1
|
Yu L, An Z, Xie D, Yin D, Xie G, Gao X, Xiao Y, Liu J, Fang Z. From waste to protein: a new strategy of converting composted distilled grain wastes into animal feed. Front Microbiol 2024; 15:1405564. [PMID: 38881654 PMCID: PMC11176434 DOI: 10.3389/fmicb.2024.1405564] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 03/23/2024] [Accepted: 05/16/2024] [Indexed: 06/18/2024] Open
Abstract
Distilled grain waste (DGW) is rich in nutrients and can be a potential resource as animal feed. However, DGW contains as much as 14% lignin, dramatically reducing the feeding value. White-rot fungi such as Pleurotus ostreatus could preferentially degrade lignin with high efficiency. However, lignin derivatives generated during alcohol distillation inhibit P. ostreatus growth. Thus, finding a new strategy to adjust the DGW properties to facilitate P. ostreatus growth is critical for animal feed preparation and DGW recycling. In this study, three dominant indigenous bacteria, including Sphingobacterium thermophilum X1, Pseudoxanthomonas byssovorax X3, and Bacillus velezensis 15F were chosen to generate single and compound microbial inoculums for DGW composting to prepare substrates for P. ostreatus growth. Compared with non-inoculated control or single microbial inoculation, all composite inoculations, especially the three-microbial compound, led to faster organic metabolism, shorter composting process, and improved physicochemical properties of DGW. P. ostreatus growth assays showed the fastest mycelial colonization (20.43 μg·g-1 ergosterol) and extension (9 mm/d), the highest ligninolytic enzyme activities (Lac, 152.68 U·g-1; Lip, 15.56 U·g-1; MnP, 0.34 U·g-1; Xylanase, 10.98 U·g-1; FPase, 0.71 U·g-1), and the highest lignin degradation ratio (30.77%) in the DGW sample after 12 h of composting with the three-microbial compound inoculation when compared to other groups. This sample was relatively abundant in bacteria playing critical roles in amino acid, carbohydrate, energy metabolism, and xenobiotic biodegradation, as suggested by metagenomic analysis. The feed value analysis revealed that P. ostreatus mycelia full colonization in composted DGW led to high fiber content retention and decreased lignin content (final ratio of 5% lignin) but elevated protein concentrations (about 130 g·kg-1 DM). An additional daily weight gain of 0.4 kg/d was shown in cattle feeding experiments by replacing 60% of regular feed with it. These findings demonstrate that compound inoculant consisting of three indigenous microorganisms is efficient to compost DGW and facilitate P. ostreatus growth. P. ostreatus decreased the lignin content of composted DGW during its mycelial growth, improving the quality of DGW for feeding cattle.
Collapse
Affiliation(s)
- Lei Yu
- School of Life Sciences, Anhui University, Hefei, China
- Anhui Key Laboratory of Modern Biomanufacturing, Hefei, China
- Anhui Provincial Engineering Technology Research Center of Microorganisms and Biocatalysis, Hefei, China
| | - Zichao An
- School of Life Sciences, Anhui University, Hefei, China
- Anhui Key Laboratory of Modern Biomanufacturing, Hefei, China
- Anhui Provincial Engineering Technology Research Center of Microorganisms and Biocatalysis, Hefei, China
| | - Dengdeng Xie
- School of Life Sciences, Anhui University, Hefei, China
- Anhui Key Laboratory of Modern Biomanufacturing, Hefei, China
- Anhui Provincial Engineering Technology Research Center of Microorganisms and Biocatalysis, Hefei, China
| | - Diao Yin
- School of Life Sciences, Anhui University, Hefei, China
- Anhui Key Laboratory of Modern Biomanufacturing, Hefei, China
- Anhui Provincial Engineering Technology Research Center of Microorganisms and Biocatalysis, Hefei, China
| | - Guopai Xie
- Anhui Golden Seed Winery Co., Ltd., Fuyang, China
| | - Xuezhi Gao
- Anhui Golden Seed Winery Co., Ltd., Fuyang, China
| | - Yazhong Xiao
- School of Life Sciences, Anhui University, Hefei, China
- Anhui Key Laboratory of Modern Biomanufacturing, Hefei, China
- Anhui Provincial Engineering Technology Research Center of Microorganisms and Biocatalysis, Hefei, China
| | - Juanjuan Liu
- School of Life Sciences, Anhui University, Hefei, China
- Anhui Key Laboratory of Modern Biomanufacturing, Hefei, China
- Anhui Provincial Engineering Technology Research Center of Microorganisms and Biocatalysis, Hefei, China
| | - Zemin Fang
- School of Life Sciences, Anhui University, Hefei, China
- Anhui Key Laboratory of Modern Biomanufacturing, Hefei, China
- Anhui Provincial Engineering Technology Research Center of Microorganisms and Biocatalysis, Hefei, China
| |
Collapse
|
2
|
Sutaoney P, Rai SN, Sinha S, Choudhary R, Gupta AK, Singh SK, Banerjee P. Current perspective in research and industrial applications of microbial cellulases. Int J Biol Macromol 2024; 264:130639. [PMID: 38453122 DOI: 10.1016/j.ijbiomac.2024.130639] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 08/29/2023] [Revised: 01/12/2024] [Accepted: 03/03/2024] [Indexed: 03/09/2024]
Abstract
The natural interactions between various bacteria, fungi, and other cellulolytic microorganisms destroy lignocellulosic polymers. The efficacy of this process is determined by the combined action of three main enzymes: endoglucanases, exo-glucanases, and β-glucosidase. The enzyme attacks the polymeric structure's β-1,4-linkages during the cellulose breakdown reaction. This mechanism is crucial for the environment as it recycles cellulose in the biosphere. However, there are problems with enzymatic cellulose breakdown, including complex cellulase structure, insufficient degradation efficacy, high production costs, and post-translational alterations, many of which are closely related to certain unidentified cellulase properties. These issues impede the practical use of cellulases. A developing area of research is the application of this similar paradigm for industrial objectives. Cellulase enzyme exhibits greater promise in many critical industries, including biofuel manufacture, textile smoothing and finishing, paper and pulp manufacturing, and farming. However, the study on cellulolytic enzymes must move forward in various directions, including increasing the activity of cellulase as well as designing peptides to give biocatalysts their desired attributes. This manuscript includes an overview of current research on different sources of cellulases, their production, and biochemical characterization.
