Inhalation toxicity of benzalkonium chloride and triethylene glycol mixture in rats

Hygiene requirements for cleaning and disinfection of surfaces: recommendation of the Commission for Hospital Hygiene and Infection Prevention (KRINKO) at the Robert Koch Institute

This recommendation of the Commission for Hospital Hygiene and Infection Prevention (KRINKO) addresses not only hospitals, but also outpatient health care facilities and compiles current evidence. The following criteria are the basis for the indications for cleaning and disinfection: Infectious bioburden and tenacity of potential pathogens on surfaces and their transmission routes, influence of disinfecting surface cleaning on the rate of nosocomial infections, interruption of cross infections due to multidrug-resistant organisms, and outbreak control by disinfecting cleaning within bundles. The criteria for the selection of disinfectants are determined by the requirements for effectiveness, the efficacy spectrum, the compatibility for humans and the environment, as well as the risk potential for the development of tolerance and resistance. Detailed instructions on the organization and implementation of cleaning and disinfection measures, including structural and equipment requirements, serve as the basis for their implementation. Since the agents for surface disinfection and disinfecting surface cleaning have been classified as biocides in Europe since 2013, the regulatory consequences are explained. As possible addition to surface disinfection, probiotic cleaning, is pointed out. In an informative appendix (only in German), the pathogen characteristics for their acquisition of surfaces, such as tenacity, infectious dose and biofilm formation, and the toxicological and ecotoxicological characteristics of microbicidal agents as the basis for their selection are explained, and methods for the evaluation of the resulting quality of cleaning or disinfecting surface cleaning are presented.

Beneficial or harmful: Time-dependent hormesis induced by typical disinfectants and their mixtures with toxicological interaction

Disinfectants and their mixtures can induce hormesis. However, how the mixture hormesis is related to those of components and the interactions in disinfectant mixtures remain unclear. In this paper, the luminescence inhibition toxicities of chlorinated sodium phosphate (CSP), dodecyl dimethyl benzyl ammonium bromide (DOB), dodecyl dimethyl benzyl ammonium chloride (DOC), ethanol (EtOH), glutaraldehyde (GLA), hydrogen peroxide (H2O2), isopropyl alcohol (IPA), n-propanol (NPA), and 20 mixture rays in four mixture systems (EtOH-H2O2, DOB-H2O2, DOC-EtOH, and EtOH-IPA-NPA) containing at least one component showing hormesis to Vibrio qinghaiensis sp.-Q67 (Q67) were determined at 0.25, 3, 6, 9, and 12 h. The synergism-antagonism heatmap based on independent action model (noted as SAHmapIA) was developed to systematically evaluate the interactions in various mixtures. It was shown that five disinfectants (CSP, EtOH, H2O2, NPA, and IPA) and 17 mixture rays exhibited time-dependent hormesis. The hormetic component was responsible for the hormesis of the mixture rays. Most mixture rays showed low- concentration/dose additive action and high-concentration/dose synergism at different time. This study further exemplified the interrelationship between the hormesis in the mixtures and their components and implied the need to pay attention to the time-dependent hormesis and interactions induced by the disinfectants.

Pulmonary Toxicity Assessment after a Single Intratracheal Inhalation of Chlorhexidine Aerosol in Mice

Guanidine disinfectants are important chemical agents with a broad spectrum of activity that are effective against most microorganisms. Chlorhexidine, one of the most used guanidine disinfectants, is added to shampoo and mouthwash and applied in medical device sterilization. During the use of chlorhexidine, aerosols with micron particle size may be formed, which may cause inhalation toxicity. To assess the toxicity of inhaled chlorhexidine aerosol, mice underwent the intratracheal instillation of different concentrations of chlorhexidine (0, 0.125%, 0.25%, 0.5%, and 1%) using a MicroSprayer Aerosolizer. The mice were exposed for eight weeks and then sacrificed to obtain lung tissue for subsequent experiments. Histopathology staining revealed damaged lung tissues and increased collagen exudation. At the same time, pulmonary function tests showed that chlorhexidine exposure could cause restrictive ventilatory dysfunction, consistent with pulmonary fibrosis. The results of transcriptome analyses suggest that chlorhexidine may trigger an inflammatory response and promote the activation of pathways related to extracellular matrix deposition. Further, we identified that chlorhexidine exposure might enhance mucus secretion by up-regulating Muc5b and Muc5ac genes, thereby inducing fibrosis-like injury. These findings underscore the need for standardized use of disinfectants and the assessment of their inhalation toxicity.

