Cryopreservation of umbilical cord blood: 2. Tolerance of CD34(+) cells to multimolar dimethyl sulphoxide and the effect of cooling rate on recovery after freezing and thawing

A 3-step method for preparing cryopreserved samples of apheresis products for post-thaw analysis yields a higher percentage of viable cells

BACKGROUND

Standard flow cytometry protocols for CD34+ cell enumeration designed for fresh samples are not appropriate for cryopreserved products. Special protocols have been developed to remove the cryoprotectant by quickly washing a freshly thawed sample. Exposing cells to a large volume of hypotonic solution and subsequent washing process was hypothesized to cause lab-induced cell death. Moreover, standard gating strategies must be altered to avoid reporting falsely high viabilities.

STUDY DESIGN AND METHODS

We developed a novel method whereby thawed samples were diluted step-wise to 1:2 by 3 additions of 1/3 sample volume using 1% Human Albumin in Dextran 40 (10% Low Molecular Weight Dextran in 0.9% NaCl) separated by 5 min between each addition. An additional 1:10 dilution was required to obtain a desired cell concentration for flow cytometry testing resulting in a 1:20 dilution.

RESULTS

Twenty samples were tested simultaneously in a method comparison; the new method demonstrated significant increases in mean cell viabilities for white blood cells, hematopoietic progenitor cells, and T cells as well as reduced standard deviations for each parameter.

DISCUSSION

Slow, step-wise dilutions of freshly thawed samples of cryopreserved apheresis products to 1:20 yielded higher and more precise viability measurements compared to quickly washing samples to remove DMSO.

Long-Term Cryopreservation of Peripheral Blood Stem Cell Harvest Using Low Concentration (4.35%) Dimethyl Sulfoxide with Methyl Cellulose and Uncontrolled Rate Freezing at -80 °C: An Effective Option in Resource-Limited Settings

Long-term cryopreservation of peripheral blood stem cells (PBSCs) is highly useful in the setting of tandem/multiple transplantations or treatment of relapse in the autologous hematopoietic stem cell transplantation (HSCT) setting. Even in allogeneic HSCT, donor lymphocyte infusions may be stored for months to years if excess stem cells are collected from donors. Cryopreservation is a delicate, complex, and costly procedure, and higher concentrations of dimethyl sulfoxide (DMSO), a commonly used cryoprotectant, can be toxic to cells and cause adverse effects in the recipient during infusions. In this study, we examined the effect of long-term cryopreservation using 4.35% DMSO (as final concentration) with methyl cellulose and uncontrolled rate freezing in a mechanical freezer (-80 °C) on the viability and colony-forming ability of CD34+ human PBSCs. For patients undergoing autologous HSCT, PBSCs were cryopreserved using DMSO (final concentration of 4.35%) with methyl cellulose. The post-thaw viability of PBSCs was determined using Trypan blue exclusion and flow cytometry-based 7-amino-actinomycin-D (FC-7AAD) methods. Concentrations of CD34+ stem cells and immune cell subsets in post-thaw PBSC harvest samples were assessed using multicolor flow cytometry, and the clonogenic potential of post-thaw stem cells was studied using a colony-forming unit (CFU) assay. CD34+ stem cell levels were correlated with the prestorage CD34 levels using the Pearson correlation test. The viability results in the Trypan blue dye exclusion method and the flow cytometry-based method were compared using Bland-Altman plots. We studied 26 PBSC harvest samples with a median cryopreservation duration of 6.6 years (range, 3.8 to 11.5 years). The median viability of post-thaw PBSCs was >80% using both methods, with a weak agreement between them (r = .03; P = .5). The median CD34+ stem cell count in the post-thaw samples was 9.13 × 106/kg (range, .44 to 26.27 × 106/kg). The CFU assay yielded a good proliferation and differentiation potential in post-thaw PBSCs, with a weak correlation between granulocyte macrophage CFU and CD34+ stem cell levels (r = .4; P = .05). Two samples that had been cryopreserved for >8 years showed low viability. Cryopreservation of PBSCs using 4.35% DMSO with methyl cellulose and uncontrolled freezing in a mechanical freezer at -80 °C allows the maintenance of long-term viability of PBSC for up to 8 years.

hMSCs in contact with DMSO for cryopreservation: experiments and modelling of osmotic injury and cytotoxic effect

In this work a combined analysis of osmotic injury and cytotoxic effect useful for the optimization of the cryopreservation process of a cell suspension is carried out. The case of human Mesenchymal Stem Cells (hMSCs) from Umbilical Cord Blood (UCB) in contact with DiMethyl SulfOxide (DMSO) acting as Cryo-Protectant Agent (CPA) is investigated from the experimental as well as the theoretical perspective. The experimental runs are conducted by suspending the cells in hypertonic solutions of DMSO at varying osmolality, system temperature and contact times; then, at room temperature, cells are pelleted by centrifugation and suspended back to isotonic conditions. Eventually cell count and viability are measured by means of a Coulter counter and flow-cytometer, respectively. Overall, a decrease of cell count and viability results when DMSO concentration, temperature and contact time increase. A novel mathematical model is developed and proposed to interpret measured data by dividing the cell population between viable and non-viable cells. The decrease of cell count is ascribed exclusively to the osmotic injury caused by expansion lysis: excessive swelling causes the burst of both viable as well as non-viable cells. On the other hand, the reduction of cell viability is ascribed only to cytotoxicity which gradually transforms viable cells into non-viable ones. A chemical reaction engineering approach is adopted to describe the dynamics of both phenomena: by following the kinetics of two chemical reactions during cell osmosis inside a closed system it is shown that the simultaneous reduction of cell count and viability may be successfully interpreted. The use of the Surface Area Regulation (SAR) model recently proposed by the authors allows one to avoid the setting in advance of fixed cell Osmotic Tolerance Limits (OTLs), as traditionally done in cryopreservation literature to circumvent the mathematical simulation of osmotic injury. Comparisons between experimental data and theoretical simulations are provided: first, a non-linear regression analysis is performed to evaluate unknown model parameters through a best-fitting procedure carried out in a sequential fashion; then, the proposed model is validated by full predictions of system behavior measured at operating conditions different from those used during the best-fit procedure. This article is protected by copyright. All rights reserved.

