Quantitative studies of food protein degradation and the energetic efficiency of microbial protein synthesis in the rumen of sheep given chopped lucerne and rolled barley

Determination of in vitro dry matter, protein, and fiber digestibility and fermentability of novel corn coproducts for swine and ruminants

New processes are being used in some dry-grind ethanol plants in the United States and Brazil to improve ethanol yield and efficiency of production while also providing nutritionally enhanced corn coproducts compared with conventional corn distillers dried grains with solubles (DDGS). The objectives of this study were to determine the chemical composition and in vitro digestibility of 5 conventional corn DDGS sources and 10 emerging novel corn coproducts for swine and ruminants, and compare coproducts produced using similar processes in the United States and Brazil. Chemical composition, on a dry matter (DM) basis, among the 15 coproducts ranged from 18.5% to 54.7% for crude protein (CP), 12.3% to 51.4% for neutral detergent fiber (NDF), 1.6% to 8.6% for acid detergent fiber, 4.7% to 12.3% for ether extract, and 1.6% to 8.6% for ash. For swine, in vitro hydrolysis of DM and CP were greater (P < 0.01) for the three U.S. corn DDGS sources compared with the two Brazilian corn DDGS sources, but in vitro fermentability of DM was comparable (P > 0.05) among all sources except one U.S. DDGS source that had less fermentable DM. High-protein and yeast dried distillers grains (Ultramax, UM; StillPro, SP) coproducts also had comparable (P > 0.05) DM fermentability for swine, but UM coproducts had greater (P < 0.01) DM and CP hydrolysis compared with SP. High-protein distillers dried grains (HP-DDG) from Brazil had greater (P < 0.01) DM and CP hydrolysis, but less (P < 0.01) DM fermentability for swine than HP-DDG produced in the United States, using the same process. For ruminants, total DM digestibility was greater (P < 0.01) in conventional DDGS sources from the United States compared with the two DDGS sources from Brazil. Total protein digestibility for ruminants was comparable and above 81% for all coproducts except for a DDGS source from Brazil, a HP-DDG source from the United States, and a UM sample. Interestingly, the corn fiber + solubles coproduct had not only relatively high digestibility of NDF (67.9%), DM (91.6%), and total CP (81.9%) for ruminants, but it also had relatively high total tract digestibility of DM (86.2%) and CP (69.9%) for swine. These results suggest that nutrient digestibility of conventional DDGS sources produced in the United States appear to be greater than corn Brazilian DDGS sources, but new process technologies being implemented in ethanol and coproduct production in both countries can enhance the nutritional value of corn coproducts for both swine and ruminants.

1.1 Nitrogen Metabolism in the Rumen

The concept that the protein reaching the duodenum of a ruminant comprises of two major components, feed and microbial, has been accepted for many years but recently there has been considerable interest in attempts to define and quantify those processes which have an influence on the quantity and quality of this protein. The main reason for this is the desire to predict accurately the total flow of protein to the duodenum when a particular diet is fed. The ability to do this, coupled with a refinement of knowledge on the needs of the animal, are essential steps in improving the efficiency with which ruminants are fed. This review examines some of the factors which control the breakdown of dietary protein and the synthesis of microbial protein in the rumen. The lack of space has prevented discussion of many important topics, for example, the contribution of endogenous proteins to the total protein entering the duodenum. Many reviews have been published in this area (see Egan, 1980; Demeyer and Van Nevel, 1980; others are referred to in the text).

4.1 The Nitrogen Needs of Ruminants

The organizers of this symposium invited me to review factors which influence the N needs of ruminants. Such a request seems to imply that, for each class of ruminant, e.g. cattle or sheep, growing or lactating, there is a definitive N or amino acid requirement. If this is known, then diets may be formulated to provide that amount of N or amino acid and the expected level of production should be achieved. As a corollary of this approach, the determination of the nutritional characteristics of the diet, its metabolizable energy (ME), rumen degradable protein (RDP) or undegraded protein (UDP), appears to be a separate issue. While such a simplistic view has advantages for ease of diet formulation, it is unlikely to be entirely correct. In general, animal responses to increasing nutrient supply are curvilinear and do not show sharp break points defining a minimum amount of nutrient to give maximum production. Secondly, animal responses are not independent of diet and, conversely, the energy and protein values of the diet depend on the physiological state of the animal, e.g. the level of food intake influences rate of passage of digesta, the extent and site of digestion and the form of metabolites absorbed.

3.2 Utilization of Conserved Forages

From the late autumn until the spring, a large proportion of the ruminant livestock in the United Kingdom, dairy cows especially, are housed indoors or sheltered and given rations of hay or silage ad libitum with supplementary feeds to provide additional energy and protein. During this period, feeding costs form the major portion of the total cost of meat and milk production and decisions about the type and quality of the conserved forage and about the amount and composition of the concentrate are of crucial economic importance. Against this background, this paper discusses the utilization of forage crude protein and considers in particular the factors influencing the supply of amino acids absorbed from the animal's gut and the implications of the use of supplementary concentrate feeds.