Collapse
Affiliation(s)
- Priya Sutaoney
- Present address-Department of Microbiology, Kalinga University, Raipur 492101, Chhattisgarh, India; Microbiology Laboratory, School of Studies in Life Science, Pt. Ravishankar Shukla University, Raipur 492010, Chhattisgarh, India
| | - Sachchida Nand Rai
- Centre of Experimental Medicine and Surgery, Institute of Medical Sciences, Banaras Hindu University, Varanasi 221005, India
| | - Sakshi Sinha
- Present address-Department of Microbiology, Kalinga University, Raipur 492101, Chhattisgarh, India
| | - Rachana Choudhary
- Department of Microbiology, Shri Shankaracharya Mahavidyalaya, Junwani, Durg 490005, Chhattisgarh, India
| | - A K Gupta
- Microbiology Laboratory, School of Studies in Life Science, Pt. Ravishankar Shukla University, Raipur 492010, Chhattisgarh, India
| | - Santosh Kumar Singh
- Centre of Experimental Medicine and Surgery, Institute of Medical Sciences, Banaras Hindu University, Varanasi 221005, India.
| | - Paromita Banerjee
- Department of Cardiology, All India Institute of Medical Sciences, Rishikesh, 249203, Uttarakhand, India.
| |
Collapse
|
3
|
Azhar S, Aihetasham A, Chaudhary A, Hussain Z, Abdul Rehman R, Abbas G, Alharbi SA, Ansari MJ, Qamer S. Cellulolytic and Ethanologenic Evaluation of Heterotermes indicola's Gut-Associated Bacterial Isolates. ACS OMEGA 2024; 9:12084-12100. [PMID: 38496968 PMCID: PMC10938596 DOI: 10.1021/acsomega.3c10030] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Grants] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 12/15/2023] [Revised: 02/09/2024] [Accepted: 02/19/2024] [Indexed: 03/19/2024]
Abstract
Cellulose is the basic component of lignocellulosic biomass (LCB) making it a suitable substrate for bioethanol fermentation. Cellulolytic and ethanologenic bacteria possess cellulases that convert cellulose to glucose, which in turn yields ethanol subsequently. Heterotermes indicola is a subterranean termite that causes destructive damage by consuming wooden structures of infrastructure, LCB products, etc. Prospectively, the study envisioned the screening of cellulolytic and ethanologenic bacteria from the termite gut. Twenty six bacterial strains (H1-H26) based on varied colonial morphologies were isolated. Bacterial cellulolytic activity was tested biochemically. Marked gas production in the form of bubbles (0.1-4 cm) in Durham tubes was observed in H3, H7, H13, H15, H17, H21, and H22. Sugar degradation of all isolates was indicated by pink to maroon color development with the tetrazolium salt. Hallow zones (0.42-11 mm) by Congo red staining was exhibited by all strains except H2, H7, H8, and H19. Among the 26 bacterial isolates, 12 strains were identified as efficient cellulolytic bacteria. CMCase activity and ethanol titer of all isolates varied from 1.30 ± 0.03 (H13) to 1.83 ± 0.01 (H21) umol/mL/min and 2.36 ± 0.01 (H25) to 7.00 ± 0.01 (H21) g/L, respectively. Likewise, isolate H21 exhibited an ethanol yield of 0.40 ± 0.10 g/g with 78.38 ± 2.05% fermentation efficiency. Molecular characterization of four strains, Staphylococcus sp. H13, Acinetobacter baumanni H17, Acinetobacter sp. H21, and Acinetobacter nosocomialis H22, were based on the maximum cellulolytic index and the ethanol yield. H. indicola harbor promising and novel bacteria with a natural cellulolytic tendency for efficient bioconversion of LCB to value-added products. Hence, the selected cellulolytic bacteria can become an excellent addition for use in enzyme purification, composting, and production of biofuel at large.