Current and Future Perspectives for the Cryopreservation of Cord Blood Stem Cells

Hematopoietic stem cell (HSC) transplantation is a well-established procedure for the treatment of many blood related malignancies and disorders. Before transplantation, HSC are collected and cryopreserved until use. The method of cryopreservation should preserve both the number and function of HSC and downstream progenitors responsible for long- and short-term engraftment, respectively. This is especially critical for cord blood grafts, since the cell number associated with this stem cell source is often limiting. Loss of function in cryopreserved cells occurs following cryoinjuries due to osmotic shock, dehydration, solution effects and mechanical damage from ice recrystallization during freezing and thawing. However, cryoinjuries can be reduced by 2 mitigation strategies; the use of cryoprotectants (CPAs) and use of control rate cooling. Currently, slow cooling is the most common method used for the cryopreservation of HSC graft. Moreover, dimethyl-sulfoxide (DMSO) and dextran are popular intracellular and extracellular CPAs used for HSC grafts, respectively. Yet, DMSO is toxic to cells and can cause significant side effects in stem cells' recipients. However, new CPAs and strategies are emerging that may soon replace DMSO. The aim of this review is to summarise key concepts in cryobiology and recent advances in the field of HSC cryobiology. Other important issues that need to be considered are also discussed such as transient warming events and thawing of HSC grafts.

Mathematical Modeling and Optimization of Cryopreservation in Single Cells

Cryobiology is a multiscale and interdisciplinary field. The scope and scale of interactions limit the gains that can be made by one theory or experiment alone. Because of this, modeling has played a critical role in both explaining cryobiological phenomena and predicting improved protocols. Modeling facilitates understanding of the biophysical and some of the biochemical mechanisms of damage during all phases of cryopreservation including CPA equilibration and cooling and warming. Moreover, as a tool for optimization of cryopreservation protocols, modeling has yielded many successes. Modern cryobiological modeling includes very detailed descriptions of the physical phenomena that occur during freezing, including ice growth kinetics and spatial gradients that define heat and mass transport models. Here we reduce the complexity and approach only a small but classic subset of these problems. Namely, here we describe the process of building and using a mathematical model of a cell in suspension where spatial homogeneity is assumed for all quantities. We define the models that describe the critical cell quantities used to describe optimal and suboptimal protocols and then give an overview of classical methods of how to determine optimal protocols using these models. We include practical considerations of modeling in cryobiology, including fitting transport models to cell volume data, performing optimization with cell volume constraints, and a look at expanding cost functions to cooling regimes.

A novel method to evaluate prethawing viability of cryopreserved CD34+ hematopoietic stem cells for autologous transplantation

BACKGROUND

Cryopreservation of CD34+ hematopoietic stem cells (HSCs) is associated with variable loss of viability. Although postfreezing CD34+ cell viability can be assessed on the sampling tube (bag tail) directly connected to the main bag (mother bag), results often underestimate the actual viability observed when the mother bag is thawed and reinfused. We assessed a novel method to measure postfreezing CD34+ cell viability, based on small bag (minibag) samples; results were compared with those obtained on the corresponding mother bags and bag tails.

STUDY DESIGN AND METHODS

Sixty-one apheresis procedures of 42 patients undergoing autologous HSC transplant were analyzed. Viable CD34+ cells were quantified with flow cytometry before controlled rate freezing (ICE-CUBE14M system, SY-LAB- IceCube, SIAD), after 10 days of storage (mini-bag and bag tail), and before reinfusion (aliquot from a thawed mother bag). Results were compared using Student's t test and Spearman's rho correlation test.

RESULTS

The mean CD34+ cell viability before cryopreservation was 99.3% (confidence interval [CI], 98.94-99.65%); the mean amount of CD34+ cells, white blood cells and neutrophils in the mother bag was 0.8 ± 1.1 × 10⁹ /L, 63.4 ± 23.5 × 10⁹ /L, and 25.7 ± 15.5 × 10⁹ /L, respectively. Mother bags postthawing CD34+ cell viability was 72.3% (CI, 67.74-76.85%; p < 0.01 compared to prefreezing); no difference was observed with respect to minibags (73.7%; CI, 69.80-77.59%; p = NS), whereas significantly lower values were found for bag tails (58.6%; CI, 54.19-63.00%; p < 0.01 vs. both mini- and mother bags).

CONCLUSION

Compared to bag tails, minibags represent a more accurate tool to measure the CD34+ cell viability of the apheresis mother bag prior to reinfusion; in addition, minibags may could be of help for case-by-case calculation of the amount of apheresis to be infused to patients undergoing autologous HSC transplant.

Umbilical cord blood quality and quantity: Collection up to transplantation

Umbilical cord blood (UCB) is an attractive source of hematopoietic stem cells for transplantation in some blood disorders. One of the major factors that influence on transplantation fate is cord blood (CB) cell count, in addition to human leukocyte antigen similarity and CD34+ cell number. Here, we review the factors that could effect on quality and quantity of CBUs. Relevant English-language literatures were searched and retrieved from PubMed using the terms: CB, quality, collection, and transplantation. The numbers of total nucleated cells (TNCs) and CD34+ cells are good indicators of CB quality because they have been associated with engraftment; thereby, whatever the TNCs in a CB unit (CBU) are higher, more likely they led to successful engraftment. Many factors influence the quantity and quality of UCB units that collect after delivery. Some parameters are not in our hands, such as maternal and infant factors, and hence, we cannot change these. However, some other factors are in our authority, such as mode of collection, type and amount of anticoagulant, and time and temperature during collection to postthaw CBUs and freeze-and-thaw procedures. By optimizing the CB collection, we can improve the quantity and quality of UCB for storage and increase the likelihood of its use for transplantation.

