Fermentation and lactic acid addition enhance iron bioavailability of maize

Developing an Acceptable Nixtamalised Maize Product for South African Consumers: Sensory, Survey and Nutrient Analysis

South Africa produces high-quality maize, yet food insecurity and malnutrition are prevalent. Maize is a staple for most South Africans and is often eaten as pap, gruel cooked from maize meal (corn flour) and water without diet diversification. Considering the reliance on maize in low-income communities, could nixtamalised maize products be developed that are nutritious, homemade and consumer-acceptable? Nixtamalisation could offer a solution. However, its acceptability and nutritional benefits remain in question. We aimed to develop a product using consumer-led methods. Consumer panels evaluated and selected products using overall acceptability (9-point hedonic scale), Just-About-Right (JAR) and penalty analysis. Consumer-acceptable nixtamalised chutney-flavoured maize chips were moderately liked (7.35) and reached acceptable JAR scores (74.2%). The nixtamalised products were liked and liked very much (56%), 61% of panel members agreed and strongly agreed to purchase and prepare, and 50% to consume nixtamalised products. Nutrient analysis of the chutney chips showed high energy (2302 kJ/100 g) and total fats (23.72), of which saturated fats were 11.47%. Total fibre (17.19 g/100 g), protein (6.64 g/100 g), calcium (163.3) and magnesium (53.67 g/100 g) were promising, while high phosphorous (566.00 mg/100 g) may indicate anti-nutrients present. Nixtamalisation can alleviate food insecurity and malnutrition in countries such as South Africa.

Effect of fermentation on nutrient composition, antinutrients, and mineral bioaccessibility of finger millet based Injera: A traditional Ethiopian food

Finger millet, like other cereals, contains high amounts of antinutrients that bind minerals, making them unavailable for absorption. This study explores the effect of traditional fermentation on nutritional, antinutritional, and subsequent mineral bioaccessibility (specifically iron, zinc, and calcium) of finger millet based Injera. Samples of fermented dough and Injera prepared from light brown and white finger millet varieties were analyzed for nutritional composition, antinutritional content, and mineral bioaccessibility following standard procedures. With some exceptions, the proximate composition of fermented dough was significantly affected by fermentation time. Compared to unfermented flour, the phytate and condensed tannin content significantly (p < 0.05) decreased for fermented dough and Injera samples. A strong decline in phytate and condensed tannin content was observed in white finger millet Injera as fermentation time increased, compared to light brown finger millet based Injera. The mineral bioaccessibility of Injera prepared from finger millet and maize composite flour increased with fermentation time, leading to a significant increase in bioaccessible iron, zinc, and calcium, ranging from 15.4-40.0 %, 26.8-50.8 %, and 60.9-88.5 %, respectively. The results suggest that traditional fermentation can be an effective method to reduce phytate and condensed tannin content, simultaneously increasing the bioaccessibility of minerals in the preparation of finger millet based Injera.

Circularity in Europe strengthens the sustainability of the global food system

Redesigning the European food system on the basis of circularity principles could bring environmental benefits for Europe and the world. Here we deploy a biophysical optimization model to explore the effects of adopting three circularity scenarios in the European Union (EU)27 + UK. We calculate a potential reduction of 71% in agricultural land use and 29% per capita in agricultural greenhouse gas emissions, while producing enough healthy food within a self-sufficient European food system. Under global food shortages, savings in agricultural land could be used to feed an additional 767 million people outside the EU (+149%), while reducing per capita greenhouse gas emissions by 38% but increasing overall emissions by 55% due to the increased population served. Transitioning the EU's food system towards circularity implies sequential changes among all its components and has great potential to safeguard human and planetary health.

Lactate Production can Function to Increase Human Epithelial Cell Iron Concentration

Introduction

Under conditions of limited iron availability, plants and microbes have evolved mechanisms to acquire iron. For example, metal deficiency stimulates reprogramming of carbon metabolism, increasing activity of enzymes involved in the Krebs cycle and the glycolytic pathway. Resultant carboxylates/hydroxycarboxylates then function as ligands to complex iron and facilitate solubilization and uptake, reversing the metal deficiency. Similarly, human intestinal epithelial cells may produce lactate, a hydroxycarboxylate, during absolute and functional iron deficiency to import metal to reverse limited availability.