Risks of benzalkonium chlorides as emerging contaminants in the environment and possible control strategies from the perspective of ecopharmacovigilance

An unprecedented increase in the use of disinfection products triggered by the coronavirus disease 2019 (COVID-19) pandemic is resulting in aggravating environmental loads of disinfectants as emerging contaminants, which has been considered a cause for worldwide secondary disasters. This review analyzed the literature published in the last decade about occurrence, bioaccumulation, and possible environmental risks of benzalkonium chlorides (BKCs) as emerging contaminants. Results indicated that BKCs globally occurred in municipal wastewater, surface water, groundwater, reclaimed water, sludge, sediment, soil, roof runoff, and residential dust samples across 13 countries. The maximum residual levels of 30 mg/L and 421 μg/g were reported in water and solid environmental samples, respectively. Emerging evidences suggested possible bioaccumulation of BKCs in plants, even perhaps humans. Environmentally relevant concentrations of BKCs exert potential adverse impacts on aquatic and terrestrial species, including genotoxicity, respiratory toxicity, behavioural effects and neurotoxicity, endocrine disruption and reproductive impairment, phytotoxicity, etc. Given the intrinsic biocidal and preservative properties of disinfectants, the inductive effects of residual BKCs in environment in terms of resistance and imbalance of microorganisms have been paid special attention. Considering the similarities of disinfectants to pharmaceuticals, from the perspective of ecopharmacovigilance (EPV), a well-established strategy for pharmaceutical emerging contaminants, we use the control of BKC pollution as a case, and provide some recommendations for employing the EPV measures to manage environmental risks posed by disinfectant emerging contaminants.

Bioaccumulation and in vivo fate of toxic benzylalkyldimethylammonium chloride in rats via the radiotracer analysis

Benzylalkyldimethylammonium chloride (BAC), a quaternary ammonium compound (QAC), is utilized in industrial and biomedical applications for antimicrobial purposes. Since the coronavirus disease (COVID-19) outbreak, various types of BAC-containing household chemicals have been produced. BACs have several adverse effects; however, their biological uptake, translocation, and excretion in animal models (essential for better understanding in vivo behavior and toxicological impact) remain unclear. In this study, we performed the first biodistribution and whole-body imaging studies of BAC in male Sprague Dawley rats, using two different administration routes. Quantitative whole-body autoradiography (QWBA) data obtained for intranasal 14C-labeled BAC ([14C]C12-BAC) exposure showed substantial uptake values for the respiratory organs (e.g. 346 ng g-1 of lung at 3 h post administration) and the radiotracer was transported to other internal organs. The amount of radiotracer in the heart, adrenal gland, and pancreas were 198, 1410, and 186 ng g-1 tissue respectively at 168 h following exposure. Autoradiograms obtained after intravenous injection also showed high accumulation and slow excretion in these organs. The cumulative excretion analysis revealed that approximately 6.4% of the administered radioactivity remained in rats after a week. The results indicated that continuous inhalation exposure to BAC leads to potential toxic effects in extrapulmonary organs and the respiratory tract. Thus, the radiolabeling method utilized may help assess various synthetic QACs in living subjects.

Adverse Outcome Pathway for Antimicrobial Quaternary Ammonium Compounds

Quaternary ammonium compounds (QACs) or quats are a large class of antimicrobial chemicals used in households and institutions as sanitizers and disinfectants. These chemicals are utilized as food processing sanitizers, algicides, in the process of water treatment, and preservatives in cosmetics. The aim of this study was to determine an Adverse Outcome Pathway (AOP) whereby two widely used QACs, alkyl dimethyl benzyl ammonium chloride (ADBAC) and didecyl dimethyl ammonium chloride (DDAC), may result in respiratory tract and gastrointestinal tract effects. When inhaled or ingested, these QACs are incorporated into the epithelial cell membrane at the point of contact. With sufficient dosage, the epithelial membrane is disrupted, reducing its fluidity, and releasing cellular contents. Further, ADBAC and DDAC might disrupt mitochondrial functions leading to decreased ATP production. Both events might lead to cell death, either attributed to direct lysis, necrosis, or apoptosis. Pro-inflammatory mediators are recruited to the tissue, inducing inflammation, edema, and excess mucus production. The primary tissue-level adverse outcome is epithelial degeneration and dysplasia. Most important, no apparent metabolism or distribution is involved in QAC action. Based upon this knowledge, it is suggested to replace default Uncertainty Factors for risk assessments with a set of Data Derived Extrapolation Factors.