Human Leukocyte Antigen and Red Blood Cells Impact Umbilical Cord Blood CD34+ Cell Viability after Thawing

Hematopoietic progenitor cell (HPC) transplantation is a treatment option for malignant and nonmalignant diseases. Umbilical cord blood (UCB) is an important HPC source, mainly for pediatric patients. It has been demonstrated that human leukocyte antigen (HLA) matching and cell dose are the most important features impacting clinical outcomes. However, UCB matching is performed using low resolution HLA typing and it has been demonstrated that the unnoticed mismatches negatively impact the transplant. Since we found differences in CD34+ viability after thawing of UCB units matched for two different patients (p = 0.05), we presumed a possible association between CD34+ cell viability and HLA. We performed a multivariate linear model (n = 67), comprising pre-cryopreservation variables and high resolution HLA genotypes separately. We found that pre-cryopreservation red blood cells (RBC), granulocytes, and viable CD34+ cell count significantly impacted CD34+ viability after thawing, along with HLA-B or -C (R2 = 0.95, p = 0.01; R2 = 0.56, p = 0.007, respectively). Although HLA-B*40:02 may have a negative impact on CD34+ cell viability, RBC depletion significantly improves it.

Technical Considerations in the Freezing, Low-Temperature Storage and Thawing of Stem Cells for Cellular Therapies

The commercial and clinical development of cellular therapy products will invariably require cryopreservation and frozen storage of cellular starting materials, intermediates and/or final product. Optimising cryopreservation is as important as optimisation of the cell culture process in obtaining maximum yield and a consistent end-product. Suboptimal cryopreservation can lead not only to batch-to-batch variation, lowered cellular functionality and reduced cell yield, but also to the potential selection of subpopulations with genetic or epigenetic characteristics divergent from the original cell line. Regulatory requirements also impact on cryopreservation as these will require a robust and reproducible approach to the freezing, storage and thawing of the product. This requires attention to all aspects of the application of low temperatures: from the choice of freezing container and cryoprotectant, the cooling rate employed and its mode of de-livery, the correct handling of the frozen material during storage and transportation, to the eventual thawing of the product by the end-user. Each of these influences all of the others to a greater or lesser extent and none should be ignored. This paper seeks to provide practical insights and alternative solutions to the technical challenges faced during cryopreservation of cells for use in cellular therapies.

Trehalose to cryopreserve human pluripotent stem cells

The successful exploitation of human pluripotent stem cells (hPSCs) for research, translational or commercial reasons requires the implementation of a simple and efficient cryopreservation method. Cryopreservation is usually performed with dimethylsulphoxide (DMSO), in addition to animal proteins. However, even at sub-toxic levels, DMSO diminishes the pluripotency capacity of hPSCs and affects their epigenetic system by acting on the three DNA methyltransferases (Dnmts) and histone modification enzymes. Our study aimed to test trehalose-based cryosolutions containing ethylene glycol (EG) or glycerol (GLY) on hESCs RC17, hiPSCs CTR2#6 and long-term neuroepithelial-like stem cells (lt-NES) AF22. Here, we demostrate the effectiveness of these cryosolutions in hPSCs by showing an acceptable rate of cell viability and high stability compared to standard 10% DMSO freezing medium (CS10). All cell lines retained their morphology, self renewal potential and pluripotency, and none of the cryosolutions affected their differentiation potential. Genotoxicity varied among different stem cells types, while trehalose-based cryopreservation did not sensibly alter the homeostasis of endoplasmic reticulum (ER). This study provides evidence that pluripotent and neural stem cells stored in trehalose alone or with other cryoprotectants (CPAs) maintain their functional properties, indicating their potential use in cell therapies if produced in good manufacturing practice (GMP) facility.

An endogenous explanation of growth: direct-to-consumer stem cell therapies in PR China, India and the USA

The recent expansion of direct-to-consumer stem cell therapies (DSCTs) across nations where medical malpractice laws are the strongest globally challenges the causal assumption that low regulatory standards in developing countries bolster DSCTs. Drawing on firm-level data of existing biopharmaceuticals, approved stem cell therapies (SCTs) and DSCT clinics across the USA, PR China and India, this paper provides an innovation studies perspective of the ways in which the paradigmatic shift in fundamental knowledge production - from in vitro to in vivo stem cells - is transforming SCT discovery and delivery. It argues that the endogenous and inherent disruptive attributes of SCTs, rather than exogenous conditions like regulations, provide a substantive explanation for the recent expansion of DSCTs and urges regulatory adaptation to endogenous imperatives for effective governance of SCTs.

Osmotic modulation of chromatin impacts on efficiency and kinetics of cell fate modulation

Chromatin structure is a major regulator of transcription and gene expression. Herein we explore the use of osmotic modulation to modify the chromatin structure and reprogram gene expression. In this study we use the extracellular osmotic pressure as a chromatin structure and transcriptional modulator. Hyposmotic modulation promotes chromatin loosening and induces changes in RNA polymerase II (Pol II) activity. The chromatin decondensation opens space for higher amounts of DNA engaged RNA Pol II. Hyposmotic modulation constitutes an alternative route to manipulate cell fate decisions. This technology was tested in model protocols of induced pluripotency and transdifferentiation in cells growing in suspension and adherent to substrates, CD34⁺ umbilical-cord-blood (UCB), fibroblasts and B-cells. The efficiency and kinetics of these cell fate modulation processes were improved by transient hyposmotic modulation of the cell environment.

Off the shelf cellular therapeutics: Factors to consider during cryopreservation and storage of human cells for clinical use

The field of cellular therapeutics has immense potential, affording an exciting array of applications in unmet medical needs. One of several key issues is an emphasis on getting these therapies from bench to bedside without compromising safety and efficacy. The successful commercialization of cellular therapeutics will require many to extend the shelf-life of these therapies beyond shipping "fresh" at ambient or chilled temperatures for "just in time" infusion. Cryopreservation is an attractive option and offers potential advantages, such as storing and retaining patient samples in case of a relapse, banking large quantities of allogeneic cells for broader distribution and use and retaining testing samples for leukocyte antigen typing and matching. However, cryopreservation is only useful if cells can be reanimated to physiological life with negligible loss of viability and functionality. Also critical is the logistics of storing, processing and transporting cells in clinically appropriate packaging systems and storage devices consistent with quality and regulatory standards. Rationalized approaches to develop commercial-scale cell therapies require an efficient cryopreservation system that provides the ability to inventory standardized products with maximized shelf life for later on-demand distribution and use, as well as a method that is scientifically sound and optimized for the cell of interest. The objective of this review is to bridge this gap between the basic science of cryobiology and its application in this context by identifying several key aspects of cryopreservation science in a format that may be easily integrated into mainstream cell therapy manufacture.

