu University, P.O. BOX 6250, Dhulikhel, Kavre, Nepal
| | - Sagar Ban
- Department of Chemical Science and Engineering, Kathmandu University, P.O. BOX 6250, Dhulikhel, Kavre, Nepal
| | - Gaurav Khatiwada
- Department of Chemical Science and Engineering, Kathmandu University, P.O. BOX 6250, Dhulikhel, Kavre, Nepal
| | - Pragati Gaire
- Department of Chemical Science and Engineering, Kathmandu University, P.O. BOX 6250, Dhulikhel, Kavre, Nepal
| | - Nerisha Tuladhar
- Department of Chemical Science and Engineering, Kathmandu University, P.O. BOX 6250, Dhulikhel, Kavre, Nepal
| | - Guangming Jiang
- School of Civil, Mining, and Environmental Engineering, University of Wollongong, Wollongong, Australia
| | - Ananda Tiwari
- University of Helsinki, Faculty of Veterinary Medicine, Department of Food Hygiene and Environmental Health, Agnes Sjöbergin katu 2, Helsinki FI-00014, Finland; Department of Health Security, Water Microbiology laboratory, Finnish Institute for Health and Welfare, Kuopio, Finland; Equally contributed to this work. E-mail:
| |
Collapse
|
2
|
Mosai AK, Ndlovu G, Tutu H. Improving acid mine drainage treatment by combining treatment technologies: A review. THE SCIENCE OF THE TOTAL ENVIRONMENT 2024; 919:170806. [PMID: 38350575 DOI: 10.1016/j.scitotenv.2024.170806] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 09/05/2023] [Revised: 02/05/2024] [Accepted: 02/06/2024] [Indexed: 02/15/2024]
Abstract
The mining and processing of some minerals and coal result in the production of acid mine drainage (AMD) which contains elevated levels of sulfate and metals, which tend to pose serious environmental issues. There are different technologies that have been developed for the treatment of wastewater or AMD. However, there is no "one-size-fits-all" solution, hence a combination of available technologies should be considered to achieve effective treatment. In this review, AMD treatment technologies and the possible alignment in tandem of the different treatment technologies were discussed. The alignment was based on the target species of each technology and AMD composition. The choice of the technologies to combine depends on the quality of AMD and the desired quality of effluent depending on end use (e.g., drinking, industrial, irrigation or release into the environment). AMD treatment technologies targeting metals can be combined with membrane and/or ettringite precipitation technologies that focus on the removal of sulfates. Other technologies can be added to deal with the secondary waste products (e.g., sludge and brines) from the treatment processes. Moreover, some technologies such as ion exchange and adsorption can be added to target specific valuable elements in AMD. Such combinations have the potential to result in effective AMD treatment and minimum waste production, which are not easily achievable with the individual technologies. Overall, this review presents combinations of AMD treatment technologies which can work best together to produce optimal water quality and valuable products in a cost-effective manner.
Collapse
Affiliation(s)
- Alseno Kagiso Mosai
- Department of Chemistry, Faculty of Natural and Agricultural Sciences, University of Pretoria, Lynnwood Road, Pretoria 0002, South Africa.
| | - Gebhu Ndlovu
- Hydrometallurgy Division, Mintek, 200 Malibongwe drive, Private Bag X3015, Randburg 2125, South Africa
| | - Hlanganani Tutu
- Molecular Sciences Institute, School of Chemistry, University of the Witwatersrand, Private Bag X3, Wits 2050, South Africa
| |
Collapse
|
3
|
Khan IA, Kim JO. Role of inorganic foulants in the aging and deterioration of low-pressure membranes during the chemical cleaning process in surface water treatment: A review. CHEMOSPHERE 2023; 341:140073. [PMID: 37689156 DOI: 10.1016/j.chemosphere.2023.140073] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/19/2023] [Revised: 08/31/2023] [Accepted: 09/04/2023] [Indexed: 09/11/2023]
Abstract
Low-pressure membrane (LPM) filtration, including microfiltration (MF) and ultrafiltration (UF), is a promising technology for the treatment of surface water for drinking and other purposes. Various configurations and operational sequences have been developed to ensure the sustainable provision of clean water by overcoming fouling problems. In the literature, various periodic physical and/or chemical approaches to the cleaning of LPMs have been reported, but little data is available on the aging of MF/UF membranes that results from the interaction between the foulants and the cleaning agent. Periodic physical cleaning of the membrane is expected to return the membrane to its original performance capacity, but it only recovers to a certain level because the remaining foulants cause irreversible fouling. Chemical cleaning can then be employed to recover the membrane from this irreversible fouling but, in the process, it can cause irrecoverable damage to the membrane. In this review, the foulants responsible for irrecoverable damage to MF/UF membranes are summarized, and their interaction with cleaning agents and other foulants is described. The impact of these foulants on various membrane parameters, including filtration efficiency, flux decline, permeability, membrane characterization, and membrane integrity are also summarized and discussed in detail. In addition, mitigation options and future prospects are also discussed with regard to increasing the operational life span of a membrane in a cost-effective manner. Ultimately, this review suggests an advanced control system based on membrane-foulant interactions under the impact of various operational parameters to mitigate the integrity loss of membranes.