Effect of forage to concentrate ratio in complete diets offered to sheep on voluntary food intake and some digestive parameters

Twelve mature ewes were used to study the effect of forage: concentrate ratio in complete diets on voluntary intake and some digestive characteristics. Diets consisted of four combinations of chopped lucerne hay and a concentrate (390 g cracked barley grains, 440 g cracked maize grains and 170 g soya-bean meal per kg of concentrate) in the following proportions (fresh matter basis): 0·8:0·2 (C20), 0·6:0·4 (C40), 0·4:0·6 (C60) and 0·2:0·8 (C80). Diets were offered over two 42-day periods and, in each of them, three sheep received one of the four diets, with the restriction that no animal received the same diet in both periods. Chromium Ill-mordanted fibre was used as a marker to estimate passage rate of digest a and microbial nitrogen supply (MNS) was estimated from the urinary excretion of purine derivatives. The increase in the proportion of concentrate affected linearly (P< 0·05) the voluntary intake of food, the mean values being 36·8, 37·9, 36·3 and 30·0 g dry matter (DM) per kg live weight per day for C20, C40, C60 and C80 diets, respectively. Apparent digestibility of DM, organic matter (OM) and crude protein increased linearly (P< 0·01) with the proportion of concentrate in the diet, whereas that of cellulose evolved auadratically (P< 0·05), reaching a minimum value in the C80 diet. Digestible OM intake was unaffected (P> 0·05) by the proportion of concentrate in the diet. Both particulate passage rate from the rumen and through the caecum and proximal colon decreased linearly (P< 0·05) as concentrate proportion in the diet increased. MNS (g/day) was not affected (P> 0·05) by the diet, whereas its efficiency (g/kg digestible OM intake) tended (P< 0·10) to increase with the proportion of concentrate in the diet.

Effect of forage to concentrate ratio in the diet on ruminal fermentation and digesta flow kinetics in sheep offered food at a fixed and restricted level of intake

The effects of four diets differing in their for age: concentrate ratio (80:20, 60:40, 40: 60 and 20:80; g/100 g fresh matter) on rumen characteristics, digestibility and digesta flow kinetics were investigated. Alfalfa hay was used as forage and concentrate was composed of barley, soya-bean meal and maize. Diets were prepared by mixing all ingredients and offered to the animals as complete diets. Eight mature Merino sheep, each fitted with a rumen cannula, were offered 1·055 kg dry matter per day of the corresponding diet over two experimental periods. The daily evolution of ruminai pH, volatile fatty acids (VFA) and ammonia nitrogen (N) concentrations were measured. Digestibility was determined by total faecal collection and Cr and Co were used as markers to estimate digesta passage rates. Microbial nitrogen flow at the duodenum (MNDF) was estimated from the urinary excretion of purine derivatives (PD). The apparent digestibility of organic matter increased (P < 0·001) whereas that of all fibrous fractions decreased linearly (P < 0·05) as the proportion of concentrate in the diet increased. Rumen pH decreased linearly (P < 0·001) with increasing proportions of concentrate but total VFA concentrations were unaffected by changes in the diet (P > 0·05). Both liquid and solid digesta outflow rates from the rumen decreased quadratically (P < 0·01) as the proportion of concentrate in the diet increased. The urinary excretion of total N, urea-N and ammonia-N was unaffected (P > 0·05) by changes in the diet. In contrast, the daily urinary excretion of both allantoin and total PD increased quadratically (P < 0·05) with increasing proportions of concentrate. Consequently, the estimated MNDF increased linearly (P < 0·001) from 9·9 g/day on the high forage diet to 14·5 g/day on the high concentrate diet.

A note on the use of field beans (Vicia faba) in lamb finishing diets

Two feeding experiments with housed lambs of the Spanish Manchega breed were carried out over 2 years with the aim of assessing the suitability of field beans in lamb finishing diets. In the 1st year field beans were compared with soya-bean meal as a protein source in a factorial experimental design with the proportion of maize in the diet being 0·15, 0·25 or 0·35. In the second experiment the effect of replacing soya-bean meal and sunflower meal by inclusion of field beans at proportions, 0, 0·1, 0·2, 0·3 and 04 of the diet was studied. All diets were isoenergetic and isoproteic. The composition of the diets had no significant effects on the average daily gain or the food conversion ratio in either experiment. Results from experiment 2 showed that the increasing amount of field beans in the basal diet did not affect protein, fat and water content of a loin sample of meat, or fatty acid composition of kidney fat.

Efficiency of utilization during pregnancy and lactation in the ewe of the protein reaching the abomasum and truly digested in the small intestine

In six experiments carried out on individually penned Finn Dorset ewes estimates were made of the quantities of non-ammonia nitrogen (NAN) reaching the abomasum and truly digested in the small intestine. For experiments 1 and 2 which each involved 33 ewes given a complete diet of milled hay and concentrates supplemented with varying amounts of a good-quality fish meal during late pregnancy, the overall regression estimate for the daily amount of truly digested NAN required for zero N retention (ewe plus conceptus) was 438 mg/kg M0·75 (441 and 434 for experiments 1 and 2 respectively). The coefficients for the efficiency of utilization of increments of truly digested NAN and maternal tissue N for net N accretion in the conceptus were 0·48 (s.e. 0·039) and 0·84 (s.e. 0·127) respectively.