Quaternary Ammonium Compounds: Bioaccumulation Potentials in Humans and Levels in Blood before and during the Covid-19 Pandemic

Quaternary ammonium compounds (QACs) are commonly used in a variety of consumer, pharmaceutical, and medical products. In this study, bioaccumulation potentials of 18 QACs with alkyl chain lengths of C8-C18 were determined in the in vitro-in vivo extrapolation (IVIVE) model using the results of human hepatic metabolism and serum protein binding experiments. The slowest in vivo clearance rates were estimated for C12-QACs, suggesting that these compounds may preferentially build up in blood. The bioaccumulation of QACs was further confirmed by the analysis of human blood (sera) samples (n = 222). Fifteen out of the 18 targeted QACs were detected in blood with the ΣQAC concentrations reaching up to 68.6 ng/mL. The blood samples were collected during two distinct time periods: before the outbreak of the COVID-19 pandemic (2019; n = 111) and during the pandemic (2020, n = 111). The ΣQAC concentrations were significantly higher in samples collected during the pandemic (median 6.04 ng/mL) than in those collected before (median 3.41 ng/mL). This is the first comprehensive study on the bioaccumulation and biomonitoring of the three major QAC groups and our results provide valuable information for future epidemiological, toxicological, and risk assessment studies targeting these chemicals.

Aerosolization Performance, Antitussive Effect and Local Toxicity of Naringenin-Hydroxypropyl-β-Cyclodextrin Inhalation Solution for Pulmonary Delivery

The aim of present study was to evaluate the feasibility of a naringenin-hydroxypropyl-β-cyclodextrin (naringenin-HPβCD) inhalation solution for pulmonary delivery. Naringenin, a flavanone derived from citrus fruits, has been proven to exhibit excellent peripheral antitussive effect. To address the limitation of its poor oral bioavailability and low local concentration in the lung, a naringenin-HPβCD inhalation solution was prepared for pulmonary delivery. The aerosolization performance of formulation was evaluated by next generation impactor (NGI). Both dose-dependent and time-dependent antitussive effects of naringenin-HPβCD inhalation solution on acute cough induced by citric acid in guinea pigs were investigated. In vitro toxicity of naringenin-HPβCD inhalation solution in pulmonary Calu-3 cells was evaluated by MTS assay, and in vivo local toxicity investigation was achieved by assessing bronchoalveolar lavage (BALF) and lung histology after a 7-day inhalation treatment in guinea pigs. Fine particle fraction (FPF) of the formulation was determined as 53.09%. After inhalation treatment of 15 min, naringenin-HPβCD inhalation solution within the studied range of 0.2-3.6 mg/kg could dose-dependently reduce the cough frequency with the antitussive rate of 29.42-39.42%. Naringenin-HPβCD inhalation solution in concentration range of 100-400 μM did not decrease cell viability of Calu-3 cells, and the maximum effective dose (3.6 mg/kg) was non-toxic during the short-term inhalation treatment for guinea pigs. In conclusion, naringenin-HPβCD inhalation solution was capable for nebulization and could provide rapid response with reduced dose for the treatment of cough.

A Review on the Fate of Legacy and Alternative Antimicrobials and Their Metabolites during Wastewater and Sludge Treatment

Antimicrobial compounds are used in a broad range of personal care, consumer and healthcare products and are frequently encountered in modern life. The use of these compounds is being reexamined as their safety, effectiveness and necessity are increasingly being questioned by regulators and consumers alike. Wastewater often contains significant amounts of these chemicals, much of which ends up being released into the environment as existing wastewater and sludge treatment processes are simply not designed to treat many of these contaminants. Furthermore, many biotic and abiotic processes during wastewater treatment can generate significant quantities of potentially toxic and persistent antimicrobial metabolites and byproducts, many of which may be even more concerning than their parent antimicrobials. This review article explores the occurrence and fate of two of the most common legacy antimicrobials, triclosan and triclocarban, their metabolites/byproducts during wastewater and sludge treatment and their potential impacts on the environment. This article also explores the fate and transformation of emerging alternative antimicrobials and addresses some of the growing concerns regarding these compounds. This is becoming increasingly important as consumers and regulators alike shift away from legacy antimicrobials to alternative chemicals which may have similar environmental and human health concerns.