Collapse
Affiliation(s)
- Imtiaz Afzal Khan
- Department of Civil and Environmental Engineering, Hanyang University, 222 Wangsimni-ro, Seongdong-gu, Seoul, 04763, Republic of Korea
| | - Jong-Oh Kim
- Department of Civil and Environmental Engineering, Hanyang University, 222 Wangsimni-ro, Seongdong-gu, Seoul, 04763, Republic of Korea.
| |
Collapse
|
4
|
Lv Z, Zhang S, Jiao W, Zuo X, Zhang Y, Liu Y. High-efficiency cleaning technology and lifespan prediction for the ceramic membrane treating secondary treated effluent. WATER SCIENCE AND TECHNOLOGY : A JOURNAL OF THE INTERNATIONAL ASSOCIATION ON WATER POLLUTION RESEARCH 2023; 88:321-338. [PMID: 37452550 PMCID: wst_2023_209 DOI: 10.2166/wst.2023.209] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 07/18/2023]
Abstract
Chemical cleaning is one of the key technical means to control membrane fouling, restore membrane flux and ensure the stable operation of membrane systems. In the experiment, the six most representative chemical cleaning agents for ceramic membranes, such as sulfuric acid (H2SO4), sodium hydroxide (NaOH), sodium hypochlorite (NaClO), ethylenediaminetetraacetic acid disodium salt (EDTA-Na2), sodium dodecyl sulfate (SDS) and nonylphenol polyoxyethylene ether (OP-10), were used as research objects. The cleaning effect of the two-step combined cleaning of chemical cleaning agents on the fouled membrane was systematically investigated. Results showed that the order of the chemical cleaning agent had a significant effect on the cleaning effect. The best chemical cleaning program was determined to be NaClO first and then SDS: the fouled ceramic membrane was soaked in NaClO solution at 0.15% for 2.5 h and further soaked in SDS solution at five times its own critical micelle concentration for 2.5 h. The predicted long-term lifespan of the ceramic membranes was 4.91 years. Scanning electron microscopy-energy spectrum analysis showed that the surface roughness of the cleaned ceramic membrane was slightly higher than that of the new membrane. The contact angle was slightly lower than that of the new membrane.
Collapse
Affiliation(s)
- Zongwei Lv
- School of Civil Engineering and Architecture, University of Jinan, Jinan 250022, China E-mail:
| | - Shoubin Zhang
- School of Civil Engineering and Architecture, University of Jinan, Jinan 250022, China
| | - Wenhai Jiao
- Jinan Municipal Engineering Design & Research Institute (Group) Co., Ltd, Jinan 250003, China
| | - Xinyi Zuo
- School of Civil Engineering and Architecture, University of Jinan, Jinan 250022, China
| | | | - Yutian Liu
- Jinan Municipal Engineering Design & Research Institute (Group) Co., Ltd, Jinan 250003, China
| |
Collapse
|
5
|
Zhang B, Fu T, Zhang Q, Wang X, Tang L, Wei Q, Li Y, Peng Y. Effects of Critical Operation and Cleaning Parameters on Performances and Economic Benefits of Biogas Slurry Concentration by Forward Osmosis Membrane. MEMBRANES 2023; 13:288. [PMID: 36984675 PMCID: PMC10051890 DOI: 10.3390/membranes13030288] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Figures] [Subscribe] [Scholar Register] [Received: 01/05/2023] [Revised: 02/06/2023] [Accepted: 02/25/2023] [Indexed: 06/18/2023]
Abstract
Forward osmosis membrane technology (FO) shows potential application prospects in biogas slurry concentration, which is conducive to promoting the sustainable development of biogas projects. However, at present, the key influencing factors of membrane concentration using FO are not well understood. Therefore, this study analyzed the influence of draw solution concentration, pH, temperature and cross-flow velocity on the concentration efficiency of FO membrane, and optimized the operation parameters of FO membrane. The results showed that the concentration effect of the NaCl draw solution at pH 5 or 9 was better than that at pH 7. The order of factor influencing the water flux was as follows: draw liquid concentration > cross-flow velocity > operating temperature. The optimal combination obtained by orthogonal analysis was under 45 °C, with a cross-flow velocity of 1 L/min and the use of 1.5 mol/L NaCl as draw solution. The results of the membrane cleaning implied that the recovery rate of the fouled membrane after acid-base cleaning is significantly higher (88%) than other cleaning solutions. This research offers a scientific reference for applying positive osmosis technology to re-utilize biogas slurry resources.