Collapse
Affiliation(s)
- Sana Azhar
- Institute
of Zoology, University of the Punjab, Lahore 54590, Pakistan
| | - Ayesha Aihetasham
- Institute
of Zoology, University of the Punjab, Lahore 54590, Pakistan
| | - Asma Chaudhary
- Department
of Zoology, Division of Science and Technology, University of Education, Township, Lahore54770, Pakistan
| | - Zawar Hussain
- Department
of Zoology, Division of Science and Technology, University of Education, Township, Lahore54770, Pakistan
| | - Rahat Abdul Rehman
- Department
of Forensic Medicine, University of Health
Sciences, Lahore54600, Pakistan
| | - Ghulam Abbas
- Department
of Biotechnology, University of Agriculture, Dera Ismail Khan, KPK 29111, Pakistan
| | - Sulaiman Ali Alharbi
- Department
of Botany and Microbiology, College of Science, King Saud University, PO Box-2455, Riyadh 11451, Kingdom of Saudi Arabia
| | - Mohammad Javed Ansari
- Department
of Botany, Hindu College, Moradabad (Mahatma
Jyotiba Phule Rohilkhand University), Bareilly, Uttar Pradesh 243001, India
| | - Samina Qamer
- Department
of Zoology, Rawalpindi Women University, Satellite Town, Rawalpindi 46300, Pakistan
| |
Collapse
|
4
|
Chen Z, Wu J, Han J, Wang Y, Ni L. UCST-Type Soluble Immobilized Cellulase: A New Strategy for the Efficient Degradation and Improved Recycling Performance of Wastepaper Cellulose. Molecules 2024; 29:1039. [PMID: 38474553 DOI: 10.3390/molecules29051039] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Abstract] [Key Words] [Grants] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/04/2024] [Revised: 02/25/2024] [Accepted: 02/26/2024] [Indexed: 03/14/2024] Open
Abstract
This paper reports an innovative study that aims to address key issues in the efficient recycling of wastepaper cellulose. The research team utilized the temperature-responsive upper critical solution temperature (UCST) polymer P(NAGA-b-DMA) in combination with the LytA label's affinity for choline analogs. This innovative approach enabled them to successfully develop a novel soluble immobilized enzyme, P(NAGA-b-DMA)-cellulase. This new enzyme has proven highly effective, significantly enhancing the degradation of wastepaper cellulose while demonstrating exceptional stability. Compared with the traditional insoluble immobilized cellulase, the enzyme showed a significant improvement in the pH, temperature stability, recycling ability, and storage stability. A kinetic parameter calculation showed that the enzymatic effectiveness of the soluble immobilized enzyme was much better than that of the traditional insoluble immobilized cellulase. After the immobilization reaction, the Michaelis constant of the immobilized enzyme was only increased by 11.5%. In the actual wastepaper degradation experiment, the immobilized enzyme was effectively used, and it was found that the degradation efficiency of wastepaper cellulose reached 80% of that observed in laboratory conditions. This novel, thermosensitive soluble immobilized cellulase can efficiently catalyze the conversion of wastepaper cellulose into glucose under suitable conditions, so as to further ferment into environmentally friendly biofuel ethanol, which provides a solution to solve the shortage of raw materials and environmental protection problems in the paper products industry.
Collapse
Affiliation(s)
- Zhaohui Chen
- School of Chemistry and Chemical Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Jiacong Wu
- School of Chemistry and Chemical Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Juan Han
- School of Food and Biological Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Yun Wang
- School of Chemistry and Chemical Engineering, Jiangsu University, Zhenjiang 212013, China
| | - Liang Ni
- School of Chemistry and Chemical Engineering, Jiangsu University, Zhenjiang 212013, China
| |
Collapse
|
5
|
Xu M, Sun H, Chen E, Yang M, Wu C, Sun X, Wang Q. From waste to wealth: Innovations in organic solid waste composting. ENVIRONMENTAL RESEARCH 2023; 229:115977. [PMID: 37100364 DOI: 10.1016/j.envres.2023.115977] [Citation(s) in RCA: 8] [Impact Index Per Article: 8.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Subscribe] [Scholar Register] [Received: 02/28/2023] [Revised: 04/13/2023] [Accepted: 04/21/2023] [Indexed: 05/21/2023]
Abstract
Organic solid waste (OSW) is not only a major source of environmental contamination, but also a vast store of useful materials due to its high concentration of biodegradable components that can be recycled. Composting has been proposed as an effective strategy for recycling OSW back into the soil in light of the necessity of a sustainable and circular economy. In addition, unconventional composting methods such as membrane-covered aerobic composting and vermicomposting have been reported more effective than traditional composting in improving soil biodiversity and promoting plant growth. This review investigates the current advancements and potential trends of using widely available OSW to produce fertilizers. At the same time, this review highlights the crucial role of additives such as microbial agents and biochar in the control of harmful substances in composting. Composting of OSW should include a complete strategy and a methodical way of thinking that can allow product development and decision optimization through interdisciplinary integration and data-driven methodologies. Future research will likely concentrate on the potential in controlling emerging pollutants, evolution of microbial communities, biochemical composition conversion, and the micro properties of different gases and membranes. Additionally, screening of functional bacteria with stable performance and exploration of advanced analytical methods for compost products are important for understanding the intrinsic mechanisms of pollutant degradation.