Methods

Here we investigate (1) if lactate can increase cell metal import of epithelial cells in vitro, (2) if lactate dehydrogenase (LDH) activity in and lactate production by epithelial cells correspond to metal availability, and (3) if blood concentrations of LDH in a human cohort correlate with indices of iron homeostasis.

Results

Results show that exposures of human epithelial cells, Caco-2, to both sodium lactate and ferric ammonium citrate (FAC) increase metal import relative to FAC alone. Similarly, fumaric, isocitric, malic, and succinic acid coincubation with FAC increase iron import relative to FAC alone. Increased iron import following exposures to sodium lactate and FAC elevated both ferritin and metal associated with mitochondria. LDH did not change after exposure to deferoxamine but decreased with 24 h exposure to FAC. Lactate levels revealed decreased levels with FAC incubation. Review of the National Health and Nutrition Examination Survey demonstrated significant negative relationships between LDH concentrations and serum iron in human cohorts.

Conclusions

Therefore, we conclude that iron import in human epithelial cells can involve lactate, LDH activity can reflect the availability of this metal, and blood LDH concentrations can correlate with indices of iron homeostasis.

A Review of Nutrients and Compounds, Which Promote or Inhibit Intestinal Iron Absorption: Making a Platform for Dietary Measures That Can Reduce Iron Uptake in Patients with Genetic Haemochromatosis

OBJECTIVE

To provide an overview of nutrients and compounds, which influence human intestinal iron absorption, thereby making a platform for elaboration of dietary recommendations that can reduce iron uptake in patients with genetic haemochromatosis.

DESIGN

Review. Setting. A literature search in PubMed and Google Scholar of papers dealing with iron absorption.

RESULTS

The most important promoters of iron absorption in foods are ascorbic acid, lactic acid (produced by fermentation), meat factors in animal meat, the presence of heme iron, and alcohol which stimulate iron uptake by inhibition of hepcidin expression. The most important inhibitors of iron uptake are phytic acid/phytates, polyphenols/tannins, proteins from soya beans, milk, eggs, and calcium. Oxalic acid/oxalate does not seem to influence iron uptake. Turmeric/curcumin may stimulate iron uptake through a decrease in hepcidin expression and inhibit uptake by complex formation with iron, but the net effect has not been clarified.

CONCLUSIONS

In haemochromatosis, iron absorption is enhanced due to a decreased expression of hepcidin. Dietary modifications that lower iron intake and decrease iron bioavailability may provide additional measures to reduce iron uptake from the foods. This could stimulate the patients' active cooperation in the treatment of their disorder and reduce the number of phlebotomies.

Investigation of a spontaneous mutant reveals novel features of iron uptake in Shewanella oneidensis

Shewanella oneidensis is among the first and the best studied bacteria capable of respiring minerals as terminal electron acceptors (EAs), including a variety of iron ores. This respiration process relies on a large number of c-type cytochromes, which per se are iron-containing proteins. Thus, iron plays an essential and special role in iron respiration of S. oneidensis, prompting extensive investigations into iron physiology. Despite this, we still know surprisingly little about the components and characteristics of iron transport in this bacterium. Here, we report that TonB-dependent receptor PutA (SO_3033) is specific to the siderophore-mediated iron uptake. Although homologs of PutA are abundant, none of them can function as a replacement. In the absence of PutA, S. oneidensis suffers from an iron shortage, which leads to a severe defect in production of cytochrome c. However, proteins requiring other types of cytochromes, such as b and d, do not appear to be significantly impacted. Intriguingly, lactate, but not other carbon sources that are routinely used to support growth, is able to promote iron uptake when PutA is missing. We further show that the lactate-mediated iron import is independent of lactate permeases. Overall, our results suggest that in S. oneidensis the siderophore-dependent pathway plays a key role in iron uptake when iron is limited, but many alternative routes exist.

Replacing electrolytic iron in a fortification-mix with NaFeEDTA increases both iron and zinc availabilities in traditional African maize porridges

While replacing electrolytic iron with NaFeEDTA in multi-micronutrient fortification-mixes is a popular option, there is no information about the effect on the iron and zinc availabilities in African staple foods. This study evaluated the effects of adding a multi-micronutrient fortification-mix, with no iron, electrolytic iron or NaFeEDTA on the availabilities of iron and zinc from thick and fermented special-grade maize porridges using a Caco-2 cell model. Replacing electrolytic iron with NaFeEDTA significantly (p ⩽ 0.05) increased iron and, importantly zinc, availabilities in both the thick (2.16% vs. 1.45% and 2.51% vs. 2.29%, respectively) and fermented (3.35% vs. 2.66% and 3.04% vs. 2.61%, respectively) porridges. Some of the NaFeEDTA complexes perhaps partially dissociated because of pH changes during simulated digestion, binding with zinc and increasing its availability. NaFeEDTA in a multi-micronutrient fortification-mix, added to less refined, high phytate maize meal, would be more effective than electrolytic iron in addressing both iron and zinc deficiencies in low socio-economic populations of sub-Saharan Africa.