Collapse
Affiliation(s)
- Bangxi Zhang
- Institute of Agricultural Resources and Environment, Guizhou Academy of Agricultural Sciences, Guiyang 550006, China
| | - Tianhong Fu
- School of Pharmacy, Zunyi Medical University, Zunyi 563006, China
| | - Qinyu Zhang
- Institute of Agricultural Resources and Environment, Guizhou Academy of Agricultural Sciences, Guiyang 550006, China
| | - Xiaomin Wang
- Institute of Agricultural Resources and Environment, Guizhou Academy of Agricultural Sciences, Guiyang 550006, China
| | - Ling Tang
- Institute of Agricultural Resources and Environment, Guizhou Academy of Agricultural Sciences, Guiyang 550006, China
| | - Quanquan Wei
- Institute of Agricultural Resources and Environment, Guizhou Academy of Agricultural Sciences, Guiyang 550006, China
| | - Yun Li
- College of Resource and Environment, Qingdao Agricultural University, Qingdao 266109, China
| | - Yutao Peng
- School of Agriculture, Sun Yat-Sen University, Shenzhen 518107, China
| |
Collapse
|
6
|
Xu L, Wang H, Min L, Xu W, Zhang W. Poly (aryl piperidinium) Anion Exchange Membranes for Acid Recovery: The Effect of Backbone Structure. Sep Purif Technol 2023. [DOI: 10.1016/j.seppur.2023.123396] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/13/2023]
|
7
|
Nikoonahad A, Gholizadeh A, Ghaneian MT, Paseban A, Naimi N, Ghorbanian M, Taghavi M, Mohammadi A, Abdolahnejad A, Moradi B. Evaluation of a novel integrated membrane biological aerated filter for water reclamation: A practical experience. CHEMOSPHERE 2022; 303:134916. [PMID: 35597458 DOI: 10.1016/j.chemosphere.2022.134916] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/10/2021] [Revised: 03/07/2022] [Accepted: 05/07/2022] [Indexed: 06/15/2023]
Abstract
The use of treated wastewater in addition to solving the problem of water shortage, can increase soil fertility and reduce the use of chemical fertilizers. We aim to provide a high-quality effluent to feed membrane system, reduce treatment costs and enhance the efficiency of wastewater recycling. All experiments were conducted on a novel integrated membrane biological aerated filter (IMBAF) consisting of a down flow cylindrical biological aerated filter (BAF) filled by silica and a novel sand-coated polystyrene granules (SCP), followed by ultrafiltration (UF) and reverse osmosis (RO) membranes. IMBAF reactor, with 73.6 L volume, was operated for 270 days (in three 90-day stages) with different conditions of returning backwash water. Accordingly, BAF generated high quality water for feeding UF membrane with 94.2%, 68%, 54.4%, 91.2%, and 99.95% of turbidity, 5-day biochemical oxygen demand (BOD5), chemical oxygen demand (COD), oil and grease (O&G), fecal coliform (FC) removal, respectively. At the end of stage 3, 99.88% of influent was recycled by UF and only 0.12% was disposed of as sludge. The BAF and UF module efficiently promote the quality of water entering RO system. After 75 days of continuous operation, the increase in trans-membrane pressure (TMP) and also decrease in RO membrane permeability were about 14% and 9.4%, respectively, indicating low clogging of the membrane. The use of BAF structure designed in this study increases the wastewater recycling rate, decreases membrane clogging and thereby reduces the costs of concentrate disposal and chemical cleaning.
Collapse
Affiliation(s)
- Ali Nikoonahad
- Department of Environmental Health Engineering, School of Public Health, Ilam University of Medical Sciences, Ilam, Iran
| | - Abdolmajid Gholizadeh
- Department of Environmental Health Engineering, Torbat Heydariyeh University of Medical Sciences, Torbat Heydariyeh, Iran.
| | - Mohammad Taghi Ghaneian
- Environmental Science and Technology Research Center, Department of Environmental Health Engineering, School of Public Health, Shahid Sadoughi University of Medical Sciences, Yazd, Iran
| | - Ali Paseban
- Department of Environmental Health Engineering, School of Public Health, North Khorasan University of Medical Sciences, Bojnurd, Iran
| | - Nayera Naimi
- Department of Environmental Health Engineering, School of Public Health, North Khorasan University of Medical Sciences, Bojnurd, Iran; Student Research Committee, Department of Environmental Health Engineering, School of Health, Mashhad University of Medical Sciences, Mashhad, Iran
| | - Mahdi Ghorbanian
- Department of Environmental Health Engineering, School of Public Health, North Khorasan University of Medical Sciences, Bojnurd, Iran
| | - Mahmoud Taghavi
- Department of Environmental Health Engineering, School of Public Health, Social Development & Health Promotion Research Center, Gonabad University of Medical Sciences, Gonabad, Iran
| | - Amir Mohammadi
- Department of Environmental Health Engineering, Maragheh University of Medical Sciences, Maragheh, Iran
| | - Ali Abdolahnejad
- Department of Environmental Health Engineering, Maragheh University of Medical Sciences, Maragheh, Iran
| | - Bagher Moradi
- Esfarayen Faculty of Medical Science, Esfarayen, Iran
| |
Collapse
|
8
|
Can the NF membrane directly obtained by the interfacial polymerization of MPD and TMC? J Memb Sci 2022. [DOI: 10.1016/j.memsci.2022.120618] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/17/2022]
|
9
|
Resource Utilization of Acid Mine Drainage (AMD): A Review. WATER 2022. [DOI: 10.3390/w14152385] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/10/2022]
Abstract
Acid mine drainage (AMD) is a typical type of pollution originating from complex oxidation interactions that occur under ambient conditions in abandoned and active mines. AMD has high acidity and contains a high concentration of heavy metals and metalloids, posing a serious threat to ecological systems and human health. Over the years, great progress has been made in the prevention and treatment of AMD. Remediation approaches like chemical neutralization precipitation, ion exchange, membrane separation processes, and bioremediation have been extensively reported. Nevertheless, some limitations, such as low efficacy, excessive consumption of chemical reagents, and secondary contamination restrict the application of these technologies. The aim of this review was to provide updated information on the sustainable treatments that have been engaged in the published literature on the resource utilization of AMD. The recovery and reuse of valuable resources (e.g., clean water, sulfuric acid, and metal ions) from AMD can offset the cost of AMD remediation. Iron oxide particles recovered from AMD can be applied as adsorbents for the removal of pollutants from wastewater and for the fabrication of effective catalysts for heterogeneous Fenton reactions. The application of AMD in beneficiation fields, such as activating pyrite and chalcopyrite flotation, regulating pulp pH, and leaching copper-bearing waste rock, provides easy access to the innovative utilization of AMD. A review such as this will help researchers understand the progress in research, and identify the strengths and weaknesses of each treatment technology, which can help shape the direction of future research in this area.