Combined effects of BPA and PFOS on fetal cardiac development: In vitro and in vivo experiments

Analyses of the combined effects of different EDCs are both important and difficult. This study attempts to evaluate the individual and combined effects of BPA and PFOS on heart development. Sprague-Dawley rats received individual or combined PFOS and BPA for 19 days during pregnancy. The results show that the combined BPA and PFOS exposure could lead to a morphological change in the fetal rat heart. An increase in the interventricular septal thickness (IVS) of approximately 20 % (391 μm in control vs 464 μm in combined exposure) was observed in the fetal rat hearts after the combined exposure to nearly 2000 μg/L PFOS and 100 μg/L BPA through drinking water. The total collagen and dynamin-related protein 1 (Drp1) mRNA level was increased in the fetal hearts exposed to the combination of 2000 μg/L PFOS and 100 μg/L BPA. However, the cell number in the IVS did not significantly change. Based on the previous literature, we believe that the combined exposure to BPA and PFOS had a synergistic effect on the thickness of the IVS. The combined exposure to 40 μg/L PFOS and 2 μg/L BPA failed to cause significant damage to the embryonic heart. The individual and combined effects and the mechanism of the effects of BPA and PFOS on heart development were further investigated by an in vitro study. Embryonic stem cells were administered individual or combined 10 ng/mL BPA and 100 ng/mL PFOS for 14 days during the cardiac differentiation period. The results show that exposure to the combination of 100 ng/mL PFOS and 10 ng/mL BPA could increase the cardiomyocyte size and collagen content. A selective inhibitor of Drp1, Mdivi-1, could inhibit the cardiomyocyte size enlargement but not the collagen content increase caused by the combined exposure. Thus, we believe that although the combined exposure to PFOS and BPA could affect mitochondrial biogenesis and collagen expression, these two effects seem to be relatively independent. Based on these results, this research concludes that combined exposure to PFOS and BPA could specifically lead to increased collagen and IVS thickening in heart development.

Comprehensive pulmonary toxicity assessment of cetylpyridinium chloride using A549 cells and Sprague-Dawley rats

Cetylpyridinium chloride (CPC), a quaternary ammonium compound and cationic surfactant, is used in personal hygiene products such as toothpaste, mouthwash, and nasal spray. Although public exposure to CPC is frequent, its pulmonary toxicity has yet to be fully characterized. Due to high risks of CPC inhalation, we aimed to comprehensively elucidate the in vitro and in vivo toxicity of CPC. The results demonstrated that CPC is highly cytotoxic against the A549 cells with a half-maximal inhibitory concentration (IC₅₀ ) of 5.79 μg/ml. Following CPC exposure, via intratracheal instillation (ITI), leakage of lactate dehydrogenase, a biomarker of cell injury, was significantly increased in all exposure groups. Further, repeated exposure of rats to CPC for 28 days caused a decrease in body weight of the high-exposure group and the relative weights of the lungs and kidneys of the high recovery group, but no changes were evident in the histological and serum chemical analyses. The bronchoalveolar lavage fluid (BALF) analysis showed a significant increase in proinflammatory cytokines interleukin (IL)-6, IL-1β, and tumor necrosis factor (TNF)-α levels. ITI of CPC induced focal inflammation of the pulmonary parenchyma in rats' lungs. Our study demonstrated that TNF-α was the most commonly secreted proinflammatory cytokine during CPC exposure in both in vitro and in vivo models. Polymorphonuclear leukocytes in the BALF, which are indicators of pulmonary inflammation, significantly increased in a concentration-dependent manner in all in vivo studies including the ITI, acute, and subacute inhalation assays, demonstrating that PMNs are the most sensitive parameters of pulmonary toxicity.

Proteomic analysis of whole-body responses in medaka (Oryzias latipes) exposed to benzalkonium chloride

Benzalkonium chloride (BAC) is a cationic surfactant commonly used as a disinfectant, and is discharged into the aquatic environment by various water sources such as wastewater. BAC may also interact with potentially toxic substances such as persistent organic chemicals. Although studies of BAC contamination toxicity and bioaccumulation have been widely reported, the biochemical responses to BAC toxicity remain incompletely understood, and the detailed molecular mechanisms are largely unknown. In this study, two-dimensional gel electrophoresis (2-DE) and matrix-assisted laser desorption/ionization tandem time-of-flight mass spectrometry-based proteomic approaches were applied to investigate the protein profiles in Oryzias latipes (medaka) chronically exposed to BAC. Fish were exposed to three different concentrations of BAC, 0.05, 0.1, and 0.2 mg/L, for 21 days. A total of 20 proteins involved in the cytoskeleton, the oxidative stress response, the nervous and endocrine systems, signaling pathways, and cellular proteolysis were significantly upregulated by BAC exposure. The proteomic information obtained in the present study will be useful in identification of potential biomarkers for BAC toxicity, and begins to elucidate its molecular mechanisms, providing new insights into the ecotoxicity of BAC.