Cryopreservation: Vitrification and Controlled Rate Cooling

Cryopreservation is the application of low temperatures to preserve the structural and functional integrity of cells and tissues. Conventional cooling protocols allow ice to form and solute concentrations to rise during the cryopreservation process. The damage caused by the rise in solute concentration can be mitigated by the use of compounds known as cryoprotectants. Such compounds protect cells from the consequences of slow cooling injury, allowing them to be cooled at cooling rates which avoid the lethal effects of intracellular ice. An alternative to conventional cooling is vitrification. Vitrification methods incorporate cryoprotectants at sufficiently high concentrations to prevent ice crystallization so that the system forms an amorphous glass thus avoiding the damaging effects caused by conventional slow cooling. However, vitrification too can impose damaging consequences on cells as the cryoprotectant concentrations required to vitrify cells at lower cooling rates are potentially, and often, harmful. While these concentrations can be lowered to nontoxic levels, if the cells are ultra-rapidly cooled, the resulting metastable system can lead to damage through devitrification and growth of ice during subsequent storage and rewarming if not appropriately handled.The commercial and clinical application of stem cells requires robust and reproducible cryopreservation protocols and appropriate long-term, low-temperature storage conditions to provide reliable master and working cell banks. Though current Good Manufacturing Practice (cGMP) compliant methods for the derivation and banking of clinical grade pluripotent stem cells exist and stem cell lines suitable for clinical applications are available, current cryopreservation protocols, whether for vitrification or conventional slow freezing, remain suboptimal. Apart from the resultant loss of valuable product that suboptimal cryopreservation engenders, there is a danger that such processes will impose a selective pressure on the cells selecting out a nonrepresentative, freeze-resistant subpopulation. Optimizing this process requires knowledge of the fundamental processes that occur during the freezing of cellular systems, the mechanisms of damage and methods for avoiding them. This chapter draws together the knowledge of cryopreservation gained in other systems with the current state-of-the-art for embryonic and induced pluripotent stem cell preservation in an attempt to provide the background for future attempts to optimize cryopreservation protocols.

The effect of Me2SO overexposure during cryopreservation on HOS TE85 and hMSC viability, growth and quality

With the cell therapy industry continuing to grow, the ability to preserve clinical grade cells, including mesenchymal stem cells (MSCs), whilst retaining cell viability and function remains critical for the generation of off-the-shelf therapies. Cryopreservation of MSCs, using slow freezing, is an established process at lab scale. However, the cytotoxicity of cryoprotectants, like Me₂SO, raises questions about the impact of prolonged cell exposure to cryoprotectant at temperatures >0 °C during processing of large cell batches for allogenic therapies prior to rapid cooling in a controlled rate freezer or in the clinic prior to administration. Here we show that exposure of human bone marrow derived MSCs to Me₂SO for ≥1 h before freezing, or after thawing, degrades membrane integrity, short-term cell attachment efficiency and alters cell immunophenotype. After 2 h's exposure to Me₂SO at 37 °C post-thaw, membrane integrity dropped to ∼70% and only ∼50% of cells retained the ability to adhere to tissue culture plastic. Furthermore, only 70% of the recovered MSCs retained an immunophenotype consistent with the ISCT minimal criteria after exposure. We also saw a similar loss of membrane integrity and attachment efficiency after exposing osteoblast (HOS TE85) cells to Me₂SO before, and after, cryopreservation. Overall, these results show that freezing medium exposure is a critical determinant of product quality as process scale increases. Defining and reporting cell sensitivity to freezing medium exposure, both before and after cryopreservation, enables a fair judgement of how scalable a particular cryopreservation process can be, and consequently whether the therapy has commercial feasibility.

Comparison of the Effects of Different Cryoprotectants on Stem Cells from Umbilical Cord Blood

Purpose. Cryoprotectants (CPA) for stem cells from umbilical cord blood (UCB) have been widely developed based on empirical evidence, but there is no consensus on a standard protocol of preservation of the UCB cells. Methods. In this study, UCB from 115 donors was collected. Each unit of UCB was divided into four equal parts and frozen in different kinds of cryoprotectant as follows: group A, 10% ethylene glycol and 2.0% dimethyl sulfoxide (DMSO) (v/v); group B, 10% DMSO and 2.0% dextran-40; group C, 2.5% DMSO (v/v) + 30 mmol/L trehalose; and group D, without CPA. Results. CD34⁺, cell viability, colony forming units (CFUs), and cell apoptosis of pre- and postcryopreservation using three cryoprotectants were analyzed. After thawing, significant differences in CD34⁺ count, CFUs, cell apoptosis, and cell viability were observed among the four groups (P < 0.05).  Conclusion. The low concentration of DMSO with the addition of trehalose might improve the cryopreservation outcome.

Modeling and optimization of cryopreservation

Modeling plays a critical role in understanding the biophysical processes behind cryopreservation. It facilitates understanding of the biophysical and some of the biochemical mechanisms of damage during all phases of cryopreservation including CPA equilibration, cooling, and warming. Modeling also provides a tool for optimization of cryopreservation protocols and has yielded a number of successes in this regard. While modern cryobiological modeling includes very detailed descriptions of the physical phenomena that occur during freezing, including ice growth kinetics and spatial gradients that define heat and mass transport models, here we reduce the complexity and approach only a small but classic subset of these problems. Namely, here we describe the process of building and using a mathematical model of a cell in suspension where spatial homogeneity is assumed for all quantities. We define the models that describe the critical cell quantities used to describe optimal and suboptimal protocols and then give an overview of classical methods of how to determine optimal protocols using these models.