Collapse
|
10
|
Cao Y, Wan Y, Chen C, Luo J. Preparation of acid-resistant nanofiltration membrane with dually charged separation layer for enhanced salts removal. Sep Purif Technol 2022. [DOI: 10.1016/j.seppur.2022.120974] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/25/2022]
|
11
|
Li LQ, Liu XH, Tang YJ, Xu ZL. How Does Alkali Etching Work on the Polyamide Membrane to Obtain an m-Phenylenediamine-Based NF Membrane? Ind Eng Chem Res 2022. [DOI: 10.1021/acs.iecr.2c00758] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/29/2022]
Affiliation(s)
- Lan-Qian Li
- State Key Laboratory of Chemical Engineering, Membrane Science and Engineering R&D Lab, Chemical Engineering Research Center, School of Chemical Engineering, East China University of Science and Technology, 130 Meilong Road, Shanghai 200237, China
| | - Xu-Hong Liu
- Shanghai Sep-Bio Technology and Engineering Co., Ltd., 1288 Luoning Road, Shanghai 200949, China
| | - Yong-Jian Tang
- State Key Laboratory of Chemical Engineering, Membrane Science and Engineering R&D Lab, Chemical Engineering Research Center, School of Chemical Engineering, East China University of Science and Technology, 130 Meilong Road, Shanghai 200237, China
| | - Zhen-Liang Xu
- State Key Laboratory of Chemical Engineering, Membrane Science and Engineering R&D Lab, Chemical Engineering Research Center, School of Chemical Engineering, East China University of Science and Technology, 130 Meilong Road, Shanghai 200237, China
| |
Collapse
|
12
|
Güneş E, Gönder ZB. Evaluation of the hybrid system combining electrocoagulation, nanofiltration and reverse osmosis for biologically treated textile effluent: Treatment efficiency and membrane fouling. JOURNAL OF ENVIRONMENTAL MANAGEMENT 2021; 294:113042. [PMID: 34126531 DOI: 10.1016/j.jenvman.2021.113042] [Citation(s) in RCA: 10] [Impact Index Per Article: 3.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/24/2021] [Revised: 05/14/2021] [Accepted: 06/06/2021] [Indexed: 06/12/2023]
Abstract
The efficiency of the hybrid electrocoagulation-nanofiltration-reverse osmosis (EC-NF-RO) system for the treatment of biologically treated textile effluent was investigated. The treatment performances and membrane fouling behaviours of nanofiltration (NF) and hybrid EC-NF systems were compared. EC process was evaluated concerning mitigate the membrane fouling and increasing the removal efficiencies. Besides, the treated wastewater with the hybrid EC-NF process was finally processed using RO process for reuse purpose in the textile industry. The EC treatment was applied using Fe and Al electrodes at various conditions; pH:4-10, current density:0.5-17 mA/cm2 and operating time:30-180 min. Fe electrode showed better performance in terms of higher removal efficiencies (76% COD, 96% DFZ436), lower energy (21.1 kWh/m3) and electrode consumptions (3.7 kg/m3) for the optimum conditions. Scanning Electron Microscopy-Energy Dispersive Index (ESEM-EDX) and Fourier-Transform Infrared Spectroscopy (FTIR) analyses were carried out for EC sludge samples obtained with Fe and Al electrodes. Desal 5 DL and NF 270 membranes were tested in terms of removal efficiency and membrane fouling for NF and hybrid EC-NF process of textile wastewater. Membrane fouling was evaluated with flux values, resistance-in-series model results as well as Atomic Force Microscopy (AFM), FTIR and contact angle measurements. NF 270 membrane achieved better chloride (28%) and conductivity (41%) removal efficiencies for NF treatment. EC pretreatment did not result in any noticeable improvement in rejections except for chloride (48%) and conductivity (59%) for the hybrid EC-NF process with NF 270. The ratios of Rc decreased to 40% for NF 270 and 42% for Desal 5DL after EC pretreatment. NF270 membrane indicated high permeate flux and low membrane fouling considering cake resistance distribution, surface roughness, hydrophilicity and chemical structure variation. >93% COD, 99% conductivity, 97% chloride, and 91% TDS removal efficiencies were obtained with the hybrid EC-NF-RO process. Finally, the obtained high quality water by RO after the EC + NF 270 hybrid process could be used for all textile finishing process.
Collapse
Affiliation(s)
- Eda Güneş
- Istanbul University-Cerrahpaşa, Faculty of Engineering, Department of Environmental Engineering, Avcilar Campus, Avcilar, 34320, Istanbul, Turkey
| | - Z Beril Gönder
- Istanbul University-Cerrahpaşa, Faculty of Engineering, Department of Environmental Engineering, Avcilar Campus, Avcilar, 34320, Istanbul, Turkey.