Collapse
Affiliation(s)
- Mingyue Xu
- School of Energy and Environmental Engineering, University of Science and Technology Beijing, Beijing, 100083, China
| | - Haishu Sun
- School of Energy and Environmental Engineering, University of Science and Technology Beijing, Beijing, 100083, China
| | - Enmiao Chen
- School of Energy and Environmental Engineering, University of Science and Technology Beijing, Beijing, 100083, China
| | - Min Yang
- School of Energy and Environmental Engineering, University of Science and Technology Beijing, Beijing, 100083, China
| | - Chuanfu Wu
- School of Energy and Environmental Engineering, University of Science and Technology Beijing, Beijing, 100083, China; Beijing Key Laboratory of Resource-oriented Treatment of Industrial Pollutants, Beijing, 100083, China.
| | - Xiaohong Sun
- Beijing Agro-Biotechnology Research Center, Beijing Academy of Agriculture and Forestry Sciences, Beijing, 100097, China
| | - Qunhui Wang
- School of Energy and Environmental Engineering, University of Science and Technology Beijing, Beijing, 100083, China; Beijing Key Laboratory of Resource-oriented Treatment of Industrial Pollutants, Beijing, 100083, China
| |
Collapse
|
6
|
Mawardi M, Indrawati A, Wibawan IWT, Lusiastuti AM. Antimicrobial susceptibility test and antimicrobial resistance gene detection of extracellular enzyme bacteria isolated from tilapia (Oreochromis niloticus) for probiotic candidates. Vet World 2023; 16:264-271. [PMID: 37042005 PMCID: PMC10082709 DOI: 10.14202/vetworld.2023.264-271] [Citation(s) in RCA: 2] [Impact Index Per Article: 2.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 10/22/2022] [Accepted: 01/13/2023] [Indexed: 02/13/2023] Open
Abstract
Background and Aim: Antimicrobial resistance (AMR) is a global problem that can increase mortality and morbidity rates and adversely affect health. Therefore, AMR control must be carried out in various sectors, including the fisheries sector, using probiotics. Bacteria can become resistant to antibiotics, including bacteria used for probiotics. This study aimed to isolate bacteria as potential producers of extracellular enzymes, phenotypic characterization, and antibiotic-resistant gene patterns.
Materials and Methods: In this study, 459 bacterial isolates were isolated from the stomach of tilapia in Indonesia. Tilapia was obtained from Sukabumi, Ciamis, Serang, Banjarnegara, Jayapura, Sorong, Manokwari Selatan, Takalar, Lampung, Batam, and Mandiangin. Enzymatic bacteria were identified. An antimicrobial susceptibility test was conducted by agar disk diffusion, and genotypic detection of encoding genes was performed using a molecular method.
Results: This study obtained 137 isolates (29.84%) that can produce extracellular enzymes. The highest number of E-sensitive isolates was found, including 130 isolates (94.89%). Six isolates (6/137) can produce four enzymes (amylase, protease, cellulose, and lipase), and they were sensitive to antibiotics. A total of 99 isolates can produce extracellular enzymes, and they were sensitive to antibiotics. Such isolates serve as a consortium of probiotic candidates. The isolates that are resistant to oxytetracycline (OT), erythromycin (E), tetracycline (TE), and enrofloxacin (ENR) included 15 isolates (10.95%), seven isolates (5.11%), three isolates (2.19%), and one isolate (0.73%), respectively. In addition, four isolates (2.92%) were detected as multidrug-resistant. The tet(A) gene obtained the highest result of detection of resistance genes in isolates that were intermediate and resistant to TE and OT. Isolates that serve as ENR intermediates have a high qnr(S) resistance gene.
Conclusion: The data in this study provide the latest update that bacteria can serve as a consortium of potential probiotics with antibiotic-resistant genes for the treatment of fish. Bacteria that are intermediate to antibiotics may contain resistance genes. The results of this study will improve the policy of probiotic standards in Indonesia.
