Process design of high-concentration benzimidazole wastewater treatment based on the molecular structure of contaminants

Removal of azimsulfuron and zoxamide using a tapered variable diameter biological fluidized bed combined with electrochemistry: Mass fraction division, energy metabolism activity and carbon emissions

The performance of the combination system of tapered variable diameter biological fluidized bed (TVDBFB) with electrochemistry (EC) was evaluated for removing azimsulfuron and zoxamide under different temperatures and influent concentrations. Maximum removal efficiency of azimsulfuron and zoxamide could reach 94% and 98% under higher influent concentration (about 780 mg/L). As temperature decreased from 32 ℃ to 8 ℃, the mS_e increased from 48% to 56%, and the mS_o and mS_xv decreased from 30% to 22% and 27% to 24%, respectively. As the influent COD equivalent concentration of azimsulfuron and zoxamide enhanced from 260 mg/L to 780 mg/L, the K_d increased from 0.06 d^-1 to 0.23 d^-1. Temperature and influent concentration were main influencing factors of DHA, ATP and ETS. Increasing aeration in TVDBFB and HRT in EC under shock conditions could improve azimsulfuron and zoxamide removal efficiency, however, it was also accompanied by higher carbon emissions.

Optimizing anaerobic technology by using electrochemistry and membrane module for treating pesticide wastewater: Chemical oxygen demand components and fractions distribution, membrane fouling, effluent toxicity and economic analysis

Optimization in performance and membrane fouling of an electrochemical anaerobic membrane bioreactor (R1) for treating pesticide wastewater was investigated and compared with a conventional anaerobic membrane bioreactor (R2). The maximum COD removal efficiency of R2 was 80.1%, 80.0%, 67.4%, 61.1% with HRT of 96, 72, 48 and 24 h, which of R1 was enhanced to 84.7%, 84.3%, 82.0% and 66.3%. These results demonstrated that the optimum HRT of R1 was shortened to 48 h, which of R2 required 72 h. R1 reduced the contents of particulate and colloidal COD, and the fraction of COD converted to sludge was 5.0-8.2% lower than that of R2. The fouling rate was 0.99-1.44 kPa/d and reduced by 31.0%-38.5% compared with R2. Detoxification was enhanced by 7.8-47.7% with the assistance of bio-electrochemistry. Ultimately, ensuring similar performance, R1 achieved a 65.6% improvement in environmental benefit, a 26.3% and 38.9% reduction in unit capital and operating costs.

Effects of iron-carbon materials on microbial-catalyzed reductive dechlorination of polychlorinated biphenyls in Taihu Lake sediment microcosms: Enhanced chlorine removal, detoxification and shifts of microbial community

Nano zero-valent iron particles (nZVI, 0.09 wt%), micro zero-valent iron particles (mZVI, 0.09 wt%), granular activated carbon (GAC, 3.03 wt%), GAC supported nZVI (nZVI/GAC, 3.12 wt%) and nZVI&GAC (nZVI 0.09 wt%, GAC 3.03 wt%) were evaluated for their effects on polychlorinated biphenyls (PCBs) anaerobic reductive dechlorination, detoxification, as well as microbial community structure in Taihu Lake (China) sediment microcosms. The results showed that all of these five materials could stimulate PCBs reductive dechlorination, especially for dioxin-like PCB congeners, and nZVI&GAC had the best removal effect on PCBs. The reduction of total PCBs increased from 13.5% to 33.2%. H₂ generated by zero-valent iron corrosion was utilized by organohalide-respiring bacteria (OHRB) to enhance the dechlorination of PCBs predominantly via meta chlorine removal in the short term. The addition of ZVI had little impact on the total bacterial abundance and the microbial community structure. The adsorption of GAC and potential bioremediation properties of attached biofilm could promote the long-term removal of PCBs. GAC, nZVI/GAC, nZVI&GAC had different influences on the microbial structure. These findings provide insights into the biostimulation technique for in situ remediations of PCBs contaminated sediments.

A novel low temperature aerobic technology with electrochemistry for treating pesticide wastewater: Compliance rate, mathematical models, economic and environmental benefit analysis

In this study, a novel combination system of the tapered variable diameter biological fluidized bed (TVDBFB) with electrochemistry (EC) has been developed and its performances are investigated at different seasons. The results showed that the COD removal efficiency of TVDBFB increased from 61% to 67% and compliance rate increased from 84% to 88% when the carrier packing rate increased from 15% to 30% and temperature was 12 ℃. However, COD removal efficiency and compliance rate increased to 87% and 100% when EC was a post treatment unit. The mathematical models could fit well with the attached biomass, which can be applied to reflect and predict the biomass per unit carrier under different conditions, and the EC removal of COD follow the first-order reaction kinetic model. The economic and environmental benefit analysis indicated that TVDBFB and EC were feasible for treating pesticide wastewater.

Novel tapered variable diameter biological fluidized bed for treating pesticide wastewater with high nitrogen removal efficiency and a small footprint

In this study, the removal efficiency of nitrogen, specific nitrification rate (SNR), specific denitrification rate (SDNR) and compliance rate of the novel tapered variable diameter biological fluidized bed (TVDBFB) and anoxic/oxic (AO) process were compared at different temperatures. The results showed that the optimal TN, NH₄⁺-N, and TKN removal efficiencies of the TVDBFB were 76%, 89% and 88%, respectively, and those of AO were 65%, 67% and 69%, respectively. The SNR and SDNR of the TVDBFB were significantly higher than those of AO. The TVDBFB had a smaller footprint than AO. The alkalinity/NH₄⁺-N, BOD₅/TN and temperature play important roles in the compliance rate. Increasing the carrier packing rate has emerged as a new strategy for enhancing the compliance rate. Mathematical models were developed and determined to be well-fitted with the experimental values, which can be employed to predict the SNR and SDNR of the TVDBFB.

Synthesis of vitamin B12 derivatives with sodium hydroxymethanesulfinate

The reaction of cyanocobalamin (CNCbl) with sodium hydroxymethanesulfinate (HMS) was studied over a wide range of pH (4–11) under aerobic conditions. CNCbl is destroyed in the presence of HMS in aqueous solution to form uncolored substances. The accumulation of stable yellow corrinoids (SYCs) preceded these changes at pH [Formula: see text] 8. The major stable yellow corrinoid is (15R)-Co[Formula: see text], Coß — dicyano-13-dehydro-15-hydro-l5-hydroxycob(III)alamin. The yield of this SYC is 25%, and the stability of this compound decreases significantly with increasing concentrations of HMS, pH and temperature.