Iron-Binding Capacity of Defatted Rice Bran Hydrolysate and Bioavailability of Iron in Caco-2 Cells

The present study was aimed at utilizing defatted rice bran (DRB) protein as an iron-binding peptide to enhance iron uptake in humans. DRB samples were treated with Alcalase and Flavourzyme, and the total extractable peptides were determined. Furthermore, the iron-binding capacities of the DRB protein hydrolysates were determined, whereas iron bioavailability studies were conducted using an in vitro digestion and absorption model (Caco-2 cells). The results showed that the DRB protein hydrolysates produced by combined Alcalase and Flavourzyme hydrolysis had the best iron-binding capacity (83%) after 90 min of hydrolysis. The optimal hydrolysis time to produce the best iron-uptake in Caco-2 cells was found to be 180 min. The results suggested that DRB protein hydrolysates have potent iron-binding capacities and may enhance the bioavailability of iron, hence their suitability for use as iron-fortified supplements.

Increased iron bioavailability from lactic-fermented vegetables is likely an effect of promoting the formation of ferric iron (Fe(3+))

Background

Lactic fermentation of foods increases the availability of iron as shown in a number of studies throughout the years. Several explanations have been provided such as decreased content of inhibitory phytate, increased solubility of iron, and increased content of lactic acid in the fermented product. However, to our knowledge, there are no data to support that the bioavailability of iron is affected by lactic fermentation.

Objectives

The objective of the present study was to investigate whether the bioavailability of iron from a vegetable mix was affected by lactic fermentation and to propose a mechanism for such an event, by conducting human and cell (Caco-2, HepG2) studies and iron speciation measurements (voltammetry). We also investigated whether the absorption of zinc was affected by the lactic fermentation.

Results

In human subjects, we observed that lactic-fermented vegetables served with both a high-phytate and low-phytate meal increased the absorption of iron, but not zinc. In vitro digested fermented vegetables were able to provoke a greater hepcidin response per ng Fe than fresh vegetables, indicating that Fe in the fermented mixes was more bioavailable, independent on the soluble Fe content. We measured that hydrated Fe³⁺ species were increased after the lactic fermentation, while there was no significant change in hydrated Fe²⁺. Furthermore, lactate addition to Caco-2 cells did not affect ferritin formation in response to Fe nor did lactate affect the hepcidin response in the Caco-2/HepG2 cell system.

Conclusions

The mechanism for the increased bioavailability of iron from lactic-fermented vegetables is likely an effect of the increase in ferric iron (Fe³⁺) species caused by the lactic fermentation. No effect on zinc bioavailability was observed.

A higher proportion of iron-rich leafy vegetables in a typical Burkinabe maize meal does not increase the amount of iron absorbed in young women

Food-to-food fortification can be a promising approach to improve the low dietary iron intake and bioavailability from monotonous diets based on a small number of staple plant foods. In Burkina Faso, the common diet consists of a thick, cereal-based paste consumed with sauces composed of mainly green leaves, such as amaranth and jute leaves. Increasing the quantity of leaves in the sauces substantially increases their iron concentration. To evaluate whether increasing the quantity of leaves in sauces would provide additional bioavailable iron, an iron absorption study in 18 young women was conducted in Zurich, Switzerland. Burkinabe composite test meals consisting of the maize paste tô accompanied by an iron-improved amaranth sauce, an iron-improved jute sauce, or a traditional amaranth sauce were provided as multiple meals twice a day for 2 consecutive days. Iron absorption was measured as erythrocyte incorporation of stable iron isotopes. Mean fractional iron absorption from maize paste consumed with an iron-improved amaranth sauce (4.9%) did not differ from the same meal consumed with an iron-improved jute sauce (4.9%; P = 0.9), resulting in a similar quantity of total iron absorbed (679 vs. 578 μg; P = 0.3). Mean fractional iron absorption from maize paste accompanied by a traditional amaranth sauce (7.4%) was significantly higher than that from the other 2 meal types (P < 0.05), but the quantity of total iron absorbed was similar (591 μg; P = 0.4 and 0.7, respectively). A food-to-food fortification approach based on an increase in leafy vegetables does not provide additional bioavailable iron, presumably due to the high phenolic compound concentration of the leaves tested. Alternative measures, such as adding iron absorption enhancers to the sauces, need to be investigated to improve iron nutrition from Burkinabe maize meals.