In experiment 3, 24 lactating ewes had their diet supplemented with either soya-bean meal or fish meal. There was no effect of protein source on the amounts of NAN reaching the abomasum in ewes fitted with an abomasal cannula or on milk yield and these observations confirmed the unusually high degradability (measured by the polyester bag technique) of the fish-meal protein in the rumen. For experiments 4, 5 and 6 a total of 36 ewes were used to test the efficiency with which the NAN truly digested in the small intestine was used for the synthesis of milk protein. In the absence of data on the possible contribution of body tissue N to milk N the coefficient for the apparent efficiency of utilization of truly digested NAN when the ewes were given a basal diet containing approximately 10 g crude protein per MJ metabolizable energy was 0·63. For those ewes receiving the basal diet supplemented with either soya-bean meal, fish meal or blood meal the coefficients for the efficiency of utilization for the production of milk N of the increments in truly digested NAN supplied by the three protein sources were 0·61, 0·54 and 0·29 respectively. It is suggested that the low coefficient for blood meal may be due to its low content of methionine.

Contribution of dietary nitrogen and purine bases to the duodenal digesta: comparison of duodenal and polyester-bag measurements

Four ewes fitted with ruminal and duodenalT-piece cannulas were given fourdietsin a 4 × 4 factorial design. Diets consisted of 700 (HF) or 400 (LF) g/day of ammonia-treated barley straw supplemented respectively with 150 or 600 g/day of concentrate made up with barley plus either soya-bean meal (SBM) or fishmeal (FM) as the protein source, offered at 2-h intervals. Duodenal flowsof digestawere estimated by the dual-phasetechniqueusing CoEDTAand Yb-acetate as markers and (15NH4)2SO4 was infusedinto the rumento label microbial N. Bacteria were isolated from the liquid (LAB) or solid (SAB) rumendigesta. Purinebases (PB) were isolated by precipitationin an acid solution of AgN03, and microbial contribution either to the duodenalnitrogen(N) or PB were determinedby 15N measurements induodenaldigesta and bacteria.Simultaneously, therumen degradation of Nand PB contained in SBM and FM was studiedby incubating supplements in polyesterbags in the rumen.PBcontent (mmol/g dry matter)and guanine: adenine(G/A) ratio of barley strawwas 2·89 and 5·23; barley grain,7·91 and 111;SBM, 18·8 and 1·26; and FM, 58·9 and 6·96, respectively. Duodenal flow ofPB(mmol/day)was significantly higher than PB intake on all diets and G/A ratio showed a meanvalue of 0·97, similarto the ratios determined in SAB(0·80) and LAB (1·04) and muchlower than diets(1·31 to 4·32). Microbial contribution to duodenal Nflow ranged from43·3% to 61·0%, beinghigherin SBM(59·0%)thanin FM(46·7%)diets. However, microbial contribution to duodenal PB was not affected by the experimentaltreatment, accounting for proportionately 0·77 of total PB at the duodenum. Rumen degradability of PB was much higher than that of total N and in both cases degradability was higher in SBM than FM. Direct measurements of non-microbialN were significantly higher than values determined by the polyester-bagmeasurements. However, once corrected forthe endogenousN (52 mgN per kg live weight)contribution, results show edan acceptable agreement. Duodenal flow of PB non-attributable to microbes (unlabelled PB) showed a mean value of 3·25 mmol/daywithouta significanteffect of dietary treatment. However, undegradablePBsupply determinedfor0·02, 0·05 and 0·08 per h fractional out flow rates were proportionately lower than 0·025 with SBM and 0·100 with FM diets of the estimated duodenalPB flow. Despite the magnitudeof the unlabelledduodenalPB, the close agreement between G/A ratios in duodenaldigesta and bacteria suggests thatthe contribution of dietary PB to the duodenalflow was low and seemsto confirm the reliability of values obtained from polyester-bag measurements.

Rumen microbial production estimated either from urinary purine derivative excretion or from direct measurements of 15N and purine bases as microbial markers: effect of protein source and rumen bacteria isolates

Four ewes fitted with ruminal and duodenal T-piece cannulae were each given six diets in a 6 × 4 factorial design. Diets or experimental treatments consisted of two ratios of forage: concentrate (700:150 (LC) and 400: 600 (HO). Forage was ammonia-treated straw and the concentrate was formulated with barley supplemented with one of three protein sources: sunflower meal, soya-bean meal or fish meal. Duodenal flows ofdigesta were estimated by the dual-phase technique using Co-EDTA and Yb acetate as liquid and solid markers. Microbial nitrogen (N) was estimated from the digesta flow of purine bases and 15N enrichment using as reference samples, bacterial isolates from the liquid (LAB) or solid (SAB) phase of rumen digesta.