Dominant unit CD34+ cell dose predicts engraftment after double-unit cord blood transplantation and is influenced by bank practice

We investigated the unit characteristics associated with engraftment after double-unit cord blood (CB) transplantation (dCBT) and whether these could be reliably identified during unit selection. Cumulative incidence of neutrophil engraftment in 129 myeloablative dCBT recipients was 95% (95% confidence interval: 90-98%). When precryopreservation characteristics were analyzed, the dominant unit CD34(+) cell dose was the only characteristic independently associated with engraftment (hazard ratio, 1.43; P = .002). When postthaw characteristics were also included, only dominant unit infused viable CD34(+) cell dose independently predicted engraftment (hazard ratio, 1.95; P < .001). We then examined the determinants of infused viable CD34(+) cell dose (precryopreservation count, postthaw recovery, and postthaw viability) in 402 units thawed at our center. This revealed close correlation between precryopreservation and postthaw CD34(+) cell counts (r(2) = 0.73). Median CD34(+) cell recovery was 101%, although it ranged from 12% to 1480%. Notably, units from non-Netcord Foundation for the Accreditation of Cellular Therapy (Netcord-FACT)-accredited banks were more likely to have low recovery (P < .001). Furthermore, although median postthaw CD34(+) cell viability was 92%, 33 (8%) units had <75% viable CD34(+) cells. Units from non-Netcord-FACT-accredited banks and units with cryovolumes other than 24.5 to 26.0 mL were more likely to have poor postthaw viability. Precryopreservation CD34(+) cell dose and banking practices should be incorporated into CB unit selection.

Mathematical model formulation and validation of water and solute transport in whole hamster pancreatic islets

Optimization of cryopreservation protocols for cells and tissues requires accurate models of heat and mass transport. Model selection often depends on the configuration of the tissue. Here, a mathematical and conceptual model of water and solute transport for whole hamster pancreatic islets has been developed and experimentally validated incorporating fundamental biophysical data from previous studies on individual hamster islet cells while retaining whole-islet structural information. It describes coupled transport of water and solutes through the islet by three methods: intracellularly, intercellularly, and in combination. In particular we use domain decomposition techniques to couple a transmembrane flux model with an interstitial mass transfer model. The only significant undetermined variable is the cellular surface area which is in contact with the intercellularly transported solutes, Ais. The model was validated and Ais determined using a 3×3 factorial experimental design blocked for experimental day. Whole islet physical experiments were compared with model predictions at three temperatures, three perfusing solutions, and three islet size groups. A mean of 4.4 islets were compared at each of the 27 experimental conditions and found to correlate with a coefficient of determination of 0.87±0.06 (mean ± SD). Only the treatment variable of perfusing solution was found to be significant (p<0.05). We have devised a model that retains much of the intrinsic geometric configuration of the system, and thus fewer laboratory experiments are needed to determine model parameters and thus to develop new optimized cryopreservation protocols. Additionally, extensions to ovarian follicles and other concentric tissue structures may be made.

Theoretical and experimental analyses of optimal experimental design for determination of hydraulic conductivity of cell membrane

Determination of cell hydraulic conductivity (Lp) is required to predict the optimal conditions for cell cryopreservation. One of the critical procedures associated with the determination of Lp is to measure the kinetics of cell volume change in response to a sudden cell exposure to anisosmotic media until the cells achieve an osmotic equilibrium state. To achieve accurate measurement, it should be ensured that (1) the cell osmotic equilibration process is sufficiently slow, and (2) the total cell volume change (ΔV) is much larger than the resolution of the measuring device (δ). In this article, a cell's half volume excursion time (t*) was defined as the time in which osmotically active cell water volume increases or decreases by half of its maximum change. Based on the water transport equations, a series of analytical solutions were derived. The t* and ΔV were expressed as functions of 2 control variables: initial intracellular osmolality (Mo) and extracellular osmolality (Me), and the effects of Me and Mo on t* and ΔV were predicted theoretically. The predictions were confirmed by performing experiments using two different cell types. In the light of this study, a strategy to optimize the experiment design for the Lp determination is suggested.

Cryopreservation of Peripheral Blood Stem Cells Using a Box-in-Box Cooling Device

The cooling process is critical for the cryopreservation of human hematopoietic stem cells (HSCs). Currently, programmed freezing methods and uncontrolled cooling methods are in use, both having obvious disadvantages. In this article, a novel device termed Box-in-Box (BIB) was developed and evaluated by in vitro cryopreservation tests in 2 different operation modes ("against-side" mode for Group I (n = 10), and "in-middle" mode for Group II (n = 10), respectively), and compared with an uncontrolled cooling method (Group III (n = 7), Styrofoam boxes) as well as a conventional programmed freezer method (Group IV (n = 10), CryoMed TM 1010, Cryogenic Tech., FL). Recorded temperature profiles of samples cryopreserved with BIB show that a consistent cooling procedure with a rate around -1°C to -3.5°C/min can be achieved during their transfer from room temperature to an -80°C freezer. Statistical analysis of the stem cell population recovery, survival, and colony generation recovery shows that there is no significant difference (P > 0.26) among the methods using the BIB or programmed freezer (Group I, Group II, and Group IV), and their related deviations are smaller than the uncontrolled cooling rate method (Group III). Methods using the BIB (Group I and Group II) generated significantly better cell survival rate (P < 0.01) than the uncontrolled cooling rate method (Group III). The results indicate that the controlled cooling rate methods (BIB or CryoMed PF) are more consistent and reliable for clinical use. Considering the advantages of low cost, durability, and no liquid nitrogen consumption for the cooling process, the BIB can be a good alternative to the programmed freezers for the cryopreservation of HSCs.