| |
Collapse
|
13
|
Nguyen MN, Trinh PB, Burkhardt CJ, Schäfer AI. Incorporation of single-walled carbon nanotubes in ultrafiltration support structure for the removal of steroid hormone micropollutants. Sep Purif Technol 2021. [DOI: 10.1016/j.seppur.2021.118405] [Citation(s) in RCA: 9] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/26/2023]
|
14
|
S E, G A, A F I, P S G, Y LT. Review on characteristics of biomaterial and nanomaterials based polymeric nanocomposite membranes for seawater treatment application. ENVIRONMENTAL RESEARCH 2021; 197:111177. [PMID: 33864792 DOI: 10.1016/j.envres.2021.111177] [Citation(s) in RCA: 4] [Impact Index Per Article: 1.3] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 01/21/2021] [Revised: 03/17/2021] [Accepted: 04/08/2021] [Indexed: 06/12/2023]
Abstract
Membrane technology, especially nanofiltration (NF) has great attention to provide an imperative solution for water issues. The membrane is considered to be the heart in the separation plant. Understanding the membrane characteristics could allow predicting and optimizing the membrane performance namely flux, rejection and reduced fouling. The membrane development using biomaterials and nanomaterials provides a remarkable opportunity in the water application. This review focuses on the membrane characteristics of biomaterials and nanomaterials based nanofiltration. In this review, recent researches based on biomaterials and nanomaterials loaded membrane for salt rejection have been analyzed. Membrane fouling depends on the membrane characteristics and this review defined fouling as a ubiquitous bottleneck challenge that hampers the NF blooming applications. Fouling mitigation strategies via membrane modification using biomaterial (chitosan, curcumin and vanillin) and various other nanomaterials are critically reviewed. This review also highlights the membrane cleaning and focuses on concentrates disposal methods with zero liquid discharge system for resource recovery. Finally, the conclusion and future prospects of membrane technology are discussed. From this current review, it is apparent that the biomaterial and various other nanomaterials acquire exclusive properties that facilitate membrane advancement with improved capability for water treatment. Regardless of membrane material developments, still exist considerable difficulties in membrane commercialization. Thus, additional studies related to this field are needed to produce membranes with better performance for large‒scale applications.
Collapse
Affiliation(s)
- Elakkiya S
- Membrane Research Laboratory, Department of Chemical Engineering, National Institute of Technology, Tiruchirappalli, 620015, Tamil Nadu, India
| | - Arthanareeswaran G
- Membrane Research Laboratory, Department of Chemical Engineering, National Institute of Technology, Tiruchirappalli, 620015, Tamil Nadu, India.
| | - Ismail A F
- Advanced Membrane Technology Research Centre (AMTEC), Universiti Teknologi Malaysia, 81310, Skudai, Johor, Malaysia.
| | - Goh P S
- Advanced Membrane Technology Research Centre (AMTEC), Universiti Teknologi Malaysia, 81310, Skudai, Johor, Malaysia
| | - Lukka Thuyavan Y
- Advanced Membrane Technology Research Centre (AMTEC), Universiti Teknologi Malaysia, 81310, Skudai, Johor, Malaysia
| |
Collapse
|
15
|
Active Treatment of Contaminants of Emerging Concern in Cold Mine Water Using Advanced Oxidation and Membrane-Related Processes: A Review. MINERALS 2021. [DOI: 10.3390/min11030259] [Citation(s) in RCA: 5] [Impact Index Per Article: 1.7] [Reference Citation Analysis] [Abstract] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 01/07/2023]
Abstract
Responsible use and effective treatment of mine water are prerequisites of sustainable mining. The behavior of contaminants in mine water evolves in relation to the metastable characteristics of some species, changes related to the mine life cycle, and mixing processes at various scales. In cold climates, water treatment requires adaptation to site-specific conditions, including high flow rates, salinity, low temperatures, remoteness, and sensitivity of receiving waterbodies. Contaminants of emerging concern (CECs) represent a newer issue in mine water treatment. This paper reviews recent research on the challenges and opportunities related to CECs in mine water treatment, with a focus on advanced oxidation and membrane-based processes on mine sites operating in cold climates. Finally, the paper identifies research needs in mine water treatment.
Collapse
|
16
|
Maalige R N, Aruchamy K, Polishetti V, Halakarni M, Mahto A, Mondal D, Sanna Kotrappanavar N. Restructuring thin film composite membrane interfaces using biopolymer as a sustainable alternative to prevent organic fouling. Carbohydr Polym 2021; 254:117297. [PMID: 33357865 DOI: 10.1016/j.carbpol.2020.117297] [Citation(s) in RCA: 3] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/15/2020] [Revised: 10/06/2020] [Accepted: 10/19/2020] [Indexed: 10/23/2022]
Abstract
Replacing polyamide (PA) layer in commercially successful thin film composite (TFC) membranes prepared via interfacial polymerization has been challenging task. Lately, PA is under scrutiny due to its increasing fouling propensity for highly contaminated waters. To mitigate the bio and organic fouling on PA layer in nanofiltration (NF) membranes in a long run, present study attempts to create a new interfacial thin film asymmetric structure using biopolymer chitosan as sustainable alternative. Herein, the effect of chitosan-silver on porous support structure and filtration performance were systematically investigated. Further, the membranes were characterized for their functionality and surface characteristics using ATR-IR, FESEM, AFM, UV-vis spectroscopy and contact angle measurements, respectively. New asymmetric membrane performances in cross flow process were evaluated in terms of pure water flux, NaCl (∼40 %), red brown/organic dye (>98 %) and tannery wastewater flux and rejection (>98 %). With a higher pure water flux (>100 L m-2 h-1) compared to control (40 L m-2 h-1) at 4 bar, membrane showed exceptional antifouling behaviors in comparison to commercial PA membrane. Further, surface characteristics of the membranes before and after rigorous testing were evaluated using AFM micrographs and SEM imaging.