Duodenal flow of purine bases (mmol/day) was lower on LC (12·9) than HC (17·7) diets but in both treatments it was depressed by fish meal (12·3) compared with either soya-bean (17·3) or sunflower meal (16·3) as supplements (s.e. 1·13). Urinary excretion of purine derivatives showed a similar trend, 8·6 v. III mmol/day in LC and HC respectively and 8·8 v. 10·4 and 10·5 mmol/day in fish meal, soya-bean and sunflower meal diets (s.e. 0·56), respectively. Variation in excretion of urinary purine derivatives was mainly associated with digestible organic matter intake with an average ratio of 1·7 (s.e. 0·11) mmol per 100 g digestible organic matter intake. Irrespective of the microbial marker used, microbial yield was higher in animals offered HC than in those offered LC and with soya-bean or sunflower meal compared with fish meal supplemented diets. The microbial purine bases/N (mmol/g) ratio varied between LAB (1·99, s.e. 0·092) and SAB (1·69, s.e. 0·071) isolates leading to different estimates of microbial-N yield (g) from duodenal purine bases (7·76 (s.e. 2·84) v. 9·13 (s.e. 3·24)), urinary excretion of allantoin (5·57 (s.e. 2·0) v. 6·57 (s.e. 2·03)) or total purine derivatives (6·43 (s.e. 2·39) v. 7·56 (s.e. 2·77)). Urinary excretion of allantoin or total purine derivatives provided consistently lower estimates of duodenal microbial-N than duodenal purine bases or 15N, although it closely reflected the pattern observed in direct measurements.

Microbial protein synthesis, ruminal digestion, microbial populations, and nitrogen balance in sheep fed diets varying in forage-to-concentrate ratio and type of forage

Six ruminally and duodenally cannulated sheep were used in a partially replicated 4 x 4 Latin square to evaluate the effects of 4 diets on microbial synthesis, microbial populations, and ruminal digestion. The experimental diets had forage to concentrate ratios (F:C; DM basis) of 70:30 (HF) or 30:70 (HC) with alfalfa hay (A) or grass hay (G) as forage and were designated as HFA, HCA, HFG, and HCG. The concentrate was based on barley, gluten feed, wheat middlings, soybean meal, palmkern meal, wheat, corn, and mineral-vitamin premix in the proportions of 22, 20, 20, 13, 12, 5, 5, and 3%, respectively (as-is basis). Sheep were fed the diets at a daily rate of 56 g/kg of BW(0.75) to minimize feed selection. High-concentrate diets resulted in greater (P < 0.001) total tract apparent OM digestibility compared with HF diets, but no differences were detected in NDF digestibility. Ruminal digestibility of OM, NDF, and ADF was decreased by increasing the proportion of concentrate, but no differences between forages were detected. Compared with sheep fed HF diets, sheep receiving HC diets had less ruminal pH values and acetate proportions, but greater butyrate proportions. No differences among diets were detected in numbers of cellulolytic bacteria, but protozoa numbers were less (P = 0.004) and total bacteria numbers tended (P = 0.08) to be less for HC diets. Carboxymethylcellulase, xylanase, and amylase activities were greater for HC compared with HF diets, with A diets showing greater (P = 0.008) carboxymethylcellulase activities than G diets. Retained N ranged from 28.7 to 37.9% of N intake and was not affected by F:C (P = 0.62) or the type of forage (P = 0.31). Microbial N synthesis and its efficiency was greater (P < 0.001) for HC diets compared with HF diets. The results indicate that concentrates with low cereal content can be included in the diet of sheep up to 70% of the diet without detrimental effects on ruminal activity, microbial synthesis efficiency, and N losses.

Effect of a saponin-based surfactant and aging time on ruminal degradability of flaked corn grain dry matter and starch

The objectives of this study were to investigate the effect of a saponin-based surfactant, Grain Prep surfactant (GP), and hot flake aging time on starch characteristics and ruminal DM and starch degradability of steam-flaked corn grain. In 2 experiments, the moisture content of incoming corn was automatically adjusted using the Grain Prep Auto Delivery System to 19.8% (Exp. 1) and 18.5% (Exp. 2). The application rate of GP was 22 mg/kg (as-is basis). Control corn was treated with water alone. Processed corn in Exp. 2 was stored in insulated containers for 0, 4, 8, or 16 h. Flaked corn samples were incubated in the rumen of lactating dairy cows for 0, 2, 4, 6, 16, or 24 h. In Exp. 1, GP increased, compared with the control, the soluble fraction and effective degradability (ED) of DM by 17.2 and 8.6%, respectively. The ED of cornstarch was increased by 6.7%. In Exp. 2, the concentration of soluble DM and starch were increased by GP by 15 and 24% compared with the control. The ED of DM and starch were also increased by 3 and 4%, respectively. No differences in gelatinization temperatures were observed due to treatment, except that GP-treated grain had a slightly greater mean gelatinization enthalpy in Exp. 2. In a pilot study, DM degradability parameters were not affected by germination of the corn kernels. Aging of the hot flakes for up to 16 h resulted in a quadratic decrease in DM and starch ruminal degradability. The aging process affected starch gelatinization enthalpy values of flaked grain in a manner opposite to that observed for ruminal DM and starch degradation. This phenomenon was most likely explained by increased starch intramolecular associations or crystallinity associated with starch annealing, or both. This study confirmed our previous observations that Grain Prep surfactant increases flaked corn DM and starch degradability in the rumen. Because the rate of degradation was not affected by the surfactant, the increase in degradability was attributed mainly to increases in DM and starch solubility.