Cryoprotective Effect of Disaccharides on Cord Blood Stem Cells with Minimal Use of DMSO

Umbilical cord blood (UCB) is an extremely attractive source of stem cells for the treatment of various benign and malignant hematological and non-hematological disorders. To facilitate the preservation of these stem cells, 10 % dimethylsulfoxide (DMSO) is widely used as cryoprotectant in cord blood banks. But it is found to be toxic at this concentration with the result of serious side effects in recipients after infusion of DMSO-cryopreserved cells. Evaluation of viability and functionality of cryopreserved hematopoietic stem cells is needed with either inclusion of nontoxic additives alone or with reduced DMSO concentration. We assessed the post thawing viability of UCB stem cells in the freezing medium containing disaccharides (sucrose or trehalose) alone and in combination with reduced amount i.e. 2 % DMSO by trypan blue staining. The functionally active progenitor cells content of the optimized media was then evaluated and compared with 5% DMSO by a colony forming unit assay using methylcellulose based media. The freezing solution containing 0.2 M trehalose with 2 % DMSO came out to be superior in the evaluation of viability and generation of hematopoietic colonies of erythroid and myeloid lineage than 5 % DMSO alone. While the percentage of viability was lower than 2 % DMSO, as observed in the medium containing 0.2 M trehalose or sucrose alone, with poor outcome of generation of myeloid lineage based colonies. Our study results suggest that trehalose (0.2M) with the inclusion of reduced concentration of DMSO(2%) can better replace 5%DMSO rather than complete removal of DMSO from the freezing medium.

Standardized cryopreservation of pluripotent stem cells

The successful exploitation of human cells for research, translational, therapeutic, and commercial purposes requires that effective and simple cryopreservation methods be applied for storage in local and master cell banks. Of all the cell types utilized in modern research, human embryonic stem cells and their more recent relatives, induced pluripotent stem cells, are two of the most sensitive to cryopreservation. It is frequently observed that the lack of quality control and proper processing techniques yield poor recovery of pluripotent stem cells. The procedures in this unit have been optimized for handling some of the most recalcitrant stem cell lines, and provide a method for controlled-rate freezing, using minimal equipment that affords levels of cell viability comparable to expensive controlled-rate freezers. The protocol also eliminates the requirement for isopropanol, avoiding the hazards, on-going cost, and inconsistencies associated with its use and disposal. It provides a clinically relevant, inexpensive, reliable, and user-friendly method that successfully prepares cells for long-term cold storage and ensures maximum levels of cell viability post thaw.

Methods of freezing cord blood hematopoietic stem cells

BACKGROUND

Cord blood (CB) is a valuable source of hematopoietic stem cells (HSCs). Extended storage of CB is possible provided that validated cryopreservation procedures are used. The study objective was to determine optimal methods of CB cryopreservation.

STUDY DESIGN AND METHODS

In the study we 1) compared the effect of two-step cryopreservation and controlled-rate freezing method on the postthaw quality of CB (Study A) and 2) evaluated the postthaw quality of HSC fractions isolated from CB with various methods and frozen with controlled-rate freezing method (Study B). The same cryoprotectant mixture was used for 20 CB units (Study A) and 122 CB units (Study B).

RESULTS

In Study A, 13.79 × 10(8) and 13.29 × 10(8) initial white blood cell (WBC) counts decreased to 6.38 × 10(8) and 6.02 × 10(8) after thaw for the two methods, respectively. The mononuclear cell (MNC) counts decreased from 5.90 × 10(8) to 3.71 × 10(8) and from 5.64 × 10(8) to 3.47 × 10(8) dependent on the method. MNC viability decreased from 99.0% to 97.4% for the former and from 98.5% to 97.2% for the latter method. The differences were insignificant. In Study B, postthaw WBC recovery in HSC fractions was 74.4% to 103.5%, MNC recovery 106.4% to 118.5%, CD34+ cell recovery 102.5% to 150.2%, and MNC viability 94.1% to 97.4%.

CONCLUSION

Neither the cryopreservation procedure nor the freezing of isolated HSCs affected product quality, which may indicate that various freezing methods can be used for cell banking provided the they follow recommendations of good manufacturing practice and Directive 2004/33/EC.

The Assessment of Parameters Affecting the Quality of Cord Blood by the Appliance of the Annexin V Staining Method and Correlation with CFU Assays

The assessment of nonviable haematopoietic cells by Annexin V staining method in flow cytometry has recently been published by Duggleby et al. Resulting in a better correlation with the observed colony formation in methylcellulose assays than the standard ISHAGE protocol, it presents a promising method to predict cord blood potency. Herein, we applied this method for examining the parameters during processing which potentially could affect cord blood viability. We could verify that the current standards regarding time and temperature are sufficient, since no significant difference was observed within 48 hours or in storage at 4°C up to 26°C. However, the addition of DMSO for cryopreservation alone leads to an inevitable increase in nonviable haematopoietic stem cells from initially 14.8% ± 4.3% to at least 30.6% ± 5.5%. Furthermore, CFU-assays with varied seeding density were performed in order to evaluate the applicability as a quantitative method. The results revealed that only in a narrow range reproducible clonogenic efficiency (ClonE) could be assessed, giving at least a semiquantitative estimation. We conclude that both Annexin V staining method and CFU-assays with defined seeding density are reliable means leading to a better prediction of the final potency. Especially Annexin V, due to its fast readout, is a practical tool for examining and optimising specific steps in processing, while CFU-assays add a functional confirmation.

Manufacturing and banking of mesenchymal stem cells

INTRODUCTION

Mesenchymal stem cells (MSC) and MSC-like cells hold great promise and offer many advantages for developing effective cellular therapeutics. Current trends indicate that the clinical application of MSC will continue to increase markedly. For clinical applications, large numbers of MSC are usually required, ideally in an off-the-shelf format, thus requiring extensive MSC expansion ex vivo and subsequent cryopreservation and banking.

AREAS COVERED

To exploit the full potential of MSC for cell-based therapies requires overcoming significant cell-manufacturing, banking and regulatory challenges. The current review will focus on the identification of optimal cell source for MSC, the techniques for production scale-up, cryopreservation and banking and the regulatory challenges involved.

EXPERT OPINION

There has been considerable success manufacturing and cryopreserving MSC at laboratory scale. Surprisingly little attention, however, has been given to translate these technologies to an industrial scale. The development of cost-effective advanced technologies for producing and cryopreserving commercial-scale MSC is important for successful clinical cell therapy.