Collapse
Affiliation(s)
- Nidhi Maalige R
- Centre for Nano and Material Sciences, Jain University, Jain Global Campus, Kanakapura, Ramanagara, Bangalore, 562112, India
| | - Kanakaraj Aruchamy
- Centre for Nano and Material Sciences, Jain University, Jain Global Campus, Kanakapura, Ramanagara, Bangalore, 562112, India
| | - Veerababu Polishetti
- CSIR-Central Salt and Marine Chemicals Research Institute (CSIR-CSMCRI), B.G. Marg, Bhavnagar, 364002, India
| | - Mahaveer Halakarni
- Centre for Nano and Material Sciences, Jain University, Jain Global Campus, Kanakapura, Ramanagara, Bangalore, 562112, India
| | - Ashesh Mahto
- Centre for Nano and Material Sciences, Jain University, Jain Global Campus, Kanakapura, Ramanagara, Bangalore, 562112, India
| | - Dibyendu Mondal
- Centre for Nano and Material Sciences, Jain University, Jain Global Campus, Kanakapura, Ramanagara, Bangalore, 562112, India.
| | - Nataraj Sanna Kotrappanavar
- Centre for Nano and Material Sciences, Jain University, Jain Global Campus, Kanakapura, Ramanagara, Bangalore, 562112, India; IMDEA Water Institute, Avenida Punto Com, 2, Parque Cientıfco Tecnoĺogico de la Universidad de Alcala, Alcal ́a de Henares, 28805, Madrid, Spain.
| |
Collapse
|
17
|
A New Method for a Polyethersulfone-Based Dopamine-Graphene (xGnP-DA/PES) Nanocomposite Membrane in Low/Ultra-Low Pressure Reverse Osmosis (L/ULPRO) Desalination. MEMBRANES 2020; 10:membranes10120439. [PMID: 33352893 PMCID: PMC7766060 DOI: 10.3390/membranes10120439] [Citation(s) in RCA: 3] [Impact Index Per Article: 0.8] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 10/22/2020] [Revised: 11/30/2020] [Accepted: 12/05/2020] [Indexed: 11/16/2022]
Abstract
Herein we present a two-stage phase inversion method for the preparation of nanocomposite membranes for application in ultra-low-pressure reverse osmosis (ULPRO). The membranes containing DA-stabilized xGnP (xGnP-DA-) were then prepared via dry phase inversion at room temperature, varying the drying time, followed by quenching in water. The membranes were characterized for chemical changes utilizing attenuated total reflectance-Fourier transform infrared spectroscopy (ATR-FTIR) and X-ray photoelectron spectroscopy (XPS). The results indicated the presence of new chemical species and thus, the inclusion of xGnP-DA in the polyethersulfone (PES) membrane matrix. Atomic force microscopy (AFM) showed increasing surface roughness (Ra) with increased drying time. Scanning electron microscopy (SEM) revealed the cross-sectional morphology of the membranes. Water uptake, porosity and pore size were observed to decrease due to this new synthetic approach. Salt rejection using simulated seawater (containing Na, K, Ca, and Mg salts) was found to be up to stable at <99.99% between 1–8 bars operating pressure. After ten fouling and cleaning cycles, flux recoveries of <99.5% were recorded, while the salt rejection was <99.95%. As such, ULPRO membranes can be successfully prepared through altered phase inversion and used for successful desalination of seawater.
Collapse
|
18
|
Molybdenum sulphide modified chelating resin for toxic metal adsorption from acid mine wastewater. Sep Purif Technol 2020. [DOI: 10.1016/j.seppur.2020.117407] [Citation(s) in RCA: 26] [Impact Index Per Article: 6.5] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 02/03/2023]
|
19
|
Arabi S, Pellegrin ML, Aguinaldo J, Sadler ME, McCandless R, Sadreddini S, Wong J, Burbano MS, Koduri S, Abella K, Moskal J, Alimoradi S, Azimi Y, Dow A, Tootchi L, Kinser K, Kaushik V, Saldanha V. Membrane processes. WATER ENVIRONMENT RESEARCH : A RESEARCH PUBLICATION OF THE WATER ENVIRONMENT FEDERATION 2020; 92:1447-1498. [PMID: 32602987 DOI: 10.1002/wer.1385] [Citation(s) in RCA: 2] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 06/02/2020] [Accepted: 06/20/2020] [Indexed: 06/11/2023]
Abstract
This literature review provides a review for publications in 2018 and 2019 and includes information membrane processes findings for municipal and industrial applications. This review is a subsection of the annual Water Environment Federation literature review for Treatment Systems section. The following topics are covered in this literature review: industrial wastewater and membrane. Bioreactor (MBR) configuration, membrane fouling, design, reuse, nutrient removal, operation, anaerobic membrane systems, microconstituents removal, membrane technology advances, and modeling. Other sub-sections of the Treatment Systems section that might relate to this literature review include the following: Biological Fixed-Film Systems, Activated Sludge, and Other Aerobic Suspended Culture Processes, Anaerobic Processes, and Water Reclamation and Reuse. This publication might also have related information on membrane processes: Industrial Wastes, Hazardous Wastes, and Fate and Effects of Pollutants.