Effect of field pea level on intake, digestion, microbial efficiency, ruminal fermentation, and in situ disappearance in beef steers fed growing diets

Effects of increasing level of field pea (variety: Profi) on intake, digestion, microbial efficiency, and ruminal fermentation were evaluated in beef steers fed growing diets. Four ruminally and duodenally cannulated crossbred beef steers (367+/-48 kg initial BW) were used in a 4 x 4 Latin square. The control diet consisted of 50% corn, 23% corn silage, 23% alfalfa hay, and 4% supplement (DM basis). Treatments were field pea replacing corn at 0, 33, 67, or 100%. Diets were formulated to contain a minimum of 12% CP, 0.62% Ca, 0.3% P, and 0.8% K (DM basis). Each period was 14 d long. Steers were adapted to the diets for 9 d. On d 10 to 14, intakes were measured. Field pea was incubated in situ, beginning on d 10, for 0, 2, 4, 8, 12, 16, 24, 36, 48, 72, and 96 h. Bags were inserted in reverse order, and all bags were removed at 0 h. Ruminal fluid was collected and pH recorded at -2, 0, 2, 4, 6, 8, 10, and 12 h after feeding on d 13. Duodenal samples were taken for three consecutive days beginning on d 10 in a manner that allowed for a collection to take place every other hour over a 24-h period. Linear, quadratic, and cubic contrasts were used to compare treatments. There were no differences in DMI (12.46 kg/d, 3.16% BW; P > 0.46). Ruminal dry matter fill (P = 0.02) and mean ruminal pH (P = 0.009) decreased linearly with increasing field pea level. Ruminal ammonia-N (P < 0.001) and total VFA concentrations (P = 0.01) increased linearly with increasing field pea level. Total-tract disappearance of OM (P = 0.03), N (P = 0.01), NDF (P = 0.02), and ADF (P = 0.05) increased linearly with an increasing field pea level. There were no differences in total-tract disappearance of starch (P = 0.35). True ruminal N disappearance increased linearly (P < 0.001) with increasing field pea level. There were no differences in ruminal disappearance of OM (P = 0.79), starch (P = 0.77), NDF (P = 0.21), or ADF (P = 0.77). Treatment did not affect microbial efficiency (P = 0.27). Field pea is a highly digestible, nutrient-dense legume grain that ferments rapidly in the rumen. Because of their relatively high level of protein, including field peas in growing diets will decrease the need for protein supplementation. Based on these data, it seems that field pea is a suitable substitute for corn in growing diets.

Yield response of lactating Holstein dairy cows to dietary fish meal and bone meal

Experiments were conducted to examine the effects of the source and amount of dietary protein on yield and composition of milk from Holstein dairy cows. Study 1 used 36 multiparous cows at 125 +/- 59 d in milk in, a replicated 2 x 2 Latin square design. Treatments were diets formulated to contain 16% crude protein (CP) in which 11% was fish meal or meat and bone meal supplied 11% of dietary CP. Intakes of dry matter, CP, and net energy for lactation; yields of milk; and percentage of milk fat were not affected by treatment. Fish meal increased contents of milk total N, casein N, and noncasein N but did not increase contents of NPN; fish meal also tended to increase milk CP yields. Study 2 used 78 cows (31 primiparous) at 31 +/- 2 d in milk in a randomized block design. Two treatment diets were formulated to contain 16 or 18.5% CP, and soybean meal was the sole source of supplemental protein in those diets. The two other treatment diets were, formulated to contain 16% CP; in these diets, fish meal or meat and bone meal partially replaced soybean meal. Treatments did not influence yield or composition of milk from multiparous cows. Compared with a soybean meal diet containing 16% CP, a soybean meal diet containing 18.5% CP or diets containing 16% CP and containing meat and bone meal or fish meal increased the milk, yield of primiparous cows similarly. Fish meal or meat and bone meal increased the efficiency of protein utilization for milk yield.

Digestive adaptations of rats given white bread and cooked haricot beans (Phaseolus vulgaris): large-bowel fermentation and digestion of complex carbohydrates

Two experiments were carried out to examine the short (1-3 d) and medium (14 d) term adaptations of rat large-bowel (LB) fermentation to alterations in substrate supply brought about by including cooked haricot beans (Phaseolus vulgaris) in diets based on white bread. Changes in organic matter (OM) flow from the ileum occurred within 1 d and were stable for 14 d but the pattern of caecal short-chain fatty acids took much longer to stabilize with considerable increases in butyrate between 1 and 3 d and up to 14 d. This suggests that the metabolic activity of the LB microflora may take a considerable time to stabilize after an abrupt change in substrate supply. Despite an almost fourfold change in OM supply to the LB, the proportion of this OM apparently fermented in that organ (0.46) remained fairly constant. None of the apparent resistant starch measured in the diets could be detected in faeces. Dietary non-starch polysaccharides (NSP) were extensively fermented with similar values (0.82) for both bread and bean NSP and there was little indication of any interaction between the two diet components on NSP fermentation. An attempt was made to fractionate ileal and faecal OM to provide a basis for a quantitative model of LB stoichiometry.