Lactic acid and thermal treatments trigger the hydrolysis of myo-inositol hexakisphosphate and modify the abundance of lower myo-inositol phosphates in barley (Hordeum vulgare L.)

Barley is an important source of dietary minerals, but it also contains myo-inositol hexakisphosphate (InsP₆) that lowers their absorption. This study evaluated the effects of increasing concentrations (0.5, 1, and 5%, vol/vol) of lactic acid (LA), without or with an additional thermal treatment at 55°C (LA-H), on InsP₆ hydrolysis, formation of lower phosphorylated myo-inositol phosphates, and changes in chemical composition of barley grain. Increasing LA concentrations and thermal treatment linearly reduced (P<0.001) InsP₆-phosphate (InsP₆-P) by 0.5 to 1 g compared to the native barley. In particular, treating barley with 5% LA-H was the most efficient treatment to reduce the concentrations of InsP₆-P, and stimulate the formation of lower phosphorylated myo-inositol phosphates such as myo-inositol tetraphosphate (InsP₄) and myo-inositol pentaphosphates (InsP₅). Also, LA and thermal treatment changed the abundance of InsP₄ and InsP₅ isomers with Ins(1,2,5,6)P₄ and Ins(1,2,3,4,5)P₅ as the dominating isomers with 5% LA, 1% LA-H and 5% LA-H treatment of barley, resembling to profiles found when microbial 6-phytase is applied. Treating barley with LA at room temperature (22°C) increased the concentration of resistant starch and dietary fiber but lowered those of total starch and crude ash. Interestingly, total phosphorus (P) was only reduced (P<0.05) in barley treated with LA-H but not after processing of barley with LA at room temperature. In conclusion, LA and LA-H treatment may be effective processing techniques to reduce InsP₆ in cereals used in animal feeding with the highest degradation of InsP₆ at 5% LA-H. Further in vivo studies are warranted to determine the actual intestinal P availability and to assess the impact of changes in nutrient composition of LA treated barley on animal performance.

Iron contamination during in-field milling of millet and sorghum

Nutritionally, contaminant iron in foods may lead to overestimation of the satisfaction of iron requirement while iron deficiencies remain a widespread health problem. Iron contamination was measured in millet and sorghum grains after decortication and in-field milling using different equipments in Burkina Faso. Total iron content did not change significantly after decortication, probably due to a balance between losses resulting from the removal of iron-rich peripheral parts and contamination. Total iron contents increased significantly after mechanical milling irrespective of whether iron or corundum grindstones were used. Contamination was highly variable, ranging from 3 to 6 mg iron/100 g DM, and was mainly due to wear of the milling equipment. After in vitro digestion of traditional cereal dishes prepared with iron-contaminated or uncontaminated flours, the contaminant iron was found mainly in the insoluble fraction. Only in sorghum was a small proportion (4%) bioaccessible, showing that contaminant iron has poor nutritional interest.

Iron bioavailability of maize hemoglobin in a Caco-2 cell culture model

Maize ( Zea mays ) is an important staple crop in many parts of the world but has low iron bioavailability, in part due to its high phytate content. Hemoglobin is a form of iron that is highly bioavailable, and its bioavailability is not inhibited by phytate. It was hypothesized that maize hemoglobin is a highly bioavailable iron source and that biofortification of maize with iron can be accomplished by overexpression of maize globin in the endosperm. Maize was transformed with a gene construct encoding a translational fusion of maize globin and green fluorescent protein under transcriptional control of the maize 27 kDa γ-zein promoter. Iron bioavailability of maize hemoglobin produced in Escherichia coli and of stably transformed seeds expressing the maize globin-GFP fusion was determined using an in vitro Caco-2 cell culture model. Maize flour fortified with maize hemoglobin was found to have iron bioavailability that is not significantly different from that of flour fortified with ferrous sulfate or bovine hemoglobin but is significantly higher than unfortified flour. Transformed maize grain expressing maize globin was found to have iron bioavailability similar to that of untransformed seeds. These results suggest that maize globin produced in E. coli may be an effective iron fortificant, but overexpressing maize globin in maize endosperm may require a different strategy to increase bioavailable iron content in maize.