Collapse
Affiliation(s)
- Mira Mawardi
- School of Veterinary Medicine and Biomedical Sciences (SVMBS), IPB University, Jl. Agatis Kampus IPB Dramaga Bogor, 16680, Indonesia; Main Center for Freshwater Aquaculture, Ministry of Marine Affairs and Fisheries, Jl. Selabintana No. 37, Selabatu, Kec, Cikole, Kota Sukabumi, Jawa Barat 43114, Indonesia
| | - Agustin Indrawati
- School of Veterinary Medicine and Biomedical Sciences (SVMBS), IPB University, Jl. Agatis Kampus IPB Dramaga Bogor, 16680, Indonesia
| | - I. Wayan Teguh Wibawan
- School of Veterinary Medicine and Biomedical Sciences (SVMBS), IPB University, Jl. Agatis Kampus IPB Dramaga Bogor, 16680, Indonesia
| | - Angela Mariana Lusiastuti
- Research Center for Veterinary Sciences, National Research and Innovation Agency, RE Martadinata 30 Bogor, Jawa Barat, Indonesia
| |
Collapse
|
7
|
Ruangjanda S, Iwai CB, Greff B, Chang SW, Ravindran B. Valorization of spent mushroom substrate in combination with agro-residues to improve the nutrient and phytohormone contents of vermicompost. ENVIRONMENTAL RESEARCH 2022; 214:113771. [PMID: 35798270 DOI: 10.1016/j.envres.2022.113771] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 04/02/2022] [Revised: 06/16/2022] [Accepted: 06/25/2022] [Indexed: 06/15/2023]
Abstract
In recent years, enormous amounts of spent mushroom substrate (SMS) have been generated because of the rapid development of mushroom production. Since the conventional disposal methods of these residues can cause serious environmental problems, alternative waste management techniques are required to ensure sustainable agriculture. However, SMS might be not suitable for vermicomposting when used alone. Therefore, the primary purpose of this study was to investigate the effect of Azolla microphylla (Azolla) biomass, eggshells, fruit peels, and cassava pulp on the biodegradation process of SMS. The results showed the treatments supplemented with cassava pulp and fruit peel waste improved the growth of earthworms, while the carbon-to-nitrogen ratio of these vermicomposts decreased significantly (p < 0.05) due to the improved total nitrogen contents (7.64 g kg-1 and 6.71 g kg-1). Concerning the degradation process and the vermicompost quality, the addition of these agro-residues facilitated the enzyme activities (cellulase, urease, and alkaline phosphatase) and increased the total macronutrient (P, K, Mg, and Ca) and phytohormone (fruit peel waste: AA, GA3, and cytokinin; cassava pulp: cytokinin) contents of the final products compared to the control treatment. On the other hand, Azolla had no additional effect on the fecundity and growth of Eudrilus eugenia. Meanwhile, the treatment supplemented with eggshells was high in Mg (7.15 g kg-1) and Ca (305.6 g kg-1). Overall, the combined decomposition of SMS-based bedding material with Azolla, eggshells, fruit peel waste, and cassava pulp resulted in mature organic fertilizers with improved chemical properties.
Collapse
Affiliation(s)
- Supawadee Ruangjanda
- Department of Soil Science and Environment, Faculty of Agriculture, Khon Kaen University, Khon Kaen, 40002, Thailand
| | - Chuleemas Boonthai Iwai
- Department of Soil Science and Environment, Faculty of Agriculture, Khon Kaen University, Khon Kaen, 40002, Thailand; Integrated Land and Water Resource Management Research and Development Center in Northeast Thailand, Khon Kaen University, Thailand.
| | - Babett Greff
- Department of Food Science, Faculty of Agricultural and Food Sciences, Széchenyi István University, 15-17 Lucsony Street, 9200 Mosonmagyaróvár, Hungary
| | - Soon Woong Chang
- Department of Environmental Energy & Engineering, Kyonggi University, Suwon-si, Gyeonggi-do, 16227, South Korea
| | - Balasubramani Ravindran
- Department of Environmental Energy & Engineering, Kyonggi University, Suwon-si, Gyeonggi-do, 16227, South Korea; Department of Medical Biotechnology and Integrative Physiology, Institute of Biotechnology, Saveetha School of Engineering, Saveetha Institute of Medical and Technical Sciences, Thandalam, Chennai, 602 105, Tamil Nadu, India
| |
Collapse
|
8
|
Yao Z, Seong HJ, Jang YS. Environmental toxicity and decomposition of polyethylene. ECOTOXICOLOGY AND ENVIRONMENTAL SAFETY 2022; 242:113933. [PMID: 35930840 DOI: 10.1016/j.ecoenv.2022.113933] [Citation(s) in RCA: 30] [Impact Index Per Article: 15.0] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 05/16/2022] [Revised: 07/26/2022] [Accepted: 07/28/2022] [Indexed: 06/15/2023]
Abstract
In the more than 100 years since the invention of plastics, various plastic polymers have been developed that exhibit different characteristics and have been widely used in production and life. In 2020 alone, nearly 400 million tons of plastics were produced globally. However, while plastic such as polyethylene brings us convenience, it also threatens environmental sustainability and human health. Due to insufficient recycling efficiency, millions of tons of polyethylene pollutants accumulate in terrestrial or marine environments each year. Polyethylene is elastic, chemically stable, and non-biodegradable, and the traditional disposal methods include landfilling and incineration. These methods are costly, unsustainable, and further increase the burden on the environment. Therefore, recent research has increasingly focused on the biodegradation of polyethylene. In this work, we briefly summarized polyethylene's properties and environmental toxicity. We also reviewed the recent advances in the biodegradation of polyethylene with a summary of traditional abiotic methods. Finally, we proposed a brief research direction in polyethylene study with the aspect of environmental toxicology and industrial applications of decomposition technology.
Collapse
Affiliation(s)
- Zhuang Yao
- Division of Applied Life Science (BK21), Department of Applied Life Chemistry, Institute of Agriculture & Life Science (IALS), Gyeongsang National University, Jinju, Republic of Korea
| | - Hyeon Jeong Seong
- Division of Applied Life Science (BK21), Department of Applied Life Chemistry, Institute of Agriculture & Life Science (IALS), Gyeongsang National University, Jinju, Republic of Korea
| | - Yu-Sin Jang
- Division of Applied Life Science (BK21), Department of Applied Life Chemistry, Institute of Agriculture & Life Science (IALS), Gyeongsang National University, Jinju, Republic of Korea.