Evaluation of chemical and physical properties of feeds that affect protein metabolism in the rumen

The goal of the NC-185 Cooperative Regional Research Project is to provide the information needed to improve the nutrition and feeding of dairy cattle, a major factor determining composition of milk and cost of milk yield. Emphasis is placed on understanding how energy and protein nutrition of lactating cows can be manipulated to increase the quantity and improve the profile of AA passing to the small intestine and to improve yield of milk and milk protein. To achieve this goal, one of the major objectives of this project has been to evaluate quantitatively the chemical and physical properties of protein and energy sources that determine AA availability to lactating cows. Reliable measurements of microbial protein synthesis and protein degradation in the rumen are critical in the evaluation process. Therefore, one of the ongoing areas of investigation of this research project has been to determine the most appropriate methods for estimating microbial protein synthesis and dietary protein degradation in the rumen. Other areas have been investigated, using continuous culture fermenters and ruminally and duodenally cannulated cows, including factors that alter microbial metabolism of N in the rumen and subsequently protein supply to the small intestine, such as sources of carbohydrate, protein, and fat and interrelationships of protein and carbohydrate. Findings of the NC-185 Cooperative Regional Research Project Committee and other investigators are summarized in this review.

Evaluation of calf starters containing different amounts of crude protein for growth of Holstein calves

Holstein calves (n = 110) were used to evaluate the effect of calf starters containing 15, 16.8, 19.6, or 22.4% CP, DM basis (diets A, B, C, and D, respectively), on calf performance from d 4 to 56 of life. Preweaning daily gain tended to increase linearly as protein content of diets increased, averaging .37, .39, .38, and .44 kg/d for diets A, B, C, and D, respectively. After weaning, calves fed diet C gained the most (.86 versus .71, .75, and .79 kg/d for A, B, and D, respectively). Overall BW gains from d 4 to 56 averaged .54, .56, .62, and .61 kg/d for A, B, C, and D, respectively. Throughout the experiment, starter consumption tended to increase as CP content of diet increased. Under these conditions, maximum growth was supported by diet C (19.6% CP); no advantage was gained from higher (22.4%) protein content. Calf growth was moderate when calf starters of lower protein contents (15 or 16.8%) were fed.

[The effect of starch sources barley, maize and potatoes and their ration portions on the nutrient digestibility and energy utilization in ruminants. 4. Nitrogen metabolism in the rumen]

In 9 experimental periods on four adult bulls (LW 550 kg) fitted with re-entrant cannulae in the proximal duodenum isoenergetic rations were used on feeding level 1.7 with ground barley, ground maize or fresh potatoes as starch sources. The net energy parts of these concentrates in the ration amounted to 50, 25 and 10%. 50 to 80% of the ration DM consisted of dried grass and about 10% of sugar beet pulp. The dried grass supplied on an average 87, 79 and 62% of the feed crude protein. The intake of DM was 7.74 +/- 0.42 (mean +/- SD) kg/d. The energetic efficiency of microbial N synthesis in the rumen (g N/kg organic matter true fermented in the rumen, TFOM) was averaged 16.4 with a range of 10.6 to 21.4. The microbial efficiency achieved a maximum when the ratio of nitrogen-free extract to crude fibre in the diet was 1.7 and 2.1 with barley, 1.8 with potatoes and 2.1 and 3.3 with corn as starch source. Changes in the microbial efficiency were positively correlated with the rate of passage of non-microbial organic matter from the rumen (g/d) and with the duodenal flow rate (kg digesta/kg DM intake). The relation to the rate of carbohydrate fermentation in the rumen (in %) and to the amount of TFOM (g/d) was negative. The duodenal flow of microbial N and non-ammonia N (g/d) correlated negatively with the organic matter apparently fermented in the rumen (AFOM) and positively with the non AFOM. The amino acid (AA) profile of the duodenal protein was affected by the starch source. It was concluded that the metabolism of nitrogen in the forestomachs of cattle is affected by the source of starch and the ratio of forage to concentrate. There exists a relationship between both factors. The net synthesis of microbial protein in the rumen is not only the result of substrate fermentation. The passage of non-AFOM from the rumen significantly affects the energetic efficiency of microbial nitrogen synthesis and the duodenal supply of AA.

[Ruminal nitrogen metabolism in calves and sheep. 3. Effect of hay-concentrate ratio in calves]

During the milk feeding period (ca. 55th day of life) and 2 weeks after the milk feeding period (ca. 80th day of life) the influence of a hay quota in the ration (on DM basis) of 6, 10, 14 and 18% in the milk feeding period and of 16, 23, 31 and 37% in the period after milk feeding was tested as to ruminal N metabolization with calves supplied with duodenal re-entrant cannulae. The increase of the hay quota in the ration for ruminating calves reduced as a tendency duodenal NAN passage, its bacterial N-quota, post-ruminal NAN digestibility and, due to a worse utilization of available N for bacterial N-synthesis, bacterial N-synthesis rate. The apparent fermentation of organic matter was, as a tendency, increased with the growing hay quota in the ration.