Collapse
Affiliation(s)
| | | | | | | | | | | | - Joseph Wong
- Brown and Caldwell, Walnut Creek, California, USA
| | | | | | | | - Jeff Moskal
- Suez Water Technologies & Solutions, Oakville, ON, Canada
| | | | | | - Andrew Dow
- Donohue and Associates, Chicago, Illinois, USA
| | | | | | | | | |
Collapse
|
20
|
Huang J, Luo J, Chen X, Feng S, Wan Y. How Do Chemical Cleaning Agents Act on Polyamide Nanofiltration Membrane and Fouling Layer? Ind Eng Chem Res 2020. [DOI: 10.1021/acs.iecr.0c03365] [Citation(s) in RCA: 40] [Impact Index Per Article: 10.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 01/20/2023]
Affiliation(s)
- Jiachen Huang
- State Key Laboratory of Biochemical Engineering, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, P. R. China
- School of Chemical Engineering, University of Chinese Academy of Sciences, Beijing 100049, P. R. China
| | - Jianquan Luo
- State Key Laboratory of Biochemical Engineering, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, P. R. China
- School of Chemical Engineering, University of Chinese Academy of Sciences, Beijing 100049, P. R. China
| | - Xiangrong Chen
- State Key Laboratory of Biochemical Engineering, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, P. R. China
- School of Chemical Engineering, University of Chinese Academy of Sciences, Beijing 100049, P. R. China
| | - Shichao Feng
- State Key Laboratory of Biochemical Engineering, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, P. R. China
- School of Chemical Engineering, University of Chinese Academy of Sciences, Beijing 100049, P. R. China
| | - Yinhua Wan
- State Key Laboratory of Biochemical Engineering, Institute of Process Engineering, Chinese Academy of Sciences, Beijing 100190, P. R. China
- School of Chemical Engineering, University of Chinese Academy of Sciences, Beijing 100049, P. R. China
| |
Collapse
|
21
|
Cui K, Li P, Zhang R, Cao B. Preparation of pervaporation membranes by interfacial polymerization for acid wastewater purification. Chem Eng Res Des 2020. [DOI: 10.1016/j.cherd.2020.01.022] [Citation(s) in RCA: 15] [Impact Index Per Article: 3.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/25/2022]
|
22
|
oulad F, Zinadini S, Zinatizadeh AA, Derakhshan AA. Novel (4,4-diaminodiphenyl sulfone coupling modified PES/PES) mixed matrix nanofiltration membranes with high permeability and anti-fouling property. Sep Purif Technol 2020. [DOI: 10.1016/j.seppur.2019.116292] [Citation(s) in RCA: 9] [Impact Index Per Article: 2.3] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/17/2022]
|
23
|
Grossi LB, Alvim CB, Alvares CM, Martins MF, Amaral MC. Purifying surface water contaminated with industrial failure using direct contact membrane distillation. Sep Purif Technol 2020. [DOI: 10.1016/j.seppur.2019.116052] [Citation(s) in RCA: 20] [Impact Index Per Article: 5.0] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/16/2022]
|
24
|
|
25
|
Amaya-Vías D, Tataru L, Herce-Sesa B, López-López JA, López-Ramírez JA. Metals removal from acid mine drainage (Tinto River, SW Spain) by water gap and air gap membrane distillation. J Memb Sci 2019. [DOI: 10.1016/j.memsci.2019.03.081] [Citation(s) in RCA: 14] [Impact Index Per Article: 2.8] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 10/27/2022]
|
26
|
Evaluation of the effect of body fluid analogs on the parameters of nanofiltration during the purification of swimming pool water. SN APPLIED SCIENCES 2019. [DOI: 10.1007/s42452-019-0568-3] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.2] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 12/30/2022] Open
|
27
|
Naidu G, Ryu S, Thiruvenkatachari R, Choi Y, Jeong S, Vigneswaran S. A critical review on remediation, reuse, and resource recovery from acid mine drainage. ENVIRONMENTAL POLLUTION (BARKING, ESSEX : 1987) 2019; 247:1110-1124. [PMID: 30823340 DOI: 10.1016/j.envpol.2019.01.085] [Citation(s) in RCA: 152] [Impact Index Per Article: 30.4] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 11/22/2018] [Revised: 01/06/2019] [Accepted: 01/17/2019] [Indexed: 05/28/2023]
Abstract
Acid mine drainage (AMD) is a global environmental issue. Conventionally, a number of active and passive remediation approaches are applied to treat and manage AMD. Case studies on remediation approaches applied in actual mining sites such as lime neutralization, bioremediation, wetlands and permeable reactive barriers provide an outlook on actual long-term implications of AMD remediation. Hence, in spite of available remediation approaches, AMD treatment remains a challenge. The need for sustainable AMD treatment approaches has led to much focus on water reuse and resource recovery. This review underscores (i) characteristics and implication of AMD, (ii) remediation approaches in mining sites, (iii) alternative treatment technologies for water reuse, and (iv) resource recovery. Specifically, the role of membrane processes and alternative treatment technologies to produce water for reuse from AMD is highlighted. Although membrane processes are favorable for water reuse, they cannot achieve resource recovery, specifically selective valuable metal recovery. The approach of integrated membrane and conventional treatment processes are especially promising for attaining both water reuse and recovery of resources such as sulfuric acid, metals and rare earth elements. Overall, this review provides insights in establishing reuse and resource recovery as the holistic approach towards sustainable AMD treatment. Finally, integrated technologies that deserve in depth future exploration is highlighted.