| |
Collapse
|
9
|
Zhang G, Dong Y. Design and application of an efficient cellulose-degrading microbial consortium and carboxymethyl cellulase production optimization. Front Microbiol 2022; 13:957444. [PMID: 35910619 PMCID: PMC9335055 DOI: 10.3389/fmicb.2022.957444] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 05/31/2022] [Accepted: 06/28/2022] [Indexed: 11/30/2022] Open
Abstract
Microbial consortia with high cellulase activities can speed up the composting of agricultural wastes with high cellulose contents and promote the beneficial utilization of agricultural wastes. In this paper, rabbit feces and sesame oil cake were used as feedstocks for compost production. Cellulose-degrading microbial strains were isolated from compost samples taken at the different composting stages and screened via Congo red staining and filter paper degradation test. Seven strains, Trichoderma reesei, Escherichia fergusonii, Proteus vulgaris, Aspergillus glaucus, Bacillus mycoides, Corynebacterium glutamicum, and Serratia marcescens, with high activities of carboxymethyl cellulase (CMCase), filter paper cellulase (FPase), and β-glucosidase (β-Gase) were identified and selected for consortium design. Six microbial consortia were designed with these strains. Compared with the other five consortia, consortium VI composed of all seven strains displayed the highest cellulase activities, 141.89, 104.56, and 131.18 U/ml of CMCase, FPase, and β-Gase, respectively. The single factor approach and response surface method were employed to optimize CMCase production of consortium VI. The optimized conditions were: culture time 4.25 days, culture temperature 35.5°C, pH 6.6, and inoculum volume 5% (v/v). Under these optimized conditions, the CMCase activity of consortium VI was up to 170.83 U/ml. Fermentation experiment of rabbit feces was carried out by using the consortium VI cultured under the optimal conditions. It was found that the application effect was better than other treatments, and the fermentation efficiency and nutrient content of the pile were significantly improved. This study provides a basis for the design of microbial consortia for the composting of agricultural wastes with high cellulose contents and provides a support for beneficial utilization of agricultural wastes.
Collapse
|
10
|
Fabrication and Characterization of Transparent and Uniform Cellulose/Polyethylene Composite Films from Used Disposable Paper Cups by the "One-Pot Method". Polymers (Basel) 2022; 14:polym14061070. [PMID: 35335401 PMCID: PMC8950660 DOI: 10.3390/polym14061070] [Citation(s) in RCA: 5] [Impact Index Per Article: 2.5] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Download PDF] [Figures] [Journal Information] [Subscribe] [Scholar Register] [Received: 02/17/2022] [Revised: 02/27/2022] [Accepted: 03/01/2022] [Indexed: 02/04/2023] Open
Abstract
Disposable paper cups are usually composed of high-grade paper board and an inner polyethylene coatings and are extensively used in daily life. However, most disposable paper cups are only used for a short time and then incinerated or accumulated in landfill at the end of their service due to the difficulty in separating the components, leading to a serious threat to our ecosystem. Therefore, developing a facile and green method to recycle and reuse disposable paper cups is vital. By using ionic liquid 1-allyl-3-methylimidazolium chloride (AmimCl) as a solvent, transparent and homogenous cellulose/polyethylene composite films were successfully prepared from used bamboo-based disposable paper cups through the "one-pot method", without any pre-treatment. It was found that there was a transformation of cellulose I to II after the dissolution and regeneration processes, and the crystallinity degree of the regenerated cellulose-based materials decreased significantly, resulting in a change in thermal properties. Meanwhile, compared to traditional pure cellulose films, the composite films possessed good UV-shielding properties and hydrophobicity. Moreover, they also displayed good mechanical properties. Additionally, the size of the ground PE coatings displayed obvious effects on the structures and properties of the composite films, where the CPE100 (sieved with 100-200 mesh) possessed the most homogeneous texture and the highest tensile strength (82 Mpa), higher than that of commercial polyethylene film (9-12 MPa), showing superiority as packaging or wrapping materials. Consequently, the goals to fabricate uniform cellulose/polyethylene composite films and valorize the solid waste from disposable paper cups were simultaneously achieved by a facile and green "one-pot method".
Collapse
|
11
|
Korsa G, Masi C, Konwarh R, Tafesse M. Harnessing the potential use of cellulolytic Klebsiella oxytoca (M21WG) and Klebsiella sp. (Z6WG) isolated from the guts of termites (Isoptera). ANN MICROBIOL 2022. [DOI: 10.1186/s13213-021-01662-4] [Citation(s) in RCA: 6] [Impact Index Per Article: 3.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Indexed: 11/10/2022] Open
Abstract
Abstract
Background
For many years, denim-heavy quality cotton twill colored with indigo colors and with a well-worn/faded look has held a lot of appeal. Machine damage, drainage system blockage, and other issues come with the conventional usage of pumice stones for “stone-washing” denims. In view of the abovementioned information, a range of works has been done to investigate the economic prospects of bacterial cellulase enzymes for use in industrial processes, including biopolishing in the textile sector. Ethiopia has excellent termite diversity to isolate bacterial gut-associated cellulose enzymes for biostoning applications. The main purpose of this study was, therfore, to decipher how to isolate and characterize cellulase enzymes from termite (Isoptera) gut bacteria with the intention of employing it for biostoning of textiles.