[ATP in the metabolism of ruminants]

The ATP yield from the carbohydrates of anaerobically living microorganisms in the rumen amounts to only 5-10% of the ATP yield of the intermediary metabolism in the presence of oxygen. Vital functions and thus microbial protein synthesis are due to protein degradation in the rumen. The ATP yield in the intermediary metabolism of ruminants is mainly achieved from propionate and microbial protein by means of gluconeogenesis because the absorption of glucose from digested starch is very low. The relationships between ATP yield in the rumen and the processes of glucose provision for the production of lactose as well as the protein content of the milk are shown. As important processes of ATP production in microorganisms from easily soluble carbohydrates take place in silage preparations before feed intake, the corresponding consequences for the metabolism of high-performance cows fed with silage are shown.

Impact of carbohydrate and protein levels on bacterial metabolism in continuous culture

Diets formulated with three levels of nonstructural carbohydrate (54, 37, and 25% of DM), with various concentrations of degradable intake protein ranging from 19 to 4% of DM, were fermented in continuous cultures to ascertain the effects of ratio of nonstructural carbohydrate to degradable intake protein on bacterial metabolism. Fermenters were maintained at a dilution rate of 12%/h with a solids retention time of 24 h. Regardless of degradable intake protein level, bacterial efficiency (g of bacterial N/kg of DM digested) and VFA production (mM/d) were lower for diets with 25% nonstructural carbohydrate compared with the 37 and 54% nonstructural carbohydrate diets. In response to widening nonstructural carbohydrate:degradable intake protein ratios, bacterial efficiencies at all nonstructural carbohydrate levels declined quadratically from 34.2 to 10.3 with the lowest efficiencies on the 25% nonstructural carbohydrate diets. Bacterial protein production, DM digestion, NDF digestion, and VFA production (mM/d) increased linearly in response to dietary protein. The enhanced NDF and DM digestion, VFA production, and bacterial efficiencies observed with the narrower ratios of nonstructural carbohydrate:degradable intake protein support the theory that level of both degradable intake protein and nonstructural carbohydrate should be considered in order to enhance ruminal digestion and bacterial N production.

Digesta kinetics in sheep and cattle fed diets with different forage to concentrate ratios at high and low intakes

Effect of maintenance and ad libitum intakes on digesta kinetics was studied with six ruminally fistulated cows and six ruminally fistulated wethers to validate the use of sheep as a model of cattle. Complete diets were made up of ratios of alfalfa:cracked corn and soybean meal of 80:20, 55:45, and 30:70. The rate of passage of Cr-mordanted alfalfa and soybean meal in the reticulorumen was negatively related to percentage of concentrate in the diet in both species at low intakes. Passage values of particulate and liquid markers were faster at high than at low intakes in both species for all diets. Rumen liquid volume increased with intake only in the cows on the low and intermediate concentrate diets. No substantial differences were found in particulate passage values between sheep and cattle. However, liquid passage rates from the rumen and the differentials between liquid and particulate dilution rates were higher in cows than in sheep for all diets at both intakes. These results together with those for digestibility data reported in a previous communication suggest that caution should be exercised when extrapolating results from one species to the other.

Influence of synchronizing protein and starch degradation in the rumen on nutrient utilization and microbial protein synthesis

A 4 x 4 Latin square design with four multiparous cows in midlactation fitted with duodenal cannulae was used to determine the effect of synchronization of protein and starch degradation in the rumen on nutrient availability in lactating cows. As major starch and protein sources, diets contained: barley plus cottonseed meal; barley plus brewers dried grains; milo plus cottonseed meal; and milo plus brewers dried grains. Experimental periods were 12 d and consisted of 8 d adjustment and 4 d collection. Chromium oxide was used as the marker to determine digestibility and nutrient flow from the rumen. Microbial protein synthesis was estimated from nucleic acid content in duodenal samples. Apparent and corrected rumen digestibilities of DM, organic matter, CP, and starch were higher for diets containing barley than milo but were not affected by protein source. For diets containing barley and milo, starch digested postruminally averaged 820 and 2190 g/d and percentage digestibility was 70 and 77%. No difference among diets was found in DM, organic matter, and CP flow to the small intestine; however, microbial N synthesis was higher in diets containing barley than in diets containing milo.