Clinical grade adult stem cell banking

There has been a great deal of scientific interest recently generated by the potential therapeutic applications of adult stem cells in human care but there are several challenges regarding quality and safety in clinical applications and a number of these challenges relate to the processing and banking of these cells ex-vivo. As the number of clinical trials and the variety of adult cells used in regenerative therapy increases, safety remains a primary concern. This has inspired many nations to formulate guidelines and standards for the quality of stem cell collection, processing, testing, banking, packaging and distribution. Clinically applicable cryopreservation and banking of adult stem cells offers unique opportunities to advance the potential uses and widespread implementation of these cells in clinical applications. Most current cryopreservation protocols include animal serum proteins and potentially toxic cryoprotectant additives (CPAs) that prevent direct use of these cells in human therapeutic applications. Long term cryopreservation of adult stem cells under good manufacturing conditions using animal product free solutions is critical to the widespread clinical implementation of ex-vivo adult stem cell therapies. Furthermore, to avoid any potential cryoprotectant related complications, reduced CPA concentrations and efficient post-thaw washing to remove CPA are also desirable. The present review focuses on the current strategies and important aspects of adult stem cell banking for clinical applications. These include current good manufacturing practices (cGMPs), animal protein free freezing solutions, cryoprotectants, freezing & thawing protocols, viability assays, packaging and distribution. The importance and benefits of banking clinical grade adult stem cells are also discussed.

Cryopreservation of Human Stem Cells for Clinical Application: A Review

SUMMARY: Stem cells have been used in a clinical setting for many years. Haematopoietic stem cells have been used for the treatment of both haematological and non-haematological disease; while more recently mesenchymal stem cells derived from bone marrow have been the subject of both laboratory and early clinical studies. Whilst these cells show both multipotency and expansion potential, they nonetheless do not form stable cell lines in culture which is likely to limit the breadth of their application in the field of regenerative medicine. Human embryonic stem cells are pluripotent cells, capable of forming stable cell lines which retain the capacity to differentiate into cells from all three germ layers. This makes them of special significance in both regenerative medicine and toxicology. Induced pluripotent stem (iPS) cells may also provide a similar breadth of utility without some of the confounding ethical issues surrounding embryonic stem cells. An essential pre-requisite to the commercial and clinical application of stem cells are suitable cryopreservation protocols for long-term storage. Whilst effective methods for cryopreservation and storage have been developed for haematopoietic and mesenchymal stem cells, embryonic cells and iPS cells have proved more refractory. This paper reviews the current state of cryopreservation as it pertains to stem cells and in particular the embryonic and iPS cell.

Development of a reliable low-cost controlled cooling rate instrument for the cryopreservation of hematopoietic stem cells

BACKGROUND AIMS

An optimal cooling rate is one of the critical factors influencing the survival of cells during cryopreservation. We describe a novel device, called the box-in-box, that has been developed for optimal cryopreservation of human hematopoietic stem cells (HSC).

METHODS

This work presents the design of the device, a mathematical formulation describing the expected temperature histories of samples during the freezing process, along with actual experimental results of thermal profile tests. In experiments, when the box-in-box device was transferred from room temperature to a -80 degrees C freezer, a cooling rate of -1 to -3.5 degrees C/min, which has been widely used for the cryopreservation of HSC, was achieved. In order to evaluate this device further, HSC cryopreservation was compared between the box-in-box device and a commercially available controlled-rate freezer (CryoMed).

RESULTS

The experimental data, including total cell population and CD34(+) hematopoietic progenitor cell recovery rates, viability and cell culture colony assays, showed that the box-in-box worked as well as the CryoMed instrument. There was no significant difference in either survival rate or the culture/colony outcome between the two devices.

CONCLUSIONS

The box-in-box device can work as a cheap, durable, reliable and maintenance-free instrument for the cryopreservation of HSC. This concept of a box-in-box may also be adapted to other cooling rates to support cryopreservation of a wide variety of tissues and cells.

Harvesting and cryopreservation of lymphatic endothelial cells for lymphatic tissue engineering

In order to provide a suitable source of cells for lymphatic tissue engineering, the present study was designed to investigate techniques for harvesting and cryopreservation of human dermal lymphatic endothelial cells (LECs) in vitro. The LECs were isolated from children's foreskins and then cultured in endothelial growth medium-2 MV (EGM-2-MV) with 5% FBS. The second passage LECs were suspended in cryopreservation solution containing 40% FBS and 10% Me(2)SO in EGM-2-MV, cooled to -80 degrees C at about 1 degrees C/min and stored in liquid nitrogen. Samples were thawed quickly in a 37 degrees C water bath, and the cryoprotectant was removed by serial elution. The membrane integrity of thawed LECs was determined by trypan blue staining exclusion, and their proliferation was evaluated using the MTT method. The expanded cells of two groups were identified using immunofluorescence staining and RT-PCR with lymphatic-specific markers such as Podoplanin and VEGFR-3. Uptake of fluorescent DiI-Ac-LDL and microtubular formation in three-dimensional cultures were used to detect the function of LECs. Flow cytometry was applied to identify cells and to measure the apoptosis rate as well. Cryopreservation resulted in a retrieval of 67+/-4% and an intact cell rate of 80+/-3%. The early apoptosis rate of thawed LECs (9.15+/-0.34%) was higher than that of fresh control LECs (5.31+/-0.23%). The growth curves of thawed LECs were similar to those of fresh LECs. The thawed LECs were propagated for at least 6-7 passages without alterations in phenotype and function. Highly purified LECs can be isolated by immunomagnetic beads from human dermis. The cryopreserved/thawed and recultivated LECs are proven to have high vitality and growth potential in vitro and may be considered suitable seed cells for lymphatic tissue engineering.