Purpose
To use cellulolytic enzymes of Klebsiella oxytoca (M21WG) and Klebsiella sp. (Z6WG) isolated from termite guts in biostoning of textiles and improving garment quality.
Methods
Cellulase enzyme-producing bacteria were isolated and screened from the guts of worker termites sampled from Meki and Zeway termite mounds in the Central Rift Valley region of Ethiopia. Bacterial screening, biochemical, morphological, and 16S rRNA sequence identification techniques were employed to characterize the bacterial strains. In addition, the production, optimization, and purification of the associated cellulase enzymes were employed, and the potential application of the enzymes for biostoning of a textile was demonstrated.
Result
The isolated M21WG was found to be 99% identical to the Klebsiella oxytoca (MT104573.1) strain, while the isolated Z6WG showed 97.3% identity to the Klebsiella sp. strain (MN629242.1). At an ideal pH of 7, a temperature of 37 °C, a 72-h incubation time, and a substrate concentration of 1.5% carboxymethylcellulose sodium, the maximum activity of the crude cellulase extract from these bacteria was assessed. These bacteria produced cellulase enzymes that were moderately efficient. Consequently, it was determined that the cellulase enzymes were effective for biostoning of denim cloth.
Conclusion
It was determined that Klebsiella oxytoca (M21WG) and Klebsiella sp. (Z6WG) could be used as a doorway to better understand harnessing the use of these cellulase-producing bacteria from termite (Isoptera) guts. In this study, it was also attempted to assess the effectiveness of the two bacterial isolates in biostoning in anticipation of their potential application in the textile realm.
Collapse
|
12
|
Ali SM, Soliman NA, Abdal-Aziz SAA, Abdel-Fattah YR. Cloning of cellulase gene using metagenomic approach of soils collected from Wadi El Natrun, an extremophilic desert valley in Egypt. JOURNAL OF GENETIC ENGINEERING AND BIOTECHNOLOGY 2022; 20:20. [PMID: 35137293 PMCID: PMC8825895 DOI: 10.1186/s43141-022-00312-9] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Track Full Text] [Download PDF] [Figures] [Subscribe] [Scholar Register] [Received: 06/10/2021] [Accepted: 01/30/2022] [Indexed: 02/22/2023]
Abstract
Background Wadi El Natrun microorganisms have been considered as a new resource for natural products due to its extreme condition of salinity and alkalinity. Therefore, this study was devoted to generate metagemic library from soils collected from such an extreme environment in order to clone a novel cellulase for physique industrial applications. Results Total soil-DNA was successfully extracted, and then digested by different restriction enzymes. Purified fragments ranged ~ 200–6500 bp were ligated and were cloned into plasmid cloning vector (pUC19) by using Escherichia coli DH5α (E. coli) host cells. A constructed metagenomic library composed of 270 clones was screened on carboxymethylcellulose (CMC) agar plate where the active clones had been characterized by the formation of the yellowish halo zone. Thereafter, clone 1 was selected as the most active as being based on cellulase activity quantification (19 μ/ml). Plasmid related to clone 1 encoded cellSNSY gene of approximately 1.5 kb was subjected to molecular characterization; the obtained partial sequence of 861 bps encoded 287 amino acids showing 76% similarity to the endoglucanase gene of Bacillus amyloliquefaciens. The recombinant cellSNSY was expressed under lacz promoter at 1 mM of isopropyl β-d-1-thiogalactopyranoside (IPTG), giving 21 μ/ml cellulase after ~ 27 h. Sodium dodecyl sulfate–polyacrylamide gel electrophoresis (SDS-PAGE) and an activity staining of the recombinant cellSNSY which revealed an active band with a molecular mass ~ 59 kDa appeared in the induced sample. The maximum enzyme activity of crude cellSNSY was observed at 45 °C and for a pH of 8.5. Interestingly, the enzyme activity was slightly inhibited by ethylenediamine tetraacetic acid (EDTA) and methanol. It showed high resistance to the tested heavy metals and the surfactant which ordered Zn> (SDS,Fe)>Mn>Cu. Conclusions This study established an easy and a skillful way to clone/express a new found cellulase gene(s) under lacZ promoter. The isolated recombinant cellSNSY showed 76% similarity to endoglucanase gene, and the enzyme showed tolerance to the mostly tested agents including heavy metals, surfactant, solvents, and EDTA. Additionally, the studied recombinant showed a high stability up to 55 °C and for alkaline pH 8.5. These features make it an ample and viable for many applications.