Changes in iron, zinc and chelating agents during traditional African processing of maize: Effect of iron contamination on bioaccessibility

The effect of the different unit operations of processing traditionally used to produce four maize foods commonly consumed in Africa on the nutritional composition of the products was investigated, using Benin as a study context. The impact of the processes on lipid, fibre, phytate, iron and zinc contents varied with the process. The lowest IP6/Fe and IP6/Zn molar ratios, the indices used to assess Fe and Zn bioavailability were obtained in mawè, a fermented dough. Analysis of maize products highlighted a significant increase in iron content after milling, as a result of contamination by the equipment used. Evaluation of iron bioaccessibility by in vitro enzymatic digestion followed by dialysis revealed that the iron contamination, followed by lactic acid fermentation, led to a considerable increase in bioaccessible iron content. Extrinsic iron supplied to food products by the milling equipment could play a role in iron intake in developing countries.

Role of antioxidant enzymes in bacterial resistance to organic acids

Growth in aerobic environments has been shown to generate reactive oxygen species (ROS) and to cause oxidative stress in most organisms. Antioxidant enzymes (i.e., superoxide dismutases and hydroperoxidases) and DNA repair mechanisms provide protection against ROS. Acid stress has been shown to be associated with the induction of Mn superoxide dismutase (MnSOD) in Lactococcus lactis and Staphylococcus aureus. However, the relationship between acid stress and oxidative stress is not well understood. In the present study, we showed that mutations in the gene coding for MnSOD (sodA) increased the toxicity of lactic acid at pH 3.5 in Streptococcus thermophilus. The inclusion of the iron chelators 2,2'-dipyridyl (DIP), diethienetriamine-pentaacetic acid (DTPA), and O-phenanthroline (O-Phe) provided partial protection against 330 mM lactic acid at pH 3.5. The results suggested that acid stress triggers an iron-mediated oxidative stress that can be ameliorated by MnSOD and iron chelators. These findings were further validated in Escherichia coli strains lacking both MnSOD and iron SOD (FeSOD) but expressing a heterologous MnSOD from S. thermophilus. We also found that, in E. coli, FeSOD did not provide the same protection afforded by MnSOD and that hydroperoxidases are equally important in protecting the cells against acid stress. These findings may explain the ability of some microorganisms to survive better in acidified environments, as in acid foods, during fermentation and accumulation of lactic acid or during passage through the low pH of the stomach.

Effect of dephytinization on bioavailability of iron, calcium and zinc from infant cereals assessed in the Caco-2 cell model

AIM: To test the effect of the dephytinization of three different commercial infant cereals on iron, calcium, and zinc bioavailability by estimating the uptake, retention, and transport by Caco-2 cells.

METHODS: Both dephytinized (by adding an exogenous phytase) and non-dephytinized infant cereals were digested using an in vitro digestion protocol adapted to the gastrointestinal conditions of infants younger than 6 mo. Mineral cell retention, transport, and uptake from infant cereals were measured using the soluble fraction of the simulated digestion and the Caco-2 cells.

RESULTS: Dephytinization of infant cereals significantly increased (P < 0.05) the cell uptake efficiency (from 0.66%-6.05% to 3.93%-13%), retention (from 6.04%-16.68% to 14.75%-20.14%) and transport efficiency (from 0.14%-2.21% to 1.47%-6.02%), of iron, and the uptake efficiency (from 5.0%-35.4% to 7.3%-41.6%) and retention (from 4.05%-20.53% to 14.45%-61.3%) of zinc, whereas calcium only cell uptake showed a significant increase (P < 0.05) after removing phytate from most of the samples analyzed. A positive relationship (P < 0.05) between mineral solubility and the cell uptake and transport efficiencies was observed.

CONCLUSION: Removing phytate from infant cereals had a beneficial effect on iron and zinc bioavailability when infant cereals were reconstituted with water. Since in developing countries cereal-based complementary foods for infants are usually consumed mixed with water, exogenous phytase additions could improve the nutritional value of this weaning food.