Cryopreservation of hematopoietic stem/progenitor cells for therapeutic use

To date, more than 25,000 hematopoietic transplants have been carried out across Europe for hematological disorders, the majority being for hematological malignancies. At least 70% of these are autologous transplants, the remaining 30% being allogeneic, which are sourced from related (70% of the allogeneic) or unrelated donors. Peripheral blood mobilized with granulocyte colony stimulating factor is the major source of stem cells for transplantation, being used in approx 95% of autologous transplants and in approx 65% of allogeneic transplants. Other cell sources used for transplantation are bone marrow and umbilical cord blood. One crucial advance in the treatment of these disorders has been the development of the ability to cryopreserve hematopoietic stem cells for future transplantation. For bone marrow and mobilized peripheral blood, the majority of cryopreserved harvests come from autologous collections that are stored prior to a planned infusion following further treatment of the patient or at the time of a subsequent relapse. Other autologous harvests are stored as backup or "rainy day" harvests, the former specifically being intended to rescue patients who develop graft failure following an allogeneic transplant or who may require this transplant at a later date. Allogeneic bone marrow and mobilized peripheral blood are less often cryopreserved than autologous harvests. This is in contrast to umbilical cord blood that may be banked for directed or sibling (related) hematopoietic stem cell transplants, for allogeneic unrelated donations, and for autologous donations. Allogeneic unrelated donations are of particular use for providing a source of hematopoietic stem cells for ethnic minorities, patients with rare human leukocyte antigen types, or where the patient urgently requires a transplant and cannot wait for the weeks to months required to prepare a bone marrow donor. There are currently more than 200,000 banked umbilical cord blood units registered with the Bone Marrow Donors Worldwide registry. In this chapter, we describe several protocols that we have used to cryopreserve these different sources of hematopoietic stem/progenitor cells, keeping in mind that the protocols may vary among transplant processing centers.

Influence of volume reduction and cryopreservation methodologies on quality of thawed umbilical cord blood units for transplantation

INTRODUCTION

Although there is considerable variability in methodology among umbilical cord blood banks, their common goal is to achieve optimal product quality for transplantation. Cryopreservation is a critical issue for a long-term maintenance of cord blood viability and colony-forming capacities.

MATERIALS AND METHODS

We designed a prospective study to compare controlled (CRF) vs. non-controlled freezing (URF) of volume-reduced cord blood units. In addition, the influence of hydroxy ethyl starch (HES) on cryopreservation was also assayed. To assess the efficiency of protocols used, cell recoveries were measured and the presence of hematopoietic colony-forming units was quantified.

RESULTS

In the study phase, we observed similar CB haematopoietc recoveries for CRF and URF strategies, except for TNC recovery that was better for HES volume reduced CB units in the URF group. When we analysed the data of routine processed CB units in samples from satellite cryovials, we found better BFU-E, CFU-GM, CFU-GEMM and CFU recoveries for those units processed with HES than without HES, in an URF manner.

CONCLUSIONS

URF of CB units is a cryopreservation procedure that allows similar hematopoietic progenitor recoveries than CRF with programmed devices. However, our study suggests that those banks that cryopreserve CB units in a URF manner should use HES for volume reduction. On the other hand, for CRF cryopreservation methodology volume reduction with and without HES are equally useful.

Collection strategies and cryopreservation of umbilical cord blood

The aim of this study was to compare (a) two different umbilical cord blood (UCB) collection methods while the placenta is still in the uterus (in utero), and (b) to evaluate the efficacy of four cryopreservation protocols based on UCB haematopoiestic stem cell (HSC) recovery. We analysed UCB samples collected with our original collection system designed for active Syringe/Flush/Syringe method or by standard in utero method. For comparing different cryopreservation procedures, dimethyl sulphoxide (DMSO) at final concentration of 5 and 10% was used and combined with our own controlled-rate or uncontrolled-rate cryopreservation. A total of 99 samples were collected. A significantly higher UCB volume, total nucleated cell and mononuclear cell were seen following the first collection strategy (n= 49; mean +/- SD, 103 +/- 35.4 mL; 12.34 +/- 5.27 x 10(8); 595 +/- 3.47 x 10(6)) vs. the second strategy (n= 50; 86 +/- 29.3 mL; 9.87 +/- 4.47; 424 +/- 2.82 x 10(6)) respectively (P < 0.01). The discard rate was 14% for the first and 36% for the second collection strategy (P < 0.01). It was shown that the most efficient procedure was the controlled-rate protocol combined with lower (5%) DMSO concentration. Using active Syringe/Flush/Syringe method, we collected UCB with greater volumes and with lower discard rate compared to the standard by gravity technique. The data presented also showed much better recovery of UCB cells when controlled-rate freezing procedure and 5% DMSO were combined.

Analysis and cryopreservation of hematopoietic stem and progenitor cells from umbilical cord blood

BACKGROUND

Umbilical cord blood (UCB) is an important source of hematopoietic stem and progenitor cells (HSC/HPC) for the reconstitution of the hematopoietic system after clinical transplantation. Cryopreservation of these cells is critical for UCB banking and transplantation as well as for research applications by providing readily available specimens. The objective of this study was to optimize cryopreservation conditions for CD34+ HSC/HPC from UCB.

METHODS

Cryopreservation of CD34+ HSC/HPC from UCB after mononuclear cell (MNC) preparation was tested in a research-scale setup. Experimental variations were concentration of the cryoprotectant, the protein additive and cell concentration. In addition, protocols involving slow, serial addition and removal of DMSO were compared with standard protocols (fast addition and removal of DMSO) in order to avoid osmotic stress for the cryopreserved cells. Viability and recoveries of MNC, CD34+ cells and total colony-forming units (CFU) were calculated as read-outs. In addition, sterility testing of the collected UCB units before further processing was performed.

RESULTS

The optimal conditions for cryopreservation of CD34+ HPC in MNC preparations were 10% DMSO and 2% human albumin at high cell concentrations (5 x 10(7) MNC/mL) with fast addition and removal of DMSO. After cryopreservation using a computer-controlled freezer, high viabilities (89%) and recoveries for CD34+ cells (89%) as well as for CFU (88%) were observed. Microbial contamination of the collected UCB samples was reduced to a rate of 6.4%.

DISCUSSION

Optimized cryopreservation conditions were developed for UCB MNC in respect of the composition of the cryosolution. In addition, our results showed that fast addition of DMSO is essential for improved cryopreservation and post-thaw quality assessment results, whereas the speed of DMSO removal after thawing has little influence on the recoveries of CD34+ cells and CFU.