Concentration- and Time-Dependent Effects of Benzalkonium Chloride in Human Lung Epithelial Cells: Necrosis, Apoptosis, or Epithelial Mesenchymal Transition

Benzalkonium chloride (BAC), an antimicrobial agent in inhalable medications and household sprays, has been reported to be toxic to pulmonary organs. Although cell membrane damage has been considered as the main cytotoxic mechanism of BAC, its concentration- and time-dependent cellular effects on lung epithelium have not been fully understood. In the present study, human lung epithelial (H358) cells were exposed to 0.2–40 μg/mL of BAC for 30 min or 21 days. Cell membranes were rapidly disrupted by 30 min exposure, but 24 h incubation of BAC (4–40 μg/mL) predominantly caused apoptosis rather than necrosis. BAC (2–4 μg/mL) induced mitochondrial depolarization, which may be associated with increased expression of pro-apoptotic proteins (caspase-3, PARP, Bax, p53, and p21), and decreased levels of the anti-apoptotic protein Bcl-2. The protein expression levels of IRE1α, BiP, CHOP, and p-JNK were also elevated by BAC (2–4 μg/mL) suggesting the possible involvement of endoplasmic reticulum stress in inducing apoptosis. Long-term (7–21 days) incubation with BAC (0.2–0.6 μg/mL) did not affect cell viability but led to epithelial-mesenchymal transition (EMT) as shown by the decrease of E-cadherin and the increase of N-cadherin, fibronectin, and vimentin, caused by the upregulation of EMT transcription factors, such as Snail, Slug, Twist1, Zeb1, and Zeb2. Therefore, we conclude that apoptosis could be an important mechanism of acute BAC cytotoxicity in lung epithelial cells, and chronic exposure to BAC even at sub-lethal doses can promote pulmonary EMT.

Assessment of respiratory and systemic toxicity of Benzalkonium chloride following a 14-day inhalation study in rats

Background

Although biocides at low concentrations have been used to control pests, they can be more harmful than industrial chemicals as humans are directly and frequently exposed to such biocides. Benzalkonium chloride (BAC or BKC) is a non-toxic substance used to control pests. Recently, BAC has been increasingly used as a component in humidifier disinfectants in Korea, raising a serious health concern. Moreover, it poses significant health hazards to workers handling the chemical because of direct exposure. In the present study, we aimed to evaluate the respiratory toxicity of BAC due to its inhalation at exposure concentrations of 0.8 (T1 group), 4 (T2 group) and 20 (T3 group) mg/m³.

Results

In our previous study on the acute inhalational toxicity of BAC, bleeding from the nasal cavity was observed in all the rats after exposure to 50 mg/m³ BAC. Therefore, in this study, 20 mg/m³ was set as the highest exposure concentration, followed by 4 and 0.8 mg/m³ as the medium and low concentrations for 6 h/day and 14 days, respectively. After exposure, recovery periods of 2 and 4 weeks were provided. Additionally, alveolar lavage fluid was analyzed in males of the BAC-exposed groups at the end of exposure and 2 weeks after exposure to evaluate oxidative damage.

In the T3 group exposed to BAC, deep breathing, hoarseness, and nasal discharge were observed along with a decline in feed intake and body weight, and nasal discharge was also observed in the T1 and T2 groups. ROS/RNS, IL-1β, IL-6, and MIP-2 levels decreased in a concentration-dependent manner in the bronchoalveolar lavage fluid. Histopathological examination showed cellular changes in the nasal cavity and the lungs of the TI, T2, and T3 groups.

Conclusions

As a result, it was confirmed that the target organs in the respiratory system were the nasal cavity and the lungs. The adverse effects were evaluated as reversible responses to oxidative damage. Furthermore, the no observed adverse effect level was found to be less than 0.8 mg/m³ and the lowest benchmark dose was 0.0031 mg/m³. Accordingly, the derived no-effect level of BAC was calculated as 0.000062 mg/m³.