Collapse
|
13
|
Krishnaswamy VG, Sridharan R, Kumar PS, Fathima MJ. Cellulase enzyme catalyst producing bacterial strains from vermicompost and its application in low-density polyethylene degradation. CHEMOSPHERE 2022; 288:132552. [PMID: 34648790 DOI: 10.1016/j.chemosphere.2021.132552] [Citation(s) in RCA: 1] [Impact Index Per Article: 0.5] [Reference Citation Analysis] [Abstract] [Key Words] [MESH Headings] [Track Full Text] [Subscribe] [Scholar Register] [Received: 07/20/2021] [Revised: 09/13/2021] [Accepted: 10/10/2021] [Indexed: 06/13/2023]
Abstract
Cellulose is the main polysaccharide present abundantly in the earth, an important substrate for the cellulase enzyme. Cellulases have attracted considerable attention due to its diverse application in different textile, detergent, leather, food, feed and paper industries. Among the cellulase producing microbes, bacteria have a faster growth compared to other microbes. The present study focuses on isolating bacterial strains (Bacillus pacificus and Pseudomonas mucidolens) from vermicompost. The study focused on extracting cellulase enzyme and its molecular weight using SDS-PAGE, which was determined to be 32Kda. The maximum enzyme activity resulted to be 0.12 U/mL and 0.17 U/mL after dialysis. The LDPE degradation was reported up to 30 days. Further, the growth conditions of the bacterial strains were optimised at different pH and temperature. The degradation of LDPE was determined using FTIR analysis, resulting in the peak changes (formation and shifts). The bacterial strains were morphologically characterized using Scanning Electron Microscopy. The bacterial strains Bacillus pacificus and Pseudomonas mucidolens were identified using 16 S rRNA sequencing.
Collapse
Affiliation(s)
- Veena Gayathri Krishnaswamy
- Department of Biotechnology, Stella Maris College (Autonomous), Affiliated to University of Madras, Chennai, India.
| | - Rajalakshmi Sridharan
- Department of Biotechnology, Stella Maris College (Autonomous), Affiliated to University of Madras, Chennai, India
| | - P Senthil Kumar
- Department of Chemical Engineering, Sri Sivasubramaniya Nadar College of Engineering, Kalavakkam, Chennai, 603 110, India; Centre of Excellence in Water Research (CEWAR), Sri Sivasubramaniya Nadar College of Engineering, Kalavakkam, Chennai, 603 110, India.
| | - Mariyam Jaffer Fathima
- Department of Biotechnology, Stella Maris College (Autonomous), Affiliated to University of Madras, Chennai, India
| |
Collapse
|
14
|
Guan Y, Zhu H, Zhu Y, Zhao H, Shu L, Song J, Yang X, Wu Z, Wu L, Yang M. Microbial consortium composed of Cellulomonas ZJW-6 and Acinetobacter DA-25 improves straw lignocellulose degradation. Arch Microbiol 2022; 204:139. [PMID: 35032191 DOI: 10.1007/s00203-021-02748-y] [Citation(s) in RCA: 2] [Impact Index Per Article: 1.0] [Reference Citation Analysis] [Abstract] [Key Words] [Track Full Text] [Journal Information] [Subscribe] [Scholar Register] [Received: 09/13/2021] [Revised: 12/15/2021] [Accepted: 12/28/2021] [Indexed: 11/02/2022]
Abstract
In the present study, 27 bacterial strains were isolated from environmental samples and screened for higher lignocellulose-degrading efficiency. The best degrader was combined in pairs with 14 strains with high β-glucosidase activity to formulate a consortium. Microbial consortium 625 showed high lignocellulose degradation efficiency. ZJW-6 with low β-glucosidase activity and the best lignocellulose decomposer was identified as a member of Cellulomonas. Consortium 625 composed of ZJW-6 and DA-25, an Acinetobacter, showed the highest degradation rate (57.62%) under optimized conditions. The DA-25 filtrate promoted ZJW-6 growth, upregulating the activity of key lignocellulose-degrading enzymes, including β-glucosidase, endoglucanase, xylanase, laccase, and lignin peroxidase. ZJW-6 and DA-25 worked in a subordination manner when co-cultivated. ZJW-6 acted as the major decomposer whose growth and enzymatic activities were promoted by DA-25. This study proposes a novel microbial consortium with improved lignocellulose degradation efficiency and reduce the C:N ratio of lignocellulose materials, which can enhance bioenergy production.
Collapse
Affiliation(s)
- Yunpeng Guan
- College of Life Sciences, Jilin Agricultural University, Changchun, China
| | - Hongyu Zhu
- College of Life Sciences, Jilin Agricultural University, Changchun, China
| | - Yuan Zhu
- College of Life Sciences, Jilin Agricultural University, Changchun, China
| | - Hemei Zhao
- College of Life Sciences, Jilin Agricultural University, Changchun, China
| | - Longhua Shu
- College of Life Sciences, Jilin Agricultural University, Changchun, China
| | - Jian Song
- College of Life Sciences, Jilin Agricultural University, Changchun, China
| | - Xue Yang
- College of Life Sciences, Jilin Agricultural University, Changchun, China
| | - Zhihai Wu
- College of Agriculture, Jilin Agricultural University, Changchun, China
| | - Lei Wu
- College of Life Sciences, Jilin Agricultural University, Changchun, China
| | - Meiying Yang
- College of Life Sciences, Jilin Agricultural University, Changchun, China.
| |
Collapse
|
15
|
BRONTOWIYONO W, RUDIANSYAH M, MAHMUDIONO T, SHICHIYAKH RA, ISWANTO AH, ABDULKADHIM AH, HUSSEIN SA, YASIN G, SHARMA S, ARAVINDHAN S. Optimal preparation time in the vermicompost production process. FOOD SCIENCE AND TECHNOLOGY 2022. [DOI: 10.1590/fst.03622] [Citation(s) in RCA: 0] [Impact Index Per Article: 0] [Reference Citation Analysis] [Track Full Text] [Subscribe] [Scholar Register] [Indexed: 12/24/2022]
|