Collapse
Affiliation(s)
- Gayathri Naidu
- Faculty of Engineering, University of Technology Sydney (UTS), P.O. Box 123, Broadway, NSW, 2007, Australia
| | - Seongchul Ryu
- Faculty of Engineering, University of Technology Sydney (UTS), P.O. Box 123, Broadway, NSW, 2007, Australia
| | - Ramesh Thiruvenkatachari
- Commonwealth Scientific and Industrial Research Organisation (CSIRO), 1 Technology Court, Pullenvale, Queensland, 4069, Australia
| | - Youngkwon Choi
- Faculty of Engineering, University of Technology Sydney (UTS), P.O. Box 123, Broadway, NSW, 2007, Australia
| | - Sanghyun Jeong
- Graduate School of Water Resources, Sungkyunkwan University (SKKU), 2066 Seobu-ro, Jangan-gu, Suwon-si, Gyeonggi-do, 16419, Republic of Korea
| | - Saravanamuthu Vigneswaran
- Faculty of Engineering, University of Technology Sydney (UTS), P.O. Box 123, Broadway, NSW, 2007, Australia.
| |
Collapse
|
28
|
Van Goethem C, Mertens M, Vankelecom IF. Crosslinked PVDF membranes for aqueous and extreme pH nanofiltration. J Memb Sci 2019. [DOI: 10.1016/j.memsci.2018.11.036] [Citation(s) in RCA: 38] [Impact Index Per Article: 7.6] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/28/2022]
|
29
|
Wei X, Xu X, Wu J, Li C, Chen J, Lv B, Zhu B, Xiang H. SiO2
-modified nanocomposite nanofiltration membranes with high flux and acid resistance. J Appl Polym Sci 2019. [DOI: 10.1002/app.47436] [Citation(s) in RCA: 12] [Impact Index Per Article: 2.4] [Reference Citation Analysis] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/09/2022]
Affiliation(s)
- Xiuzhen Wei
- College of Environment; Zhejiang University of Technology; Hangzhou 310014 China
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province; China
| | - Xufeng Xu
- College of Environment; Zhejiang University of Technology; Hangzhou 310014 China
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province; China
| | - Jiawei Wu
- College of Environment; Zhejiang University of Technology; Hangzhou 310014 China
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province; China
| | - Cuixia Li
- College of Environment; Zhejiang University of Technology; Hangzhou 310014 China
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province; China
| | - Jinyuan Chen
- College of Environment; Zhejiang University of Technology; Hangzhou 310014 China
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province; China
| | - Bosheng Lv
- College of Environment; Zhejiang University of Technology; Hangzhou 310014 China
- Key Laboratory of Microbial Technology for Industrial Pollution Control of Zhejiang Province; China
| | - Baoku Zhu
- MOE Key Laboratory of Macromolecular Synthesis and Functionalization; Zhejiang University; China
| | - Hai Xiang
- College of Bioengineering; Zhejiang Chinese Medical University; Hangzhou 310053 China
| |
Collapse
|
30
|
Runtti H, Tolonen ET, Tuomikoski S, Luukkonen T, Lassi U. How to tackle the stringent sulfate removal requirements in mine water treatment-A review of potential methods. ENVIRONMENTAL RESEARCH 2018; 167:207-222. [PMID: 30053677 DOI: 10.1016/j.envres.2018.07.018] [Citation(s) in RCA: 34] [Impact Index Per Article: 5.7] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 03/06/2018] [Revised: 05/16/2018] [Accepted: 07/09/2018] [Indexed: 06/08/2023]
Abstract
Sulfate (SO42-) is a ubiquitous anion in natural waters. It is not considered toxic, but it may be detrimental to freshwater species at elevated concentrations. Mining activities are one significant source of anthropogenic sulfate into natural waters, mainly due to the exposure of sulfide mineral ores to weathering. There are several strategies for mitigating sulfate release, starting from preventing sulfate formation in the first place and ending at several end-of-pipe treatment options. Currently, the most widely used sulfate-removal process is precipitation as gypsum (CaSO4·2H2O). However, the lowest reachable concentration is theoretically 1500 mg L-1 SO42- due to gypsum's solubility. At the same time, several mines worldwide have significantly more stringent sulfate discharge limits. The purpose of this review is to examine the process options to reach low sulfate levels (< 1500 mg L-1) in mine effluents. Examples of such processes include alternative chemical precipitation methods, membrane technology, biological treatment, ion exchange, and adsorption. In addition, aqueous chemistry and current effluent standards concerning sulfate together with concentrate treatment and sulfur recovery are discussed.
Collapse
Affiliation(s)
- Hanna Runtti
- University of Oulu, Research Unit of Sustainable Chemistry, P.O Box 4300, FI-90014, Finland
| | - Emma-Tuulia Tolonen
- University of Oulu, Research Unit of Sustainable Chemistry, P.O Box 4300, FI-90014, Finland
| | - Sari Tuomikoski
- University of Oulu, Research Unit of Sustainable Chemistry, P.O Box 4300, FI-90014, Finland
| | - Tero Luukkonen
- University of Oulu, Fibre and Particle Engineering Research Unit, P.O. Box 4300, FI-90014, Finland.
| | - Ulla Lassi
- University of Oulu, Research Unit of Sustainable Chemistry, P.O Box 4300, FI-90014, Finland; University of Jyvaskyla, Kokkola University Consortium Chydenius, Unit of Applied Chemistry, Talonpojankatu 2B, FI-67100 Kokkola, Finland
| |
Collapse
|