Effect of ruminal protein degradation of blood meal and feather meal on the intestinal amino acid supply to lactating cows

Four lactating cows fitted with ruminal cannulae and T-type cannulae in the proximal duodenum and terminal ileum were utilized to measure protein degradation in the rumen and amino acid flow to and absorption from the small intestine. Soybean meal, blood meal, feather meal, and a 50-50 combination of blood meal and feather meal provided 50% of the protein in diets that contained 50% grain mix, 40% corn silage, and 10% alfalfa pellets on a DM basis. Ruminal degradation of dietary CP was 53, 43, 32, and 37% for diets containing soybean meal, blood meal, feather meal, and the combination of meals. Cows fed the latter two diets also had lower ruminal NH3 concentrations and efficiency of bacterial protein synthesis compared to those fed the soybean meal diet. Total tract N digestibility was lower for diets containing feather meal (63.4%) and a combination of meals (66.3%) than the soybean meal diet (78.5%). Total amino acid flow to the duodenum was 19.3 and 15.6% higher for cows fed the feather meal and combined meal diets, respectively, compared with the soybean meal diet. Total amino acid absorption from the small intestine was higher as well as absorption of individual amino acids for the combined meal diet compared with the soybean meal diet. Absorption of individual amino acids, expressed as a percentage entering the duodenum, was lowest for the feather meal diet. Results from this study show that feeding a combination of blood meal and feather meal instead of soybean meal can increase intestinal supply and absorption of amino acids in dairy cattle.

Ruminal degradability of crude protein from different treated soybean meals in lactating cows

Ruminal crude protein (CP) degradability of four commercially available soybean meal (SBM) types--untoasted (U), toasted (T), heat-treated (H) and formaldehyde-treated (F)--was studied by the use of in sacco and in vivo techniques with lactating German Friesian cows cannulated in the rumen, duodenum and ileum. In two in sacco experiments three cows were fed a diet based either on grass hay plus ear-maize silage or on barley whole plant silage. Ruminal degradation rate of CP was estimated as percent nitrogen (N) disappearance from polyester bags incubated in the rumen for 2, 4, 6, 8, 12 and 24 h. Ruminal degradation rate of CP varied among the four SBM types as well as between the two basal diets. N disappearance from the bags after 12 h of incubation averaged 96, 67, 37, and 23% for the U, T, H, and F SBM types, respectively, in the cows fed the hay/ear-maize silage diet vs 99, 86, 58 and 41% for the four SBM types, respectively, in the cows fed the barley whole plant silage diet. In the in vivo experiment, four cows were fed diets based on meadow hay and ear-maize silage in a 4 x 4 Latin square design. The effect of SBM treatment on the flow rate of non-ammonia N (NAN) into the duodenum, and its relationship with the ruminal degradation rate of CP of the four SBM types, was studied. Formaldehyde treatment increased the amount of NAN entering the duodenum (P less than .05): 485 g cow-1 day-1 compared to 383, 418 and 428 g for U, T and H, respectively. Calculated ruminal CP degradabilities were 93, 75, 71 and 38% for SBM types U, T, H and F, respectively.

Evaluation of calcium lignosulfonate-treated soybean meal as a source of rumen protected protein for dairy cattle

Four Holstein cows fitted with ruminal, duodenal, and ileal cannulae were used in a 4 x 4 Latin square design to measure ruminal protein degradation and small intestinal digestion of diets containing untreated soybean meal or soybean meal treated with heat and either water, xylose, or calcium lignosulfonate. Diets consisting of 40% corn silage, 10% alfalfa cubes, and 50% grain mix, and averaging 16.8% crude protein (DM basis) were fed four times daily. Approximately 50% of the total dietary protein was supplied by the respective soybean meal source. Ruminal protein degradation was 70.6, 69.6, 55.8, and 53.7% for diets containing untreated soybean meal, water-soybean meal, xylose-soybean meal, and calcium lignosulfonate-soybean meal, respectively. Duodenal non-NH3 N flow (g/d) and absorption of non-NH3 N (g/d) in the small intestine were generally not affected by treatment. Duodenal bacterial N flow (g/d) was lower with xylose-soybean meal and lignosulfonate-soybean meal than with untreated soybean meal. Treatment of soybean meal with xylose or calcium lignosulfonate was successful in decreasing ruminal protein degradation. However, it may be necessary to include a source of readily fermentable N in diets that contain protected proteins in order to supply adequate NH3 N for microbial protein synthesis.

Monitoring the fate of dietary proteins in rumen fluid using gel electrophoresis

1. When fractionated by sodium dodecylsulphate-polyacrylamide gel electrophoresis (SDS-PAGE), strained rumen fluid from sheep fed on pelleted lucerne (Medicago sativa) hay showed no major protein components that stain with Coomassie Blue. This feature made it possible to monitor the fate of individual polypeptides within a protein mixture incubated in rumen fluid in vitro. 2. Extracts from a number of seed meals (sunflower (Helianthus annuus), lupin (Lupinus angustifolius), rape (Brassica napus) and pea (Pisum sativum L.)), as well as casein and bovine serum albumin, were examined in this system. The protein components of each seed type showed a wide range of resistances to degradation. One protein in pea seeds (pea albumin 1), which is particularly rich in cysteine, was almost as resistant to rumen degradation as bovine serum albumin. 3. Analysis of synthetic-fibre-bag experiments by SDS-PAGE showed that the rate of loss of total protein from solid meal residues does not provide an index of the resistance of individual protein components of the meal to rumen degradation. While there was no qualitative change in the protein profile of residual pea-seed meal inside a synthetic-fibre bag, there was considerable variation in the rate at which individual, solubilized protein components were degraded in the surrounding rumen fluid.